Professional Documents
Culture Documents
TDS_ADESILEX G19
TDS_ADESILEX G19
TDS_ADESILEX G19
x G
ile
es
Ad
Two-component,
epoxy-polyurethane
adhesive for resilient
and textile flooring
es
Ad
• Do not install flooring on not completely set Blend the two components together with
or wet concrete (residual moisture content a mechanical mixer until an even paste is
must be maximum 3.0%). obtained. Setting times and pot life depend
on the ambient temperature (see table).
• Do not install flooring on fresh asphalt (wait Setting times are much longer if the
at least 20 days). temperature is lower than +10°C.
Acclimatisation CONSUMPTION
Before starting the installation, make Consumption varies according to the flatness
sure that the floor covering and substrate of the substrate and the type of backing on
are acclimatised to the recommended the flooring material (and, therefore, the type
temperatures and R.H.. of trowel used):
– trowel No. 1 or TKB A1/A2: 350-450 g/m²;
Mixing the adhesive – trowel No. 2 or TKB B1; B2: 450-550 g/m²;
The two components of Adesilex G19 are – trowel No. 3 or TKB C1: 550-750 g/m²;
supplied in pre-measured proportions: – trowel No. 4: 750-1000 g/m².
TECHNICAL DATA (typical values)
PRODUCT IDENTITY
component A component B
ilex Adesilex G19 may be removed from flooring, and seek medical attention.
es
tools, clothing etc. with alcohol before it Adesilex G19 components A and B are also
Ad
hardens. Once hardened, it must be removed hazardous for aquatic life. Do not dispose of
mechanically or with Pulicol 2000. these products in the environment.
For further and complete information about
COLOUR the safe use of our product please refer to
252-1-2016 (GB)