Professional Documents
Culture Documents
ChemSet_101_PLUS_+_Reinforcing_Bar_Anchorage_12-20_06_2024
ChemSet_101_PLUS_+_Reinforcing_Bar_Anchorage_12-20_06_2024
Date : 6/20/2024
Page : 1/6
CALCULATION SHEET FOR RAMSET REBAR ANCHORAGE
Company : Phone number :
Carried out by : Mail address :
Company : Project name :
Contact name : Location :
Phone number : Fastening point :
Mail address :
Comment :
Recommended anchors
ChemSet 101 PLUS + Reinforcing Bar Anchorage 12 Effective embedment : 100 mm
Base material
Concrete resistance : 20 Mpa
Cracking of concrete : Uncracked concrete
Thickness of concrete : 200 mm
Conditions
Installation conditions : Dry concrete
Service temperature 80 °C
Anchor plate
Thickness of part to be fixed : 8 mm
Recommended plate thickness : The base plate thickness has not been checked
Clearance diameter : 0 mm
Profile :
Profile position : Ex = 0 mm ; Ey = 0 mm
Stand-off : Without Clamping ; level arm: 50 mm Restraint level: 2
Design method : ANZ Design Method
Design Actions :
Action [kN] Action type Nz Vx Vy Mz Mx My
Combination
Static 55 0 0 0 0 0
1
Geometry :
Calculation Hypothesis :
- The anchoring plate is assumed to be sufficient to resist deformation imposed by the load actions.
- Connection between profile and base plate has not been checked
-RAMSET can only be held responsible if the calculation examples exactly reflect the application and if the
installation is carried out according to the instruction given in the RAMSET specifications. The calculation is
correct for RAMSET anchors only. The
contractor or specifier should make sure that the base material is able to support the loads especially in the case
of a group of anchors. RAMSET cannot be held responsible if this software package is modified without its
written approval.
Ref : 6/20/2024 - 5:15:49 PM / Version
Date : 6/20/2024
Page : 3/6
Loads on anchors
Utilization
CALCULATION DETAILS
Pull-through capacity per anchor
Failure mode not decisive.
INSTALLATION DATA
ChemSet 101 PLUS + Reinforcing Bar Anchorage 12 Effective embedment : 100 mm
INSTALLATION Method