Professional Documents
Culture Documents
Power Train Test
Power Train Test
1|Page
Test two
1. An automatic transmission, unlike a manual transmission, does not require the driver to
use a:
a) Clutch pedal b) Parking brake c) Gear shift lever d) Steering wheel
2. Which of the following is NOT a major component of an automatic transmission?
a) Hydraulic control unit b) Manual linkage c) Spark plugs d) Torque converter
3. The purpose of the torque converter in an automatic transmission is to:
a) Increase engine power b) Provide smooth acceleration and multiply torque
c) Change gears manually d) Apply the brakes
4. Automatic transmissions can be divided into two groups. Which of the following is NOT
one of those groups?
a) Continuously variable transmission (CVT) b) Fully hydraulic controlled transmission (HCT)
c) Electronically controlled transmission (ECT) d) Hydraulic torque converter
5. Planetary gear sets are used in automatic transmissions to:
a) Change the direction of the output rotation b) Provide several gear ratios
c) Cool the transmission fluid d) All of the above
6. Brakes in an automatic transmission are used to:
a) Connect the engine to the transmission b) Hold one of the planetary gear components
stationary
c) Disengage the clutch d) Increase engine speed
7. Clutches in an automatic transmission are used to:
a) Stop the rotation of planetary gear components b) Connect and disconnect the torque
converter to the planetary gears
c) Change gears manually d) Lubricate moving parts
8. The function of a shift selector lever in an automatic transmission is similar to the
function of a gear shift lever in a manual transmission.
a) True b) False
9. The accelerator pedal is connected to the transmission by a cable. This cable controls:
a) The position of the shift selector lever b) The opening of the throttle valve
c) The pressure of the hydraulic fluid d) The speed of the engine
10. Automatic transmission fluid (ATF) is used for all of the following EXCEPT:
a) Lubricating moving parts b) Cooling moving parts
c) Transmitting torque in the torque converter d) igniting the air-fuel mixture
11. In Park (P) position, the output shaft of the transmission is locked to the transmission
housing, preventing the vehicle from rolling.
a) True b) False
12. The Drive (D) position is the only fully automatic position on an automatic
transmission. a) True b) False
13. Manual Low (L) gear provides for maximum engine braking.
a) True b) False
14. A planetary gear set consists of three gears: a sun gear, a planet carrier, and a ring
gear. a) True b) False
15. Electronic controls are used in some automatic transmissions to optimize shifting and
improve fuel efficiency.
a) True b) False
2|Page