Professional Documents
Culture Documents
IS-15381
IS-15381
IS-15381
W’wfhwm
WRr?FF&J m–mm
Indian Standard
FIRE BLANKET — SPECIFICATION
Ics 13.340.10
(3 BIS 2003
FOREWORD
This Indian Standard was adopted by the Bureau of Indian Standards, after the draft finalized by the Fire Safety
Sectional Committee had been approved by the Civil Engineering Division Council:
The blanket is intended for use in fire fighting operations for protection of the operator and for smothering and
extinguishing fire in its early stages.
For the purpose of deciding whether a particular requirement of this standard is complied with, the final value
observed or calculated, expressing the result of a test or analysis, shall be rounded off in accordance with IS 2: 1960
‘Rules for rounding off numerical values (revised)’. The number of significant places retained in the rounded off
value should be the same as that of the specified value in this standard.
IS 15381:2003
Indian Standard
FIRE BLANKET — SPECIFICATION
1
IS 15381:2003
L-* SELVEDGE
11 r
I ,8 1
1 II I
, II t
8
:
“LA I
1
630 --l ~—630 b
+ ‘
,
; I
1 1
I I
1
1 1
1 I
1
I
I
I t
1 I
I I
I I
1 1
I I
I 4
# i MNKET
~B I
/
18fn lt ---
--------------
—----- ----------------------
-------- -----------
, ------ ______ ----_-: ----- -- 4
I
I b ‘---’
SEC#ON
I
I
I
i
4
1
I
I
I
L-
I
I
I
/
I
p
J
.
lam ●
SELVEDGE
SECTION Cc
2
IS 15381:2003
9.1 Each blanket shall be legibly and indelibly marked Fire blanket, conforming to this standard may also be
with the following information: marked with the Standard Mark.
ANNEX A
(Clause 3)
A-O Tape/Web asbestos shall conform to the following A-2 CONSTRUCTION AND OTHER DETAILS
particulars.
Width Number of Threads Mass Metre
A-1 MATERIALS
(Average) Approximately (Approximately)
The asbestos yams used for the manufacture of tape mm ~ Conditioned at
shall conform to IS 13362. Ends in Picks 65* 2 percent
fill] decimeter Relative
width Humidity and
27=E2°Cfor
24hing
25 35 to 40
(2 :y) (2%y)
The plies of the yams used for making the tape shall
properly be twisted together. The tape shall have a
reasonably uniform thickness.
ANNEX B
(Clause 3)
PARTICULARS OF SEWING THREAD ASBESTOS
2 1 500to2200 3.0 4 45
NOTES
1 For determination of length per unit mass, a minimum of 20 m length of thread shall be taken, conditioned in an atmosphere of
65 + 2 percent relative humidity and a temperature of 27 + 2°C for a period of 24 h and then weighed under the same condition.
2 For determination of breaking strength, the test piece shall be of such a length as to allow 600 mm clear and between the grips of the
machine. The test piece shall be conditioned in an atmosphere of 65 + 2 percent relative humidity and a temperature of 27 + 2°C for a
period of 48 h and then broken in a suitable single thread tester, in which it is stretched at a constant rate of 300 mm/min. The breaking
strength of the sewing thread shall be the average results of 20 test specimens.
4
Bureau of Indian Standards
131S is a statutory institution established under the Bureau of Indian Standards Act, 1986 to promote
harmonious development of the activities of standardization, marking and quality certification of goods
and attending to connected matters in the country.
Copyright
BIS has the copyright of all its publications. No part of these publications may be reproduced in any form
without the prior permission in writing of BIS. This does not preclude the free use, in the course of 1
implementing the standard, of necessary details, such as symbols and sizes, type or grade designations.
1
Enquiries relating to copyright be addressed to the Director (Publications), BIS. 4
?
Review of Indian Standards \
Amendments are issued to standards as the need arises on the basis of comments. Standards are also reviewed
periodical y; a standard along with amendments is reaffirmed when such review indicates that no changes are
needed; if the review indicates that changes are needed, it is taken up for revision. Users of Indian Standards
should ascertain that they are in possession of the latest amendments or edition by referring to the latest issue of
‘BIS Catalogue’ and ‘Standards: Monthly Additions’.
This Indian Standard has been developed from Doc : No. CED 36 (6069).
Headquarters :
Manak Bhavan, 9 Bahadur Shah Zafar Marg, New Delhi 110002 Telegrams : Manaksanstha
Telephones :23230131,23233375,2323 9402 (Common to all offices)