Professional Documents
Culture Documents
Palm Kernel Oil SDS - 2023
Palm Kernel Oil SDS - 2023
2.1 Classification
3.1 Substance/Mixture
Skin Contact: Wash off with soap and water. Get medical attention
if irritation develops and persists.
4.2 Most Important Symptoms and Effects, Both Acute and Delayed
Direct contact with eyes may cause temporary irritation.
4.3 Indication of Any Immediate Medical Attention and Special Treatment Needed
Treat symptomatically. Ensure that medical personnel are aware of the
material(s) involved, and take precautions to protect themselves.
Large Spills: Stop the flow of material, if this is without risk. Dike the
spilled material, where this is possible. Absorb in vermiculite,
dry sand or earth and place into containers. Following
product recovery, flush area with water.
Small Spills: Wipe up with absorbent material (e.g. cloth, fleece). Clean
surface throughly to remove residual contamination. Used
rags or other cleaning materials should be soaked with water
and placed in a sealed container. Rags, steel wool, or waste
contaminated with this product may spontaneously catch fire
if improperly discarded.
Property Values
pH: No information available
Melting/Freezing Point: No information available
Boiling Point/Range: No information available
Flash Point: > 550.0°C (>287.8°C)
Evaporation Rate: No information available
Flammability (solid, gas): No information available
10.1 Reactivity
This product is stable and non-reactive under normal conditions of use, storage
and transport.
11.3 Delayed, Immediate Effects, Chronic Effects from Short & Long-term
Exposure
12.1 Ecotoxicity
Not expected to be harmful to aquatic organisms.
12.3 Bioaccumulation
No data available for this product.
14.4 Transport in Bulk According to Annex II of MARPOL 73/78 and the IBC Code
Not established.
Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List
Not regulated.
Clean Air Act (CAA) Section 112® Accidental Release Prevention (40 CFR
68.130) Not regulated.
*A “Yes” indicates this product complies with the inventory requirements administered
by the governing country(s).
A “No” indicates that one or more components of the product are not listed or exempt
from listing on the inventory administered by the governing country(s).
Notes:
This safety data sheet is based on the properties of the material known at the time the
data sheet was issued. The safety data sheet is intended to provide information for a
health and safety assessment of the material and the circumstances, under which it is
packaged, stored or applied in the workplace. For such a safety assessment holds no
responsibility. This document is not intended for quality assurance purposes.