Professional Documents
Culture Documents
安钢2号高炉配套鼓风机精益化设计与提升_赵丽娜
安钢2号高炉配套鼓风机精益化设计与提升_赵丽娜
安钢 2 号高炉配套鼓风机精益化设计与提升
赵丽娜
(安阳钢铁股份有限公司, 河南 安阳 455004)
摘 要:由于生产模式的调整,高炉配套鼓风机经常在小风量、高风压状态下运行,工况点距离喘振放风调节线较
近,因此防喘阀经常打开,机组处于放风运行的状态,鼓风机出力不能得以完全发挥,运行成本居高不下;此外,高
炉鼓风机启动时,由于送风止回阀受工艺技术等条件限制,会导致其无法正常打开,影响高炉正常供风。针对此情
况,根据现场实际对鼓风机进行技术革新和设计改造,经改造方案实施后,存在的问题得以解决,可为同行业者遇
到同类问题提供一定的解决思路。
关键词:动力工程及工程热物理;轴流鼓风机;止回阀
中图分类号:TF321.8 文献标识码:A 文章编号:
1672-1152(2024)06-0150-03
Lean Design and Improvement of Supporting Blower for Angang 2 # Blast Furnace
Zhao Lina
(Anyang Iron & Steel Co., Ltd., Anyang Henan 455004, China)
Abstract: Due to the adjustment of the production mode of the blast furnace, the blower often operates under the condition of small air
volume and high air pressure, and the operating point is close to the surge vent regulating line, so the anti surge valve is often opened, the
unit is in the vent operation state, the blower output cannot be fully utilized, and the operating cost is high. In addition, when the blast
furnace blower is started, the air supply check valve cannot be opened normally due to the limitations of process technology and other
conditions, affecting the normal air supply of the blast furnace. This article describes the innovation and transformation methods carried out
according to the actual situation on site. After the implementation of the methods, the problems can be solved, and some solutions can be
given to the same industry when encountering the same problems.
Key words: power engineering and engineering thermophysics; axial compressor; check valve