Professional Documents
Culture Documents
SDS Format 2
SDS Format 2
SDS Format 2
: (6620)188-1387(Revised)
DATE : November 6, 2023
BUREAU VERITAS
CONSUMER PRODUCTS SERVICES DIVISION (SHANGHAI)
Laboratory Test Location:
No.368,Guangzhong Road, Zhuanqiao Town, Minhang, Shanghai
No.168,Guanghua Road, Zhuanqiao Town, Minhang, Shanghai
PREPARED BY : Amanda
Bureau Veritas This report is governed by, and incorporates by reference, the Conditions of Testing as posted at the date of issuance of this report
at http://www.bureauveritas.com/cps and is intended for your exclusive use. Any copying or replication of this report to or for any
Consumer Products Services Division (Shanghai) other person or entity, or use of our name or trademark, is permitted only with our prior written permission. This report sets forth
No.168, Guanghua Road , Zhuanqiao Town, our findings solely with respect to the test samples identified herein. The results set forth in this report are not indicative or
Minhang, Shanghai, China. representative of the quality or characteristics of the lot from which a test sample was taken or any similar or identical product
Post Code: 201108 unless specifically and expressly noted. Our report includes all of the tests requested by you and the results thereof based upon the
information that you provided to us. You have 60 days from date of issuance of this report to notify us of any material error or
Tel: 86-21-24166888 Fax: 86-21-64890042 omission caused by our negligence; provided, however, that such notice shall be in writing and shall specifically address the issue
Email: bvcps_sh_info@cn.bureauveritas.com you wish to raise. A failure to raise such issue within the prescribed time shall constitute you unqualified acceptance of the
Http: www. bureauveritas.com/cps completeness of this report, the tests conducted and the correctness of the report contents.
Page 1/6 Safety data sheet
Printing date 05.11.2023 according to 1907/2006/EC, Article 31
05.11.2023
~
d GHS07
~
dGHS07
51.1.13
Page 2/6 Safety data sheet
Printing date 05.11.2023 according to 1907/2006/EC, Article 31
05.11.2023
(Contd. of page 1)
51.1.13
Page 3/6 Safety data sheet
Printing date 05.11.2023 according to 1907/2006/EC, Article 31
05.11.2023
(Contd. of page 2)
· Information about fire - and explosion protection: No special measures required.
· 7.2 Conditions for safe storage, including any incompatibilities
· Storage:
· Requirements to be met by storerooms and receptacles: No special requirements.
· Information about storage in one common storage facility: Not required.
· Further information about storage conditions: None.
· 7.3 Specific end use(s) No further relevant information available.
SECTION 8: Exposure controls/personal protection
· Additional information about design of technical facilities: No further data; see item 7.
· Additional information: The lists valid during the making were used as basis.
· 8.2 Exposure controls
· Personal protective equipment:
· General protective and hygienic measures:
Immediately remove all soiled and contaminated clothing
Wash hands before breaks and at the end of work.
· Respiratory protection:
Q
_ In case of brief exposure or low pollution use respiratory filter device. In case of intensive or longer exposure
use self-contained respiratory protective device.
· Protection of hands:
S
_ Protective gloves
The glove material has to be impermeable and resistant to the product/ the substance/ the preparation.
Due to missing tests no recommendation to the glove material can be given for the product/ the preparation/ the chemical
mixture.
Selection of the glove material on consideration of the penetration times, rates of diffusion and the degradation
· Material of gloves
The selection of the suitable gloves does not only depend on the material, but also on further marks of quality and varies
from manufacturer to manufacturer. As the product is a preparation of several substances, the resistance of the glove
material can not be calculated in advance and has therefore to be checked prior to the application.
· Penetration time of glove material
The exact break through time has to be found out by the manufacturer of the protective gloves and has to be observed.
· Eye protection: Goggles recommended during refilling
SECTION 9: Physical and chemical properties
· 9.1 Information on basic physical and chemical properties
· General Information
· Appearance:
Form: Liquid
Colour: Colorless to straw yellow liquid
· Odour: Orange
· Odour threshold: Not determined.
· pH-value at 20 °C: 7.5-9.8
· Change in condition:
Melting point/freezing point: Undetermined.
Initial boiling point and boiling range: Undetermined.
· Flash point: Not determined
· Flammability (solid, gas): Incombustible
(Contd. on page 4)
51.1.13
Page 4/6 Safety data sheet
Printing date 05.11.2023 according to 1907/2006/EC, Article 31
05.11.2023
(Contd. of page 3)
51.1.13
Page 5/6 Safety data sheet
Printing date 05.11.2023 according to 1907/2006/EC, Article 31
05.11.2023
(Contd. of page 4)
· Additional ecological information:
· General notes:
Water hazard class 2 (German Regulation) (Self-assessment): hazardous for water
Do not allow product to reach ground water, water course or sewage system.
Danger to drinking water if even small quantities leak into the ground.
Harmful to aquatic organisms
· 12.5 Results of PBT and vPvB assessment
· PBT: Not applicable.
· vPvB: Not applicable.
· 12.6 Other adverse effects No further relevant information available.
SECTION 13: Disposal considerations
· 13.1 Waste treatment methods
· Recommendation Must not be disposed together with household garbage. Do not allow product to reach sewage system.
· Uncleaned packaging:
· Recommendation: Disposal must be made according to official regulations.
· Recommended cleansing agents: Water, if necessary together with cleansing agents.
SECTION 14: Transport information
· 14.1 UN-Number
· ADR, IMDG, IATA Void
· 14.2 UN proper shipping name
· ADR, IMDG, IATA Void
· 14.3 Transport hazard class(es)
· ADR, ADN, IMDG, IATA
· Class Void
· 14.4 Packing group
· ADR, IMDG, IATA Void
· 14.5 Environmental hazards: Not applicable.
· 14.6 Special precautions for user Not applicable.
· 14.7 Transport in bulk according to Annex II of Marpol
and the IBC Code Not applicable.
· UN "Model Regulation": Void
51.1.13
Page 6/6 Safety data sheet
Printing date 05.11.2023 according to 1907/2006/EC, Article 31
05.11.2023
(Contd. of page 5)
· Relevant phrases
H226 Flammable liquid and vapour.
H315 Causes skin irritation.
H317 May cause an allergic skin reaction.
H400 Very toxic to aquatic life.
H410 Very toxic to aquatic life with long lasting effects.
· Abbreviations and acronyms:
ADR: Accord européen sur le transport des marchandises dangereuses par Route (European Agreement concerning the International Carriage of
Dangerous Goods by Road)
IMDG: International Maritime Code for Dangerous Goods
IATA: International Air Transport Association
GHS: Globally Harmonised System of Classification and Labelling of Chemicals
EINECS: European Inventory of Existing Commercial Chemical Substances
ELINCS: European List of Notified Chemical Substances
CAS: Chemical Abstracts Service (division of the American Chemical Society)
PBT: Persistent, Bioaccumulative and Toxic
vPvB: very Persistent and very Bioaccumulative
Flam. Liq. 3: Flammable liquids – Category 3
Skin Irrit. 2: Skin corrosion/irritation – Category 2
Skin Sens. 1: Skin sensitisation – Category 1
Aquatic Acute 1: Hazardous to the aquatic environment - acute aquatic hazard – Category 1
Aquatic Chronic 1: Hazardous to the aquatic environment - long-term aquatic hazard – Category 1
Aquatic Chronic 3: Hazardous to the aquatic environment - long-term aquatic hazard – Category 3
51.1.13