Professional Documents
Culture Documents
Jsa_installation Fire Water Pump_upgrade Existing Fire Pumps North Parking Ac Plant1,2,3 Building-330 Dhahran
Jsa_installation Fire Water Pump_upgrade Existing Fire Pumps North Parking Ac Plant1,2,3 Building-330 Dhahran
SAFETY EQUIPMENT REQUIRED: Safety Hat, Safety Shoes, Safety Gloves, Safety Glasses, Ear Plugs; pad lock & hold tag; caution/ warning tape
Note: Adequate and special PPE must also be considered for this task
JOB
STEP
NO. SEQUENCE OF BASIC JOB
POTENTIAL HAZARDS REQUIRED HAZARD CONTROLS/SAFE WORK PROCEDURES
STEPS
Lifting of Pumps Mobilization of crane on site without Prior to work crane must be inspected by E & P . Ensure
inspection minimum two tag lines are used to control lifts.
Lifting incident Ensure crane, rigging and personnel involved in lift are
approved by BHPB prior to Commencement.
Uncertified ladders / Man lift are used Certified ladders / man lifts will be used
Mechanical lifting Certified equipment, operator, and rigger and lifting tackles.
Proper supervision.
Check SWL of all lifting tackles before use.
Proper procedure of lifting
Trip and fall due to bad housekeeping Proper housekeeping, Passages free from obstacles.
and poor illumination Proper illumination by means of portable lights
Work on technical rooms Proper illumination to be provided.
Authorized person only allowed to enter Permit to work system
Installation of fire pump
Using hand and power tools Conduct pre-use inspection for all tools
Use right tools for right job
Periodical inspection for power tools training for use of power
tools
Use of required PPEs such as safety shoe, safety helmet,
coverall, hand gloves, faces shield/eye glass and respirator
(disposable type-N95 NIOSH).
Un inspected use of safety harness Prior to hooking safety harness must be checked
specially shock absorber.
Lifting incident impacting operations Perform work under CWP ( Crane is outside the transition
Zone at all the times.
Improper use of lifting cane Competent rigger supervisor will supervise whole rigging
Fastening of nuts and activity.
bolts Rushing of People at location Only concerned people will be present at location.
Ensure proper hauling of materials / get help if required /
Hand Injury wear leather gloves.
Safety Officer must be on site at all the times work as work
Lack of supervision is in progress.
Prior to work all the must be inspected and color coded.
Un inspected tools are used Ensure proper hauling of material is done .Wear hand gloves and
wear safety goggles.
Hand Injury / Eye injury
Grouting Uninspected use of Drill machine. Before use drill machine must be inspected by E&P
Prior to work all PPE’s must be inspected
Improper PPE’S of workers grouting.
Use of 4” Angle Grinder Machine (Only worker/s trained to use the grinder machine shall be allowed to operate the machine.)
a. Check cord integrity. Hand cut from cut wires.. Wear leather gloves.
Check conditions of grinding wheel and appropriate
b. (None foreseen)
RPM
c. Check grinding wheel tightness. Hand injury from inadvertent starting Do not plug in the machine until inspection is
d. Verify the guard is tight and appropriate for the job. Foot injury from dropping the tool Rest the tool on the bench. Wear steel-toed shoes.
e. Verify the appropriate handle location. Foot injury from dropping the tool (See controls for Task d.)
Inspect trigger for physical damage and proper
f. (None foreseen)
operation.
i. Begin grinding. Wear leather gloves, long sleeved shirt, long pants,
Skin damage from sparks and projectiles
or leather welding guards.
Hearing loss Wear ear plugs.
Accidental starts leading to drilled pants or Always remove bit after task and consider removing
leg. battery pack. Do not carry drill with your finger on
a. Carrying/handling of power drill
the trigger. Keep switch in locked or off position
when transporting or switching batteries.
Excessive force and vibration 1. Use both handles to provide power grip
d. Using hammer mode
Excessive noise 2. wear ear protection in addition to goggles
Activity: _____________
Date: ______________
ATTENDANCE SHEET
I DO HEREBY DECLARE THAT THE JOB SAFETY ANALYSIS WAS EXPLAINED TO ME AND I FULLY UNDERSTAND.
10
11
12
13
14
15