Professional Documents
Culture Documents
Factory Floor Paint TDS
Factory Floor Paint TDS
• Easy To Clean
• Suitable for Forklift Traffic
• Surface Usable in 24 hours
• Oil Tolerant
• Superb Coverage
Recommended Coats: 2
Industrial Traffic Time
48 Hours
Epoxy Roller Sleeve and @20°C:
Application Tools: Frame
Usage Location: Interior Full Chemical Cure Time
7 Days
Storage Temperature: 10 - 25 °C @20°C:
PRINCIPLE LIMITATIONS:
• Do not apply on New or Wet Concrete (under 28 days old with residual moisture content of or higher 6%)
• Do not apply below 7°C. Temperatures below 20°C will negatively impact curing/drying times. Do not expose to freezing conditions.
• Do not expose to chemicals, wash or allow water to rest on surface until 7 days after application.
• Do not expose to prolonged sunlight as this product is not UV Stable and will discolour
• Concrete is required to possess a Damp Proof Membrane beneath it in order for Epoxy Coatings to be applied.
GENERAL GUIDANCE:
This Data Sheet is for general purposes and may contain information which is not appropriate for certain conditions of use. All
information contained within is accordingly given freely by Resincoat in good faith, without guarantee. Further information on this
product and the data contained within this sheet can be obtained from our technical department. You can call us on 0330 0570
695 where we will provide free technical advice for your project.
Office: Unit 21A Hoyle Mill Road, Kinsley, Pontefract, WF9 5JB
Call: 0330 0570 695
E-mail: sales@resincoat.co.uk
Online: www.resincoat.co.uk
APPLICATION:
The mixed unit of Resincoat High Build Epoxy Factory Floor Paint must be applied immediately and with a consistent, thorough
coating method. Apply with a Roller and Epoxy Roller Sleeve. Flat areas should be cross-rolled ensuring an even and smooth
finish throughout. Move down the floor and repeat the process until complete. If coating a large area, you may require multiple
workpersons. A typical system would be 1 coat of relevant Primer and 2 coats of Resincoat High Build Epoxy Factory Floor Paint.
In this case after the primer has been applied, the first coat of Resincoat High Build Epoxy Factory Floor Paint should be applied
no longer than 24 hours after the primer has cured or is dry to touch. Similarly, the 2nd coat of Resincoat High Build Epoxy Fac-
tory Floor Paint should be applied no longer than 24 hours after the first coat of paint has cured. Please note the pot life for this
product is 20 minutes, the paint will be unworkable due to chemical curing after this time, ensure you remove the paint from the
tin during this window. The paint will be workable on your floor for 40 minutes. For more information on this product, please visit
our Information Hub at https://www.resincoat.co.uk/information-hub for assistance. You can also contact our technical support
staff for a free consultation about your project, either through the chat VOC
function of our website or by calling 0330 0570 695
LEVEL
HEALTH AND SAFETY:
Wear appropriate PPE. I.E Gloves and protective safety goggles. If in contact with skin wash off immediately with plenty of soap
and water. If discomfort occurs seek medical advice. Resincoat High Build Epoxy Factory Floor Paint should be applied strictly in
accordance with manufacturer’s instructions.
Always refer to the Material Safety Data Sheet before mixing or handling this product. Full MSDS available on request.
High Build Epoxy - Floor Paints - Wall Paints - Resin Bound Driveway Kits - Concrete Repair - Waterproofing
Easy to use products at unbeatable prices manufactured proudly by Resincoat in the UK