Professional Documents
Culture Documents
NJG2 Operation Manual (EN)
NJG2 Operation Manual (EN)
NJG2
Solid-state Relays
Operation Manual
Thank you for purchasing our products! Please read
the Operation Manual carefully before installing,
using or maintaining the products.
03
3 Normal Operating, Installation, Transportation
and Storage Conditions
04
Table 1: Main Technical Data
Operating
Input Parameters Output Parameters Current
Safety Factor
(5~120)A
models:
heatsink +
additional
fan-forced
cooling (to
be activated
when the
temperature
exceeds
60℃)
05
Thermal
silicone
grease must
be applied
between the
product and
the heatsink
06
Figure 2: Three-phase SSR
For the wiring diagrams for different applications, please refer to Figure 3, 4 and 5.
Output
Input
Load Load
07
DC-to-DC (D/D)
Output
Output
Input
Input
Control Power Load Load Power Control Power Load Load Power
ensure the IC has sufficient load capacity and "0" level output as low as possible.
Output operating conditions:
● To ensure the reliable operation of SSRs, it is important to use their limit
(effective value); pure resistive load: take 1-2 times the circuit voltage (effective
value).
08
● Selection of varistor: The nominal operating voltage of the varistor should be
selected according to 1.8-2 times the effective value of the SSR's operating
voltage.
● Products with an operating current below 5A should be installed near a heat
dissipation window with good ventilation, or where is exposed to the cooling wind.
● Products with an operating current above 5A should be installed with a heatsink.
Thermal conductive silicone grease should be applied between the relay and
the heatsink to enhance heat dissipation. When the surface temperature of the
heatsink approaches 60°C, forced air cooling should be implemented.
● In order to prevent the temperature rise of SSRs from exceeding the allowable
value, the heat dissipation effect and installation location should be fully
considered during design and application. When installing multiple SSRs side by
side, it is required to leave a suitable distance between them.
09
9.2 Environmental Protection
In order to protect the environment, the product or its parts which are scrapped
should be properly disposed of as industrial waste, or sent to a recycling station
for classification, disassembly, recycling and reuse in accordance with relevant
national regulations.
10
Quality Certificate
Model: NJG2
INSP 04
Inspector:
11
Address: No. 1, CHINT Road, CHINT Industrial Zone, North
Baixiang, Yueqing, Zhejiang, 325603, P.R.China
Zip Code: 325603
Tel: 0577-62877777
Fax: 0577-62875888
12