Pre-Commissioning check list - Low Voltage Drives

Customer Name
Location
Contact Person Name/ Mobile No
E- Mail ID
Date

1. Drive and Motor data:

Power Nominal Nominal Speed Power Drive Model/ Rating / Serial Type of motor Application
(kW) Current Voltage (RPM) Factor Number
(Cos Φ)

Mechanical Installation
2 Drive room civil work completed in all aspect
3 Drive Installed in Dust-free Room
4 Ventilation for hot air moveout from drive room arrangement has made
5 Enough free space around the unit
6 Distance between back side Panel and wall/wall/another panel
7 The unit fastened on the floor

Electrical Check Points

8 Incoming Supply Source (DG/TG/Electricity Board)
9 Type of Incoming Supply (Permanent/Temporary)
10 Supply voltage & supply frequency
11 Drive Panel is grounded properly (YES / NO)
12 Insulation of Incoming/ Outgoing power cables are tested and connected (YES / NO)
13 Capacitors to be reformed if stored more than year
14 Length, Size and No.of runs of Motor Power Cable
15 External control connections (All 24 Vdc & 4-20 mA signal cables should be (YES / NO)
screened cable and separately laid and away from power cables)
16 UPS provided for the control Supply (YES / NO)
17 External Emergency off and Field interlock
18 Manual, Scheme / Wiring Table available at Site (YES / NO)
19 Motor Earthing Done (Double earthing recommended) (YES / NO)
20 Motor in Final Position (YES / NO)
21 Tacho / Encoder cable ready (Only screened cable to be used) (YES / NO)
22 Motor de-coupled for ID Run (YES / NO)
23 Ready for Load Trial (YES / NO)

24 Pending points if any:

The above details are checked, and correct data filled for smooth and efficient commissioning.

In Charge of Commissioning

Name and Signature

Note: If more than one drive is there, please making a separate photocopy of the checklist and send the same to
M/s ABB after fill-in.
Contact Details: Bangalore – 7899034312/ 080-22949358