Professional Documents
Culture Documents
التجربه الاولى noninverting amp.docx
التجربه الاولى noninverting amp.docx
USFUL FORMULAS
Non-inverting amplifier closed –loop voltage gain, figure (1.1)
10 kΩ resistance
100 kΩ resistance
741 Op-amp
± 15V dc power supplies
Signal generator
Oscilloscope
Bread board
Figure (1.1): Non-inverting amplifier
PROCEDURE
Wire the non-inverting amplifier circuit shown in schematic diagram in
figure (1.1). Apply power to the breadboard and adjust the input voltage
to and the frequency at 400 Hz. Again position the input above the output
voltage on the oscilloscope's display. Draw the two waveforms, what is
the difference between the two signals?
The only difference is that the output signal is larger than the input
signals. Both signals are said to be in-phase.
QUESTION
Prove that