Professional Documents
Culture Documents
HANDLE ASSEMBLY (2)
HANDLE ASSEMBLY (2)
INSTRUCTION
STG365/465
Open box
Step 4: Insert the pitch control wire into the handle and pull it out on the pulley side.
Step 5: Hold the handle in place and line up the screw holes.
Step 6: Fasten the handle with the four screws and four washers delivered with the machine documentation.
Step 7: Tighten the screws with a 6 mm hex key. Use no more force than 18 ft-lb (25 Nm).
Step 8: Unlock and unstring the cable tie fully on the bottom side of the handle.
Step 9: Insert the throttle and wire cable into the cable tie. Lock it.
Connecting the cables
Step 10: Connect the cable couplings and be sure they are locked properly.
Step 11: Pull the pitch control wire to the pitch lever and remove the spring lock pin.
Step 12: Insert the wire end into the opening and refit the spring pin locking the wire into position.
Step 13: Tighten the pitch control knob slightly to make sure that the wire is tensioned.
Completed
Read the Safety and operating instructions.
Enjoy your new machine.