Professional Documents
Culture Documents
2FB-001
2FB-001
Background
In terms of specification, the tolerance of paper dimension should be within ±1mm lengthwise and crosswise (based
on Japanese Industrial Standards). Within the limits, performance evaluation of the machine has been made and
no particular problems are expected. However, various sorts of paper used in the field might have a dimensional
variation. In such cases, if the paper is slightly longer than expected, the force applied by the paper and Cushion
Cassette might increase too much. This will result in a possible failure to feed paper.
To prevent Fixing drive gear from being worn out, apply grease (M014000080) to exterior of Fixing drive gear, p/n:
P014000080, by following the procedure as displayed below (every 500.000 copies).
(1*) In case of doing this to old plate with no Ø20 hole, remove fixing drive unit and take out <FIXING DRIVE
GEAR>,and apply grease up.
When the specified language is not English, please order the following ‘Label vfeed caution 6nations’ which
is corresponding each language and select the one meeting that spec and put it on ‘Label vfeed caution’ (p/n:
2FB05380)
PUSH
When performing ‘center adjustment’ in DP section, please note that the procedure is different depending on the serial
number of the machine (after a certain serial number, slight changer were made to the DP section on the machine).
Figure 4/page 4
FIGURE 1
7240 / SB 2FB-001
7240 / SB 2FB-001