Owners Manual New Age Baleno

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 508

99011M55T03-74E

Part No. 99011M55T04-74E


99011M55T03-74E
September, 2023
March, 2023

99011M55T03-74E

2023
IMPORTANT MODIFICATION WARNING
WARNING/ CAUTION/NOTICE/
NOTE WARNING
Please read this manual and follow its
instructions carefully. To emphasize spe- Do not modify your vehicle. Modifica-
cial information, the symbol and the words tion could adversely affect safety,
WARNING, CAUTION, NOTICE and handling, performance, or durability
NOTE have special meanings. Pay partic- and may violate governmental regula-
ular attention to messages highlighted by tions. In addition, damage or perfor-
these signal words: mance problems resulting from
modification shall not be covered
under warranty.
WARNING
Indicates a potential hazard that
could result in death or serious
75F135 NOTICE
injury. The circle with a slash in this manual Improper installation of mobile commu-
means “Don’t do this” or “Don’t let this hap- nication equipment such as cellular
pen”. telephones, CB (Citizen’s Band) radios
CAUTION may cause electronic interference with
NOTE: your vehicle’s ignition system, result-
Indicates a potential hazard that
• Words like car, model/variant are invari- ing in vehicle performance problems.
could result in minor or moderate
ably used in this manual to denote the Consult your Maruti Suzuki authorised
injury.
“Vehicle”. workshop or qualified service techni-
• Pictorial representations used in this cian for advice on installing such
NOTICE manual are for reference purposes only. mobile communication equipment.
Indicates a potential hazard that
could result in vehicle damage. NOTICE
The diagnostic connector of your
NOTE: vehicle is prepared only for the spe-
Indicates special information to make cific diagnostic tool for inspection
maintenance easier or instructions clearer. and service purpose. Connecting any
other tool or device may interfere
with electronic parts operations and
cause running out of batteries.
WARRANTY POLICY (4) Limitation:
Maruti Suzuki India Limited (hereinafter called “Maruti Suzuki”), This warranty shall not apply to:
warrants that each new Maruti Suzuki vehicle distributed in India (a) Normal maintenance service required other than the three
by Maruti Suzuki and sold by a Maruti Suzuki authorised dealer free services, including without limitation, oil and fluid
will be free, under normal use and service, from any defects in changes, Consumables, headlight aiming, fastener retighten-
material and workmanship at the time of manufacture SUBJECT ing, wheel balancing, wheel alignment and tyre rotation,
TO THE FOLLOWING TERMS AND CONDITIONS: cleaning of injectors, adjustments of clutch and valve clear-
ance.
(1) Qualification: (b) The normal wear of parts including without limitation, bulbs,
To qualify for this warranty the vehicle must be delivered by a
tyres* and tubes, spark plugs, belts, hoses, filters, wiper
Maruti Suzuki authorised dealer and set-up, and serviced by a
blades, brushes, contact points, fuses, clutch disc, brake
Maruti Suzuki authorised workshop.
shoes, brake pads, cable and all rubber parts (except oil seal
(2) Term: and glass run).
The term of the warranty shall be twenty-four (24) months or (c) Any vehicle which has been used for competition, rallies or
40,000 kilometers (whichever occurs first) from the date of racing.
invoice to the first owner. (d) Any repairs or replacement arising from accidents or colli-
sion.
(e) Any defect/ damage caused by misuse, negligence, abnor-
(3) Maruti Suzuki Warranty Obligation: mal use, insufficient care, vandalism, theft, riot, fire, flooding -
If any defect(s) should be found in a Maruti Suzuki vehicle within not limited to entry of water in the components resulting in
the term stipulated above, Maruti Suzuki’s only obligation is to engine seizure, hydrostatic lock, etc. or external damages to
repair or replace at its sole discretion any part shown to be defec- the body/ components.
tive, with a new part or the equivalent at no cost to the owner for (f) Any damage resulting due to usage of adulterated fuel/ lubri-
parts or labour, when Maruti Suzuki acknowledges that such a cants/ oil/ coolant/ fluids/ polishing products and fuel/ lubri-
defect is attributable to faulty material or workmanship at the time cants/ oil/ coolant/ fluids used other than those specified in
of manufacture. Such defective parts, which have been replaced, the Owner’s Manual.
will become the property of Maruti Suzuki. The owner is responsi- (g) Any vehicle which has been modified or altered, including
ble for any repair or replacements which are not covered by this without limitation, the installation of performance accessories,
warranty. The decision of Maruti Suzuki shall be final & binding. enlargements of lights, other changes and external/ conse-
quential reasons.
(h) Any vehicle on which parts or accessories not approved by
Maruti Suzuki (Non-MSGA, Non-MSGP) have been used.

(* - If there is a complaint related to tyre, the customer may contact


respective tyre manufacturer.)
(i) Any vehicle which has not been operated in accordance with (x) Any vehicle on which the retro-fitment is not authorized and/
the operating instructions in this Owner’s Manual and Service or type approved as per the standards prescribed by the rele-
Booklet. vant authority including but not limited to Automotive Stan-
(j) Any vehicle which has not received the service inspections dards of India.
prescribed in this Owner’s Manual and Service Booklet. (y) Any vehicle on which the retro-fitment is such which directly
(k) Any vehicle which has been assembled, disassembled, or indirectly causes any damage to the vehicle or affects the
adjusted or repaired by other than a Maruti Suzuki authorised functions of the vehicle in any manner whatsoever.
workshop.
(l) Any vehicle which has been used for purposes other than (5) Extent of Warranty:
what it was designed for. This warranty is the entire written warranty given by Maruti Suzuki
(m) Any damage or deterioration caused by airborne fallout, for Maruti Suzuki vehicles and no dealer or its or his agent or
industrial fallout, acid rain, hail or hail storm, wind storm, employee is authorised to extend or enlarge this warranty and no
lightning, bird droppings, rodents bite / rat bite and such other
thing that result in damage to the vehicle. dealer or its or his agent or employee is authorised to make any
(n) Insignificant defects / noise which do not affect the function of oral warranty or representation or assurance on behalf of Maruti
the vehicle including without limitation, sound, vibration and Suzuki.
fluid seep. Maruti Suzuki reserves the right to add any improvements or
(o) Any natural wear and tear including without limitation, ageing, change the design of any model at any time with no obligation to
wear & tear or deterioration such as discoloration, fading, make the same changes on units previously sold.
deformation or blurring and fabric discoloration.
(p) Installation and usage of domestic LPG gas/LPG Cylinder. (6) Warranty Service:
(q) V-belts, hoses and gas leaks. To obtain warranty service, the complete vehicle must be pre-
(r) Any vehicle retrofitted with LPG/CNG kits.
sented at the owner’s expenses to Maruti Suzuki authorised work-
(s) Repainting including patchwork, bodywork and mouldings
and interior trims. shop.
(t) Corrosion, rusting of body parts and/ or components. The customer shall be responsible for his belongings or accesso-
(u) Any vehicle on which odometer has been changed unautho- ries fitted in the vehicle at the time of presenting the vehicle for
risedly or odometer reading has been modified/ tampered service and no claim shall be entertained in any manner under any
with/ or not matching the service records. circumstances.
(v) The damage(s) caused to the vehicle being unattended
despite knowledge that the defect exists and ignorance by
the owner/ user of the vehicle.
(w) Any damage(s) caused to vehicle including battery/ tyre due
to parking of the vehicle in idle condition for long duration of
time periods.
(7) Owner’s Warranty Obligations: (8) Disclaimer of Consequential Damage:
Maruti Suzuki assumes no responsibility for loss of vehicle, loss of
NOTICE time, inconvenience or any other indirect incidental or consequen-
tial damage resulting from the vehicle not being available to the
The owner shall not use the vehicle in a damaged condi- owner because of any defect covered by this warranty.
tion and report the same immediately to the nearest Maruti
Suzuki authorized workshop. This would result in early
inspection and repair of the vehicle and any possible harm (9) Change of Owner
to the person or aggravation of damage to the vehicle can Even if ownership of the vehicle changes, the remaining warranty
be prevented. period is effective for the new owner.
This warranty is applicable only in India and not transferable to
It is responsibility of each owner to: any other country.
– Have performed, at his own expenses, by a Maruti Suzuki
authorised workshop all the service inspections specified in NOTE:
the Maruti Suzuki “Owner’s Manual and Service Booklet” Notwithstanding the warranty obligations, Maruti Suzuki may
–              the reuse reworked (refurbished) parts for undertaking rectification of
              recalled vehicles in terms of applicable laws.
  wheneverrequesting service inspections or warranty
service.

If the “Owner’s Manual and Service Booklet” should be lost or


destroyed the owner should consult the Maruti Suzuki authorised
dealer from whom the vehicle was purchased for instructions con-
cerning replacement of the “Owner’s Manual and Service Book-
let”.
EMISSION WARRANTY POLICY 3. The method of examination for deciding the warranty of the
parts will be at the sole discretion of Maruti Suzuki and Maruti
Suzuki authorised workshop and results of the examination will
Maruti Suzuki offers the Emission Warranty on all Maruti Suzuki be final and binding. If after examination, the warrantable con-
vehicles (apart from the Regular Warranty and will run parallel to dition is not established, Maruti Suzuki and Maruti Suzuki
the regular product warranty) only in four metropolitan cities (New authorised workshop has the right to charge all, or part of the
Delhi, Kolkata, Mumbai and Chennai) with effect from July 1st, cost of such examination.
2001.
4. Under Emission Warranty, the parts (as given in Annexure - A)
Terms: will be changed free of cost, but the consumables will be
The Emission Warranty will be applicable for 80,000 kms or 3 charged as per actual.
years (Whichever comes earlier) from the date of invoice to the 5. If the part covered under Emission Warranty or the associated
first owner. The remaining warranty terms will be valid in case of parts, are not independently replaceable, on account of these
any change in ownership provided the production of all valid docu- being integral parts of a complete assembly, Maruti Suzuki and
ments. Maruti Suzuki authorised workshop will have the sole discre-
tion to replace either the entire assembly or by using some of
Conditions: the parts of the system through suitable repairs or modifica-
1. Under Emission Warranty, Warranty claims will be admitted for tions.
a prima-facie examination, in case vehicle fails to meet the
6. Any consequential repairs or replacement of parts which may
Emission Standard as specified in sub rule (2) of rule no. 115 of
be found necessary to establish compliance of Emission War-
Central Motor Vehicles Rules (CMVR), 1989.
ranty, will not be considered under warranty, unless the same
2. The warranty claims will only be accepted after examination is under product warranty. The consumable will be charged as
carried out by Maruti Suzuki or Maruti Suzuki authorised work- per actual under such repair or replacement.
shop which leads to firm conclusions that the 7. Maruti Suzuki will not be responsible for the cost of transporta-
a) Original settings have not been tampered in any case. tion of the vehicle to the nearest Maruti Suzuki authorised
b) Part (as given in Annexure - A) has a manufacturing defect. workshop or any loss due to non-availability of the vehicle
c) Vehicle is unable to meet the Emission Standards (as given during the period of lodging of a warranty claim and examina-
in 1.), inspite of the vehicle having been maintained and tion and/or repair by Maruti Suzuki authorised workshop.
used in accordance with the instructions as specified in
Owner’s Manual and Service Booklet and the used fuel and 8. Maruti Suzuki will not be responsible for any penalty that may
different oils (Engine oil, Transmission oil, Brake oil etc.) are be charged by statutory authorities on account of failure to
also as per specification. comply with the EMISSION STANDARDS.
9. Emission Warranty will not be affected by the change of owner,
provided all the documents are available.
 All maintenance actions (as specified in the Owner’s Manual Annexure - A
and Service Booklet) need to be followed and recorded in the List of parts (if applicable) covered under Emission Warranty
manual for emission warranty. 1. Fuel Injection Assembly, Pressure Regulator, Throttle Body
 The customer needs to produce the PUC (Pollution Under Assembly.
Control) certificate valid for the period preceding the test 2. Electronic Control Module (ECM).
during which the failure is discovered. The   
receipts (for the maintenance of the vehicle as per 3. Intake Manifold.
          in  Owner’s Manual and 4. EGR valve.
Service Booklet from the date of original purchaseof the 5. Ignition Coil.
vehicle) will also be required. 6. Canister Assembly.
7. Vapour Liquid Seperator.
8. Fuel Tank and Filler Cap.
Conditions under which the Emission Warranty is not 9. PCV (Positive Crankcase Ventilation) Valve.
APPLICABLE 10. Oil Filler Cap.
1. In the absence of valid PUC certificate. 11. Catalytic Convertor.
2. Vehicle not serviced from Maruti Suzuki authorised workshop 12. Exhaust Manifold.
as per the schedule specified in the Owner’s Manual. 13. All Fuel Injection System related Sensors.
3. Vehicle subjected to abnormal use (accident, motor race, ral- 14. High Pressure Fuel Pump.
lies or for the purpose of establishing the records etc). 15. Glow Plug.
4. Use of non MSGP (Maruti Suzuki Genuine Part). 16. Glow Plug Controller.
5. Vehicle that has been tampered with.
6. Tampering with odometer so that the actual kilometer reading
cannot be determined.
7. Use of adulterated fuel and/or unspecified oils (Engine oil,
Transmission oil and Brake oil etc).
SERVICE STATION GUIDE
1. Fuel (see section 7) 8
2. Engine hood (see section 7)
3. Tyre changing tools (see section 10) 2
4. Engine oil dipstick (see section 9) 6 1
5. Engine coolant (see section 9)
6. Windshield washer fluid 4
(see section 9)
7. Lead-acid battery (see section 9) 2
9 3
8. Tyre pressure (see Tyre Information
Label on driver’s door lock pillar)
9. Spare tyre (see section 10) 5 7

4
6 7

2
5

55T00010
TABLE OF CONTENTS QUICK GUIDE 1

FOR SAFE DRIVING 2

BEFORE DRIVING 3

INSTRUMENT CLUSTER 4

OPERATING YOUR VEHICLE 5

ADVICE FOR YOUR DRIVING 6

OTHER CONTROLS AND EQUIPMENT 7

VEHICLE LOADING AND TOWING 8

INSPECTION AND MAINTENANCE 9

EMERGENCY SERVICE 10

APPEARANCE CARE 11

SPECIFICATIONS 12
QUICK GUIDE

QUICK GUIDE 1
Illustrated Table of Contents .............................................. 1-1
Warning Lights and Indicators .......................................... 1-9
Warning Buzzer ................................................................... 1-18

59RN00020
 

   


  (1) (2) (3) (4) (5) (6) (7) (8) (9) (10)
  !"
# $ !"#
! % &  '  #"
( )    )  !"#*+,"!,
- .. /  0"
1 & 2  0"#0
0 3 '4 $  ,"!-
* 5   !"(
, & )  )    
 !"!+,"(
 & /     
 -"-(+-"*0
 4      -
     ,"!
# 4 /      -"-(
! 4     
    ,"!
(     ,"! (11) (12) (13) (18) (19) (20) (21) (26) (27) (26)
-        7   
 &$    !"#( (16) (14) (17) (15) (16) (17)
1 3   !"#+,"! (22) (23)
0 .54  $  !"#0+,"!
* ..$    
 !"#-+,"!! (17)
(24)
, 8 3  0"(
# ./      -"-( (25)
# 5 87/  "# 3    $8  
## 9 $  ,"!!
#! &  $  ,"!!
#( & 54  $  !"#0+,"!!
#- 5 $  ,"!!
#1   -"*
#0 $   $  !"#+,"!-
--5,


 

 " # 
  &  '  #"* (1) (2) (3) (4) (5) (6) (7) (8)
# . $  0"0+,"!-
! 4:  0"1
( )  $ ;. <
.2 ;  #"(!=+=# (4)
- 3  "        
 0"#,
1 / $  0"0+,"!1
0 4 9 #"#
* 4 / 2 ;    
 #"(
, .4  #"-
 4 2 ;     #"(
 .4 9     
 0"0
=>9       
  ;   
 7
=#> ?8:8&           
        ;7 
2/5:82&92@    + 8253
48&%A4?BA&C/3$ 


(11)

0#'-
(9) (10) (10)
--5#!

!
 

 " %


 2 @  0"( (1) (2) (3) (2) (2)
# 4 9 #"#
! & 4  #"(
( 274   
 0"
- A49 /   4     
 0"1

&' ( &' )

(4) (5)

--5#1

$
 

 " *


 @ 9D 0"!
# . E ;  (1) (2) (3) (4) (5) (6) (7) (8)
 #"(
! 27 0"
( 3    2  /    47
 0"*
- A49    0"1
1  E.2 ;  #"(
0 8 3 & 3  
 0"(
* .$ % $  0"
,  ; $  -"0
 @  $  -"#+-"##
 )  $4  !",
# 8 )  / !"*
! 8 ' / #"
( $4  !"!

(11) (12)

(10)

(9)
(13) (14)

--5#

 

+ , 
 3 F  )  4  !"#* (1) (2) (3) (4)(5) (6) (7) (8)
# 3  "    
 0"#,
:       
 0"#,
! )    )   ) $ 
 !"#*
& )  ) ) 4 
 !"!
( &2 /   
 0"#*
- / ("+("!
1 3 "    7   
 -"(1
0 / /4    
 -"((
* $  /$  !"# (9)
54  /$  !"#0
, 3  & )  4  !"!
  3  0"
 5 5    
4 $$  #"0
#    4       7-
    7     
 -"!
! 8  4       7 (11)
 7   
 -"-
(  A 5 7
 E4  0"#
- . ,"#(
(10) (12)(13) (14) (15)
--5#


 

+ , !
 4 =    -"(1
# A 4 =    -"(1
! 9 /4 =
    -"(1 (1) (2) (3) (4)
( 3 "    74 =
    -"(1 HUD
- 84 G%..4    
 -",#
1 /  4     -"-(
0 3      !"#1
* 8?@2"45% %.. 
    -"!,

=>.3 "    7

(5) (6) (7)

(8)
--5##

-
 

./// +'+ 0


1 ''2 (1) (2)
 $   
    0"0
# 4 7 ,"#+"-
! $   
    0"*+,"!0+#"!
( $ / 3 0"0
- $  /  9    
  
1 5 87 "#
0 B 3   "-
* B  "0
, )) "- (3) (4)
 5;  "-

(6) (7)

(8) (9)

(10)
(5)
--5#-


 

&
 H7  4  47 &
/ !",
H7 4 47 -",
4  8  -"( (1) (2)
# H7 !"
$ !"#

! H7 87 47 5  


 !"1
4  8  -"!
H7 !"
$ !"#

(3)

--5

3
 

5 / . /6   7


5 / . /6
+ 7 0&' (2

(1) (11) (8)

(10) (7) (6) (9) (13) (5) (4) (14) (12) (2) (3)
--5

4
 

+ 7 0&' )2

(1) (11) (16) (8)

(15) (10) (7) (9) (5) (13) (3) (12) (4) (2) (14)
--5


 

I      ;  ;  + 7;  ;   7/ 7  
       '  4F   F  
I                    =       
    %? +           7        +-
  '  4F   F  
I .8?@2"45% 7+                 

5 /  /6  8+

 = & 9 47)  $ 

 E4 9&  $ . E4 9&  $ 


# &
&  E4 9&  $ 

! = & 2 ; )  $ 

( %  $.)  $ 

- = %  2 "9 47294)  $ 

1 = & 3 8 / 5  )  $ 

0 = %  '    $ 


 

5 /  /6  8+

* = %  8  4 $ 

, = & 8 %  )  $ 

 = & / )  $ 

 = %  ;  FH7 4 47)  $ 

# & % )  $ 

! %  9 &  2@4 

( %  5   )  $ 2@4 

- %  $83  )  $    

!
 

5 /  /6  8+

1 = %  ' )    $    

$
 

 7
+ 7 0&' (2

(18) (25) (26) (18)

(24) (19) (20) (27) (22) (23)


--5-


 

+ 7 0&' )2

(18) (25) (26) (18)

(21) (19) (20) (27) (22) (23)


--51


 

 7  8+

* @ 54    

, 9 ' 9 3 9   $ 

# @      $ 

# @ ..$   $ 

## = %  84 G
%..  $    

#! = %  84 G
)  $    

#( 9 $8 / 5  $ 

#- = @ 8?@2"45%   $   

-
 

 7  8+

#1 = %  8?@2"45% %..  $   

#0 & 4 747  


 

5 / )99
I =>5      ; 2  +  ;      7
         7
I =#>5  ;      7          7

56 5 / 99 + 7   +&


)     ;FF 5 77   ;    C 
     ;7     >
I 9    - I A      7    7
 D-  
  I        %?
9  7#-
 
)     ;FF      77 ;    
        ;  J    
      I 9 (   ;   
 %?
9  7
D* 
 ;FF 5  ;  )  
=   +              
I /      
)     ;FF 5 ;          ;  7  7 ;
    %?  7/  '  4F   F  
  I / 

$ 
 ;FF 5  &
I / 
$ 

3
 

56 5 / 99 + 7   +&


)    ;FF 5      ;4    
I 9    -       7 ;
 D,-- 5     ;) 
   ;
9 
= 5      ;) 
 ;   
 ;FF 5  ;  ;  4    
        ; 
I ! ;      
  
$ 
=
)    ;FF %   7 4    
        7
I / 

$ 
=
)      ;FF 5       5 
 E 
I / ;

$ 
=

4
 

56 5 / 99 + 7   +&


)     ;FF 5     K&L&    
     - /      
 I 9    -




  
)     ;FF C      $%/H%..; 
       7;     / 
      I /  = '  4F   F  
   $%/H
%..
)     ;FF 5 7;  ; 7  7
    %? 2 '  4F   F   7
  I 9    

9  7

=
)     ;FF 5 7;    ; 7
     7 ;   
I 9   9     
  
$ 
=

!
 

56 5 / 99 + 7   +&


)    8D      )                
      ;FF    %?  2//+       
      3 +   + 
 %?2// I - ;              -
   ;         
9 
 ;FF =
I / 
)    8D      5 7;   
      ;FF 9    

I - ;      
   9 
=
)      ;FF                
 E  M 2//$%/H%..
I 9    -

 ;FF 5       7
      $%/H%..;7  
I / ;  M   
3        ;7  '   4F   F
 

!
 

56 5 / 99 + 7   +&


)    8D ;FF 5      2//  %?      
M
        $%/H%..
I 9    -
  D # - 5     
M
  5    
27       
/   7

$ 
=#
)    ;FF 27       
$%/H; /   7
 I 9    -
  D # -
  $ 
=#
)     ;FF &       ;        
;     -    /      7   7
 I 4 ;    7   +  ;    7
 +  ; 
   +  M
;   7 
 +   
;
)    ;FF 5            ;7  -
 M    4      
I # ;    -     


!!
 

56 5 / 99 + 7   +&


)      ;FF 5        7;  
     -     
 7;78?@2" I #9  I 5 ;    -
45%  7          ; ; 
8   I 5   
=# I 9 ;   
I 5; 7 ;   
I #          7 
;78?@2"45% 7
I 5    7   
  7     
 ;FF 5      ;          
        7
I #9  5  +  ;
M  4    ;   7+         
  K L   
# 47  
!     
 ;FF 5        7;  
       
I -;  I 5  E ;   
I 5  E    

 9  +      ;    ; 


 +;   +  
;
 4    ;   7+         
  K L   
$  # )   ;    
=# 7           +    
   

!$
*:% #(* %;8

*:% #(* %;8


 <= # * >>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>> !
# )  6  %  #&+ >>>>>>>>>>>>>>>>>>>>>>>>>>> !! !
* # >>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>> !
  ? 7' / 0  1 ''2 # / .7@ .< >>>>>>> !
A  >>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>> !3
% # >>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>> !
#   & >>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>> !
#&  6  >>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>> !
# ) >>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>> !!
 /    # ) >>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>> !!-
# ) ,  #&+ 0:&  * #2 >>>>>> !!3
# ) *7 . +  #&+ 0:&  * #2 >>>>> !!4
6  %  #&+ >>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>> !$
#''+ %  #&+ 0( /2 >>>>>>>>>>>>>>>>>>>>>>> !$4
56  < / 6 ;6 7 B 6 #%# ( / #&+ >>>>>>>> !
 /  ( / >>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>> !
-,&?#!
*7   ( / >>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>> !3
56 # / 6 /  >>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>> !
56 . / 6 ./// >>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>> ! -
*:% #(* %;8

 <= # *  / 6 *


* A 5(%88
*   @ 6 B / '7-
+'  /   +   +&   6  <=  
 +  / B 6 6 '
 7 /    <6 7 7
  77 >
D 67@ 6 6  + /++
 6@  6 >
D 8< 7@  +>
D 8<    + B6 76 
   6   6 + +&
7 6 7?+/  <6 7
  7  /> 1,&34-0
D 8<  +/  +>
5(%88
--5#

5    E     < +'& 7" 7>  &
       ;7    > 6 E7 +&  B 6
     +'  4F ' '   7 77 >
     
)  7    E   
  ;          ;
  +       
           
 7 
) 7         7
      7    -
  + 7
'  4F   
   

!
*:% #(* %;8

# )  6  % 


5(%88
#&+
/  
D   + &" +<"  +-
  >  /  +& '-
< 6+ + 7  /
''&  7 6  @ 
< E&  6  6 < 2  
  7  >

-,&?#(

-,&?#!
2;   

5(%88
D 5 &      +>    ;
D (  / ''+     
6  7   '7 
 &  > 6  < -,&?#!,
  '/ +  ''-
&   & B / 
    +" <   < / 
 <& 6  7" B66 
   /  +  6  -,&?#!*
 / '  "  +  + 9 6
 @  < E&  6  6
<   7  >
/  

!!
FOR SAFE DRIVING

WARNING WARNING WARNING


• Never allow persons to ride in the (Continued) (Continued)
cargo area of a vehicle. In the event • Check that seat belt latch plate • Do not hold a child on a passenger's
of an accident, there is a much (tongue) is inserted into the proper lap. Even if the passenger holds the
greater risk of injury for persons who buckle especially in the rear seats. It child tightly, he/she would not be
are not riding in a seat with their seat is not possible to insert into the supported enough in the event of an
belt securely fastened. wrong buckles in the rear seats. accident and it could result in a seri-
• Ensure that all seat belts are worn • Pregnant women should use seat ous injury of the child.
correctly. An improperly worn seat belts, although specific recommen- • Never use the same seat belt for
belt increases the risk of injury or dations about driving should be more than one occupant and never
death if a collision occurs. made by the woman’s medical advi-
sor. Remember that the lap portion of attach a seat belt over an infant or
• Seat belts should always be adjusted the belt should be worn as low as child being held on an occupant’s
as follows: possible across the hips, as shown in lap. Such seat belt use could cause
– the lap portion of the belt should the illustration. serious injury in the event of an acci-
be worn low across the pelvis, not • Do not wear seat belts over hard, dent.
across the waist. fragile, or sharp items such as • Periodically inspect seat belt assem-
– the shoulder straps should be pens, keys, eyeglasses, etc in blies for excessive wear and damage.
worn on the outside shoulder only, pockets or on clothing. The pres- Seat belts should be replaced if web-
and never under the arm. sure from seat belt on such items bing becomes frayed, contaminated
– the shoulder straps should be can cause injury in case of an acci- or damaged in any way. It is essential
away from your face and neck, but dent. to replace the entire seat belt assem-
not falling off your shoulder. bly after it has been worn in a severe
impact, even if damage to the assem-
• Seat belts should never be worn with bly is not obvious.
the straps twisted and should be • Children aged 12 and under should
adjusted as tightly as is comfortable ride properly restrained in the rear
to provide the protection for which seat.
they have been designed. A slack (Continued)
belt will provide less protection than
a snug belt.
(Continued)

59RN02440
(Continued)
2-3
*:% #(* %;8

(E+   < / 7   # )


5(%88
/  
D   + 76  6
<  '  6& 
''&  > %  &-
+    + 76 
7  '76 7&  6
 > 67@ 6 6 &+ &
'76 + '' 7 &
> %  B  6
 7  '<  & 6 +7-
> *B(

D * 76 "  6     6


7@  7"   76    1,&34-*
5(%88
&+ ''' &  6 76 > I 2 N         
6    & <6 7  D 56  < /"   E 6
4 7; 77  
' 7 '&  /  '   / B6 0& E
I '        ;  
  9> &' B 6 7  '7  7 2"
  
D (<  7+      6 " 6   < B + 
I '  7     
B / & ' 6"  " 76+ 7"  6   < B + >
;    ; 
 ' 7& & 7 > - :6B " 6  6  @  + -
 
/ +& &  7    / @ '   6  /
I 5   ;      
+  '  B> B6  7 B 
  7 ;      
D    & + 76  7  B6     &" ' &
; 
 7 '  6   7@"  /   77 >
I /  ;     7
  7   '   1   D     6 7@ 6
 7+    7 
6 '>   / +  / 7@ 6 7&> :6B "
    7@" 6   6 6    6  
+&  B@ ''&> 7 7   >
D ( 7@ 6 B&   
' /6 '   B6  < /"  
 7 < +&  7>
#    /   + -
++ '7  B6 7@ 
 6 ' /6 '  >
!
*:% #(* %;8

* #
# (E+ 5(%88
/  
5(%88 D  & '7  76 " 7> B
6 7@  & 7@" &
D 8< +'  E 6  <=
+&      < 6 <6 7
  7@ B6   < /> 6
  77 '> (" 6 
  7@ 7 +< -
  6 6   +& 
'7&" 7 /   7>
'<  6  '+7> 6 
67@ 6 6  <=  
+& 7 < E&   77 -
7@  ''& E
00&#-
>
 &   < />
  '7  76 " 7>
D  <  7 <   7@"
B 6 7@  &
5(%88 B6 76 7 6 7 < 
7@>
6     & < 7"
D  &    &   D   '7 & E7  6
767@ 6 6   E
''&" & & +&    >   E7 / 7@
 6    >
     @ /   6  " 6  6
D ( 7@ 6 B&  
 7  > 6  +& 7 <   76 ''&  +&
 ' /6 '   B6  < /"
E&> 7 E&>
   7 < +& 
* &   ''& D   < 7 /  /6 
7> #    / 
  < /> '& 7  6 >   7 /-
 + ++ '7  B6
D   6 '/      /6  '& 7   6
7@   6 ' /6 ' -
6    ''&" 6  & "  +&  /6 77 & B6
 >
///    6  
+&        /  
@ /   7  > 6  +& E" 7 /   >
7 < E&>
(@  6 '/  6 
'/=   6  
  6    ''&
  < />

!
*:% #(* %;8

 % 

(1)
(3)

--5#1 --5#*

# '   E+ < 02 *B

       # 6 /6 E+ < 0$2 0  3         
1 ''2    N   
         2 N  
          
          7
2 N+     -      ; 7  -
;  ;          + N    
7     ;
(2)

        
              
  !          
"         "    !
#"     "      
--5#0   $  !%      
#7@ / E+ < 0!2 $ "    !
      ; 

!-
*:% #(* %;8

   ? 7' / 0  1 ''2


5(%88 &                -
     $     - # / .7@ .<
D  &  < 6 <6 7 B 6 6           !
6   +<"  '-
/F 7@B   / 7 
'<   7   + 6
7@B  6 +'7   '-
/F 6 7  7
   @ /   7  >
6  +& 7 < E&>
8<  < 6 <6 7 B 6 6 (1) (1)
6   +<>
D  6 6    
7@       
7&" 6 6   +& (2)
 '<  6  '+7 --5##
 7  +/7&"  / 
< E&>  $%/H
 6 6     # A?$%/H
--5#,
7@  " & 7 E 6
6 /6    7&> 5        +  5            
A@    6 6         5 5 N  >
  7&  6  /6  7-      +   
     ;-    
 >  
D ) /  7 & 6            ; # 2 N   
E+ 7    77 -       +   + +    "      
>     ;         ;7      
  +'  E 6 6     7  
  B6   < /> ! 57         
;        
7     

!
*:% #(* %;8

A 
5(%88
5(%88
8< +'  E 6  / 
B6 B6  6 <6 7  +< /  *   < B / ' 
& 7  7  6 <6 7> +&     <6 7 7
 7  77 "  / 
6    E&> (B& B
B '  B6   < />
D (B&   6   -
< B +   E ''&  
  < />
D   '7 E7  6   *!4#!-#
6 <6 7 B6 76 +& 6  <  -  ?   
  &   B 6 & <   #  7  
+ 6  B B /> ! 4 ;
  %< B A  C   N        
;7   7   
   5 N   +  
  ; !   7   + 
    +    7 ;7
  ; ; 
)     + 7     
  ; !        
           -
;  7

*'!!1

!3
*:% #(* %;8

( ++ / %< B A  I 5         


5(%88 0  1 ''2    7      -
    K&L   
D  & E 6   < B
+  B6   < /" & 7 
7  6 <6 7"  / 
 77 >
(E 6   < B + 
  < />
D :&  6  /6 '     
7&  7 / + 6
6 /6  <6 7 6  &> (1) (2) (3)
) B 6  6  '   &
(3)
+&      +
E7 6 7    6
& '  >
-!49##(

(:8 C  N     


-0$!#
 ;7  7  
  + & 6   < B 7    5   
+     /  B             7 5(%88
+ >  7   E&  /            
77 >   76  7< 6  0$2
;   7 5       7 6  +& +'  + '-
       ;     K%?L    6 &+> )7@ / /
;7     + 6  B 6  E7 76
I 5    7      6"  7@" 77&  /-
        // +&  +'  '' '-
K%?L    6 &+>
I )    #   + 
       +      
          -
    5      
  +  #J
  

!4
FOR SAFE DRIVING

Outside Rearview Mirrors Electric mirrors (if equipped)


CAUTION Adjust the outside rearview mirrors so you
can just see the side of your vehicle in the (1)
The electrolyte may come out when mirrors.
the mirror is broken. Do not allow it
to come into contact your skin or (2) (3)
eyes. If it accidentally comes in con- WARNING
tact with eyes or skin, flush with If you adjust the outside rearview mir- (4)
water and consult a doctor immedi- rors while driving, you could lose (1)
ately. control of the vehicle, resulting in an
accident.
(2) (3)
NOTICE Adjust the outside rearview mirrors
before driving.
Do not hook anything heavy on the
mirror, or the mirror may break under (4)
the weight.
Manual mirrors (if equipped) 55T020230

NOTE: The switch to control the electric mirrors is


Auto dimming system may not work in any located on the driver’s door panel. You can
of the following cases: adjust the mirrors when the ignition switch
• Light from the rear is not directly focused is in “ACC” or “ON” position, or the ignition
to the sensor (3). mode is ACC or ON. To adjust the mirrors:
• Rear window glass is not transparent
enough or is dark tinted glass. 1) Move the selector switch (1) to the left
or right to select the mirror you wish to
adjust.
2) Press the outer part of the switch (2)
that corresponds to the direction in
which you wish to move the mirror.
3) Return the selector switch (1) to the
55T020220 center position to help prevent unin-
You can adjust the outside rearview mir- tended adjustment.
rors by hand so as to see the sides of your
vehicle in the mirrors.

2-10
*:% #(* %;8

:  %< B A  * / C   7 


#B 76 0  1 ''2        
127,&(       ' 
D 6 7 7 &'   < B       7  
+  ' < 6/6 6 ;7   
.
/   B 76   6 ( ' -
 > B<"  '< 7- 5(%88
& &  76/"    &  < 6 <6 7 B 6 6 -
E 6 +  / 6 7-   < B +  "  +&
& B6  6 /    - A    77 >
 />    < 6 <6 7 B 6 6 -
D 6 +  ' +< / B6 6&   < B +  >
76 6 + ++ E /
/"  6 + 7  
' B6  6 B 76  --5##- (:8
'>   7   '
A< / +  7 ' 76  E
6 B 76  76     
     6>   B &= 6
6 + +&  +/>
 /  6 +  B6  /
D   +'  E 6 - A   / 6 + >
  < B +  & 6 B6 76
+& 7 +/  6 +> 
D    6 7 7  ' &"     "$      
  < B +  & 6>  .          -
7 7 +  >       $       -
         $   
 $    !    
      $  
  "$    "   $ 
$ !
' ($   ""   $" 
         $-
   $"     !

--5##1

!
*:% #(* %;8

%+ * / A         "      B  B 76 6 +  / + 
0  1 ''2       $       7 
  $    $    #%%  )        $%/H %..+
)           ! 7         
        +- ' &"  "              ;       ;   + 
              )*   "        +   
   N   -  $     
               +   4     E       
I ) 7                    $       
   ;7               "    - I  7    +    
      +   -  !    
 ;      7
I 5     +    
           
2//%?
I 5 7      (2)
 ;  C       
  ;    ; +   
  5       7
+   K3    
      L   
 
(1)
127,&(
  7 B  76  6 +  --5#(,
 9"   6 7 >  6
+      # 5   ;     E
'& B 6 6B /" 6 + -    #
 +&  +/>

 #        " $
' &"     $      )  ,         
             ./ !
"     !
' &"           "$
       "       -
!!
*:% #(* %;8

47  ?;; 
(3) ( 
(5) (6)   ; %

(7) 8 ; 5 
(4)

I 7      


  !   (    -   -
7+   -
          
  ;FF   ;  
--5#-& -,&?#     ;  
!      !       1 $%/H;
      (   0 A?$%/H;
 +   -
;          (  7;7
&        (       7   !
  7     
I  7 ;  ;  ; 
7 
I      +    
 + +   

8 7   7      


;   +        -
         -
7       C  
   7   ;  
 ;  ;7  ;    ;FF
;           -


!$
*:% #(* %;8

% #
 %  0  1 ''2 5(%88
3          /  
   N    D ) /  7 & 6  
    E+ 7    77 -
>
5(%88   +'  E 6 6
  B6   < />
D  &  < 6 <6 7 B 6 6
D  & &    76   
6   +<"  '-
&+   76 6 6
/F 7@B   / 7 
 "  76  +&  <&
'<   7   + 6
E   7  >
7@B  6 +'7   '-
56 &   76   
/F 6 7  7
&+" E 6 6 /6  6 --5#,
   @ /   7  >
6    6 /6  ' 
6  +& 7 < E&>
 +< 6 6   
8<  < 6 <6 7 B 6 6
<  / 6 6 76   
6   +<> (1)
(1
&+ 76 6 6  >
D  6 6    
7@       
7&" 6 6   +& (:8
 '<  6  '+7
 7  +/7&"  /   & < 6 +< 6
< E&>    6 <6 7"  +& E+'
 6 6       6  '/  E7"
7@  " & 7 E 6  /  E&  +/>
6 /6    7&>   < 6 +< 6
A@    6 6    6 <6 7>
  7&  6  /6  7-
 >  --5#
/   &           " "  
      $    5    +  
           !          5  
   +    
         ;
        ;  

!
*:% #(* %;8

   +   + +   #   &


  ;      
* / % # 127,&(
   7
5      7     ; D 56 & +<  7@" +@
)          7+                6  B /  6@ 
N             6   6/  6 
           7-    7/6 & 6 -
5     >
+  7 7@"  6 /"   76> 6 
 $  7 6' '< +/  6 
% 7 6   &+>
D A@  6  B /  
B >

--5#!
-#&'#-
# 3;; ;   "
 ; ; 
)    +
     7;   --5#-

! 4           


5(%88           + 
  B &     6    ;   
7  B 6 6  7 6
  +<   B ' -
 >

!
*:% #(* %;8

127,&( 127,&( (:8


(  / 6  7@ - 56 & +<  7@" +@ ( 7 / 6  7@"
B"   B &  / +-  6  B /  6@  767@ 6   7@ 7&>   
    6 7@ ' /> 6  6   6/  6  "  B  ''  6 
+& 7 +/  6       7/6 & 6 7@" <>
6 7@  '< 6 7@  6 /"   76> 6  6'
+  / 7@ 7&> '< +/  6  &+>
127,&(
D 56  / 6  7@
5(%88  6 + '  "   B
A
 &   7& 7/  6 '- & &  / +    6
/ 7+'+ B 6 6  7@ ' /> 6  +& '< 6
7@  B" 7 6 7@ +  / 7@
7/   +&  6B " 7&>
7 / E&> 8< '  7/ D 56  / 6  7@
6 /6 6 6 7@> $
 6 + '  " 6 
7& & 6  <  & +-
5           + /  6 7@ >   '6 
  ; &  / + +   &
''& / 7 < 7>
(:8 D ( 6 7@   / 7 <&
--5#0
 7 / 6  7@" 
56  / 6  7@      & 6 ''>
6 + '  "  7 6 &  ;       77    +& 7 +-
&  /   7/6 B 6 /  6    6 7@ 
7@  6  @> 2     +     -
;  ;          '< 6 7@ +  /
7   7@ 7&>

(:8
  ' & 6  6 
7@ 7@ ' /"  &  /
+& / 7/6   E>

!-
*:% #(* %;8

#&  6 
.  7+  7       5(%88 5(%88
   D  &    6 76 ' /  
7@"  76  +& '   
6 76  +&  6B " -
,7  6   6 % # /  < E&>  <  6 "
 6 76 ' 7@  />
D 56   7&   6
76  B6     76 
  &+  6  '-
/= " < 6 B-
/ ' >
G #  6  '/= 
 6 B& 7@>  6  '-
/=     B
'  " 6    @    -,&?(1-
E&   +E +'7  6
 '/=   / G   76  '  6   6
-H**
B   '&> B B     " 6
I 4    D    - /   76  +& / < E& & 
;+            ; / +'7     7 
 7    / 7 < >
I 4       7-   B  76   ' 6
  ;  E    7-   6 B B    
  F >
D   B 6 6  " 7>"
  76   +< '  
 <6 7" 76  6 + 
6   > :6B " 6 
6 '   &  E&>

!
*:% #(* %;8

( 6  8  5 # ) 5(%88


/  
D  B  + ''    /
 "    @ /  
7  " 6   +&  '-
<  6  '+7" -
/  < E&>
  B B  + '' 
   /  >

1,&341

1,&34-,
5(%88
D 6    6  <6 7 
5(%88  /      77-
D    < B 6  76   & '    9>  6 6
'> <  & 6 6 76  '   6 7@  76   
 /6&" '' ''   ' - 76  6 6 6 6"  
"   6 <   7  " 6 ' '   6   
7>" 6 76  +& /    7&  6 6 '"
E&>  6 6 76     
D   76    B   " 76    &+ '7  6
   @ /   7  "  > *   ''&  
6 76  +& /   E&>   +&    
)   B& 6<  76  B E&  6 76 >
  > D   76    &+
/   7&   6  
 & 76  6 7 6 6 
6 ' /6     6  B>

!3
*:% #(* %;8

  .  6  ,& B 6 # ( ( 8  :'   5(%88


) 76   5 B"  (E /  
# D  & < 6 'B B B 
%7           & 7  "  +& 7  -
     N +  '   6 'B B -
   E   + +   +  B &  76 "  /  
   77 >
56 & < 6 <6 7" +@
  ' 6 /  B 76 
76/ 6 /   +  :** 
 6 /   B 76  H:**I
'  " @' 6 @& B 6 & 
< 6 <6 7 B 6 & 76 >

1,&341

5(%88
  76  '& B 6   " 
+'"  6 76 F & 
1,&341#
B'' & 6  "  +&
7 < E& 76  7-
 >  7  +/7&" 7 6 5(%88
  B 6 7 >
D  6 B B   7@" 
76  +& ' 6 B B &
+ @  6 6 '/
 / 6 6  %  #&+ +&  7/6  6 B B>
 <    '  
&K4 /  & 47 6 'B B B &  76 " 
;74 9L    6 B B 7@ B 76>
/  

!4
*:% #(* %;8

  .  6  # 7@  ?6   .<  6      ,7  6   .///


     6 5 B 6 ;6 7 +'+

1,&341! 1,&341( 1,&341-

5(%88 5(%88 5(%88


 6  76    ' 6  56 / /   6 <6 7"  6 ///     
6  6" 7>"  6 B -  B  76   &  6 <6 7 7 6 7 77++ '-
B> :6B "   E  B 6 &> '>   B  76     
   /    @ / D    B/ '  76 > :6B " 6  6
+& 77> A<"   E& &  76  +& 7      /  77    
7  77   76  B  77  + 6 <6 7 > @ /" 7>     76  '& 
7+  77 B 6 E7 - D ( 6   +'  6 ///  < B6  6 <6 7
  6 <6 7> <6 7 B  7+ 6  6  ''  6 >
9 / "  76  +& 
+ 6 @  6& "
 /  < 66 '+
 6  6 B 7> < 
&   6   7  " 
 <  76    6 <6 -
7>

!!
*:% #(* %;8

# ) 5(%88 .'6 )


+/7& 7@ / 7 0 .%2
( 6  8  5 # ) D 6 6  '/   7@? -
5   ;    7  
&K4 7/  L     +  B 6  
> B<"  6 <     8$&+        
7  " 6  6 /   ;7     
   7 7 ;
+   ,/ 5+ 6<& ' 7  7 
7; 7 7 7  -
 6 # 7@ , & >   B 6 
'6& 7   7++> +;;  + 
D * 6 6  '/"     ;  7 ; 7 
6 6 ' '   6    7
B  '  7 6 '< "
#& + 
<  /  76 6 +>
A@  6 6 6 ' 4     
 6B& B 6 6 7; 
 6   6 7@" 7 /
6 76  <  /  76 6
+> $ 

1,&3411

-,&?#!

!!
*:% #(* %;8

$ 

-,&?#!# -,&?#!! -,&?#!(

5    ; 5  ;+     5      ;+   
     +           ;     +       K &844L;;   
; 7  7    ; 7; 7 ;7  ; 
    ;   N            ;      
;7          ; 7     2     

      5     ;+     ; 
&"               "   
     N       7    2
"     "      
             ;+
    !      
 ;   7
 "   !
  

(E+  # ) ./6


5   ;     
N 5   ; D  
    
; 7 ;   +
 ;        7+ 
 ; 7

!!!
*:% #(* %;8

7   # )

5(%88
 6   77&> :6-
B "    @ /   7 -
 " 6 & +&    "
 /  < E&> :<
6 B / ' >
D  6    B   7-
  7 < 7@" 6  
/  6<& ' 7
 7  & >
D  6     6 -
+" 6   +&   6<&
' B6 & /  /
+'7>
D  6       +&
< 6 6" & +& 
6B B B6 & / 
/ +'7

!!$
FOR SAFE DRIVING

Seat Belt Reminder 1) Driver's seat belt reminder light / front


Type A passenger's seat belt reminder light /
rear passenger's seat belt reminder
light
When the driver and/or passenger (front
passenger and/or rear passenger) do not
fasten their seat belts, the seat belt
reminder lights will come on or blink and a
buzzer will sound to remind the driver and/
(1) or passenger (front passenger and/or rear
passenger) to fasten their seat belts. For
more details, refer to the explanation
below.

WARNING
It is absolutely essential that the
55T020120 driver, front passenger and rear pas-
Type B senger fasten their seat belts at all
times. Persons who are not fastening
seat belts have a much greater risk of
injury if an accident occurs. Make a
regular habit of buckling your seat
belt before starting the engine.

NOTE:
(1) Along with the seat belt reminder light, a
reminder message shall also come on the
information display (if equipped), for unre-
strained driver and/or front passenger.

55T020130

2-24

55TH0-74E
*:% #(* %;8

 <=   +  * '/=   + 
  E ; ;        - 127,&(
         K%?L          
        ;  ;         D 6   6  '/=
         %?+      K%?L          +   7  6
   >              76 >  6<&  6'
 5  E ;        %?+   <   E7  '  6  76-
  5  E   ;      "   +<"  +& 
;       +  7   6 '/=
       '+" 6  +&
 ;  B@ ''&  7  +-
# 2   E        />   ' 6<&  6'
; - +   E   ; E7  6  76 >  
       ;     ;FF +<"  +  + &
   ;,-  (2) 6 '/= >
! 5             D ' /  6 < &  
  E ; ;  7<" '   6  +&
   ;   ;  <& 7> A
    ;    ;+  #9@ 6 /6& 7++ 6
   7   ;     &  A #9@ /  
4    #      E 7< 7 <&  6  <6 7> 
   )   E        7<  " 7
  - +          B 6 A #9@ 6 
4 )  E    1,&3#! B@6'>
  - +          # 5     E D  & '   1  76   1  -
4 #  ;   + 7"   @  E 7  6
5      ;    7  -  '/=  76 " 6
5   ;     #    6  '/=
   E ; ;        
      +   +  7  6
5     <    76  7  +/>
           ;            -
   $%/H%.. ++ & B '  & B 6  
 5  E   ; 76 B6 ' >
       /  
 E ;  

!!
*:% #(* %;8

5  E ;


127,&(        5(%88
/    E ;  
D '7    + 
D 56   /  6  '-
/= "   <& +' 6  /    #  & 7  > (&  
+& B6 76 B    /
6 '/   ' /6"  / )  7   06 6  <& + 
/  6  7@  7-
  6  76   
# )  / 2 6  '7" < 
+/  6 +&  
 6  +  &+ 
< > (&   +&
7  7 <&> ( 77'
< B6 76 B     / 
  / +''& 076" 
7   +  '7  6
 B&"   B   -
  '  B 7 -
B&2 +& 6+' 6 7  /
<> 6 '   6
 6  &+   +&  7
  +  & 7  7> 
6 77'>
7 6&    7 <" 7
B 6 A #9@ 6 
 B@6'>
' &"            $ 1 D  &" 776" 7  
    $  "         6  " '7  B 6 
         "   - B >
 $ 1        $   D  6 7@   B@ ''-
           22 --5#!! &" @ A #9@ 6 
  ! B@6'  '7 >
' &"        2         7      ; 
 7      / D  / 7 B ''   6
 "    $ 1         7  " 6  
    "    $ 1   ;; + ;+    +  +
     &   7 7  +&  +/" <
$          6/6  ''7  +>
    22    !   ;       7 
    %'7 6   B 6  B
% '/=   +  >
/  
      K%?L  -
           
     K%?L+ 
;     
E   ;     
    ;
!!-
*:% #(* %;8

5(%88 # ) / # ) 


/   /   ;     
D ( 6   +&  '<   77    +
6  '+7   +&
  < E&  7  5(%88
+/7&" < 6 B /    76" <  & 
' >  >  /  +& 7
G 56  / +     "  7   /6
6 7@  & '    @"   "  6   +&
6   +&  B@ ''-  7  ''&>
&>  6  7" @ A
#9@ 6  B@6' 
'7 >
G ( 6   +&  +/"
 7   / 6   --5#!
7/6  6 > ) 7-
/ 6 " 767@ 6 6  127,&(
  7 B 6 &
7@> 56 & +<  7@" +@
G   + &  +< 6   6  B /  6@ 
> 6   6/  6 
   7/6 & 6 7@"
 6 /"   76> 6  6'
'< +/  6  &+>

!!
*:% #(* %;8

# ) ,      ;           F   N7  
  7 ;     
#&+ 0:&  * #2 &        K4  
&  47 2 ; L    4 7;   J   J 
  ;  7          7 2 N 
;         ;  
5   ;   7     +  
    7 -     K4 2 NL  
;  5       -          ;
     ;  7   ;  K4 9  / 
    ;   5 &  47L      
      7       ; N
            
  ;             
4
;     .       ;      -
                 57  
 7+K4 -           + "
  &  47 2 ; L     +     5
--5#-#
     K4  9     ;   7
7L  +      -         + 
5(%88     ;     +    -
5             7    ;7 ' 
6  7  7  & A 4F         
#9@ <6 7=   '-   ;  5    -
 ;; -  ;
  &+> %  B 
6 7  7&  +  - E; 77   5  7 ; 7-
+ 9 &  @  < E&         5      7  7  7-
6>             >
  A    +     ;     -
5    7            7 ;          ; 7+
   ;  7  5                 
         +            K%?L          
 ; ; ;  5        ;       
  K L      + 7  7  ;7   ; K%?L
      ; -   +    #  ;     7
 7C  -             +    +
          K%?L

!!3
*:% #(* %;8

       * ,' :'   # ) # ) *7 . + 
     K%?L ,  #&+
!  ;     - #&+ 0:&  * #2
  7 7    
   7     ;  
3  ; 7    ;7 '  7 5   ;  7 ;  
4F          D  7+    7  ;  7
 ;    7
4     7-
        ; - '  #7'' /
  7 ;7 '   4F   
      7    4 ;    ;
          -     ;      
               ; -
       8   
1,&3410
       7   -
  N7 5(%88           
  +    ;    
5           -  &   6  ' 
         E   
     +     ''&   '" 6 '-
    E   
 "   ; 7         &+ +& 7 < -
      +
    ; K$%/HL    '7&"  /  < E&>
     ;     ;7
         ;  $%/H 56  ' /   '  
 
%..     ,   ; - 7'' / 6 <6 7 1 '' B 6
  7   7  ' " 7 A #9@
'  4F    6  B@6'>
  7 -
     5     
  7    7 ; +   
  7) 7
'  4F   +  '  4F
   +; 7  +
 7     

!!4
*:% #(* %;8

6  %  #&+ 6   

(1)
6  %  #&+ /

(2)

--5#!(

5(%88
-,&?#!-
 6     /
+'7" 6    6 6 ) 
76 ' 02  6 / ' -,&?##*
' 0!2 7    6<& 5   7        7-
 7 " 6  7@ /  6  "    ; 7
+@ / 6      &> 
76  7" 6   +&    
'<  6  '+7" -
/  < E&  7  +-
/7&> < 6   '7 &
A #9@ 6  B@6'>

-,&?##,

'  4F  7  7


       7   
         ' 7 
*B/0 7        7  -
!$
*:% #(* %;8

;J       7 7


   ; 7    5(%88 5(%88
2   7     /  
;      ;7  D  & 7  6 7@"  76 
;       "  ;    &+ +&  
;7         ;  ;  7 ''&   76  &
   )   ;+ '  +&  ' 6 6  > 6 
4F           +& 7 < E&>
7 ;            7  6 7@ B6 
2        +    76    &+  
   7      6 >
           - D  &  6 76    &-
  + B6 76 B <& +/
&  77 " 7>"  +&  '-
 <  6  '+7> 6 
        $   1'#( +& 7 < E&   76 >
   !  6 76    &+ B
D     76    &- <& +/ &  77 "
+  6  '/F > 7>"    6 76   
D  &   76    &- &+ < 6/6  ''7
+  6  "   6  @ +>
  /6 B  6 6
76 =    77 6 
7@> 6  B  6' < 
E&  6 76   6 <  
77 >
D 6  7  /  
7    6  76    &-
+   ''& 7 
6 <6 7> 56  /  76 
  &+" B 6 7-
  B> #7 6 76   6
  &+ 77 /  6
+7= 7 >
0 2

!$
*:% #(* %;8

6  %  #&+   


6  % 
5  ;  7  E               7   ;;
) 7 7   #7  +  7    240#+    
 +  ;

4      


'244@&%A . &  &     
 %;  / %;  /

@  A  Q A A ?2 ?2

@ R A ! Q A A ?2 ?2

@  ,* Q A A ?2 ?2

@  -#- Q A A ?2 ?2

@  ##!1 Q A A ?2 ?2

H7;    ;  ;>


AO4  ;P  E 7       
QO4      ;     
?2O4      ;      

' 3  1   $   #&(*4!
' 3  1     !


!$!
*:% #(* %;8

#7 / 6  %  #&+ &


# ) 5(%88
/      E
/  
   7   F
D <  6 '/ 6 6
76   /6&" 6?6 B  
5(%88 '' /6  6 < 
 77    7   
  E&  6 76 

(:8
 & <6 7  1 '' B 6 6
6  " E 6 6 /6 
6 6    +<    -
--5#,
 / 6 76   "  7&>
B<"    76    )       7 -
1 '' B 6 6 6          + N 
 " 6 6   6       
 +<>  6 6         7
+<    / 6 76   "
1'#(
&     /   5(%88
+< / 6 76   >
D     76    &-  6 76       +''-  6 76    &+ 77
+  6  '/F > &"  76    /   7  6 6  " 6 76   
D  &   76    &- E   7  > &+ 7  7  +&>
+  6  "   6  6  +& 7 < E&  
  /6 B  6 6 76    7  >
 56  / 6 76   
76 =    77 6 
(            $- &+" E 6 6  
7@> 6  B  6' < 
$ $              6 /6  6 6 /6 '   
E&  6 76   6 <  
        ! +76  '   +< 6 6
77 >
D   6  76   '/=    6 6 76   
' B6 6 <6 7   + > #7 / &+ B  77 6 6
/   5    D         >
 7   

!$$
FOR SAFE DRIVING

2) If your vehicle is equipped with the


reclining mechanism of rear seatback, WARNING
adjust the angle of the seatback so that
there is no gap between the child Make sure to position the child
restraint system and the seatback. restraint system securely. Failure in
3) Make sure that the child restraint sys- doing so could result in the child sus-
tem is securely fastened to the main taining serious injury when sudden
seat. braking or a collision occurs.
4) Make sure to pass the seat belt of the
passenger’s seat through the specified
72M00172
parts, according to the instruction man-
ual that came with the child restraint 6) If the child restraint system does not
system. have a seat belt locking mechanism or
a locking clip, secure it to the seat by
using an aftermarket locking clip.
• The aftermarket locking clip shown in
the above figure is a typical example.
(3)
WARNING
(4) Failure to securely fasten a child
restraint system via the seat belt
locking mechanism or a locking clip
may cause serious injury to a child
when sudden braking or a collision
occurs.
59RN02140
7) Shake the child restraint system back
5) Insert the tongue plate (3) firmly into the and forth, and left and right to check if it
seat belt buckle (4) until you hear a is securely in position.
click. • If you cannot ensure secure positioning,
• The child restraint system in the above check the instruction manual that came
figure is a typical example. with the child restraint system or consult
the authorised workshop where you pur-
chased the seat.

2-34
*:% #(* %;8

#7 / 6  %  #&+ &  4%.Q7     7- 3     >
#:*J       
;7   7   (:8
#7 / 2    + 7     
 7      7  & <6 7  1 '' B 6 6
      ;   6  " E 6 6 /6 
7     6  6    +< 
   / 6 76   "  7-
&> B<"    76 
 1 '' B 6 6 6  
  " 6 6   6 
 +<>  6 6   
(1) (1) +<    / 6 76   "
(2) &     /  
+< / 6 76   >
 6 76       +''-
&"  76    /   7 
E   7  >
--5#!-

 $   


(            $-
C           $ $             
    ;   -         !
     4%.Q7 
          ;  --5#!1
5         # 5   
   ;-
 ;  C       
 A  
5(%88        
 6 #:*J &'  76    ;7   7 -
 02  6 &  -  
/ '  "   6 7 ' -
   6  >

!$
*:% #(* %;8

(1)
(3)

--5#, 1*$'#1*
--5#!0
 )       7 - #        + ! A 7      7   
      + N    ; !   ;       -
        ;   5       7  -
     7     ;  

5(%88
If the child restraint system contacts
the head restraint, the child restraint
system cannot be secured firmly.
This may cause severe injury to a
child in a collision.
When installing the child restraint
system, adjust the head restraint
height to the highest position as
much as possible or remove the head
restraint so that the child restraint
system would not contact the head
restraint.

!$-
*:% #(* %;8

   6  %  B 6
' 6

-(@*( -(@*-

(       - - @      


       ;            7 
 7       A      ;  /  
7       7  7    ;7 7   --5#!*
        7  
4      7   
 +  7  
   5  -
1 2          
      7    
K            
      
L 
5 ;       
) 7  7       
;      7     
 7+   7 
         
     
 7 >
7  E; 7
 &      
127,&(     
56  /  76    &- # 4          
+  6  " E 6          ;
 '    6 6   ;        7
   B 6 6 76        
  &+>
!$
*:% #(* %;8

! 3         


         5(%88
       -
    ;7   7-  6  " 7> / 7@  6
  2   76    &+"  +&  
          7 ''&  6  +& 7
     7 ;    < E&   76    7  >
           56 &  6 76   
         &+" 767@ 6 7  6
            6 #:*J
76/  6 ' 6
5(%88 76/>
  76 6 76    '
6 '  6 ///  
'> 77& 76 ' 6
' B  7 6  7-
 <  6 76    &+>

-#&4#(!

( )   + 


         
   &  K3  & L
    N
     
- /       
    

!$3
*:% #(* %;8

#''+ % 
(1) (2) (3) (1) (4) (5)
#&+ 0( /2
5(%88
6  7  7  6 '7 
'<  & & A #9@ <6 -
7= ''+   &+
0 /2> %  B  7-
  7&  +  + 9 &  @
 < E&  6  6 <
  7  >

C           -


    7     
       "
 ;       

 4    ;     


  
# 4     
! . E ; 
 
(  E ;  
- .   
1 . ;  
0 4  ;     
* 2 ; 

(2) (6) (7) (2) (7) (6) (8) (2)


--5#-!

!$4
*:% #(* %;8

56  #%# ( / #&+O *  /


4&4     K4   & 
5(%88
47L5 7   - D #%#  / &+     -
    7    > #%#  / &-
+  6 ''+  
&+  B  '<  6 7-
 < &  / 6   
6 +  +>
 &  6 '/  
 6   "  +& 
 < E&    @-
/   7  >
< B6 &  < 6 <6 7 *B,
1 '' B 6 #%#  / &+"
+@     > . ;         
D  6                 
''&"  / +&  '<      K%?L        
--5#!,
6  '+7> 6  +&   %?
 ;          7 < E&   
 ;  
@ /   7  > & "   $       $
           K%?L  - A@  6 6  <  
 +         " +         $ "
6 '/  6  +  " !
%?+  ;        7 +   ''&   77 '>
   + ; 7 . ;        
 ;  7 7     +    +   
  73  ; 7 5          67        +   7 
   ;7 '   4F                  7    -
     ;       $  !  4   ;   7 7 
      +   ; 
         
     
5+  ;   ; 
  ; 5  D  F 7  +
 7   7   ; 9  

!
*:% #(* %;8

   7       ;  7   7   ; 9   56  < / 6 ;6 7 B 6
N   7        7       ;
N   7     #%# ( / #&+
#   / 0  1 ''2    7-
   / 0  1 ''2 A@ #  * # )


1-B1
1*H',

4  ;        ;  


             5(%88
       %? #%#  / &+     
4  ;        ;     > #%#  / &+ 
        - 6 ''+   &+
  +          +  B  '<  6 7 < &
  7         / 6    6 +  +>
7   %7  -  &  6 '/   -
;      ;    6   "  +&  
           3- < E&    @ / 
 +        +     7  >
;        ;   7 < B6 &  < 6 <6 7
  4   ;   7 7  1 '' B 6 #%#  / &+"
      +   ;  +@     >
         
     
5+  ;   ; 
  ; 5  D  F 7  +
!
*:% #(* %;8

7 #  / , * ,' #%# ( / #&+


:' 

*B(
-,&?#,
5    ;  7 N  
 ;  ;    1,&341,
   7   7+   
5(%88
       7    D   '   & 7" 76"
       ;   7   7>" 7  6  / B6  5(%88
 ;    +      ; + 7"     D   + & 6  / B6"
          &  '  6  > :6- 76  '7 / " '7 /  7@-
B " 6  6  @      " '  /   ' / 6
E&   +E +'7  6  - 7<  >
/ B   '&> D   '7  7@  6  /
D     / 0  1 ''2       6  /  
7   / 0  1 ''2 7 - '  6+> ("   76 &
<" & +& / / +'7" 77 " /7" 7-
 /  < E&>    7  7  " '
' 6   6 B B  7 < /  &+" 7>  6 
  6 > (" B6   / "     + 
 6  "   6/ 6 6 E7 /  >
7@  6  > D   76 77  07'
 A #9@ /  '-
72" 7>"  6 B 6   6
  < B + >

!!
*:% #(* %;8

5 / .  #%# ( /  7 '   B / 


* ,/= #
#&+ #&+ + /

   


 "    
  7 
  -
E  
   ; 

-,&?##    -


E   ; 
  ;  7 +
5(%88   N   
* 6 <6 7 B 6    /  ;       "
  7   /"   76 0#'-        
77  76  7' 6  7    
C 7    ; 
6/  6 > ("  
 + /  6 >
5(%88
8 ; %   B 7 / 76 
     '7 &  .  +
(; (%)(    " (  E  
 # %:# 8P%Q  6 .
7 77>

!$
*:% #(* %;8

H#%# (%)( I A@  .7  #   / 0  1 ''2   E  ;  
  ;   E 
 <=   / ;  
4  ;      
 ;  
4   ;     
  
5 K4&42&92@L    
 ;    7  
 ; 

5(%88
D  6  /  '7  +-
/  77@" 6  / &+
--5#(-
+&  B@ ''&" B6 76 7
    E&  6 <
--5#( #  7   / 0  1 ''2   7  > < & <6 7
'7 & A #9@ 6-
-2 * '/=   /   B@6'>
D  & +6 6  / 
'7  ''&  / +'7  "
6  / +&  B@ ''&
 +&  '7&" -
/    E&>
  +6 6  / 
'7  ''&  / +'7  >

--5#(1
--5#(!
5  E  ;    ; 
        

!
*:% #(* %;8

   6  %  #&-  /  ( /


+ * ,' #%# ( / #&+ 5(%88
:'  /  
5(%88  ;N            G < 6/6 & <6 7  +-
  ;   7+  ;N / &  7  "  +&  
 ;     ; - < /6   // "
;  7  7  7      7   / 
>  & <6 7  
5(%88 &     +/"
6< 6  / &+ '7
D ( 6  / +&  '<  6 & A #9@ 6 
 '+7   +&  B@6'   6  B@
 < E&  7  +- ''&>  6  /  7 
/7&" < 6 B /   / &+  +/"  -
' > / +&  7  7 <&
G   + & 6 ' >   &  7   +-
6 <6 7 6 /6  6   /7&>
 6 '  B 
76/"  / +7  +& D  6  / ' 
> '7  ' " B6 76 6 
1'#( G 56  /  /  /" +'7  6  / 7 " 6
    76    &+ 7>"  6   6 <6 7"  / +& 7 < 7 &
 6  '/F > 7 A #9@ 6   +&  7 < B6 7-
B@6'>  & + & 6  &>
'  6 <6 7" 6  / 6 B /    +& / < 
&  K4  9   /   &  &+ +&  B@ ''&> / < +'7  6  / &-
47L         G 56  /   1 '+" +>  6 7" 7 A
7   7>" 7 A #9@ 6- #9@ 6  B@6'
  B@6'> %  B<" 6>
7>" +    +& <& G %+< / 6  / B6"
7 6 7+' + 
 6  / &+> '  / 6   6
/    / B6" 7>
/  

!
*:% #(* %;8

 <=   / '7  * '/=   / '7-
5(%88  
/  
G  7 ' " ' 
 6 + 7"
'   6  " 
'   7 7 B  /
G      1 '+"
7>
G #6 + '  /  ' 
 6 6
G %'7+  6  
 '   6 
G %'   6  ' " 1,&34##
6 7@ '   6    1,&340
G %'   6 7 ' 
5(%88
5(%88
D   '   & 6" 7"
76" 7>" 7   /    D 56   /  6  '-
   6  / B6> :6- /=   B6 B /  76 
B " 6  6  @        6  "   
E&   +E +'7  6  - < 6 B / ' > * -
/ B   '&>     +&    
D   + & 6  / B6" E&   +E +'7  6  -
76  '7 / " '7 /  7@- /  '&>
  " '  /   ' / 6 G   '   & 6 
  6  /   " 
7<  > :6B " 6  /   '   & 7" 76"
+&  '& +&  7  7>" 7  6  >
+/7&"  /  < G   B  76    
E&>   6  /      
  '/F '  6 
'/= > <  76 
   6   B / 
 >
/  

!-
*:% #(* %;8

#   / 0  1 ''2    7-


5(%88 5(%88    / 0  1 ''2 '7 
/   D ( 6  / +&  '<  6
G *  76  6   &  /  '+7   +& 
/6  B    ''-  < E&  7  +-
&"      76  /7&" < 6 B /
  &+  6  > ' >
G   '7  7@  6  -
/    6  /
  '  6+> ("  
76 & 77 " -
/7" 7 7  7
 " ' 7 < / 
&+" 7>  6  "  
  +  6 -,&?##
E7 /  >
G   76 77  5(%88
07'  A #9@ / 
'72" 7>"  6 B 6   & 76 77  76  7'
 6   < B + > 6  6/  6 " 
1,&340  &  + /  6
" B6    /    7-
   / 7 <" 6 E7
+&  6B   +& 
 ''&"  /  <
E&>
  76 77  76 
7' 6  6/  6
> ("    +
/  6 >

!
*:% #(* %;8

*7   ( /
B 6 #&+ 5@
      +     
       +    
N      -
     +-
    5  
      ;     -
  5    ;  -
     7      
; 7 5 ;        
 7 7 7   F  
     5 ;       - -,&?#!0 -,&?(10
7     D 
 
2   ;     7     5(%88
     D      D 6  < 6   < 6
;    2 N 7       / B6> 6  '-
;    ;         / 6   6   6 &
  4 7;  7 /  6 6 B6 
 J      J           /  +   76 
    ;   . - 6      6
        6> :6B " 6  6
  &  K4 2 NL - B  /  7  6 6>
    K4  9   /   &  * <6 7 B 6     / 
47L         7    /" 77'
      ; N 6     ' / 
-,&?#!1
6 >  6   " 6
'   77' B 
 7    /  /" 
+&  < E&>
/  

!3
*:% #(* %;8

5(%88 5(%88 (:8


/   /   ( / +  1 7@& 
D   76 & E7 "  D    @  ''&  /  7 7&    7 6
'7 & E7 <" 6  / <  +'7  6  / 7+- 767      E >
B6  6>   '7 ' >  7 7 6  - B<"  <  7-
& E7 B 6  /  /  +7 > 17  6 1 7@    6
6  <   '/> D < 6/6 & <6 7  +- 6  / +&    @ "
6 E7 +&  B 6 / &  7  "  +&   76  6 7   /   
 / '   +&  '- < /6   // "    /> 56  &    
' & 6  /  6 <     7   /  >   '   '< @    >
 7  > (" 6 E7 +& & <6 7   &  (" '  "     B 
+< B6 &  +< / <6 -    +/" 6< 6  / 77  + 'B  +@
7  B6  <6 7  +< /" 6& &+ '7 & A #9@ B   > 6 7  
+&  B 6  <= < B  6  B@6'     6+     7 
  < />  76 7  "  6  B@ ''&>  6  /     6 <6 7> ) B" 6B<"
+& 7 < E&> 7     / &+  +- 6 +  / 7+' +& 
D * <6 7 B 6    /"  /"   / +&  7  6   B6    >
  /   7<  7 <&  &  7   6  +& 7  E&>
6  " 7 /- +/7&>
  7< +& 7 6 C         
      /> A          ;
#9@ 6 /6& 7++ A  ; 7  ;   7 
#9@ /   7<      5       
 B6 7< / 6   ;    7  +    
 76 <6 7 B 6    />      7
("  6 "   '7
7' 6" 6/  & 6
E7      +"
 6 E7 7  ''
& 6  /  6 <   7 -
 > 6  6 7   +&
7 < E&>
/  

!4
*:% #(* %;8

#< 7 / 6  / &+ * ( / '&+  -


 ;   +  ;   (:8  
         ;7 ' 
4F           &   6 6  / ''- *  / '& 0  2
 ; &" 6& +&  '7&"
7          /  ' E&>
  E ; + ;  56 7'' / 6  /  6
   ;        - <6 7 6 6 6  /" 7
+  '   4F     - A #9@ 6  B@6'>
     ;  7  
  ;
4        -
     ; .  +
7 '   4F     
  ;         
*B,0
7 ;  &   7  -
7'  4F       I .         D     
;           
4      ;    ;#-
  ;  7;7' 
4F         
          ; 
 7       ;  (1)
   8   
 7   N7
5          
  ;  7+     ; -
7          (1)
 ; K$%/HL      
  ; $%/H%..  
, ;   7 - *B,*8
      7 '   4F I 4     -
   ;  7-     ;       
    5        ; !    
  7    7 ; +    7  
  7 7     
! 
*:% #(* %;8

*  / +& 


&        
; 77  + ;  7
 

*B#

I .            


*B
  ;-
I $      

*  / +&  


*B,,

I 3   ;  5  ;   7    
          
  ;N   ;  
      7  ;   
  +    7  -
  7;  
2+ ;  7    7
           *B!
  ; !        I /        7  
7  2+  ;  
          +  -
;  7  

*B8

I .       

! 
*:% #(* %;8

*B( *B1 *B,

I /      7   I .         D      I   
         
;#-

(1) *  /   


. ;        +
      +  3 +
       

*B-8 *B

I /     D       I :  


          
; !      
7  

*B#

I   

! !
*:% #(* %;8

#  ( / 0  1 ''2  #  #   /    7   /


  ( / 0  1 ''2 +&    / +'7
'&+    4  ;      ;  7
#   /    7   /        +  
'& 0  2       

*B8

I .       


*B#

I .   
*B,

I        ;   


;7    7
    ;! 
   

*B

I $      
-#&'#0!

I 3   ;;

! $
*:% #(* %;8

#   /    7   /


+&  

*B#! *B#-

I     ;   I   ;7 7


*B#
; 7

*B## *B#(
*B#1
I     ; 7 I       ;7    
      I /      7  

! 
*:% #(* %;8

#   /    7   / 56 # / 6 / 


   5(%88
)    A  , - (<  6 / 6 />
 / 6 / 7  7 +-
 "  ' & 6 / 6 
5(%88 7  > # 7 7
6 / 7  7 +- +     7  7 &
 "  ' & 6 / 6  " @ 6 B / '7 
7  >  & 6  6' '< 7 + 
6 /" & +&  B&" +  / & <6 7>
 /  < 66 '+ :6B "  +&   <
 6  6 B 7> 66 '+  6  6 B
*B#  &  6 / "  7  7>
7 +  '  /> D   < 6 /   / 
I    //  7  " B 6
  % /    ,&<- '/  > 6  +& 
  (  77+   7 +-
  7   +&   -
7   6 / '+ 
  6>
D   '@ B 6 6 /  -
 /   / '    +" <
  ' >  7  /
' " /  76@ / 
6   /   6 <6 7 
 '   & B6 6 /  
 />    7&    
*B  6  +   '@ <6 7
I :   B 6 6 /   /" 767@ 6
6   @ 7   
H*% # (%I  6 B  
-#!!(
6 /6 '>
/  

!
*:% #(* %;8

  @  8' B 6 /  %- 56 . / 6 .///


5(%88  / $         
/    7          
D (<  ' / 6 <6 7 B 6 ; 7    
6  /  @ '>   
7&   " 767@ 6 6 5(%88
 B B  7"  6
B   6 /6 ' B 6 6  
@ 7   H*% # (%I>
D  B '' '   &
<6 7= <   &+" @'
6    /     6 B -
6  7  B" < 
6 7     +>
D ' 6 6  ' '  7 1,&340#
 B  6 +   6'
7 6  '  6
/  6 <6 7> 6   5(%88
' 7& +' B6 '@   @  ' B 6 6 / 
  99 7  >  /> :6B "  +&   -,&?##!
D < 6 6 &+ '7  77 " < 66 '+ D *" 76+ 7 7 " '&
'  7&  +/  @-  6  6 B 7> 7 7> +& 776     7
/> (& +/  @/ D 6 / 7  6 <6 -  ' >
6  '  ++ &> 7    / 7      / 6 E7  6
 B   7 " ' & 7- <6 7>
/ 7 +  '  /> /  
D 6 /6  < 7 76/
  &"  6 77
' 7  ' 77 -
&" 7 /  77 >
D  & B  77 & ' 
6 77 ' B6  '"
6 /   6 &+
7 <6"  /  /
  
! -
*:% #(* %;8

5(%88 (:8
/   D  & 6/ & E7  6
/6  <      6-
" 6 /6  < +& 
B@ ''&"  /   +-
7    77 >
  6/ & E7  6
/6  <      6-
>
D  & '  ' ///"  +& -
 B 6  <F < B> ("  
 @ /" 6 /// B
-,&?0#,
E+'    +&   
77 >
-,&?##(
  '  ' ///  6 <6 -
7>
D  & '7 & E7  6
D   + +<   6 <6 -
+ '" 6 E7
7"  +&  B 6  <F
+& +<   B 6
< B> ("    @ /" 
 <F < B    < /> ("
+&    77 >
6  '/F   /
56 &  /  +  6
+&  B@ ''&  6
<6 7" +@  6  + 
E7 +&  6B  B6
 +< >
6  /    77 >
  '7 & E7  6
+ '>

! 
BEFORE DRIVING

BEFORE DRIVING
Keys ...................................................................................... 3-1
Doors .................................................................................... 3-1
Keyless Entry System Transmitter /
Keyless Push Start System Remote Controller ................ 3-5 3
Security System (if equipped) ............................................ 3-16
Windows ............................................................................... 3-18
Lighting Control Lever ........................................................ 3-21
Headlight Leveling Switch .................................................. 3-26
Turn Signal Control Lever .................................................. 3-27
Hazard Warning Switch ...................................................... 3-28
Windshield Wiper and Washer Lever ................................ 3-28
Horn ...................................................................................... 3-31
Heated Rear Window Switch .............................................. 3-31

60G404
BEFORE DRIVING

Keys NOTE: Doors


Your vehicle comes with a pair of identical • Carefully keep the tag in the place other
than your vehicle, so that someone does
keys. Keep one of the keys as a spare key
not find out about the key identification WARNING
in a safe place. One key can open all of the
locks on the vehicle. number. If you lose your key, inform the • When a seat belt or luggage is
key identification number to a Maruti caught by a door, the door cannot
Suzuki authorised workshop. be shut properly and it may open
• When you resell or transfer your vehicle while driving. This may cause an
Key Number Plate to a new owner or operator, give the key accident. Close a door not to catch
number plate with your vehicle to him or a seat belt or luggage in the door.
(1) her. • When you keep the tailgate open
with the engine running, exhaust
Immobilizer System gases will enter the vehicle and
For detail of immobilizer system, “Immobi- cause carbon monoxide poisoning.
lizer System” in the “OPERATING YOUR This may cause severe health prob-
VEHICLE” section lems or death in the worst case. Do
not keep the tailgate open with the
engine running.
• To prevent fire or theft, stop the
engine and lock the doors when
(2) leaving the vehicle.
• When opening a door, be careful of
55T030020 the surrounding area. An accident,
The key identification number (1) is such as a collision with the vehicle
stamped on a metal tag (2) provided with or a pedestrian behind your vehi-
the keys. Keep the tag in a safe place. If cle, may occur. Be very careful
you lose your keys, you will need this num- when opening a door especially on
ber to have new keys made. Write the a windy day.
number below for your future reference. • When a child opens or closes a
door, his / her hands, legs or head
KEY NUMBER: may be caught in the door and this
may cause injury. Opening or clos-
ing a door should be performed not
by a child but by an adult.

3-1
BEFORE DRIVING

Side Door Locks


CAUTION
• When the tailgate is not fully
opened, it may be unexpectedly (2) (1)
closed and this may cause injury.
When opening the tailgate, open it (2)
fully. (1)
• Opening the tailgate right behind
the exhaust pipes may cause burn
injury. With the engine running, do (3)
not open the tailgate right behind
the exhaust pipes.

NOTE: (4) 55T030320


• When leaving the vehicle even for a
short period of time, do not leave cash or 59RN03180 (1) UNLOCK
valuables in the vehicle, to avoid risk of (2) LOCK
(1) UNLOCK
theft. (2) LOCK
• Depending on the setting conditions of To lock a door from inside the vehicle, turn
(3) Front the lock knob forward. Turn the lock knob
the security alarm and the opening con- (4) Rear
ditions of the doors, an alarm may oper- rearward to unlock the door.
ate. Refer to “Security System (if To lock a front door from outside the vehi- To lock a rear door from outside the vehi-
equipped)” in this section. cle: cle, turn the lock knob forward and close
the door. You do not need to pull and hold
• Insert the key and turn the top of the key the door handle as you close the door.
toward the front of the vehicle, or
• Turn the lock knob forward, then pull and NOTE:
hold the door handle as you close the Be sure to hold the door handle when you
door. close a locked front door, or the door will
To unlock a front door from outside the not remain locked.
vehicle, insert the key and turn the top of
the key toward the rear of the vehicle.

3-2
BEFORE DRIVING

Central Door Locking System NOTE: NOTE:


You can switch the function that unlocks all • You can also lock or unlock all doors by
doors from requiring two turns to requiring operating the transmitter or remote con-
one turn, and vice versa, via the informa- troller. Refer to “Keyless Entry System
tion display setting mode. For details on Transmitter / Keyless Push Start System
(1)
how to use the information display, refer to Remote Controller” in this section.
(2) “Information display” in “INSTRUMENT • If your vehicle is equipped with the key-
CLUSTER” section. less push start system, you can also lock
or unlock all doors by pushing the
To unlock the driver’s door only, insert the request switch. Refer to “Keyless Entry
key in that door lock and turn the top of the System Transmitter / Keyless Push Start
(3) key toward the rear of the vehicle once. System Remote Controller” in this sec-
tion.
(4) (1) Child-proof Locks (rear door)
(2)
59RN03180

(1) UNLOCK
(1)
(2) LOCK (2)
(3) Front
(4) Rear

You can lock and unlock all doors (includ-


ing the tailgate) simultaneously by using
the key in the driver’s door lock.
To lock all doors simultaneously, insert the 55T030130
key in the driver’s door lock and turn the (1) LOCK
top of the key toward the front of the vehi- (2) UNLOCK
cle.
55T030410
To unlock all doors simultaneously, insert You can also lock or unlock all doors by
pressing the front or rear of the switch, (1) UNLOCK
the key in the driver’s door lock and turn (2) LOCK
the top of the key toward the rear of the respectively.
vehicle twice. Each of the rear doors is equipped with a
child-proof lock which can be used to help
prevent unwanted opening of the door
3-3
BEFORE DRIVING

from inside the vehicle. When the lock Tailgate


lever is in the lock position (2), the rear
Locking and unlocking from outside the
CAUTION
door can only be opened from outside.
When the lock lever is in the unlock posi- vehicle .

tion (1), the rear door can be opened from


inside or outside.

WARNING
Be sure to place the child-proof lock
in the lock position whenever chil-
dren are seated in the rear.
(3) (1) (2)
(4)
NOTE:
When you open a door from inside, put
your hand out of the window and use the
door handle. 55T030420

(1) UNLOCK 55T030440


(2) LOCK To avoid damage and malfunction of
(3) Tailgate unlatch switch the dumper stay, observe the follow-
You can lock and unlock the tailgate by ing precautions. Otherwise, the
using the key in the driver’s door lock. damper stay (4) which upholds the
tailgate may not operate smoothly
To open the tailgate, push and hold the and the tailgate may not be kept up
tailgate unlatch switch (3) and lift the tail- when opening it.
gate.
• Do not scratch the rod part of the
NOTE: damper stay and do not attach for-
When the tailgate is closed incompletely, eign materials such as dirt, vinyl
follow the procedure below: and tape to this part.
1) Push the tailgate unlatch switch (1) and • Do not lay your hands on the
open the tailgate. damper stay and do not hang any
2) After a few seconds, close the tailgate. objects.
3) Check that the tailgate is closed com-
pletely.

3-4
BEFORE DRIVING

Unlocking from inside the vehicle Keyless Entry System


If you cannot unlock the tailgate by using
the key in the driver’s door lock due to a Transmitter / Keyless Push
discharged lead-acid battery or malfunc- (6) Start System Remote
tion, ask Maruti Suzuki authorised work-
shop. In emergency situations, follow the Controller
procedures below.
(7)
1) Remove the luggage compartment
cover (if equipped) and fold the rear (2) (1)
seat forward for easier access. Refer to
“Folding rear seats” in “FOR SAFE
DRIVING” section for details on how to
fold the rear seat forward.

55T030460

3) Open the cover (6), and then, move the


emergency lever (7) to the direction of
the arrow with a flat-blade screwdriver
as shown in the illustration.
4) Push open the tailgate from inside. The
55T030010
(5) tailgate will be latched again by simply
closing the tailgate. Your vehicle is equipped with either a key-
less entry system transmitter (1) or a key-
If the tailgate cannot be unlatched by less push start system remote controller
pushing the unlatch switch (3), have the (2). The transmitter has only a keyless
vehicle inspected by a Maruti Suzuki entry system. The remote controller has a
authorised workshop . keyless entry system and a keyless push
55T030450 start system. For details, refer to the fol-
2) Remove the cover (5) using a flat- CAUTION lowing explanations.
bladed screwdriver.
Check that there is no one near the
tailgate when pushing open the tail-
gate from inside the vehicle.

3-5
BEFORE DRIVING

Keyless Entry System Transmitter Central door locking system


WARNING • To lock all doors, push LOCK button (1)
once.
Radio waves from the keyless push • To unlock only the driver’s door, push
start system antenna(s) may interfere UNLOCK button (2) once.
with operation of electrical medical • To unlock other doors, push UNLOCK
equipment such as pacemakers. Fail- button (2) once again.
ure to take the precautions listed
below can increase the risk of severe NOTE:
injury or death due to radio wave You can switch the function that unlocks all
interference. doors from requiring two pushes to requir-
• Anyone who uses electrical medi- ing one push, and vice versa, via the infor-
cal equipment such as a pace- (1)
(2) mation display setting mode. For details on
maker should consult the medical how to use the information display, refer to
equipment supplier or their medical “Information display” in “INSTRUMENT
advisor about whether radio waves 79MH0237 CLUSTER” section.
from the antenna(s) can interfere
with the medical equipment. (1) LOCK button
(2) UNLOCK button The turn signal lights will flash once and
• If radio wave interference is a con- the siren will sound once (if equipped)
cern, have the function of the when the doors are locked.
antenna(s) disabled by a Maruti You can lock or unlock all doors (including
Suzuki authorised workshop . the tailgate) simultaneously by operating
the transmitter near the vehicle. When the doors are unlocked:
• The turn signal lights will flash twice and
the siren will sound twice (if equipped).
• If the interior light switch is in DOOR
position, the interior light will turn on for
about 15 seconds and then fade out. If
you insert the key into the ignition switch
during this time, the light will start to fade
out immediately.
Check that the doors are locked after you
operate LOCK button (1).

3-6
BEFORE DRIVING

NOTE: other transmitting devices such as radio The turn signal lights will blink for about
If no door is opened within about 30 sec- towers or CB (Citizen’s Band) radios. 27.5 seconds. Also, the siren will sound for
onds after UNLOCK button (2) is operated, • The door locks cannot be operated with about 27.5 seconds at the same time.
the doors will automatically lock again. the transmitter, if the ignition key is To cancel the car locator function, press
inserted in the ignition switch. any button (LOCK or UNLOCK).
NOTE:
• When any door is open, the door locks You can also turn the ignition switch to the
• If you lock the doors using the transmit-
can only be unlocked with the transmit- “ON” position to cancel the car locator
ter when the engine hood is open, the
ter, and the turn signal light will not flash. function.
siren will sound 3 times to remind you (if
• If you lose one of the transmitters, ask
equipped). NOTE:
your Maruti Suzuki authorised workshop
• If the security system was triggered due The car locator function will not activate
as soon as possible for a replacement.
to an unauthorised entry into the vehicle when the key is in the ignition switch or pre
Have your Maruti Suzuki authorised
and then you unlock the doors using the warning / full blast warning by shock sen-
workshop program the new transmitter
transmitter, the siren will sound 4 times sor or alarm is in activated condition.
code in your vehicle’s memory so that
to remind you. If this happens, check
the old code is erased.
whether your vehicle has been broken
into while you were away from it.
• Once you push both of the LOCK button NOTICE
(1) and UNLOCK button (2), then you The transmitter is a sensitive elec-
push one of the buttons within 5 sec- tronic instrument. To avoid damaging
onds, the siren will not sound (if the transmitter:
equipped). However, push one of the • Do not expose it to impacts, mois-
buttons 5 seconds later, the siren will ture or high temperature such as
sound. by leaving it on the dashboard
• You can set whether the siren sounds (if under direct sunlight.
equipped) when locking or unlocking the • Keep the transmitter away from
door(s) via the setting mode of the infor- magnetic objects such as a televi-
mation display. For details on how to use sion.
the information display, refer to “Informa-
tion Display” in “INSTRUMENT CLUS- Car locator function (if equipped)
TER” section. This function helps in locating the vehicle.
NOTE: Push both of the LOCK button (1) and
• The maximum operating distance of the UNLOCK button (2) for more than 3 sec-
keyless entry system transmitter is about onds.
5 m (16 ft.), but this can vary depending
on the surroundings, especially near
3-7
BEFORE DRIVING

Battery replacement
If the transmitter becomes unusable, WARNING
replace the battery. (2)
Swallowing a lithium battery may
To replace the battery of the transmitter: cause serious internal injury. Do not
allow anyone to swallow a lithium
battery. Keep lithium batteries away
from children and pets. If swallowed,
(1) contact a physician immediately.
(3)
(2) NOTICE
• The transmitter is a sensitive elec-
tronic instrument. To avoid damag-
55T030380 ing it, do not expose it to dust or
moisture or tamper with internal
(3) Lithium disc type battery:
parts.
CR1616 or equivalent
• When replacing the battery by
yourself, the transmitter controller
55T030370 3) Put the edge of a flat-bladed screw-
could be damaged affected by
driver in the slot of the transmitter (2)
1) Remove the screw (1), and open the static electricity. Discharge the
and pry it open.
transmitter cover. static electricity built up in your
4) Replace the battery (3) so its + terminal
2) Remove the transmitter (2). body by touching metal before
faces “+” mark of the transmitter.
replacing the battery.
5) Close the transmitter and install it into
the transmitter holder.
6) Close the transmitter cover, install and NOTE:
tighten the screw (1). Used batteries must be disposed of prop-
7) Check that the door locks can be oper- erly according to applicable rules or regu-
ated with the transmitter. lations and must not be disposed of with
8) Dispose of the used battery properly ordinary household trash.
according to applicable rules or regula-
tions. Do not dispose of lithium batter-
ies with ordinary household trash.

3-8
BEFORE DRIVING

Keyless Push Start System Remote


WARNING Controller
When you take the remote controller The remote controller enables the follow-
in an airplane, do not press the lock ing operations:
(1) button or the unlock button. When • You can lock or unlock the doors by
you put the remote controller in a operating LOCK/UNLOCK buttons on
bag, place it so that either of these the remote controller. Refer to the expla-
buttons is not pressed easily. If either nation in this section.
of these buttons is pressed, radio • You can lock or unlock the doors by
wave may interfere with operation of pushing the request switch. For details,
the airplane. refer to the explanation in this section.
*The remote controller is an elec- • You can start the engine without using
tronic device which has a restriction an ignition key. For details, refer to
80JM133
on its use in the airplane. “Engine switch (vehicle with keyless
push start system) (if equipped)” in
(1) Crossed-out wheeled bin symbol “OPERATING YOUR VEHICLE” section.
The crossed-out wheeled bin symbol (1)
indicates that a used battery should be col-
lected separately from ordinary household
trash.
(2)
By ensuring the used battery is disposed
of or recycled correctly, you will help pre-
(1)
vent potential negative consequences for
the environment and human health, which
could otherwise be caused by inappropri-
ate battery disposal. The recycling of
materials will help to conserve natural
resources. For more detailed information
about disposing of or recycling of the used
battery, consult a Maruti Suzuki authorised 52RM20060

workshop . (1) LOCK button


Be careful not to lose your key and to (2) UNLOCK button
leave it in the locked vehicle.

3-9
BEFORE DRIVING

There are two ways to lock or unlock all Check that the doors are locked after you • If the security system was triggered due
doors (including the tailgate) simultane- operate LOCK button (1). to an unauthorised entry into the vehicle
ously by operating the remote controller NOTE: and then you unlock the doors using the
near the vehicle. If no door is opened within about 30 sec- remote controller, the siren will sound 4
onds after UNLOCK button (2) is operated, times to remind you. If this happens,
Central door locking system the doors will automatically lock again. check whether your vehicle has been
• To lock all doors, push LOCK button (1) broken into while you were away from it.
once. Car locator function • Once you push both of LOCK button (1)
• To unlock only the driver’s door, push This function helps in locating the vehicle. and UNLOCK button (2), then you push
UNLOCK button (2) once. Push both of LOCK button (1) and one of the buttons within 5 seconds, the
• To unlock other doors, push UNLOCK UNLOCK button (2) for more than 3 sec- siren will not sound. However, push one
button (2) once again. onds. The turn signal lights will blink for of the buttons 5 seconds later, the siren
about 27.5 seconds. Also, the siren will will sound.
NOTE: sound for about 27.5 seconds at the same • You can set whether the siren sounds
You can switch the function that unlocks all time. when locking or unlocking the door(s) via
doors from requiring two pushes to requir- To cancel the car locator function, press the setting mode of the information dis-
ing one push, and vice versa, via the infor- any button (LOCK or UNLOCK). play.
mation display setting mode. For details on You can also cancel the car locator func- • For details on how to use the information
how to use the information display, refer to tion in any of the following operations. display, refer to “Information Display” in
“Information display” in “INSTRUMENT • Press the engine switch to change the “INSTRUMENT CLUSTER” section.
CLUSTER” section. ignition mode to “ON”.
• Bring the remote controller with you and NOTE:
The turn signal lights will flash once and press the request switch. • The maximum operating distance of the
the siren will sound once (if equipped) remote controller is about 5 m (16 ft.),
when the doors are locked. NOTE: but this can vary depending on the sur-
The car locator function will not activate roundings, especially near other trans-
When the doors are unlocked: when the ignition mode is “ACC” or “ON” or mitting devices such as radio towers or
• The turn signal lights will flash twice and pre warning / full blast warning by shock CB (Citizen’s Band) radios.
the siren will sound twice. sensor or alarm is in activated condition. • The door locks cannot be operated with
• If the interior light switch is in DOOR the remote controller if the ignition mode
position, the interior light will turn on for NOTE: is other than the “LOCK” (OFF).
about 15 seconds and then fade out. If • If you lock the doors using the remote • When any door is open, if you push
you press the engine switch during this controller when the engine hood are LOCK button on the remote controller,
time, the light will start to fade out imme- open, the siren will sound 3 times to the exterior buzzer will sound and doors
diately. remind you. cannot be locked.

3-10
BEFORE DRIVING

• If you lose one of the remote controllers, Keyless unlocking/locking using the • Push one of the request switches twice
ask a Maruti Suzuki authorised work- request switches to unlock all doors.
shop as soon as possible for replace-
ment. Have a Maruti Suzuki authorised NOTE:
workshop program the new remote con- You can switch the function that unlocks all
troller code in your vehicle’s memory so doors from requiring two pushes to requir-
that the old code is erased. ing one push, and vice versa, via the infor-
mation display setting mode. For details on
how to use the information display, refer to
“Information display” in “INSTRUMENT
(1) CLUSTER” section.
(2)
When the doors are unlocked:
• The turn signal lights will flash twice and
the exterior buzzer will sound twice.
• If the interior light switch is in DOOR
55T030470 position, the interior light will turn on for
When the remote controller is within the about 15 seconds and then fade out. If
operating range described in this section, you press the engine switch during this
you can lock or unlock all the doors time, the light will start to fade out imme-
(including tailgate) by pushing the request diately.
switch (1) on the driver’s door handle or
front passenger’s door handle or tailgate. Check that the doors are locked after you
operate the request switch to lock the
When all doors are unlocked: doors.
• To lock all doors, push one of the
request switches once. NOTE:
• The door locks cannot be operated by
The turn signal lights will flash once and the request switch under the following
the siren will sound once when the doors conditions:
are locked. – If any door is open or is not completely
closed.
To unlock a door or all doors: – If the ignition mode is in any other
• Push one of the request switches once mode than LOCK (OFF).
to unlock only one door. • If no doors are opened within about 30
seconds after unlocking the doors by
3-11
BEFORE DRIVING

pushing the request switch, the doors • If the remote controller is too close to the • When there are strong signals coming
will be locked again automatically. door glass, the request switches may not from a television, power station or a cel-
operate. lular phone.
• If a spare remote controller is in the vehi- • When the remote controller is in contact
cle, the request switches may not oper- with or covered by a metal object.
(1) ate normally. • When a radio wave type remote keyless
• The remote controller will only operate a entry is used nearby.
request switch if it is within the switch’s • When the remote controller is placed
(1) operating range. For example, if the near an electronic device such as per-
remote controller is within the operating sonal computer.
range of the driver’s door request switch
but not the front passenger’s door Some additional precautions you should
request switch or the tailgate request take and information you should be aware
(1) switch, the driver’s door switch can be of are:
operated but the front passenger’s door • Check that the key is stowed in the
switch or tailgate switch cannot be oper- remote controller. If the remote controller
68PH00210 ated. becomes unusable, you will not be able
to lock or unlock the doors.
(1) 80 cm (2.6 ft) • Check that the driver always carries the
NOTICE remote controller.
When the remote controller is within
approximately 80 cm (2.6 ft) from a front The remote controller is a sensitive • If you lose one of the remote controllers,
door handle or the tailgate switch, you can electronic instrument. To avoid dam- ask a Maruti Suzuki authorised work-
lock or unlock the doors by pushing the aging the remote controller: shop as soon as possible for a replace-
request switch. • Do not expose it to impacts, mois- ment. Have a Maruti Suzuki authorised
ture or high temperature such as workshop program the new remote con-
NOTE: by leaving it on the dashboard troller code in your vehicle’s memory so
• If the remote controller is outside the under direct sunlight. that the old code is erased.
request switch operating range • Keep the remote controller away • You can use up to four remote control-
described above, you will not be able to from magnetic objects such as a lers and the keys for your vehicle. Ask a
operate the request switch. television. Maruti Suzuki authorised workshop for
• If the battery of the remote controller details.
runs down or there are strong radio NOTE: • The battery life of the remote controller
waves or noise, the request switch oper- The keyless push start system may not is about two years, but it can vary
ating range may be reduced or the function correctly in certain environments depending on usage conditions.
remote controller may be inoperative. or under certain operating conditions such
as the following:

3-12
BEFORE DRIVING

– Any door (including the tailgate) is


open.
Press the request switch again after doing
)A( the following:
With the ignition mode changed to LOCK
(OFF) by pressing the engine switch, bring
out the remote controller if it is inside the
vehicle and check that all doors are com-
pletely closed.

Reminder function

55T030030 55T030040

To stow the key into the remote controller, To remove the key from the remote con-
push the key in the remote controller until troller, slide the lock knob (A) in arrow
you hear a click. direction and pull the key out from the
remote controller.

Request switch warning buzzer


The exterior buzzer beeps for about 2 sec-
onds in the following conditions to warn
you that the request switch is not working:
• The request switch is pressed after all
55T030360
doors are closed with the ignition mode
changed to ACC or ON position by If the remote controller is not in the vehicle
pressing the engine switch when the under the following conditions, the buzzer
remote controller is outside the vehicle. sounds intermittently for about 2 seconds
• The request switch is pressed in any of and the immobilizer/keyless push start sys-
the following conditions after changing tem warning light on the instrument cluster
the ignition mode to LOCK (OFF) by blinks:
pressing the engine switch. When one or more doors are opened and
– The remote controller is left inside the all of the doors are later closed with the
vehicle. ignition in any other mode than LOCK
(OFF).
3-13
BEFORE DRIVING

The indicator light will turn off within sev- Battery Replacement NOTE:
eral seconds after the remote controller is • Used batteries must be disposed of
returned to an area of the vehicle other WARNING properly according to applicable rules or
than the rear luggage area. regulations and must not be disposed of
Swallowing a lithium battery may with ordinary household trash.
If the remote controller is left in the vehicle cause serious internal injury or death • You may damage the remote controller
and you lock the driver’s door or front pas- in the worst case. Do not allow any- when replacing its battery. Asking Maruti
senger’s door as described below, the one to swallow a lithium battery. Suzuki authorised workshop is recom-
door will be automatically unlocked. Keep lithium batteries away from mended.
• If you open the driver’s door and lock the children and pets. If swallowed, con- • When you purchase the battery by your-
door by turning the lock knob forward or tact a physician immediately. self at a Maruti Suzuki authorised work-
pushing the power door locking switch,
shop or the other stores, check the year
the driver’s door will be automatically
unlocked. NOTICE of manufacture for the battery.
• If you open the front passenger’s door • The remote controller is a sensitive If the remote controller becomes unreli-
and lock the door by turning the lock electronic instrument. To avoid able, replace the battery as follows:
knob forward or pushing the power door damaging it, do not expose it to
locking switch, the front passenger’s dust or moisture or tamper with
door will be automatically unlocked. internal parts.
• When you replace the battery by
NOTE: yourself, touch a metallic part and
• The reminder will not operate when the remove static electricity to prevent
remote controller is on the instrument damaging the remote controller. (1)
panel, in the glove box, in a storage
compartment, in the sun visor or on the
floor, etc.
• Check that the driver always carries the
remote controller.
• Do not leave the remote controller in the (2)
vehicle when leaving the vehicle.
59RN03060

3-14
BEFORE DRIVING

1) Pry open the remote controller. 3) Place the battery (3) so its + terminal By ensuring the used battery is disposed
• To prevent the case from being dam- faces up as shown in the illustration. of or recycled correctly, you will help pre-
aged, cover the flat-bladed screw- 4) Close the remote controller firmly. vent potential negative consequences for
driver with a soft cloth. Insert the flat- 5) Make sure the door locks can be oper- the environment and human health, which
bladed screwdriver in the slot (1) to ated with the remote controller. could otherwise be caused by inappropri-
pry it open. 6) Dispose of the used battery properly ate battery disposal. The recycling of
according to applicable rules or regula- materials will help to conserve natural
NOTICE tions. Do not dispose of lithium batter- resources. For more detailed information
ies with ordinary household trash. about disposing of or recycling of the used
When you pry open the remote con- battery, consult Maruti Suzuki authorised
troller with a flat-bladed screwdriver, workshop.
you may damage the internal unit. Be
careful not to damage the internal
unit with the flat-bladed screwdriver.
2) Replace the battery. (1)
• Remove the old battery. To prevent
the case from being damaged, use
the flat-bladed screwdriver covered
with a soft cloth.

(3) CR20
32

80JM133

(1) Crossed-out wheeled bin symbol

The crossed-out wheeled bin symbol (1)


indicates that a used battery should be col-
lected separately from ordinary household
trash.
59RN03070

(3) Lithium disc type battery:


CR2032 or equivalent

3-15
BEFORE DRIVING

Security System (if equipped) NOTE: • Even if the security system is armed,
The security system is armed after you • The default setting of the shock sensor you should still be careful to guard
close and lock all doors (including engine is in the disabled state. Set to the against theft. Do not leave money or
hood and tailgate) by using the keyless enabled state and adjust sensitivity of valuable things in the vehicle.
entry system transmitter, keyless push each warning according to your prefer-
ence. For details on how to use the infor- How to Arm the Security System
start system remote controller or request Lock all doors (including engine hood and
switch. mation display, refer to “Information
Display” in “INSTRUMENT CLUSTER” tailgate) using the keyless entry system
Once the system is armed, any attempt to transmitter, keyless push start system
open a door by using any other means (*) section.
• Your authorised workshop may have remote controller or request switch.
than the keyless entry system transmitter, When the system is armed, the indicator
keyless push start system remote control- already set the shock sensor of the vehi-
cle to the enabled state before you pur- continues to blink at intervals of approxi-
ler, request switch or open the engine mately 2 seconds.
hood, will cause the alarm to be triggered. chase it.
* These means include the following: Consult your authorised workshop for
– The key further information.
– The lock knob on a door
– The central door locking switch NOTE:
– The tailgate unlatch switch • The security system generates alarms
Also, in case that you have set the shock when any of the predetermined condi- (1)
sensor to enabled state and set sensitivity tions is met. However, the system does
of the pre-warning function and full blast not have any function of blocking unau-
warning function to a level other than 0, the thorised entry into the vehicle.
warning will be triggered in case of any • Always use the keyless entry system
attempt to tamper with the vehicle. The transmitter, keyless push start system
shock sensor can be selected enabled or remote controller or request switch to
disabled state, and sensitivity of each unlock the doors when the security sys- 55T030170

warning can be adjusted as desired. To set tem has been armed.Using a key
instead will trigger the alarm. NOTE:
the shock sensor, ask your Maruti Suzuki • To prevent the alarm from being acci-
authorised workshop or use the setting • If a person who does not know the secu-
rity system is going to drive the vehicle, dentally triggered, avoid arming it while
mode of the information display. anyone remains inside the vehicle. The
we recommend you explain the system
and its operation to the person. Mistak- alarm will be triggered if any person
enly triggering the alarm may cause a inside opens the door, tailgate, engine
nuisance to others. hood, or the warning may be triggered if
anyone swings the vehicle (if the shock
sensor is in the enabled state).

3-16
BEFORE DRIVING

• The security system is not armed when How to Stop the Alarm Checking Whether the Alarm has
all doors are locked using the key from Should the alarm be triggered accidentally, Been Triggered During Parking
outside, using the door lock knobs or the the alarm will stop by the following opera- If the alarm was triggered and you then
central door locking switch from inside. tions. turn the ignition switch to “ON” position or
• If any door is not operated within approx- • Press the engine switch to change the the ignition mode is ON the security sys-
imately 30 seconds after the doors have ignition mode to ON or turn the ignition tem indicator will blink rapidly for about 8
been unlocked using the keyless entry switch to “ON” position in case of emer- seconds and a buzzer will beep 4 times
system transmitter, keyless push start gency. during this period. If this happens, check
system remote controller or request • Unlock the doors using the keyless entry whether the vehicle has been broken into
switch, the doors are automatically system transmitter, keyless push start while you were away from it.
locked again. When the doors are system remote controller or request
locked, the security system will be switch.
armed. Security System Indication
• If the security system indicator (1) blinks NOTE: • If any of the doors or tailgate are opened
when the ignition switch is in the “ON” • Even after the alarm has stopped, if you without unlocking by the keyless entry
position or the ignition mode is “ON”, lock the doors using the keyless entry system transmitter, keyless push start
there may be something wrong with the system transmitter, keyless push start system remote controller or request
security system. Ask your Maruti Suzuki system remote controller or request switch, all turn signal lights start to blink
authorised workshop to inspect the sys- switch, the security system will be and the interior buzzer beeps intermit-
tem. rearmed. tently. After 5 seconds, the siren will
• If you disconnect the battery while the sound for about 27.5 seconds. The
security system is in the armed condition security system indicator continues to
How to Disarm the Security System or the alarm is actually in operation, the blink during this time.
Simply unlock the doors using the keyless alarm will be re-triggered when the bat- • If the engine hood is opened, all turn sig-
entry system transmitter, keyless push tery is reconnected. nal lights blink, and the siren sounds for
start system remote controller or request • Even after the alarm has stopped at the about 27.5 seconds. The security sys-
switch. The security system indicator will end of the predetermined operation time, tem indicator continues to blink during
go out, indicating that the security system it will be triggered again if any of the this time.
is disarmed. doors, tailgate or engine hood is opened,
without disarming the security system. (If the shock sensor is in the enabled state)
• If the vehicle feels a shock higher than
the pre-warning sensitivity, the siren
sounds for about 2 seconds (pre-warn-
ing). If the vehicle feel a shock higher
than the full blast warning sensitivity, the
siren sounds for about 5 seconds (full
3-17
BEFORE DRIVING

blast warning). The security system indi- Windows Passenger’s door / rear door
cator continues to blink during this time.
Electric Window Controls
The electric windows can only be operated
NOTE:
when the ignition switch is in “ON” position
If you set the full blast warning sensitivity
or the ignition mode is ON.
higher than the pre-warning sensitivity in
the setting mode of the information display, Driver’s side
or the vehicle feels such shock as to be
able to trigger the full blast warning, the full
blast warning will be triggered preferen-
tially. In this case, the pre-warning will not
be triggered. (1) (5)

(3)
55T0300130
(2)
The passenger’s door has a switch (5) to
operate the passenger’s window.
(4)

55T0300120

The driver’s door has a switch (1) to oper-


ate the driver’s window, and a switch (2) to
operate the front passenger’s window or
there are switches (3), (4), to operate the
rear left and right passenger windows,
respectively.

3-18
BEFORE DRIVING

Lock switch
CLOSE
WARNING
• When opening or closing a window,
a part of body such as hands, legs
and neck may be caught by the
window and an accident may
occur. When you operate a window,
observe the following precautions:
OPEN – A driver and the other passen-
gers should be careful when
opening or closing a window.
– Do not allow a child to operate
the window switches.
81A009
– You should always lock the pas-
55T0300140 senger’s window operation when
To open a window, push the top part of the there are children in the vehicle.
The driver’s door also has a lock switch for
switch. To close the window, lift up the top Children can be seriously injured
the passenger’s window(s). When you
part of the switch. if they get part of their body
push in the lock switch, the passenger’s
The driver’s window has AUTO-DOWN window(s) cannot be raised or lowered by caught by the window during
and AUTO-UP features for greater conve- operating any of the switches (2), (3), (4) operation. Refer to “Window
nience (at toll booths or drive-through or (5). To restore normal operation, release Lock Switch” in this section for
restaurants, for example). These features the lock switch by pushing it again. details.
allow the driver to open or close the win- – When you leave your vehicle,
dow without holding the window switch in make sure to press the engine
DOWN or UP position. Press down or lift switch to change the ignition
up the driver’s window switch completely mode to OFF. Then, carry your
and release it. To stop the window before it key with you and take a child or
reaches the FULL-DOWN or FULL-UP children out of the vehicle.
position, pull up or push down the switch (Continued)
briefly.

3-19
BEFORE DRIVING

Pinching Prevention Function


WARNING The driver’s window is equipped with a CAUTION
pinching prevention function. This function
(Continued) • The pinching prevention function
detects a foreign object that is caught in
– When you open or close the front does not operate while you are
the window as it is being closed by AUTO-
passenger’s window or the rear holding the window switch in UP
UP feature, which allows you to close the
windows on the driver’s side, position.
window without holding the window switch
check that the other passengers • The pinching prevention function
in UP position, and stops the window from
and children do not take their may not detect an object caught in
closing to prevent damage.
hands and faces outside the the window just before the window
vehicle, before the window oper- is fully closed.
ation. Also, make sure to inform WARNING
them that you will perform the The function may not detect the NOTE:
window operation. object depending on shape, size, Even if you cannot close the window by the
• When you operate the electric win- hardness and position of the object AUTO-UP feature because there may be
dow controls from the outside of caught by the closing window. This something wrong with the pinching preven-
the window, your hands or neck may cause severe injury. tion function, you can close the window by
may be caught by the window and Be very careful when opening or holding the window switch in UP position.
an accident may occur. Do not closing the windows. If you drive in extreme off-road condition,
operate the electric window con- the pinching prevention function may oper-
trols from the outside of the win- ate accidentally because the window
dow. reacts to vehicle jolting.

Pinching prevention function initializa-


NOTE:
tion
If you drive with one of the rear windows
When you disconnect and reconnect the
open, you may hear a loud sound caused
lead-acid battery or replace the fuse, the
by air vibration. To reduce the sound, open
function will be deactivated. In this condi-
the driver’s or front passenger’s window, or
tion, the AUTO-DOWN feature will be
narrow the rear window opening.
deactivated, while the AUTO-UP feature
may remain activated. The pinching pre-
vention function needs to be initialized.

3-20
BEFORE DRIVING

To initialize the pinching prevention func- Lighting Control Lever


tion, use the following procedure:
1) Turn the ignition switch to “ON” position Automatic Light Operation
or press the engine switch to change (if equipped)
the ignition mode to ON.
2) Open the driver’s window fully by hold-
ing the window switch in DOWN posi-
tion.
(4)
(3)
3) Close the driver’s window by holding
the switch in UP position, and keep
holding the switch for 2 seconds after
the window is fully closed.
4) Check the driver’s window to see if the
AUTO-DOWN/UP feature works.
(2)
(1)
WARNING
As the pinching prevention function
will not operate until its initialization 55T030090
is completed, an accident may occur.
Make sure to perform the pinching
prevention function initialization.

If the AUTO-DOWN/UP feature will not


work after initialization, there might be
something wrong with the pinching preven-
tion function. Have your vehicle inspected
by Maruti Suzuki authorised workshop. (5)

55T030190

3-21
BEFORE DRIVING

Your vehicle’s lighting system is controlled by two main systems: the lighting switch and To turn the lights on or off, twist the knob
the auto-on headlight system (when the lighting switch is in “AUTO” position). on the end of the lever. There are four
The two systems work together to operate your lights as shown in the following chart: positions:

ON: Lights ON OFF (1)


LIGHT: When it is light around the light sensor (5). All lights are off.
DARK: When it is dark around the light sensor (5).
AUTO (2) (if equipped)
Ignition switch in the Ignition switch in the This function works when the ignition
Lighting “LOCK” or “ACC” position / “ON” position / switch is turned to “ON” position or the
switch Main lights to Ignition mode engine switch is pressed to change the
be operated LOCK (OFF) or ACC Ignition mode ON
position ignition mode to ON. The headlights and
LIGHT DARK LIGHT DARK position lights are turned on and off auto-
matically according to the amount of out-
Position lights, – – – – side light detected by a sensor. They go
(1) OFF Tail lights out automatically when you turn the igni-
Headlights – – – – tion switch to “ACC” or “LOCK” position or
change the ignition mode to ACC or LOCK
(2) AUTO Position lights, – – – ON (OFF) by pressing the engine switch.
(if Tail lights
The light sensor (5) for sensing the amount
equipped) Headlights – – – ON of outside light is installed on the passen-
Position lights, ger’s seat side of instrument panel.
ON ON ON ON
(3) Tail lights
Headlights – – – – CAUTION
Position lights, If the light sensor area of the wind-
ON ON ON ON
(4) Tail lights shield is covered with mud, ice, or
Headlights ON ON ON ON other similar substances, the head-
lights and position lights may be
turned on even when it is still light
outside.

3-22
BEFORE DRIVING

NOTE: Auto-on headlight system


• Avoid covering the light sensor area of
the windshield with a sticker. The sticker
may impair the performance of the sen-
sor and make the system unable to con-
trol operation of the lights correctly.
• If you turned the ignition switch to “ON”
position or changed the ignition mode to
ON by pressing the engine switch and
“AUTO” position remains selected, the (5)
headlights and position lights come on
automatically as it gets dark outside,
even with the engine not running. Leav-
ing the lights lit for a long time may lead
to a completely discharged battery. 55T030100
55T030190
With the headlights on, push the lever for-
(3) ward to switch to the high beams (main The auto-on headlight system automati-
Front position lights, tail lights, license beams) and pull the lever toward you to cally turns on all lights that are operated by
plate light and instrument lights are on, but switch to the low beams. When the high the lighting switch, when the following
headlights are off. beams (main beams) are on, a light on the three conditions are all met.
instrument cluster will come on. To
(4) Conditions for auto-on headlight system
momentarily activate the high beams (main
Front position lights, tail lights, license operation:
beams) as a passing signal, pull the lever
plate light, instrument lights and headlights 1) It is dark around the light sensor (5).
slightly toward you and release it when you
are on. 2) The lighting switch is in “AUTO” posi-
have completed the signal.
tion.
3) You turn the ignition switch to “ON”
position or press the engine switch to
change the ignition mode to ON.

This system is activated by a signal from


the light sensor (5) on the passenger side
of instrument panel. Do not cover the sen-
sor (5). Otherwise, the system will not work
correctly.

3-23
BEFORE DRIVING

Light Reminder Buzzer Guide Me Light (if equipped)


WARNING The interior buzzer continuously beeps if Guide me light has two functions of “To
you open the driver’s door without turning home” and “To car” for improving your visi-
It takes about 5 seconds for the light
off the headlights and position lights. This bility in the dark.
sensor to react to a change in light-
function is triggered under the following
ing conditions. To help avoid an acci-
condition: “To home” function
dent due to reduced visibility, turn on
The headlights and/or position lights are Even after you leave the car, the ground
your headlights before driving into a
on even after the ignition switch is turned will be illuminated for a short while with this
tunnel, parking structure, etc.
off, or the engine switch is pressed to function. You can turn on the front position
change the ignition mode to LOCK (OFF). lights and the headlights in the low beam
NOTE: setting for about 10 seconds after the igni-
The light sensor reacts even to infrared The buzzer stops sounding when you turn tion switch is turned to “LOCK” position or
rays, so it may operate incorrectly when off the headlights and position lights. the engine switch is pressed to change the
there are strong infrared rays. ignition mode to LOCK (OFF).
NOTE:
A message is indicated on the information To set the function:
display in the instrument cluster while the 1) Turn the lighting switch to “AUTO” posi-
buzzer is sounding. tion.
2) Turn the ignition switch to “LOCK” posi-
Daytime Running Light (D.R.L.) tion or press the engine switch to
System (if equipped) change the ignition mode to LOCK
When the engine is started, the daytime (OFF).
running lights are turned on by this system. 3) Pull the lighting control lever toward
Conditions for D.R.L. system operation you once and open the driver’s side
1) The engine is running. door within 60 seconds. Or pull the
2) Headlights and front fog light (if lighting control lever toward you once
equipped) are off. while the driver’s side door is open.

NOTE:
Brightness of the daytime running lights is
different from the brightness of the position
lights, but it is not a malfunction.

3-24
BEFORE DRIVING

To cancel the function: To cancel the function: Front Fog Light Switch
Perform any of the following operations. Perform any of the following operations. (if equipped)
• Pull the lighting control lever toward you • Lock the doors by using the keyless
once. push start system remote controller, the
• Turn the ignition switch to “ACC” or “ON” request switch or the key in the driver’s
position or change the ignition mode to door lock.
ACC or ON by pressing the engine • Change the ignition mode to ACC or ON
switch. by pressing the engine switch.
• Turn the lighting switch to any other • Turn the ignition switch to “ACC” or “ON”
position than “AUTO” position. position or change the ignition mode to
ACC or ON by pressing the engine
NOTE: switch.
• When the “To home” is functioning, the
front fog lights (if equipped), rear fog NOTE:
light (if equipped) and the headlights • When the “To car” is functioning, the
(high beam) are not turned on. front fog lights (if equipped), rear fog
• Lighting time of the “To home” function light (if equipped) and the headlights 55T030110
can be changed on the information dis- (high beam) are not turned on. To turn the front fog light on, twist the knob
play. Refer to “Information display” in • Lighting time of the “To car” function can as shown in the illustration with the posi-
“INSTRUMENT CLUSTER” section. be changed on the information display. tion lights, tail lights and/or the headlights
Refer to “Information display” in are on. When the front fog light is on, an
“To car” function “INSTRUMENT CLUSTER” section. indicator light on the instrument cluster will
Before you get in the vehicle, the ground come on.
will be illuminated for a short while to easily
lead the driver to the vehicle. If UNLOCK NOTE:
button of the keyless push start system In some countries the lighting operation
remote controller is pressed while the light- may be different from the above descrip-
ing switch is positioned in “AUTO”, the tion according to local regulations.
front position lights and the headlights in
the low beam are turned on for 10 sec-
onds.
This function will operate only when it is
dark outside the vehicle.

3-25
BEFORE DRIVING

Headlight Leveling Switch For Petrol Model For CNG Model

Halogen LED Halogen LED


headlight headlight headlight headlight
Vehicle Load Vehicle Load
Switch Position Switch Position
Condition Condition
Driver only 0 0 Driver only 0 0
Driver + 1 pas- Driver + 1 pas-
senger 0 0 senger 0 0
(in front seat) (in front seat)
75RM008 Driver + 4 pas- Driver + 4 pas-
Level the headlight beam according to the sengers, 2.0 1.5 sengers, 2 1.5
load condition of your vehicle by turning no cargo no cargo
this switch. The chart shows the appropri- Driver + 4 pas- Driver + 4 pas-
ate switch position for different vehicle load sengers, 3.0 2.5 sengers, NA NA
conditions. cargo added cargo added*
Driver + full Driver + full
4.5 3.5 NA NA
cargo cargo*
NA= Not Applicable

*: In case of CNG, luggage cannot be


placed in boot.

3-26
BEFORE DRIVING

Turn Signal Control Lever • When you move the lever to its original Lane change signal
position, the turn signal lights and the
You can use the turn signal control lever turn signal light indicators on the instru-
when the ignition switch is in “ON” position ment cluster will be turned off.
or the engine switch is in ON mode. • When changing lanes, if you lightly press
the turn signal control lever in the direc-
tions (a) or (b) in which you want to
Turn Signal Operation change lanes, the turn signal lights and
With the ignition switch in “ON” position or turn signal light indicators on the instru-
the ignition mode ON, move the lever ment cluster will flash only while the turn
upward or downward to activate the right signal control lever is pressed.
or left turn signals. • The turn signal control lever in the above
figure is a typical example; the actual
equipment depends on the vehicle type. 55T030510
Turning left (a) NOTE: Move the lever partially upward or down-
(1) If the angle which you turn the steering ward to turn right or left and hold the lever
wheel is small, the lever will not automati- in the moved position.
cally returned to its original position. In this • The turn signal and its indicator flash
case, return the lever to its original position while the lever is held at the moved posi-
by your hand. tion.
• The turn signal and its indicator flash 3
(b) times even if you returned the lever
Turning right immediately after the activation.
NOTE:
• The turn signal and its indicator can be
55T030340 set whether they flash 3 times after the
• Move the turn signal control lever (1) as turn signal lever is returned via the infor-
follows: mation display. Refer to “Information dis-
– Turning left: Move the lever upward. play” in “INSTRUMENT CLUSTER”
– Turning right: Move the lever down- section.
ward • You can customize the setting for the
• When you move the lever, the turn signal number of flashing times of the turn sig-
lights and the turn signal light indicators nal and its indicator (1 to 4 times).
on the instrument cluster will flash simul- Please ask Maruti Suzuki authorised
taneously. workshop for the customization.

3-27
BEFORE DRIVING

Hazard Warning Switch


NOTICE NOTICE
If you use the hazard warning switch • If you use the wipers with the glass
for many hours with the engine dried, the glass and the wiper blade
stopped, the lead-acid battery may rubbers may be damaged. When
run out. the glass is dry, use the washer
Do not use the hazard warning switch fluid and then use wipers.
for many hours with the engine • If you operate the wipers with the
stopped. wiper blades stuck on the glass,
the wiper blade rubbers may be
damaged or the wipers may be bro-
Windshield Wiper and Washer ken. When the wiper blades are
Lever stuck on the glass, do not operate
the wipers.
When the ignition switch in “ON” position • If you use the washer when the
55T030280 or the ignition mode ON, you can use the washer fluid cannot be sprayed
wiper/washer lever. enough, the washer pump may be
You can use the hazard warning switch to
warn the other drivers of possible risk of broken. When the washer fluid can-
CAUTION not be sprayed enough, turn off the
traffic hazard when you park your vehicle
in case of emergency. In cold weather, the sprayed washer washer switch.
fluid on the glass may get frozen and
• Push the hazard warning switch to acti- it may cause poor visibility to a
vate the hazard warning lights. The turn driver. Use the defroster to warm the
signal lights and the turn signal indica- glass and spray the washer fluid.
tors on the instrument cluster will flash Refer to “Heating And Air Condition-
simultaneously. ing” in the “OTHER CONTROLS AND
• Push the switch again to turn off the haz- EQUIPMENT” section.
ard warning switch.
• The instrument panel in the above figure
is a typical example; the actual equip-
ment depends on the vehicle type.

3-28
BEFORE DRIVING

When the operative wipers suddenly Windshield Wipers Windshield Washer


stop
When the wipers are under heavy load
such as covered by snow and the tem- (1)
MIST (1)
perature of the wiper motor becomes high,
the breaker will be activated and the wip-
ers will temporarily stop to protect the OFF
wiper motor from overheating.
If this happens, perform the following oper- INT
ations:
1) Stop the vehicle in a safe place, and LO
turn the ignition switch to “ACC” or
“LOCK” position or press the engine HI
switch to change the ignition mode to
ACC or LOCK (OFF).
55T030240 55T030250
2) Move the wiper lever and switch to
“OFF” position. You can operate the windshield wipers by If you pull the lever (1) toward you, the
3) Remove obstacles such as snow on the moving the lever (1) upward or downward. windshield washer fluid will be sprayed
wipers. and the windshield wipers will automati-
Temporaryࠉoperation only cally operate a few times.
4) After a while, when the temperature of MIST
while the lever is up
the wiper motor becomes low enough,
the breaker will be reset automatically OFF Off WARNING
and you can use the wipers. • To prevent windshield icing in cold
INT Intermittent operation
weather, turn on the defroster to
If you cannot use the wipers after a while, heat the windshield before and
there may be another problem. Ask Maruti LO Low speed operation
during windshield washer use.
Suzuki authorised workshop to have the HI High speed operation • Do not use radiator antifreeze in
wipers inspected. the windshield washer reservoir. It
can severely impair visibility when
sprayed on the windshield, and can
also damage your vehicle’s paint.

3-29
BEFORE DRIVING

Rear Window Wiper (If equipped) Rear Window Washer (If equipped)
NOTICE
To help prevent damage to the wind-
shield wiper and washer system ON (2) (2)
components, you should take the fol-
lowing precautions:
• Do not continue to hold in the lever
when there is no windshield
washer fluid being sprayed or the
washer motor can be damaged. OFF
• Do not attempt to remove dirt from
a dry windshield with the wipers or (2)
you can damage the windshield
and the wiper blades. Always wet 55T030270
the windshield with washer fluid 55T030260
before operating the wipers. • If you twist the lever (2) in the direction
• Clear ice or packed snow from the You can operate the rear window wiper by of © and align it to (washer) position
wiper blades before using the wip- twisting the lever (2) as shown in the illus- above “ON” position, the rear window
ers. tration. washer fluid will be sprayed and the rear
• Check the washer fluid level regu- wiper will operate simultaneously. If you
larly. Check it often when the ON Normal operation release your hand from the lever, it will
weather is bad. OFF Off return to “ON” position.
• If you twist the lever (2) in the direction
of ª and align it to (washer) position
below “OFF” position, the rear window
NOTICE washer fluid will be sprayed and the rear
Clear ice or snow from the rear win- wiper will operate simultaneously.ࠉIf
dow and rear wiper blade before you release your hand from the lever, it
using the rear wiper. Accumulated will return to “OFF” position.
ice or snow could prevent the wiper
blade from moving, causing damage
to the wiper motor.

3-30
BEFORE DRIVING

Horn Heated Rear Window Switch switch to change the ignition mode to
ACC or LOCK (OFF) with the defogger
on, the defogger will not automatically
operate even if you start the engine
again.

NOTICE
(1)
The heated rear window use a large
amount of electricity. If you do not
turn off the switch after the window
and mirrors have become clear, the
battery may run out. To protect the
lead-acid battery, turn off the switch
shortly after the window and mirrors
55T030300 have become clear.
52RM20420 Also, do not use the defogger to melt
While the engine is running or the engine snow or dry rain water.
Press the horn button of the steering wheel automatically stops by the ENG A-STOP
to sound the horn. The horn will sound with system, you can use the heated rear win-
the ignition switch in any position or any dow switch as the defogger for the rear NOTE:
ignition mode. window glass. • When you wipe the interior side of the
Refer to “ENG A-STOP System (Engine rear window glass, use a soft cloth
Auto Stop Start System) (if equipped)” in dampened with water and wipe the glass
the “OPERATING YOUR VEHICLE” sec- along the heat wires, not to damage the
tion. heat wires and the terminals.
• The defogger will work only when the
• If you push the rear defogger switch, the engine is running.
rear window glass will be heated and the
indicator light (1) will turn on. To turn off
the defogger, push the switch again.
• The defogger will automatically turn off
after the defogger remains on for 15
minutes to prevent discharging of the
lead-acid battery.
• If you turn the ignition switch to “ACC” or
“LOCK” position or press the engine
3-31
INSTRUMENT CLUSTER

INSTRUMENT CLUSTER
Instrument Cluster (Type A) ............................................... 4-1
Information Display (Type A) ............................................. 4-4
Instrument Cluster (Type B) ............................................... 4-13
Information Display (Type B) ............................................. 4-16
Warning and Indicator Lights ............................................ 4-42
4

59RN04640
INSTRUMENT CLUSTER

Instrument Cluster (Type A)


(1) Speedometer (4) Trip meter selector knob
(2) Tachometer (5) Indicator selector knob
(3) Information display (6) Warning and indicator lights

(4) (2) (6) (1) (5)

(6) (3) (6)


55T040070

4-1
INSTRUMENT CLUSTER

Speedometer Tachometer Fuel Gauge


The speedometer indicates vehicle speed. The tachometer indicates engine speed in
revolutions per minute.

NOTICE
Speed Alert System Never drive the vehicle with the
The speed alert system gives audible
warning for alert of over-speed to driver. engine revving in the red zone or
When vehicle speed exceeds about 80 km/ severe engine damage can result. (2)
Keep the engine speed below the red
h, primary level warning with two beeps will
sound every minute. When the vehicle zone even when downshifting to a
speed exceeds about 120 km/h, second- lower gear position. (1)
Refer to “Downshifting maximum
ary level warning with continuous beeps
allowable speeds” in “OPERATING
will sound.
If the vehicle speed is slowed down to YOUR VEHICLE” section.
about 118 km/h, primary warning will 52RM20470
resume. If the vehicle is slowed down to When the ignition switch is in “ON” position
about 78 km/h, speed alert warning will or the ignition mode is ON, this gauge
stop. This buzzer does not indicate any gives a rough indication of the amount of
malfunction in vehicle. fuel in the fuel tank. “F” stands for full and
“E” stands for empty.
If the fuel meter indicator shows only one
segment to “E”, refill the tank as soon as
possible.

NOTE:
If the last segment blinks, it means that the
fuel is almost empty.

If the low fuel warning light (1) comes on,


refill the fuel tank immediately.

4-2
INSTRUMENT CLUSTER

Brightness Control When the ignition switch is turned to “ON”


position or the engine switch is pressed to
NOTICE change the ignition mode to ON, the instru-
To minimize the possibility of dam- ment panel lights come on.
age to catalytic converter or other
components of the vehicle, avoid Your vehicle has a system to automatically
driving the vehicle near empty fuel dim the brightness of the instrument panel
tank level. lights when the position lights or headlights
are on.
NOTE: When the position lights and/or headlights
The activation point of the low fuel warning are on, you can adjust the meter illumina-
light (1) varies depending on road condi- tion brightness.
tions (for example, slope or curve) and To increase the brightness of the instru-
driving conditions because of fuel move- ment panel lights, turn the indicator selec-
ment in the tank. tor knob (1) clockwise.
52RS20090
Refer to “Low fuel warning light” in “Warn- To reduce the brightness of the instrument
ing and indicator lights” in this section for panel lights, turn the indicator selector
details. knob (1) counterclockwise.
The mark (2) indicates that the fuel filler WARNING
door is located on the left side of the vehi- (1)
cle. Do not adjust the brightness of the
instrument panel lights while driving.
Otherwise, you could lose control of
the vehicle.

55T040170

4-3
INSTRUMENT CLUSTER

NOTE: Information Display (Type A)


• If you do not turn the knob within several Information display is shown when the igni-
seconds of activating, the brightness tion switch is turned to “ON” position or the
control display will be canceled automat- (A) (B)
ignition mode is ON.
ically.
• When you reconnect the lead-acid bat- (C)
tery, the brightness of the instrument
panel lights will be reinitialized. Readjust (1) (2)
the brightness according to your prefer- (D)
ence. (E)
NOTE: (F)
If you adjust to the maximum brightness (3)
level when the position lights or headlights
are on, the following functions will be can- 55T040190
celled. (3) Information display
• The function which automatically dims
the brightness of instrument panel lights The information display shows the follow-
• The function which operates with the 55T040180 ing information.
brightness control, except maximum
brightness level (1) Trip meter selector knob Display (A)
(2) Indicator selector knob Clock
Display (B)
Thermometer
Display (C)
Parking sensors (if equipped) / Cruise con-
trol (if equipped)
Display (D)
Gear position (for Auto Gear shift vehicles)
(if equipped) / Gear shift indicator (if
equipped)

4-4
INSTRUMENT CLUSTER

Display (E) When the display (E) shows the driving


Trip meter / Odometer / Fuel consumption / WARNING range, you can change the unit of tem-
Driving range perature.
If you attempt to adjust the display
Display (F) while driving, you could lose control To change the unit of temperature, while
Fuel gauge of the vehicle. pushing and holding the trip meter selector
Do not attempt to adjust the display knob (1), turn the indicator selector knob
Clock while driving. (2).
The display (A) shows the time.
To change the time indication: Thermometer (if equipped)
1) Push the trip meter selector knob (1) The display (B) shows the thermometer.
The thermometer indicates the outside (Initial
and the indicator selector knob (2) setting)
together. temperature.
2) To change the hour indication, turn the
indicator selector knob (2) left or right (a)
repeatedly when the hour indication
blinks. To change the hour indication
quickly, turn and hold the indicator
selector knob (2). To set the hour indi-
cation, push the indicator selector knob 55T040200
(2) and the minute indication will blink.
3) To change the minute indication, turn If the outside temperature drops to freez-
the indicator selector knob (2) left or ing condition, the mark (a) will appear on 55T040210

right repeatedly when the minute indi- the display.


cation blinks. To change the minute
indication quickly, turn and hold the NOTE: Gearshift Indicator (if equipped)
indicator selector knob (2). To set the • The outside temperature indication is not The display (D) shows the gearshift indica-
minute indication, push the indicator the actual outside temperature when tor.
selector knob (2). driving at low speed, or when stopped.
• If there is something wrong with the ther- Refer to “Gearshift indicator” in the
mometer, or just after the ignition switch “OPERATING YOUR VEHICLE” section.
To select 12/24H format, refer to “Setting
mode” in this section. is turned to “ON” position or the engine
switch is pressed to change the ignition
mode to ON, the display may not indi-
cate the outside temperature.

4-5
INSTRUMENT CLUSTER

Gear Position (for Auto Gear Shift Manual mode indicator


vehicles) (if equipped) (for Auto Gear Shift models)
The display (D) shows some of the follow- When you are using the manual mode, the
ing indications. display shows the manual mode indicator (b)
(5).
NOTE:
For Auto Gear Shift models, the manual
mode indicator will only appear when the (c)
gearshift lever is in “M”.

Drive mode indicator


(4) (5) (6) (for Auto Gear Shift models)
When the gearshift lever is in “D”, the dis- (d)
55T040220 play shows the drive mode indicator (6).
(4) Gear position
(5) Manual mode indicator For details on how to use the transmission,
(6) Drive mode indicator refer to “Using transmission” in the “OPER- (e)
ATING YOUR VEHICLE” section.
Gear position
(for Auto Gear Shift models)
For Auto Gear Shift models, the display (f)
shows the current gear position. Trip Meter / Odometer / Fuel Con-
sumption / Driving Range
NOTE: The display (E) shows one of the following
For Auto Gear Shift models, when the indications; trip meter A, trip meter B,
gearshift lever position and the gear posi- odometer, instantaneous fuel consump- (g)
tion indication in the information display tion, average fuel consumption or driving
are unmatched, the indication will blink and range.
the interior buzzer will sound. Refer to 55T040230
“Auto Gear Shift” in the “OPERATING To switch the display indication (E), push
YOUR VEHICLE” section for details. the trip meter selector knob (1) or the indi-
cator selector knob (2) quickly.

4-6
INSTRUMENT CLUSTER

Trip meter Instantaneous fuel consumption


Push the trip meter selector The trip meter can be used to measure the The display shows the value of instanta-
knob (1). distance traveled on short trips or between neous fuel consumption only when the
fuel stops. vehicle is moving.
Push the indicator selector You can use the trip meter A or trip meter
knob (2). B independently. NOTE:
• The display does not show the value
(b) Trip meter A To reset the trip meter, push and hold the
unless the vehicle is moving.
(c) Trip meter B trip meter selector knob (1) until the display
• Depending on the vehicle’s specification,
(d) Odometer shows 0.0.
the fuel consumption units of initial set-
(e) Instantaneous fuel consumption ting are indicated as L/100km or km/L.
(f) Average fuel consumption NOTE:
• For “L/100km” setting, the indicated
(g) Driving range The indicated maximum value of the trip
maximum value of instantaneous fuel
meter is 9999.9. When you run past the
consumption is 30. No more than 30 will
WARNING maximum value, the indicated value will
be indicated on the display even if the
return to 0.0.
If you attempt to adjust the display actual instantaneous fuel consumption is
while driving, you could lose control higher.
Odometer
of the vehicle. • For “km/L” setting, the indicated maxi-
The odometer records the total distance
Do not attempt to adjust the display mum value of instantaneous fuel con-
the vehicle has been driven.
while driving. sumption is 50. No more than 50 will be
indicated on the display even if the
NOTICE actual instantaneous fuel consumption is
NOTE:
Keep track of your odometer reading higher.
• Indications will change when you push
and check the maintenance sched- • The indication on the display may be
and release a knob.
ule regularly for required services. delayed if fuel consumption is greatly
• The display shows estimated values.
Increased wear or damage to certain affected by driving conditions.
Indications may not be the same as
parts can result from failure to per- • The display shows estimated values.
actual values.
form required services at the proper Indications may not be the same as
mileage intervals. actual values.
• For “L/100km” or “km/L” setting, you can
change the units that instantaneous fuel
consumption is displayed in. Refer to
“Average fuel consumption” in this sec-
tion.

4-7
INSTRUMENT CLUSTER

Average fuel consumption (For “L/100km” or “km/L” setting) The driving range shown in the display is
If you selected average fuel consumption To change the unit of average fuel con- an indicative unit of the approximate dis-
the last time you drove the vehicle, the dis- sumption, while pushing and holding the tance you can drive until the fuel gauge
play shows the last value of average fuel trip meter selector knob (1), turn the indica- indicates “E”, based on current driving con-
consumption from previous driving when tor selector knob (2). ditions and current fuel level in the fuel
the ignition switch is turned to “ON” posi- tank.
tion or the engine switch is pressed to
change the ignition mode to ON. Unless When the low fuel warning light comes on,
you reset the value of average fuel con- the display “---” will appear.
(Initial
sumption, the display indicates the value of If the low fuel warning light comes on, fill
average fuel consumption which includes setting)
the fuel tank immediately regardless of the
average fuel consumption during previous value of driving range shown in the display.
driving.
When you refuel, the driving range is
To reset the average fuel consumption, updated. However, if you only add a small
push and hold the indicator selector knob amount of fuel, the correct value will not be
(2) for a while when the display shows the displayed.
average fuel consumption.
NOTE:
NOTE: 55T040240
• If you refuel when the ignition switch is in
When you reset the indication or reconnect “ON” position or the ignition mode is ON,
the negative (–) terminal to the lead-acid NOTE: the driving range may not indicate the
battery, the value of average fuel con- When you change the units that average correct value.
sumption will be shown after driving for a fuel consumption is displayed in, the • When you reconnect the negative (–)
while. instantaneous fuel consumption units will terminal to the lead-acid battery, the
be changed automatically. value of driving range will be shown after
driving for a while.
Driving range • If there are substantial changes in the
If you selected driving range the last time driving pattern or vehicle usage, the dis-
you drove the vehicle, the display indicates played range may vary significantly.
“---” for a few seconds and then indicates
the current driving range when the ignition
switch is turned to “ON” position or the
Fuel Gauge
The display (F) shows the fuel gauge.
engine switch is pressed to change the
ignition mode to ON. Refer to “Fuel gauge” in this section.

4-8
INSTRUMENT CLUSTER

Setting Mode
In the setting mode, you can set up and customize the following functions.
Indication Functions
Time indication of clock “ ”

Central door locking system “ ”

Automatic door locking function “ ”

Automatic door unlocking function “ ”

Door locking and unlocking siren “ ”

Additional flashes of the turn signal “ ”

4-9
INSTRUMENT CLUSTER

Indication Functions

Shock sensor “ ”

Pre-warning sensitivity of the shock sensor “ ”

Full blast warning sensitivity of the shock


sensor “ ”

Initialization setting “ ”

Exit the setting mode “ ”

4-10
INSTRUMENT CLUSTER

NOTE: Door locking and unlocking siren “ ”


Turn the indicator selector knob • As shown in the above illustration, “ ” • : Siren sounds when the doors
(2). indicates on the display of currently set- (including the tailgate) are
ting item. locked or unlocked by using
• To go back to the higher level display the keyless entry system
Push the indicator selector during operation, turn the indicator transmitter (default setting)
knob (2). selector knob (2) to display “ ” or • : Siren does not sound when
“ ” and then push the indicator the doors (including the tail-
selector knob (2). gate) are locked or unlocked
NOTE: by using the keyless entry
Depending on vehicle’s specifications, Time indication of clock “ ” system transmitter
some items may not be displayed. • : 12-hour format (default set-
ting) Additional flashes of the turn signal
How to use the setting mode: • : 24-hour format “ ”
1) When the ignition switch is in “ON” • : Turn signal flashes three
position or the ignition mode is ON, and Central door locking system “ ” times after the turn signal
the vehicle is stationary. • : Unlock all doors by turning lever is returned (default set-
2) Push and hold the indicator selector the key once ting)
knob (2) until the display shows • : Unlock all doors by turning • : Disable the additional flashes
“ ”. the key twice (default setting) of turn signal
3) Turn and/or push the indicator selector
knob (2) to select a function that you Automatic door locking function “ ” Shock sensor “ ”
want to set up according to the chart in • : Disable the automatic door • : Enable the shock sensor
the previous page. locking function • : Disable the shock sensor
4) Turn and/or push the indicator selector • : Lock all doors when the vehi- (default setting)
knob (2) to register settings of the fol- cle speed reaches 15 km/h
lowing functions. (default setting) Pre-warning sensitivity of
the shock sensor “ ”
Automatic door unlocking function “ ” • : Disable the pre-warning
• : Disable the automatic door • to :
unlocking function Adjust the pre-warning sensi-
• : Unlock all doors when the key tivity of shock sensor (Lowest
is pulled out from the ignition sensitivity level is L01 and
switch (default setting) highest is L15, and default
68PM00272 setting is L14)

4-11
INSTRUMENT CLUSTER

Full blast warning sensitivity of


the shock sensor “ ”
• : Disable the full blast warning
• to :
Adjust the full blast warning
sensitivity of shock sensor
(Lowest sensitivity level is L01
and highest is L15, and
default setting is L09)

Initialization setting “ ”
• : Initialize all settings

How to exit the setting mode:


Switch the display to show “ ” and then
push the indicator selector knob (2).

4-12
INSTRUMENT CLUSTER

Instrument Cluster (Type B)


1. Speedometer 5. Information display
2. Tachometer 6. Trip meter selector knob
3. Fuel gauge 7. Indicator selector knob
4. Temperature gauge 8. Warning and indicator lights

(6) (2) (8) (1) (7)

(8) (4) (8) (8) (5) (8) (3) (8)


55T040090

4-13
INSTRUMENT CLUSTER

Speedometer Tachometer Fuel Gauge


The speedometer indicates vehicle speed. The tachometer indicates engine speed in
revolutions per minute.

NOTICE
Speed Alert System
The speed alert system gives audible Never drive the vehicle with the
warning for alert of over-speed to driver. engine revving in the red zone or
When vehicle speed exceeds about 80 km/ severe engine damage can result.
h, primary level warning with two beeps will Keep the engine speed below the red
sound every minute. When the vehicle zone even when downshifting to a
speed exceeds about 120 km/h, second- lower gear position.
ary level warning with continuous beeps Refer to “Downshifting maximum
will sound. allowable speeds” in “OPERATING
If the vehicle speed is slowed down to YOUR VEHICLE” section. (1) (2)
about 118 km/h, primary warning will 55T040120
resume. If the vehicle is slowed down to
about 78 km/h, speed alert warning will When ignition switch is turned to “ON”
stop. This buzzer does not indicate any position or the engine switch is pressed to
malfunction in vehicle. change the ignition mode to ON, this
gauge gives a rough indication of the
amount of fuel in the fuel tank. “F” stands
for full and “E” stands for empty.
If the indicator approaches a low level
(near “E”) on fuel gauge, refill the tank as
soon as possible.

NOTE:
The indicator moves a little depending on
road conditions (for example, slope or
curve) and driving conditions because of
fuel movement in the tank.

If the low fuel warning light (1) comes on,


refill the fuel tank as soon as possible.

4-14
INSTRUMENT CLUSTER

Temperature Gauge Brightness Control


NOTICE
To minimize the possibility of dam-
age to catalytic converter or other
components of the vehicle, avoid
driving the vehicle near empty fuel
tank level.

Refer to “Low fuel warning light” in “Warn-


ing and indicator lights” in this section for
details.
The mark (2) indicates that the fuel filler
door is located on the left side of the vehi-
cle. 55T040130 56RM02010

When the ignition switch is turned to “ON”


position or the engine switch is pressed to
change the ignition mode to ON, this
gauge indicates the engine coolant tem-
perature. Under normal driving conditions,
the indicator should stay within the normal,
acceptable temperature range between
“H” and “C”. If the indicator approaches
“H”, overheating is indicated. Follow the
instructions for “Engine trouble: Overheat-
ing” in “EMERGENCY SERVICE” section. (1)

NOTICE
Continuing to drive the vehicle when 55T040140
engine overheating is indicated can
result in severe engine damage. When the ignition switch is turned to “ON”
position or the engine switch is pressed to
change the ignition mode to ON, the instru-
ment panel lights come on.

4-15
INSTRUMENT CLUSTER

Your vehicle has a system to automatically are on, the following functions will be can- Information Display (Type B)
dim the brightness of the instrument panel celled. The information display is shown when the
lights when the position lights or headlights • The function which automatically dims ignition mode is “ON”.
are on. the brightness of instrument panel lights
• The function which operates with the
When the position lights and/or headlights
brightness control, except maximum
are on, you can adjust the meter illumina- (A) (B)
brightness level
tion brightness.
To increase the brightness of the instru-
ment panel lights, turn the indicator selec-
tor knob (1) clockwise. (C)
To reduce the brightness of the instrument
panel lights, turn the indicator selector
knob (1) counterclockwise. (D) (E)
(F)
WARNING (1)
Do not adjust the brightness of the 55T040150
instrument panel lights while driving.
Otherwise, you could lose control of (1) Information display
the vehicle.

NOTE:
• If you do not turn the knob within several
seconds of activating, the brightness
control display will be cancelled auto-
matically.
• When you reconnect the lead-acid bat-
tery, the brightness of the instrument
panel lights will be reinitialized. Readjust
the brightness according to your prefer-
ence.

NOTE:
If you adjust to the maximum brightness
level when the position lights or headlights
4-16
INSTRUMENT CLUSTER

Display (C)
Warning and indicator messages /
(2)
Fuel consumption / Driving range /
(3) /Average Speed / Driving time /
Total idling stop time and Total idling fuel
saved (if equipped) / Clock and date /
Motion (if equipped) / Torque and power /
Accelerator and brake (if equipped) /
Cruise control (if equipped)
Display (D)
Selector position / Gearshift indicator (if
equipped)
Display (E)
55T040160
Seat belt reminder 55T040250

(2) Trip meter selector knob Display (F) When the ignition switch is turned to “ON”
(3) Indicator selector knob Odometer / Trip meter position or the engine switch is pressed to
change the ignition mode to ON, the mes-
The information display shows the follow- sage display shown in the above illustra-
ing information. tion will appear on the display for several
seconds.
Display (A)
Some warning and indicator messages
Clock
may appear on the display when the igni-
Display (B) tion switch to “ACC” or “LOCK” position or
Thermometer change the ignition mode to ACC or LOCK
(OFF)

Clock
The display (A) shows the time.
To set the clock, follow “Setting mode”
instructions in this section.

4-17
INSTRUMENT CLUSTER

Thermometer
The display (B) shows the thermometer.
The thermometer indicates the outside
temperature.

52RM21050

If the outside temperature nears freezing


condition, the message shown in the
above illustration will appear on the dis-
play.
To change the temperature unit between
“°C” and “°F”, follow “Setting mode”
instructions in this section.

NOTE:
The outside temperature indication is not
the actual outside temperature when driv-
ing at low speed, or when stopped.

4-18
INSTRUMENT CLUSTER

Fuel Consumption / Driving Range / Average Speed / Driving Time / Total (a) Instantaneous fuel consumption /
Idling Stop Time and Total Idling Fuel Saved (if equipped) / Clock and Date Average fuel consumption /
/ Motion (if equipped) / Torque and Power / Accelerator and Brake (if Driving range (If equipped)
equipped) (b) Instantaneous fuel consumption /
When there are no warning or indicator messages on the display (C), you can select one Average fuel consumption /
of the following indications to appear on the display: instantaneous fuel consumption, 5-minute average fuel consumption (If
average fuel consumption, driving range, average speed, driving time, total idling stop equipped)
time and total idling fuel saved (if equipped), clock and date, motion, torque and power, (c) Average speed /
accelerator and brake (if equipped) or no indication. 5-minute average speed /
Driving time (If equipped)
WARNING (d) Total idling stop time and total idling
fuel saved (if equipped)
If you attempt to adjust the display while driving, you could lose control of the (e) Clock and date
vehicle. Do not attempt to adjust the display while driving. (f) Motion (if equipped)
(g) Torque and power
(a) (b) (c) (d) (e) (h) Accelerator and brake (if equipped)
(i) Mode ratio and total CNG mode time
(If equipped) - Refer to the CNG sup-
plementary owner’s manual
(j) CNG gauge and total CNG mode time
(If equipped) - Refer to the CNG sup-
plementary owner’s manual
(k) No indication

To switch the display indication, push the


indicator selector knob (3) quickly.
(k) (j) (i) (h) (g) (f)
NOTE:
The value of instantaneous fuel consump-
tion, average fuel consumption, driving
range, average speed, total idling fuel
saved (if equipped), motion (if equipped),
torque and power, accelerator and brake
and energy flow (if equipped) shown on
55T040260
the display are affected by the following
conditions;
4-19
INSTRUMENT CLUSTER

• road condition • For “L/100km” setting, the indicated Average fuel consumption / 5-minute
• surrounding traffic condition maximum value of instantaneous fuel average fuel consumption / 1-driving
• driving condition consumption is 30. No more than 30 will cycle average fuel consumption
• vehicle condition be indicated on the display even if the Average fuel consumption from previous
• a malfunction which causes the malfunc- actual instantaneous fuel consumption is reset and 5-minute average fuel consump-
tion indicator light to come on or blink higher. tion, and 1-driving cycle average fuel con-
• For “km/L” setting, the indicated maxi- sumption are shown.
Instantaneous fuel consumption mum value of instantaneous fuel con-
The display shows instantaneous fuel con- sumption is 50. No more than 50 will be (Average fuel consumption)
sumption with a bar graph only when the indicated on the display even if the
vehicle is moving. actual instantaneous fuel consumption is (5)
higher.
• For “MPG(UK)” setting, the indicated
(4) maximum value of instantaneous fuel
consumption is 80. No more than 80 will
be indicated on the display even if the
actual instantaneous fuel consumption is
higher. (5)
• The indication on the display may be
delayed if fuel consumption is greatly
affected by driving conditions.
• The display shows estimated values.
Indications may not be the same as 52RM21080
actual values.
(5) Average fuel consumption
52RM21070
If you selected average fuel consumption
(4) Instantaneous fuel consumption the last time you drove the vehicle, the dis-
play shows the last value of average fuel
NOTE: consumption from previous driving when
• The display does not show the bar graph the ignition switch is turned to “ON” position
unless the vehicle is moving. or the engine switch is pressed to change
• Depending on the vehicle’s specification, the ignition mode to ON. Unless you reset
the fuel consumption units of initial set- the value of average fuel consumption, the
ting are indicated as L/100km, km/L or display indicates the value of average fuel
MPG. consumption based on the average fuel
consumption during previous driving.
4-20
INSTRUMENT CLUSTER

(5-minute average fuel consumption)


NOTE: You can check transition of average fuel
When you reconnect the negative (–) ter- consumption every 5 minutes from 15 min-
minal to the lead-acid battery, the value of utes before up to now. Also, you can check
average fuel consumption will be shown transition of average fuel consumption the
after driving for a period of time. past 3 driving cycles. Time indication and
driving cycle indication can be changed.
You can select the timing to reset the value
For details, refer to “Setting mode” in this
of average fuel consumption by one of the
section.
following three methods;
• Reset after refuel: the value of average
(6) Driving range
fuel consumption will be reset automati-
cally by refueling.
• Reset with trip meter A: the value of
average fuel consumption will be reset
automatically by resetting trip meter A. 68PM00282
• Reset manually: the value of average (6) 5-minute average fuel consumption
fuel consumption will be reset by push-
ing and holding the indicator selector (1-driving cycle average fuel consumption)
knob (3) when the display indicates the
average fuel consumption.
To change the timing to reset the value of
average fuel consumption, refer to “Setting (8)
mode” in this section.
52RM21090
NOTE:
If you add only a small amount of fuel (8) Driving range
when you select “Reset after refuel”, the
average fuel consumption value may not (7) If you selected driving range the last time
be reset. you drove the vehicle, the display indicates
“---” for a few seconds and then indicates
the current driving range when the ignition
56RM02018
switch is turned to “ON” position or the
engine switch is pressed to change the
(7) 1-driving cycle average fuel con- ignition mode to ON.
sumption

4-21
INSTRUMENT CLUSTER

The driving range shown in the display is (Average speed) NOTE:


an indicative unit of the approximate dis- When you reconnect the negative (–) ter-
tance you can drive until the fuel gauge minal to the lead-acid battery, the value of
indicates “E”, based on current driving con- average speed will be shown after driving
ditions and current fuel level in the fuel for a period of time.
tank. (9)
(5-minute average speed)
When the low fuel warning light comes on,
the display “---” will appear.
If the low fuel warning light comes on, fill
the fuel tank immediately regardless of the
value of driving range shown in the display.
When you refuel, the driving range is
updated. However, if you only add a small
amount of fuel, the correct value will not be 52RM21100
(10)
displayed.
(9) Average speed
NOTE:
• If you refuel when the ignition mode is If you selected average speed the last time
“ON”, the driving range may not indicate you drove the vehicle, the display indicates
the correct value. the last value of average speed from previ-
• When you reconnect the negative (–) ous driving when the ignition switch is 52RM21110
turned to “ON” position or the engine (10) 5-minute average speed
terminal to the lead-acid battery, the switch is pressed to change the ignition
value of driving range will be shown after mode to ON. Unless you reset the value of
driving for a period of time. You can check transition of 5-minute aver-
average speed, the display indicates the age speed every 5 minutes from 10 min-
• If there are substantial changes in the value of average speed which includes
driving pattern or vehicle usage, the dis- utes before up to now.
average speed during previous driving.
played range may vary significantly.
To reset the value of average speed, push
Average speed / 5-minute average and hold the indicator selector knob (3) for
speed about 2 seconds when the display indi-
cates an average speed. The display
Average speed from previous reset and 5- shows “---” and then indicates a new aver-
minute average speed are shown. age speed after driving for a short time.

4-22
INSTRUMENT CLUSTER

Driving time Total idling stop time and total idling • When you reconnect the negative (–)
fuel saved (if equipped) terminal to the lead-acid battery, the
value of the total idling stop time and the
total idling fuel saved will be reset.

Clock and date


Date and time are shown. For the setting
(12) procedure, refer to “Setting mode” in this
section.

Motion (if equipped)


(13)
(11)
(14) (15)

52RM21120
52RM217
(11) Driving time
(12) Total idling stop time
Driving time from previous reset is shown. (13) Total idling fuel saved
To reset the driving time, push and hold
the indicator selector knob (3) for about 2 The display shows the total length (in
seconds when the display indicates a driv- hours, minutes and seconds) of engine
ing time. The display shows “---” and then stopping time and the total amount (in milli-
indicates a new driving time after driving liters) of fuel conservation by ENG A-
for a short time. STOP system since the indication was
52RM218
reset.
NOTE: • To reset the total idling stop time and the his indicates how the center of gravity is
• Disconnection of the lead-acid battery total idling fuel saved, push and hold the moved while driving.
negative (-) terminal will reset the indica- indicator selector knob (3) for a while G (acceleration of gravity) position applied
tion of the driving time. when the display shows the total idling to the vehicle body while driving is shown
• The indicated maximum value of driving stop time and the total idling fuel saved. by a globe (14).
time is 99:59:59. No more than this When the vehicle is stopped, historical
value will be indicated on the display NOTE: data of G positions applied to the vehicle
until you reset the driving time. • The indicated maximum value of the body during the driving is shown as a
total idling stop time is 99:59:59 and this graph (15).
value is fixed until it is reset.
4-23
INSTRUMENT CLUSTER

G position history graph at the vehicle Information shown after driving Intersection Guidance (When using
stopped can be changed to indicate or When you turn the ignition switch to “LOCK” Android AutoTM*1 or Apple CarPlay*2 on
hide. For details, refer to “Setting mode” in position or press the engine switch to infotaiment system
this section. change the ignition mode to “LOCK” (OFF),
the following information appears for sev-
WARNING eral seconds on the information display.
Do not look in the display intensively
while driving. Doing so may result in
an unexpected accident.

NOTE:
• If G position history graph at the vehicle
stopped has been set in indication
mode, the graph (15) is shown for sev- 59RN04710
eral seconds when you turn the ignition
switch to “LOCK” position or change the (if equipped)
The display shows the direction of your
ignition mode to “LOCK” (OFF) after driving and the distance, working with the
infotainment system.
driving. (if equipped)
• The graph is shown approximately and NOTE:
the actual movement may differ. • A slight time lag may occur between the
intersection guidance on the information
Torque and power display and the guidance from the info-
Present engine torque and power are tainment system.
shown. • Switch the intersection guidance to ON
or OFF while the guidance from the info-
Accelerator and brake (if equipped) (if equipped) tainment system is displayed.
Present accelerator pedal depressing – A time lag may occur between ON dis-
degree and brake line pressure are shown. play and OFF display of the intersec-
The display is selectable to indicate or not tion guidance.
to indicate. For details, refer to “Setting – For the functions and operations of the
mode” in this section. infotainment system, refer to the sup-
plementary manual, provided along
53SB2036 with it.

4-24
INSTRUMENT CLUSTER

• You can display or hide the intersection Gear Position (for Auto Gear Shift Manual mode indicator
guidance by changing the setting (cus- Vehicles) / Gearshift Indicator (for (for auto gear shift vehicles)
tomization). For details, refer to “Setting Manual Transmission Vehicles) When you are using the manual mode, the
Mode” in this section. display shows the manual mode indicator
(17).
*1: Android AutoTM may not be available in (16)
your country or region. NOTE:
For details about Android AutoTM, refer to For Auto Gear Shift models, the manual
http://support.google.com/androidauto (17) (18) mode indicator will only appear when the
*2: Apple CarPlay may not be available in gearshift lever is in “M”.
your country or region.
For details about Apple CarPlay, refer to 55T040300 Drive mode indicator
https://www.apple.com/ios/carplay/ (16) Gear position (for auto gear shift vehicles)
(17) Manual mode indicator When the gearshift lever is in “D”, the dis-
(18) Drive mode indicator play shows the drive mode indicator (18).
Gear position For details on how to use the transmission,
(for auto gear shift vehicles) refer to “Using transmission” in the “OPER-
When the ignition switch is turned to “ON” ATING YOUR VEHICLE” section.
position or the engine switch is pressed to Gearshift Indicator (for manual trans-
change the ignition mode to ON, the dis- mission vehicles)
play shows the current gear position (16). Refer to “Gearshift indicator” in “OPERAT-
NOTE: ING YOUR VEHICLE” section.
For Auto Gear Shift models, when the
gearshift lever position and the gear posi-
tion indication in the information display
are unmatched, the indication will blink and
the interior buzzer will sound. Refer to
“Auto Gear Shift” in the “OPERATING
YOUR VEHICLE” section for details.

4-25
INSTRUMENT CLUSTER

Trip Meter Setting Mode NOTE:


The display (F) shows the trip meter. When the ignition switch is in “ON” position • If you push and hold the indicator selec-
or the ignition mode is ON and the vehicle tor knob (3) to enter into the setting
The trip meter can be used to measure the mode when the display (D) shows aver-
is stationary, you can enter into the setting
distance traveled on short trips or between age fuel consumption, average speed,
mode of the information display by pushing
fuel stops. driving time, total idling stop time and
and holding the indicator selector knob (3)
You can use trip meter A or trip meter B total idling fuel saved (if equipped), the
for few seconds.
independently. value will be reset simultaneously. If you
• To select the setting item that you want do not want to reset the value, push the
To reset the trip meter, push and hold the
to change, turn the indicator selector indicator selector knob quickly to switch
trip meter selector knob (2) for few sec-
knob (3) left or right. the indication of the display.
onds when the display shows the trip
• To change the setting, push the indicator • If you turn the ignition switch, press the
meter.
selector knob (3). engine switch or start to move the vehi-
• To exit the setting mode, select “Back” cle when the display is in the setting
Odometer and push the indicator selector knob (3).
The display (F) shows the odometer. mode, the setting mode will be cancelled
automatically.
The odometer records the total distance
the vehicle has been driven. Distance unit
(Odometer / trip meter / driving range /
NOTICE average speed distance unit setting)
Keep track of your odometer reading You can change the units in which odome-
and check the maintenance sched- ter / trip meter / driving range / average
ule regularly for required services. speed distance is displayed.
Increased wear or damage to certain
parts can result from failure to per- Fuel economy (If equipped)
form required services at the proper (Fuel consumption unit setting)
mileage intervals. You can change the units that fuel con-
sumption is displayed in.

53SB2023 Language
You can change the language of the infor-
NOTE: mation display.
The currently selected setting item is sur-
rounded by a frame.

4-26
INSTRUMENT CLUSTER

Fuel reset (If equipped) Clock setting (Adjusting the clock) (Adjusting the date)
(Average fuel consumption reset set- (If equipped) • Adjust the date by selecting “Clock set-
ting) • Adjust the clock by selecting “Clock set- ting” in “Setting mode”. Then select
You can change when the value of aver- ting” in “Setting mode”. Then, select “Adjust date”.
age fuel consumption is reset. “Adjust clock”. • To adjust year, month and day, operate
• To change the hour indication, turn the the indicator selector knob (3) in the
Temperature indicator selector knob (3) left or right same way as adjusting the clock.
(Temperature unit setting) repeatedly when the hour indication
You can change the units that temperature blinks. To change the hour indication Door lock (Door lock setting)
is displayed in. quickly, turn and hold the indicator selec- (Door unlock)
• To change the temperature unit, select tor knob (3). To set the hour indication, • All Doors:
“Temperature” in “Setting mode”. Then, push the indicator selector knob (3) and Unlock all doors by keyless push start
select “°C” or “°F”. the minute indication blinks. system remote controller or request
• To change the minute indication, turn the switch once
NOTE: indicator selector knob (3) left or right • Driver Door:
When you change the units that tempera- repeatedly when the minute indication Unlock all doors by keyless push start
ture is displayed in, the automatic heating blinks. To change the minute indication system remote controller or request
and air conditioning system (if equipped) quickly, turn and hold the indicator selec- switch twice (default setting)
temperature display units will be changed tor knob (3). To set the minute indica-
automatically. tion, push the indicator selector knob (3). (Auto lock)
• Manual Lock:
Set sensors (Selecting 12H / 24H format) Disable the automatic door locking func-
(Parking sensor setting) (if equipped) • Switch the time indication between 12- tion
The parking sensor can be switched hour and 24-hour format by selecting • Speed Syncro:
between the normal mode and trailer “Clock setting” in “Setting mode”. Then, Lock all doors when the vehicle speed
mode. select “12H” or “24H”. reaches 15 km/h (default setting)

4-27
INSTRUMENT CLUSTER

(Auto unlock) (Lane change setting) IS A/C


• Syncro Off: The turn signal and its indicator can be set (ENG A-STOP system setting)
Disable the automatic door unlocking whether they flash three times even if you (if equipped)
function (default setting for the vehicle return the turn signal control lever shortly • When using the automatic heating and
with the keyless push start system) after operating it. air conditioning system (if equipped),
• IG-OFF Sync: • To change the lane change setting, you can select one of the following
Unlock all doors when the engine switch select “Lane Change” in “Setting mode”. engine auto stop settings.
is pressed to change the ignition mode Then, select “ON” or “OFF” – Standard
to LOCK (OFF) (default setting for the • If you want to change the number of – Economy
vehicle without the keyless push start flashing, consult a Maruti Suzuki autho- – Comfort
system) rised workshop. • When “Economy” is selected, engine
auto stop condition is eased, compared
(Alarm) Antitheft with “Standard”. As engine auto stop
• You can turn off or on the siren sound (Shock sensor system setting) condition will occur more frequently, the
when the door(s) is(are) locked or You can change the on/off of the shock stop time will be longer, leading to reduc-
unlocked. sensor. tion of fuel consumption.
• When “Comfort” is selected, engine auto
Lights (Shock sensor P setting)
stop condition becomes severe, com-
(Footwell light setting) You can adjust the pre-warning sensitivity
pared with “Standard”. As engine auto
(if equipped) of shock sensor.
stop condition will occur less frequently,
The footwell lights can be programmed for (Shock sensor F setting) the stop time will be shorter, leading to
interlocked operation with either lighting You can adjust the full blast warning sensi- more comfortable cabin condition by air
control or door operation and for no light- tivity of shock sensor. conditioner.
ing.

4-28
INSTRUMENT CLUSTER

Display item (“Parking sensors” setting) (if equipped) Default


(“Car color” setting) Display of “Parking sensors” is selectable (Initialization setting)
You can change the car color of the infor- to indicate or not to indicate. If you select “YES” and push the indicator
mation display. selector knob (3), all settings will be reini-
(“Intersection” setting) (if equipped) tialized.
(“Calendar dis” setting) Display of “Intersection” is selectable to
You can select whether you show the cal- indicate or not to indicate.
ender on the information display or not.
Animation
(“warning” setting)
(“Calendar form” setting) Display of “Animation (warning)” is select-
You can change the calendar form of the able to indicate or not to indicate.
information display.
To change the calendar form, select “Cal- Head-up Display setting (if equipped)
endar form” in “Display item”. Then, select (Vehicle speed)
the display order of date, month and year. You can change ON/OFF of the vehicle
speed.
(“Fuel eco hist” setting) (If equipped)
Transitional indication of average fuel con- (Gear position)
sumption can be switched to time indica- You can change ON/OFF of the gear posi-
tion and driving cycle indication. tion.

(“Motion hist” setting) (if equipped) (Clock)


Indication of G position history graph at the You can change ON/OFF of the clock.
vehicle stopped can be selected to enable
or disable. (Intersection guidance
(working with the infotainment system))
(“Idling disp” setting) (if equipped) You can change ON/OFF of the intersec-
tion guidance.
Display of ENG A-STOP operation with
ignition mode LOCK (OFF) is selectable to (Air conditioning system)
indicate or not to indicate. You can change ON/OFF display of the air
conditioning system.
(“Idling warn” setting) (if equipped)
You can switch whether the information (High temperature warning message)
display shows the warning and indicator You can change ON/OFF of the high tem-
messages related on the ENG A-STOP perature warning message.
system.
4-29
INSTRUMENT CLUSTER

Warning and Indicator Messages problem that caused the message is not
The display shows warning and indicator corrected, the message will appear
messages to let you know about certain again after 5 seconds. When you push
vehicle problems. and hold the indicator selector knob (3)
In some cases, the external or internal for about 2 seconds while a message is
buzzer may also sound at the same time to displayed, the message will disappear
alert you. temporarily. If the problem that caused
the message is not corrected, the mes-
If warning and indicator messages appear sage will appear again after 5 seconds.
on the display, follow the messages.

Master warning indicator light

68PM00278

When the display shows warning and indi-


cator messages, the master warning indi-
cator light may also blink.
NOTE:
• When the problem that causes a mes-
sage to appear is corrected, the mes-
sage will disappear.
• If a message is displayed, and other
problems requiring a message occur, the
message for each of the problems will
be alternately displayed about every 5
seconds.
• When you push and hold the indicator
selector knob (3) for about 2 seconds
while a message is displayed, the mes-
sage will disappear temporarily. If the
4-30
INSTRUMENT CLUSTER

Warning and indicator messages


All models

Warning and indicator Master warning


Sound Cause and remedy
message indicator light
Blinks Beep (one time from interior A door, tailgate or engine hood is not prop-
(only while vehicle buzzer; only while vehicle is erly closed. Stop the vehicle in a safe place
is in motion) in motion) and close the door, tailgate or engine hood
properly.

55T040270

Blinks Continuous beep (from inte- The parking brake is not released. Stop the
rior buzzer) vehicle in a safe place and release the
parking brake.

52RS005

4-31
INSTRUMENT CLUSTER

Warning and indicator Master warning


Sound Cause and remedy
message indicator light
Blinks Continuous beep (from inte- The headlights and/or the position lights
rior buzzer) are left on. Turn them off.

52RM21170

Off Beep (one time from interior Fuel level is low. Refill it as soon as possi-
buzzer) ble. (#1)

52RM21180

(#1) This message will disappear for a while even if the problem that caused the message to appear is not corrected.

4-32
INSTRUMENT CLUSTER

Warning and indicator Master warning


Sound Cause and remedy
message indicator light
Off Beep (one time from interior CNG level is low. Refill CNG Tank as soon
buzzer) as possible. (#1)

55T050831C

Off Off The road may be icy. Drive very carefully.


(#1)

52RM21190

(#1) This message will disappear for a while even if the problem that caused the message to appear is not corrected.

4-33
INSTRUMENT CLUSTER

Warning and indicator Master warning


Sound Cause and remedy
message indicator light
Off Off This message is displayed when ACC posi-
tion is selected as the ignition mode. (#1)

52RM21210

Off Off The brake pedal (for auto gear shift model)
or the clutch pedal (for manual transmission
models) is depressed. Press the engine
switch to start the engine.

52RM21220

(#1) This message will disappear for a while even if the problem that caused the message to appear is not corrected.

4-34
INSTRUMENT CLUSTER

Warning and indicator Master warning


Sound Cause and remedy
message indicator light
Blinks Beep (one time from interior There is a problem with the steering lock
buzzer) system.
Have your vehicle inspected by aMaruti
Suzuki authorised workshop.

52RM21230

Blinks Beep (one time from interior There is a problem with the immobilizer/
buzzer) keyless push start system. Also, the vehicle
battery voltage may be decreased.
When the message is displayed even if you
start the engine with normal voltage of the
vehicle battery, have your vehicle inspected
by a Maruti Suzuki authorised workshop.

52RM21240

4-35
INSTRUMENT CLUSTER

Warning and indicator Master warning


Sound Cause and remedy
message indicator light
Blinks Series of beeps under cer- The remote controller may be outside the
tain conditions (for about 2 vehicle or its battery may be discharged.
seconds from exterior and/or Bring the remote controller in the vehicle or
interior buzzers) touch the engine push start switch with the
remote controller.
If the message still appears, replace the
remote controller battery.

55T040090

55T040100

4-36
INSTRUMENT CLUSTER

Warning and indicator Master warning


Sound Cause and remedy
message indicator light
Off Off This message is displayed when “ON” posi-
tion is selected as the ignition mode. (#1)

52RM21270

Blinks Beep (one time from interior The steering lock is not disengaged. While
buzzer) lightly turning the steering wheel in both
directions, press the engine switch again.

55T040020

(#1) This message will disappear for a while even if the problem that caused the message to appear is not corrected.

4-37
INSTRUMENT CLUSTER

Warning and indicator Master warning


Sound Cause and remedy
message indicator light
Off Off The remote controller battery is about to
become flat. Replace the battery. (#1)

55T040110

(#1) This message will disappear for a while even if the problem that caused the message to appear is not corrected.

4-38
INSTRUMENT CLUSTER

Manual transmission models

Warning and indicator Master warning


Sound Cause and remedy
message indicator light
Off Off The engine switch is pressed without
depressing the brake and clutch pedals.
Try again as instructed by the message.

52RM21300

4-39
INSTRUMENT CLUSTER

Auto gear shift models

Warning and indicator Master warning


Sound Cause and remedy
message indicator light
Off Off The engine switch is pressed with the gear-
shift lever in a position other than “N” and
depressing the brake pedal. Try again as
instructed by message.

56RM02030

4-40
INSTRUMENT CLUSTER

Vehicle with ESP® system

Warning and indicator Master warning


Sound Cause and remedy
message indicator light
Blinks Beep (one time from interior There may be a problem with ESP® system
buzzer) (if equipped).
Have your vehicle inspected by a Maruti
Suzuki authorised workshop.

52RM21340

Hill hold control system (if Blinks Beep (one time from interior There may be a problem with hill hold con-
equipped) buzzer) trol system (if equipped).
Have your vehicle inspected by a Maruti
Suzuki authorised workshop.

52RM21350

4-41
INSTRUMENT CLUSTER

Warning and Indicator Lights Brake System Warning Light The light also comes on together with the
NOTE: ABS warning light when the rear brake
If warning and indicator lights blink or force control function (proportioning valve
come on, the corresponding messages function) of the ABS system fails.
may be shown on the information display. If the brake system warning light comes on
while you are driving the vehicle, it may
mean that there is something wrong with
the vehicle’s brake system. If this happens,
82K1701 you should:
Three different types of operations exist 1) Pull off the road and stop carefully.
depending on the vehicle’s specification.
1) The light comes on briefly when the WARNING
ignition switch is turned to “ON” position Remember that stopping distance
or the engine switch is pressed to may be longer, you may have to push
change the ignition mode to ON. harder on the pedal, and the pedal
2) The light comes on when the parking may go down farther than normal.
brake is engaged with the ignition mode
ON.
3) The light comes on when under either 2) Test the brakes by carefully starting
or both of above two conditions. and stopping on the shoulder of the
road.
The light also comes on when the fluid in 3) If you determine that it is safe, drive the
the brake fluid reservoir falls below the vehicle cautiously at low speed to the
specified level. nearest Maruti Suzuki authorised work-
The light should go out after starting the shop for repairs or tow the vehicle to
engine and fully releasing the parking the nearest Maruti Suzuki authorised
brake, if the fluid level in the brake fluid workshop for repairs.
reservoir is adequate.

4-42
INSTRUMENT CLUSTER

Seat Belt Reminder Light Airbag Warning Light


WARNING
If any of the following conditions
occur, you should immediately ask a
Maruti Suzuki authorised workshop
to inspect the brake system.
• If the brake system warning light
does not go out after the engine
has been started and the parking 80J221 63J030

brake has been fully released. When the driver and/or passenger (front This light blinks or comes on for several
• If the brake system warning light passenger and/or rear passenger) seconds when the ignition switch is turned
does not come on when the engine do(does) not buckle his or her seat belt, to “ON” position or the engine switch is
switch is pressed to change the this light will come on and/or blink. pressed to change the ignition mode to ON
ignition mode to ON. For details about the seat belt reminder, so you can check if the light is working.
• If the brake system warning light refer to “Seat Belt Reminder” in “FOR
comes on at any time during vehi- The light will come on and stay on if there
SAFE DRIVING” section.
cle operation. is a problem in the airbag system or the
seat belt pretensioner system.
NOTE:
NOTE: Along with the seat belt reminder light, a
Because the brake system is self-adjust- reminder message shall also come on the WARNING
ing, the fluid level will drop as the brake information display (if equipped), for un- If the airbag warning light does not
pads become worn. Replenishing the restrained driver and/or front passenger. blink or come on briefly when the
brake fluid reservoir is considered normal engine switch is pressed to change
periodic maintenance. the ignition mode to ON, stays on for
more than 6 seconds, or comes on
NOTE:
while driving, the airbag system or
(Parking Brake Reminder Buzzer)
the seat belt pretensioner system
A buzzer sounds intermittently to remind
may not work properly, which could
you to release the parking brake if you
result in serious injury in the event of
start the vehicle without releasing the park-
a crash. Have both systems
ing brake. Make sure that the parking
inspected by a Maruti Suzuki autho-
brake is fully released and the brake sys-
rised workshop.
tem warning light turns off.

4-43

55TH0-74E
INSTRUMENT CLUSTER

Low Fuel Warning Light Anti-lock Brake System (ABS) If the light and the brake system warning
Warning Light light stay on, or come on simultaneously
when driving, your ABS system is
equipped with the rear brake force control
function (proportioning valve function) and
there may be something wrong with both
the rear brake force control function and
anti-lock function of the ABS system.
54G343 If one of these happens, have the system
When the ignition switch is in “ON” position 80J127 inspected by a Maruti Suzuki authorised
or the ignition mode is ON, this light comes When the ignition switch is turned to “ON” workshop.
on if the remaining fuel level is about 5.0L position or the engine switch is pressed to If the ABS becomes inoperative, the brake
or less. If this light comes on, fill the fuel change the ignition mode to ON, the light system will function as an ordinary brake
tank immediately. comes on briefly so you can check that the system that does not have this ABS sys-
light is working. tem.
When this light comes on, a ding sounds
once to remind you to fill the fuel. If the light stays on, or comes on when For details of ABS system, refer to “Anti-
If you do not fill the fuel, a ding sounds driving, there may be something wrong Lock Brake System (ABS)” in the “OPER-
every time when the engine switch is with the ABS. ATING YOUR VEHICLE” section.
pressed to change the ignition mode to If this happens:
ON. 1) Pull off the road and stop carefully.
2) Turn the ignition switch to “LOCK” posi-
NOTE: tion or change the ignition mode to
• The activation point of this light varies LOCK (OFF) by pressing the engine
depending on road conditions (for exam- switch and then start the engine again.
ple, slope or curve) and driving condi-
tions because of fuel moving in the tank. If the warning light comes on briefly then
• When this light comes on, low fuel warn- turns off, the system is normal. If the warn-
ing message is displayed on the infor- ing light still stays on, the system will be
mation display. something wrong.
For details, refer to “Warning and Indica-
tor Messages” in this section.

4-44
INSTRUMENT CLUSTER

High Engine Coolant Temperature Malfunction Indicator Light


Warning Light (red color) WARNING
(if equipped) If this light blinks, stop your vehicle
immediately in a safe place to avoid
catalyst's melting problem since
there may be a misfire in the engine.
• Do not drive or stop over such as
withered grasses.
80J222 Drive slowly if required to move the
Your vehicle has a computer-controlled vehicle.
54G344 emission control system. A malfunction
When the ignition switch is turned to “ON” indicator light is provided on the instrument
position or the engine switch is pressed to panel to indicate when it is necessary to NOTICE
change the ignition mode to ON, this light have the emission control system serviced. Continuing to drive the vehicle when
comes on briefly so you can check that the The malfunction indicator light comes on the malfunction indicator light is on
light is working. If this light blinks while when the ignition switch is turned to “ON” or blinking can cause permanent
driving, it means the engine is running hot. position or the engine switch is pressed to damage to the vehicle’s emission
If the light stays on after blinking, then the change the ignition mode to ON to let you control system, and can affect fuel
engine is overheating. To avoid actual know the light is working and goes out economy and driveability.
overheating, if this light blinks or stays on when the engine is started.
while driving, follow the instructions in the If the malfunction indicator light comes on
“If the Engine Overheats” of “EMER- or blinks when the engine is running, there
GENCY SERVICE” section. is a damage in the emission control sys-
tem.
NOTICE Bring the vehicle to a Maruti Suzuki autho-
Continuing to drive the vehicle when rised workshop to have the damage fixed.
engine overheating is indicated can
result in severe engine damage.

4-45
INSTRUMENT CLUSTER

Electric Power Steering Light When the power steering control system Engine Oil Pressure Warning Light
cool down, the power steering system
back to the original condition.
However, repeating these operations
could cause the power steering system
damaged.
• If the power steering system does not
work properly, you will feel heavier to
80J408 steer but you still will be able to steer. 80J223
• If the steering is operated, you may hear
This light comes on when the ignition a noise. This is normal and indicates that This light comes on when the ignition
switch is turned to “ON” position or the the power steering system works prop- switch is turned to “ON” position or the
engine switch is pressed to change the erly. engine switch is pressed to change the
ignition mode to ON, and goes out when ignition mode to ON, and goes out when
the engine is started. the engine is started. The light will come
on and remain on if there is insufficient oil
If this light comes on while driving, the
pressure. If the light comes on when driv-
power steering system may not work prop-
ing, pull off the road as soon as you can
erly. Have the system inspected by a
and stop the engine.
Maruti Suzuki authorised workshop.
Check the oil level and add oil if necessary.
If there is enough oil, the lubrication sys-
NOTE:
tem should be inspected by a Maruti
• Following operations of the steering
Suzuki authorised workshop before you
wheel while parking or driving at a very
drive the vehicle again.
low speed may have steering effort big-
ger gradually. This is not a malfunction of
the steering system, but the power steer- NOTICE
ing control system limits the power assist • If you operate the engine with this
in order to prevent them from overheat- light on, severe engine damage can
ing. result.
– The steering wheel is operated very • Do not rely on the engine oil pres-
often. sure warning light to indicate the
– The steering wheel is kept in a fully need to add oil. Be sure to periodi-
turned position for a long while. cally check the engine oil level.

4-46
INSTRUMENT CLUSTER

Charge Warning Light “SET” Indicator Light (if equipped) Transmission Warning Light
(Auto Gear Shift models)

65D474

When a cruising speed of the cruise con-


80J226 trol is set, this light will be on.
This light comes on when the ignition 80J219

switch is turned to “ON” position or the Depress Brake Pedal Indicator When the ignition switch is turned to “ON”
engine switch is pressed to change the Light (Auto Gear Shift models) position or the engine switch is pressed to
ignition mode to ON, and goes out when change the ignition mode to ON, this light
the engine is started. The light will come comes on for several seconds so you can
on and remain on if there is something check that the light is working.
wrong with the battery charging system. If
the light comes on when the engine is run- If this light comes on when the ignition
ning, the charging system should be switch is turned to “ON” position or the
inspected immediately by a Maruti Suzuki 76MH0A047 engine switch is pressed to change the
authorised workshop. ignition mode to ON, there is a problem
Refer to “Auto Gear Shift” in the “OPERAT- with the Auto Gear Shift system.
Cruise Control Indicator Light ING YOUR VEHICLE” section for details. If this light comes on or blinks, stop the
(if equipped) vehicle in a safe place and contact a
Maruti Suzuki authorised workshop. If the
light comes on or blinks again after the
light goes out, have the system inspected
by a Maruti Suzuki authorised workshop.

64MM02015

When the cruise control is on, this light will


be on.

4-47
INSTRUMENT CLUSTER

If the light comes on, it may become fol- Immobilizer / Keyless Push Start Open Door Warning Light
lowings: System Warning Light
• The transmission gear will not change
even if you shift the gearshift lever.
• The transmission gear will change to “N”
automatically when the vehicle speed
becomes less than 10 km/h, also the “N”
indicator in the instrument cluster will
blink and the interior buzzer will sound. 54G391
• The engine will stall automatically when 80JM122
the vehicle stops. This light remains on until all doors (includ-
• The engine will not start. When the ignition switch is turned to “ON” ing the tailgate) are completely closed.
position or the engine switch is pressed to If any door (including the tailgate) is open
If the above occurs, have the system change the ignition mode to ON, the light
inspected by a Maruti Suzuki authorised when the vehicle is moving, a ding sounds
comes on briefly so you can check that the to remind you to close all doors completely.
workshop. light is working.
NOTE: If this light blinks or stays on, there is a prob-
If the Auto Gear Shift clutch temperature lem with the system.
becomes too high, this light will blink. Stop
the vehicle in a safe place and let the sys- If this light still blinks or stays on even if
tem cool down. you start the engine with normal voltage of
the vehicle battery, ask a Maruti Suzuki
authorised workshop to have the system
inspected.

4-48
INSTRUMENT CLUSTER

Turn Signal Indicators Illumination Indicator Light ESP® OFF Indicator Light
(if equipped)

59RN04690 64J045

When you turn on the left or right turn sig- This indicator light comes on while the 57L30045

nals, the corresponding green arrow on the position lights, tail light and/or the head- When the ignition switch is turned to “ON”
instrument panel will blink along with the lights are on. position or the engine switch is pressed to
respective turn signal lights. When you change the ignition mode to ON, this light
turn on the hazard warning switch, both Front Fog Light Indicator Light comes on briefly so you can check that the
arrows will blink along with all of the turn (if equipped) light is working.
signal lights.
When the ESP® OFF switch is pushed to
NOTE: turn off the ESP® systems (other than
If any abnormality of the turn signals is ABS), the ESP® OFF indicator light comes
observed, such as fast blinking, there may on and stays on.
be a malfunction in the turn signal system.
Ask your Maruti Suzuki authorized work- For details of the ESP® systems, refer to
shop to inspect the system. “Electronic Stability Program (ESP®)” in
74P30830 the “OPERATING YOUR VEHICLE” sec-
Main Beam (High beam) Indicator tion.
Light The front fog light indicator light comes on
when the front fog light operates.

80J212

This indicator comes on when headlight


main beams (high beams) are turned on.
4-49
INSTRUMENT CLUSTER

ESP® Warning Light (if equipped) Low Engine Coolant Temperature ENG A-STOP Indicator Light (if
Light (blue color) (if equipped) equipped)

52KM133

ESP® is a registered trademark of Daimler 54G344 72M00032


AG.
When the ignition switch is turned to “ON” When the ignition switch is turned to “ON”
This light blinks 5 times per second when position or the engine switch is pressed to position or the engine switch is pressed to
one of the ESP® systems other than ABS change the ignition mode to ON, this light change the ignition mode to ON, this light
is activated. If this light blinks, drive care- comes on and stays on if the engine is comes on briefly to let you know the light is
fully. cold, and goes off after the engine warms working.
up.
When the ignition switch is turned to “ON” When the engine stops automatically, this
position or the engine switch is pressed to If this light still stays on after the engine light comes on.
change the ignition mode to ON, the light warms up, there is a problem with the sen-
For details, refer to “ENG A-STOP System
comes on briefly so you can check that the sor.
(Engine Auto Stop Start System) (if
light is working. If the light stays on, or Have your vehicle inspected by a Maruti
equipped)” in the “OPERATING YOUR
comes on when driving and remains on, Suzuki authorised workshop.
VEHICLE” section.
there may be something wrong with the
ESP® systems (other than ABS). You
should have the system inspected by a
Maruti Suzuki authorised workshop.
For details of the ESP® systems, refer to
“Electronic Stability Program (ESP®)” in the
“OPERATING YOUR VEHICLE” section.

WARNING
The ESP® systems cannot prevent
accidents. Always drive carefully.

4-50
INSTRUMENT CLUSTER

ENG A-STOP OFF Indicator Light


(if equipped)

62R0352

When the ignition switch is turned to “ON”


position or the engine switch is pressed to
change the ignition mode to ON, this light
comes on briefly if the system works prop-
erly.
When you push the ENG A-STOP OFF
switch, this light comes on.
If this light blinks when driving, there may
be something wrong with the ENG A-
STOP system. You should have the sys-
tem inspected by a Maruti Suzuki autho-
rised workshop.

4-51
OPERATING YOUR VEHICLE

OPERATING YOUR VEHICLE


Daily Inspection Checklist .................................................. 5-1
Ignition Switch (Vehicle without
Keyless Push Start System) (if equipped) ........................ 5-3
Engine Switch (Vehicle with
Keyless Push Start System) (if equipped) ........................ 5-5
Immobilizer System ............................................................ 5-7
Pedal ..................................................................................... 5-8
Keyless Push Start System (if equipped) ......................... 5-9 5
Starting / Stopping Engine (Vehicle without
Keyless Push Start System) (if equipped) ........................ 5-13
Starting / Stopping Engine (Vehicle with
Keyless Push Start System) (if equipped) ........................ 5-14
Parking Brake Lever ........................................................... 5-17
Precaution for Parking ........................................................ 5-18
Using Transmission ............................................................ 5-21
Gearshift Indicator (if equipped) ........................................ 5-32
59RN05760
ENG A-STOP System (Engine Auto Stop Start System)
(if equipped) ......................................................................... 5-34
Cruise Control (if equipped) ............................................... 5-44
SUZUKI SAFETY SUPPORT (if equipped) ......................... 5-46
Parking Sensors .................................................................. 5-81
Rearview Camera (if equipped) .......................................... 5-87
Electronic Stability Program (ESP®) (if equipped) ........... 5-89
Braking ................................................................................. 5-94
Anti-lock Brake System (ABS) ........................................... 5-95
OPERATING YOUR VEHICLE

Daily Inspection Checklist NOTE: Once a week, or each time you fill your fuel
It is normal for water to drip from the air tank, or before a long distance driving (like
Before Driving conditioning system while and after use. highway driving) perform the following
under-hood checks:
4) Check that the hood is fully closed and
latched. 1) Engine oil level
5) Check the headlights, turn signal lights, 2) Coolant level
brake lights and horn for proper opera- 3) Brake fluid level
tion. 4) Battery fluid (acid) level
6) Adjust the seat and head restraint. 5) Windshield washer fluid level
7) Check the brake pedal feeling and the 6) Hood latch operation
adjustment condition for the parking Pull the hood release lever inside the
brake lever or pedal. vehicle. Check that you cannot open
Refer to “Brake” in “INSPECTION AND the hood further without releasing the
MAINTENANCE” section for details. secondary latch. Close the hood
8) Adjust the mirrors. securely after checking for proper latch
9) Check that you and all the passengers operation. See the item “All latches,
59RN05750 have properly fastened the seat belts. hinges and locks” of “Chassis, body
10)Check that all the warning lights come and others” in “Maintenance Schedule”
1) Check that the windows, mirrors, lights in “INSPECTION AND MAINTE-
and reflectors are clean and unob- on as the ignition switch is turned to
“ON” position. NANCE” section for lubrication sched-
structed. ule.
2) Visually check the tyres for the follow- 11)Check all the gauges.
ing points: 12)Check that the brake system warning
light turns off when the parking brake is WARNING
– the depth of the tread groove
– abnormal wear, cracks and damage released. Check that the hood is fully closed
– loose wheel nuts and latched before driving. If it is not,
– existence of foreign material such as it can fly up unexpectedly during
nails, stones, etc. driving, obstructing your view and
resulting in an accident.
Refer to “Tyres” in “INSPECTION AND
MAINTENANCE” section for details. Once a month, or each time you fill your
fuel tank, check the tyre pressure using a
3) Look for fluid and oil leakage. tyre pressure gauge. Also check the tyre
pressure of the spare tyre.

5-1
OPERATING YOUR VEHICLE

When You Notice the Following Check the Tyre Pressure


Symptoms WARNING
• Driving with extremely low tyre
pressure can cause a tyre blowout
(bursting) and may result in an
accident. Do not drive with
(1) extremely low tyre pressure.

80J009

CAUTION
55T090020
If you keep using your vehicle in the
following conditions, malfunction • Periodically check and adjust the tyre
and an accident may occur. Consult a pressure. The specified tyre pressure for
Maruti Suzuki authorised workshop. the tyres of this vehicle can be confirmed
• Leaked oil or other liquid appears by checking the tyre information label (1)
69RHS173
on the ground below the vehicle. affixed to the opening of the driver’s
• Brake fluid level is low. door. • If the specified tyre pressure is not
• There are unusual odors, sounds • Driving with insufficient tyre pressure maintained, the full performance of
or vibrations. can cause the sides of the tyre to wear, the vehicle cannot be achieved and
• The feeling of operating the steer- in addition to decreasing fuel efficiency. the following could occur, leading
ing wheel or the brakes is different to accidents or malfunctions.
than usual. Adjust the tyre pressure as speci-
fied.
– Decreased driving stability
– Longer distance required for brak-
ing
(Continued)

5-2
OPERATING YOUR VEHICLE

Check the Exhaust Pipe Ignition Switch (Vehicle


WARNING
without Keyless Push Start
(Continued)
– Accurate tyre rotation speed can- System) (if equipped)
not be detected, which interferes
with the following functions:
• ABS
• Electronic stability program
(ESP®) (if equipped)

To adjust the tire pressure, refer to “Tyres”


in “INSPECTION AND MAINTENANCE” 80J011
section.
Periodically check the exhaust pipes for
holes or cracks.

WARNING
If leaks in exhaust pipes are present, 68PH00310
exhaust gas could enter the vehicle
and possibly cause carbon monoxide The ignition switch has the following four
poisoning. If you feel that something positions:
is abnormal, consult a Maruti Suzuki
authorised workshop. LOCK
This is the normal parking position. It is the
only position in which the key can be
removed.

5-3
OPERATING YOUR VEHICLE

Manual transmission ACC


Accessories such as the radio can oper-
Turn to “LOCK” ate, but the engine is off.

ON
This is the normal operating position. All
C
K AC electrical systems are on.
Push
START
LOC

This is the position for starting the engine


using the starter motor. The key should be
released from this position as soon as the
engine starts.

Ignition key reminder 55T050020


55T050010 A buzzer sounds intermittently to remind
• Manual transmission vehicles: you to remove the ignition key if it is in the WARNING
You must push in the key to turn it to ignition switch when the driver’s door is
“LOCK” position. It locks the ignition, and opened. • Never return the ignition switch to
prevents normal use of the steering “LOCK” position and remove the
wheel after the key is removed. ignition key while the vehicle is
moving. The steering wheel will
• Auto Gear Shift vehicles: lock and you will not be able to
The gearshift lever must be in “N” (Neu- steer the vehicle.
tral) to turn the key to “LOCK” Position. It (Continued)
locks the ignition and prevents normal
use of the steering wheel and gearshift
lever.

To release the steering lock, insert the key


and turn it clockwise to one of the other
positions. If you have trouble turning the
key to unlock the steering wheel, try turn-
ing the steering wheel slightly to the right
or left while turning the key.

5-4
OPERATING YOUR VEHICLE

Engine Switch (Vehicle with ACC


WARNING Press the engine switch to select this igni-
Keyless Push Start System) tion mode to use such electric equipment
(Continued)
• Always return the ignition switch to (if equipped) as the audio system, outside rearview mir-
rors and accessory socket with the engine
“LOCK” position and remove the off. When this position is selected, the
ignition key when leaving the vehi- information display in the instrument clus-
cle even only for a short time. Also ter shows the following message.
do not leave children alone in a
parked vehicle. Unattended chil-
dren could cause accidental move-
ment of the vehicle or could tamper
with power windows. They also
could suffer from heat stroke in
warm or hot weather. These could
result in severe injury or even
death.

NOTICE 59R40300

Do not leave the ignition switch in ON


“ON” position if the engine is not run- • With the engine off
ning as the lead-acid battery will dis-
55T050130 You can use such electric equipment as
charge. LOCK (OFF) the power windows and wipers with the
This mode is for parking the vehicle. When engine off. When this ignition mode is
this mode is selected by pressing the selected by pressing the engine switch,
engine switch and then any door (including the information display in the instrument
the tailgate) is opened or closed, the steer- cluster shows the following message.
ing will be locked automatically.

5-5
OPERATING YOUR VEHICLE

Unreleased Steering Lock Warning


NOTICE If the steering lock remains engaged when
Do not leave the engine switch in you press the engine switch to change the
ACC or ON mode when the engine is ignition mode to ON, the information dis-
not running. Avoid using the radio or play in the instrument cluster shows the
other electric accessories for a long following message and you cannot start
time when the engine switch is in the engine. If this happens, press the
ACC or ON mode when the engine is engine switch, turning the steering wheel
not running, otherwise the lead-acid to right or left.
battery may discharge.
52RM21270

• With the engine on NOTE:


All electric equipment is operational. The • The steering will be unlocked when you
vehicle can be driven when you have press the engine switch to change the
selected this ignition mode by pressing ignition mode from LOCK (OFF) to ACC
the engine switch. or ON.
• You do not need to keep the engine
START switch pressed until the engine starts.
Manual transmission vehicles: • In the presence of strong radio wave or
Provided you have the keyless push start noise, you may not be able to change
system remote controller with you, the the ignition mode to ACC or ON or to 55T050160

engine automatically starts when you start the engine using the engine switch.
press the engine switch to select this igni- In this case, the information display in
tion mode after shifting to “N” (Neutral) and the instrument cluster will show the fol-
depressing the brake and clutch pedals. lowing message.

Auto Gear Shift vehicles:


Provided you have the keyless push start
system remote controller with you, the
engine automatically starts when you
press the engine switch to select this igni-
tion mode after placing the gearshift lever
in “N” (Neutral) position and depressing
the brake pedal.
55T050180
55T040090

5-6
OPERATING YOUR VEHICLE

NOTE: Immobilizer System


The steering lock may not be released and This system is designed to help prevent NOTICE
the immobilizer/keyless push start system vehicle theft by electronically disabling the
warning light turns on if some load is If the immobilizer system is modified
engine starting system. or removed, it cannot be properly
applied on the steering wheel. If this hap- The engine can be started only with your
pens, turn the steering wheel system to the operated. Do not modify or remove
vehicle’s original immobilizer ignition key the immobilizer system.
right or left to relieve it from the load before or keyless push start system remote con-
you press the engine switch again to troller, which has an electronic identifica-
change to the desired ignition mode. NOTE:
tion code programmed in it. The key or This immobilizer system is maintenance-
remote controller communicates the identi- free.
fication code to the vehicle when the igni-
tion switch is turned to “ON” position or the
engine switch is pressed to change the Immobilizer/Keyless Push Start
ignition mode to ON. If you need to make System Warning Light
spare keys or remote controllers, see a
Maruti Suzuki authorised workshop. The
vehicle must be programmed with the cor-
rect identification code for the spare. A key
made by an ordinary locksmith will not
work.

In the case you can start the engine, when


80JM122
you turn the ignition switch to “LOCK” posi-
tion or press the engine switch to change If the immobilizer/keyless push start sys-
the ignition mode to ON, the immobilizer tem warning light blinks when the ignition
system will be released and the immobi- switch is in “ON” position or the ignition
lizer/keyless push start system warning mode is ON, the engine will not start.
light will turn on for about 2 seconds and
then it will turn off. NOTE:
If the immobilizer/keyless push start sys-
When you turn the ignition switch to tem warning light blinks or comes on, a
“LOCK” position or press the engine switch
to change the ignition mode to LOCK message may be shown on the information
(OFF), the immobilizer system will operate. display.

5-7
OPERATING YOUR VEHICLE

For vehicles without a keyless push NOTE: Pedal


start system • If you lose your immobilizer ignition key Manual transmission
If this light blinks, turn the ignition switch to or remote controller, ask a Maruti Suzuki
“LOCK” position, and then turn it back to authorised workshop as soon as possi-
“ON” position. ble to deactivate the lost one, and to
If the light still blinks after the ignition make a new key or remote controller.
switch is turned back to “ON” position, • If you own other vehicles with immobi- (1) (2)
there may be something wrong with your lizer keys, keep those keys away from
key or with the immobilizer system. Ask a the ignition switch or the engine switch
Maruti Suzuki authorised workshop to when using your Maruti Suzuki vehicle.
have the system inspected. Otherwise, the engine may not be
started because they may interfere with
your Maruti Suzuki vehicle’s immobilizer
For vehicles with a keyless push start system. (3)
system • If you attach any metal objects to the
If this light blinks, change the ignition mode immobilizer key or remote controller, it
to LOCK (OFF), and then change it back to may not start the engine.
ON. Also refer to “If the master warning 80J2121
indicator light blinks and the engine cannot NOTICE Auto Gear Shift
be started” in “Starting / stopping engine
(vehicle with keyless push start system) (if The immobilizer key and remote con-
equipped)” in “OPERATING YOUR VEHI- troller are sensitive electronic instru-
CLE” section. ments. To avoid damaging them:
If the light still blinks after the ignition mode • Do not expose them to impacts,
is changed back to ON, there may be moisture or high temperature such (2)
something wrong with your key or with the as on the dashboard under direct
immobilizer system. Ask a Maruti Suzuki sunlight.
authorised workshop to have the system • Keep them away from magnetic
inspected. objects.
The immobilizer/keyless push start system (3)
warning light may also blink if the remote Ignition Key Reminder (if equipped)
controller is not in the vehicle when you
close the door or attempt to start the A buzzer sounds intermittently to remind
engine. you to remove the ignition key if it is in the 80J2122
ignition keyhole when the driver’s door is
opened.

5-8
OPERATING YOUR VEHICLE

Clutch Pedal (1) Keyless Push Start System


A clutch pedal is used to disengage the WARNING
driving force to the wheels when starting (if equipped)
If brake squeal is excessive and
the engine, stopping, or shifting the gear- Provided the keyless push start system
occurs each time the brakes are
shift lever. Depressing the pedal disen- remote controller is within the interior work-
applied, you should have the brakes
gages the clutch. able area, you can use the engine switch
checked by a Maruti Suzuki autho-
rised workshop. for starting the engine and selecting an
WARNING ignition mode (ACC or ON). In addition, the
Do not drive with your foot resting on following functions can be used:
WARNING • Keyless entry function. Refer to “Keyless
the clutch pedal. It could result in Push Start System Remote Controller” in
excessive clutch wear, clutch dam- Do not apply brakes continuously or “BEFORE DRIVING” section for details.
age, or unexpected loss of engine rest your foot on the brake pedal. • Locking and unlocking doors (including
braking. This will result in overheating of the the tailgate) using a request switch.
brakes which could cause unpredict- Refer to “Keyless Push Start System
Brake Pedal (2) able braking action, longer stopping Remote Controller” in “BEFORE DRIV-
Your vehicle is equipped with either front distances, or permanent brake dam- ING” section for details.
and rear disc brakes or front disc brakes age. • Immobilizer (anti-theft) function. Refer to
and rear drum brakes. Depressing a brake “Immobilizer System” in this section for
pedal applies both sets of brakes. Accelerator Pedal (3) details.
You may hear occasional brake squeal An accelerator pedal controls the speed of
when you apply the brakes. This is a nor- the engine. Depressing the accelerator
mal condition caused by environmental pedal increases power output and speed.
factors such as temperature, humidity,
snow or dust, etc. NOTE:
Your vehicle is equipped with Brake Over-
Auto Gear Shift - You may hear occasional ride System. If you depress both the accel-
sound when you release brake pedal while erator pedal and the brake pedal
vehicle is in “D” (Drive) mode and about to simultaneously, the engine power output
move. This is a normal phenomenon. may be suppressed.

5-9
OPERATING YOUR VEHICLE

–The remote controller is in the sun visor Engine Switch Illumination


pocket or on the floor. The engine switch is illuminated (lit) in the
following situations:
• Even when the remote controller is out-
• When the engine is off and the driver’s
side the interior workable area, if it is in
door is open, or for 15 seconds after the
any of the following conditions, you may
driver’s door is closed. The illumination
be able to start the engine or select the
will fade out after 15 seconds passed.
ignition mode. The remote controller out-
• While the headlights and/or the position
side warning may not be given at that
lights are on, the illumination will turn on.
time.
The illumination will go out when the
–The remote controller is outside the
headlights and the position lights are
vehicle but very close to a door.
turned off.
–The remote controller is on the instru-
(1) ment panel.
81M40230

(1) Interior workable area


The interior workable area is defined as all
the interior spaces except for the space on
the instrument panel or in the luggage
compartment.

NOTE:
• Even when the remote controller is in the
82K253
interior workable area, if it is in any of the
following conditions, you may not be NOTE:
able to start the engine or select the igni- To save the lead-acid battery, the illumina-
tion modes, and the remote controller tion will be automatically turned off when
outside warning may be given. both of the following conditions are simul-
–The remote controller’s battery is low. taneously met:
–The remote controller is affected by • The headlights and the position lights
strong radio wave or noise. are turned off.
–The remote controller is in contact with • 15 minutes has elapsed since opening
or covered by a metallic object. the driver’s door.
–The remote controller is in the secluded
stowages such as the glove box or a
door pocket.

5-10
OPERATING YOUR VEHICLE

Selection of Ignition Modes Every time you press the engine switch, If the master warning indicator light
Press the engine switch to select ACC or the ignition mode changes as follows. blinks and the ignition modes cannot
ON mode as follows when you use an be selected
electric accessory or check the operation Auto Gear Shift
Your keyless push start system remote con-
of instrument cluster without running the Manual transmission
troller may not be sensed as being within the
engine. interior workable area (refer to the related
explanation in this section). Try again after
NOTE:
checking that you have the remote controller
When selecting the ignition modes, the
with you. If the ignition modes still cannot be
information display in the instrument clus-
selected, the battery of the remote controller
ter show certain messages. Refer to “Infor-
may be discharged. To select an ignition
mation Display” in the “INSTRUMENT
mode, you must then use the following
CLUSTER” section.
method:
(OFF) (Audio equipment)
1) Bring the keyless push start system
remote controller with you and sit in the
driver’s seat. (1)

68PH00322

Gearshift (2)
lever in P
(1)
63R40050
82K254 LOCK ACC ON
1) Manual transmission – Without
2) Manual transmission – Without (OFF) (Audio equipment) depressing the clutch pedal, push the
depressing the clutch pedal, press the engine switch (1).
engine switch (1). Gearshift lever in a
Auto Gear Shift – Without depressing position other than P Auto Gear Shift – Without depressing
the brake pedal, press the engine the brake pedal, press the engine
switch (1). 57L31006 switch (1).

5-11
OPERATING YOUR VEHICLE

2) Within about 10 seconds while the NOTE:


master warning indicator light blinks • You may customize the system to cause Remote Controller Outside Warning
and the information display in the the interior buzzer to sound once for
instrument cluster shows the following warning that remote controller is out of When either of the following conditions is
message, touch the engine switch with sensing range. For this customization, met, the system causes the remote con-
the lock switch end of the remote con- consult a Maruti Suzuki authorised work- troller outside warning by sounding the
troller (2) for about 2 seconds. shop. interior and exterior buzzers. At the same
• If the battery of the remote controller is time, the immobilizer/keyless push start
almost discharged, the information dis- system warning light comes on, the master
play in the instrument cluster shows the warning indicator light blinks and the infor-
following message when you press the mation display in the instrument cluster will
engine switch to change the ignition show the corresponding message.
mode to ON. Refer to “Information Dis- • Any door is opened and then closed
play” in “INSTRUMENT CLUSTER” sec- while the remote controller is not inside
tion for details. For details on replacing the vehicle and the engine is running or
the battery, refer to “Keyless Push Start the ignition mode has been changed to
System Remote Controller” in “BEFORE ACC or ON by pressing the engine
55T040100
DRIVING” section. switch.
• The remote controller is not inside the
While the master warning indicator light vehicle when you attempt to start the
blinks, the immobilizer/keyless push sys- engine after changing the ignition mode
tem warning light will come on for about 5 to ACC or ON by pressing the engine
seconds. switch.
If you still cannot select the ignition modes,
there may be the other problem such as
the discharged lead-acid battery. In this
case, consult a Maruti Suzuki authorised
workshop.
55T040120

5-12
OPERATING YOUR VEHICLE

• Normally, the immobilizer/keyless push Starting / Stopping Engine


(1) (2) start system warning light should go out
and the master warning indicator light (Vehicle without Keyless
should stop blinking shortly after the Push Start System)
remote controller is brought back inside
the vehicle. If they remain lit and blink- (if equipped)
ing, change the ignition mode to LOCK
(OFF) by pressing the engine switch and
Starting Engine
then perform the engine starting opera- MT
tion. Refer to “Starting / Stopping Engine
(Vehicle with Keyless Push Start Sys-
tem) (if equipped)” in this section.

NOTE:
55T050200 Always keep the remote controller with you
(1) Immobilizer/keyless push start sys- as the driver.
Auto Gear Shift
tem warning light (blinks)
(2) Master warning indicator light (blinks)

If the warning is given, place the remote


controller inside the vehicle as soon as
possible.
• Any attempt to start the engine will fail
while the warning is active. The mes-
sage appearing in the information dis- 56RH00305
play in the instrument cluster will also 1) Check that the parking brake is set fully.
indicate this condition. Refer to “Informa- 2) Turn off such loads as the headlights
tion Display” in the “INSTRUMENT and air conditioning system to facilitate
CLUSTER” section for details. starting of the engine.

5-13
OPERATING YOUR VEHICLE

3) Manual transmission vehicles: NOTE: Starting / Stopping Engine


Shift into “N” (Neutral). Hold the clutch Auto Gear Shift vehicles:
pedal and brake pedal fully depressed. If the engine cannot be started, make sure (Vehicle with Keyless Push
Auto Gear Shift vehicles: the gearshift lever is in “N” before restart- Start System) (if equipped)
Shift into “N” (Neutral) and depress the ing the engine.
brake pedal. Hold the brake pedal while
Starting Engine
starting the engine.
4) With your foot taken off the accelerator MT
pedal, crank the engine by turning the Stopping Engine
ignition key to “START”. Release the
key immediately after the engine has WARNING
started.
Except in cases of emergency, do not
NOTICE stop the engine while the vehicle is in
Auto Gear Shift
motion. If you stop the engine while
• Release the key immediately after the vehicle is in motion, the steering
the engine has started or the wheel will lock and you will not be
starter can be damaged. able to steer the vehicle. This may
• For protection of a lead-acid bat- result in an accident. Avoid stopping
tery and a starter motor, do not use the engine while driving.
the starter motor by turning the key
to “START” for more than 12 sec-
onds at a time. If the engine dose
not start, turn the key to “LOCK” 56RH00306
position and wait for more than 30 1) Check that the parking brake is set fully.
seconds before trying again. If the 2) Turn off such loads as the headlights
engine does not start after several and air conditioning system to facilitate
attempts, consult a Maruti Suzuki starting of the engine.
authorised workshop.
• Do not try to start the engine by
pushing or towing the vehicle, or
coasting down a hill. This starting
method could result in damage to
the catalytic converter or damage
to other parts.

5-14
OPERATING YOUR VEHICLE

3) Manual transmission vehicles: • If there is a problem with the system, NOTE:


Shift into “N” (Neutral). Hold the clutch the engine will not start automatically • You do not need to keep the engine
pedal and brake pedal fully depressed. even if the switch is pressed. In case switch pressed to start the engine.
Auto Gear Shift vehicles: the starter motor does not turn or • Manual transmission vehicles:
Shift into “N” (Neutral) and depress the stops immediately, start the engine The engine of a manual transmission
brake pedal. Hold the brake pedal while by the following procedure. vehicle will not start unless the clutch
starting the engine. a. Press the engine switch to select pedal is depressed.
4) The “PUSH START SWITCH” message the ON mode. • Auto Gear Shift vehicles:
will appear in the information display in b. Perform the above procedure 1) If the engine cannot be started, make
the instrument cluster. to 3). sure the gearshift lever is in “N” before
c. Keep the engine switch pressed restarting the engine.
until the engine starts. Release • During the engine starting procedure,
your finger from the engine switch messages on the information display will
after the engine has started. help you. Refer to “Information display”
in “INSTRUMENT CLUSTER” section
NOTICE for details.
• When the engine stalls in intersection
• If the engine does not start, press and railway crossing etc., restart the
the engine switch to select LOCK engine by usual procedure.
(OFF) mode and wait for more than
30 seconds before trying again, for
(1) protection of a lead-acid battery
and a starter motor. If the engine
does not start after several
82K254
attempts, consult a Maruti Suzuki
authorised workshop.
5) With your foot taken off the accelerator • Do not try to start the engine by
pedal, push the engine switch (1). pushing or towing the vehicle, or
When the engine is started, the starter coasting down a hill. This starting
motor will automatically stop. method could result in damage to
• Even if you fail to start the engine, the catalytic converter or damage
the starter motor will stop turning to other parts.
automatically after approximately 12
seconds. In this case, press the
engine switch to select LOCK (OFF)
mode and restart the engine.

5-15
OPERATING YOUR VEHICLE

Stopping Engine If the Master Warning Indicator


• Depress the engine switch to stop the Light Blinks and the Engine
engine after the vehicle stopped com- cannot be Started
pletely.
• If the engine remains stopped for a while Your keyless push start system remote con-
after it was stopped unexpectedly or was troller may not be sensed as being within the
raced before stopping, a clicking sound interior workable area (refer to the related
may be heard from around the engine explanation in this section). Try again after
when it is restarted. This is not a mal- checking that you have the remote controller
function. Always let the engine idle with you. If the engine cannot be started, the
before stopping it. battery of the remote controller may be dis-
charged. To start the engine, you must then 52RM21220

WARNING use the following method: 3) Within about 10 seconds while the
master warning indicator light blinks
Except in cases of emergency, do not 1) Check that the gearshift lever is in “P” and the information display in the
stop the engine while the vehicle is in (Park) position and keep depressing instrument cluster shows the following
motion. If you stop the engine while the brake pedal fully. message, touch the engine switch with
the vehicle is in motion, the steering the lock switch end of the remote con-
wheel will lock and you will not be troller (2) for about 2 seconds.
able to steer the vehicle. This may (1)
result in an accident. Avoid stopping
the engine while driving.

Emergency Stop
In case of emergency, you can stop the (2)
engine by quickly pushing the engine
switch more than 3 times, or pushing and
holding the engine switch for more than 2
seconds while the vehicle is in motion.
55T040100
63R40050
NOTE: While the master warning indicator light
Except in cases of emergency, do not stop 2) If the following message is shown on blinks, the immobilizer/keyless push sys-
the engine while the vehicle is in motion. the information display in the instru- tem warning light will come on for about 5
The steering and braking operation will ment cluster, press the engine switch seconds.
require more effort when the engine is (1).
stopped. Refer to “Braking” in this section.
5-16
OPERATING YOUR VEHICLE

If you still cannot start the engine, there Parking Brake Lever
may be the other problem such as the dis- WARNING
charged lead-acid battery. In this case,
consult a Maruti Suzuki authorised work- • Never drive your vehicle with the
shop. parking brake on: rear brake effec-
(1) tiveness can be reduced from over-
(2)
NOTE: heating, brake life may be
• You may customize the system to cause shortened, or permanent brake
the interior buzzer to sound once for damage may result.
warning that remote controller is out of • If the parking brake does not hold
sensing range. For this customization, the vehicle securely or does not
consult a Maruti Suzuki authorised work- fully release, have your vehicle
shop. inspected immediately by a Maruti
• If the battery of the remote controller is (3) Suzuki authorised workshop.
almost discharged, the information dis- • Always set the parking brake fully
play in the instrument cluster shows the before leaving your vehicle or it
following message when you press the 55T050220 may move, causing injury or dam-
engine switch to change the ignition (1) To set age. When parking, check that the
mode to ON. Refer to “Information Dis- (2) To release gearshift lever is in one of the fol-
play” in “INSTRUMENT CLUSTER” sec- (3) To release lowing positions:
tion for details. For details on replacing – 1st gear or “R” (Reverse) for
the battery, refer to “Keyless Push Start The parking brake lever is located between manual transmission vehicles.
System Remote Controller” in “BEFORE the front seats. To set the parking brake, – “D”, “M” or “R” for Auto Gear
DRIVING” section. depress the brake pedal and pull the park- Shift vehicles. Also, check the
ing brake lever all the way up. To release instrument cluster to make sure
the parking brake, depress the brake pedal that the transmission is engaged
and pull up slightly on the parking brake in “1” or “R” position.
lever, push the button on the end of the Remember, even though the trans-
lever with your thumb, and lower the lever mission is in gear or in Park, you
to its original position. must set the parking brake fully.
(Continued)

55T040110

5-17
OPERATING YOUR VEHICLE

Parking Brake Reminder Buzzer Precaution for Parking


WARNING A buzzer sounds intermittently to remind
When Moving the Vehicle
you to release the parking brake if you When moving the vehicle, start the engine.
(Continued)
start the vehicle without fully releasing the
• When parking the vehicle in
parking brake. Check that the parking
extremely cold weather, the follow-
brake is fully released and the brake sys- WARNING
ing procedure should be used:
1) Set the parking brake. tem warning light turns off. If you coast with the engine off,
2)Manual transmission – turn off stronger force than normal is
the engine, then shift into reverse required when turning the steering
or first gear. wheel or depressing the brake pedal,
Auto Gear Shift – shift into resulting in an accident.
reverse or first gear and check Do not coast on a downhill slope with
the gear position indicator in the the engine off.
instrument cluster to make sure
that the transmission is engaged
in 1st or reverse, then turn off the When Taking a Nap in the Vehicle
engine.
3) Get out of the vehicle and put
chocks under the wheels.
4) Release the parking brake.
When you return to your vehicle,
first set the parking brake, and
then remove the wheel chocks.
• Do not leave cigarette lighters,
spray cans, soft drink cans or plas-
tic articles (such as glasses, CD
cases, etc.) in sun-heated vehicle.
The temperature inside the vehicle
may cause as follows:
69RHS172
– Gas may leak from a cigarette
lighter or spray can and may lead Do not take a nap in the vehicle with the
to a fire. engine running.
– The glasses, plastic cards or CD
cases, etc. may deform or crack.
– Soft drink cans may fracture.

5-18
OPERATING YOUR VEHICLE

With the Engine Running, the Cool- When You Park the Vehicle Outside
WARNING ing Fan (Radiator Fan) may Rotate on a Snowy Day
• Exhaust gases can enter the vehi- Suddenly
cle due to surrounding conditions The cooling fan (radiator fan) in the engine
WARNING
and wind direction, possibly caus- compartment may automatically stop and • When you park the vehicle under
ing carbon monoxide poisoning. rotate depending on the conditions of the the eaves or the trees, fallen snow
• The gearshift lever could change engine coolant temperature. may hit the vehicle's roof and it
unintentionally, or the accelerator may be dented.
pedal could be depressed acciden- WARNING Do not park the vehicle under the
tally, causing an accident. eaves or the trees on a snowy
• If you were to accidentally step on If you get close to a rotating cooling day.
the accelerator pedal while you are fan (radiator fan), your hands, hair • If you park the vehicle outside on
asleep, the engine and the exhaust and clothing may get caught in it, a snowy day, the wiper arms may
system could overheat, resulting in resulting in personal injury. be deformed and the wiper blades
danger of fire. With the engine running, even when may be frozen on the windshield,
the cooling fan (radiator fan) stops, it because of the weight of snow.
may automatically rotate. Therefore, When you park the vehicle out-
do not get close to the cooling fan side, raise the wiper arms.
(radiator fan).

5-19
OPERATING YOUR VEHICLE

Do not Park the Vehicle Near Flam- When Leaving the Vehicle, Stop the Do not Leave the Computer and the
mable Materials Engine and Lock Doors Mobile Phone in the Vehicle
There is the possibility of theft, or these
items could become damaged due to
moisture, humidity or temperature change.

Do not Leave Lighters and Eye-


glasses in the Vehicle

69RHS174 69RHS054

Even when leaving the vehicle for a short


WARNING time, do not leave cash or valuables
inside, as there is a risk of theft.
If you park the vehicle near flamma-
ble materials, the exhaust pipes and WARNING
exhaust gas will get hot, resulting in
danger of fire. If you leave the vehicle unattended
Do not park the vehicle near flam- with the engine running, problems
such as fire or theft can occur. 69RHS175
mable materials such as dry grass,
paper waste and plywood. Do not leave the vehicle unattended
with the engine running.

5-20
OPERATING YOUR VEHICLE

Using Transmission Starting off


WARNING To start off, depress the clutch pedal all the
way to the floor and shift into 1st gear.
• As the inside of the vehicle WARNING After releasing the parking brake, gradu-
becomes hotter when parking in Do not hang any items on the gear- ally release the clutch. When you hear a
areas where strong sunlight shift lever and do not use the gear- change in the engine’s sound, slowly press
causes increased temperature, shift lever as a handrest. Otherwise, the accelerator while continuing to gradu-
there is the danger of sponta- it could prevent proper operation of ally release the clutch.
neous ignition of lighters or spray the gearshift lever and cause its mal-
cans, fire due to explosion, the function, resulting in an accident. Shifting
deformation or cracking of eye- All forward gears are synchronized and
glasses, plastic cards or CD provide quiet and easy shifting. Always
cases, or the rupture of carbon- depress the clutch pedal all the way to the
ated beverage cans. When park- Manual Transmission
floor before shifting gears. Keep the
ing in those areas, do not leave engine speed from rising into the red zone
lighters, spray cans, plastic prod- of the tachometer.
ucts (eyeglasses, plastic cards,
CD cases, etc.) or carbonated Downshifting maximum allowable
beverage cans in the vehicle. speeds
• When items get pushed around or
when the seats are moved, it is For K12N engine models
possible that gas could escape Downshifting km/h
and lead to a fire. Do not place
accessories such lighters or 2nd to 1st 20
spray cans with exposed operat-
ing parts in the glove box, in stor- 3rd to 2nd 85
age compartments, between the 56RM03002 4th to 3rd 130
seats, on the floor, etc.
5th to 4th 180*

5-21
OPERATING YOUR VEHICLE

*NOTE: Auto Gear Shift


You may not accelerate to the maximum NOTICE
allowable speed because of the driving sit-
uation and/or the vehicle condition. • Do not downshift to a lower gear at
the speed faster than the maximum
allowable speeds for the next lower
WARNING speed, or severe damage to engine
• Reduce your speed and downshift and transmission can result.
to a lower gear before going down • Before engaging reverse gear [R],
a long or steep hill. A lower gear check that the vehicle is com-
will allow the engine to provide pletely stationary and gear lever is
braking. Avoid riding the brakes or in neutral [N] position. After
they may overheat, resulting in depressing clutch pedal fully, shift
brake failure. to [R]. 55T050050
• When driving on slippery roads, • To help avoid clutch damage, do Auto Gear Shift is a 5-speed forward/
slow down before downshifting. not use the clutch pedal as a foot- reverse transmission.
Excessive and/or sudden changes rest while driving or use the clutch
in engine speed may cause loss of to keep the vehicle stationary on a Auto Gear Shift has the basic features of
traction, which could cause you to slope. Depress the clutch fully conventional manual transmission, but
lose control. when shifting. clutch operation and transmission gear
• When shifting or starting off, do not shifting are controlled electronically.
race the engine. Racing the engine
can shorten engine life and cause NOTICE
negative effect to smooth shifting.
Do not depress both the brake pedal
and accelerator pedal simultane-
NOTE: ously.
If it is difficult to engage reverse gear [R], This can cause damage or overheat-
follow below procedure. ing to the clutch.
• Put gear lever in neutral [N] position.
• Release clutch pedal once. NOTE:
• Again depress the clutch pedal and shift When you open the driver’s door, the Auto
from [N] to [R]. Gear Shift systems run automatically and
you may hear an operating noise. This
sound does not indicate malfunction.

5-22
OPERATING YOUR VEHICLE

Depress brake pedal indicator Starting the engine


When starting the engine, always place the CAUTION
gearshift lever in the “N” position and
depress the brake pedal firmly. The engine For the vehicles with the keyless
cannot be started unless the gearshift push start system, if you cannot
lever is in the “N” position and the brake press the engine switch firmly, the
pedal is depressed. engine may not start. Even if you
shift the gearshift lever into “R” or
If you parked vehicle with gear engaged on “D” position without the engine run-
76MH0A047
last time (if you can see “1” or “R”), shift ning, the vehicle does not move.
This light will come on if you do not into “N” (Neutral) and depress the brake If you try to move your vehicle under
depress the brake pedal in the following pedal. Hold the brake pedal while starting the above-mentioned condition, the
situations. the engine. You can hear buzzer in short vehicle may move in unexpected
• When starting the engine. time. directions on a slope, etc.
• When the engine is on and the gearshift This may cause an accident.
lever is shifted from “N” position to “D”, When starting engine, press engine
“M” or “R” position. switch firmly. Also, make sure that
• When the ignition switch is in “ON” posi- the engine is running by checking
tion or the ignition mode is “ON”, and the engine sound or warning and indica-
engine is off, the gearshift lever is shifted tor lights.
into any position.
This light will also come on if one of the NOTE:
gears cannot be engaged and the system 76MH0A056 • If you start the engine without the gear-
is unable to re-try shifting when you shift shift lever in the “N” position, the gear
the gearshift lever from “N” position to “D”, position indicator in the instrument clus-
“M” or “R” position. ter will blink.
• When the engine restarts automatically
after engine A-Stop, the gear position
indicator in instrument cluster may dis-
play “N” temporarily. This is a normal
phenomenon.

5-23
OPERATING YOUR VEHICLE

Clutch operation NOTE:


You can select either the Drive (D) mode NOTICE • If 1st gear cannot be engaged even
or the Manual (M) mode or the Reverse though the gearshift lever has been
(R) mode. Since this vehicle controls A buzzer will sound continuously if shifted from the “N” to the “D” position,
clutch operation electronically in either the vehicle is operated with the gear- the system will re-try shifting automati-
mode, you do not need to operate the shift lever in-between of each shift cally. This will take some time, noise
clutch. positions. The vehicle will become may be heard from the gears, and shift-
inoperative if you continue to operate ing gear shock may occur. However,
Creeping function the vehicle with the gearshift lever in they do not indicate malfunction.
This vehicle has a creeping function that between shift positions. – The “N” indicator will flash, the
helps the vehicle to start smoothly by depress brake pedal indicator will
engaging the clutch. When the gearshift Drive (D) mode come on and a warning buzzer (long
lever is in any of the positions “D”, “M” or When the Drive (D) mode is activated, the pulse sound) will sound if any of the
“R”, and you release your foot from the most appropriate gear position is automati- following cases occur;
brake pedal, the vehicle starts slowly with- cally selected upon operation of the accel- – If you shift the gearshift lever from
out depressing the accelerator pedal. erator pedal and variation of vehicle the “N” to the “D” position without
However, creep is not possible in manual speed. depressing the brake pedal
(M) mode with 2nd gear engaged. The – If the system is unable to re-try shift-
creeping function is disabled if you Normal driving: ing You should depress the brake
depress the brake pedal or pull up the 1) Start the engine as instructed in “Start- pedal and shift the gearshift lever to
parking brake lever. ing the engine” in this section. “N” position, then shift to “D” again.
2) With your foot on the brake pedal, shift
NOTE: the gearshift lever to the “D” position. 3) Release the parking brake and brake
If the driver’s door is opened and/or the When the gearshift lever is shifted to pedal.
parking brake lever is engaged with the the “D” position, the gear will be shifted 4) Depress the accelerator pedal slowly.
gear in the “M”, “D” or “R” position, the to 1st.
creeping function will not operate.

Parking and Stopping the vehicle


Auto Gear Shift does not have a parking
position. Park the vehicle with a gear
engaged. Make sure that the gearshift D
lever is “D”, “M”, or “R”.
Also, check the instrument cluster to make
55RM03009
sure that the transaxle is engaged in “1” or
“R” position.
5-24
OPERATING YOUR VEHICLE

Starting off on an uphill/downhill:


WARNING NOTICE
• While driving the vehicle, do not Do not operate the system as CAUTION
shift the gearshift lever to the “N” described below. The life cycle of the The hill hold control system (if
position. The engine brake may not clutch may be reduced. equipped) will not activate while the
work and you may get involved in • Using the accelerator pedal to hold parking brake is engaged.
an unexpected accident. If you the vehicle on an uphill slope with
return the gearshift lever from “N” the gearshift lever in the “D” or “M” Uphill
to “D” because of unintended shift- position. If you perform this opera- 1) Apply the parking brake firmly so that
ing, the gear position will be shifted tion for a certain period of time, a the vehicle does not roll backwards.
according to the current vehicle warning buzzer will sound. 2) Shift the gearshift lever to the “D” posi-
speed. • Shifting the gearshift lever to the tion while depressing the brake pedal.
• Always keep your foot on the brake “D”, “M” or “R” position while rac- Make sure that the gear position indica-
pedal while stopped with the ing the engine. tor in the instrumental cluster displays
engine running. This operation pre- • Driving at low speed using a high 1st gear.
vents the vehicle from moving due gear. 3) Release the brake pedal and depress
to unintended activation of the • Holding the vehicle on an uphill the accelerator pedal gradually, and
creeping function. slope using the creeping function. when the vehicle starts to move,
If you perform this operation for a release the parking brake and depress
certain period of time, a warning the accelerator pedal to start off.
NOTICE buzzer will sound.
If the gearshift lever cannot shift into NOTICE
any position, or the gear is changed On an uphill slope, never hold the
to “N” position automatically when vehicle at a stop using only the accel-
the vehicle speed becomes less than erator pedal or the creeping function.
10 km/h, there may be a systematic If you perform this operation for a
malfunction. In this case, ask a certain period of time, a warning
Maruti Suzuki authorised workshop buzzer will sound, and in some cases
to inspect the Auto Gear Shift system the engine will stall. This can also
as soon as possible. cause excessive damage to the
clutch.

5-25
:, %(8 Q:% ; .

B6  '6   B6 R B6  /


    ;        
   KL   '  '6  /
    ;7 
       
# &   ;       
    78  
       +
 ;    
    

 / /  @ /R


)        + -
       4 7    -1&3!, -1&3!
 ;  
97            K'L    KRL      KML  
  +'  '   +    8 7    -    8 7    -
 7      7  +          +          
.       +  o# o! o(o    - o ( o !  o #  o 
KA      L K'  ' -   
 L
A 0A2 +
5        75
      +    
     KRLKML
 
2            
 +       01'32-, 01'321
   7           5        7  
7      5       -
           
9    +  7   
            
            
    +   -
!-
OPERATING YOUR VEHICLE

erator pedal. It is possible to start vehicle


in 2nd gear using manual mode, from stop WARNING NOTICE
condition.
• Be careful when accelerating, • If the gearshift lever cannot shift
NOTE: upshifting, downshifting or brak- into any position, or the gear is
• Always use 1st gear while starting off an ing on a slippery surface. Sudden changed to “N” position automati-
uphill slope otherwise you can damage acceleration or engine braking cally when the vehicle speed
the clutch. could cause the vehicle to spin or becomes less than 10 km/h, there
• To downshift smoothly, the engine runs skid. While starting off on a slip- may be a systematic malfunction.
fast in some cases. This is done inten- pery or snowy roads, please use In this case, ask a Maruti Suzuki
tionally by the system and is not mal- 2nd gear (if required). authorised workshop to inspect the
function. • To drive down a long or steep hill, Auto Gear Shift system as soon as
• When driving down a hill, downshift and reduce your speed and downshift. possible.
use the engine braking appropriately. If Remember, if you ride the brakes • The manual (M) mode does not
necessary, continuous downshifting is excessively, they may overheat and upshift even if the engine speed
possible. However, if downshifting more fail. reaches the rev-limit.
than 3 steps, gear shifting will take more • While driving the vehicle, do not • The system will not allow shifting
time. shift the gearshift lever to “N” posi- up or down to a gear that would
• When the gear is shifting, a noise can be tion. The engine brake may not cause engine over-revving or
heard in some case. This is not malfunc- work and you may get involved in under-revving.
tion. an unexpected accident. If you • If frequently driving at low speed
return the gearshift lever from “N” using a high gear position, the life
to “M” because of unintended shift- cycle of the clutch may be reduced.
ing, the gear position will be shifted • Frequent downshifting (more than
according to the current vehicle 3 positions consecutively) causes
speed. the reduction of transmission life.
• Do not apply the parking brake
while driving. Otherwise, it could
cause a skid and you may get
involved in an unexpected acci-
dent.

5-27
OPERATING YOUR VEHICLE

Starting off: 3) Release the parking brake and brake Starting off on an uphill/downhill
1) Start the engine as instructed in “Start- pedal. Depress the accelerator pedal slope:
ing the engine” in this section. slowly for smooth starting.
2) With your foot on the brake pedal, shift Uphill
the gearshift lever to the “M” position. WARNING 1) Apply the parking brake firmly so that
When the gearshift lever is shifted to the vehicle does not roll backwards.
Always keep your foot on the brake 2) Shift the gearshift lever to the “M” posi-
the “M” position, the gear will be shifted
pedal while stopped with the engine tion while depressing the brake pedal.
to 1st. Before starting off, always make
running. These operations prevent Make sure that the gear position indica-
sure that the intended gear is engaged
the vehicle from starting due to unin- tor in the instrumental cluster displays
by checking the gear position indicator,
tended activation of the creeping 1st gear.
then depress the accelerator pedal.
function. 3) Release the brake pedal and depress
NOTE: the accelerator pedal gradually, and
when the vehicle starts to move,
• If 1st gear cannot be engaged even NOTICE release the parking brake and depress
though the gearshift lever has been
shifted from the “N” to the “M” position, Do not operate the system as the accelerator pedal to start off.
the system will re-try shifting automati- described below. The life cycle of the
cally.This will take some time, noise may clutch may be reduced. NOTICE
be heard from the gears, and shifting • Using the accelerator pedal to hold On an uphill slope, never hold the
gear shock may occur. However, they do the vehicle on an uphill slope oper- vehicle at a stop using only the accel-
not indicate malfunction. ation with the gearshift lever in the erator pedal or creeping function. If
• The “N” indicator will flash, the depress “M” or “D” position. If you perform you perform this operation for a cer-
brake pedal indicator will come on and a this operation for a certain period tain period of time, a warning buzzer
warning buzzer (long pulse sound) will of time, a warning buzzer will will sound, and in some cases the
sound if any of the following cases sound. engine will stall. This can also cause
occur; • Shifting the gearshift lever to the excessive damage to the clutch. In
– If you shift the gearshift lever from the “M”, “D” or “R” position while rac- case the warning buzzer is on, shift-
“N” to the “M” position without ing the engine. ing to 2nd gear will not be possible in
depressing the brake pedal. • Driving at low speed using a high manual mode. Always use 1st gear
– If the system is unable to re-try shift- gear. while starting off on a uphill slope.
ing. • Stopping on a slope using the Otherwise you may damage the
You should depress the brake pedal and creeping function. If you perform clutch.
shift the gearshift lever to “N” position, then this operation for a certain period
shift to “M” position again a few seconds of time, a warning buzzer will
later. sound.

5-28
OPERATING YOUR VEHICLE

Downhill NOTE:
1) Depress the brake pedal and shift the • If reverse gear cannot be engaged even NOTICE
gearshift lever to the “M” position. though the gearshift lever has been
Make sure the gear position indicator to shifted from the “N” to the “R” position, On a downhill slope, never hold the
make sure that the gear is in 1st. the system will re-try shifting automati- vehicle at a stop using only the accel-
2) Release the brake pedal and depress cally.This will take some time, noise may erator pedal or the creeping function.
the accelerator pedal slowly. Even be heard from the gears, and shifting If you perform this operation for a
though the accelerator pedal is not gear shock may occur. However, they do certain period of time, a warning
depressed, the clutch will be engaged not indicate malfunction. buzzer will sound, and in some cases
when the vehicle speed increases. • The “N” indicator will flash, the depress the engine will stall. This can also
brake pedal indicator will come on and a cause excessive damage to the
Backing up warning buzzer (long pulse sound) will clutch.
After the vehicle has stopped completely, sound if any of the following cases
depress the brake pedal and shift the gear- occur; Stopping
shift lever to the “R” position. Depress the – If you shift the gearshift lever from the The vehicle can be stopped by depressing
accelerator pedal slowly as when starting “N” to the “R” position without depress- the brake pedal regardless of the gear
off in 1st gear. Before backing up, make ing the brake pedal. position. This is because the clutch is auto-
sure that reverse gear is selected by – If the system is unable to re-try shift- matically disengaged to prevent the engine
checking the gear position indicator. ing. from stopping.
You should depress the brake pedal and • If the gearshift lever is in the “D” position,
shift the gearshift lever to “N” position, the gear will be downshifted to 1st when
then shift to “R” position again a few sec- the vehicle stops.
onds later. • If the gearshift lever is in the “M” posi-
• The system will not allow shifting to the tion, the gear will be downshifted to 1st
“R” position if the vehicle speed is over when the vehicle stops.
about 3 km/h. If the gearshift lever is
operated under this condition, the “N”
76MH0A062 indicator in the instrument cluster will
blink. However, when the vehicle speed
drops below about 3 km/h, the gear will
be shifted to reverse. Make sure that the
vehicle has stopped completely before
shifting to the “R” position.

5-29
OPERATING YOUR VEHICLE

Parking
WARNING NOTICE Unlike an automatic transmission, Auto
Gear Shift does not have a parking posi-
• When stopping, for example, at a • On a slope, never hold the vehicle tion. The vehicle can be parked with the
traffic light, be sure to depress the at a stop using only the accelerator gearshift lever at “D” or “R” position.
brake pedal firmly. For your safety, pedal or the creeping function. If Remember, even though the transmission
apply the parking brake, too, when you perform this operation for a is in gear, you must set the parking brake
stopping on a hill. certain period of time, a warning firmly. Park the vehicle with a gear
• When racing the engine, make sure buzzer will sound, and in some engaged.
that the gear is in the “N” position cases the engine will stall. This can 1) Apply the parking brake firmly.
by checking the gear position indi- also cause excessive damage to 2) While depressing the brake pedal, shift
cator. If the accelerator is operated the clutch. the gearshift lever to the “R” position on
with the gear in any other position, • If the gearshift lever is operated a downhill slope, and to the 1st position
the vehicle may move resulting in more than necessary, the system in the drive (D) mode or the “M” position
an unexpected accident. may not allow operation of the in the manual (M) mode on an uphill
• Do not leave your vehicle unat- gearshift lever for a certain period slope and confirm the gear position by
tended while the engine is running. of time, and the gear may not be checking the gear position indicator.
• When leaving the vehicle, stop the shifted appropriately. Therefore, do 3) Stop the engine.
engine and park the vehicle with a not operate the gearshift lever if 4) In the case of uphill/downhill slope,
gear engaged. If you need to leave not necessary. release the parking brake and brake
the vehicle with the engine running, pedal slowly in order to check the gear
apply the parking brakes firmly, is engaged.
and shift the gearshift lever to the 5) After check the vehicle stopped by the
“N” position. Otherwise, the vehi- gear engaged, Apply the parking brake
cle may move unexpectedly and and the brake pedal firmly again.
may cause an accident. 6) Get out of the vehicle and put chocks
under the wheels.
When you return to your vehicle, you must
remember to remove the wheel chocks.
NOTE:
• After the engine is stopped, the gear in
the transmission does not change even
if you shift the gearshift lever in any posi-
tion. Always shift the gearshift lever
before stop the engine.

5-30
OPERATING YOUR VEHICLE

• Check the transmission gear position by Parking cancel to “LOCK” position or press the engine
looking at the gear position indicator, Depress the brake pedal, turn the ignition switch to change the ignition mode
then turn the ignition switch to “LOCK” switch to the “ON” position or press the “LOCK” (OFF).
position or press the engine switch to engine switch to change the ignition mode • During a stop, the driver’s door is
change the ignition mode to “LOCK” to “ON”, and shift the gearshift lever to the opened with the gearshift lever in the
(OFF), to stop the engine. Release the “N” position. The gear will be disengaged. “R”, “D” or “M” position while the engine
brake pedal after a few seconds. is running.
Warning functions
WARNING A warning buzzer will sound or the indica- “N” indicator blinking
tor will blink under the following conditions. When the gear indicator lamp blinks “N”,
• If the gear is not engaged properly you should depress the brake pedal and
and completely before the ignition Warning buzzer shift the gearshift lever to “N” position.
switch is turned to “LOCK” posi- • The clutch is heated due to excessive
tion or the engine switch is pressed load. “1” indicator blinking
to change the ignition mode to • The creeping function is being activated When the gear indicator lamp blinks “1”,
“LOCK” (OFF), the vehicle may not for a long period of time. you should depress the brake pedal and
be parked with the gear engaged. shift the gearshift lever to “N” position, then
Always confirm the gear position
by checking the gear position indi-
NOTICE shift to “D” or “M” position again a few sec-
onds later.
cator when parking. In the above cases, pull over to the
• On a downhill slope, the gear side of the road and stop the engine,
should be put in reverse, and in 1st and then ask a Maruti Suzuki autho- “R” indicator blinking
gear on an uphill slope. In case of rised workshop to inspect your vehi- When the gear indicator lamp blinks “R”,
uphill/downhill slope, after check- cle. Otherwise, the clutch disc may you should depress the brake pedal and
ing the vehicle stopped by the gear be damaged. shift the gearshift lever to “N” position, then
engaged, put the chocks under the shift to “R” position again a few seconds
wheels. Otherwise, the vehicle may later.
• The ignition switch is turned to “LOCK”
move, and cause an unexpected position or the engine switch is pressed
accident. If the gear is left in the to change the ignition mode to “LOCK”
“N” position, the vehicle cannot be (OFF) with the gear in 2nd, 3rd, 4th or
parked with a gear engaged. 5th. In this case, turn the ignition switch
to “ON” position or press the engine
switch to change the ignition mode to
“ON”, and shift the gearshift lever in the
“N” position, shift it to the “D” or “M” or
“R” position, then turn the ignition switch
5-31
OPERATING YOUR VEHICLE

Gearshift Indicator NOTE:


When cruise control system SET indicator
(if equipped) is ON, Gear Shift Indicator may not be dis-
played.
For details on how to use the transmission,
refer to “Using Transmission” in this sec-
tion.

WARNING
56RM03028 The gearshift indicator is designed to
indicate optimal gear position for
In the following case, the gearshift indica- your driving, however, a driver will
tor is indicated in the information display not be relieved from the duty of care
when the ignition switch is in the “ON” of driving operation or gear change
position or the ignition mode is “ON”. with this indicator.
To drive safe, do not gaze the gear-
• When the gearshift lever is in a position shift indicator, pay attention to your
other than “N” (Neutral). driving situation and shift up or down
The electronic control system monitors if necessary.
driving condition (such as vehicle speed
and/or engine revolution), and it recom-
mends gearshift for your driving with indi-
cations on display.
If UP/DOWN arrow is indicated on the dis-
play while driving, we recommend you to
shift up or down. It is the optimal gear posi-
tion for a driving condition that reduces the
over revolution and stress to the engine,
and improves fuel consumption.

5-32
OPERATING YOUR VEHICLE

NOTE:
• The gearshift indicator is not indicated when the gear position is in “N” (Neutral).
• If you depress the clutch pedal while UP/DOWN arrow is indicated, the indication will disappear.
• In ordinary driving, UP arrow will disappear when you release your foot from the accelerator pedal.
• The indication of gearshift indicator timing may differ depending on the vehicle condition and/or driving situation even in the same vehi-
cle speed and engine revolution.
• If ESP® system (if equipped) is working, the gear shift indicator will disappear temporarily.

Example of the gearshift indicator


Indication Description

Lower gear position is selected for the vehicle speed and/or engine revolution. Changing to a higher
gear position is recommended.
55T050060

Higher gear position is selected for the vehicle speed and/or engine revolution. Changing to a lower
gear position is recommended.
55T050070

5-33
OPERATING YOUR VEHICLE

ENG A-STOP System (Engine NOTICE


CAUTION
Auto Stop Start System) The vehicle equipped with this sys-
• Do not get out of the vehicle while
(if equipped) the engine is automatically stopped
tem uses a dedicated high-perfor-
mance battery that supports ENG A-
The ENG A-STOP system (engine auto by the ENG A-STOP system. Doing
STOP system. Accordingly, observe
stop start system) automatically stops the so may lead to an accident.
the instructions listed below. If these
engine while waiting briefly at a traffic light, – Manual transmission vehicle – If
instructions are not observed, the
etc., and automatically restarts the engine the driver’s seat belt is unfas-
system may not actuate properly or
afterward. This system helps reduce emis- tened and the driver’s door is
the battery may die prematurely.
sions, improve fuel consumption and lower opened, the engine will stall.
• When replacing the battery, use a
engine noise. – Auto Gear Shift vehicle – If the
Maruti Suzuki genuine battery
driver’s seat belt is unfastened,
This system stops the engine temporarily specified in the Specification.
even if the brake pedal is pressed
under specific conditions. Before parking • Do not draw power from the battery
down, or the driver’s door is
the vehicle for an extended period of time terminals for electrical products.
opened, the engine will be
or leaving the vehicle, properly apply the restarted to warn you that the
parking brake and stop the engine with the engine was stopped automati-
engine switch. cally by the ENG A-STOP system.
Once the specific conditions are met, the • If the engine does not restart auto-
engine will stop automatically after the matically after having been
vehicle has stopped. However, the engine stopped automatically by the ENG
will not be stopped automatically until con- A-STOP system, push the engine
firmation of the system function is finished. switch to start the engine. Trying to
move the vehicle when the engine
NOTE: has not yet restarted requires a
If your vehicle is equipped with automatic strong force to turn the steering
heating and air conditioning system, you wheel or depress the brake pedal,
can change the automatic engine stop potentially leading to an accident.
condition via the information display. Refer
to “Information display” in “INSTRUMENT
CLUSTER” section.

5-34
OPERATING YOUR VEHICLE

Automatic Stopping / Restarting of an interior buzzer or restarted, to ensure trol mode) to keep the cabin air-
the Engine safety. conditioned for a longer time.
Manual transmission vehicle For details, refer to “Points to note during NOTE:
1) With the brake pedal depressed, decel- the automatic engine stop” in this section. For manual transmission vehicles, if the
erate the vehicle. engine stalled by a rapid clutch operation,
NOTICE the engine will restart with the gear posi-
tioned “N” (neutral) and the clutch pedal
During the automatic engine stop depressed.
condition,
• Do not shift the gearshift lever to a
position other than “N” without
depressing the clutch pedal. If the
(1)
gear shift lever is in a position
other than “N”, the engine will not
restart automatically even if the
clutch pedal is depressed. (1)
• If the driver unfastens the seat belt,
the engine does not restart auto-
matically even if the clutch pedal is
55T050240 depressed. Also a buzzer will
2) After the vehicle has stopped with the sound to alert the driver. In this
clutch pedal depressed and the gear- case, fasten the seat belt.
shift lever shifted to “N”, and then NOTE: 55T050250
release the clutch pedal, the engine will During the automatic engine stop, electric 3) Regardless of whether the vehicle has
stop automatically. equipment will be in the following condi- stopped or not, depressing the clutch
The ENG A-STOP indicator light (green) tions: pedal will restart the engine and ENG
(1) will come on. • The audio and other electrical compo- A-STOP indicator light (green) (1) will
nent can be used during the automatic go off.
• The ENG A-STOP system will not stop engine stop, but the air conditioner will While the engine is stopped automatically,
the engine automatically if all the auto- switch to the fan mode. depressing the clutch pedal will restart the
matic engine stop conditions are not • If the vehicle is equipped with automatic engine consuming fuel. Therefore, for fuel
met. For details, refer to “Automatic heating and air conditioning system, the economy, it is recommended to depress
engine stop conditions” in this section. fan speed will be limited during the auto- the clutch pedal just before the vehicle
• During the automatic engine stop, the matic engine stop (only in the auto con- start.
engine may shut down, accompanied by

5-35
OPERATING YOUR VEHICLE

• Without depressing the clutch pedal, the • The ENG A-STOP system will not stop
engine may restart automatically if the the engine automatically if all the auto-
automatic engine restart conditions are matic engine stop conditions are not
met. met. For details, refer to “Automatic
engine restart conditions” in this section.
For details, refer to “Automatic engine
• During the automatic engine stop, the
restart conditions” in this section.
engine may shut down, accompanied by
an interior buzzer or restarted, to ensure (1)
Auto Gearshift vehicle
safety.
1) With the brake pedal depressed, stop
the vehicle. For details, refer to “Points to note during
the automatic engine stop” in this section.

NOTE:
During the automatic engine stop, electric 55T050270
equipment will be in the following condi-
tions: 3) Remove your foot from the brake pedal.
• The audio and other electrical compo- “ENG A-STOP” indicator light (green)
(1) nent can be used during the automatic (1) in the instrument cluster will be
engine stop, but the air conditioner will turned off and the engine will restart
switch to the fan mode. automatically.
• If the vehicle is equipped with automatic When restarting the engine, keeping brake
heating and air conditioning system, the force temporarily prevents the vehicle from
fan speed will be limited during the auto- moving forward by the creeping function.
matic engine stop (only in the auto con- Also, this prevents the vehicle from rolling
55T050260 trol mode) to keep the cabin air- downward on a hill. For details, refer to
conditioned for a longer time. “Hill hold control system (if equipped)” in
2) While depressing the brake pedal,
this section.
place the gearshift lever in “D” position.
“ENG A-STOP” indicator light (green)
NOTE:
(1) in the instrument cluster will illumi-
When the engine is restarted automati-
nate and the engine will stop automati-
cally, the following conditions may be
cally.
found as the hill hold control system (if
equipped) is activated, but this is not a
malfunction.
• You may hear a sound from the engine
room.
5-36
OPERATING YOUR VEHICLE

• As brake pedal becomes heavy, it may NOTE: NOTE:


be difficult for you to depress it. The power steering warning light, engine For manual transmission vehicles, if the
oil pressure warning light and charge engine stalled by a rapid clutch operation,
NOTE:
warning light on the meter panel do not the engine will restart with the gear posi-
When the engine does not restart automat-
come on during the automatic engine stop, tioned “N” (neutral) and the clutch pedal
ically when the brake pedal is released, an
but they will come on once the engine depressed.
interior buzzer will sound and the engine
shuts down.
will come out of the automatic engine stop
mode and shut down. The ENG A-STOP
indicator light (green) will go off. NOTICE
The ENG A-STOP system will not
Points to note during the automatic operate and engine does not restart
engine stop automatically or the engine stalls
When the following operations are per- with warning buzzer under the follow-
formed during the automatic engine stop, ing conditions:
the engine may shut down, accompanied • Engine hood is open.
by an interior buzzer or restarted, to
ensure safety. For manual transmission vehicle
• When the hood is opened, an interior • Driver’s seat belt is not fastened
buzzer will sound intermittently and the and driver’s door is open.
engine will come out of the automatic • The gearshift lever is moved to a
engine stop mode and shut down. The position other than “N” (Neutral)
ENG A-STOP indicator light (green) will position without depressing the
go off. clutch pedal.
• For manual transmission model, when When the engine stalls, restart the
the driver releases the seat belt and engine by usual operation.
opens the driver's door, the buzzer Refer to “Starting / Stopping Engine
sounds 5 times and the ENG A-STOP (vehicle with keyless push start sys-
indicator light (green) turns off and then tem) (if equipped)” or “Starting /
the engine will stall. Stopping Engine (vehicle without
• For Auto Gear Shift vehicle, if the engine keyless push start system) (if
does not start 2 seconds after the brake equipped)” in this section for details.
is released, the buzzer will sound, the
ENG A-stop light will go off, and the
engine will stall.

5-37
OPERATING YOUR VEHICLE

Actuation Conditions for ENG Automatic engine stop conditions


A-STOP System When all of the following conditions are
(a) met under the standby conditions, the
Standby conditions engine will stop automatically after the
When all of the following conditions are vehicle has stopped:
met while the vehicle is traveling, ENG A- • The gearshift lever is in “N” (Neutral)
STOP system will be permitted: position (for manual transmission vehi-
• The engine is started with the hood com- cle).
pletely closed. • The clutch pedal is released (for manual
• The hood is completely closed. transmission vehicle).
• The ENG A-STOP OFF switch has not 55RH03001 • Engine auto stop function will be ready
been pressed to deactivate the ENG A-
• The ABS or ESP® (if equipped) has not once the vehicle runs at a speed
STOP system. exceeding 6km/h after restart of the
been activated during one driving cycle
• The battery is fully charged and the tem- engine.
(a) from the engine start to the vehicle
perature inside the battery is within the • The vehicle has stopped.
start and stop.
specified range (#1). • The accelerator pedal is not depressed.
• The gearshift lever is in “D” or “N” (for
• The engine has warmed up and the • The vehicle is not stopped on a steep hill
auto gearshift vehicle).
engine coolant temperature is within the (for auto gear shift vehicle).
specified range. #1 If the vehicle has not been in use for an • The gearshift lever is in “D” or “N” posi-
• The driver is wearing seat belts. extended period of time or the audio or tion (for auto gearshift vehicle).
• The driver’s door is completely closed. other electrical component was used • The brake pedal is depressed appropri-
• No electronically controlled system for an extended period of time while the ately (for auto gearshift vehicle).
besides the ENG A-STOP system is engine was stopped, the battery may
issuing a signal to inhibit stopping of the have discharged and it may take some NOTICE
engine (#2). time before the standby mode is
• For the vehicle equipped with automatic achieved. For Auto Gear Shift vehicle, the ENG
heating and air conditioning system, the #2 If any of the warning and indicator lights A-STOP system will not operate, if
temperatures at air-conditioner outlets affecting the ENG A-STOP system the brake pedal is depressed weakly
are sufficiently low in the cooling mode come on, the engine will not be stopped or very strongly.
or sufficiently high in the heating mode. automatically.
• For the vehicle equipped with automatic
heating and air conditioning system, the
defroster is turned off.
• The negative pressure of the brake
booster is normal.

5-38
OPERATING YOUR VEHICLE

Automatic engine restart conditions • For the vehicle equipped with automatic ENG A-STOP OFF Switch
If one of the following operations is per- heating and air conditioning system, the
formed or the vehicle enters one of the fol- defroster is turned on (#). The ENG A-STOP system can be deacti-
lowing modes during the automatic engine • The accelerator pedal depressed (for vated.
stop, the engine will restart automatically auto gearshift vehicle). • To deactivate the system, press the
and the ENG A-STOP indicator light • The gearshift lever is put in “R” or in “M” ENG A-STOP OFF switch (1) to turn on
(green) will go off: position (for auto gear shift vehicle). ENG A-STOP OFF light (2).
• After the gearshift lever is shifted to “N”, • To activate the system once again,
• The clutch pedal is depressed (for man- it is returned to “D” (for auto gear shift press the switch (1) again to turn off the
ual transmission vehicle). vehicle). indicator.
• When the brake pedal is released (for • The driver releases the seat belt (for • Every time the engine is stopped manu-
auto gearshift vehicle). auto gearshift vehicle) (#). ally, the system is enabled again and the
• The ENG A-STOP OFF switch is • The driver’s door is opened (for auto ENG A-STOP OFF light (2) goes off.
pressed to deactivate the ENG A-STOP gearshift vehicle) (#).
system.
• The battery has discharged substantially • The vehicle starts to move on a slope,
(#). etc. (#).
• A malfunction of the system is detected • Some time (2 minutes or so) has (1)
(#). elapsed after the start of the automatic
• The negative pressure of the brake engine stop (#).
booster has dropped (#).
• For the vehicle equipped with automatic # The ENG A-STOP indicator light (green) (2)
heating and air conditioning system, the will blink and then go off.
temperatures at air conditioner outlets
have changed considerably after the NOTICE
automatic engine stop to the point of For manual transmission vehicle, if
affecting the cooling/heating perfor- driver's seat belt is not fastened or 55T050280
mance (#). the gear shift lever is in a position
• For the vehicle equipped with automatic other than “N”, the engine will not be NOTE:
heating and air conditioning system, the restarted automatically. Pressing the ENG A-STOP OFF switch (1)
temperature selector has been turned during the automatic engine stop will
considerably to the COOL side in the restart the engine automatically and the
cooling mode or to the HOT side in the ENG A-STOP OFF light (2) will come on.
heating mode (#).

5-39
OPERATING YOUR VEHICLE

ENG A-STOP OFF Indicator Light

56RM03012

When the ignition switch is turned to “ON”


position or the engine switch is pressed to
change the ignition mode to ON, this light
comes on briefly if the system works prop-
erly.

When you push the ENG A-STOP OFF


switch, this light comes on.

If this light blinks when driving, there may


be something wrong with the ENG A-
STOP system. You should have the sys-
tem inspected by a Maruti Suzuki autho-
rised workshop.

5-40
OPERATING YOUR VEHICLE

Information Message (if equipped)


The information display shows the messages to let you know certain problems of the ENG A-STOP system.

Information message Sound Cause and remedy


Off The ENG A-STOP system cannot stop the engine automatically because one of the fol-
lowing conditions is met.
• The engine is started with the hood open.
• The temperature of the vehicle battery is either low or high.
• The vehicle battery performance is low.
• The blower speed selector is set to the ON mode and the inside of the vehicle has not
sufficiently cooled and warmed (for the vehicle with automatic air conditioning).
• The defrost switch is set to the ON mode (for the vehicle with automatic air condition-
ing).
• During or after the ABS or ESP® system (if equipped) is activated, and the vehicle is
52RM30650
stopped.
• The brake booster vacuum pressure is low.
• The accelerator pedal is depressed.
• The clutch pedal is not depressed and the gearshift lever is in a position other than “N”
(Neutral) (for manual transmission vehicle).
• The driver’s door is opened.
• The driver’s seat belt is unfastened.
• The engine hood is opened.
• The engine has warmed up and the engine coolant temperature is out of range of the
specified limit.
• The ENG A-STOP system is issuing a signal to inhibit stopping of the engine.
• The gearshift lever is in a position other than "D" or "N" (for auto gearshift vehicle).

5-41
OPERATING YOUR VEHICLE

Information message Sound Cause and remedy


Off The engine is restarting automatically because one of the following automatic
engine restart conditions is met.
• The temperatures at air conditioner outlets have changed considerably after
the automatic engine stop to the point of affecting the cooling/heating perfor-
mance.
• The lead-acid battery has discharged substantially.
• Some time has elapsed after the start of the automatic engine stop.
• The temperature selector was greatly set toward cool while cooling or greatly
set toward hot while heating.
52RM30660

Off The engine restarted automatically.

56RM03027

Beep For vehicle without keyless push start system, while the engine is stopped auto-
(2 times from interior matically, if the hood is opened and the engine does not restart automatically,
buzzer) and then the engine stalls, this message appears in the display when the hood
is closed to prompt the engine start.
Beep For manual transmission vehicle without keyless push start system, while the
(5 times from interior engine is stopped automatically, if the driver’s door is opened and the driver’s
buzzer) seat belt is unfastened, and then engine stalls, this message appears in the dis-
play when the driver’s door is closed and the driver’s seat belt is fastened to
prompt the engine start.
56RM03127

5-42
OPERATING YOUR VEHICLE

Information message Sound Cause and remedy


Beep The engine restarted automatically because the following automatic engine
(10 times from interior restart condition is met.
buzzer) • When the vehicle coasts down a slope.
• The negative pressure of the brake booster has dropped.
• The defroster is turned on.
• The door is opened (for auto gearshift vehicle).
1. The seat belt is unfastened (for auto gearshift vehicle).

52RM30670

Beep This message appears in the display for manual transmission vehicle (with key-
(2 times from interior less push start system), if the gearshift lever is shifted to a position other than
buzzer) “N” (Neutral) without depressing the clutch pedal during an engine stall.
To restart the engine, place the gearshift lever in “N” (Neutral) position and
depress the clutch pedal.

52RM30690

5-43
OPERATING YOUR VEHICLE

Cruise Control (if equipped) Setting Cruising Speed Instrument cluster Type B
The cruise control system allows you to Cruise control switch
maintain a steady speed without keeping (6) (7) (8)
your foot on the accelerator pedal. The
controls for operating the cruise control (3)
system are on the steering wheel.
You can use the cruise control system (2)
under the following conditions: (1)
• For manual transmission vehicle, the
gear position is in 3rd, 4th or 5th.
• For auto gearshift vehicle, the gearshift
lever is in “D” position or the gear posi-
tion is in 3rd, 4th or 5th, in the manual 55T050080
mode. (6) Cruise indicator
• The vehicle speed is about 40 km/h or (7) “SET” indicator
higher. 56RM03017 (8) Set speed indication
(1) Cruise switch
WARNING (2) “CANCEL” switch
To help avoid loss of vehicle control, (3) “RES +/SET –” switch
do not use the cruise control system
when driving in heavy traffic, on slip- Instrument cluster Type A
pery or winding roads, or on steep
downhills.

(4) (5)

52RS30170

(4) Cruise indicator light


(5) “SET” indicator light

5-44
OPERATING YOUR VEHICLE

1) Turn on the cruise control system by Changing Speed Temporarily Changing Cruising Speed
pushing cruise switch (1). When the
cruise indicator light (4) (for instrument When the cruising speed is maintained, you Using the accelerator pedal
cluster type A), cruise indicator (6) (for can temporarily accelerate or decelerate. To reset at a faster cruising speed, acceler-
instrument cluster type B) comes on, ate to the desired speed using the accelera-
To accelerate, depress the accelerator
you can set cruising speed. tor pedal and push down the “RES +/SET –”
pedal. When you take your foot off the pedal, switch (3). The new speed will be main-
2) Accelerate or decelerate to the desired your vehicle will return to the set speed.
speed. tained.
3) Push down the “RES +/SET –” switch To decelerate, depress the brake pedal.
(3), “SET” indicator light (5) (for instru- The set speed will be canceled and “SET” Using the brake pedal
ment cluster type A), “SET” indicator (7) indicator light (5), “SET” indicator (7) will To reset at a slower cruising speed, decel-
(for instrument cluster type B) comes go off. erate to the desired speed using the brake
on. Also, set speed indication (8) (for To resume the previously set speed, push pedal and push down the “RES +/SET –”
instrument cluster type B) comes on at up the “RES +/SET –” switch (3) and turn switch (3). The new speed will be main-
the same time. Take your foot off the on “SET” indicator light (5), “SET” indicator tained.
accelerator pedal and the set speed will (7) again when vehicle speed is above 40
be maintained. km/h. The vehicle will accelerate to the NOTE:
previously set speed and maintain its When the brake pedal is depressed, “SET”
speed. indicator light (5), “SET” indicator (7) will
WARNING go off until you reset the cruising speed.
If the cruising speed is set by acci- NOTE:
dent, you cannot decelerate or could For automatic transmission vehicle, when Using “RES +/SET –” switch
loose control of the vehicle. This the cruising speed is maintained, you can- To reset at a faster cruising speed, press
could lead to an accident, resulting in not decelerate by using the engine brake repeatedly or hold push up the “RES +/
severe injury or death. even if you downshift from higher gear to SET –” switch (3). Vehicle speed will
Turn off the cruise control system 3rd in the manual mode. steadily increase. When you release the
and check that cruise indicator light To decelerate while the cruise control is switch, the new speed will be maintained.
(4), cruise indicator (6) or (8) is off on, depress the brake pedal or push down
when the system is not in use. To reset at a slower cruising speed, press
the “RES +/SET –” switch (3). repeatedly or hold push down the “RES +/
SET –” switch (3) until the vehicle has
NOTE: slowed to the desired speed, and then
Established cruising speed may differ a lit- release the switch. The new speed will be
tle from the speed meter indication maintained.
depending on the road conditions.

5-45
OPERATING YOUR VEHICLE

NOTE: To resume the previously set speed, push SUZUKI SAFETY SUPPORT
• You can adjust the set speed by approx- up the “RES +/SET –” switch (3) and turn
imately 1 km/h by pushing “RES +/ on “SET” indicator light (5), “SET” indicator (if equipped)
SET –” switch quickly. (7). The vehicle speed must be above 40
• When the current vehicle speed is about km/h when the vehicle is not under the Head-up Display
10 km/h or more faster than the previ- above conditions. Head-up display (HUD) will show the infor-
ously set speed, the cruising speed can- mation such us the current vehicle speed
not be decreased even if the “RES +/ To turn off the cruise control system, push and the gear position in the driver's front
SET –” switch (3) is pushed down. cruise switch (1) and check that the cruise vision.
• When the current vehicle speed is about indicator light (4), cruise indicator (6) is off.
10 km/h or more slower than the previ-
ously set speed, the cruising speed can- Also, if the malfunction indicator light in the (1)
not be increased even if the “RES +/ instrument cluster comes on or blinks, the
SET –” switch (3) is pushed up. cruise control system will be turned off.

Canceling Cruise Control NOTE: (2)


“SET” indicator light (5), “SET” indicator (7) If you turn off the cruise control system, the (4) (3)
will go off and the cruise control will be previously set speed in the memory is
canceled temporarily with the following cleared. Reset your cruising speed again.
conditions: (5) (6) (7) (8)
• Push “CANCEL” switch (2).
HUD
• Depress the brake pedal.
• For manual transmission, depress the clutch
pedal.
• For auto gearshift model, down-shift from 3rd to 55T050290

2nd gear in the manual mode. (1) Display


• The vehicle speed falls more than about (2) Cover
20 percent from the set speed. (3) Light-received surface
• Any time the vehicle speed falls below (4) Mirror
40 km/h. (5) Down switch
• When the vehicle skids and ESP® (if (6) Up switch
equipped) is activated. (7) Brightness control switch
(8) HUD (Head-up display) switch

5-46
OPERATING YOUR VEHICLE

NOTE:
WARNING NOTICE • If you wear your sunglasses, you may
have trouble seeing the displayed infor-
• Do not continue to look at the head- • Performing the following points mation. In this case, adjust the bright-
up display while driving. Other- may prevent the proper operations ness or take your sunglasses off.
wise, you may not find the vehicle, of the head-up display and result in • You may have trouble seeing the dis-
pedestrians or obstacles in front of its malfunction. Observe these played information in the following
you. This could result in an acci- points. cases.
dent. – Do not adjust the display angle – On a rainy day or a day with strong
• Adjust the display brightness and by your hands. Do not open or sunlight
position to your preference not to close the cover by your hands. – When driving on snowy roads or when
obstruct a safe driving. If adjust- – Do not place any object or drink a wet road is shining after the rain
ment is not performed properly, it on the cover, its peripheral part – When the headlights from your vehicle
could result in an accident. and the light-received surface. is reflected to the vehicle in front of
• Operate the head-up display while – Do not place stickers, etc. to the you at night
the vehicle is stopped. If you display, the inside of the cover – When the position of the vehicle in
attempt to operate the display while and the light-received surface. front of you and the displayed informa-
driving, you may not look ahead – Do not shine a strong light on the tion get overlapped
carefully. This could result in an light-received surface. – Depending on the driving posture
accident. • If you drop any object inside the • Under the very cold condition, the vehi-
cover, carefully pick it up not to cle speed on the speedometer and the
injure the part such as the mirror. one on the head-up display may differ a
CAUTION • Ask a Maruti Suzuki authorised little.
workshop, if you drop any object
When the head-up display is moving, inside the place where the head-up
do not put your hands closer to it. display is stored and you cannot
Your hands may get caught in it and pick up the object or the head-up
get injured. display is stuck inside.
• Do not wipe the HUD cover force-
fully. When you wipe it off, use a
soft cloth.

5-47
OPERATING YOUR VEHICLE

• When the head-up display gets hot, such Operation of the head-up display
as after parking the vehicle under the
blazing sun, the displayed information Operate the head-up display while the
(1) (2) vehicle is stopped. You cannot adjust the
may temporarily become dark for its pro-
tection. When the head-up display gets brightness and the displayed position while
hotter, the displayed information will driving.
temporarily disappear and the message
Head-up display operation switch
will be shown on the information display
of the instrument cluster.
– When the temperature becomes low,
the above condition will be canceled.
However, if the above condition is (3) (4) (5) (6)
kept, ask a Maruti Suzuki authorised
55T050750
workshop.
– You can turn off the message on the (1) Vehicle speed
information display in high tempera- (2) Standard display
ture by changing the setting (customi- (3) Gear position indicator (for Auto Gear (1) (2) (3) (4)
zation). For details, refer to "Setting shift vehicles) (if equipped)
Mode" in "INSTRUMENT CLUSTER" (4) Clock HUD
section. (5) Cruise indicator (if equipped)
(6) “SET” indicator (if equipped)
When you press the engine switch to ACC 55T050310

Activation of the head-up display or LOCK (OFF) mode, the head-up display (1) Down switch
will be automatically stored. (2) Up switch
When you press the engine switch to ON
(3) Brightness control switch
mode and the engine starts, the head-up NOTE: (4) HUD (Head-up display) switch
display will automatically appear and the • Even if you stop the engine, the display
following information will be displayed as setting will be stored.
necessary. • The vehicle speed on the head-up dis-
play and the one on the speedometer
may differ a little.
• You can turn off a part of the information
by changing the setting (customization).

5-48
OPERATING YOUR VEHICLE

ON / OFF operation of the head-up display NOTE: Brightness control


If you press and hold the HUD (Head-up • For ON / OFF operation of the intersec- Brightness of the display will be automati-
display) switch (4) with the engine on, you tion guidance display, you need to cally adjusted depending on the surround-
can make the head-up display appear or change the setting on the information ing conditions. You can adjust the
store. display. For details, refer to “Setting brightness to your preference by the fol-
Mode” in “INSTRUMENT CLUSTER” lowing steps.
NOTE: section.
• The intersection guidance display on the 1) Press the brightness control switch (3).
If you store the head-up display inside by
head-up display and the one on the nav- 2) To make the display brighter, press
operating the HUD (Head-up display)
igation system may differ a little. “ ” of the up switch (2). To make the
switch and stop the engine, the head-up
display will not appear automatically on the display darker, press “ ” of the down
next engine start. *1: Android AutoTM may not be available in switch (1).
your country or region.
ON / OFF operation of the intersection For details about Android AutoTM, refer to
guidance display (When using Android http://support.google.com/androidauto
AutoTM*1 or Apple CarPlay*2 on infotai- *2: Apple CarPlay may not be available in
ment system) your country or region.
For details about Apple CarPlay, refer to
https://www.apple.com/ios/carplay/

55T050770

(5)
55T050760

(5) The intersection guidance display


(The above image is an example of
Apple CarPlay.)

5-49
OPERATING YOUR VEHICLE

NOTE: Displayed information of the head-up


• You can adjust brightness of the display display
from 10 to +10 (21 levels) by the bright-
Activation / ending of the head-up display (1)
ness control switch.
• Depending on brightness which was When turn the ignition switch to “ON” posi-
automatically adjusted, you may not be tion or you press the engine switch to ON
able to make the display brighter or mode, the head-up display will automati-
darker. cally activate and the following images will
• Regardless of the driver's seat condi- be displayed by turns.
(2)
tions, brightness may be automatically
changed in the following conditions.
– When driving in a tunnel or around its
gateway
– When driving on a road where there is
a structural object over your head (3)
Adjustment of the displayed position
Press the down switch (1) or up switch (2) 55T050790 55T050800
to adjust the displayed position of the (1) Vehicle speed
head-up display. Standard display of the head-up display (2) Instantaneous fuel consumption
(3) Tachometer
Every time you press the HUD (Head-up
display) switch, the displayed information NOTE:
will be changed as follows. • Even if you stop the engine, the display
• The following images are typical exam- setting will be stored.
ples; they depends on the vehicle type. • The vehicle speed on the head-up dis-
play and the one on the speedometer
may differ a little.
55T050780 When operating the air conditioner
NOTE: If you operate the air conditioner with
• You can adjust the displayed position of instantaneous fuel consumption, tachome-
the head-up display from 12 to +12 (25 ter displayed, the following images will be
levels) by the up/down switch. displayed.

5-50
OPERATING YOUR VEHICLE

83S05811 83S05830

When you press “AUTO” switch, “AUTO” When you operate the blower speed selec-
and the set temperature will be displayed tor, the blower speed will be displayed for a
for a certain time. certain time.

NOTE:
• When the vehicle speed is displayed in
standard display of the head-up display,
the air conditioner setting will not be dis-
played.
• You can hide the information of air con-
ditioner by the setting mode on the infor-
mation display. For details, refer to
83S05821
“Setting Mode” in “INSTRUMENT CLUS-
When you operate the temperature selec- TER” section.
tor, the set temperature will be displayed
for a certain time.

5-51
OPERATING YOUR VEHICLE

Interrupt display
When there is the information to tell you and you press the engine switch to ON mode, the following interrupt display will appear.
Depending on the type of the display, a buzzer may sound at the same time.
• The following images are typical examples; they depends on the vehicle type.
Display Buzzer Description
Chime (Once) When one of doors, the bonnet or the fuel lid is not com-
(Only when one of the pletely closed, the interrupt display will appear. For the
doors is not completely vehicles with the power sliding door, if you are driving
closed) your vehicle, stop the vehicle in a safe place and close
the door completely.

55T050810

3 beeps repeating at short When the parking brake is not released while driving, the
intervals interrupt display will appear. Stop the vehicle in a safe
place and release the parking brake.

55T050820

Chime (Once) When the fuel level is low, the interrupt display will
appear. Refill the fuel tank as soon as possible.

55T050830

Chime (Once) When the CNG level is low, the interrupt display will
appear. Refill the CNG tank as soon as possible.

55T050831

5-52
OPERATING YOUR VEHICLE

Display Buzzer Description


Beeping at short intervals The driver does not wear his/her seat belt. Stop the vehi-
cle in a safe place and wear your seat belt.
The front passenger does not wear his/her seat belt.
Wear the seat belt.

55T050840

– When outside temperature nears freezing, this interrupt


display will appear.

55T050850

Off The intersection guidance is displayed. (When using


Android AutoTM or Apple CarPlay on infotainment system)
For details, refer to “ON / OFF operation of the intersec-
tion guidance display” in this section.

55T051030

NOTE:
To turn off the intersection guidance display (When using Android Auto or Apple CarPlay on infotainment system), you can change the
setting on the information display. For details, refer to “Setting Mode” in “INSTRUMENT CLUSTER” section.

5-53
OPERATING YOUR VEHICLE

360 View Camera 㻔 if equipped㻕


The 360 view camera is the function which shows visual image for the surrounding of your vehicle on the infotainment system screen,
using the front camera, the side camera (left and right) and the back camera. This helps the driver improve visibility when the driver tries
to park your vehicle, go by an oncoming vehicle in a narrow road or start the vehicle with poor visibility for left and right sides of the vehi-
cle.
• Use the infotainment system which corresponds with the 360 view camera.

Camera positions

(3)

(2)

(1)
55T050330

(1) Back camera


(2) Front camera
(3) Side camera (under left and right outside rearview mirrors)

• Each camera in the above figure is a typical example; the actual equipment depends on the vehicle type.

5-54
OPERATING YOUR VEHICLE

WARNING
• The 360 view camera cannot reduce the driver's duty of care for driving operation. Use the 360 view camera only to pro-
vide driving assistance.
• The 360 view camera has limits and it may not show a person or an obstacle. Drive your vehicle slowly confirming the
safety of the backward and the surrounding conditions by directly checking with your eyes and mirrors. If you drive your
vehicle only by checking the 360 view camera, an accident may occur.
• The cameras are precision instruments. Do not apply excessive force to the cameras, disassemble them and modify
them. Also, do not pour hot water to the cameras and poke them with a stick to remove mud or frozen snow on the cam-
eras. Doing so may damage the cameras and cause a fire and malfunction.
• Do not use the 360 view camera, when the outside rearview mirrors are folded and any of front doors and the tailgate is
not closed. The image of the surrounding area may not be displayed properly and an accident may occur.

NOTICE
If you use the 360 view camera for a long period of time with the engine stopped, the lead-acid battery could run out. Do not
use the 360 view camera for a long period of time with the engine stopped.
NOTE:
• Rough indication lines of vehicle width will be displayed more widely, compared with an actual vehicle width. Drive your vehicle by directly
checking the safety of the surrounding conditions.
• With the outside rearview mirrors folded, if you try to display the image from the cameras, the following image (1) will be displayed on the screen.

(1)

55T051040

5-55
OPERATING YOUR VEHICLE

How to use the 360 view camera


3D view mode function
The 360 view camera will display the image of the surroundings with a view from the outside or the inside of the vehicle.

1) Press the engine switch to change the ignition mode to ON.


2) After the opening image was displayed, 3D view mode will be automatically displayed on the screen.

Pattern 1
(Default setting) Pattern 2

(1) (1) (3)

(2) (2)
The 360 view camera will display the The 360 view camera will display the
image of the surroundings with a view image of the surroundings with a view
from the outside of the vehicle. from the inside of the vehicle.
55T050120

3) For switching the current image to the image with a different view, touch the image switching button (1) on the screen. For temporarily
stopping the rotation of 3D view mode, touch the temporary stop or replay button (2). For restarting the rotation of 3D view mode,
touch the button (2) again.

5-56
OPERATING YOUR VEHICLE

NOTE:
• For manual transmission vehicle, if you press the camera switch (3) when the gearshift lever is in other than “R”, parking brake is
applied, and the vehicle is stopped, you can display 3D view mode.
• For Auto Gear Shift vehicle, if you press the camera switch (3) when the gearshift lever is in “N” position, the parking brake is applied
and the vehicle is stopped, you can display 3D view mode.
• You can change the display screen of 3D view mode by changing the setting.
• When you press the camera switch while the opening image is displayed, 3D view mode will end. If you display 3D view mode, follow
the procedure below.
3D view mode  Press the camera switch  Change the mode of display  Press the camera switch  End of 3D view mode
• When the engine switch is in ACC mode, 3D view mode will not be displayed on the screen.

5-57
OPERATING YOUR VEHICLE

Displaying the forward of the vehicle


1) Press the engine switch to change the (a) (b)
ignition mode to ON.
2) Manual transmission vehicle:
Shift the gearshift lever into a position
other than “R” while the parking brake
is released or the vehicle is in motion.
Auto Gear Shift vehicle:
There are following cases. (2) (2)
–Shift the gearshift lever into a posi-
tion other than “R” or “N”.
–Shift the gearshift lever into “N” when
the parking brake is released or the
vehicle is in motion.
3) Press the camera switch (1). “Top
image and forward image” (default set-
(c)
ting) will be displayed.

(2)

(1)

55T050360

(a)Top image and forward image (Default setting)


The 360 view camera will display the surrounding image and the forward image.
55T050890 (b)Forward wide image
4) Every time you touch the image switch- The 360 view camera will display the forward image widely.
ing button (2), the image will be (c)Side image and forward image
changed as follows: The 360 view camera will display the image under the front passenger's seat and the for-
ward image.
5-58
OPERATING YOUR VEHICLE

• When you press the camera switch, the current image will be changed to the previous image.
• Even when you do not press the camera switch, the current image will be changed to the previous image by the following methods:
– When 3 minutes passed after you press the camera switch
– When you operate the infotainment system
– When the vehicle speed becomes over about 10 km/h
• When the vehicle speed becomes over about 10 km/h and you press the camera switch, you can display the side image on the screen.
When the vehicle speed becomes about 10 km/h or less, the forward image will be displayed on the screen.

NOTE:
• For manual transmission vehicle, you can adjust the image quality and set up the initial display image when the gearshift lever is in
other than “R”, parking brake is applied and the vehicle is stopped.
• For Auto Gear Shift vehicle, you can adjust the image quality and set up the initial display image when the gearshift lever is in “N” posi-
tion, the parking brake is applied and the vehicle is stopped.
• When the engine switch is in ACC mode, the camera image will not be displayed.

5-59
OPERATING YOUR VEHICLE

Displaying the backward of the vehicle


1) Press the engine switch to change the ignition mode to ON.
2) Shift the gearshift lever into “R” (Reverse). “Top image and backward image” (default
setting) will be automatically displayed.
3) Every time you touch the image switching button (1), the image will be changed as fol-
lows:
(a)Top image and backward image
(a) (b) (Default setting)
The 360 view camera will display the sur-
rounding image and the backward image.

(b)Backward wide image


The 360 view camera will display the back-
ward image widely.
(1) (1)
(c)Side image and backward image
The 360 view camera will display the
image under the front passenger's seat
and the backward image.

(c) When you shift the gearshift lever other


than “R”, the camera image will return to
the previous one.

(1)

55T050370
5-60
OPERATING YOUR VEHICLE

NOTE:
• The backward image of the 360 view camera is displayed as the top priority out of all the images. However, when the infotainment sys-
tem itself is being activated, the backward image will not displayed.
• For manual transmission vehicle, you can adjust the image quality and set up the initial display image when the gearshift lever is in
other than “R”, parking brake is applied and the vehicle is stopped.
• For Auto Gear Shift vehicle, you can adjust the image quality and set up the initial display image when the gearshift lever is in “N” posi-
tion, the parking brake is applied and the vehicle is stopped.
• When the engine switch is in ACC mode, the camera image will not be displayed.

5-61
OPERATING YOUR VEHICLE

Error display on the screen


When there is an abnormality in the camera system, the following mark will be displayed
on the screen.
Consult a Maruti Suzuki authorised workshop to have the camera system inspected.

(1)

55T050380

(1) Error mark of camera system

5-62
OPERATING YOUR VEHICLE

Front and rear traffic alert


WARNING
(2) The front and rear traffic alert cannot
detect all the moving objects. Directly
check safety of the surroundings
with your eyes.

(1) NOTE:
You can change the setting of the front and
rear traffic alert.

(3)

(3)

55T050390

(1) Detected vehicle

While you park the vehicle in a parking lot or drive the vehicle at a very low speed, if a per-
son or a vehicle moves from the outside to the center in the detection area of the 360 view
camera, the buzzer of detection (the default setting is in OFF state) from the speaker will
sound and the support indicator (2) for checking left and right directions will come on. This
function informs the driver of necessity to confirm safety and evasive action such as
depressing the brake pedal.
When you reverse the vehicle, the information (3) which is detected by the rear parking
sensors will be displayed as well as the interior buzzer of detection sounds and the sup-
port indicator (2) for checking left and right directions comes on.

5-63
OPERATING YOUR VEHICLE

Examples which the front and rear traffic alert does not activate Situations where the front and rear traf-
fic alert does not activate
• When a person or a vehicle approaches
from front or straight behind of your vehi-
cle *1
• When a person or a vehicle does not
move *2
• When a person or a vehicle move from
the center to the outside on the screen *3
• When you do not park the vehicle in a
*2 parking lot or you do not drive the vehi-
*1 cle at a very low speed
*3 *3 • When there is a long distance between a
person or a vehicle to your vehicle
• When a moving object is not displayed
on the screen
• When the detected target object overlap
with strong light of sunshine and head-
lights
• When there is a big difference of camera
*5 image between a bright place and a dark
place on the screen
*4

59RN05470

5-64
OPERATING YOUR VEHICLE

Situations where the front and rear traf- Situations where the front and rear traf-
fic alert may not activate fic alert may activate by chance
• When a person or a vehicle approaches • When a person or a vehicle steps away
parallel to your vehicle *4 parallel from your vehicle *5
• When a labarum outside of a conve-
nience store or a street tree swings in
the wind
• When there is a wall or a shutter which
55T050420 has running wavy pattern, fences, white
• When it is difficult to detect a person or a lines, a metal lid such as a grating cover
vehicle which gets across at night, • When the lights from signs, the turn sig-
because there is no street lamp nal lights or the reversing lights of a vehi-
55T050410 cle or your vehicle are flashing nearby
• When the body color of a vehicle or the • When waterdrop or white smoke runs on
• When a small object such as a ball is cloths of a person that gets across is
moving a camera lens
similar to the background • When the road is wet and shiny or there
• When a moving object such as a bicycle are puddles after the rain
gets across at a high speed • When the brightness is changed by
• When a camera lens is dirty by spider's shadow of trees or buildings
web or mud • When your vehicle is severely inclined
• When a camera lens is misted • When a strong impact is applied to a
camera and its peripheral part and the
installed position of the camera is mis-
aligned
55T050430
• When the detection area is misaligned
• When a person or a vehicle moves at a by inclination on the road
higher place than the space which you
try to park your vehicle
55T050400 • When a tailgate is opened
• When visibility is poor due to snow, rain • When a strong impact is applied to a
or fog camera and its peripheral part and the
installed position of the camera is mis-
• When a camera lens is directly exposed aligned
to light from the sun or headlights • When the detection area is misaligned
by inclination on the road

5-65
OPERATING YOUR VEHICLE

How to understand the displayed items on the screen


The following guide lines and buttons will be displayed on the screen.
The guide lines would provide a rough indication for your driving operations.
Top image Forward or backward image Side image

(6) (5) (9) (5)

(10) (6) (10)


(8)
(1) (4)
(6) (6) (7) (10)
(4) (4)
(4)

(2) (3)
55T050510

• Each displayed item in the above figure is a typical example; it depends on the vehicle type.

No. Displayed item Contents

(1) This shows the position of your vehicle.

5-66
OPERATING YOUR VEHICLE

No. Displayed item Contents

This shows that the forward of your vehicle is displayed


and the front and rear traffic alert is activated.

This shows that the backward of your vehicle is displayed


and the front and rear traffic alert is activated.
By touching the button, you can
change ON/ OFF of front and rear traf-
fic alert.

This shows that the front and rear traffic alert is not acti-
(2)
vated.

This shows that you increases the vehicle speed and the front and rear traffic alert is not activated.

5-67
OPERATING YOUR VEHICLE

No. Displayed item Contents

This shows that there is abnormality in the front and rear traffic alert. Consult a Maruti Suzuki
(2)
authorised workshop to have the function inspected.

This shows that the top image and forward image are displayed.

This shows that the top image and backward image are displayed.

(3)

This shows that the forward wide image is displayed.

This shows that the backward wide image is displayed.

5-68
OPERATING YOUR VEHICLE

No. Displayed item Contents

This shows that the side image and forward image are displayed.

(3)

This shows that the side image and backward image are displayed.

No. Displayed color Item name Contents


Green or yellow Indication detected from the When the rear parking sensors detects a wall or an obstacle is revers-
(4)
or red rear parking sensors ing, this icon is displayed.
Indication of the support for
When a person or a vehicle moves from the outside to the center in
(5) Yellow checking left and right direc-
the detection area of a camera, this icon is displayed.
tions
In conjunction with your operations of the steering wheel, this shows
(6) Green Guide line for the course the guide line of predicted course when your vehicle moves forward or
backward. *

5-69
OPERATING YOUR VEHICLE

No. Displayed color Item name Contents


This shows the guide line of the position where is about 0.5 m (1.6 ft)
(7) Red forward or backward from the center of bumper front-end or bumper
back-end
This shows the guide line of the position where is about 1 m (3.3 ft)
(8) Yellow Guide line for the distance forward or backward from the center of bumper front-end or bumper
back-end.
This shows the guide line of the position where is about 2 m (6.6 ft)
(9) Light blue forward or backward from the center of bumper front-end or bumper
back-end.
*: When the steering wheel is in straight position, the top image and the guide line for the course of forward/backward movement will
not be displayed.
Guide line for the vehicle This shows the guide line of the position where is slightly outside of
width (vertical line) the vehicle width (including the width of outside rearview mirrors).
(10) Purple
Guide line for the vehicle This shows the guide line of the position where is the most front-end of
width (horizontal line) the vehicle.

• As each guide line is displayed towards road surface, the distance from your vehicle to an obstacle such as the parked vehicle near
your vehicle is not accurately displayed. Also, as the top image is displayed by processing the image based on a flat road surface, the
position of an obstacle (such as the bumper of the other vehicle) where is higher than the road surface is not accurately displayed.
• Trapezoidal guide lines for the distance and the vehicle width which are displayed on the screen are rough indications and they
depend on the actual distance and vehicle width.
• If you modify suspensions or replace a tyre by the undesignated tyre, the guide lines and the top image will not be accurately dis-
played.
• The buttons on the screen are displayed by pressing.

5-70
OPERATING YOUR VEHICLE

CAUTION
• The top image is the quasi-image which combines and processes several images from the cameras on the outside rear-
view mirrors, the forward of your vehicle and the backward of your vehicle. Therefore, the top image may be displayed
as follows:
– A steric object is displayed as if it is fell down.
– If the position of a steric object is higher than the road surface, the object is displayed farther away or it is invisible.
– A steric object is not displayed out of the screen or its position is misaligned.
• A steric object on the forward image or the backward image may not be displayed on the top image.
• On the top image, the lines on the road may be misaligned on the frame of screen or these lines may look bended. The
farther distance from your vehicle there is, the much misalignment the lines have.
• When the position of a camera is misaligned, the images or the guide lines may be misaligned. Ask a Maruti Suzuki
authorised workshop to have the camera inspected.
• On a snowy road or a slippery road surface, the guide line for the course and the actual course may be different.
• As the icon of vehicle on the top image is displayed by a computer graphics, it is different from color, shape and size of
the actual vehicle. Therefore, the position between your vehicle and the road surface or obstacles may be different from
the actual position.
• On the top image, the brightness of the image from each camera may vary depending on brightness conditions.
• After an image is switched to the other image, it may be displayed late. Until the 360 view camera is completely dis-
played, the image may be temporarily distorted.
• The camera of the 360 view camera uses a special lens. Therefore, the displayed distance and the actual distance may
look different and the target object may be displayed as a distorted image. The farther distance from your vehicle there
is, the much tendency these situations have.
• As the wide image displays a large range, it displays a significantly-distorted image. Also, the distance on the wide
image looks different from the actual distance.

NOTE:
When you activate the infotainment system or there is abnormality on the touch panel, you cannot operate the buttons. In this case, wait
for a while. Or, press a camera switch to go back to the original displayed screen, press a camera switch again and operate the buttons
while the screen is displayed.
If you cannot operate the buttons by performing the above procedure, Consult a Maruti Suzuki authorised workshop.

5-71
OPERATING YOUR VEHICLE

Difference between the camera image (3) Light blue, the point which the guide When there is an steric object near your
and the actual road surface line for the distance (about 2.0 m [6.6 vehicle
The position and distance which the guide ft]) shows In this case, the distance from your vehicle
lines on the screen shows vary depending to the steric object may be different from
on the number of passengers, the load When there is an downhill slope on the actual distance.
capacity, the inclination and situation on your movement direction
the road surface. Directly check safety of You will see the guide line for the distance Example 1:
the surroundings with your eyes. in the back of the actual distance.

When there is an uphill slope on your Backward image (Example):


movement direction
You will see the guide line for the distance (1) (2) (3)
in front of the actual distance.
Backward image (Example):

(1) (2) (3) (1)


About 0.5 m (1.6 ft)

About 1.0 m (3.3 ft)

About 2.0 m (6.6 ft)


About 0.5 m (1.6 ft)
55T050930

About 1.0 m (3.3 ft)


(1) Red, the point which the guide line for
the distance (about 0.5 m [1.6 ft])
About 2.0 m (6.6 ft) shows
55T050920 (2) Yellow, the point which the guide line
for the distance (about 1.0 m [3.3 ft])
(1) Red, the point which the guide line for shows 81M50590
the distance (about 0.5 m [1.6 ft]) (3) Light blue, the point which the guide In the illustration, the guide line for the
shows line for the distance (about 2.0 m [6.6 course (1) does not touch the body of the
(2) Yellow, the point which the guide line ft]) shows displayed truck. However, if the body of
for the distance (about 1.0 m [3.3 ft]) this truck protrudes on the actual course
shows which your vehicle will go, a collision may
occur.
5-72
OPERATING YOUR VEHICLE

Example 2: Displayed areas on the screen The image of view area by the 360 view
• The areas of next image will be dis- camera
played on the screen. However, the
areas around and under the front CAUTION
bumper and the rear bumper will not be
displayed. The specified areas will become blind
• The areas above a camera will not be spots which will not be displayed on
displayed. If an obstacle is high or the the screen. Make sure to directly
upper part of an obstacle protrudes, check the safety with your eyes.
such as a sign, the upper part will not be
(2) displayed on the screen.
• A feeling of distance on the image of the
360 view camera is different from the
actual distance.
• If there is an obstacle such as an parked
vehicle on the areas which are displayed
on the screen, it may be displayed differ-
ent from the actual distance.
• The backward image may be inverted on
the screen, which is the same as you
look the image on the inside rearview 55T050940
mirror or the outside rearview mirrors. • The areas under the front bumper and
• As the front camera and the back cam- the rear bumper or the ground surface
era are installed on the places which are which is indicated in the below illustra-
55T050550
a little misaligned from the center of your tion may not be displayed on the screen.
In the illustration, the top image (2) shows vehicle, the forward image and the back-
that there is a little distance between your ward image will be displayed with a little
vehicle and the body of the displayed misaligned positions.
truck. However, the actual distance is
shorter than the displayed distance and a
collision may occur.

5-73
OPERATING YOUR VEHICLE

• Under the following situations, it may be Change of setting


difficult for the driver to see the image of You can adjust the image quality or
the 360 view camera. However, it is not change the setting of the 360 view camera
malfunction. and the front and rear traffic alert.
– At night, on a rainy day or at a dark
place WARNING
– When the area around a camera is hot
or cold under the blazing sun or the If you do not change the setting in a
cold condition, or when humidity is safe place where there is nothing
high on a rainy day (A camera lens around your vehicle, an accident may
may be fogged) occur.
– When strong light directly streams to a Change the setting in a safe place
camera (White vertical lines may be where there is nothing around your
55T050520 vehicle.
displayed on the image)
• On the top image, an object near the – Under the lights such as the fluores-
edge of areas which a camera displays cent light (The image on the screen
and an object which is higher than the NOTICE
may flicker)
road surface may not be displayed on – When the outside air temperature is If you change the setting for a long
the screen. low (The screen may get dark) time with the engine off, the lead-acid
– When you park your vehicle for a long battery may run out.
NOTE: time with the engine on (Noise may be Change the setting with the engine
• The image of the 360 view camera may displayed on the image) on.
be a little different from the actual color. – When a camera lens is dirty or when
• If a moving object is displayed on the snow or waterdrop is attached to a
screen, its accidental image may be dis- camera lens
played as well.

5-74
OPERATING YOUR VEHICLE

Adjusting the image quality 4) 3D view mode image will be displayed. Setting of the 360 view camera and the
When you adjust the image quality, per- Press the button (2) for adjusting the front and rear traffic alert
form the following procedure: image quality. When you change the setting, perform the
1) Set the parking brake firmly. 5) Adjust brightness and contrast of the following procedure:
2) Press the engine switch to change the image to your preference. 1) Set the parking brake firmly.
ignition mode to ON. 2) Press the engine switch to change the
NOTE: ignition mode to ON.
• The figure of the set brightness varies
depending on ON/OFF condition of the
light.
• Refer to the owner’s manual of infotain-
ment system for details.

(1)
(1)

55T050890
55T050890
3) After the opening image is finished,
press a camera switch (2)
3) After the opening image is finished,
press a camera switch (1).

(2)
55T050530

5-75
OPERATING YOUR VEHICLE

(4)

(3)
3)
55T050540

4) 3D view mode image will be displayed.


Press the button (3) for the setting.

59RN05661

5) Touch the indication (4) to perform the


setting of the 360 view camera. Change
the setting to your preference. To
switch to the different page, press or
.

5-76
OPERATING YOUR VEHICLE

• The image in the above figure is a typical example; it depends on the vehicle type.

Indication Function
You can select one of the following guide lines:
• Hiding guide lines
• Displaying rudder-interlocked guide lines
Guideline display • Displaying fixed guide lines

59RN05501

As the image to check the forward area of your vehicle, you can
select one of the following images:
• Top image and forward image (default setting)
• Forward wide image
• Side image and forward image
59RN05502

As the image to check the backward area of your vehicle, you


can select one of the following images:
• Top image and backward image (default setting)
• Backward wide image
• Side image and backward image
59RN05503

You can select to display or hide 3D view mode which is auto-


matically displayed on activation.

59RN05530

When you shift the gearshift lever from “R” to the other position
than “P”, you can select to display or hide the camera image
which is automatically displayed.

59RN05504

5-77
OPERATING YOUR VEHICLE

(5)

55T051021

6) Touch the indication (5) to perform the setting of the front and rear traffic alert. Change the setting to your preference.
• The image in the above figure is a typical example; it depends on the vehicle type.
Indication Function
You can select ON/OFF condition of the front and rear traffic alert.

59RN05550

You can select one of the following detecting levels.

High: Normal level Low: Low level


59RN05560

You can select ON/OFF condition of sound (buzzer) for the above-
mentioned function. (The default setting is in OFF state.)

59RN05570

5-78
OPERATING YOUR VEHICLE

Handling a camera When you doubt malfunction of camera When the image and the guide lines are
misaligned
CAUTION When the error mark of camera system In the following case, the image and the
is displayed on the screen guide lines will be misaligned. However,
When you strike a camera or its When the error mark is displayed on this is not malfunction.
periphery, the image may not be dis- the screen, there is abnormality in the • Your vehicle is tilted due to the number
played properly. Ask a Maruti Suzuki camera system. of passengers and baggage.
authorised workshop to have the • If the error mark does not disappear, ask
camera inspected. a Maruti Suzuki authorised workshop to
have the camera system inspected.
NOTE:
• When you replace a camera with new When the image quality on the 360 view
one, adjustment is necessary. Ask a camera is poor
Maruti Suzuki authorised workshop for • When a camera lens is dirty, you may
adjustment. have difficulty to see the image. If water-
• Do not attach any object which prevents drop, snow or dirt is attached to the cam-
the camera's activation to the camera era lens, wash it with water and wipe it
and its periphery. You cannot attach the off with a soft cloth. If the camera lens is
backlit license plate. heavily dirty or wax is attached to the
camera lens, use a mild detergent.
• When reflected light from strong sun or
strong headlights from the vehicle
behind your vehicle streams directly to a
camera, white lines may be displayed on
the image and you may have difficulty to
see the image. However, this is not mal-
function.

5-79
OPERATING YOUR VEHICLE

License Information
The software in the 360 view camera includes open software. The license information is as follows:

79R40530

5-80
OPERATING YOUR VEHICLE

Parking Sensors • The parking sensor system uses ultra-


Instrument cluster (Type A) sonic sensors to detect obstacles near WARNING
the rear bumper. If obstacles are sensed
while you are parking or moving the • The parking sensor warns you of
vehicle slowly, the system warns you by obstacles with buzzers and by
sounding a buzzer and displaying sym- showing you the location of the
bols representing the obstacles on the obstacles on the information dis-
information display in the instrument play. However, you must still pay
cluster. full attention yourself while driving.
• The system emits an ultrasonic wave • The sensors can detect obstacles
and the relevant sensor detects the only within a limited area and only
return of the wave reflected by an obsta- when the vehicle is moving within a
cle. The system measures the time limited speed range. So, in tricky
(1) taken by the ultrasonic wave to reach areas, you must move the vehicle
the obstacle and return from it, from slowly while checking around it
55T050090
which it determines the obstacle’s posi- using your direct vision or rearview
Instrument cluster (Type B) tion. mirrors. There is increased risk of
• The parking sensor function can be used an accident if you control the vehi-
when you turn the ignition switch to “ON” cle relying only on the parking sen-
position or the engine switch is pressed sor.
to change the ignition mode to “ON”, the
gearshift lever is in the “R” position. This NOTICE
function is helpful in the following cases:
pulling over to the curb; parallel-parking Parking sensors are only for driver’s
the vehicle; steering the vehicle into a assistance.
garage; driving along an alley; and mov-
ing slowly in a place with obstacles. NOTE:
(1) When the gearshift lever is shifted to the
55T050860
“R” position, a buzzer will sound once.
(1) Symbol representing an obstacle
detected by parking sensor*
* This symbol shows that an obstacle is
located on the right rear of vehicle.

5-81
OPERATING YOUR VEHICLE

Sensor Locations Working sensors


The sensors work depending on the gearshift lever position as follows:

Gearshift lever Manual transmission Auto Gear Shift Parking


position R N, 1st – 5th R N, D or M brake lever

Rear sen- Center On Off On Off No relation


sors Corner On Off On Off No relation

(2) (1) (1) (2)


(
55T050570

(1) Rear center sensors (2 places)


(2) Rear corner sensors (2 places)

NOTICE
• Avoid hitting the sensor areas or
directing the nozzle of a high-pres-
sure car washer onto the sensor
areas. Otherwise, the sensors may
be damaged.
• If the bumper hits a hard object, the
sensors on it may not work prop-
erly. If this occurs, have the sen-
sors inspected by a Maruti Suzuki
authorised workshop.

5-82
OPERATING YOUR VEHICLE

Approximate areas where obstacles


can be detected WARNING WARNING
• Under the following conditions, the (Continued)
parking sensor system may not – Sensors have intercepted ultra-
work normally because the sensors sonic noise from another vehi-
cannot detect obstacles correctly. cle’s horn, engine, air braking
– Sensors are covered with mud, system (large vehicles), or park-
ice or other materials (Such ing sensor.
materials must be removed for – Obstacles are too close to the
normal operation). sensors.
– Sensors are wet from water – Sensors are at an angle to a
splashes or heavy rain. highly reflective object such as
– Sensors are covered by a hand, glass (Ultrasonic waves are not
sticker, accessory, etc. reflected back from the obstacle).
– There is an accessory or other • Sensors may not be able to cor-
55T050580 object attached within the sen- rectly detect the following types of
• An obstacle within about 20 cm (8 in) sor’s sensing area. obstacles:
from a sensor or just below a sensor is – Items such as tow hooks, com- – Objects made of a thin material
not detectable. mercially available corner poles, like wire netting and ropes.
• The sensors can detect obstacles such radio antenna, etc. are installed – Square-shaped curbstones or
as a wall up to about 1.5 m (5 ft) from the on the bumper. other objects with sharp edges.
rear of vehicle. – The height of the bumper is – Tall objects with a large upper
changed due to alteration to the part like a road sign.
suspension or other causes. – Low-profile objects such as curb-
– The sensor areas are extremely stones.
hot from direct sunlight or cold – Sound-absorbing objects such
due to freezing weather. as cotton and snow.
– The vehicle is on a rough sur-
face, slope, gravel road or grass
field.
– The vehicle is at a steep angle.
(Continued)

5-83
OPERATING YOUR VEHICLE

NOTE:
• Thin poles or obstacles lower than the
sensors may become undetectable as
the vehicle moves closer to them even if
they have been detected from longer
distances.
• The system may calculate the distance
to a road sign or similar obstacle to be
shorter than the actual distance.

5-84
OPERATING YOUR VEHICLE

Obstacle Indication by Parking Sen- Upon detecting an obstacle, the parking sensor causes an interior buzzer to sound and a
sor symbol representing the obstacle appears on the information display in the instrument cluster.
• A different symbol is displayed depending on the direction and distance of the obstacle.
Instrument cluster (Type A) • A buzzer located behind the rear seat sounds when a sensor at the rear detects an
obstacle.
• Warnings when obstacles are detected by rear sensors
Distance (approx.) Buzzer Symbol
Center 60–150 cm Short beeps at long intervals
sensors (24–59 in)
Three lines
45–60 cm Short beeps at short intervals
(18–24 in)
35–45 cm Short beeps at very short intervals Two lines
(14–18 in)
(2) (1) (2) Less than 35 cm
Continuous beep One line
55T050100
(14 in)
Instrument cluster (Type B) NOTE:
• Symbols are displayed with a short delay after the detection of obstacles.
• If the system detects multiple obstacles simultaneously, the display shows all of their
positions using the corresponding symbols. However, the buzzers will sound only for
the nearest obstacles.

(2) (1) (2)


55T050870

(1) Obstacle detected by rear center sen-


sors
(2) Obstacle detected by rear corner sen-
sors

5-85
OPERATING YOUR VEHICLE

Warning and Indicator Messages Vehicle with Instrument Cluster (Type B)


If there is a problem or warning regarding the parking sensor system, a message is dis-
Vehicle with Instrument Cluster (Type played on the information display in the instrument cluster, and a symbol blinks and the
A) buzzer sounds. If a message is displayed, follow its instruction.
If there is a problem or warning regarding
the parking sensor system, a buzzer and
the status of the indicator on the parking Message Symbol Probable cause and remedy
sensor inform it. Follow its instruction.
• The buzzer sounds intermittently. The Two blinking lines There may be a problem with the park-
indicated sensor is contaminated. Wipe in a sensor loca- ing sensor system.
it clean with a soft cloth. If the buzzer tion Have your vehicle inspected by a Maruti
does not stop after wiping, there may be Suzuki authorised workshop.
problem with the parking sensor system.
Have your vehicle inspected by a Maruti
Suzuki authorised workshop.

One blinking line The indicated sensor is contaminated.


in a sensor loca- Wipe it clean with a soft cloth.
tion

5-86
OPERATING YOUR VEHICLE

Rearview Camera
NOTICE NOTICE
(if equipped)
If you use the rearview camera for a The rearview camera is a precision
When the gearshift lever is shifted to “R” long time when the ignition switch is instrument. If you strike the camera,
position while the ignition switch is in “ON” in “ON” position or the ignition mode it may be broken and cause damage
position or the ignition mode is “ON”, the is ON, but the engine is not running, resulting in a catch fire or a malfunc-
rearview camera system automatically the battery may discharge. tion.
shows the view behind the vehicle on the Do not leave the ignition switch in • Do not strike the camera.
display. “ON” position or the ignition mode to • Do not remove snow or mud on the
ON for a long time when the engine is camera lens with a stick.
WARNING not running.
The distance viewed in the rearview NOTICE
camera may differ from the actual
distance according to the condition Rearview Camera Location If water enters the rearview camera, it
of road or the load the vehicle is car- may cause a malfunction or catch
rying. Since the camera display area fire.
is also limited, backing up by only Do not use high pressure water
looking at the display may cause an around the camera.
accident or a crash with an object.
The rearview camera cannot replace
the driver’s attention. The driver NOTICE
alone is responsible for parking and This lens is hard coated to prevent
similar driving maneuvers. damage or discoloration. Damage or
• Use the rearview camera only to discoloration of lens may obscure
provide driving assistance. (1) the image.
• Always drive carefully confirming • Do not use a brush to clean lens.
the safety of the rear and the sur- • Do not use alcohol, benzene or
rounding conditions by looking thinner to clean the lens.
55T050600
directly with your eyes and using • Do not use wax on the camera lens.
the rear view mirror. (1) Rearview camera
• Check that the trunk lid is securely NOTE:
closed when backing up. The rearview camera is installed on the
tailgate. If body wax gets on the camera lens, wipe
off the wax with a clean cloth dampened
with mild detergent diluted with water, and
then wipe the lens with a dry cloth.
5-87
OPERATING YOUR VEHICLE

How to use rearview camera Display range of rearview camera NOTE:


1) Turn the ignition switch to “ON” position • Images shown on the display from the
or press the engine switch to change rearview camera are reversed images
the ignition mode to “ON”. (mirror images).
2) Shift the gearshift lever in “R” position. • The colors of objects on the rearview
• The display automatically shows the (1) camera may differ from the actual object
view behind the vehicle. colors.
• When the gearshift lever is shifted • The rearview camera display may be dif-
from “R” to another gearshift lever ficult to see under the following condi-
position, the display returns to the tions, but this is not a system
previous display. malfunction.
– In dark areas, on a rainy day or at
NOTE: night.
The rearview camera display has first pri- – When the temperature around the lens
ority in any display mode. However, the 55T050610
is too high/low, or the camera is wet
rearview camera display does not show such as on a rainy day or during peri-
the rear view while the system is initializ- ods of high humidity (dew condensa-
ing. tion may occur on the camera lens).
(1) – When a foreign object such as mud or
a drop of water is stuck around the
Display Range of Rearview Camera camera lens.
The rearview camera display shows the – When strong light directly enters the
area behind the rear end of the bumper. camera (vertical lines may be seen on
The display cannot show objects which are the display).
close to the bumper or under the bumper. – Under fluorescent light (The display
The rearview camera display cannot show may flicker).
obstacles which are higher than the cam- – When the outside temperature is low
era. Upper parts of tall objects such as (the image on the display may be
road signs cannot be viewed on the dis- darkened).
play.
55T050620 Rearview camera screen indication
(1) Display range The distance viewed in the rearview cam-
era may differ from the actual distance
according to the condition of the road or
the load the vehicle is carrying.

5-88
OPERATING YOUR VEHICLE

Uphill incline behind the vehicle When there is a downhill incline behind the Electronic Stability Program
vehicle, the object shown on the display
(1) appears closer than the actual distance. (ESP®) (if equipped)
ESP® is a registered trademark of Daimler
If the rear view from the rearview cam- AG.
era is not shown or there is a poor
image The Electronic Stability Program (ESP®)
• If the rear view from the rearview camera helps to control the vehicle during corner-
(2) is not shown. ing if front wheels or rear wheels skid. It
(3) – Check that the ignition switch is in also assists you in maintaining traction
“ON” position or the ignition mode is while accelerating on loose or slippery
55T050630 road surfaces. It does this by regulating
“ON”.
(1) Object – Check that the gearshift lever is the engine’s output, and by selectively
(2) Actual distance shifted to “R” position. applying the brakes. In addition, ESP®
(3) Distance on the display helps to avoid skidding by controlling brak-
• If the image from the rearview camera is ing pressure.
When there is an uphill incline behind the poor.
vehicle, the object shown on the display – Check that the camera lens is not dirty. WARNING
appears farther away than the actual dis- – Check that light from the sun or the
tance. The ESP® cannot enhance the vehi-
beam of the headlights from the vehi-
cle’s driving stability in all situations
Downhill incline behind the vehicle cle behind is not shining directly into
and does not control your vehicle’s
the lens.
entire braking system. The ESP® can-
(1) not prevent accidents, including
If the rearview camera system is still not
those resulting from excessive speed
working properly after checking the above,
in turns, or hydroplaning. Only safe
have the system inspected by a Maruti
and attentive drive can prevent acci-
Suzuki authorised workshop as soon as
dents.
possible.
(3) The capabilities of an ESP®-equipped
vehicle must never be used as a sub-
(2) stitute for careful driving.
55T050640

(1) Object
(2) Actual distance
(3) Distance on the display

5-89
OPERATING YOUR VEHICLE

The ESP® has the following systems: Stability Control System


The vehicle stability control system helps CAUTION
Anti-lock Brake System (ABS) provide integrated control of systems such
Refer to “Anti-lock Brake System (ABS)” in • Observe the following points. Oth-
as anti-lock brakes, traction control, engine
this section. erwise, ESP® may not operate
control, etc. This system automatically
properly or it may result in a mal-
controls the brakes and engine to help pre-
function.
vent the vehicle from skidding when cor-
Brake Assist System nering on a slippery road surface or when
– Adjust the tyre pressure as spec-
Refer to “Brake Assist System” in this sec- ified.
turning the steering wheel abruptly.
tion. – When replacing tyres, use the
same tyres with the size, type,
WARNING and tread patterns.
Traction Control System Always check the surrounding condi- – Do not use the tyres which have
The traction control system automatically tions and drive the vehicle in a safe excessively worn conditions.
helps prevent the spinning of wheels when manner, as controlling the vehicle by – Do not modify the suspension or
the vehicle is started or accelerated on ESP® has limits and ESP® may not the brake and do not change
slippery road surfaces. The system oper- function properly depending on the vehicle height or suspension
ates only if it senses that some of the surrounding conditions. hardness.
wheels are spinning or beginning to lose – Do not drive the vehicle with sus-
traction. When this happens, the system pension or brake excessively
operates the front or rear brakes and deteriorated.
reduces engine power to limit wheel spin. – Do not modify the engine or the
muffler.
– Do not install LSD (limited slip
differential).
• When you install the snow chains,
ESP® may not operate properly.

5-90
OPERATING YOUR VEHICLE

NOTE: ESP® Warning Light (if equipped) • If any of the following situations occurs,
• If you perform the following operations, this light will blink at very short intervals
you may hear an operation sound or a of 0.2 seconds.
clicking sound. This means that the – Traction control system is activated
ESP® system is in the self-check mode when starting or accelerating the vehi-
and this does not indicate a malfunction. cle
– When ignition switch is turned to the – Stability control system is activated
“ON” position or pressing the engine when making a sharp turn or whirling
switch to change the ignition mode to round
“ON”
– When releasing your foot from the • If the system is in normal condition,
brake pedal, after the ignition switch is when you turn the ignition switch to “ON”
in “ON” position or the ignition mode is position or press the engine switch to
“ON” with the brake pedal depressed change the ignition mode to ON, this
– When starting the engine light will come on for about 2 seconds
– When starting the vehicle after starting 55T050670 and then come off.
the engine • If there is a problem in the ESP® system
– When engine revolutions is high and with the ignition switch in “ON” position CAUTION
ESP® operates, you may feel the or the engine switch in ON mode, this
change of engine revolutions or vibra- If this light blinks at very short inter-
light will come on. While this light comes vals, there is high possibility that the
tion of vehicle body. However, this is on, the following situations will occur. In
normal. vehicle will be stuck or skid on a slip-
this case, ask a Maruti Suzuki autho- pery road surface. In this case, drive
rised workshop for inspection. the vehicle very carefully.
– The following functions will not work:
- Traction control system NOTE:
- Stability control system While this light comes on, traction control
- ENG A-STOP system (if equipped) system and stability control system will not
– Hill hold control system (if equipped) be activated. However, you can use ABS.
may not work.
– ABS will work.
– Depending on the malfunction condi-
tion, brake assist system may not
work.

5-91
OPERATING YOUR VEHICLE

– Pressing the ESP® OFF switch again


ESP® OFF Switch (if equipped) – Stopping the engine and then restart- ESP® OFF Indicator Light
ing the engine (if equipped)
• If you would like to perform normal driv-
ing after escaping from the stuck condi-
tion, press the ESP® OFF switch again.
This will allow the ESP® OFF indicator
light to come off and the vehicle will
return to the original condition. Traction
control system and stability control sys-
tem will not be activated automatically.
(except when stopping the engine and
then restarting the engine)

NOTE:
55T050690
For safety reasons, even if you press the
ESP® OFF switch, ABS and brake assist 55T050710
• In the following situation, keep pressing system will not be deactivated. • If you press and hold the ESP® OFF
the ESP® OFF switch until the ESP®
OFF indicator light in the instrument switch with the ignition switch is in “ON”
cluster comes on. Traction control sys- position or the ignition mode is “ON”, this
tem and stability control system will not light will come on.
work. – While this light comes on, traction con-
– When placing the vehicle on the tester trol system and stability control system
for automobile inspection, traction will not work.
control system and stability control • If the system is in normal condition,
system needs to be deactivated. when you turn the ignition switch to “ON”
– If your vehicle is stuck and you try to position or press the engine switch to
get out of the stuck condition, traction change the ignition mode to ON, this
control system may not be suitable. light will come on for about 2 seconds
• If you perform the following operations, and then come off.
the ESP® OFF indicator light will come
off. Also, traction control system and sta-
bility control system will return to be in
the activated condition.

5-92
OPERATING YOUR VEHICLE

Hill Hold Control System NOTE:


(if equipped) WARNING • If there is a problem with the hill hold
control system, the ESP® warning light
The hill hold control system is designed to • Always check the surrounding con- in the instrument cluster may come on
assist you in starting to move up hills. ditions and drive the vehicle in a and the hill hold control system may not
When you start to move up a hill, the sys- safe manner by depressing the work. Also, ENG A-STOP system (if
tem helps to prevent the vehicle from roll- brake pedal as necessary, as con- equipped) may not work. In this case,
ing downward (for approximately 2 trolling the vehicle by the hill hold consult a Maruti Suzuki authorised work-
seconds) while you move your foot from control system has limits and the shop.
the brake pedal to the accelerator pedal. system may not function properly • If you move up an excessively sharp
• The hill hold control system is not depending on the surrounding con- slope, a frozen road or a mud track, or
designed to stop the vehicle on a hill. ditions. depending on laden weight, the vehicle
• If you do not depress the brake may roll downward when you start the
pedal firmly enough, the hill hold vehicle.
control system may not work. • If you move up an excessively sharp
• If you release your foot from the slope, a frozen road or a mud track and
brake pedal for more than 2 sec- the hill hold control system activates, the
onds, the hill hold control system tyres may be locked and the vehicle may
will be canceled. If so, the vehicle not be controlled properly.
may roll downward, which can
result in an accident depending on
the degree of a slope. Also, the
engine may stall and the power
assist for the steering and brakes
will not work so steering and brak-
ing will be much harder than usual
55T050670 which can result in an accident or
vehicle damage. After you release
your foot from the brake pedal,
accelerate the vehicle to move up
immediately.

5-93
OPERATING YOUR VEHICLE

Activation conditions for the hill hold Braking


control system WARNING
The hill hold control system activates to
prevent the vehicle from rolling downward If water gets into the brake devices,
for about 2 seconds if your foot is moved brake performance may become poor
from the brake pedal when the following and unpredictable. After driving
conditions are all met. through water or washing the under-
side of the vehicle, test the brakes
• The gearshift lever is in the forward gear while driving at a slow speed to see if
or reverse position. they have maintained their normal
• The parking brake is released. effectiveness. If the brakes are less
• The vehicle is on an upward slope. effective than normal, dry them by
• The brake pedal is depressed firmly. repeatedly applying the brakes while
For the vehicles with ENG A-STOP system driving slowly until the brakes have
(if equipped), the hill hold control system is regained their normal effectiveness.
activated when the engine is restarted
after being stopped automatically, even if 59RN05770
the previous conditions are not met. The distance needed to bring any vehicle
to a halt increases with the speed of the Power-assisted Brakes
NOTE: Your vehicle has power-assisted brakes. If
vehicle. The braking distance needed, for
When the hill hold control system is acti- power assistance is lost due to a stalled
example, at 60 km/h will be approximately
vated, you may hear a sound coming from engine or other failures, the system is still
4 times greater than the braking distance
the engine, or you may feel hardness of fully operational on reserve power and you
needed at 30 km/h. Start to depress the
the brake pedal. These are normal and do can bring the vehicle to a complete stop by
brake pedal when there is plenty of dis-
not indicate a malfunction. pressing the brake pedal once and holding
tance between your vehicle and the stop-
it down. The reserve power is partly used
ping point, and slow down gradually.
up when you depress the brake pedal and
NOTE: reduces each time the pedal is pressed.
While braking you may hear operational Apply smooth and even pressure to the
noise due to friction between brake disc/ pedal. Do not pump the pedal.
drum and brake lining. This is a normal
phenomenon and does not indicate any
abnormality or affect normal functioning of
the vehicle.

5-94
OPERATING YOUR VEHICLE

Anti-lock Brake System (ABS) above systems are in the self-check


WARNING ABS will help you avoid skidding by elec- mode. This sound does not indicate a
tronically controlling braking pressure. It malfunction.
Even without reserve power in the
brake system, you can still stop the will also help you maintain steering control
vehicle by pressing the brake pedal when braking on slippery surfaces or when
harder than normally required. How- braking hard. Braking Distance
The ABS works automatically, so you do ABS is not designed to shorten the stop-
ever, the stopping distance may be ping distance.
longer. not need any special braking technique.
Just push the brake pedal down without
pumping. The ABS will operate whenever WARNING
it senses that the wheels are locking up. • In the following situations, the
Brake Assist System You may feel the brake pedal move a little braking distance required for a
When you slam the brakes on, the brake while the ABS is operating. vehicle with ABS may be slightly
assist system determines it to be an emer- greater than the one required for a
gency stop and provides more powerful WARNING vehicle without ABS, resulting in an
braking for a driver who cannot hold down accident. Drive the vehicle slowly
the brake pedal firmly. • Always check the surrounding con-
ditions and drive the vehicle in a and maintain ample distance
safe manner, as controlling the between your vehicle and the vehi-
NOTE: cle in front of you.
If you quickly and forcefully depress the vehicle by ABS has limits and the
system may not function properly – When driving on rough roads
brakes, you may hear clicking sound by such as unpaved or stone-paved
the brake assist system operation. This is depending on the surrounding con-
ditions. roads
normal and indicates that the brake assist – When driving on gravel roads or
system is activated properly. • If tyre grip performance is over the
limit or hydroplaning occurs, ABS fresh snow roads
cannot work properly. – When driving over bumps on the
roads such as joint seams
– When passing over metal plates
NOTE: such as manholes
• If the ABS system is activated, you may – When snow chains are installed
hear a clunking noise and/or feel pulsat-
ing in the brake pedal. This is normal
and indicates that the brake fluid pres-
sure is being controlled properly.
• You may hear an operation sound when
you start the engine or after the vehicle
begins to move. This means that the
5-95
OPERATING YOUR VEHICLE

NOTE: Situations where ABS may Activate


• When applying sudden brake or apply- Tyres by Chance when Applying Brake
ing brake on slippery roads, the braking
distance required for a vehicle with ABS • When driving on slippery roads
WARNING
is almost the same as the one required
for a vehicle without ABS. ABS detects each wheel rotation
• If you would like to suddenly apply speed via a sensor. If tyres or wheels
brake, just push the brake pedal down other than those specified in the
firmly without pumping. Otherwise, the owner’s manual are used for size,
longer braking distance will be required. type, tread pattern, or if worn condi-
• The ABS will not work if vehicle speed is tions of tyres are different, the cor-
under about 9 km/h. This depends on rect wheel rotation speed cannot be
the road conditions. detected and ABS will not work prop-
erly. This may result in an accident.
When replacing tyres, use the tyres
Vibration and Sound during ABS with the size, type, and tread patterns 69RHS150
Operation which are specified in this owner’s
manual. – Manholes
When strongly depressing the brake Also, do not use the tyres which are
pedal, you might feel vibration of the brake excessively worn.
pedal, the steering wheel, and the vehicle
body. This is due to ABS operation, and
does not indicate a malfunction; continue
strongly depressing the brake pedal at this
time.

NOTE:
Immediately after starting the engine and
beginning to drive, you might temporarily
hear a motor sound. This means that the
69RHS151
systems are in self-check mode. This
sound does not indicate a malfunction. – Metal plates in construction zones

5-96
OPERATING YOUR VEHICLE

• When driving over joints in roads and • When driving on rough roads
other height differences

69RHS152

– Gravel roads 69RHS155


69RHS153
– Bumpy roads
– Joints in roads

69RHS156
69RHS154
– Cobblestone
– Height differences in roads

5-97
OPERATING YOUR VEHICLE

ABS Warning Light Braking Assist


This function assists you in applying more
force when operating the brake. When
sudden braking is applied, the time until
the ABS comes into full effect is shortened.
• If you do not depress the brake pedal
firmly, braking assist will not operate.
• Brake assist is not a device that provides
control beyond the original braking per-
formance.

55T050730

If there is a problem in the ABS system


with the ignition switch in “ON” position or
the engine switch in ON mode, this light
will come on.

5-98
OPERATING YOUR VEHICLE

MEMO

5-99
ADVICE FOR YOUR DRIVING

ADVICE FOR YOUR DRIVING


When Driving ....................................................................... 6-1
Off-road Driving ................................................................... 6-8
Improving Fuel Economy ................................................... 6-8
Stuck Vehicle ....................................................................... 6-9
Precaution for Handling Vehicle ........................................ 6-10
Running-in ........................................................................... 6-14
Catalytic Converter ............................................................. 6-14

60G409
ADVICE FOR YOUR DRIVING

When Driving Start Driving after Carefully Check- Do not Race the Engine, and Do not
ing the Surrounding Circumstances Avoid Fast Starts and Rapid Accel-
Be sure to always fully check the safety of eration Just after Engine Start
the surrounding circumstances before Refer to “Avoid Fast Starts, Rapid Accel-
beginning to drive. eration and Hard Braking” and “Do not
Race the Engine” in the “Improving Fuel
Economy” section.

59RN02301

WARNING
• Wear your seat belts at all times.
Even though airbags are equipped 69RHS176
at the front seating positions, the
driver and all passengers should
be properly restrained at all times, CAUTION
using the seat belts provided. Refer You cannot check the safety of the
to “Seat belts and child restraint surrounding circumstances enough
systems” section for instructions only by the 360 view camera, the rear
on proper use of the seat belts. parking sensors and the inside mir-
• Never drive under the influence of ror. When moving the vehicle forward
alcohol or other drugs. Alcohol and or backward, check the safety of the
drugs can seriously impair your surrounding circumstances by
ability to drive safely, greatly directly checking with your eyes.
increasing the risk of injury to
yourself and others. You should
also avoid driving when you are
tired, sick, irritated or under stress.

6-1
ADVICE FOR YOUR DRIVING

Do not Concentrate on a Mobile Do not Reach Through the Steering Do not Drive with Your Foot on the
Phone or Navigation System Wheel Brake Pedal
CAUTION
Driving with your foot resting on the
brake pedal could cause brake parts
to become worn out more quickly
than normal or cause brake compo-
nents to overheat, making them less
effective.

When Depressing the Accelerator


55T060040 69RHS178
Pedal and the Brake Pedal Simulta-
neously
WARNING WARNING
• Do not operate a mobile phone, etc. Reaching through the steering wheel NOTE:
while driving. Being distracted by could interfere with steering wheel If you depress both the accelerator pedal
phone operation could lead to an operation and result in an accident. and the brake pedal simultaneously while
accident. driving, the engine power output may be
• Do not operate navigation/audio suppressed.
equipment, etc. while driving. Oth-
erwise, there is the danger of an
accident due to being distracted.

6-2
ADVICE FOR YOUR DRIVING

Do not Shift the Gearshift Lever into • You feel that the brake pedal is heavy
What Should You Do in Case of to use
“N” (Neutral) while Driving
Malfunction or Emergency? Via engine vacuum pressure, the vehi-
• Warning light turns on cle utilizes a brake booster to reduce
Stop immediately in a safe place and the force necessary for depressing the
take corrective action. brake pedal. If this engine vacuum
For details, refer to “Warning Lights and pressure decreases, you may feel as if
Indicators” in the “QUICK GUIDE” sec- the brakes require more force than
tion or “Warning and indicator mes- usual to depress, but this is not abnor-
sages” in the “INSTRUMENT mal. Depress the brake pedal as
CLUSTER”. strongly as you need to.
• You feel strong shock from under the • Metallic screeching sound is heard
floor from the brakes
Immediately stop in a safe place and Promptly consult with a Maruti Suzuki
69RHS180 check whether there is brake fluid leak- authorised workshop. The disk brake
age or fuel leakage, and also check pads (Maruti Suzuki genuine parts) are
whether there is any abnormality in the designed to emit a creaking/screeching
CAUTION sound as a function to warn the wear, as
exhaust pipe, etc. If any abnormality is
Do not put the gearshift lever into the found, consult with a Maruti Suzuki they have almost reached usage limit
“N” (Neutral) position while driving, authorised workshop. and replacement timing.
except in times of emergency, as this
disengages engine braking, which • Sudden tyre puncture WARNING
could result in an accident. Grasp the steering wheel firmly, carefully
apply the brake, slowly reduce speed, The brakes could be losing their
and stop in a safe place. ability to function normally, which
NOTE: could result in an accident.
Non-usage of vehicle for long duration may If you hear a metallic creaking/
cause gradual rusting on brake disc sur- screeching sound, do not continue
face as it is made of cast iron. This may driving.
result in noise/vibration. The same has no
bearing on functioning of the vehicle. Reg-
ular driving of vehicle may prevent/remove
rust, thus reducing the noise and vibration.

6-3
ADVICE FOR YOUR DRIVING

Use Engine Brake on a Long Down- Auto Gear Shift vehicles When Side Wind Is Strong
hill Slope
Use engine braking(*) in tandem with regu-
lar braking when driving on a long downhill
slope. Release the accelerator pedal and
shift down according to vehicle speed,
release the accelerator pedal and shift
down according to vehicle speed.

Manual transmission vehicles

72J20330

At a tunnel exit, on a bridge, or when a


large truck passes you, your vehicle might
be blown slightly sideways by side wind.
Do not panic. Firmly grasp the steering
55T060020 wheel, gradually reduce speed, and regain
For Auto Gear Shift vehicle, shift the your intended course.
gearshift lever into “M” (manual mode)
first. Then, pull “–” side of the shift paddle
to shift down to an appropriate gear
position.

*: Engine braking is a braking effect that


occurs when you release your foot from
55T060010 the accelerator pedal while driving. The
For manual transmission vehicle, shift lower the gear, the greater the effect of
down to a lower gear one by one. engine braking becomes.

WARNING
Continuously depressing the brake
pedal could cause the brakes to over-
heat, possibly rendering them inef-
fective.

6-4
ADVICE FOR YOUR DRIVING

Drive Slowly on a Slippery Road Do not Drive on Puddles at High Check Brake Effectiveness after
Surface Speed Driving on Puddles or Washing a
Vehicle

72J20360
59RN06030 69RHS182 • After verifying the safety of the surround-
ings, depress the brake pedal several
CAUTION CAUTION times at low speed and check the brake
effectiveness.
When driving on wet, icy, or snowy When driving on puddles or on wet • If the brake effectiveness is still poor,
roads, etc., refrain from sudden road surfaces at high speed, a thin depress the brake pedal at low speed
movements, such as sudden starting, surface of water is built between the gently and repeatedly until the brake
acceleration, braking, turning or wheels and the road surface, and the effectiveness is fully recovered, to dry
abrupt engine braking. Otherwise, wheels may float. This is called as the brake equipment.
there is the danger of an accident due hydroplaning, which leads to a loss
to loss of traction. of control in the steering wheel and
the brakes and possibly results in an
accident.

6-5
ADVICE FOR YOUR DRIVING

When Encountering a Flooded Area Highway Driving


NOTICE When driving at highway speeds, pay
attention to the following:
Avoid driving in a flooded area or a
• Stopping distance progressively
deep puddle. It may cause an engine
increases with vehicle speed. Apply the
stall, short in electrical components,
brakes far enough ahead of the stopping
engine and transmission damages,
point to allow for the extra stopping dis-
etc.
tance.
• On rainy days, hydroplaning can occur.
Hydroplaning is the loss of direct contact
between the road surface and the vehi-
cle’s tyres due to a water film forming
between them. Steering or braking the
vehicle during hydroplaning can be very
61M0075
difficult, and loss of control can occur.
Avoid driving in a flooded area or a deep Keep speed down when the road sur-
puddle. If driving in a flooded area is face is wet.
unavoidable, go slowly in the lowest gear. • At high speeds, the vehicle may be
In case that you have driven in a flooded affected by side winds. Therefore,
area, stop the vehicle in a safe and non reduce speed and be prepared for unex-
flooded place while checking the brake pected buffeting, which can occur at the
effectiveness. Then, ask Maruti Suzuki exits of tunnels, when passing by a cut
authorised workshop to check the follow- of a hill, or when being overtaken by
ing inspection items. large vehicles, etc.
• Function of brake
• Function of electrical components
• Changes of oil level and quality for
engine, transmission and differential. In
case that the oil is turbid whitely, water
has been mixed in the oil and an oil
change is required.
• Lubricant condition of the bearings, sus-
pension joints, etc.

6-6
ADVICE FOR YOUR DRIVING

Driving on Hills Auto Gear Shift vehicles • When driving on steep hills, the vehicle
Manual transmission vehicles may begin to slow down and show a lack
of power. If this happens, you should
shift to a lower gear so that the engine
will again be operating in its higher
power range. Shift rapidly to prevent the
vehicle from losing momentum.
• When driving down a hill, the engine
should be used for braking by shifting to
the next lower gear.

WARNING
Do not hold the brake pedal down too
long or too often while going down a
steep or long hill. This could cause
the brakes to overheat, resulting in
55T060020 reduced braking efficiency. Failure to
55T060010 take this precaution could result in
loss of vehicle control.

NOTICE
When descending a downhill, Never
turn the ignition key to “LOCK” posi-
tion or press the engine switch to
change the ignition mode to LOCK
(OFF). Emission control system dam-
age may result.

6-7
ADVICE FOR YOUR DRIVING

Off-road Driving Improving Fuel Economy Avoid Fast Starts, Rapid Accelera-
Do not Drive in the Field Covered NOTE: tion and Hard Braking
with Grown Grass Fuel economy (mileage) of the vehicle may
vary due to several factors i.e. driving hab- Avoid fast starts
its-gear change pattern, usage of A.C, Air Fast starts away from lights or stop signs
pressure in the tyres, wind speed, traffic will consume fuel unnecessarily and
conditions, fuel quality-non adulterated shorten engine life. Start off slowly.
standard fuel, maintenance of vehicle, Avoid unnecessary stops
road conditions, braking etc. Avoid unnecessary deceleration and stop-
The following instructions will help you ping. Try to maintain a moderate, steady
improve fuel economy. speed whenever possible. Slowing down
and then accelerating again uses more
Keep Tyre Pressures Correct fuel.
Under-inflation of the tyres can waste fuel
due to increased running resistance of the Keep a steady cruising speed
tyres. Keep your tyres inflated to the cor- Drive at a constant speed that road and
69RHS181
rect pressure shown on the label on the traffic conditions will permit.
Do not drive in the field covered with grown
grass If you drive in the field covered with driver’s side door or the driver’s door lock
grass, it may cause accident or fire or vehi- pillar.
cle damage by getting caught in grown
grass.
Keep Weight to a Minimum
WARNING The heavier the load is, the more fuel the
vehicle consumes. Unload any unneces-
If loose grass, etc. becomes entan- sary luggage or cargo.
gled in drive train parts or exhaust
pipes, drive train components might
become damaged or fire may result. Avoid Excessive idling
If you park your vehicle for more than one
minute, stop the engine and start it again
later. When warming up a cold engine, do
not allow the engine to idle or apply full
throttle until the engine has reached oper-
ating temperature. Allow the engine to
warm up by driving.
6-8
ADVICE FOR YOUR DRIVING

Do not Race the Engine Keep the Air Cleaner Clean Stuck Vehicle
If your vehicle gets stuck in snow, mud or
sand, follow the directions below:
1) Shift the transmission back and forth
between a forward range (or first gear
for manual transmission) and reverse.
This will create a rocking motion which
may give you enough momentum to
free the vehicle. Press gently on the
accelerator to keep wheel spinning to a
minimum wheel rpm. Remove your foot
from the accelerator while shifting. Do
not race the engine. Excessive wheel
spin will cause the tyres to dig deeper,
69RHS060 making it more difficult to free the vehi-
Revving the engine only consumes extra 59RN06050 cle.
fuel and has no benefit. If the air cleaner is clogged with dust, there NOTE:
will be greater intake resistance, resulting You may have to turn the ESP® system (if
NOTICE in decreased power output and increased equipped) off in order to allow spinning the
Immediately after starting, the engine fuel consumption. wheels.
is often not yet fully warmed up.
Therefore, revving the engine, start- 2) If your vehicle remains stuck after a few
ing to drive suddenly, or rapid accel- minutes of rocking, we recommend you
eration can cause engine failure. to consult a Maruti Suzuki authorised
workshop or a roadside assistance ser-
vice. If a towing service is not available
Drive with an Appropriate Gear for in an emergency, your vehicle may be
Vehicle Speed temporarily towed by a towing cable or
Running the vehicle at a high engine rota- chain secured to the towing eye either
on the front or rear of the vehicle. Refer
tion speed by using a low-speed gear will to “Towing by Using Towing Eye” in the
result in poor fuel economy. Use the cor- “EMERGENCY SERVICE” section.
rect gear according to the vehicle speed.

6-9
ADVICE FOR YOUR DRIVING

WARNING Precaution for Handling


WARNING
(Continued) Vehicle
• Do not allow anyone to stand near – Do not use tyres other than those Do not Apply Strong Force to Exte-
the vehicle when you are rocking it, specified by Maruti Suzuki. Never
and do not spin the wheels faster rior Parts
use different sizes or types of
than an indicated 40 km/h on the
speedometer. Personal injury and/
tyres on the front and rear NOTICE
wheels. For information regard-
or vehicle damage may result from ing the specified tyres, refer to Do not apply strong force to the body
spinning the wheels too fast. the tyre information label located panel, spoiler, front and rear bumper,
on the driver’s door lock pillar. side skirts, etc. These forces can
– Never use oversized tyres or spe- cause damage to these exterior
cial shock absorbers and springs parts.
to raise (jack up) your vehicle.
This will change the handling
characteristics. Oversized tyres
may also rub against the fender
over bumps, causing vehicle Be Careful of Uneven Road Surface
damage or tyre failure.
– After driving through water, test NOTICE
55T060070 the brakes while driving at a slow In the following cases, the bumper or
speed to see if they have main- the lower part of the vehicle could get
• In addition to following the driving tained their normal effectiveness.
tips in this section, it is important damaged. Ensure proper care.
If the brakes are less effective
to observe the following precau- than normal, dry them by repeat- • Entering the areas where there is
tions. edly applying the brakes while uneven road surface, such as road
– Check that your tyres are in good driving slowly until the brakes shoulder
condition and always maintain have regained their normal effec- • Driving on roads with grooves,
the specified tyre pressure. Refer tiveness. bumps or potholes
to “Tyres” in “INSPECTION AND
MAINTENANCE” section for
details. NOTICE
(Continued)
Do not continue rocking the vehicle
for more than a few minutes. Pro-
longed rocking can cause engine
overheating or transmission damage.

6-10
ADVICE FOR YOUR DRIVING

Do not Modify Your Vehicle Illegally


WARNING NOTICE
(Continued) (Continued)
• Do not use wheels or wheel nuts • Only a troubleshooting device
other than specified Maruti Suzuki designed for inspection and main-
genuine products. Doing so could tenance for this model can be con-
lead to accidents, such as nuts nected to the vehicle’s onboard
loosening and the wheel coming off diagnostics system. Connecting a
while driving. Also, fuel consump- device other than that specified
tion and driving stability could could hinder the functioning of
worsen, or it could result in other electronic components and cause
malfunctions. battery runout, etc.

69RHS184
NOTICE
• When installing or removing elec-
WARNING trical equipment such as radio
• If you modify your vehicle illegally, equipment, navigation, audio
there is a danger of a fire or an equipment or electronic toll control
accident. Illegal modifications equipment, consult with a Maruti
might adversely affect handling, Suzuki authorised workshop. Also,
performance or durability. Also, do not operate electrical equipment
this could even violate laws and directly from the battery terminals
ordinances. or connect ground wires directly.
Do not install unsuitable parts to Otherwise, there is a danger of hin-
your vehicle or do not make your dering the functioning of electronic
own adjustments or wiring. components, causing fire, malfunc-
(Continued) tion, battery runout, etc.
(Continued)

6-11
ADVICE FOR YOUR DRIVING

When Installing, Removing and Be Careful When Placing Accesso- When Spilling Drinks or Liquids
Repairing Parts ries
WARNING
WARNING Do not allow liquids to spill, splash or
The SRS airbag system and the seat spray inside the vehicle. The follow-
belt pretensioner system could acti- ing items could malfunction, or fire
vate unexpectedly or could be ren- could result. In the case of spilling
dered ineffective if the parts that drinks, etc., promptly consult with a
affect their functions are adjusted or Maruti Suzuki authorised workshop.
arranged. In the following cases, • SRS airbag system
these systems will be adversely • Audio equipment
affected. Consult with a Maruti • Electrical parts such as switches
Suzuki authorised workshop before- and wiring
hand. • Movable parts such as the gear-
• When removing the steering wheel 69RHS185 shift lever or seat belt buckles
and conducting repairs around the
steering wheel, etc.
• When conducting repairs around
WARNING NOTICE
the center console, around the Do not attach accessories to the win- The sensor of the seat belt reminder
instrument cluster, under the front dow glasses. Accessories and suc- is built into the front passenger's
seats or to electrical wiring tion cups could hinder vision, or a seat cushion.
• When installing audio equipment, suction cup could act as a lens and If you spill liquid such as soft drinks
etc. cause a fire. Also, if an airbag is acti- or juice, the sensor of the seat belt
• When conducting sheet metal vated, such accessories could be reminder may be damaged.
painting or repairs around the ejected outward within the vehicle, If you spill any liquid on the seat
dashboard possibly resulting in injury. cushion, immediately wipe it with a
• When replacing the front seats or soft cloth.
conducting repairs around the
seats
• Repairs around the front pillar, the
back pillar or the roof side
• When conducting repairs around
the center pillar

6-12
ADVICE FOR YOUR DRIVING

When Replacing Engine Oil Specification and viscosity of engine oil Except for India
As performance factors such as fuel con-
Replace engine oil regularly sumption depend on the engine oil used, Specification All vehicles
use oil that satisfies the specifications in
the following Table 1 and Table 2. Using 0W-20, 5W-30,
Viscosity: SAE(*3)
Maruti Suzuki genuine oil is recom- 0W-16
mended.
*1: The API standard is determined by the
Table 1 American Petroleum Institute and rep-
resents the quality grade of engine oil.
Specification Oil quality *2: The ILSAC standard is an engine oil
standard for automobiles, established
by the International Lubricant Standard-
SP / GF-6
54M3143 ization and Approval Committee, and is
based on the API standard while indi-
• If the vehicle is normally used, replace
cating even higher performance specifi-
the engine oil and filter every 10,000 km SN / GF-5
cations such as for fuel conservation
or every 12 months, whichever is earlier. API(*1) /
and durability.
• When the vehicle is used under severe ILSAC(*2)
*3: SAE viscosity is a standard that deter-
driving conditions, the engine oil and fil- SM / GF-4
mines the viscosity of lubricating oil.
ter replacement is required earlier than
The number on the left side (the num-
the case that the vehicle is normally
SL / GF-3 ber with a “W”) means the viscosity at
used.
low temperature. The smaller this figure
is, the stronger the oil resistance to
NOTICE coldness is and the better the engine
Observe the periods designed for the Table 2 start capability is. The number on the
engine oil and filter replacement. For India right side means the viscosity at high
Degraded oil or clogged filters can temperature. The larger this figure is,
cause engine malfunction or abnor- Specification All vehicles the stronger the oil resistance to heat is
mal noise. For replacement, consult and the better the engine protection
with a Maruti Suzuki authorised work- Viscosity: SAE(*3) 0W-16 performance is.
shop.

6-13
ADVICE FOR YOUR DRIVING

Running-in Catalytic Converter


NOTICE
NOTICE To minimize the possibility of cata-
The future performance and reliabil- lytic converter or other vehicle dam-
ity of the engine depends on the care age:
and restraint exercised during its • Maintain the engine in the proper
early life. It is especially important to operating condition.
observe the following precautions • In the event of an engine malfunc-
during the first 960 km of vehicle tion, particularly one involving
operation. engine misfire or other apparent
• After starting, do not race the loss of performance, have the vehi-
engine. Warm it up gradually. cle serviced promptly.
• Avoid prolonged vehicle operation • Do not turn off the engine or inter-
at a constant speed. Moving parts 80G106
rupt the ignition when the transmis-
will break in better if you vary your sion is in gear and the vehicle is in
The purpose of the catalytic converter is to motion.
speed. minimize the amount of harmful pollutants
• Start off from a stop slowly. Avoid • Do not try to start the engine by
in your vehicle’s exhaust. Use of leaded pushing or towing the vehicle, or
full throttle starts. fuel in vehicles equipped with catalytic
• Avoid hard braking, especially coasting down a hill.
converters is prohibited, because lead • Do not idle the engine with any
during the first 320 km of driving. deactivates the pollutant-reducing compo-
• Do not drive slowly with the trans- spark plug wires disconnected or
nents of the catalyst system. removed, such as during diagnos-
mission in a high gear.
• Drive the vehicle at moderate The converter is designed to last the life of tic testing.
engine speeds. the vehicle under normal usage and when • Do not idle the vehicle for pro-
• Do not tow a trailer during the first unleaded fuel is used. No special mainte- longed periods if idling seems
960 km of vehicle operation. nance is required on the converter. How- rough or there are other malfunc-
ever, it is very important to keep the engine tions.
properly tuned. Engine misfiring, which can • Do not allow the fuel tank to get
result from an improperly tuned engine, near the empty level.
may cause overheating of the catalytic
converter. This may result in permanent
heat damage to the catalytic converter and
other vehicle components.

6-14
ADVICE FOR YOUR DRIVING

59RN06060

WARNING
Be careful where you park and drive;
the catalytic converter and other
exhaust components can get very
hot. As with any vehicle, do not park
or operate this vehicle in areas where
combustible materials such as dry
grass or leaves can come in contact
with a hot exhaust system.

6-15
OTHER CONTROLS AND EQUIPMENT

OTHER CONTROLS AND EQUIPMENT


Fuel Filler Opening .............................................................. 7-1
Refueling .............................................................................. 7-2
Hood ..................................................................................... 7-4
Sun Visor ............................................................................. 7-6
Interior Light ........................................................................ 7-7
Accessory Socket ............................................................... 7-10
Drink Holder ......................................................................... 7-11
Storage Area ........................................................................ 7-12
Assist Grips ......................................................................... 7-14
Footrest ................................................................................ 7-15
Door Pocket ......................................................................... 7-15
USB Socket (if equipped) ................................................... 7-16 7
USB Charging Socket (if equipped) .................................. 7-16
Front Seatback Pocket (if equipped) ................................. 7-17
Luggage Compartment Hook ............................................. 7-17
Luggage Compartment Cover (if equipped) ..................... 7-17
60G407
Heating and Air Conditioning System ............................... 7-18
Automatic Heating and Air Conditioning System
(Climate Control) ................................................................. 7-20
Radio Antenna ..................................................................... 7-27
Installation of Radio frequency Transmitters ................... 7-27
Audio Function .................................................................... 7-28
Remote Audio Controls (if equipped) ............................... 7-28
Suzuki Connect (if equipped) ............................................. 7-30
OTHER CONTROLS AND EQUIPMENT

Fuel Filler Opening be unlocked by pulling up the opener lever Fuel Filler Cap
(1) located on the outboard lower side of
Make sure to read “Refueling” in this the driver’s seat and locked by simply clos-
section. ing the door. Open Close
WARNING
Be sure to observe the following
points when refueling. Otherwise,
gasoline may catch a fire from fuel
and it may cause a fire.
• Always stop the engine first.
• Close all the doors and windows 57L51093
when refueling. • To open the fuel filler cap, turn it counter-
• As gasoline is highly flammable, clockwise.
open sparks such as lit cigarettes • To close the fuel filler cap, turn it clock-
are strictly prohibited. wise until you hear more than 2 clicks.

Fuel Filler Door (1)

(3)

(1) (1)
(1) (2)

55T070660

55T070420

A fuel filler door is located on the left rear


side of the vehicle. The fuel filler door can
7-1
OTHER CONTROLS AND EQUIPMENT

NOTE: Refueling When Refueling at a Self-service


The cap holder (1) holds the fuel filler cap Gas Station
(2) by hooking the groove (3) when refuel- Watch Out for Fire
ing. WARNING
When refueling at a self-service gas
WARNING station, be sure to observe the follow-
ing points.
• If you open the fuel filler cap sud- • If substantial static electricity is
denly, fuel may be under pressure accumulated within your body, a
and may spray out. Loosen the fuel spark could ignite fuel vapors and
filler cap slowly. After air deflating possibly cause burns. Before open-
sound stops, open the fuel filler ing the fuel filler cap, discharge any
cap. static electricity* that might have
• If fuel spills out, an accident such accumulated in your body, by
as a fire may occur. Also, if you touching a metal part of the vehicle
leave spilled fuel as it is, it may body or the gas pump machine. In
cause paint staining, discoloration 69RHS186 addition, do not re-enter the vehicle
or cracking. Be careful not to spill while refueling, as static electricity
out fuel. If you spill it out, wipe it off WARNING could be charged to your body
with a soft cloth. again.
• If the fuel filler cap is not closed Be sure to observe the following • Do not allow others who have not
securely, it may cause fuel leakage points when refueling. Otherwise, discharged their static electricity to
or a fire. After refueling, close the gasoline may catch a fire from fuel come close to the fuel filler open-
fuel filler cap until you hear more and it may cause a fire. ing.
than 2 clicks. • Always stop the engine first.
• If you use the fuel cap other than a • Close all the doors and windows *Take special care when air is dry,
genuine Maruti Suzuki cap, it may when refueling. as this can cause your body to
cause fuel leakage. Do not use the • As gasoline is highly flammable, become charged with static elec-
fuel cap other than a genuine open sparks such as lit cigarettes tricity more easily. In addition,
Maruti Suzuki cap. are strictly prohibited. wearing layers of clothing can
generate static electricity due to
the friction of the fibers.
(Continued)

7-2
OTHER CONTROLS AND EQUIPMENT

WARNING WARNING WARNING


(Continued) (Continued) (Continued)
• If you open the fuel filler cap sud- • If fuel spills out, an accident such
denly, fuel may be under pressure as a fire may occur. Also, if you
and may spray out. Loosen the fuel leave spilled fuel as it is, it may
filler cap slowly. After air deflating cause paint staining, discoloration
sound stops, open the fuel filler or cracking. Be careful not to spill
cap. out fuel. If you spill it out, wipe it off
• If you do not insert the fuel filler with a soft cloth.
nozzle securely into the fuel filler • If the fuel filler cap is not closed
opening, fuel may spill out. Insert securely, it may cause fuel leakage
the fuel filler nozzle securely into or a fire. After refueling, return the
the fuel filler opening until it stops. fuel filler nozzle to its original posi-
• Pull the gas pump filler nozzle lever tion and close the fuel filler cap
until it stops. until you hear more than 2 clicks.
(Continued) 69RHS070 • Fuel contains substances harmful
• If you continue to refuel after the to the human body. Do not breathe
automatic stop to top up the tank, in vaporized fuel.
fuel could overflow. When the auto- • In addition, be sure to observe all
matic stop function of gas pump the warnings posted at the gas sta-
filler nozzle is activated, stop refu- tion.
eling.
*Depending on the type of gas Use Unleaded Gasoline Only
pump machine being used, the
automatic stop function could NOTICE
activate early and refueling might
not be possible. Please follow the Using leaded gasoline, low-quality
instructions of the employees at gasoline or other types of fuel (such
the gas station. as alcohol and diesel oil) can cause
(Continued) harmful effects to the engine and fuel
delivery system.
Do not use fuel other than unleaded
gasoline.

7-3
OTHER CONTROLS AND EQUIPMENT

Hood Opening the Hood

WARNING (2)
• As the hood is heavy, if a child tries
to open or close it, the child may
get injured. Do not allow a child to
open or close the hood.
• As the engine compartment
becomes hot, it may cause burns.
When opening the hood, do not (1)
allow a child to come close to the
hood.
• If you leave any tool or cloth in the
engine compartment, it may cause 55T070440 55T070460
a malfunction. Also, as the engine 1) Pull up the hood release lever (1) 2) Push the under-hood release lever (2)
compartment becomes hot, it may located under the driver’s side instru- sideways with your finger, as shown in
result in vehicle fire. Do not leave ment panel in the outboard position. the illustration. While pushing the lever,
any tool or cloth for inspection or This will disengage the hood lock half- lift up the hood.
cleaning in the engine compart- way.
ment. CAUTION
The under-hood release lever can be
CAUTION hot enough to burn your finger while
If you come close to a running drive the engine is running or right after
belt or a cooling fan (radiator fan), the engine stopped.
hands, hair, clothing, etc. may be If you try to open the hood while the
caught and you may get injured. engine is running or right after the
When the engine is running, keep engine stopped, touch the under-
away from the drive belt or the cool- hood release lever after it becomes
ing fan (radiator fan). cool enough.

7-4
OTHER CONTROLS AND EQUIPMENT

Closing the Hood


NOTICE CAUTION
If you lift up the hood with the wiper • The prop rod can be hot enough to
arms raised, the wiper arms and the burn your finger while the engine is
hood may get damaged. running or right after the engine
Do not lift up the hood with the wiper stopped. If you would like to use
arms raised. the prop rod while the engine is
running or right after the engine
stopped, touch the prop rod after it
becomes cool enough.
※ • If the prop rod slips out, you may
get caught in the closing hood.
Insert the end of the prop rod into
(3) the hole securely.
(4) • The prop rod may slip out when the 55T070480
hood is blown by wind. If this
occurs, you may get caught in the 1) Lift up the hood slightly and remove the
closing hood. Be very careful when prop rod from the hole. Put the prop rod
you open the hood on a windy day. back into the holding clip.
(5)
NOTE: 2) Lower the hood to about 20 cm above
When you pull out the prop rod from the the hood latch, and then let it drop
55T070470 holding clip, hold the part. down. Check that the hood is securely
3) While holding the hood, pull the prop latched after closing.
rod (3) out from the holding clip (4), and
then insert the end of the rod into the WARNING
designated hole (5). If the hood is not fully closed, it can
fly up unexpectedly during driving,
obstructing your view and resulting
in an accident. Check that the hood is
fully closed and latched before driv-
ing.

7-5
OTHER CONTROLS AND EQUIPMENT

Sun Visor Card Holder (if equipped)


CAUTION
When closing the hood, the occu- (1) (2)
pant’s body such as hands may get
caught in the hood and get injured.
Also, pushing on the hood from the
top may damage it.
When closing the hood, check that
no part of the occupant’s body such
as hands is in the path of the hood.

(3)

72M2058
79J161

The sun visors can be pulled down to block (1) Hook


glare coming through the windshield, or (2) Mirror cover
they can be unhooked and turned to the (3) Card holder
side to block glare coming through the side
window. You can put a card in the card holder (3) on
the back of the sun visor.

NOTICE
If you park your vehicle outdoors in
direct sunlight in hot weather, the
inside of the vehicle will become hot.
The heat may distort or crack a card.
When you park your vehicle outdoors
in direct sunlight or in hot weather,
do not leave plastic cards in the card
holder.

7-6
OTHER CONTROLS AND EQUIPMENT

Vanity Mirror (if equipped) Interior Light • The hazard warning lights, the position
lights and the headlights are off.
• After 15 minutes of the light on.
NOTICE
If you turn on the interior light for a Center
long time with the engine stopped,
the lead-acid battery may discharge. (c) (b) (a)
Do not turn on the interior light for a
long time with the engine stopped.

Front (if equipped)

(4)
70K178

(4) Vanity mirror

To use the vanity mirror (4) on the back of


the sun visor, pull up the mirror cover (2).
55T070020
WARNING This light switch has three positions which
• If you use the vanity mirror while function as described below:
driving, you may lost control of the 55T070010
ON (a)
vehicle, resulting in an accident. Push the switch to turn on the light and The light comes on and stays on regard-
Do not use the vanity mirror while push it again to turn off the light.
driving. less of whether the door is open or closed.
• Do not place any object on the NOTE: NOTE:
location where an airbag is stored If your vehicle is equipped with the keyless If your vehicle is equipped with the keyless
or come close to the location where push start system or the keyless entry sys- push start system or the keyless entry sys-
airbag is stored, when using a van- tem, the light will automatically be turned tem, the light will automatically be turned
ity mirror. Doing so may cause the off to prevent the lead-acid battery from off to prevent the lead-acid battery from
airbag to deploy and cause serious discharging when the following conditions
injury due to the impact of airbag. discharging when the following conditions
are simultaneously met: are simultaneously met:
• The ignition switch is in the “LOCK” posi- • The ignition switch is in the “LOCK” posi-
tion, or the ignition mode is “LOCK” (OFF). tion, or the ignition mode is “LOCK” (OFF).

7-7
OTHER CONTROLS AND EQUIPMENT

• The hazard warning lights, the position Luggage Compartment Light


lights and the headlights are off. (if equipped)
• After 15 minutes of the light on.

DOOR (b) (1) (2)


• The light comes on when the door is
opened. After closing all doors, the light
will remain on for 15 seconds and then
fade out. If you insert the key, or press
the engine switch to change the ignition
mode to “ACC” or “ON” during this time,
the light will start to fade out immedi-
ately. After removing the key from the
ignition switch or press the engine switch
to change the ignition mode to “LOCK” 68PM00510 68PM00511
(OFF), the light will turn on for 15 sec- When you open the tailgate with the lug- NOTE:
onds and then fade out. gage compartment light switch in the “ON” The number of doors involved in the light-
• When the ignition switch is in LOCK position (1), the light comes on for about ing operation of the interior light depends
position, or the ignition mode is “LOCK” 15 minutes. on the vehicle specification. If there is a
(OFF), to prevent the lead-acid battery When the luggage compartment light switch (rubber protrusion) at the door
from discharging, the light will automati- switch is in the “OFF” position (2), the light opening as shown, the door is involved in
cally be turned off when a period of 15 remains off regardless of whether the tail- the lighting operation. The tailgate is also
minutes has elapsed after any of the gate is open or close. involved in this operation even without the
doors (including the tailgate) is opened rubber protrusion.
and other operations are not done.

OFF (c)
The light remains off even when the door is
opened.

7-8
OTHER CONTROLS AND EQUIPMENT

Vanity Mirror Light (If equipped) NOTE: NOTE:


If you leave any door open, the light will • You can change the footwell lights oper-
automatically be turned off after about 15 ation via the information display. Refer to
minutes to prevent the battery from dis- “Information Display” in the “INSTRU-
charging. MENT CLUSTER” section.
• The light will automatically be turned off
Front Footwell Lights (If equipped) to prevent the lead-acid battery from dis-
charging when all of the following condi-
tions are simultaneously met for 15
minutes or more:
– The ignition switch is in the “LOCK”
(1) position, or the ignition mode is LOCK
55T070030
(OFF).
– If footwell lights setting mode is in
The vanity mirror light (1) comes on when lighting control mode and headlamp or
the mirror cover is opened. position lamp is off.
Courtesy Lights (If equipped) – If any door is open.

Glove Box Light (If equipped)


Refer to “Glove Box” in this section.
55T070500

A footwell light is provided in the leg space


in front of each front seat. The light comes
on when the door is opened. After closing
all doors, the light will remain on for about
15 seconds and then fade out. If you turn
the ignition switch to “ACC” or “ON” posi-
tion or press the engine switch to change
the ignition mode to ACC or ON during this
time, the light will start to fade out immedi-
55T070490
ately.
Each front door has a courtesy light on its
inside bottom. It lights automatically when
the door is opened.
7-9
OTHER CONTROLS AND EQUIPMENT

Accessory Socket Floor Console (if equipped)


NOTICE
Center Console • To prevent the fuse from being
blown, when using sockets at the
same time, do not exceed the total
combined power capacity of 12
volt/120 watt/10 ampere.
• Use of inappropriate electrical
(1) accessories can cause damage to
your vehicle’s electrical system.
(1)
Check that any electrical accesso-
ries you use are designed to plug
into this type of socket.
• Check that the cap remains on the
55T070540 socket when the socket is not in
The accessory socket will work when the use.
55T070520 ignition switch is in “ACC” or “ON” position • When the ignition switch is in
or the engine switch is in ACC or ON “LOCK” positionࠉor the ignition
mode. mode to LOCK (OFF) during using
This socket can be used to provide 12 volt/ the accessory socket, the following
120 watt/10 ampere power for electrical accidents may occur;
accessories. Check that the rubber cap – the audio or navigation system
remains on the socket when the socket is does not turn off.
not in use. – the keyless entry system does
When using the accessory socket, open not work, etc.
the rubber cap (1). If they occur, disconnect the item
from the accessory socket and check
WARNING whether the electrical equipments
When the accessory socket is not in work properly.
use, closed the rubber cap. If any for- If the problem persists, ask a Maruti
eign material enters the accessory Suzuki authorised workshop to have
socket, it may cause a malfunction or the system inspected.
short circuit.

7-10
OTHER CONTROLS AND EQUIPMENT

Drink Holder Rear


Floor Console WARNING
• Be careful and use a lid for a drink
not to spill out liquid. Spilling out
(2) hot liquid can cause burn injury. In
addition, if liquid spills out on the
following parts, it may cause a fire
or a malfunction and an airbag sys-
tem may not work properly.
– Navigation system, audio sys-
tem or the relevant switches
– Wiring or electrical components
under the floor
(1) 55T070090 – Moving part of the gearshift lever
(2) Bottle holder or the seatbelt buckle
55T070070 • If you place a long drink container,
NOTE: sharp-edged, hard or breakable
(1) Floor console drink holder
Maruti Suzuki recommends to use maxi- objects in the drink holders, these
mum 1 liter capacity of bottle. objects may be thrown out, result-
Door
ing in personal injury and hindering
Front your view. In the driver’s side drink
holder or the front passenger’s
side drink holder, you can place a
can, a cup or a plastic bottle.
• Do not place a long drink container
(2) in the driver’s side drink holder.
The container may hinder your
view, resulting in an accident.

55T070080

7-11
OTHER CONTROLS AND EQUIPMENT

NOTE: Storage Area


• If you place the keyless remote control-
ler in a drink holder or a bottle holder, it
may not be detected.
• If you spill or drop liquid accidentally,
have your vehicle inspected by a Maruti
Suzuki authorised workshop.
(2)

(1)

(3)

(4)

55T070550

(1) Glove box


(2) Floor console tray
(3) Driver’s side pocket
(4) Front armrest with console box (if equipped)

Each item in the figure is a typical example; the actual equipment depends on the vehicle
type.

7-12
OTHER CONTROLS AND EQUIPMENT

Using Storage Area with a Lid


WARNING Glove box
• If any object gets caught in the
brake pedal or the accelerator
pedal, you may not operate the
pedal properly, resulting in an acci-
dent. If you use a storage area with-
out a lid, do not place the object
which may fall out while driving.
• If there is any object within the area
where the front passenger’s airbag
(1)
could inflate, the object may be
thrown out or the front passenger’s
airbag may not inflate properly. Do 55T070050
not place a big object on the instru-
ment panel tray. The glove box light (If equipped) stays on
55T070570 while the lid is open.
• To open the glove box, pull the latch
CAUTION lever (1).
If you use a storage area with a lid, • To close it, push the lid until it is latched
do not drive the vehicle with the lid securely.
open. In acceleration, a sudden brak-
ing or an collision, your body may be WARNING
hit by the lid or the object which falls
out from the storage area. • Never drive with the glove box lid
open. It could cause injury if an
accident occurs.
NOTE: • Do not leave cigarette lighters or
If you place the keyless remote controller spray cans in the glove box. If a
in any of storage areas, it may not be cigarette lighter or spray can is in a
detected. place such as the glove box, it may
light accidentally when luggage is
loaded, causing a fire.

7-13
OTHER CONTROLS AND EQUIPMENT

Front armrest with console box Assist Grips Coat Hooks


(if equipped)
(1)
(1)

55T070060

You can hang clothing on the coat hooks.


These hooks are not designed for large or
80J1233 heavy items and are located with rear right
Assist grips are provided for convenience. assist grip.
55T070650
Pull the assist grip (1) towards you.
Use this stowage for keeping small items. WARNING
Open the compartment by raising the top
lid while keeping the lever (1) up. NOTICE If your vehicle is equipped with side
To avoid damaging the assist grip curtain airbags, do not hang sharp
and the molded headlining, do not items like a hanger on the coat hook.
NOTICE hang down the assist grip. When hanging the clothes, hang
them on the hook without using a
To avoid damage to the armrest, do hanger.
not lean on it or allow a child to sit on
it.
NOTICE
NOTE: To avoid breaking the hook, do not
Always close the lid after you put some- hang items heavier than the following
thing into or take something out of the box. weight.
Coat hook: 2 kg

7-14
OTHER CONTROLS AND EQUIPMENT

Footrest Door Pocket Each pocket is provided for holding light


and soft things such as gloves, newspa-
Front pers or magazines.

CAUTION
• If an accident occurs, objects such
as bottles, cans, etc. in the door
pocket can injure the occupants.
Do not put hard or breakable
objects in the door pocket.
• If you grab and pull the door
pocket, it may be broken, resulting
in personal injury. When closing a
55T070590
door, do not grab and pull the door
pocket.
Use the footrest as a support for your left
foot only. 55T070190 NOTE:
Rear If you place the keyless remote controller
in a door pocket, it may not be detected.

55T070200

7-15
OTHER CONTROLS AND EQUIPMENT

USB Socket (if equipped) USB Charging Socket


WARNING
(if equipped)
When the ignition switch is in “ACC” or When the USB charging socket is not
“ON” position, or the ignition mode is ACC in use, close the cover. If any foreign
or ON, you can charge your mobile device material enters the USB charging
such as your smart phone by using the socket, it may cause a malfunction or
connecting cable (commercial item). short circuit.
(1) Left side socket (1)
The standard capacity is 5 V / 2.4 A (12 W) NOTICE
for one socket and USB Type-A can be Do not charge your mobile device for
used. a long period of time, while the
Right side socket (2) engine is stopped. Otherwise, the
The standard capacity is 5 V / 3.0 A (15 W) lead-acid battery may run out.
55T070610
for one socket and USB Type-C can be
Open the cover (1), and then connect your used. NOTE:
portable digital music player, etc. to this • The USB charging socket should be
socket to enjoy music through the vehicle’s used only for charging.
audio system. Refer to the supplementary • For some models, charging may pause.
manual for details. However, this is not a malfunction.
(2) • Depending on the vehicle conditions
WARNING such as the following examples,
charging may temporarily pause.
If foreign material enters the USB
(1) – When the inside temperature of the
socket, a malfunction or a short cir-
vehicle is high after parking the vehicle
cuit may occur.
under the blazing sun
Always close the cover when the
– When the engine is started
USB socket is not in use.

55T070390

Open the cover to use the USB charging


socket.

7-16
OTHER CONTROLS AND EQUIPMENT

Front Seatback Pocket Luggage Compartment Hook Luggage Compartment Cover


(if equipped) (if equipped)

55T070210 55T070640

This pocket is provided for holding light Luggage or other cargo placed in the lug-
and soft things such as gloves, newspa- gage compartment is hidden from view by
55T070630
pers or magazines. a luggage compartment cover.
You can hang the shopping bag or other
CAUTION suitable objects on the hook. WARNING
This hook is not designed for large or
• If an accident occurs, objects such heavy items. Do not carry items on top of the lug-
as bottles, cans, etc. can injure the gage compartment cover, even if they
occupants in the rear seat. Do not are small and light. Objects on top of
put hard or breakable objects in the
NOTICE the cover could be thrown about in
pocket. To avoid breaking the hook, do not an accident, causing injury, or could
• If you put sharp or heavy objects in hang items heavier than the following obstruct the driver’s rear view.
the pocket, the seat may be dam- weight.
aged. Do not put sharp or heavy Shopping hook: 1 kg
objects in the pocket.

7-17
OTHER CONTROLS AND EQUIPMENT

Heating and Air Conditioning System Center outlet


Air Outlet
(1) (1)
1 1
2 2

3 3
4 4

55T070100

5 5 Move the knob (1) vertically or horizontally


to adjust the direction of airflow as desired.

CAUTION
Prolonged exposure to hot air from
the heater or air conditioner could
result in low temperature burns. All
6 6 vehicle occupants, particularly chil-
dren, the elderly, those with special
needs, individuals with delicate skin,
and sleeping individuals, should
55T070220 maintain sufficient distance from the
1. Windshield defroster outlet air outlets to prevent prolonged
2. Side defroster outlet exposure to hot airflow.
3. Side outlet
4. Center outlet
5. Floor outlet
6. Rear outlet (if equipped)

7-18
OTHER CONTROLS AND EQUIPMENT

Side outlet and rear outlet (if equipped)


CAUTION
(2) (3) Prolonged exposure to hot air from
the heater or air conditioner could
result in low temperature burns. All
vehicle occupants, particularly chil-
dren, the elderly, those with special
needs, individuals with delicate skin,
and sleeping individuals, should
maintain sufficient distance from the
air outlets to prevent prolonged
55T070110 exposure to hot airflow.

NOTE:
(2) • For side outlet, if the front door windows
are fogged, adjust to direct wind from the
side outlets towards the front door win-
dows. This will allow you to remove fog
more quickly.
• The airflow from the rear outlet can be
increased by fully moving the center out-
let knob (1) to the inner side.
(3)

55T070120

When open, air comes out regardless of


the air flow selector position. Move the
knob (2) vertically or horizontally, to adjust
the direction of airflow as desired. The side
outlet opens when you turn the dial (3)
upward and closes when you turn it down-
ward.

7-19
OTHER CONTROLS AND EQUIPMENT

Automatic Heating and Air Conditioning System (Climate Temperature selector (1)
Control)
Description of Controls

(2) (9) (1)

(1)

55T070140

Push upper part or lower part of the tem-


perature selector (1) to adjust the tempera-
ture. The display (9) shows the selected
(3) (6) (7) (8) (5) (4) temperature.

NOTE:
55T070130 If you push the temperature selector (1)
(1) Temperature selector until “HI” or “LO” appears on the display,
(2) Blower speed selector the climate control system will operate at
(3) Air intake selector maximum heating or cooling. The tempera-
(4) Air flow selector ture of the air from the outlets may change
(5) Defrost switch suddenly while “LO” or “HI” is displayed,
(6) Air conditioning switch but this is normal.
(7) “OFF” switch
(8) “AUTO” switch
(9) Display

7-20
OTHER CONTROLS AND EQUIPMENT

Blower speed selector (2) Air intake selector (3) or to reduce unwanted odor from entering
the vehicle.

(3) FRESH AIR (b)


When this mode is selected, outside air is
introduced. At the same time, the indicator
(10) light (10) will turn off.

The fresh air position (b) and recirculated


air position (a) are selected alternately
each time the air intake selector is pushed.
(2)
NOTE:
55T070150
(a) (b) If you select the recirculated air position (a)
The blower speed selector (2) is used to 55T070160
for an extended period of time, the air in
turn on the blower and to select blower the vehicle may become contaminated.
Push the air intake selector (3) to change Therefore, you should occasionally select
speed.
between the following modes. the fresh air position (b).
If the “AUTO” switch (8) is pushed, the
If the “AUTO” switch (8) is pushed, the air
blower speed will vary automatically as the
intake will vary automatically as the climate
climate control system maintains the
control system maintains the selected tem-
selected temperature.
perature.

NOTE:
When you select the recirculated air mode,
the automatic operation system is deacti-
vated if you push the “AUTO” switch (8).

RECIRCULATED AIR (a)


When this mode is selected, inside air is
recirculated. At the same time, the indica-
tor light (10) will turn on. This mode is suit-
able when driving through an area with
polluted air such as a tunnel, or when
attempting to quickly cool down the vehicle

7-21
OTHER CONTROLS AND EQUIPMENT

Air flow selector (4) Ventilation (c) Bi-level (d)

(c)

(d)

(e)
(4)

(f)
55T070240 55T070260
55T070170

Push the air flow selector (4) to change Temperature-controlled air comes out of Temperature-controlled air comes out of
among the following functions. The indica- the center, side and rear (if equipped) out- the floor outlets and cooler air comes out
tion of the selected mode appears on the lets. of the center, side and rear (if equipped)
display. outlets. When the temperature selector (1)
is in the fully COLD position or fully HOT
If the “AUTO” switch (8) is pushed, the air position, however, the air from the floor
flow will vary automatically as the climate outlets and the air from the center, side
control system maintains the selected tem- and rear (if equipped) outlets will be the
perature. same temperature.

7-22
OTHER CONTROLS AND EQUIPMENT

Heat (e) Heat and defrost (f) Defrost switch (5)


(11)

(5)
59RN07170

Push the defrost switch (5) to turn on the


defroster. At the same time, the indicator
light (11) will turn on.

55T070280 55T070300 Defrost


Temperature-controlled air comes out of Temperature-controlled air comes out of
the floor outlets and the side outlets, also the floor outlets, the windshield defroster
comes out of the windshield defroster out- outlets, the side defroster outlets and the
lets and also comes slightly out of the side side outlets.
defroster outlets.

55T070320

Temperature-controlled air comes out of


the windshield defroster outlets, the side
defroster outlets and the side outlets.

7-23
OTHER CONTROLS AND EQUIPMENT

NOTE: Models with idling stop system System Operating Instructions


When the defrost switch (5) is pushed to When the engine is stopped automatically,
turn on the defroster, the air conditioning the air conditioner switches to the ventila- Automatic operation
system will come on and the fresh air posi- tion position (a). (1)
tion (b) will be selected automatically. In
very cold weather, however, the air condi- NOTE:
tioning system will not turn on. • If the cooling and heating performance is
insufficient when the engine is stopped
Air conditioning switch (6) automatically, push the idling stop sys-
tem OFF switch to deactivate the idling
(12) stop system. (The engine is restarted
automatically, and the cooling and heat- (6) (7) (8)
ing performance is restored.)
• If the windshield and/or front door win- 55T070180
dows are fogged, push the defrost You can let the climate control system
(6) switch. (When the defrost switch is work automatically. To set the system for
59RN07190
pushed, the engine is restarted automat- fully-automatic operation, follow the proce-
ically and the defroster is turned on.) dure below.
The air conditioning switch (6) is used to
turn on and off the air conditioning system 1) Start the engine.
only when the blower is on. Push in the 2) Push the “AUTO” switch (8).
switch to turn on the air conditioning sys- 3) Set the desired temperature by pushing
tem. At the same time, “A/C” will appear on the temperature selector (1).
the display and the indicator light (12) will
turn on. The blower speed, air intake and air flow
Push in the switch again to turn off the air are controlled automatically to maintain the
conditioning system. At the same time, “A/ set temperature. However, the air flow is
C” will go off and the indicator light (12) will not changed to the defrost position auto-
turn off. matically.

7-24
OTHER CONTROLS AND EQUIPMENT

NOTE: NOTE:
When you select the recirculated air mode, • To find the temperature at which you are
the automatic operation system is deacti- most comfortable, start with the 25°C
vated if you push the “AUTO” switch (8). (75°F) setting.
• If you push the temperature selector (1)
You can use the air conditioning switch (6) until “HI” or “LO” appears on the display,
to manually turn the air conditioner on or off the climate control system will operate at
according to your preference. When you maximum heating or cooling and the
turn the air conditioning switch off, the cli- blower will run at full speed.
mate control system cannot lower the • To avoid blowing cold air in cold weather
inside temperature below outside tempera- or hot air in hot weather, the system will
ture. delay turning on the blower until warmed
or chilled air is available. (13)
To turn the climate control system off, push • If your vehicle has been left in the sun
the “OFF” switch (7). with the windows closed, it will cool 55T070340

faster if you open the windows briefly.


NOTE: • Even under the automatic operation, you
If the “AUTO” on the display blinks, there is can set individual selectors to the man- (14)
a problem in the heating system and/or air ual mode. The manually selected func-
conditioning system. You should have the tions are maintained, and the other
system inspected by Maruti Suzuki autho- functions remain under automatic opera-
rised workshop. tion.
• If the windshield and/or the front door
windows are fogged, push the defrost
switch (5) to turn on the defroster, or
push the air flow selector (4) to change
the air flow to the heat and defrost posi-
tion (f) to defog the windows.
• To return the blower speed selector (2), 55T070350
air intake selector (3), and air flow selec- Be careful not to cover the interior tem-
tor (4) to automatic operation, push the perature sensor (13) located on the climate
“AUTO” switch (8). control panel, or the solar sensor (14)
located at the top of the driver’s side dash-
board. These sensors are used by the
automatic system to regulate temperature.

7-25
OTHER CONTROLS AND EQUIPMENT

Manual Operation NOTE: Maintenance


You can manually control the climate con- If you need maximum defrosting, take the If you do not use the air conditioner for a
trol system. Set the selectors to the following procedure: long period, such as during winter, it may
desired positions. 1) Push the defrost switch (5) to turn on not give the best performance when you
the defroster (the air conditioning sys- start using it again. To help maintain opti-
tem will come on and the fresh air posi- mum performance and durability of your air
tion (b) will be selected automatically). conditioner, it needs to be run periodically.
2) Set the blower speed selector to HIGH. Operate the air conditioner at least once a
3) Adjust the temperature selector to the month for one minute with the engine
“HI” indication on the display. idling. This circulates the refrigerant and oil
4) Adjust the side outlets so the air blows and helps protect the internal components.
on the side windows.
Your air conditioner is equipped with air fil-
ters. Clean or replace them as specified in
“Maintenance Schedule” in the “INSPEC-
TION AND MAINTENANCE” section. Have
this job done by a Maruti Suzuki autho-
rised workshop as the lower glove box
55T070370
must be lowered for this job.

NOTE:
Your vehicle uses the air conditioning
refrigerant HFC-134a, commonly called
R-134a. R-134a replaced R-12 around
1993 for automotive applications. Other
refrigerants are available, including recy-
cled R-12, but only R-134a should be used
in your vehicle.

NOTICE
Using the wrong refrigerant may
damage your air conditioning sys-
tem. Use R-134a only. Do not mix or
replace the R-134a with other refrig-
erants.

7-26
OTHER CONTROLS AND EQUIPMENT

How to Use Air Conditioning Sys- Radio Antenna Installation of Radio


tem Effectively
Parking under the blazing sun
Removal and Installation frequency Transmitters
After parking for a long time under the We recommend that you always ask an
blazing sun, the interior temperature can authorized Maruti Suzuki authorised work-
become very high. Use the air conditioning shop about frequency band, max output
system, with the windows or doors opened power, antenna position of vehicle and
to ventilate the interior. specific conditions for installation and/or
use before installing a radio transmitter in
your vehicle. Such equipments may cause
the electronic control system to malfunc-
tion if they are incorrectly installed or they
are not suited for the vehicle.

63J055

The radio antenna on the roof is remov-


able. To remove the antenna, turn it coun-
terclockwise. To reinstall the antenna, turn
it clockwise firmly by hand.

NOTICE
To avoid damage to the radio
antenna:
• Remove the antenna when using an
automatic car wash.
• Remove the antenna when the
antenna hits anything such as a
low ceiling in a parking garage or
putting a car cover over your vehi-
cle.
• Remove the antenna when parking
your vehicle for a long time on a
snowy day.

7-27
OTHER CONTROLS AND EQUIPMENT

Audio Function NOTE: Remote Audio Controls


Due to poor quality of FM/AM signal, some
When Using Audio System with
disturbance/noise may be heard from (if equipped)
Appropriate Volume not to Disturb
Safe Driving speakers. It is recommended to switch off Controlling basic functions of the audio
the tuner system to prevent the said system is available using the switches on
• When playing music or other audio, if a disturbance/noise in the speaker. the steering wheel.
mobile phone is used inside or nearby The remote audio switches are available
the vehicle, noise may be heard from the when the engine switch is in ACC or ON
speakers. This does not indicate a mal- mode.
function. • For operation of an audio system or a
• Navigation and audio equipment may navigation system, refer to the supple-
not function properly if they are inter- mentary manual, provided along with it.
fered with unauthorized radio waves. • The operating procedure may be differ-
• For further information about the fea- ent depending on an audio system or a
tures of the navigation or audio equip- navigation system.
ment, refer to the instruction manuals.

WARNING
If you operate the navigation or audio
equipment, you may be distracted by
them, resulting in an accident.
Do not operate the navigation or
audio equipment while driving.

NOTICE
While the engine is stopped, using
the navigation or audio equipment for
a long period of time may cause the
lead-acid battery to run out.
Do not use the navigation or audio
equipment for a long period of time
while the engine is stopped.

7-28
OTHER CONTROLS AND EQUIPMENT

Mute Switch (2) Voice Recognition Switch (6)*


(1) (3) (4) To mute this sound, press the switch (2). You can use this switch for the equipment
which has the voice recognition function.
(4) “MODE” Switch (3) To use the function, you need to set up for
Every time you press this switch, the audio the equipment. Refer to the supplementary
modes such as radio, etc. will be switched manual for details.
in order.
Depending on a navigation system or an *: When using Apple CarPlay® or Android
(2) audio systems, you can turn on the system AutoTM on infotainment system
by pressing this switch, even when the
Apple CarPlay® may not be available in
(5) equipment itself is turned off.
your country or region.
For details about Apple CarPlay, visit
Select Switch (4) the following site:
Every time you press this switch, you can http://www.apple.com/ios/carplay
select broadcast station or music accord-
(6) ing to your preference, along with the cur- Android AutoTM may not be available in
rently selected mode. your country or region.
55T070400
For details about Android Auto, please
(1) Volume switch Hands-free Switch (5) refer to the Google support site:
(2) Mute switch You can use this switch for the equipment http://support.google.com/androidauto
(3) “MODE” switch which has the hands-free function. To use
(4) Select switch the function, you need to set up for the
(5) Hands-free switch equipment. Refer to the supplementary
(6) Voice recognition switch manual for details.

Volume Switch (1)


You can adjust volume with this switch.
• To increase the volume, press “+” side.
• To decrease the volume, press “–” side.
• The volume will continue to increase or
decrease until this switch is released.

7-29
OTHER CONTROLS AND EQUIPMENT

Suzuki Connect (if equipped) The communication device equipped with


your vehicle includes free/open source
Suzuki Connect is an advanced Telematics
software.
solution that offers Connected car features
related to Vehicle Alerts & Notifications, The license information and/or source
Safety & Security, Trips & Location & code for free/open source software is
Remote Vehicle Operation. available at the following URL:

Refer to MARUTI SUZUKI website for https://www.denso-ten.com/support/


below details: source/oem/sg1/
1. Feature & Vehicle applicability
2. Terms & Conditions
3. FAQs
4. Suzuki Connect App Manual
5. Help & Contact us
6. Suzuki Connect Alexa Skill Manual
NOTE:
• Application services are subject to
change. It is recommended to install the
latest updates from Google Play/Apple
App store for optimal experience.
• Application functioning is subject to net-
work availability & also depends on
Smartphone hardware & OS perfor-
mance.
• Amazon, Alexa and all related logos are
trademarks of Amazon.com, Inc. or its
affiliates.

7-30
OTHER CONTROLS AND EQUIPMENT

7-31
VEHICLE LOADING AND TOWING

VEHICLE LOADING AND TOWING


Vehicle Loading ................................................................... 8-1
Trailer Towing ...................................................................... 8-1

54G215
VEHICLE LOADING AND TOWING

Vehicle Loading Trailer Towing


Your vehicle was designed for specific WARNING Your vehicle was originally designed to
weight capacities. The weight capacities of • Never overload your vehicle. The carry people and a normal amount of
your vehicle are indicated by the Gross gross vehicle weight (sum of the cargo, not to tow a trailer.
Vehicle Weight Rating (GVWR) and the weights of the vehicle, all the occu-
Permissible maximum Axle Weight (PAW, pants, accessories, cargo plus
front and rear). The GVWR and PAW (front trailer nose weight if towing a
and rear) are listed in the “SPECIFICA- trailer) must never exceed the
TIONS” section. Gross Vehicle Weight Rating
GVWR – Maximum permissible overall (GVWR). In addition, never distrib-
weight of the fully loaded vehicle (including ute a load so that the weight on
all the occupants, accessories and cargo either the front or rear axle exceeds
plus the trailer nose weight if towing a the Permissible maximum Axle
trailer). Weight (PAW).
PAW – (Front and Rear) Maximum permis- • Always distribute cargo evenly. To
sible weight on an individual axle. avoid personal injury or damage to
your vehicle, always secure cargo
Actual weight of the loaded vehicle and to prevent it from shifting if the
actual loads at the front and rear axles can vehicle moves suddenly. Place
only be determined by weighing the vehi- heavier objects on the floor and as
cle. Compare these weights to the GVWR far forward in the cargo area as
and PAW (front and rear). If the gross vehi- possible. Never pile cargo higher
cle weight or the load on either axle than the top of the seat backs.
exceeds these ratings, you must remove
enough weight to bring the load down to
the rated capacity.

8-1
INSPECTION AND MAINTENANCE

INSPECTION AND MAINTENANCE


Maintenance Schedule ....................................................... 9-2
Periodic Maintenance Schedule ........................................ 9-2
Drive Belt ............................................................................. 9-6
Engine Oil and Filter ........................................................... 9-6
Engine Coolant .................................................................... 9-10
Air Cleaner ........................................................................... 9-11
Spark Plugs ......................................................................... 9-12
Gear Oil ................................................................................ 9-12
Clutch ................................................................................... 9-13
Brakes .................................................................................. 9-14
Steering Wheel .................................................................... 9-18
Tyres ..................................................................................... 9-18
Battery .................................................................................. 9-21
Fuses .................................................................................... 9-24
Headlight Aiming ................................................................. 9-27
Bulb Replacement ............................................................... 9-28 9
60G410
Wiper Blades ....................................................................... 9-39
Windshield Washer Fluid ................................................... 9-42
Air Conditioning System .................................................... 9-42
Preparation Before Winter Season .................................... 9-43
INSPECTION AND MAINTENANCE

WARNING WARNING
(Continued) (Continued)
• When the engine is running, keep • Do not get under your vehicle if it is
hands, clothing, tools, and other supported only with the portable
objects away from the fan and drive jack provided in your vehicle.
belt. Even though the fan may not • Be careful not to cause accidental
59RN05750
be moving, it can automatically short circuits between the positive
turn on without warning. and negative battery terminals.
WARNING • When it is necessary to perform • Keep used oil, coolant, and other
service work with the engine run- fluids away from children and pets.
Take extreme care when working on ning, check that the parking brake Dispose of used fluids properly;
your vehicle to prevent accidental is set fully and the transmission is never pour them on the ground,
injury. Carefully observe the follow-
ing precautions: in Neutral. into sewers, etc.
• To prevent damage or unintended • Do not touch ignition wires or other
activation of the airbag system or ignition system parts when starting
seat belt pretensioner system, check the engine or when the engine is
that the lead-acid battery is discon- running, or you could receive an
nected and the ignition switch has electric shock.
been in “LOCK” position or the igni- • Be careful not to touch a hot
tion mode has been in LOCK (OFF) engine, exhaust manifold and
position for at least 90 seconds pipes, muffler, radiator and water
before performing any electrical ser- hoses.
vice work on your Maruti Suzuki • Do not allow smoking, sparks, or
vehicle. Do not touch airbag system flames around fuel or the battery.
components, seat belt pretensioner Flammable fumes are present.
system components or wires. (Continued)
The wires are wrapped with yellow
tape or yellow tubing, and the cou-
plers are yellow for easy identifica-
tion.
• Do not leave the engine running in
garages or other confined areas.
(Continued)

9-1
INSPECTION AND MAINTENANCE

Maintenance Schedule Periodic Maintenance


WARNING
The following table shows the timing when Schedule
you should perform regular maintenance MARUTI SUZUKI recommends that
on your vehicle. This table shows in kilo- maintenance on your Maruti Suzuki
meters and months when you should per- NOTICE
vehicle should be performed by
form inspections, adjustments, lubrication Maruti Suzuki authorised workshop. Whenever it becomes necessary to
and other services. replace parts on your vehicle, it is
recommended that you use genuine
MARUTI SUZUKI replacement parts
or their equivalent.

“C”: Clean
“R”: Replace or Change
“I”: Inspect, clean, adjust, lubricate or
replace as necessary
“L”: Lubricate
“T”: Tighten to Specified Torque
“O”: Rotate

NOTE:
This table includes services as scheduled
up to 80,000 km mileage. Beyond 80,000
km, carry out the same services at the
same intervals respectively.

9-2
INSPECTION AND MAINTENANCE

FREE INSPECTION PERIODIC MAINTENANCE AT COST


Interval: This interval should be judged by odometer reading
or months, whichever comes first. km (x1000) 1 5 10 20 30 40 50 60 70 80
months 1 6 12 24 36 48 60 72 84 96
ENGINE
1-1. Water pump drive belt (Wear) - - I I I I I I I R
1-2. Engine coolant (Level, Leakage) l l l R l R l R l R
1-3. Engine oil, engine oil filter and drain plug gasket (Level, Leakage) I I R R R R R R R R
1-4. Cooling system hoses and connections (Leakage and Damage) l l l l l l l l l l
1-5. Engine mounting and manifold fixing (Loose Damage) - - I - I - I - I -
1-6. Exhaust system (Noise, Leakage etc.) - l - l - I - I - l
Positive crank case ventilation system
1-7. - l - l - I - I - l
(Hoses, Connections and Valve)
IGNITION
2-1. Ignition wire (Damage, Deterioration) - - - l - l - l - l
Petrol Replace every 100,000 KM or 84 months whichever comes first
2-2. Spark plug
CNG Replace every 50,000 KM or 48 months whichever comes first
FUEL
Paved-road Clean every 5,000 KM. Replace after every 40,000 KM
3-1. Air cleaner filter element
Dusty Condition Clean every 2,500 KM or as required. Replace after every 40,000 KM
3-2. Fuel tank cap, fuel lines and connections (Leakage and Damage) - l - - - l - - - l
3-3. Fuel tank - - - - - l - - - l
I I I I I I I I I I
3-4. Fuel filter (Leakage)
Replace every 100,000 KM or 120 months whichever comes first
CLUTCH AND TRANSMISSION
4-1. Clutch pedal (Play) I I I I I I I I I I
I I I I I I I I I I
4-2. Clutch Fluid (Level, Leakage)
Replace every 40,000 KM or 24 months whichever comes first.
4-3. Clutch slipping (Dragging or Excess Damage) I I l l l l l l l l
4-4. Manual / Auto Gear Shift (AGS) - Transmission oil (Level, Leakage) l l l l l l l l l l
4-5. Gear shifter (Operation) I I l l l l l l l l
4-6. AGS Actuator oil (Level, Leakage) AGS model I I l l l l l l l l

9-3

55TH0-74E
INSPECTION AND MAINTENANCE

FREE INSPECTION PERIODIC MAINTENANCE AT COST


Interval: This interval should be judged by odometer reading
or months, whichever comes first. km (x1000) 1 5 10 20 30 40 50 60 70 80
months 1 6 12 24 36 48 60 72 84 96
DRIVE SHAFT
5-1. Drive shaft noise I I I I I I I I I I
5-2. Drive shaft boot (Damage) - l l l l l l l l l
BRAKE
I I I I I I I I I I
6-1. Brake fluid (Level, Leakage)
Replace every 40,000 KM or 24 months whichever comes first.
6-2. Brake pedal (Pedal - carpet clearance) I I I I I I I I I I
6-3. Parking brake lever and cable (Play, Damage) I I I I I I I I I I
6-4. Brake disc and pad (Wear) - I I I I I I I I I
6-5. Brake drum and shoes (Wear) - - I I I I I I I I
Master cylinder, wheel cylinder, caliper piston
6-6. I I I I I I I I I I
(Fluid leakage, Boot/Seal damage)
6-7. Brake hoses and pipes (Fluid leakage, Damage) I I I I I I I I I I
WHEEL
7-1. Tyres (Air pressure, Abnormal wear, Crack and Rotation) I I&O I&O I&O I&O I&O I&O I&O I&O I&O
7-2. Wheels (Damage) I I I I I I I I I I
7-3. Front/Rear wheel bearing (Loose, Damage) I I I I I I I I I I
FRONT / REAR SUSPENSION
8-1. Suspension strut (Oil leakage, Damage) I I I I I I I I I I
8-2. Suspension arms / Knuckle support and Torsion rods (Loose, Damage) - I I I I I I I I I
8-3. Rear spring (Damage) I I I I I I I I I I
8-4. Shock absorbers (Oil leakage, Damage) I I I I I I I I I I
8-5. All bolts and nuts (Loose) - T T T T T T T T T

9-4

55TH0-74E
INSPECTION AND MAINTENANCE

FREE INSPECTION PERIODIC MAINTENANCE AT COST


Interval: This interval should be judged by odometer reading
or months, whichever comes first. km (x1000) 1 5 10 20 30 40 50 60 70 80
months 1 6 12 24 36 48 60 72 84 96
STEERING
9-1. Steering wheel (Play, Loose) I I I I I I I I I I
9-2. All rods and arms (Loose, Damage, Wear) I I I I I I I I I I
9-3. Tilt / Telescopic (if equipped) steering (Operation) I I I I I I I I I I
ELECTRICAL
10-1. Battery - Electrolyte (Level, Leakage) and voltage I I I I I I I I I I
10-2. Wiring harness connection (Loose, Damage) - I I I I I I I I I
10-3. Lighting system (Operation, Stains, Damage) I I I I I I I I I I
10-4. Wiper (Operation) I I I I I I I I I I
10-5. Horn (Operation) I I I I I I I I I I
10-6. USB (if equipped), USB charger (if equipped) and accessory socket - I I I I I I I I I
(Operation)
BODY
11-1. All chassis bolts and nuts (Tighten) - I T T T T T T T T
11-2. All latches, hinges and locks (Function) I I&L I&L I&L I&L I&L I&L I&L I&L I&L
ROAD TEST
12-1. Operation of Brakes, gear shifting and speedometer I I I I I I I I I I
12-2. Body and chassis noise I I I I I I I I I I
AIR CONDITIONER
13-1. Check belt tension I I I I I I I I I I
13-2. Tighten compressor mounting bolt - T T T T T T T T T
13-3. All hose joint (Check, Tighten) I I I I I I I I I I
13-4. Check functioning of recirculating flap I I I I I I I I I I
13-5. Clean condenser with low pressure water - C C C C C C C C C
13-6. Check belt for frayed edges I I I I I I I I I I
13-7. Check all mounting bolts I I I I I I I I I I
13-8. Air conditioner filter element I I I I R I I R I I

9-5
INSPECTION AND MAINTENANCE

Drive Belt Engine Oil and Filter For India, check that the engine oil you use
comes under the quality classification of
Specified Oil API SN. Select the appropriate oil viscosity
WARNING according to the above chart
For India
When the engine is running, keep
Except for India, be sure that the engine oil
hands, hair, clothing, tools, etc. away
you use comes under the quality classifica-
from the moving fan and drive belts.
(1) tion as listed below.
• API SL, SM, SN, SP
The drive belts tension is adjusted auto- • ILSAC GF-6
0W-16
matically. If the belt is too loose, insufficient o
C -30 -20 -10 0 10 20 30 40
battery charging, engine overheating, poor o
F -22 -4 14 32 50 68 86 104 SAE 0W-16 (1) is the best choice for good
power steering, poor air conditioning, or fuel economy and good startability in cold
excessive belt wear can result. weather.
The belts should also be examined to
ensure that they are not damaged. NOTE:
56RM07013
• The replacement timing varies with the
If you need to replace or adjust the belt (1) Preferred type of engine oil that you choose. Refer
have it done by your Maruti Suzuki autho- to “Maintenance schedule” in this sec-
rised workshop. Except for India tion for corresponding maintenance
schedule.
• We recommend that you use MARUTI
SUZUKI genuine oil. To purchase it, see
a Maruti Suzuki authorised workshop.
5W-30
(1) 0W-20

0W-16
o
C -30 -20 -10 0 10 20 30 40
o
F -22 -4 14 32 50 68 86 104

55T090690

(1) Preferred

9-6
INSPECTION AND MAINTENANCE

Oil Level Check Changing Engine Oil and Filter


NOTICE Drain the engine oil while the engine is still
warm.
Failure to check the oil level regularly
could lead to serious engine trouble
due to insufficient oil.

Refilling

Upper
Lower Open Close

55T090120

It is important to keep the engine oil at the


55T090150
correct level for proper lubrication of your
vehicle’s engine. Check the oil level with 1) Remove the oil filler cap.
the vehicle on a level surface. The oil level
indication may be inaccurate if the vehicle
is on a slope. The oil level should be
checked either before starting the engine 55T090140
or at least 5 minutes after stopping the Remove the oil filler cap and pour oil slowly
engine. through the filler hole to bring the oil level
Pull out the oil dipstick, wipe the oil off with to the upper limit on the dipstick. Be careful
a clean cloth, insert the dipstick all the way not to overfill the oil. Too much oil is almost
into the engine, and then remove it again. as bad as too little oil. After refilling, start the
The oil on the stick should be between the engine and allow it to idle for about a min-
upper and lower limits shown on the stick. ute. Stop the engine, wait about 5 minutes
If the oil level indication is near the lower and check the oil level again.
limit, add enough oil to raise the level to
the upper limit.

9-7
INSPECTION AND MAINTENANCE

Oil Filter Replacement


WARNING 1) Remove the screws (1), and then rotate
(1) the engine under cover (2).
(1) Engine oil can be hazardous. Chil-
2) Using an oil filter wrench, turn the oil fil-
dren and pets may be harmed by
ter counterclockwise and remove it.
swallowing new or used oil. Keep
(2) 3) Using a clean rag, wipe off the mount-
new and used oil and used oil filters
ing surface on the engine where the
away from children and pets.
new filter will be seated.
(1) Repeated, prolonged contact with
4) Smear a small amount of engine oil
used engine oil may cause skin can-
around the rubber gasket of the new oil
cer.
filter.
Brief contact with used oil may irri-
5) Screw the new filter by hand until the fil-
tate skin.
ter gasket contacts the mounting sur-
To minimize your exposure to used
face.
oil, wear a long-sleeve shirt and
moisture-proof gloves (such as dish-
washing gloves) when changing oil. If (1)
oil contacts your skin, wash thor-
oughly with soap and water.
55T090170 Launder any clothing or rags if it is
2) Remove the screws (1), and then rotate with oil. (2)
the engine under cover (2). Recycle or properly dispose of used
3) Place a drain pan under the drain plug. oil and oil filters.
(1)
4) Using a wrench, remove the drain plug
and drain the engine oil. 5) Reinstall the drain plug with new gas-
ket. Tighten the plug with a wrench to (1)
(3)
CAUTION the specified torque. (4)
The engine oil temperature may be NOTE:
high enough to burn your fingers Ask a Maruti Suzuki authorised workshop
when the drain plug is loosened. Wait for changing engine oil and filter if you
until the drain plug is cool enough to have difficulties. 55T090180
touch with your bare hands.
(3) Loosen
Tightening torque for drain plug: (4) Tighten
35 Nm (3.6 kg-m, 25.8 lb-ft)

9-8
INSPECTION AND MAINTENANCE

Tightening (viewed from filter top) 6) Tighten the filter as specified below Refilling with Oil and Oil Leakage
from the point of contact with the Check
((6) mounting surface (or to the specified 1) Pour oil through the filler hole and
torque) using an oil filter wrench. install the filler cap.
Tightening torque for oil filter: For the approximate capacity of the oil,
3/4 turn or refer to “Recommended fuel / lubricants
14 Nm (1.4 kg-m, 10.3 lb-ft) and capacities (approx.)” in “SPECIFI-
CATIONS” section.
2) Start the engine and carefully check the
NOTICE oil filter and the drain plug for leakage.
To prevent oil leakage, check that the Run the engine at various speeds for at
(5)) oil filter is tight, but do not over- least 5 minutes.
tighten it. 3) Stop the engine and wait about 5 min-
utes. Check the oil level again and add
55T090190
oil if necessary. Check for leakage
again.
(5) Oil filter
(6) 3/4 turn NOTICE
NOTICE • When replacing the oil filter, it is
recommended that you use a genu-
To tighten the oil filter properly, it is ine MARUTI SUZUKI replacement
important to accurately identify the filter. If you use an aftermarket fil-
position at which the filter gasket ter, check that it is of equivalent
first contacts the mounting surface. quality and follow the manufac-
turer’s instructions.
• Oil leakage from the periphery of
the oil filter or drain plug indicate
incorrect installation or gasket
damage. If you find any leakage or
are not sure that the filter has been
properly tightened, have the vehi-
cle inspected by a Maruti Suzuki
authorised workshop.

9-9
INSPECTION AND MAINTENANCE

Engine Coolant Coolant Level Check


NOTICE Check the coolant level at the reservoir
Selection of Coolant To avoid damaging your cooling sys-
tank, not at the radiator. With the engine
To maintain optimum performance and cool, the coolant level should be between
tem:
durability of your engine, use MARUTI “FULL” and “LOW” marks.
• Always use a high quality ethylene
SUZUKI genuine coolant or equivalent.
glycol base non-silicate type cool- Adding Coolant
This type of coolant is the best for cooling ant diluted with distilled water at
system for the following reasons: the correct mixture concentration. WARNING
• The coolant helps maintain proper • Check that the proper mix is 30/70
coolant to distilled water and in no Swallowing engine coolant can cause
engine temperature. severe injury or death. Inhaling cool-
• It gives proper protection against freez- case higher than 70/30. Concentra-
tions greater than 70/30 coolant to ant mist or vapors or getting coolant
ing and boiling. in your eyes could result in severe
• It gives proper protection against corro- distilled water will cause overheat-
ing conditions. injury.
sion and rust. • Do not drink antifreeze or coolant
• Do not use straight coolant nor
Failure to use the proper coolant can dam- plain water. solution. If swallowed, do not
age your cooling system. Your Maruti • Do not add extra inhibitors or addi- induce vomiting. Immediately con-
Suzuki authorised workshop can help you tives. They may not be compatible tact a poison control center or a
select the proper coolant. with your cooling system. physician.
• Do not mix different types of base • Avoid inhaling coolant mist or hot
coolants. Doing so may result in vapors. If inhaled, remove to a
accelerated seal wear and/or the fresh air area.
possibility of severe overheating • If coolant gets in the eyes, flush
and extensive engine/automatic with water and seek medical atten-
transmission damage. tion.
• Wash thoroughly after handling
coolant.
• Keep engine coolant out of the
reach of children and pets.

9-10
INSPECTION AND MAINTENANCE

Air Cleaner
NOTICE NOTICE If the air cleaner is clogged with dust, there
• The mixture you use should con- When putting the cap on the reser- will be greater intake resistance, resulting
tain 50% concentration of anti- voir tank, line up the mark on the cap in decreased power output and increased
freeze. and the mark on the tank. Failure to fuel consumption.
• If the lowest ambient temperature follow this can result in coolant leak-
in your area is expected to be –35°C age.
(–31°F) or below, use higher con-
centrations up to 60% following the (2)
instructions on the antifreeze con- Coolant Replacement
tainer. Since special procedures are required, ask
a Maruti Suzuki authorised workshop for
this job.
(1)

(1)
(1)

55T090220

1) Unclamp the side clamps (1).


2) Hold up the air cleaner upper case (2).
3) Remove the element from the air
cleaner case. If it appears to be dirty,
clean or replace it with a new one.
55T090200
4) Reinstall the air cleaner case securely.
If the coolant level is below “LOW” mark,
coolant should be added. While the engine
is cool, remove the reservoir tank cap and
add coolant until the reservoir tank level
reaches “FULL” mark. Never fill the reser-
voir tank above “FULL” mark.

9-11
INSPECTION AND MAINTENANCE

Spark Plugs Gear Oil Gear Oil Level Check


Spark Plug Replacement and Manual Transmission Oil / Auto
Inspection Gear Shift oil (1)
When adding gear oil, use gear oil with the
Since special procedures, materials and
appropriate viscosity and grade as shown
tools are required, it is recommended that
in the chart below.
you trust this job to a Maruti Suzuki autho-
rised workshop. We highly recommend you use:
“MARUTI GENUINE GEAR OIL 75W” for
manual transmission oil / auto gear shift
oil.
68KH073
Manual transmission oil / Auto Gear
Shift oil (1) Oil filler and level plug
To check the gear oil level, use the fol-
lowing procedure:
75W 1) Park the vehicle on a level surface with
o
the parking brake applied. Then, stop
C -30 -20 -10 0 10 20 30 40 the engine.
o
F -22 -4 14 32 50 68 86 104 2) Remove the oil filler and level plug.
75
3) If gear oil flows from the plug hole, the
56RM07006 oil level is correct. Reinstall the plug. If
gear oil does not flow from the plug
hole, add oil through the filler plug hole
until oil flows a little from the plug hole.

Tightening torque for oil filler and


level plug
Manual transmission (1)
21 Nm (2.1 kg-m, 15.5 lb-ft)
Auto Gear Shift (1)
21 Nm (2.1 kg-m, 15.5 lb-ft)

9-12
INSPECTION AND MAINTENANCE

Clutch Clutch Fluid


CAUTION
After driving the vehicle, the gear oil
Clutch Pedal
temperature may be high enough to
burn you. Wait until the oil filler and
level plug are cool enough to touch
with your bare hands before inspect- MAX
ing gear oil level.

MIN
NOTICE
When tightening the plug, apply the
following sealing compound or
equivalent to the plug threads to pre-
vent oil leakage. “d”
55T090010

MARUTI SUZUKI Bond No. “1217G” Check the clutch pedal for smooth opera-
54G274
tion and clutch fluid level from time to time.
Gear Oil Change If clutch dragging is felt with the pedal fully
Clutch pedal play “d”:
Since special procedures, materials and depressed, have the clutch inspected by a
MAX 10 mm
tools are required, ask a Maruti Suzuki Maruti Suzuki authorised workshop. If the
authorised workshop for this job. Measure the clutch pedal play by moving clutch fluid level is near “MIN” line, fill it up
the clutch pedal with your hand and mea- to “MAX” line with DOT3 or SAE J1703
suring the distance it moves until you feel brake fluid.
slight resistance. The play in the clutch
pedal should be less than the specified
values. If the play is more than the above,
or clutch dragging is felt with the pedal fully
depressed, have the clutch inspected by a
Maruti Suzuki authorised workshop.

9-13
INSPECTION AND MAINTENANCE

Brakes
NOTICE WARNING
Clutch fluid is supplied from brake
Brake Fluid • Failure to follow the guidelines
fluid reservoir. If your clutch fluid below can result in personal injury
level is increased or near the “MIN” or serious trouble in the brake sys-
line, there is a possibility of clutch or tem.
brake fluid leakage or abnormal wear – If the brake fluid in the reservoir
of clutch. drops below a certain level, the
Have your vehicle inspected immedi- MAX brake warning light on the instru-
ately by a Maruti Suzuki authorised ment cluster will come on (the
workshop. engine must be running with the
MIN
parking brake fully disengaged).
Should the light come on, imme-
diately ask a Maruti Suzuki
authorised workshop to inspect
the brake system.
55T090010
– A rapid fluid loss indicates leak-
age in the brake system. In this
Check the brake fluid level by looking at case, immediately ask a Maruti
the reservoir in the engine compartment. Suzuki authorised workshop to
Check that the fluid level is between “MAX” inspect the brake system.
and “MIN” lines. – Do not use any fluid other than
DOT3 or SAE J1703 brake fluid.
Do not use reclaimed fluid or
fluid that has been stored in old
or open containers. It is essential
that foreign particles and other
liquids are kept out of the brake
fluid reservoir.
(Continued)

9-14
INSPECTION AND MAINTENANCE

NOTE: Brake Pedal


WARNING • The fluid level can be expected to gradu- Check brake pedal stroke. If the stroke is
ally fall as the brake pad and/or shoe so large, have the brake system inspected
(Continued) wear. by a Maruti Suzuki authorised workshop. If
• Brake fluid is harmful or fatal if • Brake fluid absorbs water over time and you doubt the brake pedal is at its normal
swallowed, and harmful if it comes brake fluid with high water content may height, check it as follows:
in contact with skin or eyes. If swal- cause vapor lock or brake system mal-
lowed, do not induce vomiting. function.
Immediately contact a poison con- Replace the brake fluid according to the
trol center or a physician. If brake maintenance schedule in this owner’s
fluid gets in eyes, flush eyes with manual.
water and seek medical attention.
Wash thoroughly after handling.
Solution can be poisonous to ani-
mals. Keep out of reach of children
and animals.
“a”

NOTICE
• If your brake fluid level is near the 54G108
“MIN” line, there is a possibility of Minimum distance between brake pedal
brake pad and/or shoe wear and and floor carpet “a”
brake fluid leakage. In this case,
ask a Maruti Suzuki authorised 53 mm
workshop to inspect the brake sys-
tem.
• Brake fluid can damage painted
surfaces. Be careful when refilling
the reservoir.

9-15
INSPECTION AND MAINTENANCE

With the engine running, measure the dis-


tance between the brake pedal and floor EXAMPLE CAUTION
carpet when the pedal is depressed with
approximately 30 kg of force. The mini- If you experience any of the following
mum distance required is as specified. problems with your vehicle’s brake
Since your vehicle’s brake system is self- system, have the vehicle inspected
adjusting, there is no need for pedal immediately by a Maruti Suzuki
adjustment. authorised workshop.
If the pedal to floor carpet distance as • Poor braking performance
measured above is less than the minimum • Uneven braking (brakes not work-
distance required, have your vehicle ing uniformly on all wheels)
inspected by a Maruti Suzuki authorised • Excessive pedal travel
workshop. • Brake dragging

NOTE: 52RM70500
• When measuring the distance between
the brake pedal and floor wall, be sure WARNING
not to include the floor mat or rubber on
the floor carpet in your measurement. If the brake pad lining becomes worn
• Measure the distance at the brake and it has reached its minimum thick-
pedal’s side facing toward the driver’s ness, squealing noise sounds during
door. braking.
If you hear this noise, have the vehi-
cle inspected immediately by a
Maruti Suzuki authorised workshop.
Continued driving with this condition
can cause an accident.

9-16
INSPECTION AND MAINTENANCE

Parking Brake Brake Discs and Brake Drums Brake drum


Brake disc

“a” “a”

“b”

“b”

55T090660
55T090270
55T090650
Ratchet tooth specification “b”: Maximum inner
4th – 9th Brake location
diameter “b”
Lever pull force (1): Brake location Minimum thickness “a”
200 N (20 kg) Rear wheels 202 mm
Front wheels 18.0 mm
Check the parking brake for proper adjust- If the measured thickness or inner diame-
ment by counting the number of clicks ter of the most worn part falls below or
made by the ratchet teeth as you slowly exceeds the value indicated above, the
pull up on the parking brake lever to the parts should be replaced with a new one.
point of full engagement. The parking The measurement involves disassembling
brake lever should stop between the speci- each brake and requires the use of a
fied ratchet teeth and the rear wheels micrometer or caliper, which must be done
should be securely locked. If the parking according to the instructions described in
brake is not properly adjusted or the the relevant service manual or available
brakes drag is suspected even after the from the relevant repair information site.
lever has been fully released, have the
parking brake inspected and/or adjusted by
a Maruti Suzuki authorised workshop.

9-17
INSPECTION AND MAINTENANCE

Steering Wheel Tyres Tyre Inspection


Inspect your vehicle’s tyres at least once a
month or before long trip by performing the
following checks:
1) Measure the air pressure with a tyre
gauge. Adjust the pressure if neces-
(1) sary.

“c” WARNING
• Air pressures should be checked
when the tyres are cold or you may
get inaccurate readings.
• Check the tyre pressure from time
to time while inflating the tyre grad-
55T090090 55T090020 ually, until the specified pressure is
obtained.
Steering wheel play “c”: 0–30 mm The front and rear tyre pressure specifica- • Never under-inflate or over-inflate
tions are listed in the tyre information label the tyres.
Check the free play of the steering wheel (1). Both front and rear tyres should have Under-inflation can cause unusual
by gently turning it from left to right and the specified tyre pressure. handling characteristics or can
measuring the distance that it moves cause the rim to slip on the tyre
Note that the value does not apply to the
before you feel slight resistance. The play bead, resulting in an accident or
compact spare tyre, if equipped.
should be between the specified values. damage to the tyre or rim.
Check that the steering wheel turns easily Over-inflation can cause the tyre to
and smoothly without rattling by turning it burst, resulting in personal injury.
all the way to the right and to the left while Over-inflation can also cause
driving very slowly in an open area. If the unusual handling characteristics
amount of free play is not as specified or which may result in an accident.
you find anything else to be wrong, an
inspection must be performed by a Maruti
Suzuki authorised workshop.

9-18
INSPECTION AND MAINTENANCE

CAUTION WARNING
Hitting curbs and running over rocks (Continued)
(1) can damage tyres and affect wheel • Replacing the wheels and tyres
alignment. Have tyres and wheel equipped on your vehicle with cer-
alignment checked periodically by a tain combinations of aftermarket
Maruti Suzuki authorised workshop. wheels and tyres can significantly
change the steering and handling
4) Check for loose wheel nuts. characteristics of your vehicle.
5) Check that there are no nails, stones or • Therefore, use only those wheel
(2) other objects sticking into the tyres. and tyre combinations approved by
MARUTI SUZUKI as standard or
WARNING optional equipment for your vehi-
52KM110
cle.
• Your MARUTI SUZUKI vehicle is
(1) Tread wear indicator equipped with tyres which are all
(2) Indicator location mark the same type and size. This is NOTICE
important to ensure proper steer-
• Replacing the original tyres with
2) Check that the depth of the tread ing and handling of the vehicle.
tyres of a different size may result
groove is more than 1.6 mm. To help Never mix tyres of different size or
in false speedometer or odometer
you check this, the tyres have molded- type on the four wheels of your
readings. Check with a Maruti
in tread wear indicators in the grooves. vehicle. The size and type of tyres
Suzuki authorised workshop before
When the indicators appear on the used should be only those
purchasing replacement tyres that
tread surface, the remaining depth of approved by MARUTI SUZUKI as
differ in size from the original tyres.
the tread is 1.6 mm or less and the tyre standard or optional equipment for
• Replacing a tyre with one of a dif-
should be replaced. your vehicle.
ferent size, or using different
3) Check for abnormal wear, cracks and (Continued)
brands among the four tyres can
damage. Any tyres with cracks or other
result in damage to the drive train.
damage should be replaced. If any
tyres show abnormal wear, have them
inspected by a Maruti Suzuki autho-
rised workshop.

9-19
INSPECTION AND MAINTENANCE

Tyre Rotation To avoid uneven wear of your tyres and to Care and maintenance tips for tubeless
prolong their life, rotate the tyres as illus- tyres
4-tyre rotation (Vehicle with 195/55R16 trated. Tyres should be rotated every 1) Always maintain recommended infla-
87H tyre) 10000 km. After rotation, adjust front and tion pressure. Driving continuously at
rear tyre pressures to the specification low inflation pressure can lead to tyre
listed on your vehicle’s Tyre Information damage.
Label. 2) In case any leakage is found, check for
any nail penetration/valve core damage
Wheel Balancing or rim bent. Damaged wheel must not
If the vehicle vibrates abnormally on be used.
smooth road, have the wheel balanced at 3) In case tyre has run at low pressure, it
a Maruti Suzuki authorised workshop. must be inspected for any defect.
4) Whenever new tyre is fitted, replace the
Wheel Alignment valve.
In case of abnormal tyre wear or pulling 5) If continuous high speed driving is
towards one side, have the wheel aligned required, increase tyres pressure by 5
65D459 at a Maruti Suzuki authorised workshop. psi over recommended inflation pres-
sure.
5-tyre rotation (Vehicle with 185/65R15 Tubeless Tyres 6) Never run the tyre beyond TWI (Tread
88H tyre) The vehicle is equipped with Tubeless wear indicator). The tyre is recom-
Tyres. In tubeless tyre, a thin layer of butyl mended to be replaced when the
rubber is used for lining the inside of the remaining tread has worn to this point.
tubeless tyre. This layer is to prevent air The indicators are spaced across the
loss and fulfilling the purpose of tube. The tread around the tyre marked by a trian-
air pressure is maintained by the sealing gular symbol (TWI).
between tyre bead and wheel rim. Tube- 7) Always prefer tubeless tyre mounting
less tyres are having advantage of slow air machine. In case of manual mounting-
loss and preventing sudden deflation while tyre/wheel rim damage may occur.
driving. 8) In case of any problem, please get in
touch with a Maruti Suzuki authorised
workshop.

55T090680

9-20
INSPECTION AND MAINTENANCE

Temporary Spare Tyre (if equipped) Battery


Your vehicle comes equipped with the WARNING
temporary spare tyre. It is only intended for
temporary emergency use, until the con-
The temporary spare tyre and wheel WARNING
are intended for temporary emergency • Batteries produce flammable
ventional tyre can be repaired or replaced.
use only. Continuous use of this spare hydrogen gas. Keep flames and
The inflation pressure of the temporary
can result in tyre failure and loss of sparks away from the battery or an
spare tyre should be checked at least
control. Always observe these precau- explosion may occur. Never smoke
monthly. At the same time, check that the
tions when using this spare: when working near the battery.
tyre is stored securely. If it is not, tighten it.
• Your vehicle will handle differently
• When checking or servicing the
with this temporary spare.
Note that two or more temporary spare battery, disconnect the negative
• Do not exceed 80 km/h speed (only
tyres should not be used on one vehicle cable. Be careful not to cause a
vehicle with 195/55R16 87H tyre).
simultaneously. short circuit by allowing metal
• Replace this spare with a standard
objects to contact the battery posts
tyre and wheel as soon as possible.
and the vehicle at the same time.
• Use of this spare may reduce
• To avoid harm to yourself or dam-
ground clearance.
age to your vehicle or battery, fol-
• Set the specified tyre pressure indi-
low the jump-starting instructions
cated on the tyre information label
in “EMERGENCY SERVICE” sec-
located on the driver’s door lock
tion if it is necessary to jump-start
pillar.
your vehicle.
• Do not use tyre chains on the tem-
• Diluted sulfuric acid spilled from
porary spare. If you must use tyre
battery can cause blindness or
chains, rearrange the wheels so
severe burns. Use proper eye pro-
standard tyres and wheels are fit-
tection and gloves. Flush eyes or
ted to the front axle.
body with ample water and get
• The temporary spare tyre has a
medical care immediately if suf-
much shorter tread life than the
fered. Keep batteries out of reach
conventional tyres on your vehi-
of children.
cle. Replace the tyre as soon as the
tread wear indicator appears.
• When replacing the temporary
spare tyre, use a replacement tyre
with the exact same size and con-
struction.

9-21
INSPECTION AND MAINTENANCE

WARNING NOTICE
If the battery is used with battery (Continued)
level being less than the lower level • If your vehicle is equipped with the
(1) line “MIN” (2), it may cause reduced ENG A-STOP system and the bat-
battery life, an exothermic heat, or an tery which is exclusive for the ENG
explosion by hydrogen gas occurring A-STOP system is used, only use
from the battery. Do not use the bat- the specified type of battery for
(2) tery with battery level being less than ENG A-STOP system. Refer to
the lower level line “MIN” (2). “SPECIFICATIONS” section for
details. Otherwise, you could dam-
age your vehicle, and the ENG A-
NOTICE STOP system could not be avail-
59RN09430 • If the battery liquid is added more able. If a vehicle battery has to be
than the upper level line “MAX” (1), replaced, consult a Maruti Suzuki
For maintenance-free battery (cap-less authorised workshop.
liquid may leak by vibrations
type), you need not add water. For tradi-
during driving or liquid may spray
tional type battery, which has water filler
out in some case depending on the NOTE:
caps, the level of the battery solution must
condition of battery charging. The battery liquid is consumed when the
be kept between the upper level line
These may cause damage to the battery is used. If the level is found to be
“MAX” (1) and the lower level line “MIN” (2)
parts near the battery. If the battery less than the center of upper level “MAX”
at all times. If the level is found to be below
liquid overspills, immediately wash (1) and lower level “MIN” (2), add distilled
the lower level line (2), add distilled water
away with water. Do not add the water till it reaches the upper level line
to the upper level line (1). You should peri-
battery liquid more than the upper “MAX” (1).
odically check the battery, battery termi-
level line “MAX” (1).
nals, and battery hold-down bracket for
(Continued)
corrosion. Remove corrosion using a stiff
brush and ammonia mixed with water, or
baking soda mixed with water. After
removing corrosion, rinse with clean water.
If your vehicle is not going to be driven for
a month or longer, disconnect the cable
from the negative terminal of the battery to
help prevent discharge.

9-22
INSPECTION AND MAINTENANCE

Replacement of the Battery NOTE:


• When the battery is disconnected, some NOTICE
(3) (1) of the vehicle’s functions will be initial-
ized and/or deactivated. After stopping the engine, controller
These functions must be required to and system are operated for a while.
(2) Therefore, before removing the bat-
reset after the battery is reconnected.
• Do not disconnect the battery terminals tery, wait for more than one minute
for at least one minute after the ignition after turning the ignition switch to
switch is turned off, or the engine switch “OFF” or changing the ignition mode
is pressed to change the ignition mode to “LOCK” (OFF).
(4)
to “LOCK” (OFF).

WARNING
Batteries contain toxic substances
68PM00711
including sulfuric acid and lead. They
could have potential negative conse-
To remove the battery: quences for the environment and
1) Disconnect the negative cable (1). human health. Used batteries must
2) Disconnect the positive cable (2). be disposed of or recycled according
3) Remove the retainer nuts (3) and to applicable rules or regulations and
remove the retainer (4). must not be disposed of with ordi-
To install the battery: nary household trash. Make sure not
1) Install the battery in the reverse order of to tip over the battery when you
removal. remove it from the vehicle. Other-
2) Tighten the bracket bolt and battery wise, sulfuric acid could run out and
cables securely. you might get injury.

9-23
INSPECTION AND MAINTENANCE

(Battery label) Fuses (2)


Your vehicle has three types of fuses, as
described below:
Main fuse
The main fuse takes current directly from
(5) the lead-acid battery.
Primary fuses
These fuses are between the main fuse
and individual fuses, and are for electrical
load groups.

Pb (6)

51KM042
Individual fuses
These fuses are for individual electrical cir-
cuits.
55T090720

(2) Spare fuse


(5) Crossed-out wheeled bin symbol To remove a fuse, use the fuse puller pro-
(6) Chemical symbol of “Pb” vided in the fuse box cover and relay box. Fuses in Engine Compartment
The crossed-out wheeled bin symbol (5)
located on the battery label indicates that
the used battery should be collected sepa- (4)
rately from ordinary household trash. The
chemical symbol of “Pb” (6) indicates the (2) (1) (3)
battery contains more than 0.004% lead.
By ensuring the used battery is disposed
of or recycled correctly, you will help pre-
vent potential negative consequences for
the environment and human health, which
could otherwise be caused by inappropri-
ate trash handling of the battery. The recy-
55T090640
cling of materials will help to conserve 55T090600
natural resources. For more detailed infor- (1) Fuse puller
mation about disposing of or recycling the (2) Spare fuse (3) Main fuse box
used battery, consult a Maruti Suzuki (4) Relay box
authorised workshop.
9-24
INSPECTION AND MAINTENANCE

Main fuse box (4) 100 A FL4 (26) 50 A Ignition switch 2


(5) 50 A FL5 (27) 15 A Transmission
(5) (6) 30 A Starting motor (28) 15 A FI
(4) (7) 40 A Blower fan (29) 10 A CPRSR
(3) (1) (8) 40 A Battery (30) – Blank
(2) (9) 40 A ABS motor (31) 5A CNG IG1
(10) 40 A Ignition switch (32) 5A Starting Signal
56RS00707 (11) 30 A B/U (33) 7.5 A CNG
Relay box (12) – Blank The main fuse, primary fuses and some of
the individual fuses are located in the
(10) (13) – Blank engine compartment. If the main fuse
(6)

(7)

(8)

(9)

(14) – Blank blows, no electrical component will func-


tion. If a primary fuse blows, no electrical
(15) 25 A ABS control module
(11)
(12)
(13)
(14)
(15)
(16)
(17)
(18)

component in the corresponding load


(16) 15 A Headlight (Left) group will function. When replacing the
main fuse, a primary fuse or an individual
(19)

(20)

(21)

(22)
(23)
(24)
(25)

(26)

(27)
(28)
(29)

(17) 15 A Headlight (Right) fuse, use a genuine MARUTI SUZUKI


replacement.
(30) (31) (32) (33) (18) 30 A DCDC To remove a fuse, use the fuse puller pro-
(19) 30 A Radiator fan vided in the fuse box. The amperage of
each fuse is shown in the back of the fuse
(20) 30 A T/M Pump box cover.
56RS00705 (21) – Blank
MAIN FUSE / PRIMARY FUSE (22) 7.5 A CNG VLV
(1) 120 A FL1 (23) 20 A Fuel pump
(2) 100 A FL2 (24) 20 A Front fog light
(3) 80 A FL3 (25) 10 A Transmission 2

9-25
INSPECTION AND MAINTENANCE

Fuses Under Dashboard


PRIMARY FUSE
(1) 30 A Power window
(2) 10 A Meter
OK
(3) 15A Ignition coil
(4) 5A Ignition-1 signal 2
(5) 20 A Shift lever
BLOWN (6) 10 A CHG
(7) 10 A STL2
55T090620 (8) 20 A Door
55T090570
(9) 15 A Steering lock
WARNING
(10) 10 A Hazard
If the main fuse or a primary fuse
blows, have your vehicle inspected (11) 5A A-STOP controller*
by a Maruti Suzuki authorised work-
shop. Always use a genuine MARUTI (12) 10A Rear fog lamp*
SUZUKI replacement. Never use a (1) (2) (3) (4) (5) (6) (7) (8) (9) (10) (11) (12) ABS / ESP® control
substitute such as a wire even for a (13) 5A
(13) (14) (15) (16) (17) (18) (19) (20) (21) (22) (23) (24) (25)
module
temporary repair, or extensive electri-
cal damage and a fire can result. (26) (27) (28) (29) (30) (31) (32) (33) (34) (35) (36) (37) (38) (14) 15A Seat heater*
(15) 5A Ignition-1 signal 3*
NOTE:
Check that the fuse box always carries (16) 10 A Dome light-2
spare fuses.
(17) 5A Dome light
55T090590
(18) 15 A Radio
(19) 5A CONT
(20) 5A Key-2

9-26
INSPECTION AND MAINTENANCE

(21) 20 A Power window timer Headlight Aiming


Since special procedures are required, ask
(22) 5A Key a Maruti Suzuki authorised workshop for
(23) 15 A Horn this job.
(24) 5A Tail light (Left)
(25) 10 A Tail light
(26) 10 A Air bag
(27) 10 A Ignition-1 signal OK BLOWN
(28) 10 A Buck up light
(29) 5A ACC-3*
55T090630
(30) 20 A Rear defogger
(31) 10 A Heated mirror* WARNING
(32) 15 A ACC-2 Always replace a blown fuse with a
fuse of the correct amperage. Never
(33) 5A ACC use a substitute such as aluminum
foil or wire to replace a blown fuse. If
(34) 10 A Wiper you replace a fuse and the new one
(35) 5A Ignition-2 signal blows in a short period of time, you
may have a major electrical problem.
(36) 15 A Washer Have your vehicle inspected immedi-
ately by your Maruti Suzuki autho-
(37) 25 A Front wiper rised workshop.
(38) 10 A Stop light

* Feature not available in the vehicle

9-27
INSPECTION AND MAINTENANCE

Bulb Replacement
WATT- BULB
No. ITEM: Lights
AGE No.
(9) (12)
(1) Headlight 12V55W HIR2
*1
(2) Headlight LED –
(3) Front fog light*1 LED –
(4) Position light 12V5W W5W
Position light*1
Position light
(5) and daytime LED –
running light
(D.R.L.)*1
(6) Turn Front
12V
signal PY21W
(7) Rear 21W
light
Side turn 12V
(8) WY5W
signal light 5W
(8) (3)
(14) Side turn
(9) LED –
signal light*1

(1) (4) (2) (6) (10) (13) (10) Brake light*1 LED –
*1
(11) Tail light LED –
High mount
(12) LED –
(7) stop light*1
(13) Reversing light 12V16W W16W
License plate
(6) (5) (11) (14) 12V5W W5W
light
If you need to replace the following bulbs
55T090100 indicated in the above table, consult a
Maruti Suzuki authorised workshop.
9-28
INSPECTION AND MAINTENANCE

However, if water is piled up in the lights or


*1: Since the lights are non-disassemble
type, you cannot replace a bulb. NOTICE large waterdrop adheres to the inner sur-
face of lens, have your vehicle inspected
Replace the target assembly if any • The oils from your skin may cause by a Maruti Suzuki authorised workshop.
bulb is defective. a halogen bulb to overheat and
burst when the lights are on. Grasp
CAUTION a new bulb with a clean cloth. Non-disassembled Type Lights
• Frequent bulb replacement indi- Since the lights shown below are non-dis-
• Light bulbs can be hot enough to
cates the need for an inspection of assemble type, you cannot replace a bulb.
burn your finger right after turning
the electrical system. This should Replace the target assembly if any bulb is
off lights. This is true especially for
be carried out by a Maruti Suzuki defective.
halogen headlight bulbs. Replace
authorised workshop. If you need to replace the assembly, ask
the bulbs after they become cool
• During bulb replacement always your Maruti Suzuki authorised workshop.
enough.
use same bulb number as used in
• The headlight bulbs are filled with
vehicle which is imprinted on the • Headlight (LED type) (if equipped)
pressurized halogen gas. They can
said bulb/unit and/or mentioned in • Front fog light (if equipped)
burst and injure you if they are hit
this section. • Position light and Daytime running light
or dropped. Handle them carefully.
(LED type) (if equipped)
• To avoid injury by sharp-edged
• Tail/brake light (LED type)
parts of the body, wear gloves and
NOTE: • Side turn signal light/hazard warning
a long-sleeved shirt when replacing
The inner surface of lens such as the light on outside rearview mirrors (if
light bulbs.
headlights or the rear combination lights equipped)
may be clouded or dew condensation may • High mount stop light
occur by driving on a rainy day or washing
the vehicle. This is a temporary phenome-
non caused by temperature difference
between the inside and the outside of the
lights. (This is the same phenomenon as
the windows are clouded on a rainy day.)
Also, it sometimes seems that water gets
into the lights because of waterdrop on the
edge of the lens. This is a temporary phe-
nomenon caused by water adherence to
the outside of the lights.
The above-mentioned phenomena are not
vehicle malfunction.
9-29
INSPECTION AND MAINTENANCE

Headlights Side Turn Signal Light


LED headlights Fender type (if equipped)
Since special procedures are required, we (3)
recommend you take your vehicle to your
Maruti Suzuki authorised workshop for
light replacement. (1)
(2)
Halogen headlights

(1)

55T090290

Disconnect the coupler (2) by pushing the


lock release. Turn the bulb (3) counter- 68PM00736
clockwise and remove it.
1) Remove the light housing (1) by sliding
to left with your finger.
55T090280

(1) Headlight (high/low beam)

9-30
INSPECTION AND MAINTENANCE

Front Turn Signal Light and


Front Position Light
Vehicle with the halogen headlights
(2)
(3) (2)

(4)
(5)

(1)
68PM00717 68PM00718

2) Turn the bulb holder (2) clockwise and (4) Removal 55T090300
pull it out from the light housing. (5) Install
(1) Front turn signal light
3) To remove and install the bulb of the (2) Front position light
side turn signal light (3), simply pull out
or push in the bulb.

Outside Rearview Mirror Type


(if equipped)
LED module is used. Since special proce-
dures are required, we recommend you
take your vehicle to your Maruti Suzuki
authorised workshop for LED module
replacement.

9-31
INSPECTION AND MAINTENANCE

Vehicle with the LED headlights Vehicle with the halogen headlights

(2)

(3)
(2)

(3)
(1)
(4) (1)
55T090330
55T090310
68PM00721
Vehicle with the LED headlights
(1) Front turn signal light (3) Removal
(4) Installation
NOTE:
Position light and daytime running light (2) 2) To remove the bulb of the front turn sig-
(D.R.L.) are LED type. They are not nal light (1) from the bulb holder, push
replaceable. (3) in the bulb and turn it counterclockwise.
To install a new bulb, push it in and turn
it clockwise.
To remove and install the bulb of the
front position light (2), simply pull out or
push in the bulb.

55T090340

1) Open the engine hood. To remove the


bulb holder of the front turn signal light
or the front position light from the light
housing, turn the holder counterclock-
wise and pull it out.

9-32
INSPECTION AND MAINTENANCE

Front Fog Light (if equipped) Rear Combination Light


Since special procedures are required, it is (3)
recommended that you take your vehicle
to a Maruti Suzuki authorised workshop for
light replacement. (2)
(1)

Daytime Running Light (D.R.L.) (if


equipped)
For DRL replacement, we recommend you
to take your vehicle to the Maruti Suzuki
authorised workshop as special procedure
for the same is required.
55T090390
55T090380 2) Disconnect the coupler (3) by pushing
1) Remove the bolts (1) and pull the light the lock release.
housing (2) firmly to the rearward.

9-33
INSPECTION AND MAINTENANCE

(7) (5) (6)


(7)

(8)
(4) (9) (6)
55T090400 55T090410

3) Remove the wire (4) from a clamp (5). (8) Removal


4) To remove the bulb holder of the rear (9) Installation
turn signal light (6) or the reversing light
5) To remove the bulb of the rear turn sig-
(7) from the light housing, turn the
nal light (6) from the bulb holder, push
holder counterclockwise and pull it out.
in the bulb and turn it counterclockwise.
To install a new bulb, push it in and turn
55T090420
it clockwise.
To remove and install the bulb of the NOTE:
reversing light (7), simply pull out or When reinstalling the light housing, check
push in the bulb. that the clips are properly attached.

9-34
INSPECTION AND MAINTENANCE

License Plate Light Interior Light


Front (if equipped)

(1)

(2)
(2)

(3)
(4)
55T090440
55T090450
(3) Removal
(4) Installation 1) To prevent scratches, insert a commer-
cially available flat-blade screwdriver
2) To remove and install the bulb of the covered with a soft cloth into the notch
license plate light (2), simply pull out or (1), and then remove the lens (2).
55T090430
push in the bulb.
1) Remove the cover (1) by pushing in
arrow direction.
High Mount Stop Light
Since special procedures are required, it is
recommended that you take your vehicle
to a Maruti Suzuki authorised workshop for
light replacement.

9-35
INSPECTION AND MAINTENANCE

Center
(1)

(3)
(4) (3)
(2)
(4)

55T090040 55T090050
55T090460
(3) Removal (3) Removal
1) To prevent scratches, insert a commer-
(4) Install (4) Installation
cially available flat-blade screwdriver
2) Pull the bulb out and then insert a new covered with a soft cloth into the notch 2) Pull the bulb out and then insert a new
one. (1), and then remove the lens (2). one.
3) After replacing the bulb, install the front 3) After replacing the bulb, install the cen-
interior light lens in the reverse order of ter interior light lens in the reverse order
removal. of removal.

9-36
INSPECTION AND MAINTENANCE

Luggage compartment (if equipped) Courtesy light (if equipped)

(1)

(1)
(2) (3) (2)

(4)

55T090470
55T090040
1) To prevent scratches, insert a commer- 55T090480
cially available flat-blade screwdriver (3) Removal
1) To prevent scratches, insert a commer-
covered with a soft cloth into the notch (4) Install
cially available flat-blade screwdriver
(1), and then remove the lens (2). 2) Pull the bulb out and then insert a new covered with a soft cloth into the notch
one. (1), and then remove the lens (2).
3) After replacing the bulb, install the lug-
gage compartment light lens in the
reverse order of removal.

9-37
INSPECTION AND MAINTENANCE

Glove box light (if equipped)

(3)
(4)

55T090040 55T090500
55T090490
(3) Removal 2) To remove and install the bulb of the
1) Press inward on both sides of the glove
(4) Install glove box light (1), simply pull out or
box and pull frontward and then
push in the bulb.
2) Pull the bulb out and then insert a new unclamp it.
one.
3) After replacing the bulb, install the cour- Front footwell lights (if equipped)
Since special procedures are required, we
tesy light lens in the reverse order of
recommend you take your vehicle to your
removal.
Maruti Suzuki authorised workshop for
light replacement.

9-38
INSPECTION AND MAINTENANCE

Wiper Blades NOTE:


Some wiper blades may be different from
the ones described here depending on
vehicle specifications. If so, consult a
Maruti Suzuki authorised workshop for
proper replacement method.
(1)
For Windshield Wipers (1)

(2)
(2)

59RN09450 59RN09240

If the wiper blades become brittle or dam- 2) Squeeze lock (1) towards wiper arm (2)
aged, or make streaks when wiping, and remove the wiper frame from the
replace the wiper blades. arm as shown.
To install new wiper blades, follow the pro-
cedures below.
55T090510
NOTICE
1) Hold the wiper arm away from the win-
To avoid scratching or breaking the dow.
window, do not let the wiper arm
strike the window while replacing the
wiper blade.

9-39
INSPECTION AND MAINTENANCE

(3)

(3)
(A)

(B)
(3)

59RN09250 59RN09260 59RN09270

3) Unlock the lock end of the wiper blade (3) Retainer (A) Up
and slide the blade out as shown. (B) Down
4) If the new blade is provided without the
two metal retainers, move them from
the old blade to the new one. NOTE:
When you install the metal retainers (3),
make sure the direction of metal retainers
as shown in the above illustration.

9-40
INSPECTION AND MAINTENANCE

For Rear Window Wiper

(4)

(5)

(4)

55T090710 59RN09300

(4) Locked end 3) Slide the blade out as shown.


55T090530
5) Install the new blade in the reverse 1) Hold the wiper arm away from the win- NOTE:
order of removal, with the locked end dow. Do not flex the wiper blade frame end more
positioned toward the wiper arm. Make 2) Remove the wiper frame from the arm than necessary. If you do, it can break off.
sure the blade is properly retained by as shown.
all the hooks. Lock the blade end into
place.
6) Reinstall wiper frame to arm, making
sure that the lock lever is snapped
securely into the arm.

NOTICE
Fit the stopper side (5) of the wiper
blade rubber in the driver’s seat side.
Otherwise, the wiper blade rubber
may be misaligned while the wiper
operates.

9-41
INSPECTION AND MAINTENANCE

Windshield Washer Fluid Air Conditioning System


If you do not use the air conditioner for a
(1)
long period, such as during winter, it may
not give the best performance when you
start using it again. To help maintain opti-
mum performance and durability of your air
conditioner, it needs to be run periodically.
Operate the air conditioner at least once a
month for one minute with the engine
idling. This circulates the refrigerant and oil
and helps protect the internal components.
(1)

59RN09310

(1) Retainer 55T090540

Check that there is washer fluid in the tank.


4) If the new blade is provided without the
Refill it if necessary. Use a good quality
two metal retainers, move them from
windshield washer fluid, diluted with water
the old blade to the new one.
as necessary.
5) Install the new blade in the reverse
order of removal.
Make sure the blade is properly WARNING
retained by all the hooks. Do not use radiator antifreeze in the
6) Reinstall wiper frame to arm in the windshield washer reservoir. This
reverse order of removal. can severely impair visibility when
sprayed on the windshield, and also
can damage your vehicle’s paint.

NOTICE
Damage may result if the washer
motor is operated with no fluid in the
washer tank.

9-42
INSPECTION AND MAINTENANCE

Air Conditioner Filter Replacement Preparation Before Winter


Since special procedures are required, ask Season
a Maruti Suzuki authorised workshop for (2) Windshield Washer Fluid
this job. To prevent windshield washer fluid from
freezing, dilute it by the ratio according to
outside temperature.
(1) (3)
(4)
Lead-acid Battery
Check the liquid measure and the specific
gravity of lead-acid battery. When it
becomes cold, the battery performance
gets worse. Also, it becomes difficult to
start the engine by the weak battery. Refer
to “Battery” in the “INSPECTION AND
MAINTENANCE” section.

55T090070
55T090490
2) Remove the cover (1) and pull out the Engine Coolant
1) To approach the air conditioner filter, To prevent the inside of engine from cor-
remove the glove box by pressing both air conditioner filter (2).
roding and freezing, use the designated
sides of the glove box inward and pull- engine coolant. Refer to “Specifications” in
ing it out. NOTE:
• When you install a new filter, check that the “SPECIFICATIONS” section.
the UP mark (3) faces upward.
• When you install the cover, check that NOTE:
the UP mark (4) faces upward. To check the concentration of engine cool-
ant or replace it, ask a Maruti Suzuki
authorised workshop.

9-43
INSPECTION AND MAINTENANCE

Winter Tyres and Chocks Before Your Driving Frozen Wiper Blades
Snow on the Roof

(1)
(2)
55T090670 65P60060

(1) Winter tyre 80J308 Melt ice by pouring lukewarm water. After
(2) Chock melting it, wipe off water to prevent
Remove snow on the roof before your driv- refreezing. If you operate the wiper blades
Winter tyres and chocks are necessary to ing. If you do not remove it, snow may fall forcedly when ice stays freezing, the wiper
drive on the snow roads or the frozen during your driving and it may hinder your rubbers may be damaged and the wiper
roads. view. blades may be broken.

9-44
INSPECTION AND MAINTENANCE

Snow and Frost on the Window Glasses Frozen Outside Rearview Mirrors
NOTICE
• For the outside rearview mirror
folding switch, check if you can
move the mirrors by your hands
first. Then, operate the switch. If
you repeat to operate the switch
when ice stays freezing, the mir-
rors may be broken.
(1) • For the remote folding mirrors,
deactivate the function of the
82K261 65P60070
remote folding mirrors in the cold
condition where the outside rear-
Use the plastic board (1). You can remove Melt ice by pouring lukewarm water. After view mirrors are frozen. If you
snow and frost not to damage the window melting it, wipe off water to prevent repeat to operate them when ice
glasses. refreezing. If you operate the outside rear- stays freezing, the mirrors may be
view mirrors forcedly when ice stays freez- broken.
ing, the outside rearview mirrors may be
broken.

9-45
INSPECTION AND MAINTENANCE

Frozen Doors Snow Attaching to Shoes When Parking the Vehicle Outside

65P60080 80J312 80J315

Pour lukewarm water except the keyhole Remove snow attaching to shoes before
on the door. After opening the door, wipe getting in your vehicle. If you do not NOTICE
off water. If you open the door forcedly remove it, you may slip when operating the
when ice stays freezing, the rubbers pedals and the window glasses may mist • If you park the vehicle under eaves
around the door may be come off and bro- easily because of high humidity inside the or trees, the roof of the vehicle may
ken. vehicle. be dented by accumulated snow or
fallen snow.
When it is snowing, do not park the
vehicle under eaves or trees.
• If you park the vehicle outside
when it is snowing, the wiper arms
may be deformed or the wiper
blades may be frozen on the wind-
shield by snow weight. Raise the
wiper arms away from the wind-
shield when parking the vehicle.

9-46
INSPECTION AND MAINTENANCE

9-47
EMERGENCY SERVICE

EMERGENCY SERVICE
Towing by Tow Truck ......................................................... 10-1
Towing by Using Towing Eye ............................................ 10-2
Tyre Changing Tool ............................................................ 10-5
Jacking Instructions ........................................................... 10-7
Jump-starting Instructions ................................................10-12
Running Out of Battery ......................................................10-14
If You Get a Flat Tyre While Driving .................................10-14
Engine Trouble: Starter Does not Operate ......................10-14
Engine Trouble: Does not Start ........................................10-15
Engine Trouble: Overheating ............................................10-15
Warning Triangle ................................................................10-16

60G411

10
EMERGENCY SERVICE

Towing by Tow Truck 2-wheel Drive (2WD) Manual Trans-


If you need to have your vehicle towed, mission or Auto Gear Shift NOTICE
contact a professional service. Maruti Manual transmission vehicles or Auto Gear • After shifting the Auto Gear Shift
Suzuki authorised workshop can provide Shift may be towed using either of the fol- gearshift lever to the “N” position,
you with detailed towing instructions. lowing methods. always check the gear position
• Being towed from the front: indicator in the instrument cluster
WARNING Lift the front wheels and keep the rear shows the “N” position to make
For vehicles equipped with the dual wheels on the ground. Before the vehicle sure that the transmission is disen-
camera brake support, if your vehicle is towed, make sure that the parking gaged.
is towed with the engine on, press brake is released. If the transmission cannot be put in
the dual camera brake support OFF • Being towed from the rear: neutral, turn the key from “LOCK”
switch and turn off the dual camera Lifted and the front wheels on the to “ON” position or press the
brake support. If not, an accident ground, provided the steering and drive- engine switch to change the igni-
related to the system being turned on train are in operational condition. Before tion mode to ON, and move the
may occur. towing, check that transmission is in Auto Gear Shift gearshift lever from
neutral, the steering wheel is unlocked “N” to “D”, “M” or “R”, then back to
(vehicle without keyless push start sys- “N” again. Then turn the key from
NOTICE tem - the ignition key should be in “ACC” “ON” to “LOCK” position or press
position) (vehicle with keyless push start the engine switch to change the
To help avoid damage to your vehicle system - the ignition mode is ACC), and ignition mode to LOCK (OFF).
during towing, proper equipment and the steering wheel is secured with a These procedures may help put the
towing procedures must be used. clamping device designed for towing transmission in neutral. If the trans-
service. mission still cannot be put in neu-
tral, you cannot tow the vehicle
without using a towing dolly.
• The steering column is not strong
enough to withstand shocks trans-
mitted from the front wheels during
towing. Always unlock the steering
wheel before towing.

10-1
EMERGENCY SERVICE

Towing by Using Towing Eye


NOTICE
Hanging Point of a Towing Cable • Observe the following instructions
Hang a towing cable on a towing eye. when using the towing eye (4). Oth-
The towing eye is provided on the front of erwise, the towing eye or the vehicle
the vehicle for use in emergency situations body may break and cause serious
or sea shipping purposes. injury or damage:
– Avoid pulling the vehicle to get out
(
(3) of severe snowy, muddy or sandy
(4) conditions.
– Avoid sudden starts or erratic
driver performance which could
55T100050 cause excessive stress on the
2) Install the towing eye (4) by hand. towing eye.
(1) In such cases, we recommend that
you contact a professional service.
• Do not use the towing eye (4) for
(2) (4) (5) towing another vehicle or trans-
porting your vehicle by a car carrier
55T100040 trailer, etc.
1) Remove the cover (1) by using a jack
handle (2) covered with a soft cloth (3)
as shown in the illustration.

NOTICE
Do not apply excessive force as it
may damage the cover strap.
55T100060

NOTE: 3) To tighten the towing eye (4), turn it


We recommend that you fasten the cover clockwise by using a wheel brace (5)
with tape to prevent damage during tow- until the towing eye (4) is securely
ing. installed.

10-2
EMERGENCY SERVICE

Towing by Using a Rope WARNING


1) Hang a towing cable on a towing eye (Continued)
horizontally, so that the hanging side • Depress the brake pedal more
would be the same for the towing vehi- firmly than usual, as the brake
cle and the towed vehicle if possible. booster does not work.
• Operate the steering wheel with
2) Keep the engine running. more force, as the power steering
• When you cannot start the engine, system does not work.
press the engine switch to change the
ignition mode to the position other NOTICE
(6) than LOCK (OFF).
• Turn the steering wheel to left and If you cannot release the steering
55T100070
right to check that the steering lock is lock, you cannot operate the steering
released. wheel and it may cause an accident.
If you cannot release the steering
NOTICE WARNING lock because of malfunction and run-
• Your vehicle was originally ning out of the lead-acid battery, do
If you drive the vehicle without the not perform towing by using a rope.
designed to carry people and a nor- engine running, it may cause an acci-
mal amount of cargo, not to tow a dent.
trailer. 3) Shift the gearshift lever into “N”.
When your vehicle is towed by using
• The frame hook (6) is provided on a rope, observe the following instruc-
the rear of the vehicle for use in NOTE:
tions.
emergency situations and sea ship- • Do not press the engine switch to • If you cannot shift the gearshift lever into
ping purposes only. Do not use the change the ignition mode to LOCK “N”, towing by using a towing cable is not
frame hook for towing another vehi- (OFF). Otherwise, the steering possible. Consult a Maruti Suzuki autho-
cle, being towed by another vehicle wheel will be locked and not be rised workshop.
or transporting your vehicle by a car turned. • If you cannot shift the gearshift lever
carrier trailer, etc. Otherwise, the (Continued) from “P” to the other position with the
frame hook or the vehicle body may engine running and the brake pedal
break and cause serious injury or depressed, because of malfunction and
damage. running out of the lead-acid battery, can-
cel the shift lock system referring to
“Canceling the Shift Lock System” in the
“OPERATING YOUR VEHICLE” section.

10-3
EMERGENCY SERVICE

4) During towing, make sure that a towing


cable is not slack. To avoid a collision,
carefully drive your vehicle checking
the brake lights of the front vehicle.
• To warn the driver of a following vehi-
cle, turn on the hazard warning lights
of the towed vehicle.

WARNING
If you continuously depress the
brake pedal on a long or steep down-
hill slope, the brakes could overheat
and become ineffective.
When there is a long or steep down-
hill slope, do not perform towing by a
rope. Make a request of a tow truck.

NOTICE
• If a strong impact is applied to a tow-
ing eye or a towing cable by sudden
starting etc., the towing eye or the
vehicle body may be damaged.
When the vehicle needs to be towed,
do not apply a strong impact to a tow-
ing eye or a towing cable by sudden
starting etc.
Do not accelerate suddenly.
• If the vehicle unavoidably needs to be
towed by a rope, tow your vehicle on
paved roads. Do not exceed the vehi-
cle speed of 30 km/h and do not drive
the vehicle for longer than 30 km to
protect the transmission.

10-4
EMERGENCY SERVICE

Tyre Changing Tool (If equipped) The tyre changing tools are stowed in the
luggage compartment.
Refer to “Luggage Compartment” in
“QUICK GUIDE” section.

When using the jack, check that there is no


deformation or damage on the jack.
Also, check that there is no dirt on the
screw part and grease is applied on it.

The tyre changing tools are stowed in the


luggage compartment, below luggage
compartment boards.
(1) To remove the luggage compartment
board (if equipped) easily, lift the board
from the hole provided on the board and
pull it out.

(2)
(3)
(3)
(1)
(4)

55T100090

(1) Jack
(2) Wheel wrench 55T100110
(3) Jack handle
(4) Towing eye To remove the jack (1), turn its shaft coun-
terclockwise by using jack handle (3) and
pull the jack out of the storage bracket.

10-5
EMERGENCY SERVICE

CAUTION
The jack should be used only to
change wheels. It is important to read
(1) (3) the jacking instructions in this sec-
tion before attempting to use the
(3) jack.
(6)

NOTICE
(5) To avoid damaging the storage
bracket, do not expand the jack
excessively.
55T100120
55T100130
To stow the jack (1), place it in the storage
bracket (5) and turn the shaft clockwise After temporarily tightening the jack till it
with the hand. contacts the jacket holder bracket (6), turn
the shaft approximately 90° to 180° by
using jack handle (3) to securely hold the
jack in place.

WARNING
After using the tyre changing tools,
be sure to stow them securely or they
can cause injury if an accident
occurs. (7)

68PM08007

To remove the spare tyre, turn the bolt (7)


counterclockwise and remove it.

10-6
EMERGENCY SERVICE

Jacking Instructions
1) Place the vehicle on level, hard ground.
2) Set the parking brake firmly and shift
into “R” (Reverse) if your vehicle has a
manual transmission or Auto Gear
Shift.

WARNING
• Shift into “P” (Park) when you jack
up the vehicle.
• Never jack up the vehicle with the
(7) transmission in “N” (Neutral). Oth-
erwise, unstable jack may cause an
68PM08008 accident. 59RN10010

Return the spare tyre back into the lug- 4) Block the front and rear of the wheel
gage compartment in the reverse order of 3) Turn on the hazard warning switch if diagonally opposite to the wheel being
removal and tighten its bolt (7) clockwise your vehicle is near traffic. lifted.
as shown in the above illustration.
While replacing tyre with alloy wheel make
sure to remove the wheel cap before keep-
ing the tyre in the trunk.

NOTICE
Make sure that the spare tyre is fixed
securely on the floor. Loosely fixed
tyre may cause noise during driving
and damage paint on vehicle body.

10-7
EMERGENCY SERVICE

WARNING
• Use the jack only to change wheels
on level, hard ground.
• Never jack up the vehicle on an
inclined surface.
• Never raise the vehicle with the
jack in a location other than
between the frame bosses near the
wheel to be changed.
• Make sure that the jack is raised at
59RN10120 least 25 mm (1 inches) before it
contacts the boss. Use of the jack
81PN117
when it is within 25 mm (1 inches)
of being fully collapsed may result
6) Continue to raise the jack slowly and in failure of the jack.
smoothly until the tyre clears the • Do not use wooden blocks or simi-
ground. Do not raise the vehicle more lar objects as a jack underlay.
than necessary. • No person should place any por-
tion of their body under a vehicle
that is supported by a jack. Never
place your hands or feet under the
raised vehicle when it is supported
by a jack.
• Never run the engine when the
(1) vehicle is supported by the jack
(1) and never allow passengers to
remain in the vehicle.
59R80200

5) Position the jack at an angle as shown


in the illustration and raise the jack by
turning the jack handle clockwise until
the jack-head groove fits around the
jacking bar boss (1)beneath the vehicle
body.
10-8
EMERGENCY SERVICE

Raising Vehicle with Garage Jack


• Apply the garage jack to one of the
points indicated below. (1) (2)
• Always support the raised vehicle with
jack stands (commercially available) at
the points indicated below.
(1) Front
(2) Rear (3) (3)
(3) Jack stand
(4) Garage jack
(5) Jacking point for garage jack

(1)

(1) (2)

(5)
(5)

(4) (4)

55T100140

10-9
EMERGENCY SERVICE

Changing Wheels
CAUTION
(a) WARNING
(6) (b) (6) Immediately after the vehicle has
Never change a wheel in traffic lane. been driven, the wheels, the wheel
Always move the vehicle off the road nuts and the area around the brakes
on level, hard ground away from traf- might be extremely hot. Touching
fic for changing a wheel. For any fur- these areas may cause burn injury
ther assistance contact your nearest Do not touch these areas, immedi-
Maruti Suzuki authorised workshop. ately after the vehicle has been
driven.
(2) (2) To change a wheel, use the following pro-
cedure: 4) Remove the wheel nuts and wheel.
1) Prepare the jack and tools.
2) Loosen, but do not remove the wheel
55T100180
nuts.
(a) Specified position of jack stand for the 3) Jack up the vehicle (follow the jacking
front side instructions in this section).
(b) Specified position of jack stand for the
rear side WARNING
• Shift into “R” (Reverse) for a manual
NOTICE transmission or Auto Gear Shift
If you use the jack stand (2) in the vehicle when you jack up the vehi-
condition that it touches the side cle.
skirt (6), the side skirt may be broken • Never jack up the vehicle with the
or damaged. transmission in “N” (Neutral). Oth-
When using the jack stand, make erwise, unstable jack may cause an
sure that it does not touch the side accident.
skirt.

NOTE:
For more details, consult a Maruti Suzuki
authorised workshop.

10-10
EMERGENCY SERVICE

(1)
Loosen

Tighten

(4)
(1)

68PM08010
(2) (5) 68PM08001
(1) Tightening torque for wheel nuts
Return the spare tyre back into the lug-
100 Nm (10.2 kg-m, 74.0 lb-ft)
gage compartment in the reverse order of
removal and tighten its bolt (1) clockwise
(3) 7) Lower the jack and fully tighten the nuts
as shown in the above illustration.
with a wrench in numerical order as
shown in the illustration.
NOTICE
(4)
(3) WARNING Make sure that the spare tyre is fixed
84S08170 securely on the floor. Loosely fixed
Use genuine wheel nuts and tighten
tyre may cause noise during driving
5) Clean any mud or dirt off from the sur- them to the specified torque as soon
and damage paint on vehicle body.
face of the wheel (1), hub (2), thread as possible after changing wheels.
part (3) and surface of the wheel nuts Incorrect wheel nuts or improperly
(4) with a clean cloth. Clean the hub tightened wheel nuts may come
carefully; it may be hot from driving. loose or fall off, which can result in
6) Install the new wheel and replace the an accident. If you do not have a
wheel nuts with their cone shaped end torque wrench, have the wheel nut
facing the wheel. Tighten each nut torque checked by an authorized
snugly by hand until the wheel is Maruti Suzuki authorised workshop.
securely seated on the hub.

10-11
EMERGENCY SERVICE

Full Wheel Cover (if equipped) Jump-starting Instructions


NOTICE
WARNING Your vehicle should not be started by
• Never attempt to jump-start your pushing or towing. This starting
vehicle if the lead-acid battery method could result in permanent
(1) appears to be frozen. Batteries in damage to the catalytic converter.
this condition may explode. Use jump leads to start a vehicle with
• When making jump lead connec- a weak or flat battery.
(2)
tions, check that your hands and
(3) the jump leads remain clear from 1) Use only a 12-volt lead-acid battery to
pulleys, belts or fans. jump-start your vehicle. Position the
68PM08011
• Lead-acid batteries produce flam- good 12-volt lead-acid battery close to
mable hydrogen gas. Keep flames your vehicle so that the jump leads will
(1) or (2) Flat end tool and sparks away from the battery reach both batteries. When using a bat-
or an explosion may occur. Never tery installed on another vehicle, check
Your vehicle includes two tools, a wheel smoke when working near the bat- that two vehicles do not touch each
wrench and a jack crank, one of which has tery. other. Set the parking brakes fully on
a flat end. • If the booster battery you use for both vehicles.
Use the tool with the flat end with soft cloth jump-starting is installed in another 2) Turn off all vehicle accessories, except
(3) to remove the full wheel cover, as vehicle, check that the two vehicles those necessary for safety reasons (for
shown above. are not touching each other. example, headlights or hazard lights).
• If your lead-acid battery discharges
repeatedly, for no apparent reason,
have your vehicle inspected by a
Maruti Suzuki authorised work-
shop.
• To avoid harm to yourself or dam-
age to your vehicle or battery, fol-
low the jump-starting instructions
below.
68PM08012 If you are in doubt, call for qualified
When installing the cover, make sure that it road service.
is positioned so that it does not cover or
foul the air valve.

10-12
EMERGENCY SERVICE

2. Connect the other end to the positive 4) If the booster battery you are using is
(+) terminal of the booster battery fitted to another vehicle, start the
(2). engine of the vehicle with the booster
3. Connect one end of the second jump battery. Run the engine at moderate
lead to the negative (–) terminal of speed.
the booster battery (2). 5) Start the engine of the vehicle with the
4. Make the final connection to an discharged battery.
unpainted, heavy metal part (i.e. 6) Remove the jump leads in the exact
engine mount bolt (3)) of engine cyl- reverse order in which you connected
inder head in the vehicle with the them.
(3) discharged battery (1).

WARNING
(1) Never connect the jump lead directly
to the negative (–) terminal of the dis-
charged battery, or an explosion may
occur.
4 1
CAUTION
Connect the jump lead to the engine
mount bolt securely. If the jump lead
2 3 disconnects from the engine mount
bolt because of vibration at the start
(2) of the engine, the jump lead could be
caught in the drive belts.

55T100150

3) Connect jump leads as follows:


1. Connect one end of the first jump
lead to the positive (+) terminal of
the discharged battery (1).

10-13
EMERGENCY SERVICE

Running Out of Battery If You Get a Flat Tyre While Engine Trouble: Starter Does
In the following cases, the lead-acid Driving not Operate
battery is running out. Firmly hold the steering wheel and care- 1) Try turning the ignition mode to START
• The starter does not engage when fully apply the brakes to slow down the with the headlights turned on to deter-
attempting to turn on the engine. Or, the vehicle and stop it in a safe place. mine the lead-acid battery condition. If
starter rotation is too weak to make the the headlights go excessively dim or go
engine start. off, it usually means that either the
• The headlight illumination is extremely lead-acid battery is discharged or the
low or the horn volume is low. battery terminal contact is poor.
Recharge the lead-acid battery or cor-
rect battery terminal contact as neces-
sary.
2) If the headlights remain bright, check
the fuses. If the reason for failure of the
starter is not obvious, there may be a
major electrical problem. Have the vehi-
cle inspected by a Maruti Suzuki autho-
rised workshop.

10-14
EMERGENCY SERVICE

Engine Trouble: Does not Engine Trouble: Overheating If the high engine coolant temperature
warning light does not go off or the tem-
Start The engine could overheat temporarily
perature indication does not come down to
Make sure that your vehicle has enough under severe driving conditions. If the high
engine coolant temperature warning light within the normal, acceptable range:
fuel and battery.
If the engine does not start under very cold comes on as overheating or the engine 1) Turn off the engine and check that the
condition, press the accelerator pedal all coolant temperature gauge indicates over- water pump belt and pulleys are not
the way to the floor and hold it while crank- heating during driving: damaged or slipping. If any abnormality
ing the engine. 1) Turn off the air conditioner. is found, correct it.
Refer to “Starting / Stopping Engine (Vehi- 2) Take the vehicle to a safe place and 2) Check the coolant level in the reservoir.
cle without Keyless Push Start System) (if park. If it is found to be lower than “LOW”
equipped)” or “Starting / Stopping Engine 3) Run the engine at a normal idle speed line, check radiator, water pump, radia-
(Vehicle with Keyless Push Start System) for a few minutes until the high engine tor hoses and heater hoses for leakage.
(if equipped)” in “OPERATING YOUR coolant temperature warning light goes If leakage that may cause overheating
VEHICLE” section. off or the indicator is within the normal, is found, do not run the engine until
If the engine still does not start have your acceptable temperature range between these problems have been corrected.
vehicle inspected at a Maruti Suzuki autho- “H” and “C”. 3) If leakage is not found, carefully add
rised workshop. coolant to the reservoir and then the
• Do not operate the starter motor for radiator, if necessary. (Refer to “Engine
WARNING coolant” in “INSPECTION AND MAIN-
more than 12 seconds.
If you see or hear escaping steam, TENANCE” section.)
NOTE: stop the vehicle in a safe place and
If the engine refuses to start, the starter immediately turn off the engine to NOTE:
motor automatically stops after a certain cool it. Do not open the hood when If engine overheats and you are not sure
period of time. After the starter motor has steam is present. When the steam what to do, contact a Maruti Suzuki autho-
automatically stopped or if there is any- can no longer be seen or heard, open rised workshop.
thing abnormal in the engine starting sys- the hood to see if the coolant is still
tem, the starter motor runs only while the boiling. If it is, you must wait until it
engine switch is held pressed. stops boiling before you proceed.

10-15
EMERGENCY SERVICE

Warning Triangle • Remove the warning triangle carefully


from the cover as shown by arrow (1).
• Open both the reflector arms as shown
by arrow (2) and lock the arms with each
other with the clip provided in the right
arm. Open the bottom stand in counter
clock-wise direction as shown by arrow
(1) (3). Position the warning triangle behind
55T100010 the vehicle on a plain surface.
In case of vehicle break-down or during • Reverse the removal procedure for
emergency stopping, where, your vehicle keeping inside the cover.
could become a potential traffic hazard,
keep the warning triangle, provided with
your vehicle, on the road free from any
79J007
obstacles behind your vehicle so as to
warn the approaching traffic, at an approxi-
WARNING mate distance of 50-100 m. The reflecting
• It is hazardous to remove the radia- side of the triangle should face the oncom-
tor cap when the water temperature ing traffic. Please activate the hazard
is high, because scalding fluid and warning lamps before alighting the vehicle
steam may be blown out under to keep the warning triangle.
pressure. The cap should only be
taken off when the coolant tem- (2) (2)
perature has lowered.
• To help prevent personal injury,
keep hands, tools and clothing 55T100030

away from the engine cooling fan


and air-conditioner fan. These elec-
tric fans can automatically turn on
without warning.
(3)

55T100020

10-16
EMERGENCY SERVICE

MEMO

10-17
APPEARANCE CARE

APPEARANCE CARE
Corrosion Prevention ......................................................... 11-1
Cleaning Exterior ................................................................ 11-2
Cleaning Interior .................................................................. 11-7

60G412

11
APPEARANCE CARE

Corrosion Prevention 3) Moisture in certain areas of a vehicle Remove foreign material deposits
for an extended period of time may pro- Foreign materials such as salts, chemicals,
It is important to take good care of your
mote corrosion even when other body road oil or tar, tree sap, bird droppings and
vehicle to protect it from corrosion. Listed
sections are completely dry. industrial fall-out may damage the finish of
below are instructions for how to maintain
4) High temperatures will cause an accel- your vehicle if it is left on painted surfaces.
your vehicle to prevent corrosion. Please
erated rate of corrosion to parts of the Remove these types of deposits as quickly
read and follow these instructions carefully.
vehicle which are not well-ventilated to as possible. If these deposits are difficult to
permit quick drying. wash off, an additional cleaner may be
Important Information about Corro- required. Check that any cleaner you use
sion This information illustrates the necessity of
is not harmful to painted surfaces and is
keeping your vehicle (particularly the
Common causes of corrosion specifically intended for your purposes.
underbody) as clean and dry as possible. It
1) Accumulation of road salt, dirt, moisture Follow the manufacturer’s directions when
is equally important to repair any damage
or chemicals in hard-to-reach areas of using these special cleaners.
to the paint or protective coatings as soon
the vehicle underbody or frame. as possible.
2) Chipping, scratches and any damage to Repair finish damage
treated or painted metal surfaces Carefully examine your vehicle for damage
resulting from minor accidents or abra- to the painted surfaces. Should you find
sion by stones and gravel.
How to Help Prevent Corrosion any chips or scratches in the paint, touch
3) Any or all of the below mentioned Wash your vehicle frequently them up immediately to prevent corrosion
points: The best way to preserve the finish on your from starting. If the chips or scratches have
vehicle and to help avoid corrosion is to gone through to the bare metal, have a
• Continuous exposure to sunlight qualified body shop make the repair.
keep it clean with frequent washing.
• Hard water & sea water coming in con-
Wash your vehicle at least once during the
tact with vehicle.
winter and once immediately after the win-
• Foot rubbing (skirting).
ter. Keep your vehicle, particularly the
underside, as clean and dry as possible.
Environmental conditions which accel-
If you frequently drive on salted roads,
erate corrosion
your vehicle should be washed at least
1) Road salt, dust control chemicals, sea
once a month during the winter. If you live
breeze or industrial pollution will all
near the ocean, your vehicle should be
accelerate the corrosion of metal.
washed at least once a month throughout
2) High humidity will increase the rate of
the year.
corrosion particularly when the tem-
perature range is just above the freez- For washing instructions, refer to “Cleaning
ing point. Exterior” section.

11-1
APPEARANCE CARE

Keep passenger and luggage compart- Cleaning Exterior NOTE:


ments clean Do not use wax on plastic parts that are
Moisture, dirt or mud can accumulate For Keeping the Paintwork Beauti- not coated. Waxing these surfaces could
under the floor mats and may cause corro- ful result in a whitened or uneven appear-
sion. Occasionally, check under these To keep your vehicle’s beautiful appear- ance.
mats to ensure that this area is clean and ance for a long term, daily care is import-
dry. More frequent checks are necessary if ant.
the vehicle is used for off-road driving or in • For parking and storing the vehicle, we
wet weather. recommend garages with good ventila-
Certain cargos such as chemicals, fertiliz- tion and locations with roofs.
ers, cleaners, salts, etc. are extremely cor-
rosive by nature. These products should • The following situations may cause rust-
be transported in sealed containers. If they ing and discoloration of the paint. Wash
are spilled or leaked, clean and dry the your vehicle promptly.
area immediately. – When driving in coastal areas or on
roads sprayed with antifreeze agent
Park your vehicle in a dry, well-venti- (Wash the underside of the vehicle
lated area and around the wheel wells especially) 80J302

Park your vehicle to save it from continu- – When bird droppings, dead insects, • Chips from flying rocks, scratches, etc.
ous exposure to direct sunlight. Do not sap, iron dust, soot or smoke residue, can cause rust. Repair these areas as
park your vehicle in a damp, poorly-venti- coal tar, etc., adhere to the paint or soon as possible.
lated area. If you often wash your vehicle when the vehicle gets wet with acid
in the garage and place it there in wet con- rain NOTICE
dition, your garage may be damp. The high – When the vehicle is dirty with dust or
humidity in the garage may cause or accel- mud • When repairing scratches on
erate corrosion. A wet vehicle may corrode painted surfaces, consult a Maruti
even in a heated garage if the ventilation is • Give the vehicle a wax about once a Suzuki authorised workshop. Using
poor. month or whenever the water-repelling an inappropriate material for repair
ability of the painted surfaces has could cause damage to the paint.
WARNING declined. Follow all instructions on the • It is important that your vehicle be
package of the wax (sold separately). kept clean and free from dirt. Fail-
Do not apply additional undercoating
or rust preventive coating on or ure to keep your vehicle clean may
around exhaust system components result in fading of the paint or cor-
such as the catalytic converter and rosion to various parts of the vehi-
the exhaust pipes. It may catch a fire cle body.
if the undercoating substance
becomes overheated.
11-2
APPEARANCE CARE

Washing NOTICE
NOTICE
WARNING (Continued)
• Never attempt to wash and wax
your vehicle with the engine run-
ning.
• When cleaning the underside of the
body and fender, where there may
be sharp-edged parts, wear gloves
and a long-sleeved shirt to protect
your hands and arms from being
cut.
• After washing your vehicle, care-
fully test the brakes before driving
to check that they have maintained
their normal effectiveness. 84S09240
55T110010
• When washing or waxing the vehi- • When washing or waxing the vehi-
cle, do not lean on the vehicle body cle, do not put your foot on the
or do not push it hard. door opening.
This might cause it to deform. This might cause it to damage.
(Continued)

11-3
APPEARANCE CARE

Washing by hand
NOTICE
When using a commercial car wash
product, observe the cautions speci-
fied by the manufacturer. Never use
strong household detergents or
soaps.
4) Once the dirt has been completely
removed, rinse off the detergent with
running water.
5) Wipe off the vehicle body with a wet
chamois or cloth and allow it to dry in
the shade.
68PM09005 6) Check carefully for damage to painted
80J303 surfaces. If there is any damage, touch
2) Rinse the body to loosen the dirt.
When washing the vehicle, park it in the Remove dirt and mud from the body up the damage following the procedure
place where direct sunlight does not fall on exterior with running water. You may below:
it as much as possible and follow the use a soft sponge or brush. Do not use 1. Clean all damaged spots and allow
instructions below: hard materials which can scratch the them to dry.
1) Flush the underside of body and wheel paint or plastic. Remember that the 2. Stir the paint and touch up the dam-
housings with pressurized water to headlight covers or lenses are made of aged spots lightly using a small
remove mud and debris. Use plenty of plastic in many cases. brush.
water. 3. Allow the paint to dry completely.
NOTICE
NOTICE To avoid damage to the paint or plas-
When washing the vehicle: tic surface, do not wipe the dirt off
• Avoid directing steam or hot water without ample water. Follow the
of more than 80°C (176°F) on plas- above procedure.
tic parts.
• To avoid damaging engine compo- 3) Wash the entire exterior with a mild
nents, do not use pressurized detergent or car wash soap using a
water in the engine compartment. sponge or soft cloth. The sponge or
cloth should be frequently soaked in the
soap solution.
11-4
APPEARANCE CARE

Washing by an automatic car wash Washing by a high-pressure cleaner Caring for Lights
Wash the lens part of light and wipe it off
NOTICE NOTICE with a soft cloth.
• If you use an automatic car wash, If you use a high-pressure cleaner,
check that your vehicle’s body keep away the nozzle from your vehi- NOTICE
parts, such as antenna and spoil- cle sufficiently. • Do not use the detergent including
ers, cannot be damaged. If you are • Pointing the nozzle to the sur- organic solvent on the lens surface
in doubt, consult the car wash rounding parts of camera can allow of the light. The lens surface may
operator for advice. water to enter the camera. be cracked.
• Do not wash a car with a roof end This may cause a fire, malfunction, If you use the detergent including
spoiler in an automatic car wash. dew condensation, etc. organic solvent, rinse it off with
It may get caught in the car wash • For vehicle with 360 view camera or ample water.
and damage the spoiler. rear view camera, do not point to • Do not wipe the lens surface by
the nozzle to the camera. wax or a hard brush. This may
• Bringing the nozzle to your vehicle damage the lens or hasten its dete-
too close or pointing the nozzle to rioration.
the opening of front grill or bumper
etc. can cause damage and mal-
function of the vehicle body and
parts.
• Pointing the nozzle to door glasses
and door frames can allow water to
enter the cabin.

Caring for the Windshield


If an oil film, etc. adheres to the windshield
and the windshield wipers cannot clean it,
use a glass cleaner (sold separately) to
clean the windshield by hand.

11-5
APPEARANCE CARE

Caring for Cameras Caring for Aluminum Wheels Waxing


Wash the lens part of camera and wipe it
off with a soft cloth. If the lens part is very NOTE:
dirty, use a mild detergent. • Do not use an acidic or alkaline deter-
gent, or a cleaner containing petroleum
NOTICE solvent to wash aluminum wheels.
These types of cleaners will cause per-
• Using alcohol, benzine, thinner etc. manent spots, discoloration and cracks
to wipe the camera may cause dis- on the finished surface and damage to
coloration. the center cap.
When you wipe the camera, do not • Do not use a bristle brush and a soap
use alcohol, benzine, thinner etc. containing an abrasive material. These
• Hard coating is used for the lens of will damage the finished surface.
camera not to be easily scratched.
However, if you use the brush for a
vehicle, it may be difficult for you 60G412
to see the image on the 360 view
camera. After washing the vehicle, waxing and pol-
Be very careful not to scratch the ishing are recommended to further protect
lens. and beautify the paint.
• The resin cover of the camera may • Only use waxes and polishes of good
be damaged if an organic solvent quality.
adheres to the camera. • When using waxes and polishes,
Do not let organic solvent, body observe the precautions specified by the
wax, oil film remover, or glass coat- manufacturers.
ing agent adhere to the product.
• If the camera is subjected to a sud-
den temperature change, it may be
damaged.
Do not expose the camera to sud-
den temperature changes such as
melting frozen snow with hot water.

11-6
APPEARANCE CARE

Cleaning Interior Vinyl Upholstery


NOTICE Prepare a solution of soap or mild deter-
• Clean out any dirt, sand, etc. using a gent dissolved in warm water. Apply the
vacuum cleaner, or wipe off the surfaces • Do not use chemical products con- solution to the vinyl with a sponge or soft
using a soft cloth moistened with cold or taining the following ingredients. cloth and let it soak for a few minutes to
lukewarm water. If the interior is left dirty, Doing so may cause staining, dis- loosen dirt.
scratches can occur. coloration, deformation, or a deteri- Rub the surface with a clean, damp cloth
• Quickly clean off any liquids such as oration in strength, etc. to remove dirt and the soap solution. If
those from air fresheners or spilled bev- – Solvents such as benzine, gas- some dirt still remains on the surface,
erages by using tissue paper or a soft oline, thinner, or sticker peeling repeat this procedure.
cloth. Leaving spilled liquids can cause agents
staining, discoloration or cracking. – Acidic or alkaline detergents
– Bleaches or dyes
Fabric Upholstery
WARNING • Do not use chemical products that Remove loose dirt with a vacuum cleaner.
• Do not spray the interior with water include silicone for cleaning the Using a mild soap solution, rub stained
or other liquids. If the navigation areas around the air conditioner, areas with a clean damp cloth. To remove
equipment, audio components, electronic equipment such as the soap, rub the areas again with a cloth
switches, wiring under the floor, or audio or navigation systems or dampened with water. Repeat this until the
other electrical parts become wet, switches. Contact with silicone stain is removed, or use a commercial fab-
may cause them to malfunction. ric cleaner for tougher stains. If you use a
there is a risk of fire or malfunction,
and the SRS airbag system could • Do not leave colored leather goods, fabric cleaner, carefully follow the manu-
furs, vinyl articles, etc. in your vehi- facturer’s instructions and precautions.
fail to function normally.
cle for long periods. Doing so
If you pour water or spill a drink in
could cause discoloration or defor-
the vehicle, consult a Maruti Suzuki
mation of the interior.
authorised workshop as soon as
possible for inspection.
NOTE:
To prevent liquid-based air fresheners from
spilling, it is recommended to fix their con-
tainers in place, or use solid-type air fresh-
eners instead.

11-7
APPEARANCE CARE

Leather Upholstery Seat Belts Instrument Panel and Console


Remove loose dirt with a vacuum cleaner. Clean seat belts with mild soap and water. Remove loose dirt with a vacuum cleaner.
Using a mild soap or saddle soap solution, Do not use bleach or dye on the belts. Gently wipe dirt off with a tightly squeezed
wipe dirt off with a clean damp soft cloth. They may weaken the fabric of the belts. damp clean cloth. Repeat this until the dirt
To remove soap, wipe the areas again with is removed.
a soft cloth dampened with water. Wipe the
areas dry with a soft dry cloth. Repeat this Vinyl Floor Mats NOTICE
until the dirt or stain is removed, or use a Ordinary dirt can be removed from vinyl
commercial leather cleaner for tougher dirt Do not use chemical products that
with water or the mild soap. Use a brush to
or stains. If you use a leather cleaner, contain silicon to wipe electrical
help loosen dirt. After the dirt is loosened,
carefully follow the manufacturer’s instruc- components such as the air condi-
rinse the mat thoroughly with water and
tions and precautions. Do not use solvent tioning system, audio, navigation
dry it in the shade.
type cleaners or abrasive cleaners. system, or other switches. These will
cause damage to the components.
NOTE: Carpets Do not spray water or any liquid
• In order to keep the leather upholstery Remove the dirt and soil as much as possi- directly on instrument cluster or any
looking good, it should be cleaned at ble with a vacuum cleaner. Using a mild other electrical or electronic compo-
least twice a year. soap solution, rub stained areas with a nents. This may cause damage and/
• If the leather upholstery becomes wet, clean damp cloth. To remove soap, rub the or lead to non-functioning of the part.
immediately wipe it dry with a tissue areas again with a cloth dampened with
paper or a soft cloth. Water may cause water. Repeat this until the stain is
the leather to harden and shrink if it is removed, or use a commercial carpet
not wiped off. cleaner for tougher stains. If you use a car-
• When parking on sunny days, select a pet cleaner, carefully follow the manufac-
shady place or use a sunshade. If the turer’s instructions and precautions.
leather upholstery is exposed to the
direct sunlight for a long time, it may dis-
color and shrink.
• As is common with natural materials,
leather is inherently irregular in grain and
cowhide has spots in its natural state.
These do not affect the performance of
the leather in any way.
68PM09004

11-8
APPEARANCE CARE

NOTICE
• Liquids such as liquid aromatics,
soft drinks or juice may cause dis-
coloration, wrinkles, and cracking
to resin-based parts and textiles.
Immediately wipe it dry with tissue
paper or a soft cloth.
• Do not leave leather products with
color, fur or vinyl products, etc. in
your vehicle for long periods. It
may cause discoloration or deterio-
ration of interior.

Inside of the Tailgate Window


NOTE:
Wipe the window along the antenna wires
or heat wires by a soft cloth dampened
with water to avoid damaging these wires.

Head-up Display
The surface of the display is coated, so
please wipe off the dirt with a soft cloth like
an eyeglass wipe.

NOTICE
• Do not use a hard cloth or deter-
gent as it may damage the display
or the surface coating.
• Do not apply too much force when
wiping the display or mirror, as it
may damage it.

11-9
SPECIFICATIONS

SPECIFICATIONS
Vehicle Identification .......................................................... 12-1
FASTag (if equipped) ........................................................... 12-2
High Security Registration Plate (HSRP) (if applicable)....12-3
Fuel Recommendation ........................................................ 12-4
Specifications ...................................................................... 12-5

84MM01001

12
SPECIFICATIONS

Vehicle Identification also used to assist a Maruti Suzuki autho- Engine Serial Number
rised workshop when ordering or referring
Chassis Serial Number to special service information. Whenever
you have occasion to consult a Maruti
Suzuki authorised workshop, remember to
identify your vehicle with this number.
Should you find the number difficult to
read, you will also find it on the identifica-
tion plate.

55T120060

The engine serial number is stamped on


55T120020 the cylinder block as shown in the illustra-
tion.

55T120040

The chassis and/or engine serial numbers


are used to register the vehicle. They are
12-1
SPECIFICATIONS

FASTag (if equipped) As seen from inside of the vehicle As seen from outside of the vehicle
As per Ministry of Road Transport and
Highways, the FASTag (1) is mandatory
for each vehicle for the purpose of elec-
tronic toll collection or any other purpose Easy to Cruise

as may be defined by the Government of


India.
In case of any damage to FASTag or
! Please do not peel off the tag, as it
would permanently damage the tag

replacement of front windscreen, please 4


contact your nearest Maruti Suzuki autho- xxxx xxxx xxxx xxxx xxxx xxxx
rised workshop. 64MM01002

NOTE:
64MM01003
The picture shown is for indicative purpose
(1) only. Internal structure of actual device NOTE:
mounted on vehicle may be different. The picture shown is for indicative purpose
only. Internal structure of actual device
mounted on vehicle may be different.
NOTE:
• Any attempt to remove the tag from the
windscreen will result in permanent dam-
age to the tag.
64MM01001 • Use of chemical cleaners to clean the
windscreen area where the tag is
mounted can damage the tag.
• Use of any sharp objects on the tag can
damage the tag.

12-2
SPECIFICATIONS

High Security Registration Third license plate - As seen from out- • Use of any sharp objects on the label
side of the vehicle can damage the label.
Plate (HSRP) (if applicable) • In the event of any replacement of the
(a)
As per Ministry of Road Transport and third license plate, may please contact
Highways, every new vehicle must have the approved authority.
HSRP.
HSRP contains; Third license plate - As seen from
• Front and rear HSRP, which will be fitted inside of the vehicle
(b)
with 2 snap-locks each on number plate
area. (c)) F : XXXXXXXX R : XXXXXXXX (d)
• Third license plate on front windshield. (e) -
Notice
- It is unlawful for any person to duplicate, alter,
Third License Plate change, deface, destroy, multilate, remove,
64MM01008
tear down this Third Registration Plate Sticker,
except if done by authority of law.
(1) (a) HSRP issuing authority name Do not wipe with harsh abrasive materials,
(b) Vehicle registration number detergents, etc. as it may deface or damage this Sticker.
(c) Unique laser number - Front plate
(d) Unique laser number - Rear plate
(e) Date of 1st registration
64MM01009
(in DD-MM-YYYY format)
(f) Green strips (BS6 vehicle) NOTE:
The picture shown is for indicative purpose
NOTE: only.
The picture shown is for indicative purpose
64MM01005 only. Internal structure of actual label NOTE:
(1) Third license plate mounted on vehicle may be different. Color of third license plate (back) is as per
HSRP regulation as defined by Ministry of
NOTE: Road Transport and highways.
• Any attempt to remove the third license
plate from the windscreen will result in
permanent damage to the label.
• Use of chemical cleaners to clean the
windscreen area where the label is
mounted can damage the same.

12-3
SPECIFICATIONS

Fuel Recommendation
Petrol Engine NOTICE
• The fuel tank has an air space to
To avoid damaging catalytic converter, you
allow for fuel expansion in hot
must use unleaded petrol with an octane
weather. If you continue to add fuel
number (RON) of 91 or higher.
after the filler nozzle has automati-
Gasoline/Ethanol blends cally shut off or an initial blowback
Blends of unleaded gasoline and ethanol, occurs, the air chamber will
also known as gasohol, are commercially become full. Exposure to heat
available in the country and can vary with when fully fuelled in this manner
location. Gasoline Ethanol blend up to E20 will result in leakage due to fuel
can be used as fuel for this vehicle. expansion. To prevent such fuel
leakage, stop filling after the filler
Gasoline containing MTBE nozzle has automatically shut off,
Unleaded gasoline containing MTBE or when initial vent blowback
(methyl tertiary butyl ether) may be used in occurs, if using an alternative non-
your vehicle if the MTBE content is not automatic system.
greater than 15%. This oxygenated fuel • Be careful not to spill fuel contain-
does not contain alcohol. ing alcohol while refueling. If fuel is
spilled on the vehicle body, wipe it
up immediately. Fuels containing
CAUTION alcohol can cause paint damage,
which is not covered under the
Use of spurious, low quality, adulter- New Vehicle Limited Warranty.
ated fuel can cause damage to the
engine and engine auxilliaries, affect
functioning of engine and degrade
engine performance including but
not limited to engine seizure.

12-4

55TH0-74E
SPECIFICATIONS

Specifications
NOTE:
Specifications are subject to change without notice.
M/T: Manual transmission

ITEM: Dimensions UNIT: mm


Overall length 3990
Overall width 1745
Overall height 1500
Wheelbase 2520
Track 185/65R15 tyre 1515
Front
195/55R16 tyre 1505
185/65R15 tyre 1520
Rear
195/55R16 tyre 1510
Ground clearance 150

ITEM: Mass (weight) UNIT: kg


Curb mass (weight) M/T 925-955
Auto Gear Shift 940-960
Gross vehicle mass (weight) rating 1410
Permissible maximum Axle Weight Front 810
Rear 780

12-5

55TH0-74E
SPECIFICATIONS

ITEM: Engine
Type K12N(DOHC)
Number of cylinders 4
Bore 73.0 mm
Stroke 71.5 mm
Piston displacement 1197 cm3 (1197 cc)
Compression ratio 12.0: 1

ITEM: Electrical
Standard spark plug NGK ILZKR6F11
Petrol ISS M42*1 20HR 38 AH CCA 330 A (JIS)
Battery
CNG 34B19L
Fuses See “INSPECTION AND MAINTENANCE” section.
*1: Your vehicle is equipped with a lead-acid battery for exclusive use of the ENG A-STOP system (if equipped).
When replacing the lead-acid battery, make sure to select the specified type for ENG A-STOP system. Consult a Maruti Suzuki autho-
rised workshop for replacing the lead-acid battery.

12-6
SPECIFICATIONS

ITEM: Lights WATTAGE BULB No.


Interior light Front 12V 5W W5W
Center 12V 10W C10W
Luggage compartment 12V 5W W5W
(if equipped)
Courtesy light (if equipped) 12V 5W W5W
Glove box light (if equipped) 12V 1.4 W T5
Front foot well light LED*1 –
(if equipped)
• If you need to replace the following bulbs indicated in the above table, consult a Maruti Suzuki authorised workshop.
*1 Since the lights are non-disassemble type, you cannot replace a bulb. Replace the target assembly if any light is defective.

12-7
SPECIFICATIONS

ITEM: Wheels and tyres


Tyre size, front and rear 185/65R15 88H*1, 195/55R16 87H*1
Rim size with steel wheels 15X5 1/2J
with aluminum wheels 16X6J
Tyre pressures For the specified tyre pressure, see the tyre information label located
on the driver’s door lock pillar.
*1: If you cannot prepare tyres with the specified load index rate and speed symbol, prepare tyres with higher load index rate and speed
symbol.

12-8
SPECIFICATIONS

ITEM: Recommended fuel / lubricants and capacities (approx.)


Fuel See “FUEL RECOMMENDATION” section. 37 L
For india Classification: API SN
Viscosity: SAE 0W-16
Engine oil 3.7 L (replacement with oil filter)
Except for india Classification: API SN, SP
Viscosity: SAE 0W-16
Petrol See “INSPECTION AND MAINTENANCE” sec- 4.2 L (including reservoir tank)
Engine coolant
CNG tion. 4.3 L (including reservoir tank)
Manual transmission oil
“MARUTI GENUINE GEAR OIL 75W” 1.5 L
Auto Gear Shift transmission oil
MARUTI GENUINE BRAKE FLUID (MGBF) Refill to the proper oil level accord-
or DOT 3. ing to the instructions in “INSPEC-
Brake fluid / Clutch fluid
TION AND MAINTENANCE”
section.
Windshield washer fluid – 2.0 L
Auto Gear Shift (AGS) actuator oil – 0.55 L (including reservoir tank)

12-9
MEMO
6(59,&(1(7:25. $621

„0$587,68=8.,$87+25,6(''($/(5:25.6+23  6$/(66(59,&(:$55$17< 63$5(3$576


„0$587,68=8.,1(;$'($/(5:25.6+23  6$/(66(59,&(:$55$17< 63$5(3$576
„0$587,6(59,&(0$67(5 060  6(59,&(:$55$17< 63$5(3$576
„0$587,6(59,&(=21( 06=  6(59,&(:$55$17< 63$5(3$576
„0$587,$87+25,6('6(59,&(67$7,216 0$66V  µ$¶&$7(*25<0$66V 0$5.('
Free & paid Service, Major repairs & Accidental repairs
µ%¶&$7(*25<0$66V 0$5.('
Free & paid Service & Major repairs
µ&¶&$7(*25<0$66V 0$5.('
Free & paid Service & Minor repairs
µ'¶&$7(*25<0$66V 0$5.('
Free Service & Minor repairs
NOTE:
&HUWDLQ MASSs are not authorised to undertake Warranty jobs. Customers are requested to approach only Maruti Suzuki
Authorised DealerWorkshop / Maruti Suzuki Nexa Dealer Workshop / Maruti Service Master / Maruti Service Zone for Warranty jobs.
7KHFKDUJHVDQGVHUYLFHVPD\YDU\GHSHQGLQJXSRQVHUYLFHQHWZRUNDQGORFDWLRQ
For latest Service Network details kindly visit ZZZPDUXWLVX]XNLFRP or contact our regional office / area office as mentioned below.
5(*,21$/2)),&( $5($&29(5('
5(*,21$/2)),&( 1257+, 0$587,68=8.,,1',$/,0,7('
QG)/225',9,1(5$-38552$''(+5$'81877$5$.+$1' 877$5$.+$1'$1'3$572)83
3+
5(*,21$/2)),&( 1257+,, 0$587,68=8.,,1',$/,0,7(' 381-$%&+$1',*$5+3$1&+.8/$=,5$.385
6&26(&725&0$'+<$0$5*&+$1',*$5+093+12 02+$/,-$008$1'.$6+0,5 /$'$.+
5(*,21$/2)),&( 1257+,,, 0$587,68=8.,,1',$/,0,7('
7+)/2256800,73/27127&*9,%+87,.+$1'*207,1$*$5±/8&.12: 3$572)83

5(*,21$/2)),&( 1257+,9 0$587,68=8.,,1',$/,0,7('


6&2),567)/2256(&7253$1&+.8/$ +$5<$1$ 3+   3$572)+$5<$1$$1'+,0$&+$/35$'(6+

5(*,21$/2)),&( ($67, 0$587,68=8.,,1',$/,0,7('


3/2712,,'$&7,21$5($,,'1(:72:1.2/.$7$ :(67%(1*$/6,..,0$1'$0$1 1,&2%$5

5(*,21$/2)),&( ($67,, 0$587,68=8.,,1',$/,0,7('


7+)/22552+,1,233+27(/$36$5$&,5&8/$552$'/$/3855$1&+, %,+$5-+$5.+$1'
-+$5.+$1'3+
5(*,21$/2)),&( ($67,,, 0$587,68=8.,,1',$/,0,7('
$581$&+$/35$'(6+$66$00$1,385
$7+)/2253($&((1&/$9(8/8%$5,*652$'*8:$+$7, $66$0  0(*+$/<$0,=25$01$*$/$1'75,385$
7(/(


6(59,&(1(7:25. $621

5(*,21$/2)),&( :(67, 0$587,68=8.,,1',$/,0,7('


Plot No-GEN 25 + 25 B/2,TTC INDUSTRIAL AREA,PAWANE VILLAGE,THANE BELAPUR ROAD,NAVI 3$572)0$+$5$6+75$$1'*2$
MUMBAI- 400705 PH NO-022 45042300
5(*,21$/2)),&( :(67,, 0$587,68=8.,,1',$/,0,7('
6$&5(':25/'7+)/2251257+%/2&.81,7180%(5-$*7$3&+2:.:$1$:$', 3$572)0$+$5$6+75$
381(± 0$+$5$6+75$ 3+  
5(*,21$/2)),&( :(67,,, 0$587,68=8.,,1',$/,0,7('
1')/225,6&210$//$%29(67$5,1',$%$=$56$7(//,7($+0('$%$' *8-$5$7'$'5$ 1$*$5+$9(/,'$0$1$1'
3+12± ',8

5(*,21$/2)),&( 6287+, 0$587,68=8.,,1',$/,0,7('


WK)ORRU%ORFN$*OREDO,QIRFLW\3DUN1R$QQD1HGXQFKDODL.DQGDQFKDYDGL3HUXQJXGL&KHQQDL 7$0,/1$'8$1'321',&+(5<
7DPLO1DGX±3+±
5(*,21$/2)),&( 6287+,, 0$587,68=8.,,1',$/,0,7('
1')/225(0%$66<&/$66,&%8,/',1*9,77$/0$//<$52$'%$1*$/25( .$51$7$.$
.$51$7$.$3+  
5(*,21$/2)),&( 6287+,,, 0$587,68=8.,,1',$/,0,7(' .(5$/$
1')/2257878672:(561+%<(3$663$',9$7720&2&+,1
5(*,21$/2)),&( 6287+($67, 0$587,68=8.,,1',$/,0,7'
),567)/2250$+$9,5&+$0%(56/,%(57<648$5(67$1=$+,0$<$7+1$*$5 $1'+5$35$'(6+7(/$1*$1$
+<'(5$%$'7(/$1*$1$&217$&712
5(*,21$/2)),&( 6287+($67,, 0$587,68=8.,,1',$/,0,7('
87.$/6,*1$785(81,712  7+)/225 1+3$+$/&877$&.%+8%$1(6:$5 2',6+$$1'&++$77,6*$5+
52$'%+8%$1(6:$52',6+$3+ 
5(*,21$/2)),&( &(175$/, ,, 0$587,68=8.,,1',$/,0,7('
1HOVRQ0DQGHOD0DUJ9DVDQW.XQM,,9DVDQW.XQM1HZ'HOKL'HOKL '(/+,

5(*,21$/2)),&( &(175$/,,, 0$587,68=8.,,1',$/,0,7('


7+322-$72:(5*23$/385$%<(3$66721.52$'-$,385 5$-$67+$1  5$-$67+$1
&217$&712
5(*,21$/2)),&( &(175$/,9 0$587,68=8.,,1',$/,0,7('
5')/225&200(5&(+286(5$&(&2856(52$',1'25( 03 3,1&2'( 0$'+<$35$'(6+
&217$&712


6(59,&(1(7:25. $621

'(7$,/62)$5($2)),&(6
$UHD2IILFH/RFDWLRQ $UHD2IILFH$GGUHVV

Maruti Suzuki India Limited, 7th Floor, B-15/8, Shri Vrindavan Tower, Sanjay Place, Agra-282001
Agra
Ph:-0562-4052646/47

Maruti Suzuki India Limited, 522, 5th Floor Corporate Zone, Ashima Mall, Hoshangabad Road, Bhopal (M.P)
Bhopal
Pin Code: 462 026 Contact : 0755 6051555

Maruti Suzuki India Limited,*URXQG)ORRU$DUSHHV$UFDGH<0&$&URVV5RDG2SS,QGXVLQG%DQN


Calicut
.R]KLNRGH.HUDOD3,13KRQH

Maruti Suzuki India Limited, Srivari Gokul Towers, First floor, (East wing), No.108/3, Race course,
Coimbatore
Coimbatore - 641018 Ph.- 0422-2221091

Maruti Suzuki India Limited, Shiva Avenue, 2nd Floor, Gokul Road, Hubli - 580030,
Hubli
Ph: 0836-4259447

Maruti Suzuki India Limited, Hall no: 315, A2,3rd Floor, South Block, Bahu Plaza, Jammu-180012
Jammu
M: 9622066444/9622524343

Maruti Suzuki India Limited, SCO No. 16/17, 4Th Floor, Fortune Chambers, Feroze Gandhi Market,
Ludhiana
Ludhiana-141001, Ph: 0161-464976

Maruti Suzuki India Limited, 3rd floor, ADR towers, Kalavasal, Theni Bye pass road, Madurai-625016
Madurai
Ph. - 0452-4200203

Maruti Suzuki India Limited, )1st Floor, &ODVVLF*DWHZD\0DKDYHHU&LUFOH3XPSZHOO


0DQJDORUH
0DQJDORUH±3h. 



6(59,&(1(7:25. $621

'(7$,/62)$5($2)),&(6
$UHD2IILFH/RFDWLRQ $UHD2IILFH$GGUHVV

Maruti Suzuki India Limited, 3lot No.244, 1st Floor, Narayani House, Hill Road, Dharampeth ExtenVion,
Nagpur
Nagpur - 440010 (MahDrashtra) Ph. (0712) 2225808

Maruti Suzuki India Limited, Plot No.202, Rushiraj Towers, Jehan Circle, Gangapur Road,
Nashik
Nashik - 422 005 (Maharashtra) Ph. (0253) 6698551

Maruti Suzuki India Limited, 307-308, Vasundhara Metro Mall, Rajapur Pul, East Boring Canal Road,
Patna
Patna - 800001, Bihar Phone - 0612-2559145

Maruti Suzuki India Limited, 629-630, Magneto Offizo,Magneto The Mall, Labhandi, Raipur,
Raipur
Chhattisgarh, Pin - 492001 Ph.- 0771-4039643

Maruti Suzuki India Limited, Unit 401, 4th Floor, Quantum Siliguri, Parivahan Nagar, Matigara
Siliguri
Siliguri - 734010 West Bengal

Maruti Suzuki India Limited, 304, Shivalik Western, Above TGB Restaurant, L.P. Savani Road, Adajan
Surat
Surat - 395009

Maruti Suzuki India Limited, 8th Floor, KEK Tower, Opp. Police Head Quarters, Vazhuthacadu,
Trivandrum
Trivandrum - 695010, Phone:- 0471-2322366

Maruti Suzuki India Limited, 302 & 303, 3rd Floor. Manglam's Fun Square, Durga Nursery Road.
Udaipur
Udaipur, (Rajasthan) 313001

Maruti Suzuki India Limited, 9DLVKLQDYL&RPSOH[WK)ORRU8QLW2SSRVLWH([HFXWLYH&OXE


9LMD\DZDGD
9LMD\DZDGD -530002,
Maruti Suzuki India Limited, Door No. 10-50-58/1, 3rd Floor, Waltair Main Road, Ramnagar,
Visakhapatnam
Above westside store, RK Estates, Visakhapatnam-530002, Andhra Pradesh Contact No: 0891 2745299


Nexa Workshop (AS ON 31.05.2023 )
11. VARUN MOTORS (26NA-26-02), DOOR 21. VISHAL CAR WORLD (J4NA-J4-01), NEXA 31. SATYA AUTOMOBILES (U7NB-U7-01), SHED NO
ANDHRA PRADESH NO1-1-153,REVENUE WARD NO.1,BLOCK SHOWROOM (BESIDE VISHAL BIKER’S 10, PART OF KHASRA NO 885, INDUSTRIAL
ANANTHAPUR NO3,VIDHYADARARPURAM,VIJAYAWADA - WORLD),A.T. ROAD, LAIPULI,TINSUKIA ,ASSAM AREA, RAJGAMAR ROAD, KORBA (C.G) - 495677
1. SRI DURGA (1BNA-1B-01), NO.124, 520012 -786183 - 786183 PH :9993092051.
SOMALADODDI, ANANTHAPUR, ANDRA PH :9989477120. PH :9864211022. RAIPUR
PRADESH - 515004 VISAKHAPATNAM BIHAR 32. SPARSH (50NA-50-01), NEAR TCI GODOWN,
PH :9885183851.
12. VARUN MOTORS (46NA-46-01), DOOR NO GAYA NH-6, CHANDANDIH, TATIBANDH, RAIPUR,
GUNTUR 38-22-27, SURVEY NO 39, KAPARADA VILLAGE, CHATTISGARH - 492029
22. KARLO MOTORS (Y6NA-Y6-01), GAYA DOBHI
2. JAYLAXMI (G5NA-G5-01), D-NO:199/2, INDUSTRIAL ESTATE, VISHAKHAPATNAM - PH :9926626662.
MAIN ROAD, NEAR DOMUHAN, BODHGAYA, PIN
OPP.AUTONAGAR, NH 16, VJA - GNT SERVICE 533016 33. SKY AUTOMOBILES (50NB-50-01), NEXA
-824231, BIHAR. - 824231
ROAD, GUNTUR, ANDHRA PRADESH - 522001 PH :9885317344. MAGNETO, LABHANDHI ,G. E. ROAD, RAIPUR -
PH :9934096400.
PH :9959844644. VIZIANAGARAM 492001
PATNA PH :9425204051.
KAKINADA 13. JAYABHERI AUTO (N8NA-N8-01), OPPOSITE
3. VARUN MOTORS (W7NA-W7-01), BHASKARA RELIANCE MART, BALAJI JUNCTION, 100 FEET
23. ALANKAR AUTOMOBILES (15NA-15-01), DELHI
OPP.RUPASPUR THANA, BAILEY ROAD NEAR
GARDENS JAGANDHAPURAM ,KAKINADA - RING ROAD , VIZIANAGARAM - 535002 DELHI
GOLA ROAD, PATNA - 800002
533016 PH :08340833999.
PH :9199427707. 34. RANA MOTORS (08NE-08-01), B-242, OKHLA
PH :9885313744. ASSAM 24. REESHAV AUTOMOBILES (15NB-15-01), INDUSTRIAL AREA PHASE 1, OKHLA, NEW
KURNOOL BONGAIGAON MUKDUMPUR,DIGHA,90 NO GATE, PATNA - DELHI - 110020
4. MSA MOTORS (C2NA-C2-01), PLOT NO. 1, 1A, 2, 800012 PH :7290030289,
14. BHARATI MOTORS (7NNA-7N-01), CHAPAGURI
2A, WARD NO. 96, NH 44, AUTO NAGAR, PH :7369944132. 9290030288.
RD, NEAR POST OFFICE, NORTH
KURNOOL, ANDHRA PRADESH 518003 - 518003 25. SHRI GOPAL (15NC-`15-01), BIKHACHAK 35. TR SAWHNEY (08NN-08-01), C-46, OKHLA
BONGAIGAON, AMGURI, BONGAIGAON, ASSAM
PH :9912826682. ANISHABAD NEW BYPASS ROAD, OPPOSITE INDUSTRIAL AREA PHASE 2, OKHLA NEW
783380 - 783380
NELLORE SITA RAM COMMUNITY HALL, PATNA, BIHAR - DELHI - 110020
PH :7002350887.
800002 - 800002 PH :9953350008.
5. BHARGAVI AUTO (A8NA-A8-01), SURVEY NO DIBRUGARH PH :9113746967. 36. PLATINUM MOTORS (08NQ-08-01), PLOT
245B, CHEMUDUGUNTA VILLAGE, NH-16, NO-H4,BLOCK-B1,MOHAN CO-OPERATIVE
15. VISHAL CAR WORLD (C1NA-C1-01), PURNEA
ADJACENT TO SRIDS KALYANA MANDAPAM, INDEX,MATHURA ROAD,PIN-110044 - 110044
MOHPUALIMORA GOHAIN GAON, A.T ROAD,
NELLORE, ANDHRA PRADESH - 524002 26. SIMANCHAL (6VNA-6V-01), DAMKA
DIBRUGARH, ASSAM - 786008 PH :9811386000,
PH :8886682222. CHOWK,KISHANGANJ ROAD,
PH :8000900008. 8860200000.
ONGOLE NH-31,GUALBBAGH,PURNEA,BIHAR - 854326
GUWAHATI 37. MAGIC AUTO (08NA-08-01), CISF GATE NO 1,
PH :9334710055.
6. JAYALAXMI (8YNA-8Y-01), SURVEY NO:194/2, D-21, CORPORATE PARK, NEAR DWARKA
BESIDE NH 5, MUKTHINUTHALAPADU, ONGOLE,
16. PODDAR AUTO (09NA-09-01), AT ROAD CHANDIGARH SEC-8 METRO STATION, NEW DELHI - 110075
,KAMAKHYA GATE ,GUWHATI ,KAMRUP-781009 PH :9873052000.
ANDHRA PRADESH – 523225 - 523225
- 781009 CHANDIGARH
PH :9492133433. 38. AAA VEHICLEADES (08NW-08-01), BLOCK C,
PH :8085957586. 27. AUTOPACE (FEB) (07NA-07-01), PLOT NO. 37, NAJAFGARH ROAD INDUSTRIAL AREA, NEW
RAJAHMUNDRY 17. BIMAL AUTO (09NB-`09-01), DREAMLAND INDUSTRIAL AREA – PHASE 1, CHANDIGARH - DELHI, DELHI 110015 - 110015
7. SB MOTORS (C5NA-C5-01), D.NO:84-1-12, APPARTMENT,NAHRANI PATH, DISPUR LAST 160002 PH :8750611111.
PADMAVATI NAGAR, BESIDE ONGC BASE GATE, GUWAHATI - 781006 (ASSAM) - 781006 PH :7087119861. 39. COMPETENT AUTO (08NF-08-01), PLOT
COMPLEX, NH-45, RAJAHMUNDRY, PH :9864074525. 28. NAVDESH AUTO (07NE-07-01), PLOT NO 182/11, NO-34,RAJASTHAN UDYOG NAGAR, GT AKRNAL
ANDRAPRADESH-533106. - 533016 JORHAT INDUSTRIAL AREA PHASE 1, CHANDIGARH - ROAD ,DELHI - 110033
PH :9248727888. 160002 PH :9932049425.
18. RD MOTOR (G9NB-G9-01), M/S R D MOTORS
SRIKAKULAM PH :8827057534. 40. JAGMOHAN MOTORS (08NX-08-01),
PVT LTD , DHAPKATA, NEAR TINALI, JORHAT
8. VARUN MOTORS (W6NA-W6-01), PEDDAPADU -785006 - 785006 CHHATTISGARH C133-136(PART, PHASE I, INDUSTRIAL AREA,
PH :7002099547. MANGOLPURI S BLOCK, NEW DELHI, DELHI
ROAD, ARASAVALLI POST, SRIKAKULAM AMBIKAPUR
110083 - 110083
DISTRICT, ANDHRA PRADESH - 532401 SILCHAR 29. MAHAMAYA (AENA-AE-01), AJAB PH :9812259000.
PH :9885317344.
19. JAIN UDHYOG (J2NA-J2-01), R.S. PATTA NO.149, NAGAR,MAHATHMA GANDHI ROAD,AMBIKAPUR
VIJAYAWADA DAG NO.579, MOUZA RONGPUR, SILCHAR, - 497001 GOA
9. VARUN MOTORS (26NA-26-01), OPP TO PRIYA ASSAM - 788009 PH :9516609632. MARGAON (GOA)
PICKLES, BANDAR ROAD, PORANKI, PH :9436121557. BILASPUR 41. CHOWGULE INDUSTRIES (34NB-34-01), SY. NO.
VIJAYAWADA, ANDRAPRADESH-521137. - TEZPUR 30. SATYA AUTOMOBILES (C3NB-C3-01), PLOT NO 267/1, NEXT TO ARLEM RTO, ARLEM, RAIA,
521137 SALCETE - (GOA) - 403720. - 403720
20. RD MOTOR (T1NA-T1-01), SOLAGAN VILLAGE , 53, SECTOR C, SIRGITTI INDUSTRIAL AREA,
PH :6309955655. PH :9850966950.
GOROIMARI , SONABEEL, BEFORE MAA BILASPUR, CHHATTISGARH - 495001
10. PARAMSHIVA MOTORS (26NB-26-01), NO. PORVORIM(PANJIM)
KALYANI PETROL PUMP, TEZPUR -784105 - PH :6372803057.
20-1-34, C K REDDY ROAD, AYODHYA NAGAR,
784105 KORBA
VIJAYAWADA, ANDRAPRADESH- 520003. -
PH :9836872710.
520003
PH :9866551078. TINSUKIA

5
Nexa Workshop (AS ON 31.05.2023 )
42. SAI SERVICE (34NA-34-01), EMPRESSA 51. NANDA AUTOMOBILES (2BNA-2B-01), BLOCK 61. KATARIA AUTO (22NA-22-01), WARD NO 11 72. EAKANSH MOTORS (U8NA-U8-01), NH-65, OPP
INDUSTRIAL CHODANKAR, SURVEY NO. 114/2, NO 403, NR SANGATH GATEWAY, OPP RAISAN CIRCLE SAINATH ROAD, HARINAGAR-VASNA RKM FARM, AMBALA ROAD, KAITHAL - 136027
SALVADOR DO MUNDO, PORVORIM, BARADEX, PETROL PUMP, KUDASAN, GANDHINAGAR, ROAD VADODARA - 390007 PH :7419900804,
GOA - 403521 GUJARAT. - 382421 PH :9824701590. 7419900803.
PH :022-61841111, PH :9687641974. VAPI 73. EAKANSH MOTORS (U8NA-U8-02), KHEWAT NO
8291941070. GODHRA -458, KHATONI - 563, KITTAS - 20/87K 01M
62. KATARIA AUTO (97NA-97-01), NEAR CROMA
ADJOINING NEXA SHOWROOM, AMBALA HISAR
GUJARAT 52. RB CARS (2CNA-2C-01), SURVEY NO. 38/2 OUTLET, RATHOD CHAMBERS, DAMAN
ROAD, KAITHAL - 136027
AHEMADABAD PAIKE 1 PAIKE 2, LUNAWADA ROAD, OPP. ROAD,CHALA VAPI - 396191
PH :8813038777.
GIDC, GODHRA - 389001 - 389001 PH :9714799985.
43. STAR LINE CARS (01NE-01-01), PLOT NO 236,
PH :9925051444. KARNAL
GIDC, NARODA, AHMEDABAD, GUJARAT. 382 HARYANA 74. KARNAL MOTORS (89NA-89-01), 118-119 KM
330 - 382330 JUNAGARH
AMBALA MILESTONE, G.T. ROAD, KARNAL, HARYANA -
PH :7436003235. 53. PERFECT AUTO SERVICES (K8NA-K8-01), GIDC
63. EAKANSH WHEELS (18NA-18-01), 132001
44. PEGASUS (01NG-01-01), PLOT NO 9, OPP 2, RAJKOT HIGHWAY, JUNAGARH - 362037
AMBALA-CHANDIGARH HIGHWAY ADJOINING PH :8572801011.
RABARI COLONY BRTS STOP, CTM, NAROL - PH :9909022619.
NARODA HIGHWAY, NH-8, AHMEDABAD,
AAJ SAMAJ VILLAGE-SADDOPUR, AMBALA - PALWAL
MEHASANA 134003
GUJARAT. - 380026 75. AUTONATION (EENA-EE-01), KILA NO.-15/2 &
54. STAR LINE CARS (D1NA-D1-01), REVENUE PH :8395903111.
PH :9909023000. 16/1, 57 MILESTONE, NEAR ECHS HOSPITAL,
SURVEY NO. 342, PLOT NO.1, 4, 5 AND 6 TO 12, BHIWANI
45. POPULAR WHEELERS (01NC-01-01), T P 20, F P MATHURA ROAD, PALWAL - 121102
VILLAGE NAGALPUR, DISTRICT MEHSANA,
78, OPPOSITE SUN SQUARE COMPLEX OFF, C 64. PASCO AUTOMOBILES (X3NA-X3-01), NEAR PH :9811321581.
GUJARAT - 384002
G ROAD, NEAR HL COLLEGE, NAVRANGPURA HUNNAMAL PIAYU, ROHTAK ROAD, BHIWANI- PANIPAT
PH :7211138986,
GULBAI TEKRA, AHMEDABAD, GUJARAT - HARYANA-127021 - 127021
7211138987. 76. AUTO GALLERY (D3NB-D3-01), NANGAL KHERI,
380009 PH :9289192582.
MORBI NEAR BBMB POWER HOUSE, OPP. SEC-29,
PH :9925203344. FARIDABAD PANIPAT, HARYANA - 132103
ANAND 55. PERFECT AUTO SERVICES (X5NA-X5-01),
PH :9812615000.
65. PASCO AUTOMOBILES (58NB-58-01), 14/4,
RAJKOT MORBI HIGHWAY, VILLAGE SANALA,
46. AMAR CARS (F7NA-F7-01), SURVEY NO 1583, MATHURA ROAD, FARIDABAD, HARYANA - REWARI
MORBI - GUJARAT (363641) - 363641
PLOT NO 144, NEAR GANESH CROSSING, 121003
PH :9909022619. 77. DINCO MOTORS (U1NA-U1-01), OPP. TULARAM
ANAND SOJITRA ROAD, ANAND, GUJARAT - PH :9999790229.
PATAN STADIUM, DELHI ROAD, REWARI - 123401
388001 66. BVA AUTO (58NC-58-01), 2J/53-54, NH-2, NIT
PH :0129-4353535,
PH :9925407666. 56. STARINE CARS (Q9NA-Q9-01), ADJACENT FARIDABAD, HARYANA - 121001
9953357777
BHARUCH ARENA SET UP, PATAN UNJHA ROAD, PATAN PH :9911259288.
8448787882
(GUJARAT) - 382465 - 382465 67. VIPUL MOTORS (58NA-58-01), SUB DIVISION
47. RAVIRATNA (F8NA-F8-01), SURVEY NO 185/3, 8448787883.
PH :9909043244. NO-3, INDUSTRIAL PLOT NO. -34, N.I.T,
NH8, ZARDESHWAR, BHARUCH, GUJARAT. - ROHTAK
RAJKOT FARIDABAD HARYANA - 121001
392001
PH :8562019252. 78. JAGMOHAN MOTORS (A6NA-A6-01), NORTHERN
PH :9727700823. 57. PERFECT AUTO SERVICES (55NB-55-01), PLOT
GURGAON BYEPASS, SUKHPURA CHOWK, JIND ROAD,
BHAVNAGAR NO. 110, 111, 127 & 128, KOTHARIYA, NEAR
ROHTAK, HARYANA - 124001
PERFECT HOUSE, GONDAL ROAD, RAJKOT - 68. PREM MOTORS (95ND-95-01), PLOT NO. 5, IDC,
48. KIRAN MOTORS (C9NB-C9-01), RAMDEV PH :8754045446.
360004 SECTOR-16, GURGAON, HARYANA - 122001
SOCIETY, CHITRA GIDC, BHAVNAGAR - SIRSA
PH :9512035501. PH :1292565666.
GUJARAT - 364001
SURAT 69. TR SAWHNEY (95NB-95-01), CRPF CAMP ROAD, 79. SHAKTI MOTORS (E4NA-E4-01), OPP. DELHI
PH :9924123973.
VILLAGE ULLAWAS, NR. PIONEER PARK PUBLIC SCHOOL, NH-09, HISSAR ROAD, SIRSA -
BHUJ 58. KIRAN MOTORS (40NB-40-01), BLOCK NO 443,
SECTOR-62, GURGAON, HARYANA - 122001 125055
FP NO 26 MOJE PALGAM, ADAJAN, SURAT,
49. KD MOTORS (P5NA-P5-01), 33, UMA PARK, PH :1274254441. PH :88160-72888,
GUJRAT -395009 - 395009
BEHIND MARUTI SUZUKI SHOWROOM, 70. PASCO AUTOMOBILES (95NA-95-01), SEC 17-18 88138-75888.
PH :7020569426.
MIRZAPAR HIGHWAY, BHUJ - 370040 DIVIDING ROAD, GURGAON- HARYANA, 122015
PH :9879898799.
59. AMAR CARS (40ND-40-01), SURVEY NO
- 122015
HIMACHAL PRADESH
139,BLOCK NO-"218"\A,OPPOSITE TO AWADH NAGROTA
GANDHIDHAM PH :0124-4398400,
ARENA MALL,V.I.P ROAD
9999239959, 80. KANGRA VEHICLEADS (D9NA-D9-01), VILL
50. BM AUTO LINK (77NA-77-01), SURVEY NO ,BHARTHAMA,SURAT,GUJRAT - 395007
9873873807. HATWAS, PATHANKOT - MANDI HIGHWAY,
129/26, GALPADAR - ANJAR HIGHWAY, PH :9871389795.
AIRPORT ROAD, GANDHIDHAM, KUTCH , JIND NAGROTA BAGWAN DISTT. KANGRA - 176047
SURENDARNAGAR PH :7087916168.
GUJARAT - 370201 71. EAKANSH MOTORS (2KNA-2K-01), KHEWAT NO.
60. DREAM VEHICLES (LCNA-LC-01), PLOT NO. 302,
PH :7211120014.
GIDC AREA, WADHWAN CITY,
- 155, KHASRA NO. - 142, MURRABA NO. - 210 JAMMU AND KASHMIR
GANDHINAGAR OPP. HP LPG BOTTLING PLANT, ROHTAK-JIND JAMMU
SURENDERNAGAR, GUJARAT. - 363035
ROAD, JIND. PIN - 126102. - 126102
PH :8511104644. 81. JAMKASH VEHICLES (33NB-33-01), NH-1A BYE
PH :8529860482.
VADODARA KAITHAL
PASS OPPOSITE CHANNI HIMMAT, JAMMU
(J&K) - 180015
PH :7710400000.

6
Nexa Workshop (AS ON 31.05.2023 )
82. JAMMU MOTORS (33ND-33-01), KHASRA NO. 92. KALYANI MOTORS (02NI-02-01), SURVEY MYSORE 114. INDUS MOTOR (3LNA-3L-01), SURVEY
421, TOPE SHERKHANIA, AKHNOOR ROAD, NO.17/2, KENCHENAHALLI VILLAGE, NO.384/3C,10, MUTTATHODY VILLAGE, INDIRA
104. FRIENDLY MOTORS (25NB-25-01), PLOT NO.262,
OPPOSITE BEST PRICE, JAMMU, JAMMU & RAJARAJESHWARI NAGAR, MYSORE NAGAR, CHENGALA POST, KASARGODE,
HEBBAL INDUSTRIAL AREA, MYSORE,
KASHMIR - 180016 ROAD,BANGALORE, KARNATAKA - 560032 KERALA- 671541 - 671541
KARNATAKA- 570016. - 570016
PH :9419581624. PH :9845049626. PH :9745998341.
PH :9845011686.
93. SURAKSHAA CAR CARE (02NF-02-01), 2/6, KAYAMKULAM
JHARKHAND BERTEN AGRAHARA, OPP TO METRO CASH &
105. KALYANI MOTORS (25NC-25-01), PLOT NO.262,
BOKARO HEBBAL INDUSTRIAL AREA, MYSORE, 115. SAI SERVICE (8LNA-8L-01), S.NO 111/48, KP
CARRY, HOSUR MAIN ROAD, ELECTRONIC
KARNATAKA- 570016. - 570016 ROAD, KAYAMKULAM, KERALA - 690502
83. HINDUSTAN AUTO AGENCY (B5NA-B5-01), CITY, BANGALORE, KARNATAKA - 560100
SHIMOGA PH :9288024222.
KHATA NO. 752, PLOT NO. 7792, NH-32, CHAS, PH :9845047393.
BOKARO. - 827013 94. PRATHAM MOTORS (02NK-02-01), 106. SHRUTI MOTORS (B7NA-B7-01), 217/215/91/79/1, KOLLAM
PH :9304807318. 120,SARJAPUR MAIN ROAD,DODDAKANAHALLI, OPP TO FOREST OFFICE, SHANTI NAAGARA, 116. SARATHY AUTOCARS (C7NA-C7-01), NH-47 BYE
DEOGHAR VARTHUR HOBLI, BANGALORE EAST, HONNALI ROAD, SHIMOGA,KARNATAKA - PASS ROAD, AYATHIL.P.O KOLLAM DIST,
KARNATAKA- 560035. - 560035 577201 KERALA STATE PIN 691021 - 691021
84. PREMSONS (SGWN-SGW-01), PLOT NO 318/319 PH :8884000579. PH :989596666. PH :9848659456.
UNDER THANA NO 583,MAHESHMARA MOUJA 95. VARUN MOTORS (02NG-02-01), NO.23/A,
,DEOGHAR - 814112 KERALA TRIVANDRUM
INDUSTRIAL SUBURB, 2ND STAGE, TUMKUR
PH :9835507004. ROAD,YESHWANTPUR, BANGALORE, KOTTAYAM 117. INDUS MOTOR (16NB-16-01), OPPOSITE EVM
DHANBAD KARNATAKA- 560022. - 560022 ASHOK LEYLAND,ALUMOOD JN,NH
107. SAI SERVICE (B8NB-B8-01), SY. NO. 341/11,
PH :8971888885. 47,KANNIYAPURAM, TRIVANDRUM - 695301. -
85. RELIABLE (52NA-52-01), RELIABLE INDUSTRIES 341/12, PERUR VILLAGE, MC ROAD,
96. VARUN MOTORS (02NM-02-01), 37/56 695301
NEXA WORKSHOP AMAGHATA ,BY PASS ROAD THELLAKOM, KOTTAYAM - 686630
NAGAVARA VILLAGE,HEBBAL RING ROAD PH :9656685678.
SUGIADIH,PIN -828109 - 828109 PH :92880 24220.
PH :7992470853. ,BANGALORE - 560024
THRISUUR MADHYA PRADESH
PH :9513394753.
HAZARIBAGH 108. POPULAR VEHICLES (A4NB-A4-01), SURVEY NO BHOPAL
97. KALYANI MOTORS (02NN-02-01), 152/7, OUTER
86. PREMSONS (Y9NA-Y9-01), PREMSON MOTOR RING ROAD, DODDA BANASWADI, HORAMAVU, 62/P, CHUNGAM,OLLARI, KANJANI ROAD, 118. RAJRUP MOTOR JUNCTION (A UNIT OF RMJ
UDYOG PVT LTD ,NEXA SHOWROOM NEXT TO KR PURAM HOBALI, BANGALORE -560043. - ARANATTUKARA VILLAGE, THRISSUR - 680618 - MOTORS PVT LTD) (03NC-`03-01), 42, 6_BLOCK,
GST OFFICE,ARYA 560043 680618 BHEL INDUSTRIAL ESTATE, HABIBGANJ,
NAGAR,HURHURU,HAZARIBAGH,JHARKHAND HOSHANGABAD ROAD, BHOPAL (M.P.) - 462016
825301 - 825301
PH :9900020454. KERELA PH :7909903921.
98. BIMAL AUTO (02NL-02-01), NO.1, 3RD BLOCK,
PH :9835507004. 2ND STAGE, NAGARABHAVI, OUTER RING
ALLEPEY 119. OCEAN MOTORS (03ND-03ND-01), PLOT NO-54
JAMSHEDPUR ROAD, BANGALORE – 560072 - 560072 109. POPULAR VEHICLES (E5NB-E5-01), 12/287A, & 55, SECTOR-A, GOVINDPURA INDUSTRIAL
PH :9513843355. PARAVOOR, ALLEPPEY - 0 AREA, JK ROAD, BHOPAL - 462023
87. MOTOR WORLD (31NB-31-01), NS-6, 2ND
BELGAUM PH :9846161601. PH :7389936400.
PHASE, ADITYAPUR INDUSTRIAL AREA,
JAMSHEDPUR - 831013 CALICUT INDORE
99. SHANTESHA MOTORS (E8NA-E8-01), PLOT NO.
PH :9431128683. 6/B, R.S NO. 34, BOUXIDE ROAD, KANGRALI B 110. AM MOTORS (47NA-47-01), 18/1472, OPP TO 120. PATEL MOTORS (53NA-53-01), 1105/1528/5/2,
88. PEBCO MOTORS (31NA-31-01), KANDRA ROAD, K, BELGAUM, KARNATAKA-590010. - 590010 COMTRUST EYE HOSPITAL,SRAMBIKKAL MIN-1 AND 1105/1528/4/5, GRAM: KHAJRANA,
ADITYAPUR INDUSTRIAL AREA, JAMSHEDPUR - PH :9538195381. PARAMBA,MINI BYPASS JAIL ROAD DISTRICT: INDORE, KANADIA ROAD, INDORE
831013 DAVANGREE JUNCTION,PUTHIYARA POST,CALICUT, (M.P.) - 452016
PH :9334183260. KERELA-673004. - 673004 PH :7771002581.
100. SHRUTI MOTORS (S1NA-S1-01), AVARAGERE 121. OCEAN MOTORS (53NB-53-01), BICHOLI
RANCHI PH :7708833966.
ROAD, OLD, PB RD, DAVANAGERE, 111. MARDANA NEAR SAMPATH PALACE OPP
POPULAR VEHICLES (47NB-47-01), BYPASS
89. SUDHA MOTORS (51NB-51-01), KATHALMORE, KARNATAKA 577003 - 577003
SERVICE ROAD, BEHIND JAYA ARCADE, HOTEL PRIDE - 452001
OPP. MANER DHABA, RANCHI - 834005 HASSAN THONDAYADU, CALICUT, KERALA - 673017 PH :0731-4826666.
PH :7001124836,
101. VENKAT MOTOR (C8NA-C8-01), KHATA NO PH :9946104660. 122. RANA MOTORS (53ND-53-01), LASUDIA MORI,
8837221096.
200-201, DM HALLY, BANGALORE - COCHIN DEWAS NAKA, INDORE, PIN CODE 452010 -
90. PREMSONS (51NC-51-01), PLOT NO 2651/2652,
MANGALORE ROAD, HASSAN, KARNATAKA - 0 452010
KHATA NO 239, MAUJA, 112. INDUS MOTOR (27NC-27-01), NH PH :9933055539.
VILLAGE BARAGAI , BARIATU MAIN ROAD, HUBLI 47,THAIKATTUKARA PO,THAIKAVU, ALUVA, 123. RUKMANI (53NC-53-01), RUKMANI MOTORS
RANCHI, JHARKHAND - 834009 102. LEKHYA MOTORS (73NA-73-01), OPP TO APMC COCHIN - 683106 - 683106 NEXA SERVICE,FOOTHI OTHI
PH :9334811248. 2ND GATE, ESHWAR NAGAR, HUBLI-DHARWAD PH :9747508822. SQUARE,OPP.DASTOOR GARDEN,INDORE -
KARNATAKA ROAD, HUBLI-580025. - 580025 113. SAI SERVICE (27NA-27-01), 723/7,6,18,OPP TO 452002
PH :9513777265. HOTEL AARYAS, SEAPORT-AIRPORT, POOJARY PH :9755512100.
BANGALORE VALAVU, KANAYANNOOR TALUK,
MANGLORE JABALPUR
91. MANDOVI MOTORS (02NJ-02-01), SURVEY THIRRAKKARA NORTH, COCHIN-682021. -
NO.33/2,ALLALASANDRA, YELAHANKA NORTH, 103. MANDOVI MOTORS (45NA-45-01), SUMIT 682021 124. STANDARD MOTORS (54NC-54-01), KHARSA
BANGALORE, KARNATAKA - 560064 APARTMENT BUILDING, AIRPORT ROAD, MARY PH :9645106193. NO-529/1/1 ,NEAR TRIPURI CHOWK GARHA
PH :9513729888. HILL, MANGLORE - 574142 JABALPUR M. P - 482003
KASARGOD
PH :9845133077. PH :9773543358.

7
Nexa Workshop (AS ON 31.05.2023 )
125. SHUBH MOTORS (54NB-54-01), SHUBH 135. PAGARIYA AUTO (21NA-21-01), OPP AIRPORT, 145. SHIVAM AUTOZONE (05NE-05-01), PLOT NO. 1 & 157. JAGRUT MOTORS (G3NA-G3-01), 410/6/1B,
MOTORS, 4 MILE, LAL BUNGALOW, TILHARI, NEXT TO INDIAN OIL PETROL PUMP, JALNA 2, RAMCHANDRA LANE EXTN., KANCHPADA, SALVI STOP, SHIVAJI NAGAR MAIN ROAD
JABALPUR MADHYA PRADESH - 482001 ROAD, AURANGABAD, MAHARASHTRA - 431006 OFF LINK ROAD, MALAD-WEST. - 400064 RATNAGIRI, MAHARASHTRA - 415612
PH :9644454545. PH :8888859502. PH :9870938888. PH :9820039626.
126. STANDARD MOTORS (54NC-54-01), UKHARI BARAMATI NAGPUR SHOLAPUR
TIRAHA, OPPOSITE TO RAMESHWARAM
136. MAHALAXMI AUTO (7RNA-7R-01), BHIGWAN 146. BARBATE AUTO (20NA-20-01), 37/2, MANISH 158. CHAVAN MOTORS (B1NA-B1-01), SURVEY NO.
WATER TANK, MR-4 ROAD, VIJAY NAGAR,
ROAD, SHIV NAGAR, BARAMATI NAGAR, BESA T POINT, BESA ROAD NAGPUR 534/4, BALE PUNE ROAD, SOLAPUR,
JABALPUR ( M.P.) - 482001
(MAHARASHTRA) - 413102 440025 - 440025 MAHARASHTRA - 413224 - 413224
PH :7800806222.
PH :9850994014. PH :7923600147, PH :8888881314.
SAGAR 9727726004.
CHANDRAPUR THANE
127. ADINATH CARS (G1NA-G1-01), KHASRA NO 155, NANDED
137. BARBATE AUTO (H3NA-H3-01), PLOT NO 15-18, 159. EXCEL AUTOVISTA (39NA-39-01), MOHAN MILL
P H NO. -77, BAHERIA GADGAD,
OUT OF SURVEY NO 14/4, 15/5, MAUZA BADOLI, 147. SEVA AUTOMOBILES (68NA-68-01), AIRPORT COMPOUND, GHODBUNDER ROAD , THANE ,
SAGAR JABALPUR ROAD, SAGAR - 470004,
NAGPUR CHANDRAPUR HIGHWAY, ROAD,SANGVI - 431605 MAHARASTHRA - 400607
MADHYA PRADESH, INDIA - 470004
CHANDRAPUR, MAHARASHTRA - 440025 PH :7065026520. PH :9967331726.
PH :9752447690.
PH :8380887666. NASHIK 160. EXCEL AUTOVISTA (39NA-39-02), NEAR
SATNA ARIHANT COMPOUND, KALHER, BHIWANDI,
DHULE 148. SEVA AUTOMOBILES (37NA-37-01), PLOT B-17,
128. CITY CARS (D7NA-D7-01), BEHIND NEXA THANE - 400607
138. SEVA AUTOMOBILES (P3NA-P3-01), PLOT NO. MIDC, AMBAD, NASIK, MAHARASHTRA - 422010
SHOWROOM, 666/2, AMOUDHA, PANNA ROAD, PH :9967331726.
F-1, ADDITIONAL DHULE INDUSTRIAL AREA, PH :8975762303.
SATNA, MADHYA PRADESH - 485001 161. MY CAR PUNE- CODO (05NL-05-01), PLOT NO.
DHULE, MAHARASHTRA - 424006 NAVI MUMBAI
PH :6262230999. B-21 & B-24/1, THANE INDUSTRIAL AREA,
PH :9960090614.
SHAHDOL 149. AUTOMOTIVE MANUFACTURER LTD THANE, MAHARASHTRA - 400604
JALGAON (39NB-39-01), NERUL, MUMBAI PUNE HIGHWAY, PH :8104906953.
129. STANDARD MOTORS (SFAN-SAF-01), KHASRA
NO-459, VILLAGE JAMUI NEAR BAGHEL DHABA,
139. MANRAJ AUTO (C4NB-C4-01), P 93, MIDC, R L NAVI MUMBAI - 400706 YAVATMAL
CHOWK, AJANTA ROAD, JALGAON, PH :9769206120.
BUDHAR ROAD, SHAHDOL (M.P.) - 484001 162. HIMALAYA CARS (4MNA-4M-01), PLOT NO. 14,
MAHARASHTRA – 425003 - 425003 150. MY CAR (05NK-05-01), PLOT NO- GEN-25 &
PH :9329927451, 9329927458. MIDC, YAVATMAL INDUSTRIAL AREA,
PH :0253-6686666, GEN-25 B/1, TTC INDUSTRIAL AREA, PAWANE,
UJJAIN YAVATMAL - 445001
9130033951. NAVI MUMBAI, MAHARASHTRA (400709) -
PH :9011014729.
130. RUKMARANI (YUG) (3WNA-3W-01), 59/1, DEWAS KHARGHAR 400709
ROAD, ADARSH NAGAR, NAGZIRI, UJJAIN - PUNE NAGALAND
140. SIMRAN MOTORS (AACN-AAC-01), 60/72,
456664 DIMAPUR
JAWAHAR COOPERATIVE INDUSTRIAL ESTATE, 151. KOTHARI WHEELS (19NB-19-01), GATE NO 1605,
PH :9755512100.
KALAMBOLI, KHARGHAR, MUMBAI, OLD 1099, KESNAND ROAD, WAGHOLI, 163. PROGRESSIVE MOTORS (32NA-32-01),
MAHARASHTRA MAHARASHTRA. - 410209 TAL-HAVELI, DISTRICT - PUNE, MAHARASHTRA OPPOSITE AIRPORT, N.H.39, DIMAPUR KOHIMA
AHMEDNAGAR PH :022-71430900, - 412207 ROAD, DIMAPUR OPPOSITE AIRPORT, N.H.39,
9594952348. PH :7721865000. DIMAPUR KOHIMA ROAD, - 797115
131. KANKARIYA AUTOMOBILES (A5NA-A5-01),
KOLHAPUR 152. EXCEL AUTOVISTA (19NG-19-01), SURVEY NO PH :7669223736.
SH-60,NEWASA ROAD
98/2A/P, NEW PUNE - MUMBAI HIGHWAY, NEAR
,NAGARDEOLE,AHEMDANAGAR,MAHARASTRA - 141. SAI SERVICE (38NA-38-01), 1243/66, E WARD,
BALEWADI STADIUM, BANER TALUKA, PUNE -
ODISHA
414601 SHIVAJI UDHYAMNAGAR, KOLHAPUR - 416001 BERHAMPUR
411045
PH :9403961522. PH :9923208401.
PH :0257-2212145. 164. SKY AUTOMOBILES (E2NA-E2-01), PLOT NO
AKOLA MUMBAI 153. SEHGAL AUTO RIDERS (19NE-19-01), SURVEY 373/2229 & 373/1204, AMABAPUA MOUZA,
132. ASPA BANDSONS (F1NA-F1-01), SHIVANI 142. SAI SERVICE (05NB-`05-01), JOSEPH CARDIJN NO 63/2, SHEWALEWADI, MANJARI BUDRUK, BRAHMAPUR (ODISHA) - 760007
AIRPORT AREA, AKOLA - MAHARASHTRA TECHNICAL SCHOOL , KHASHABA JADHAV PUNE SOLAPUR HIGHWAY, PUNE, PH :7381266000.
(444001) - 444001 MARG , OFF DR. AMBEDKAR ROAD , DADAR MAHARASHTRA - 412307 BHUBANESWAR
PH :942312366. (EAST) MUMBAI, MAHARASHTRA. - 400014 PH :9158000049.
154. WONDER CARS (19ND-19-01), PLOT NO 52/1 165. NARAYANI MOTORS (04NC-04-01), PLOT NO
AMARAVATI PH :022-48767777.
BLOCK F2, MIDC PIMPRI, PUNE - 411019 140/2004, KHATA NO -1152/364, UNIT-20,
143. SHIVAM MOTORS (05ND-`05-01), PLOT NO
133. ASPA BANDSONS (F2NA-F2-01), F32/1 MIDC , PH :9850094151. JAGAMARA, KHANDGIRI, CHAWAK,
SILVER HOUSE, 110 MIDC, ROAD NO 13,
AURANGABAD NAGPUR EXPRESS HIGHWAY, 155. MAHALAXMI AUTO (19NI-19-01), NEAR BHUBANESHWAR - 751001
MAROL, ANDHERI (EAST), MUMBAI,
AMRAVATI, MAHARASHTRA - 444607 SADGURU PETROL PUMP, PUNE NASHIK PH :9583001877.
MAHARASHTRA. - 400069
PH :9130041513. HIGHWAY, AT KURALI, KHED TALUKA, CHAKAN JEYPORE
PH :02352-220084,
AURANGABAD 9689533472. - 410501 166. LEGEND CARS (SWNA-SW-01), NH26,
134. AUTOMOTIVE MANUFACTURER LTD 144. KTS AUTOMOTORS (05NH-05-01), UNIT NO A1, PH :9923589214. OPPOSITE HOTEL HELLO, INDUSTRIAL
(21NB-21-01), PLOT NO :- L- 3 / 1 , BETWEEN PANNALAL COMPOUND, LBS KANTILAL 156. SAI SERVICE (19NC-19-01), SINHAGAD ROAD, ESTATE, JEYPORE, ODISHA - 764001
GARWARE & WOCKHARDT LTD, JALGAON MAGANLAL ESTATE, L.B.S MARG, BHANDUP NEAR NANDED CITY, VADGAON KHURD, PUNE. PH :09692883057.
ROAD, MIDC CHIKALTHANA,AURANGABAD PIN : (W), MUMBAI - 400078 (MAHARASHTRA) - 411041
ROURKELA
- 431006, MAHARASHTRA - 431006 PH :020-30414000, PH :9923308333.
PH :9970499273. 9168656888. RATNAGIRI

8
Nexa Workshop (AS ON 31.05.2023 )
167. ORBIT MOTORS (87NA-87-01), PLOT NO 5G/3, PATHANKOT 188. AUDI MOTORS (65NA-65-01), 14 A, HEAVY 200. VISHNU CAR (14NG-14-02), POONAMALLE HIGH
VED VYAS, SUNDARGARH, ROURKELA - 769041 INDUSTRIAL AREA, ITI CIRCLE, SARASH DAIRY ROAD, ARUMBAKKAM, KOYAMBEDU, CHENNAI,
178. PATHANKOT VEHICLEADS (A7NA-A7-01), PLOT
PH :9165071234. ROAD, JODHPUR - 334001 TAMIL NADU. - 600056
NO.-C-30, INDUSTIAL GROWTH CENTRE, VILL.
SAMBHALPUR PH :7300077394. PH :7550333622.
CHACELI, PATHANKOT - 145023
189. LMJ AUTO (65NB-65-01), B-8, C-9,10, MIA, BASNI, 201. KHIVRAJ MOTORS (14NA-14-02), OLD S.NO. 11/1
168. ODYSSEY MOTORS (D4NA-D4-01), SAMBALPUR, PH :7527006800.
PHASE-1 & 2, NEW S.NO.11/2 - B, NO.100, NERKUNDRAM
CHOWK, REMED, ODISHA 768006 - 768006
PH :0832-2408800,
RAJASTHAN JODHPUR - 342009 VILLAGE, SAIDAPET TALUK, CHENNAI - 600107
AJMER PH :7412087320. PH :9962195957.
+91-9881746562.
190. LMJ SERVICES (65NB-65-02), PLOT NO.-61, COIMBATORE
PUNJAB 179. NAVNEET MOTORS (B2NA-B2-01), PLOT NO7 GERU MARKET, BHADWASIYA FRUIT MANDI,
202. AADHI CARS (41NB-41-01), OLD KALIAPPA
-8,RIICO INDUTRAIL ESTATE MAKHAPURA JODHPUR, RAJASTHAN - 342001
AMRITSAR NASIRBAD ROAD,AJMER(RAJASTHAN)-PIN KALYANAMANDAM, PREMISES,
PH :8094011126.
169. JAYCEE MOTORS (17NC-17-01), JAYCEE CODE-305002 - 305002 KAVUNDAMPALAYAM, COIMBATORE, TAMIL
KOTA NADU - 627007
MOTORS, VERKA BYE PASS, OUTSIDE PH :9414149149.
ASHBERRY HOMES, VILLAGE VALLAH, ALWAR 191. BHATIA & CO. (61NA-61-01), G-11A, PH :9003977577.
AMRITSAR, PUNJAB - 143501 AUTOMOBILE ZONE, IPIA, NEAR DAKANIYA 203. SREE SARADHAMBAL (41NA-41-01), 18/1472,
180. FORTUNE CAR (F9NA-F9-01), 6TH MILESTONE RAILWAY STATION, KOTA - 324005 S.N.R COLLEGE ROAD, NAVA INDIA,
PH :01815045400,
VILLAGE JATIYANA,OPP. PETROL BEHROR PH :8094011126. COIMBATORE, AND TAMILNADU-641004. -
7536966666.
ROAD ALWAR - 301001 641004
BHATINDA SIKAR
PH :9982341741. PH :9790004271.
170. TARA (70NA-70-01), KHASRA NO. 3534, NEAR ITI BHILWARA 192. JAMU (K7NA-K7-01), THAR PETROL
204. JAIKRISHNAA AUTOSALES PVT LTD
CHOWK, MANSA ROAD, BHATHINDA, PUNJAB - PUMP,JAIPUR ROAD,SIKAR - 332001
181. CHAMPION CARS (E3NA-E3-01), NEXA (41ND-41-01), NO. 656, TRICHY ROAD, NEAR
151001 PH :9414037515.
SUKHADIA CIRCLE, CHAMPION CARS, AJMER ORTHO ONE HOSPITAL, COIMBATORE, TAMIL
PH :8437019666. UDAIPUR NADU- 641012 - 641012
ROAD, BHILWARA - 311001
JALANDHAR PH :9001027933. 193. TECHNOY (49NB-49-01), OPP. NAND BHAWAN, PH :9788850734.
171. MARWAHA (35NC-35-01), KHASRA NO - 16450, BIKANER GOVERDHAN VILLAS , UDAIPUR - 313001 ERODE
SITUATED AT RAJA GARDEN, KAPURTHALA PH :0141 2984568.
182. AUDI MOTORS (71NA-71-01), PLOT NO. F-189, 205. SREE SARADHAMBAL (H7NA-H7-01), NO.75,
ROAD, JALANDHAR CITY. - 144003
SRI GANAGANAGAR ROAD, OPPOSITE TAMIL NADU NEAR SURABI NURSERY, PERUNDURAI ROAD,
PH :9814735707. ERODE, TAMILNADU-638011. - 638011
RAC-3RD , BICHHWAL INDUSTRIAL AREA , CHENGALPET
JALLANDHAR BIKANER 334001 - 334001 PH :9786022272.
194. AIE CARS (BBSN-BBS-01), NO. 1/7-A, GST
172. LOVELY AUTO (35NA-35-01), NH 1 GT ROAD, PH :9887222786. HOSUR
ROAD, CHENGALPET – 603001 - 603001
PRAGPUR, JALANDHAR PUNJAB - 144024 CHITTORGARH 206. SRI AMMAN CARS (7QNA-7Q-01), NEAR CATER
PH :74012 92949.
PH :7617571039, PILLAR WARE HOUSE, SEETHA
7617571040.
183. TECHNOY (K9NA-K9-01), PLOT NO-28, OLD CHENNAI
RIICO INDUSTRIAL AREA, CHITTORGARH, RAMNAGAR,NH-44,OPP TO ANAND
LUDHIANA 195. PILLAI & SONS (14NC-14-01), DOOR NO.46, ELECTRONICS, HOSUR, KRISHNAGIRI
RAJASTHAN - 312001
MEDAVAKKAM MAIN ROAD, KEELAKATTALAI, DISTRICT, TAMILNADU - 635109
173. GULZAR (62NE-62-01), PLOT NO 2662 NEAR PH :8905992939.
CHENNAI, TAMILNADU - 600117 PH :9841033464.
SILVER ARC MALL, AARTI CHOWK, LUDHIANA, JAIPUR PH :9994950505.
PUNJAB - 141003 KARAIKUDI
184. K P AUTOMOTIVES (11NB-11-01), PLOT 196. POPULAR VEHICLES (14NB-14-01), 69/A & 69/B,
PH :9814839777. 207. MEENAKSHI AUTOZONE (HXNA-HX-01), T S NO
NO.3-4,MANGLAM RIICO INDUSTRIAL SAMAYAPURAM MAIN ROAD, PORUR,
174. HOSHIARPUR AUTO (62NG-62-01), S-46/1616/1, 624/1, DOOR NO. 5, 1ST STREET,
AREA,NEAR KANAKPURA RAILWAY CHENNAI,TAMILNADU- 600116. - 600116
G.T. ROAD, DHOLEWAL CHOWK, LUDHIANA, SUBRAMANIAPURAM, KARAIKUDI, TAMIL NADU
STATION,SIRSI ROAD - 302034 PH :9842389111.
PUNJAB - 141003 - 630001
PH :7412059823. 197. KHIVRAJ MOTORS (14NA-14-01), PLOT NO.21,
PH :8872501234. PH :9940094881.
185. SATNAM MOTORS (11ND-11-01), D-27, K/L/M, AMBIT IT PARK ROAD, AMBATTUR INDUSTRIAL
175. MARWAHA AUTOS (A UNIT OF INDERJIT
ROAD NO-3,SIKAR ROAD, VISHWAKARMA ESTATE, CHENNAI-600058. - 600058 MADURAI
MARWAHA AUTOS PVT LTD) (62NH-62-01), OPP.
INDUSTRIAL AREA ,JAIPUR, PH :9626099999.
MEDIWAYS HOSPITAL, FEROZPUR ROAD, 208. ASIR (42NA-42-01), 176, MAIN ROAD,
RAJASTHAN-302023. - 302023 198. VISHNU CAR (14NG-14-01), SURVEY NO 219,
LUDHIANA - 141015 KAMARAJAR ROAD, MADURAI, TAMIL NADU –
PH :9649373311. ADJOINING HP PETROL PUMP, POONAMALLE
PH :8872000357. 625001 - 625001
186. PREM (11NC-11-01), PLOT NO- 12,13,14, HIGH ROAD, KATTUPAKKAM, CHENNAI, TAMIL
176. LOVELY AUTO (62NF-62-01), 287/1, MOTI PH :99440 59911.
SUDARSHANPURA INDUSTRIAL AREA, NEAR 22 NDU - 600056
NAGAR, SHERPUR BYPASS, GT ROAD,
PH :7339359111. NAGERCOIL
GODAM, JAIPUR - 302016
LUDHIANA - 141010
PH :8058998123. 199. ABT (14NJ-14-01), NO123, KANNIGAPURAM, 209. ATHEN CARS (S5NA-S5-01), NO. G. 3/9, NO.
PH :9875999161.
JHUNJHUNU VELACHERY MAIN ROAD, BEHIND RACE 1197, NELSON COMPOUND, KP ROAD,
MOHALI COURSE, GUINDY, CHENNAI, TAMIL NADU - PARVATHIPURAM, NAGERCOIL, TAMILNADU -
187. AUDI MOTORS (FNNA-FN-01), NEAR TVS TWO 600032 629003
177. CM AUTO SALES (L1NA-L1-01), C-155,
WHEERLER SHOWROOM ROAD NO 3 GUDHA PH :9994444303. PH :9751196436.
INDUSTRIAL AREA, PHASE-7, MOHALI - 160055
MOD, RAJASTHAN 333001 - 333001
PH :9888034555, PONDICHERRY
PH :7970006402.
9780011459.
JODHPUR

9
Nexa Workshop (AS ON 31.05.2023 )
210. SHENBAKA CARS (96NA-96-01), RS NO 50/5A, 220. GEM MOTORS (10NH-10-01), D.NO.8-96, 231. VARUN MOTORS (1HNA-1H-01), 1-51/4/1/D4 242. SHAKUMBARI (6DNA-6D-01), 4TH KM.
PONDICHERRY CUDDLORE MAIN ROAD SURVEY NO.128/2 & 129, TYAGARAYANANAGAR MADAHAVA NAGAR,HYDERABAD MILESTONE, BIJNOR - NAJIBABAD RD, NEAR
,KIRUMAMBAKKAM, BAHOOR COLONY, KOTHAPET, HYDERABAD, ROAD,NIZAMABAD,TELANGANA,503230 - 503230 DPS SCHOOL, BIJNOR, UTTAR PRADESH
COMMUNE,PONDICHERY - 607402 TELANGANA. - 500084 PH :9542222486. 246701 - 246701
PH :7338322220. PH :9912345899. SECUNDERABAD FIROZABAD
SALEM 221. JAYABHERI AUTO (10ND-10-01), HNO 2-40/64,
232. MITHRA AGENCIES (10NK-10-01), USHA MAYURI 243. DEV MOTOR (DFNA-DF-01), DHOLPURA, NEAR
SURVEY NO 23 TO 28, JUBILEE GARDENS,
211. THRIVENI CARS (A2NA-A2-01), 2/6, THEATER, OPP TO SPENCERS MARKET, ST. JOHNS CHAURAHA, AGRA ROAD,
KOTHAGUDA, HYDERABAD,
KANDHAMPATTY,BYE PASS ROAD, SALEM, MUSHEERABAD, SECUNDERABAD, FIROZABAD - 283203
TELANGANA-500032. - 500032
TAMILNADU - 636005 ANDRAPRADESH-500020. - 500020 PH :9045031800.
PH :9849103917,
PH :9786022272. PH :98850 01155. GHAZIABAD
9437061030.
212. SM CAR (A2NB-A2-01), S NO 131/1A,BYPASS 233. AUTO FIN (K6NB-K6-01), PLOT NO.6, SURVEY
222. VARUN MOTORS (10NB-10-02), H.NO. 244. ROHAN MOTORS (59NA-59-01), KHASRA NO 46 ,
ROAD, NEAR INDIAN OIL ASSOCIATION, NO.267/1 & 267/2, BOWENPALLY, BALANAGAR
8-2-120/117/A/2. PLOT NO. 83,83A,83B, ROAD DELHI MEERUT ROAD MEERUT ROAD
PETROL BUNK, KONDALAMPATTY, SALEM - MAIN ROAD, SECUNDERABAD, TELANGANA -
NO. 2, BESIDES SBI BANK, BANJARA HILLS, INDUSTRIAL AREA, MORTA, GHAZIABAD,
636010 500011
HYDERABAD - TELANGANA - 500033 UTTAR PRADESH 245101 - 245101
PH :7094440010. PH :8886144551.
PH :9885610555. PH :8178839830.
THANJAVUR 234. VARUN MOTORS (K6NC-K6-01), VARUN
223. SAI SERVICE (10NC-10-01), SURVEY NO 78, 245. MSM (JJ IMPEX) (5982-59-N1), PLOT NO C, J J
MOTORS,2ND CROSS
213. PILLAI & SONS (E7NA-E7-01), SURVEY NO 237/1, ADJACENT TO HP PETROL PUMP, IMPEX (DELHI) LIMITED, 224, SITE-1,
ROAD,SAINIKPURI,SECUNDERABAD - 500094
NEELAGIRI THAKUR THOTTAM, VALLAM ROAD, GOPANAPALLY, GACHIBOWLI, HYDERABAD INDUSTRIAL AREA, BULANDSHAHR ROAD
PH :779960094.
THANJAVUR, TAMIL NADU - 613403 -500046. - 500046 INDUSTRIAL AREA, GHAZIABAD, UTTAR
PH :9443264165. PH :9966377888. WARANGAL PRADESH 201003 - 201003
TIRUNEVELI 224. RKS (10NI-10-01), SY NO:42, PET 235. ADARSHA AUTOMOTIVE (D5NA-D5-01), H.NO: PH :9990033015.
BASHEERABAD, QUTHBULLAPUR, MEDCHAL 23-6-132, HUNTER ROAD, OPP TO CITIZENS GORAKHPUR
214. AADHI CARS (A3NA-A3-01), PLOT NO.50-55, MANDAL, HYDERABAD - 500014 CLUB, WARANGAL, TELANGANA - 506007
ASHOK NAGAR, C-COLONY, TAKKALPURAM, PH :9542234567. 246. SMART WHEELS (72NA-72-01), ARAZI NO. 623,
PH :8978944414.
TRIVANDRUM ROAD, C1 KOKKARAKULAM - 225. ADARSHA AUTOMOTIVE (10NG-10-01), PLOT NO 624 & 625, GULHARIA BAZAR, MEDICAL
627007 6/P, 54, SURVEY NO. 204, PRAGATI NAGAR, UTTAR PRADESH COLLEGE ROAD, GORAKHPUR, UTTAR
PH :7373091461. BALANAGAR, KUKATPALLY, HYDERABAD - AGRA PRADESH - 273009
TRICHY 500072 PH :8222002147.
236. MADHUSUDAN MOTORS (66NA-66-01),
PH :9154854949 247. ARBIT AUTO (72NB-72-01), PLOT NO - A & B,
215. PLA MOTORS (23NA-23-01), TS NO.29P,31P & ADJOINING HEMA PETROL PUMP, EIT MANDI,
8897972200. BUDDH VIHAR YOJNA, PART-B, TARAMANDAL
32P,36P, NEW WARD "E", NEW BLOCK NO.27, BODLA, AGRA - 282007
226. ADARSHA AUTOMOTIVE, SHAMSHABAD ROAD, GORAKHPUR - 273009
ANNA NAGAR, TRICHY, TAMILNADU - 620017. - PH :6386901181,
(10NG-`10-02), SHAMSHABAD, NH44, PH :8429526255.
620017 6386901188.
PH :8110099991. HYDERABAD, TELANGANA – 501218 - 501218 237. PREM MOTORS (66NB-66-01), KHASRA NO.-655, GREATER NOIDA
PH :8297116633. VILL ARTONI, DELHI-AGRA HIGHWAY, AGRA - 248. MSM (JJ IMPEX) (T283-T2-N1), MARUTI SERVICE
TRIPUR
KARIMNAGAR 282007 MASTERS, NEXA SERVICE, PLOT NO 02,
216. SHASHTI (Y7NA-Y7-01), 16A-1,SHREE PADMINI
227. ADARSHA AUTOMOTIVE (N6NA-N6-01), 8-6-301, PH :9690010839. ECOTECH 12, GREATER NOIDA, GAUTAM
GARDENS, KANGAYAM RD, TIRUPPUR, TAMIL
BY PASS ROAD, AUTO NAGAR, KARIMNAGAR, 238. KTL PVT LTD (66NC-66-01), KHASRA NO - 246/1, BUDDHA NAGAR, UTTAR PRADESH - 201009
NADU - 641604
TELANGANA - 505001 249/1, 251 , KUBERPUR, AGRA. - 282006 PH :9711474930.
PH :9942903310.
PH :9847073265. PH :8449710014. HARDOI
VELLORE ALIGARH
KHAMMAM 249. CONCEPT (QENA-QE-01), PLOT NO. 1609 &
217. SRI GANESH CARS (C6NA-C6-01), 96/6,
228. PARAMSHIVA MOTORS (1GNA-1G-01), SY NO. 239. CLML (B6NA-B6-01), PLOT NO. 5/129, GT ROAD, 1605, GUNGABUX PURVA, BILGRAM RD,
CHENNAI-BANGALORE HIGHWAY, NH-46,
507,VELUGUMATLA, VILLAGE, KHAMMAM, RAM NAGAR COLONY, SARSOL, ALIGARH, HARDOI, UTTAR PRADESH - 241001
PERUMUGAI,VELLORE, TAMILNADU - 632009
TELANGAN - 507318 UTTAR PRADESH. - 202002 PH :7607696666.
PH :9884722126.
PH :9848988312. PH :9639775522. JHANSI
TELANGANA MAHBUBNAGAR
240. CLML (B6NA-B6-02), VILL KARSUA,
250. SURI (60NA-60-01), SHIVPURI - JHANSI ROAD,
HYDERABAD PALWAL-DELHI ROAD, ALIGARH PIN 202140 -
229. JAYARAMMA AUTO (WPNA-WP-01), OPPOSITE HANSRAJ MODERN SCHOOL,
202140
218. KALYANI MOTORS (10NE-10-01), SURVEY CHRISTIANPALLY, BHOOTPOOR ROAD, JHANSI, UTTAR PRADESH - 284003
PH :9358373099.
NO.184, KARMAGHAT VILLAGE, BESIDE MAHBUBNAGAR, TELANGANA - 509001 PH :7705000558.
BARIELY
KHARMANGHAT HANUMAN TEMPLE, R.R PH :8096990074. KANPUR
DISTRICT, HYDERABAD, TELANGANA - 500079 241. CORAL (56NA-56-01), DELHI RAMPUR ROAD, IN
MANCHERIAL 251. KTL PVT LTD (28NB-28-01), ARAZI NO. 352,
PH :9347121212. FRONT OF MINI BYPASS, CB GANJ, BARIELLY,
230. ADARSHA AUTO (CMNA-CM-01), SURVEY SINGHPUR KACHHAR, BITHOOR ROAD,
219. VARUN MOTORS (10NB-10-01), B-54, UP - 243001
NO-417,BELLAMPALLI MANCHERIAL ROAD NORTHERN RAILYWAY COLONY, KANPUR,
CO.INDUTRIAL ESTATE, BALANAGAR, PH :9359101010.
,MANCHERIAL,TELANGANA - 504208 UTTAR PRADESH. - 208017
HYDERABAD, TELENGANA - 500037 BIJNORE PH :7408409312.
PH :8886631496, PH :9133329709.
8886631499. NIZAMABAD LUCKNOW

10
Nexa Workshop (AS ON 31.05.2023 )
252. ANAND MOTORS (13NC-13-01), GATA NO. 1062 271. BHANDARI AUTOMOBILES (G7NA-G7-01),
PARGANA RAJA BIJLI PASI VILLAGE
UTTARAKHAND CHOWRANGEE, PLOT NO-138 & 139, O T ROAD,
AURANGABAD, SHAHEED PATH (OPPOSITE TO DEHRADUN KHARAGPUR - 721301
RAMABAI AMBEDKAR MAIDAN), LUCKNOW, 263. SHAKUMBARI (57ND-57-01), KHASRA NO. PH :7603076061.
UTTAR PRADESH - 226012 -15-ANA, MOHABBEWALA, SAHARANPUR KOLKATA
PH :7705807552, ROAD, DEHRADUN-248001 - 248001
272. JYOTE MOTORS (06ND-06-01), MIRANIA ROAD,
9838480480. PH :7895058449.
ARUPOTA ON BASANTI HIGHWAY, - 700105
253. KTL AUTOMOBILE PVT LTD (13ND-13-01), PLOT HALDWANI PH :9074158220.
NO - 513, VILL HARIHARPUR BIJNAUR, OPP
264. NAINITAL MOTORS (J6NA-J6-01), 5TH KM 273. MACHINOTECHNO (06NG-06-01), 98/A/2 BT
ANSAL API, AMAR SHAHEED PATH, LUCKNOW -
RAMPUR ROAD, JEETPUR NEGI, NEAR AMAR ROAD,P.S - BARANAGAR, P.O. - ISI BT ROAD,
227105
UJALA PRINTING PRESS, HALDWANI, KOLKATA, WEST BENGAL – 700090. - 712250
PH :7311190503.
UTTARAKHAND - 263139 PH :6292283744.
254. BRIGHT4WHEELS (13NB-13-01), PLOT NO - D10,
SAROJINI NAGAR INDUSTRIAL AREA, PH :7467800077, SREERAMPORE
LUCKNOW. PIN - 226008 - 226008 7467800050.
274. STARBURST (BBTN-BBT-01), NEAR ALLAHABAD
PH :9151004111. ROORKEE BANK, MOLLARBER, SERAMPORE. - 700090
MATHURA 265. SHAKUMBARI (H2NA-H2-01), 5 KM MILESTONE PH :9830081672.
255. UMA MOTORS (H8NA-H8-01), PLOT NO 222, ,NH-58,ROORKEE-DELHI ROAD ,NEAR HOTEL
MAHOLI, NEAR KIRAN HOSPITAL, MATHURA - GODWARI,ROORKEE, UTTARAKHAND - 247667
281004 PH :9634092690,
PH :9997385999. 7500860007.
MEERUT RUDRAPUR
256. TR SAWHNEY (48NB-48-01), 1183/17 RITHANI, 266. AKANKSHA AUTOMOBILES (RUDRAPUR) PVT.
ZONE - A, SECTOR 4 NEAR PETROL PUMP, LTD. (U4NB-U4-01), KASHIPUR ROAD,
MEERUT, UTTAR PRADESH - 250103 OPPOSITE GREEN PARK COLONY, VILLAGE
PH :18002704142. DIBDIBA, TEHSIL BILASPUR, RAMPUR,
UTTRAKHAND - 244901
NOIDA
PH :01912465542,
257. FAIR DEAL (A1ND-A1-`01), A-107, SECTOR-5. 9797770257.
NOIDA - 201301
PH :9810542222. WEST BENGAL
258. MOTOR CRAFT (59NB-59-01), C 42 SECTOR 57, ASANSOL
NOIDA, UTTAR PRADESH - 201301 267. BEEKAY AUTO (F6NA-F6-01), NH-2 ,CHANDA
PH :7230029429, MORE ,POST KALI PAHARDI, JAMMURIA
7230000000. DISTRICT WEST BARDHAMAN - 713339
RAIBARIELY PH :9932049425.
259. KTL AUTOMOBILE PVT LTD (HSNA-HS-01), 1481, COCHBEHAR
NEAR KATHWARA BUS STAND, LUCKNOW 268. SEVOKE MOTORS PVT. LTD. (BWZN-BWZ-01),
RAIBARELI HIGHWAY, HARCHANDPUR, NEXA COOCH BEHAR CENTRAL VILL & P.O. -
RAIBARELI - 229303 MAHISHBATHAN P.S. - KOTWALI, NH - 31
PH :7311190503. COOCHBEHAR,W.B. -734617 - 734617
SAHIBABAD PH :8016095268.
260. MSM (JJ IMPEX) (M983-M9-N1), MARUTI HOWRAH
SERVICE MASTERS, NEXA SERVICE, PLOT 269. MACHINOTECHNO (X7NA-X7-01), 109, 1, UPPER
NUMBER 58/4, SITE 4, SAHIBABAD INDUSTRIAL FORESHORE RD, CHOURA BUSTEE, SHIBPUR,
AREA, - 201010 HOWRAH, WEST BENGAL 711102 - 711102
PH :9711474930. PH :9830081632.
SHAHJHANPUR JALPAIGURI
261. SUMITRA DS (W2NA-W2-01), SH25 , RETI ROAD 270. PODDAR AUTO (XYNA-XY-01), ASSAM MORE
SHAHJAHANPUR - 242001 BUS STOP, SH12A, JALPAIGURI, WEST BENGAL
PH :9936095228. 735102 - 735102
VARANASI PH :8945533002.
262. AGR (84NA-84-01), ARAZI NO - 285,286 KHARAGPUR
LUCCHERPUR, PARGANA-ATHGAWA TEHSIL,
HARHUA , VARANASI - 221105
PH :9305646425.

11
Dealer Workshop (AS ON 31.05.2023 )

ARAKU CUDDAPAH 29. SANTOSH MOTORS (SHB1-SHB-1), SY NO. 569/1


ANDAMAN AND NICOBAR ISLANDS BESIDES NH5, VELURU VILLAGE, BAPULAPADU
DIGLIPUR 10. VARUN MOTORS (SJG1-SJG-01), SURVEY NO 19. MSA MOTORS (C201-1D-03), K.T. BYE PASS
MANDAL, HANUMAN JUNCTION
33-9/A, RAVULAGADDA VILLAGE,BESIDE GOVT ROAD,CUDDPPAH,ANDHRA PRADESH, - 516001
1. AGENCY HOUSE (A & N ISLANDS) PVT. LTD. KRISHNA DISTRICT PIN 521105 - 521115
DEGGRE PH :7396685628.
(PU01-PU-01), MADHUPUR VILLAGE,TEHSIL PH :9703633755.
COLLEGE,ARAKU,VISHAKAPATNAM,ANDHRAPR ELURU
DIGLIPUR,NORTH ANDAMAN - 744202
ADESH - 531151 HINDUPUR
PH :271056. 20. REDDY & REDDY MOTORS (1E01-1E-01), OLD
PH :7799499931. 30. SRI DURGA AUTOMOBILES PVT. LTD.
PORTBLAIR NH-5 ROAD,BESIDES C R REDDY WOMEN'S
BHIMAVARAM (1B01-36-02), PLOT NO.83, NEAR RELIANCE
COLLEFE OLD NH-5,ELURU, - 534001
2. AGENCY HOUSE (A & N ISLANDS) PVT. LTD. PETROL BUNK, BYE PASS ROAD, HINDUPUR -
11. NOVELTY REDDY & REDDY MOTORS PVT LTD PH :9705311566.
(E102-E1-01), GARACHRAMA, PORT BLAIR - 515201
(7M01-7M-01), NEAR BYEPASS ROAD,UNDI GAJAPATINAGARAM
744105 PH :9849773030.
ROAD,BHIMAVARAM - 534202
PH :251980, 253586, 211590.
PH :7799771177.
21. JAYABHERI AUTOMOTIVES (SNN1-SNN-01), ICHAPURAM
3. AGENCY HOUSE (A & N ISLANDS) PVT. LTD. SURVEY NO 50-14, D.NO 3-1/C, BONDAPALLI
BOBBILI 31. JAYABHERI AUTOMOTIVES PVT. LTD.
(E102-E1-02), NAYAGEN, PORTBLAIR - 744101 MANADALAM, GAJAPATHINAGARAM, ANDHRA
(GLL1-GLL-01), SURVEY NO. 105/3 , 105/4 AND
PH :227104, 211682. 12. VARUN MOTORS PVT. LTD. (CAM1-CAM-01), D. PRADESH. - 535270
229/7, ICHAPURAM, BALAKRISHNAPURAM
RANGAT NO. 4-64, SURVEY NO. 219/8, VILLAGE – PH :9100818111.
PANCHAYAT,MUNIBHADRA VILLAGE,ANDHRA
MALLAMMAPETA, BESIDE GROWTH CENTRE, GAMBHEERAM
4. AGENCY HOUSE (A & N ISLANDS) PVT. LTD. PRADESH. - 532312
BOBBILI, DISTRICT – VIZIANAGARAM, ANDHRA
(E102-FJ-03), NIMBUTULLA, PO RANGAT, DIST. 22. JAYABHERI AUTOMOTIVES PVT. LTD. PH :9394006666, 8142933666.
PRADESH. - 535558
MIDDLE ANDMAN, - 744201
PH :9885280772.
(BQQ1-GJF-02), PLOT NO. 40-45 & 48, GREEN JAGGAIAHPETA
PH :211546. INDUSTRIAL PARK, GAMBHERAM,
CHALLAPALLI 32. VARUN MOTORS PVT. LTD. (2603-PC-05), DOOR
ANANDPURAM, VISHAKAPATNAM. - 530052
ANDHRA PRADESH 13. MITHRA AUTO AGENCIES PVT LTD PH :9642496789.
NO. 2-20, MUTHYALAMMA GUDI STREET
AMALAPURAM JAGGAIAHPET TOWN, JAGGAIAHPET, KRISHNA
(CSX1-CSX-01), D.NO.9-30, 9TH BLOCK, GUDIVADA DISTT. - 521175
5. S.B. MOTOR CORPORATION (BTS1-BTS-01), LAKSHMIPURAM LIMITS, RAMANAGARAM,
23. VARUN MOTORS PVT. LTD. (2603-CL-02), D NO. PH :9642437099.
#241/2B, BESIDE: BAPUJI PRIMARY SCHOOL CHALLAPALLI MANDALAM, DISTT. KRISHNA -
521126
1-621,AUTONAGER 1ST LANE,GUDIVADA - JANGAREDDYGUDEM
MAIN ROAD, OPP. RR NAGAR, BANDARULANKA,
521301
AMALAPURAM, EAST GODAVARI (DIST) - 533201 PH :8886063526. 33. REDDY & REDDY MOTORS (1E01-HQ-02), NEAR
PH :9885651383.
PH :8374303303. CHILKALURIPET R&B GUEST HOUSE,ELURU
GUDUR ROAD,JANGAREDDYGUDEM, - 534447
AMARAVATI 14. JAYALAKSHI (SFT1-SFT-01), M/S JAYALAKSHMI
24. BHARGAVI AUTO PVT. LTD. (IS01-IS-01), PH :9912563666.
6. JAYALAKSHMI AUTOMOTIVES PVT. LTD AUTO, SURVEY NO 457/C3, CHILKALURIPET,
NADENLA MANDAL, GUNTUR, ANDHRA
SURVEY NO.1619/3A,GUDUR BYPASS, GUDUR KAIKALURU
(CVB1-CVB-01), SURVEY NO. 29, TOWNSHIP-16,
RURAL, GUDUR DISTT. NELLORE, A.P. - 524101
SECTOR-137, COLONY-539, BLOCK-2029, PLOT PRADESH - 522616 34. SANTOSH AUTOMOTORS PVT. LTD.
PH :9652984999.
NO. 1, SUB-DIVISION-L40, MALKAPURAM PH :9989144344. (CLW1-CLW-01), SY. NO. 127/7 &9, OPP. NAIDU
LIMITS, MANDAL - THULLURU, CHINTALAPUDI GUNTAKAL COMPLEX, AATAPAKA, KAIKALURU MANDAL,
AMARAVATI-CITY, DIST.-GUNTUR, ANDHRA 25. SRI DURGA AUTOMOBILES PVT. LTD. DIST. KRISHNA - 521333
15. REDDY AND REDDY MOTORS (BYQ1-BYQ-01),
PRADESH. - 522237 (BJA1-BJA-01), SURVEY NO. 407, D. NO. PH :7799787969.
RS NO.698/2 MARUTI NAGAR COURT CENTRE,
PH :8374847777.
ELURU-CHINTALAPUDI HIGHWAY,
20/342-19, BELLARY ROAD, GUNTAKAL, DIST. KAKINADA
ANAKAPALLE -ANANTPUR, ANDHRA PRADESH. - 515801
CHINTALAPUDI MANDAL, ANDHRA PRADESH - 35. S B MOTORS (W701-W7-01), D. NO.
PH :8142847353.
7. JAYABHERI AUTOMOTIVES PVT. LTD. 534460 52-10-36/3,NEAR AMAR GHATI CENTER,KARAPA
(0N01-0N-01), SURVEY NO.822/1 & 2, NH-5 PH :9912341624, 9948827555. GUNTUR ROAD, KAKINADA - 533001
ROAD, ANAKAPALLE, DISTT. CHIRALA 26. JAYALAKSHMI AUTOMOTIVES PVT. LTD PH :9885119888.
VISHAKHAPATNAM. - 531001
16. JAYALAKSHMI AUTOMOTIVES PVT. LTD
(G502-G5-01), D-N-8-24-31,MANGALAGIRI KANCHIKACHERLA
PH :7093575555. ROAD,GUNTUR - 522001
(G502-NT-04), 9-1-92, CHURCH ROAD,CHIRALA, - 36. VARUN MOTORS PVT. LTD. (GJD1-GJD-01),
ANANTAPUR PH :7893117111/0863-2241000.
523157 SURVEY NO. 510/5, DOOR NO. 13-144, 146, 13TH
27. JAYALAKSHMI (G502-G5-05), AT 1-14-114, OPP.
8. SRI DURGA AUTOMOBILES PVT. LTD. PH :7331151661. WARD, KANCHIKACHERLA VILLAGE AND
HINDU COLLEGE, BANDLAMUDI GARDENS,
(1B01-1B-01), 17/377-A,GOOTY CHITTOOR MANDAL, KRISHNA DIST., ANDHRA PRADESH. -
AMARAVATI ROAD, GUNTUR-522003, AP -
ROAD,,ANANTAPUR - 515001 521180
17. BHARGAVI AUTO PVT. LTD. (A801-1C-03), 522203
PH :9100984249. PH :9703906444.
22-241/A,KATTAMANCHI TIRUPATI PH :9848131133/9625255555.
ANNAVARAM ROAD,CHITTOOR, - 517001 28. JAYALAKSHMI AUTO (G502-G5-06), SURVEY NO KANDUKURU
9. VARUN MOTORS (SJH1-SJH-01), DO-NO : 5/116, PH :8463955558. 509, D.NO 25-11-50 TOWN, WARD NO 22, 37. JAYALAKSHMI AUTOMOTIVES PVT. LTD
SURVEY NO – 59.,CHALAMAYYA NAGAR, CHODAVARAM OPPOSITE ITC BUILDING, R AGRAHARAM, (BEY1-BEY-01), SURVEY NO. 414,
RAILWAY STATION ROAD, NEAR SMP BAJAJ NAGARAPALAM ROAD,GUNTUR, - 522004 MAHADEVAPURAM VILLAGE, O. V. ROAD,
18. VARUN MOTORS (SHT1-SH-01), SURVEY.NO:
SHOWROOM, PH :8374847777. KANDUKURU MANDAL, DISTRICT –
108-2-A, 108-3-A & 108-4, GOVCHODAVARAM,
ANNAVARAM, EAST GODAVARI DISTRICT, HANUMAN JUNCTION PRAKASHAM, ANDHRA PRADESH. - 523105
DIST. VISAKHAPATNAM, - 531036
ANDHRA PRADESH. - 533406 PH :9848131133.
PH :#REF!.
PH :9885511911.

12
Dealer Workshop (AS ON 31.05.2023 )

KANIGIRI 47. JAYALAKSHMI AUTOMOTIVES PVT. LTD 56. BHARGAVI AUTO PVT. LTD. (A801-A8-04), A2, 65. JAYALAKSHMI AUTOMOTIVES PVT. LTD
(CFF1-CFF-01), D. NO. 4-515/12, SURVEY NO. INDUSTRIAL ESTATE,A.K. NAGAR,NELLORE, - (BFN1-BFN-01), SURVEY NO. 897/16,
38. JAYALAKSHMI AUTOMOTIVES PVT. LTD
1167, OPP. INDUSTRIAL ESTATE, ONGOLE 524004 PIDUGURALLA, DISTRICT – GUNTUR, ANDHRA
(SCC1-SCC-01), SURVEY NO 793, PLOT NO
ROAD, MARKAPURAM, DISRT.-PRAKASAM, PH :9248727888. PRADESH. - 522413
11,12 , KANIGIRI, PRAKASHAM DISTRICT,
ANDHRA PRADESH. - 523316 57. VISHNU CARS PVT. LTD. (A802-A8-01), FIELD PH :9848131133, 9100787058.
ANDHRA PRADESH - 523230
PH :9848131133, 7331151674. NO. 628 /SURVEY NO. 877, 878/A/4 AND PITHAPURAM
PH :9848131133, 9052457512.
MYLAVARAM 883/A/1A, NELLORE BIT-II, BESIDES GSR
KAVALI 66. S B MOTORS (CTS1-CTS-01), NO. 11-2-114, 11TH
GARDENS, BALAJI NAGAR, NH-16, NELLORE
48. VARUN MOTORS PVT. LTD. (GKL1-GKL-01), D WARD, KAKINADA-KATHIPUDI ROAD,
39. BHARGAVI AUTO PVT. LTD. (A801-PF-05), CITY. - 542002
NO. 2-176/2, MAIN ROAD, MYLAVARAM, PITHAPURAM, EAST GODAVRI DIST., ANDHRA
KAVALI NELLORE,ANDHRA PRADESH - 524201 PH :7337340778.
KRISHNA DISTRICT, PIN-521230, ANDHRA PRADESH. - 533 450
PH :9248702567.
PRADESH - 521230 NUZIVIDU PH :8886677759, 8886677754.
KURNOOL PH :9581337222. 58. VARUN MOTORS PVT. LTD. (2603-CN-03), RS PONNUR
40. MSA MOTORS (C201-C2-01), AUTO NAKKAPALLI NO:880/2,MUNCIPAL,D NO:25-12,WRD
67. JAYALAKSHMI AUTOMOTIVES PVT. LTD
NAGAR,INDUSTRIAL ESTATE, NH-7, KURNOOL NO:25,BLOCK NO:25,BESIDE
49. VARUN MOTORS (SFR1-SFR-01), SURVEY NO (CFC1-CFC-01), PLOT NO. 4, D.NO. 213-1,
- 518004 S SQUIRE CONVENTION HANUMAN JUNCTION
202/3, 203/4,PEDGUMMULURU GRAM VAISHNAVI NAGAR, PONNUR, GUNTUR,
PH :9959513945. ROAD, NIZVID , ANDHRA PRADESH. - 521201
PANCHAYAT, ANDHRA PRADESH. - 522124
MACHERLA PH :9581337222.
RAYAVARAM PH :9849445639, 9121141913.
MANDAL,NAKKAPALLI,VISHAKAPATNAM, ONGOLE
41. JAYALAKSHMI AUTOMOTIVES PVT. LTD RAJAHMUNDRY
(CEY1-CEY-01), D.NO. 343/7, 343/5-3, 15-2-3, ANDHRA PRADESH - 531081 59. JAYALAKSHMI AUTOMOTIVES PVT. LTD
68. S.B. MOTOR CORPORATION (C501-C5-01),
MACHERLA, MACHERLA MUNICIPALITY. - PH :9885317344. (8Y01-8Y-02), THROVAGUNTA COMPANY
OPP.FCI
522426 NANDIGAMA CENTRE,NH-5,GUNTUR
GOWDOWN,JAILROAD,LALACHERUVLI,RAJAMU
PH :9848131133, 9705261801. ROAD,ONGOLE,PRAKASAM DISTRICT. - 523003
50. VARUN MOTORS PVT. LTD. (CUB1-CUB1-01), RE NDRY - 533101
MACHILIPATNAM PH :9701055955.
SURVEY NO. 601/1B, NH-9 ROAD, NANDIGAMA, PH :08885585667.
DIST.-KRISHNA, ANDHRA PRADESH. - 521185 PALAKONDA 69. S B MOTORS (C501-C5-03), D. NO. 3-243, NH-5,
42. MITHRA AUTO AGENCIES PVT LTD (2604-0K-04),
NARASIMHA NAGAR, MACHLIPATNAM, ANDHRA PH :9642225287. 60. VARUN MOTORS PVT. LTD. (CKO1-CKO-01), ROAD, HUKUMPETA, RAJAHMUNDRY. - 533 107
PRADESH - 521001 NANDYAL SURVEY NO. 8, ANAVARAM GRAMAM, PH :08885886262.
PH :8886063526. PALAKONDA, SRIKAKULAM DISTRICT, ANDHRA 70. VARUN MOTORS PVT. LTD. (C502-C5-01),
51. MSA MOTORS (CKB1-CKB-01), SURVEY NO. 333,
MADANAPALLI PRADESH. - 532440 SURVEY NO. 660, PALACHERLA VILLAGE OF
VUDUMALPURAM, MANDAL – NANDYAL, OPP.
PH :9966877033, 9885317344. RANJANAGRAM MANDAL, RAJAHMUNDRY,
43. BHARGAVI AUTO PVT. LTD. (AAT1-AAT-01), AUTO NAGAR, NANDYAL, DISTRICT –
PALASA EAST GODAVARI DSIT. - 533102
SURVEY NO.762, BASIKONDA VILLAGE, KURNOOL. - 518501
PH :8886616717.
MADANPALLI, CHITTOOR DISTT. ANDHRA PH :7337292822. 61. JAYABHERI AUTOMOTIVES PVT. LTD.
(BWH1-BWH-01), SURVEY NO. 63 OF VILLAGE – RAJAM
PRADESH - 524101 NARASARAOPET
PH :9959893434. PURUSHOTTAPURAM, PALASA MANDAL, 71. VARUN MOTORS PVT. LTD. (BLJ1-BLJ-01), PLOT
52. JAYALAKSHMI AUTOMOTIVES PVT. LTD
MADHURAWADA KASIBUGGA MUNICIPALITY, DISTRICT – NO. 44, SARATHI NAGAR, RAJAMNAGAR
(G502-JT-03), NEAR RELIANCE PETROL PUMP
SRIKAKULAM, ANDHRA PRADESH. - 532221 PANCHAYAT, RAJAM, DISTRICT - SRIKAKULAM,
44. JAYABHERI AUTOMOTIVES PVT. LTD. BUNK,VINUKONDA ROAD, NARASAROAPET,
PH :9849054442, 8790946464. ANDHRA PRADESH - 532127
(BQQ1-BQQ-01), PLOT NO. 5, SURVEY NO. 4/P, GUNTUR, - 522603
PATHAPATNAM PH :7799666998.
KOMMADI ROAD, MADHURAWADA, PH :7680000502/9100791343.
62. VARUN MOTORS (CODE UNDER RAMPACHODAVARAM
VISHAKAPATNAM, ANDHRA PRADESH - 530048 NARSAPURAM
PH :8886669985. CREATIONS-CODE UNDER CREATIONS-CODE 72. VARUN MOTORS (SOK1-SOK-01), SURVEY NO
53. NOVELTY REDDY & REDDY (SIU1-SIU-01), SY
MALKIPIURAM UNDER CREATIONS), D.NO 4-245,SURVEY NO 14/1,IRLAPALLY VILLAGE,
NO. 98/7, NARSAPURAM– CHINCHINDA BYPASS
264/1A, PATHAPATNAM, SRIKAKULAM, ANDHRA RAMPACHODAVARAM,ANDHRA PRADESH -
45. VARUN MOTORS (SEH1-SEH1-01), SURVEY NO ROAD,NARSAPURAM, PALAKOLLU MANDAL,
PRADESH - 532213 533288
49/6A, MALKIPURAM VILLAGE AND MANDAL, WEST GODAVARI DISTRIC
PH :9885317344. PH :9885511911.
EAST GODAVARI DISTRICT, ANDHRA PRADESH T,ANDHRA PRADESH - 534206
PH :9703900011. PENDURTHI REPALLE
- 533250
PH :9154255226. NARSIPATNAM 63. VARUN MOTORS PVT. LTD. (BAP1-BAP-01), 73. JAYALAKSHMI (SKA1-SKA-01), D.NO 430,
MANDAPETA SURVEY NO.107/1B, VELAMPETA, ANAKAPALLI BESIDE ESAR PETROL BUNK, REPALLE,
54. JAYABHERI AUTOMOTIVES PVT. LTD.
TO PENDURTHI HIGHWAY, NEAR BRIDGE, DISTRICT: GUNTUR, ANDHRA PRADESH -
46. S B MOTOR CORPORATION (BJC1-BJC-01), (WT01-WT-01), OPP. RDO BUNGLAW, BANK
PENDURTHI DISTT: VISAKAPATNAM - 530047 522265
BLOCK NO. 4, D. NO. 4-1-64, MANDAPETA, COLONY, VISAKHAPATNAM ROAD,
PH :9160445699. PH :8374847777.
DISTRICT – EAST GOADAVARI, ANDHRA NARSIPATNAM - 531116
64. VARUN MOTORS PVT LTD (BAP1-BAP-02), S KOTA
PRADESH . - 533308 PH :7702333513.
SURVEY NO 240/1,2 & 241, PENDURTHI, VIZAG -
PH :8886664090. NELLORE 531173
MARKHAPURAM 55. BHARGAVI AUTO PVT. LTD. (A801-A8-01), PH :9642403366.
D.NO.25/II/97 INDUSTRIAL ESTATE, A.K. NAGAR, PIDUGURALLA
P.B.NO.18, NELLORE(A.P.) - 524004
PH :9248742225.

13
Dealer Workshop (AS ON 31.05.2023 )
74. JAYABHERI (SIV1-SIV-01), SURVEY NO 83. BHARGAVI AUTO PVT. LTD. (A801-N9-02), 94. VARUN MOTORS PVT. LTD. (2603-26-07), DOOR 105. VARUN MOTORS PVT. LTD. (4603-46-1B),
113/3,MALLIPUDI MADHURA 11/66/1,TIRUPATI RENIGUNTA ROAD,TIRUPATI, NO. 1-4-208 AND 1-4-208(1), IN R.S. NO. 33/3A, SURVEY NO. 2/A, SECTOR XI, MVP COLONY,
VENKATARAMANAPETA, - 517507 BHAVANIPURAM, VIJAYAWADA, MUNICIPAL VISHAKAPATNAM. - 530 017
SRUNGAVARAPUKOTA, VIZIANAGARAM, PH :7997969946. CORPORATION, VIJAYAWADA, ANDHRA PH :07901644535.
ANDHRA PRADESH - 535145 84. BHARGAVI AUTO PVT. LTD. (A801-N9-06), PRADESH. - 520012 VISSANNAPETA
PH :9100818111. SURVEY NO. 2/B3, ADJACENT TO PARK HOTEL, PH :8297241177.
106. VARUN MOTORS (SNO1-SNO-01), RS NO.
SOMPETA RENIGUNTA ROAD, TIRUPATI. - 517501 95. SANTOSH AUTOMOTORS PVT. LTD
434/10, WARD NO. 10, VISSANNAPETA,
PH :7997969919. (2607-26-02), D NO. 77-42-16A, OPP, NUNNA
75. VARUN MOTORS PVT LTD (GLX1-GLX-01), KRISHNA DISTRICT, ANDHRA PRADESH -
85. VISHNU CARS (N902-N9-01), SURVEY NO. FIRE STATION, PRAKASH NAGAR, INNER RING
KHATA NO 406,407,408 DENOTED IN SURVEY 521215
192/3A2A, 200’ CHENNAI – TIRUPATI HIGHWAY, ROAD, VIJAYAWADA - 520 015
NO 241/1,MOGILIKOTURU VILLAGE, SOMPETA, PH :9581337222.
KOTRAMANGALAM,RENIGUNTA MANDAL, PH :7799787932.
SRIKAKULAM, ANDHRA PRADESH - 532284 VIZAG
TIRUPATI - 517520 VISHAKAPATNAM
PH :8142331166.
PH :9154971551. 107. VARUN MOTORS (4603-46-10), SURVEY NO
SRIKAKULAM 96. VARUN MOTORS PVT. LTD. (4603-46-0E), PLOT
TIRUVURU NO 88,BESIDES POLICE
228/224, WARD NO 19, AGNAMPUDI,VIZAG -
76. VARUN MOTORS PVT. LTD. (4603-W6-09), 533053
86. SANTOSH AUTOMOTORS PVT. LTD. STATION,SRINAGAR,GAJUWAKA - 530026
NH-16, BESIDE EENADU UNIT OFFICE, PEDDA PH :9885438455.
(CIM1-CIM-01), D NO. 23-1/5, OPP. AYYAPA PH :9703843737.
PADDU-VILL,ARASAVILLI (P.O.),SRIKAKULAM, - VIZIANAGARAM
SWAMY TEMPLE, MAIN ROAD, TIRUVURU. - 97. VARUN MOTORS PVT. LTD. (4603-46-08), DOOR
532001
521235 NO. 58/2,BLOCK NO. 5,BALAJI NAGAR, OPP. 108. VARUN MOTORS PVT. LTD. (4603-N8-0C),
PH :9703119797.
PH :7799787969. ANDHRA UNIVERSITY, SIRIPURAM - 580003 OPPOSITE SUN SCHOOL, 100 FEET RING
77. JAYABHERI AUTOMOTIVE (4606-W6-04),
TUNI PH :7799124243. ROAD, VIZIANAGARAM, VIZIANAGARAM -
SURVEY NO 22/7P,22/8 AND SURVEY NO
98. VARUN MOTORS PVT. LTD. (4603-46-0F), D-25, 535001
29/12,16,17, BALAGA RURAL,SRIKAKULAM CITY, 87. SATTIBABU MOTORS (PVT) LTD. (KY01-KY-01),
INDUSTRIAL ESTATE, MARRIPALLEM, BESIDES PH :8886721213.
DISTRICT: SRIKAKULAM - 532001 D. NO. 65-31-15/1, OPP. FCI GODOWNS,
COLA MANCHU KONDA GARDENS, 109. JAYABHERI AUTOMOTIVES PVT. LTD.
PH :9100818111. NARAYANAPURAM, TUNI, EAST GODAVARI,
VISAKHAPATNAM., - 530007 (N801-N8-01), PLOT NO.B-1,DOOR
SULURUPETA ANDHRA PRADESH - 533401
PH :9581444477. NO.8-32-1,SURVEY NO.108/12A & 109/2A,
PH :7661893888.
78. BHARGAVI AUTO PVT. LTD. (BZA1-BZA-01), 99. JAYABHERI AUTOMOTIVES PVT. LTD. INDUSTRIAL ESTATE, VANTITHADI
KEERTI ENCLAVE,NEAR RTO VENKATAGIRIKOTA (4606-46-01), PLOT NO. A-9, INDUSTRIAL AGRAHARAM VILLAGE, VIZIANAGARAM,
OFFICE,NH-5,SULLURPETA - 524121 88. BHARGAVI AUTO PVT. LTD. (CDI1-CDI-01), M/S ESTATE, VISHAKAPATANAM, ANDHRA ANDHRA PRADESH - 535001
PH :9848602345, 7997998516. BHARGAVI AUTOMOBILES, BESIDE INDIAL OIL PRADESH - 530018 PH :7702333514.
TADA BUNK,GMR FUNTION PH :8886332209. YANAM
HALL,DARASALLA,PALLIKUPPAM,KUPPAM 100. JAYABHERI AUTOMOTIVES PVT. LTD.
79. VISHNU CARS PVT.LTD. (SFW1-SFW-01), (4606-46-02), D.NO:51-17-2 , NH-5, 110. SB MOTORS (CTR1-CTR-01), SURVEY NO
ROAD,V KOTA - 517242
SURVEY NO 58/3,TADA, NELLORE DISTRICT - KRANTHINAGAR, VISAKHAPATNAM,(ANDHRA 82-2,TALLAREVU MANDAL,YANAM, EAST
PH :9848602345, 7799997720.
524401 PRADESH). - 530013 GODAVARI DISTRICT - 533463
PH :7995088868. VENKATAPGIRI PH :8886677759.
PH :7799772272.
TANUKU 89. BHARGAVI AUTOMOBILES (SOL1-SOL-01), 101. VARUN MOTORS PVT. LTD. (4607-46-01), S. NO. YELAMANCHILI
SURVEY NO 166,169/1,169/2,RTC 8, KAPPARADA VILLAGE, BESIDE IOCL PETROL
80. NOVELTY REDDY & REDDY MOTORS PVT LTD 111. JAYABHERI AUTOMOTIVES PVT. LTD.
COLONY,VENKATAGIRI, NELLORE, ANDHRA BUNK, MANCHUKONDA GARDENS, MURALI
(BAR2-BAR-01), NH-5 ROAD, NEAR WOMEN’S (GJR1-GJR-01), SURVEY NO. 19-1, 2, 3, 45/1,
PRADESH - 524132 NAGAR, NATIONAL HIGHWAY,
COLLEGE, BESIDE IOC PETROL PUMP, 45/2&3, KOKIRAPALLI, YELAMANCHILI,
PH :9248747777. VISHAKAPATNAM. - 530007
TANUKU, DISTT: WEST GODAVARI(ANDHRA NARSIPATNAM, VIZAG DIST., ANDHRA
PRADESH) - 534211 VIJAYAWADA PH :7799124243. PRADESH. - 531055
PH :9912341624. 90. MITHRA AUTO AGENCIES PVT LTD (2604-26-01), 102. JAYABHERI AUTOMOTIVES PVT. LTD. PH :9849445639, 9642502345.
40-17-3,,PICHAIAH STREET,GANDHI (4606-46-03), SURVEY NO. 119/6,
TENALI YELESWARAM
COLONY,VIJAYAWADA - 520001 KURMANNAPALEM, GAJUWAKA MANDAL,
81. JAYALAKSHMI AUTOMOTIVES PVT. LTD VIZAG, ANDHRA PRADESH. - 530046 112. VARUN MOTORS (CODE UNDER
PH :8886063507.
(PE01-PE-01), KAVI RAJA NAGAR, GUNTUR PH :8897541234. CREATIONS-CODE UNDER CREATIONS-CODE
91. VARUN MOTORS PVT. LTD. (2603-26-01),
ROAD, TENALI, GUNTUR DISTT. - 522002 103. VARUN MOTORS PVT. LTD. (4603-46-0K), UNDER CREATIONS), VARUN MOTORS
48-17-4/1,RING ROAD,VIJAYAWADA - 520008
PH :226100/ 9866111788. SURVEY NO. 394 & 395, PLOT NO. 7 AT VILLAGE P.LTD,DO-NO – 2-4-41,BESIDE GOLLAJI GARU
PH :9885576602.
THAGARAPUVALASA – DUPPITURU, MANDAL – ACHUTAPURAM, BUNK,YERRAVARAM ROAD,YELESWARAM –
92. VARUN MOTORS PVT. LTD. (2603-26-06),
DISTRICT – VISHAKAPATNAM, ANDHRA 533429 - 533429
82. VARUN MOTORS PVT. LTD. (CQV1-CQV-01), SURVEY NO.561/1, 562/5 & 561/3, 562/6
PRADESH. - 531011 PH :9885511911.
SURVEY NO.11/2B,11/3,NAGARAMPALEM KESARAPALLY,VIJAYAWADA, KRISHNA
VILLAGE, NH-16, NAGARAMPALEM GRAMA DISTRICT, A.P. - 521102 PH :9966877133. ARUNACHAL PRADESH
PH :9581480099. 104. VARUN MOTORS PVT. LTD. (4603-46-0L),
PANCHAYAT LIMITS, THAGARAPUVALASA, BHALUKPONG
93. SANTOSH AUTOMOTORS PVT. LTD. SURVEY NO. 408/1 OF MADHURAWADA
BHEEMUNIPATNAM MANDAL,
(2607-26-01), SURVEY NO. 223/5, D. NO. 11-61/2, VILLAGE, RUSHIKONDA ITI SEZ, 113. DY MOTORS (YT01-YT-01), NEAR SBI UPPER
VISHAKAPATNAM, - 531162
KANURU PANCHAYAT, PENAMALURU MANDAL, VISHAKAPATNAM RURAL MANDAL, MARKET, BHALUKPONG, WEST KAMENG ,
PH :9885317344, 9885280772.
VIJAYAWADA, KRISHNA DISTRICT, ANDHRA VISHAKAPATNAM DISTRICT, ANDHRA ARUNACHAL PRADESH - 790114
TIRUPATI PRADESH. - 530045 PH :8415075164.
PRADESH. - 520010
PH :7799787459/7799787918. PH :9885315344.

14
Dealer Workshop (AS ON 31.05.2023 )

ITANAGAR 124. RAMLAL DURGADUTT MOTORS PVT LTD GOALPARA HOJAI


(BXI1-BXI-01), DAG NO- 7,8,9 PERIODIC PATTA
114. BUISHI YADA MOTORS (7501-75-01), A' 134. BHARATI MOTORS PVT. LTD. (YN01-YN-01), PO: 146. RAMLAL DURGADUTT MOTORS PVT LTD
NO - 24, REVENUE VILLAGE, BRAHMAPUTRA
SECTOR, NAHARLAGUN, ARUNACHAL KALYANPUR, VILLAGE: SOLMARI, P/S: AGIA, (ARA1-ARA-01), KHATIYAN NO.: 312/3F, HOJAI
CHAPORI, MOUZA - BAGHMORA - 784176
PRADESH. - 791110 NH: 37, DISTRICT: GOALPARA, ASSAM - 781301 MAIN ROAD, NEAR UCO BANK,
PH :8724087940.
PH :9436268870. PH :9101940372. SHANKARDEVNAGAR, HOJAI, DISTRICT –
115. BUISHI YADA MOTORS (7501-75-04), MODEL BONGAIGAON NAGAON , ASSAM - 782435
GOLAGHAT
VILLAGE, BEFORE GOVERNMENT HIGHER 125. BHARATI MOTORS PVT. LTD. (7N01-7N-01), PH :7002680534.
135. RAMLAL DURGADUTT MOTORS PVT LTD
SECONDARY SCHOOL, NAHARLAGUN, CHAPAGURI ROAD, BONGAIGAON - 7833830 HOWLY
(J303-J3-01), DAG NO. - 718, 684 & 706, PATTA
ITANAGAR - 791110 PH :7002350887/9864427537.
NO 213, 168 & 192, KURUKA GAON, P.O - 147. PODDAR CARWORLD (GKW1-GKW-01), PATTA
PH :8257075033. CHAMATA MORANGI, P.S -GOLAGHAT, DIST: GOLAGHAT, NO. 601, DAG NO. 1567, HOWLI TOWN, MOUZA
116. D Y MOTORS (7502-75-01), LPC NO -
126. PALLAVI MOTORS PVT LTD (CEI1-CEI-01), DAG ASSAM PIN-785702 - 785702 GHILAJARI, DISTT BARBETA, ASSAM - 781316
DC/ICC/LPC, BORUM VILLAGE, PO/PS-
NO.1137, PATTA NO.376, MOUZA – PH :7002099547. PH :8085957586.
NAHARLAGUN, PAPUM PARE DIST,
DAHRAMAPUR, CHAMATA DISTT. NALBARI, GORAIMARI HOWRAGHAT
ARUNACHAL PRADESH - 791100
ASSAM - 781306
PH :8415075164. 136. BAJRANG CAR WORLD (A UNIT OF MAA 148. BAJRANG CARWORLD (SGR1-SGR-01),
PH :9864052488.
PASSIGHAT VAISHNAVI AUTOMOTIVE PVT. LTD.) HOWRAGHAT TOWN, KARBI ANGLONG, ASSAM
DHEKIAJULI (GMB1-GMB-01), DAG NO- 3, KP PATTA NO - 11, - 782481 - 782481
117. BUISHI YADA MOTORS (7501-8A-03),
127. RAMLAL DURGADUTT MOTORS PVT LTD VILLAGE- CHALABASTI, MOUZA- GORAIMARI - PH :9864191169.
PASSIGHAT BAZAR, PASSIGHAT, ARUNACHAL
(BRX1-BRX-01), DAG NO.242, K.P. PATTA NO.88, 783390 JAGI ROAD
PRADESH - 791102
VILLAGE-BHAKUAMARI, MOUZA-BORCHOLA, PH :7002279100.
PH :9402878414. 149. RAMLAL DURGADUTT MOTORS PVT LTD
BESIDES-NH15, DHEKIAJULI, DISTT. SONITPUR, GUWAHATI
RUKSIN ASSAM. - 784110
(7J01-RB-02),
137. BIMAL AUTO AGENCY (0901-09-01), JAGIROAD,MORIGAON,NALAOW,ASSAM -
118. DY MOTORS (SHZ1-SHZ-01), RUKSIN IN EAST PH :9706568722.
JHALUKBARI, GUWAHATI. - 781014 782410
SIANG DISTRICT, ARUNACHAL PRADESH - DHEMAJI PH :9864074525. PH :9365884355.
787060
128. SAIKIA AUTO PVT. LTD. (7P01-UD-02), 138. PALLAVI MOTORS PVT LTD (0902-09-01), DAG JORHAT
PH :8415075164.
NALANIPAM KONCH GAON,NH-52,DHEMAJI NO. 1&2,NEXT TO DEPTT. OF FAMILY
ZIRO (ASSAM) - 787057 WELFARE,SIX MILE. KHANAPARA G.S. ROAD,
150. RAMLAL DURGADUTT MOTORS PVT LTD
(G902-G9-01), DAG NO. 7 & 8 OF P.P NO. 33,
119. BUISHI YADA MOTORS (CHM1-CHM-01), PH :8638725209. GUWAHATI - 781022
DAG O. 9 OF P.P NO. 61, DAG NO. 382 OF P.P
HAPOLI, NEAR TELECOMMUNICATION CENTRE, DIBRUGARH PH :9864210937.
NO. 206, VILLAGE - PAKIMURI HABIGAON,
ZIRO, ARUNACHAL PRADESH. - 791120 139. PODDAR CAR WORLD PVT LTD (0904-09-01),
129. JAYBEE AUTO AGENCIES PVT. LTD. MOUZA - SARAIBAHAL, JORHAT. - 785006
PH :9732010858. HENGRABARI ,VIP ROAD,GUWAHATI - 781036
(C101-C1-01), CHIRING CHAPARI, T.R. PHUKAN PH :7002099547.
PH :9508746340.
ASSAM ROAD, P.O. DIBRUGARH (ASSAM) - 786001
140. BIMAL AUTO AGENCY (0903-09-01), KALGACHIA
BAIHATA CHARIALI PH :9954799273.
CHANDMARI, BAMUNI MAIDAN, OPP SBI NEW 151. MITTAL AUTO (SLB1-SLB-01), VILL -
130. BIMAL AUTO AGENCY (C102-C1-01), DAG NO.
120. PALLAVI MOTORS PVT LTD (BNL1-BNL-01), DAG GUWAHATI BRANCH, GUWAHATI - 781021 KALGACHIA, PO - KALGACHIA , DIST BARPETA -
104, GHARBANDICHUK JARUA GAON, MOUZA -
NO. 1042, PATTA NO. 17, MOUZA – PH :9864489722. 781319
MANKHATTA KANIKAR, DIST.-DIBRUGARH,
BORBANKHAR, P.S. – BAIHATA CHARIALI, 141. BIMAL AUTO AGENCY (0901-09-02), PH :8638487401.
ASSAM. - 786004
DISTRICT – KAMRUP, ASSAM - 781381 BEHARBARI,BEHIND DHOOM RESTAURANT, KARIMGANJ
PH :9864074525, 7003901301.
PH :9864052488. NH-37,GUWAHATI - 781028
DIGBOI PH :9864040406. 152. JAIN UDYOG (6901-1S-04), STEAMER GHAT
BARAMA ROAD, KARIMGANJ, ASSAM - 788710
131. VISHAL CAR WORLD PVT LTD (BYD1-BYD-01), 142. PODDAR CAR WORLD (0905-09-01), NH-37,
121. MITTAL AUTOZONE (SOX1-SOX-01), VILLAGE - NEAR, GORCHUK CHAIRALI, GUWAHATI PH :9435179025.
BORBIL NO. 1, NEAR LIONS CLUB, NH-38, P.O. –
BARJAR, PO & PS - BARAMA, ASSAM -781346 - (ASSAM). - 781029 KHATKHATI
DIGBOI, DISTRICT – TINSUKIA , ASSAM. -
781346 PH :7002929414.
786171 153. PODDAR CAR WORLD PVT. LTD.
PH :8638487401. 143. BIMAL AUTO AGENCY (0903-09-03), BESIDE NRL
PH :9435860000.. (CAZ1-CAZ-01), NEAR TELEPHONE EXCHANGE,
BARPETA DIPHU PETROL PUMP, RGB ROAD, ZOO ROAD, NH-39, KHATKHATI, DISTRICT – KARBI
122. BHARATI MOTORS PVT. LTD. (7N01-7Z-02), GUWAHATI, ASSAM - 781005 ANGLONG . - 782460
132. RAMLAL DURGADUTT MOTORS PVT LTD PH :7578005159.
SIMULGURI,NH-31,DISTRICT-BARPETA, ASSAM PH :6000900381.
(1P01-1P-01), MANJA ROAD, DILLAJI, DIPHU, 144. MITTAL AUTOZONE (0908-09-01), NH-37,
- 781313 LANKA
KARBI ANGLONG, ASSAM - - 782460 BELTOLA, NEAR HANUMAN KANTA, GUWAHATI
PH :7002819523.
PH :9707556868. - 781028 154. RAMLAL DURGADUTT MOTORS PVT LTD
BIJOYNAGAR DULIAJAN (SDD1-SDD-01), DAG NO 95 OF PP NO 59, DAG
PH :9864296666.
123. PODDAR CAR WORLD (IA01-IA-01), AT/PO - 145. PALLAVI MOTORS PVT LTD (0902-09-02), DAG NO 96 OF PP NO 26 & DAG NO 418 OF PP NO 73
133. JAYBEE AUTO AGENCIES PVT. LTD.
BIJOYNAGAR, INDIAN OIL PETROL PUMP, NO. 2201, PATTA NO. 237, VILLAGE – KISAM LAKHIMPUR , MOUZA - LANKA, DIST -
(ADA1-ADA-01), JAYBEE AUTO AGENCIES,
KAMRUP DIST.,BIJOYNAGAR - 781125 JYOTIKUCHI, MOUZA – BELTOLA, AK AZAD HOJAI , ASSAM. - 782442
TIPLING TINIALI, DULIAJAN DIST. DIBRUGARH -
PH :9864209733. ROAD, GUWAHATI, DISTRICT – KAMRUP, PH :9707556868.
786602
BISWANATH CHAIRALI PH :7002722358. ASSAM. - 781034 MANGALDOI
PH :9864052488.

15
Dealer Workshop (AS ON 31.05.2023 )
155. PODDAR CAR WORLD (YW01-YW-01), PUNIA, 165. PODDAR CAR WORLD PVT. LTD (CLD1-CLD-01), 175. SEEMANCHAL MOTORS PVT. LTD. 184. RAM KRISHNA MOTORS PVT. LTD.
NH-52, MANGALDOI, DISTT. DARRANG - 784115 DAG NO. 451, PATTA NO. 151 KMP, PATHSALA, (O701-O7-01), NEAR BUS STAND, JAGDISH RICE (CWA1-CWA-01), OJHA TOLA, NEW BYPASS,
PH :9706970132. DIST.-BARPETA, ASSAM. - 781325 MILL COMPOUND, HOSPITAL ROAD, CHAKIA-845412, PURVI CHAMPARAN DISTT.,
MARGHERITA PH :6000900256. FORBESGANJ, DISTT. ARRARIA, BIHAR - 854318 BIHAR - 845412
RAJGARH PH :8797096013. PH :9801773716.
156. VISHAL CAR WORLD PVT LTD (YR01-YR-01),
MARGERITA TOWN, BEHIND IOCL PETROL 166. JAYBEE AUTO AGENCIES PVT. LTD. ARRAH CHAPRA
PUMP, NH-38, MARGHERITA, ASSAM - 786181 (CIJ1-CIJ-01), DAG NO.182, PP NO.140 OF 2 NO. 176. PEARL CARS (VU01-VU-01), (A UNIT OF 185. REESHAV AUTOMOBILES (MG01-TH-02), 146,
PH :9435860000. BHAGATIA GAON, LAT NO.11, RAJGARH, VINDHYAVASINI AUTOMOBILES PVT. LTD.), PLOT NO. 381, VILLAGE RAUJA, CHAPRA
MORIGAON MOUZA-TINKHONG, DISTT. DIBRUGARH, DHANUPRA, NEAR GANPAT CHOUDHARY PATNA ROAD, NEAR BHIKHARI CHOWK,
ASSAM - 786611 DWAR, NH-30, ARRAH (BIHAR) - 802301 CHAPRA, BIHAR - 841301
157. RAMLAL DURGADUTT MOTORS PVT LTD
PH :9954799273. PH :8294634604. PH :7061295296.
(RB01-RB-01), DAG NO. 423 OF PP NO. 221,
KISSAM BACHNAGHAT, MORIGAON, ASSAM. - RANGIA AURANGABAD DANAPUR
782105 167. PODDAR CAR WORLD PVT. LTD. (6X01-6X-01), 177. KARLO AUTOMOBILES (SNG1-SNG-01), KARLO 186. ALANKAR AUTO SALES & SERVICE PVT LTD
PH :7002239592. RANGIA TOWN, WARD NO. 5, SHANTIPUR, AUTOMOBILES PVT LTD, GT ROAD, NEAR, (1504-NN-02), ADJASCENT ARYA SAMAJ
NAGAON BHUTAN ROAD, NEAR POLYCLINIC HOSPITAL, RAIPURA MORE, BABHANDI, AURANGABAD - MANDIR, NEAR SAGUNA MORE, DANAPUR, -
RANGIA DISTT. KAMRUP (ASSAM) - 781354 824101 800018
158. RAMLAL DURGADUTT MOTORS PVT LTD
PH :8724877892. PH :7019085212. PH :9386898458.
(7J01-7J-01), KHUTIKHATIA, HAIBARGON,
NAGAON - 782002 SHIBSAGAR BANKA DANAPUR, PATNA
PH :9706007918. 168. RAMLAL DURGADUTT MOTORS PVT LTD 178. SEEMANCHAL MOTORS PVT. LTD. 187. ALANKAR AUTO SALES & SERVICE PVT LTD
159. BAJRANG CAR WORLD (A UNIT OF MAA (G902-L9-02), RANGHAR CHARIALI, DHAPROTA, (CEQ1-CEQ-01), KHATA NO. 134, KHESRA NO. (1504-NN-05), TOUZI NO. 5057, THANA NO. 35,
VAISHNAVI AUTOMOTIVE PVT. LTD.) AT ROAD, OPPOSITE RANGHAR, SHIVASAGAR - 118, BEHIND MARUTI SHOWROOM, STATION MOUZA - BABAKKARPUR, DANAPUR, PATNA. -
(7J03-7J-01), DAG NO. 255, 1508(N)/254(O), 785640 ROAD, BANKA, BIHAR. - 813101 801503
1509(N)/257(O) AND 291, PATTA NO. PH :7002099547. PH :8797096020. PH :9334415434.
506(N)/15(O), 507(N)/15(O), 507(N)/97(O) AND 98, SILCHAR BEGUSARAI DARBHANGA
VILLAGE - DEODHAR, MOUZA - PAKHIMORIA,
169. JAIN UDYOG (6901-J2-02), KAUSHAL COMPLEX, 179. GS MOTORS PVT. LTD. (1U01-1U-01), HARHAR 188. RAJKRISHNA MOTORS LLP (1V02-1V-01),
DIST.-NAGAON. - 782002
SONAI ROAD, SILCHAR, ASSAM - 788006 MAHADEV CHOWK, NH 31, BEGUSARAI, BIHAR - KHATA NO.61936, RAUSHAN CHOWK,
PH :9435060474/9864191169.
PH :9706002524. 851101 BAJITPUR, B.M.P.-13, ROAD, DARBHANGA,
160. RAMLAL DURGADUTT MOTORS PVT LTD
SORBHOG PH :9204756206. BIHAR - 846009
(7J01-7J-03), PAKHIMURIA, NEAR BHUGDOI
BETTIAH PH :7004529271.
DHABA, NAGAON, ASSAM - 782003 170. MITTAL AUTOZONE (SGS1-SGS-01), VILLAGE
189. RAJKRISHNA MOTORS LLP (1V02-1V-02), VIP
PH :9706007918. DAHALAPARA, KISMAT DWARIKA, PS 180. SHREE GOPAL AUTO PVT. LTD. (O401-O4-01),
ROAD, ALLALPATTI, DARBHANGA (BIHAR) -
NAHARKATIYA SORBHOG, SUB DIVISION- BARPETA- ASSAM. - BEETIAH - MOTIHARI HIGHWAY , NH-28 B,
846003
781317 NEAR MACHALI LOK, BEETIAH (BIHAR). - 845438
161. JAYBEE AUTO AGENCIES PVT. LTD. PH :9693127351.
PH :8011042222. PH :9771486183.
(C101-CJI-03), NAHARKATIYA TOWN PART NO. DEHRI ON SONE
4, MOUZA – JAYPORE, NEAR ST. MARY’S TANGLA BHAGALPUR
190. PEARL CARS (1X01-MK-02), MOUZA - KHASRA,
SCHOOL, DISTRICT – DIBRUGARH, ASSAM . - 171. BIMAL AUTO AGENCY (CHO1-CHO-01), DAG 181. SEEMANCHAL MOTORS PVT. LTD.
KHATA NO. 141, PLOT NO. 186, SAAT KATDA
786610 NO.:121, PATTA NO.101/320, VILLAGE (G802-G8-01), BAUSI ROAD, ALIGANJ, NEAR
THANA - DEHRI-ONE-SONE, DIST.-ROHTAS,
PH :7002722358. BULLARPARA, MOUZA TANGLA. - 784521 SAINT TRESA SCHOOL, ALIGANJ, BHAGALPUR.
BIHAR. - 821307
NALBARI PH :9954387619. - 812005
PH :8294634602.
TEZPUR PH :8797096020.
162. BIMAL AUTO AGENCY (9201-92-01), GAYA
CHOWKBAZAR, NALBARI HAJO ROAD, NALBARI 172. RAMLAL DURGADUTT MOTORS PVT LTD BIHARSHARIF
191. KARLO AUTOMOBILES PVT LTD (Y601-Y6-01),
DIST. NALBARI - 781335 (T102-T1-01), NEAR DON BASCO SCHOOL, P.O. 182. REESHAV AUTOMOBILES (MG01-TG-03), PATNA
BODH GAYA, GAYA. - 824231
PH :7576842484. NIKAMULSATRA, TEZPUR, ASSAM - 784154 RANCHI ROAD, NR GAGAN DIWAN SOGARA
PH :7004574631/8539063615.
NORTH LAKHIMPUR PH :8724087940. SCHOOL, THANA-LAHERI MURARPUR,
192. DMC CARS (A UNIT OF DHANRAAJ AGENCIES
173. RAMLAL DURGADUTT MOTORS PVT LTD BIHARSHARIF, DISTRICT-NALANDA, BIHAR -
163. SAIKIA AUTO PVT. LTD. (7P01-7P-01), PVT LTD (Y602-Y6-01), DHANRAAJ AGENCIES
(T102-T1-02), GORAIMARI, VILLAGE - SOLGAON, 803101
HATILUNG, NH-52 ROAD, NORTH LAKHIMPUR, PRIVATE LIMITED, MARUTI SUZUKI ARENA
TEZPUR, ASSAM. - 784001 PH :9263632175.
ASSAM - 787031 SHOWROOM, OPPOSITE AIRPORT RUNWAY,
PH :9836036157. BUXAR
PH :8473946336. GAYA-DOBHI ROAD,GAYA, PIN 823004 - 823004
164. SAIKIA AUTO PVT. LTD. (7P01-7P-03), TINSUKIA 183. PEARL CARS (VV01-VV-01), C/O DEVDHTRHA PH :9031011806/9900024001.
KHELMATI, WARD NO. 14, NH -52, NORTH 174. VISHAL CAR WORLD PVT LTD (J401-J4-01), UPPDHYYA, SYNDICATE, BYE PASS ROAD, GOPALGANJ
LAKHIMPUR, ASSAM - 787001 LAIPULY, A.T. ROAD, TINSUKIA, DIST - BUXAR - 802101
193. SHREE GOPAL AUTO PVT. LTD. (O301-O3-01),
PH :7002571073. TINSUKIA, ASSAM - 786183 PH :8294634605/8294634602.
NH-28, DANAPUR,
PATHSALA PH :9435860000. CHAKIA TEHSIL-MANJAGARH,GOPALGANJ (BIHAR) -
BIHAR 800023
ARARIA PH :9771486170/9771486139.

16
Dealer Workshop (AS ON 31.05.2023 )

HAJIPUR 204. SEEMANCHAL MOTORS PVT. LTD. SITAMARHI BALOD


(CFS1-CFS-01), NEAR GAYATRI PLY ROOM,
194. REESHAV AUTOMOBILES (MG01-MG-01), 216. RAJIV AUTOMOBILES PVT. LTD. (EO01-EO-01), 226. CHOUHAN (SFE1-SF-01), H.NO 185, WARD NO
NH-31, NAUGACHIA MARKET, NAUGACHIA,
KHATA 617 & KHASHRA 354/1605, NEAR DUMRA ROAD, SHANTI NAGAR, SITAMARHI. - 25, NAYA MARKET, DALLIRAJHARA, BALOD
DISTRICT – BHAGALPUR, BIHAR. - 853204
RELIANCE PETROL PUMP, M G SETU ROAD, 843301 -491228 - 491228
PH :8797096014, 8797096020.
HAJIPUR ( VAISHALI). - 844101 PH :9234609671 PH :9837325267.
PH :9060945038. NAWADA 7280074124. BALODA BAZAR
KATIHAR 205. REESHAV AUTOMOBILES (MG01-TJ-04), 191 & SIWAN 227. SKY AUTOMOBILES (5001-GJ-04), AMBEDKAR
400, KHSARA NO. 3105 & 3102, NEAR DM'S
195. SEEMANCHAL MOTORS PVT. LTD. 217. SHREE GOPAL AUTO PVT. LTD. (O501-O5-01), CHOWK, RAIPUR ROAD, BALODA BAZAAR,
OFFICE, PATNA-RANCHI MAIN ROAD, NAWADA,
(O601-O6-01), NEAR SBP VIDIYA VIHAR CHAPRA ROAD, NEAR CHAPDHALA, NH 85, CHATTISGARH. - 493332
BIHAR - 805110
SCHOOL, SIRSA, KATIHAR PURNEA ROAD, SIWAN - 841236 PH :9893307429.
PH :6206162228.
KATIHAR - 854105 PH :9771486132. BEMETRA
PH :7762893700. PATNA
206. VAU'S AUTOMOBILE (1503-15-01), BESIDES
CHANDIGARH 228. CHOUHAN AUTOMOBILES LLP (CBC2-CBC-01),
KISHANGANJ KHASRA NO. 88/2, CHOUHAN AUTOMOBILE LLP,
GODAVARI APPARTMENT, ASHIANA ROAD, CHANDIGARH
196. SEEMANCHAL MOTORS PVT. LTD. KAWARDHA ROAD, NAVGHAD CHOWK,
PATNA. - 800014 218. MODERN AUTOMOBILES (0702-07-01), 4 M.W.
(PX01-PX-01), PASCHIM PALI ROAD, COLLEGE BEMTARA CHATTISGARH - 491335
PH :9771446012. INDL AREA, CHANDIGARH - 160002
ROAD, THANA:KNE, WARD NO.1, KISHANGANJ PH :6262000222.
207. KARLO AUTOMOBILES PVT LTD (1502-15-04), PH :9646000190.
(BIHAR). - 855101 BHATAPARA
NEAR BATA GUNJ, DINGA PATNA, BIHAR. - 219. AUTOPACE NETWORK PVT LTD (0705-07-01),
PH :8797096019.
800013 PLOT #112-113, INDUSTRIAL AREA, PHASE-1, 229. SPARSH AUTOMOBILES (BBJ1-BBJ-01), RAIPUR
LAKHISARAI PH :09304212119/7004573547. CHANDIGARH - 160002 ROAD, BHATAPARA (CHATTISGARH) - 493118
197. GS MOTORS PVT. LTD. (CHU1-CHU-01), TAUZI 208. ALANKAR AUTO SALES & SERVICE PVT LTD PH :9878422201. PH :8921326361/ 9285505780.
NO. 39, KHATA NO. 3, KHESRA NO. 496, MOUZA (1504-15-03), PLOT NO.118-119, BEHIND DURGA 220. TRICITY AUTOS (9M01-07-02), PLOT NO 29/6, BHILAI
- JAINAGAR, ANCHAL - LAKHISARAI, DIST. MARINE DRIVE APARTMENTS, DUJRA DEVI INDUSTRIAL AREA PHASE-2, CHANDIGARH -
STHAN, ASHOK RAJPATH, PATNA - 800001 230. CHOUHAN AUTOMOBILES LLP (8305-83-01),
-LAKHISARAI, BIHAR. - 811311 160002
PH :9934020200. PLOT NO.1 & 34, SHIVNATH COMPLEX, BEHIND
PH :9204756206. PH :9988882335.
209. REESHAV AUTOMOBILES PVT.LTD. CHOUHAN ESTATE, G.E. ROAD, SUPELA,
MADHUBANI 221. NAVDESH AUTO LLP (0708-07-01), PLOT NO. 42,
(1506-15-01), PLOT NO.25/1581 KHATA NO.494, BHILAI. - 490023
INDUSTRIAL AREA PHASE-1, CHANDIGARH. -
198. RAJKRISHNA MOTORS LLP (CAJ2-CAJ-01), MOUZA KUMHRAR, PARGANA AZEEMABAD, PH :9111100140.
160002
BHOWRA TOLA, BARDIBAN, MADHUBANI, KANKARBAGH, PATNA. - 800004 231. SPARSH AUTOMOBILES PVT LTD (8304-83-01),
PH :7087035482.
BIHAR - 847211 PH :7632995356. R-17, INDUSTRAIL AREA, NANDNI ROAD,
PH :9304481978 210. KARLO AUTOMOBILES PVT LTD (1502-15-05), CHHATTIGARH CHHAWANI CHOWK, BHILAI, CHHATTISGARH -
9693127351. JAGDEOPATH , NEAR SAI CORPORATE PARK, PENDRA 490026
MOHANIA PATNA - 801506 PH :8779064848.
222. M SQAURE (SCZ1-SCZ-01), – M SQUARE
PH :9264190675. 232. CHOUHAN AUTOMOBILES LLP (8305-83-02),
199. PEARL CARS (VW01-VW-01), MOHANIA-BUXAR MOTORS, NEAR SEMRA CLOCK MAIN ROAD,
211. ALANKAR (1504-15-06), ALANKAR COMPOUND, NH-6, DURG BYPASS ROAD, KHASRA NO.1/14,
ROAD ,SH-14,MOHANIA - 821109 PENDRA,GOURELA PENDRA MARWAHI-495119 -
BESIDE ALANKAR SUN CITY, SANDALPUR, 1/23, 1/192, VILLAGE-KATULBOD, BHILAI,
PH :8294634632/8294634649. 495119
KUMHRAR, PATNA – 800006 - 800006 TEHSIL & DISTT. DURG, BHILAI,
MOTIHARI PH :7987590484.
PH :9304403916. CHHATTISGARH - 491001
200. RAJIV AUTOMOBILES PVT LTD (T401-FH-03), PURNEA CHHATTISGARH PH :6262000222.
NEAR CHHATAUNI CHOWK, BESIDE NH 28 A, AMBIKAPUR BHILLAI
MOTIHARI TOWN , BIHAR - 845401 212. SEEMANCHAL MOTORS PVT. LTD. (6V01-6V-01),
NH-31, NEAR MARKETING YARD, GULAB BAGH, 223. MAHAMAYA AUTOCARS PVT LTD (AE01-AE-01), 233. SPARSH AUTOMOBILES (8304-83-02), M/S.
PH :9234609669.
PURNEA (BIHAR) - 854326 MANEDRAGARH ROAD, AMBIKAPUR, SPARSH AUTO,VEERSAVARKAR MARKET, G.E
MUZAFFARPUR CHATTISGARH. - 497001 ROAD, SUPELA,BHILLAI-490023 - 490023
PH :8797096014.
201. RAJIV AUTOMOBILES PVT LTD (T401-T4-01), PH :7987741432. PH :9926626662.
SAHARSA
RAMDAYALU NAGAR, PATNA HAZIPUR ROAD, BAGBAHARA BILASPUR
MUZAFFARPUR, BIHAR - 842002 213. GS MOTORS PVT. LTD. (AAP1-AAP-02),
PATUAHA, NH 107 SAHARSA,BIHAR - 852201 224. HDN MOTORS (SEB1-SEB-01), M/S HDN 234. SATYA AUTO PVT LTD (C303-C3-01), SECTOR C,
PH :9910347908.
PH :9263638456. MOTORS, BESIDE R.N RICE MILL, NEW PLOT NO. 42, SIRGITTI INDUSTRIAL AREA,
202. RAM KRISHNA MOTORS PRIVATE LTD.
MAHAVEER COMPLEX, MAHASAMUND ROAD, BILASPUR, CHATTISGARH - 495001
(T402-T4-01), KRISHNA TALKIES CAMPUS, SAMASTIPUR
BAGBAHARA - 493449 PH :9109194833.
AKHARAGHAT ROAD, MUZAFFARPUR, BIHAR. - 214. RAJKRISHNA MOTORS LLP (1W02-1W-01), PH :7909800004. 235. SATYA AUTO PVT LTD (C303-C3-02), PLOT NO.
842001 KHESRA NO. 3190-95, KHATA NO. 76, HERPUR
BAIKUNTHPUR 848/20, 848/26, 848/40, MOPKA BYPASS ROAD,
PH :9102173333. ALLOTH, SAMASTIPUR, BIHAR. - 848101 BILASPUR, CHHATTISGARH. - 495006
203. RAJIV AUTOMOBILES PVT LTD (T401-T4-04), PH :9204552405. 225. MAHAMAYA AUTOCARS PVT LTD PH :9977879698.
KHABRA POKHAR LANE NO -1, PANCHAYAT (CQU1-CQU-01), WARD NO.01, KHATA NO.91/6,
SASARAM
-KHABRA, CITY- MUZAFFARPUR - 843146 TEHSIL - BAIKUNTHPUR, DISTT. - KORIYA,
PH :9234609671. 215. PEARL CARS (1X01-1X-01), PLOT NO.7, 9 & 11, CHATTISGARH - 497335
NAUGACHIA NH-2 MORE SARAI, SASARAM (BIHAR) - 821115 PH :9179350707.
PH :8294634602/8294634649.

17
Dealer Workshop (AS ON 31.05.2023 )
236. M SQUARE MOTORS ( A UNIT OF MAHAVIR KHAIRAGARH RAIPUR 269. SATYA AUTO PVT LTD (BUC2-BUC-01), KASRA
MOTORCORP PRIVATE LIMITED) (C302-C3-01), NO. 71/4, 73/2, 74/2, 75/1 AND 76/2, SARANGARH
246. SPARSH AUTOMOBILES PVT LTD 256. SKY AUTOMOBILES (5001-50-01), G.E.ROAD,
KHASRA NO. 420 AND 414/1, NEAR RELIANCE BIKAS KHAND, SARANGARH, DISTT. RAIGARH. -
(GMG1-GMG-01), KHAIRAGARH -JHALBANDHA MOHABA BAZAR, RAIPUR. - 492010
PETROLEUM PUMP, BESIDES TRANSPORT 733751
ROAD,AMLIPARA, OPP - BIJALI OFFICE, PH :9584433102.
NAGAR GATE, RAIPUR ROAD, PARSADA, PH :8462000841.
KHAIRAGARH -491881 - 491881 257. SKY AUTOMOBILES (5001-50-02), K.K. ROAD,
BILASPUR. - 495223 TILDA
PH :9926626662. MOUDHAPARA, RAIPUR. - 492001
PH :6262622560.
KHARSIA PH :9584460290. 270. SKY AUTOMOBILES (CWR1-CWR-01), KASRA
DALLIRAJHARA 258. SPARSH AUTOMOBILES (5002-50-01), NO. 29/31, TILDA, DIST.-RAIPUR,
247. SATYA AUTO (SET1-SET-01), M/S SATYA AUTO ,
237. CHOUHAN (SMZ1-SMZ-01), H.NO 185, WARD NO PACHPADI NAKA, OPP. DUTTA DRY CLEANER, CHHATTISGARH. - 493 114
BESIDE GOVT HIGH SCHOOL, RANISAGAR,
25, NAYA MARKET,DALLIRAJHARA,BALOD DHAMKARI, JAGDALPUR ROAD, RAIPUR. - PH :9425204051.
KHARSIA, DISTRICT: RAIGARH, CHHATTISGARH
DISTRICT-491228 - 491228 492001 TITLAGARH
- 496661
PH :6262000222. PH :9669792000.
PH :9993092051. 271. ODYSSEY MOTORS (SQE1-SQE-01), M/S PLOT
DEOBHOG 259. SKY AUTOMOBILES (5001-50-05), NEAR R.K.
KONDAGAON NO 687/1216, MOUZA PIPALPADAR.
MALL, KOTA ROAD, RAIPUR - 492001
238. SPARSH AUTO (SIQ1-SIQ-01), M/S SPARSH TITLAGARH,BALANGIR, ODISHA - 767033
248. SKY AUTO (SDF1-SDF-01), – M/S SKY AUTO, PH :9893000161.
AUTOMOBILES PVT LTD SANTOSHI PH :9439314464.
NH-90 RAIPUR ROAD, NEAR INDIAN OIL 260. SKY AUTOMOBILES (5003-50-01), AVANTIVIHAR
NAGAR,NEAR BHARAT PETROL PUMP,
DHARAMGARH ROAD, DEOBHOG – 493890 -
PETROL PUMP, KONDAGOAN, CHHATTISGARH ROAD, TELEBANDHA, RAIPUR (C.G) - 492006 DADRA AND NAGAR HAVELI
- 494226 PH :9522314155. SILVASSA
493890
PH :9425204051. 261. SPARSH AUTOMOBILES (5002-50-04), OPP.
PH :9926626662. 272. KATARIA AUTOMOBILES PVT. LTD.
KORBA UNION BANK, MAIN ROAD, PANDRI, RAIPUR -
DHAMTARI 492004 (ED01-ED-01), NEAR ATHAL CHAR
249. SATYA AUTO PVT LTD (U702-U7-01), SHED NO. PH :9009666400. RASTA,DADAR & NAGAR HAVELI, SILVASSA -
239. SKY AUTOMOBILES (7V01-7V-01), KASRA
1, INDUSTRIAL AREA, KORBA - 495681 262. SPARSH AUTOMOBILES (5002-50-05), PLOT - 31, 396230
NO.238/2, SEHARA DABRI, RAIPUR ROAD,
PH :8462000861. INDUSTRIAL ESTATE, OPP MAHESH COLD PH :9723816223.
DHAMTARI-493773 CHATTISGARH - 492009
PH :8889998612. MAHASAMUND STORAGE, BHANPURI, RAIPUR - ?? DAMAN AND DIU
DURG 250. SPARSH AUTOMOBILES (5002-9P-02), PH :9977220395.
DAMAN
BARONDA CHOWNK, BAGBAHRA ROAD, 263. SKY AUTOMOBILES (5001-50-07), ADJOINING
240. SPARSH AUTOMOBILES PVT LTD WALLFORT CITY, BHATGAON, RING ROAD NO. 273. KATARIA AUTOMOBILES PVT. LTD. (0104-98-08),
MAHASAMUND. - ??
(7W03-7W-01), OPP. JAINAM PLACE, BEFORE 2, RAIPUR, CHHATTISGARH. - 492013 NEAR AKASWANI CENTER, RINGANWADA,
PH :9926280700.
PULGAON CHOWK, PULGAON NAKA, DURG, PH :9584460289. NANI DAMAN , DAMAN UNION TERRITORY -
CHHATTISGARH - 491001 MANENDRAGARH 396210
264. HDN MOTORS PVT. LTD. (5005-50-01), BESIDES
PH :9840437544. 251. MAHAMAYA AUTOCARS PVT LTD BHARAT BENZ SHOWROOM, DURG-BHILAI PH :9924130655.
GARIYABANDH (AE01-BCE-02), WARD NO.21, NH-43, ROAD, TATIBANDH, RAIPUR, CHHATTISGARH. - DELHI
AMBIKAPUR ROAD, NEAR HP PETROL PUMP, 492001
241. SPARSH AUTOMOBILES (CCH1-CCH-01), NEAR DELHI
MANENDRAGARH, DISTT. KORIYA - 497442 PH :7909800093.
HP PETROL PUMP, RAIPUR ROAD,
PH :9584136234. 265. VISHWABHARTI AUTOMOBILES PRIVATE 274. SAYA AUTOMOBILES PVT. LTD. (0808-08-03), A
GARIYABAND, CHHATTISGARH. - 756032
PH :9669638883. MUNGELI LIMITED (5004-50-01), VIDHAN SABHA ROAD, 21-22, G.T.KARNAL ROAD, NEW DELHI - 110033
MOWA, RAIPUR DISTT. CHHATTISGARH - PH :47088888.
JAGDALPUR 252. SATYA AUTO PVT LTD (BLE2-BLE-01), KHASRA
492005 275. BAGGA LINK MOTORS PVT LTD. (0811-08-01),
NO. 270/2, BILASPUR ROAD, MUNGELI,
242. SKY AUTOMOBILES (EC01-EC-01), GEEDAM PH :6262620057. 395 PATPAR GANJ INDL.
CHHATTISGARH - 861468
ROAD, JAGDALPUR, CHATTISGARH. - 494001 RAJIM AREA,PATPARGANJ,NEW DELHI - 110092
PH :8462000844.
PH :9109996511. PH :46488830, 46488831.
JANJGIR PATHALGAON 266. SPARSH AUTOMOBILES (5002-MO-03), RAIPUR 276. BAGGA LINK MOTORS PVT LTD. (0811-08-02),
253. ROAD, NEAR AMMANI PETROL PUMP,
MAHAMAYA AUTOCARS PVT LTD LINK ROAD,(NEAR BAGGA PETROL
243. SATYA AUTO PVT LTD (9N02-9N-01), NEAR NAYAPARA, RAJIM. - 493881
(BXO1-BXO-01), KHASRA NO. 567/2, PUMP),KAROL BAGH,NEW DELHI - 110005
KHOKSHA RAILWAY CROSSING, CHAMPA PH :966963883.
PHATALGAON, DISTRICT – JASPUR, PH :23524646, 23522626.
ROAD, NH-200, JANJGIR - 495668 RAJNANDGAON
CHHATTISGARH. - 496118 277. DD MOTORS (A DIVISION OF D.D. PREM
PH :7747000446.
PH :9752195523. 267. SPARSH AUTOMOBILES PVT LTD (LQ02-LQ-01), PVT.LTD.) (08F1-08-01), A-100
KANKER MAYAPURI,PHASE-II,NEW DELHI - 110064
PITHORA NEAR HANUMAN TEMPLE, VILL-MANKI , NH-6,
244. SKY AUTOMOBILES (5001-KG-06), RAZA RAJNANDGAON, CHHATTISGARH - 491441 PH :41845000, 49305232.
254. SPARSH AUTOMOBILES (CCG1-CCG-01), PLOT
NAGAR, SINGARBHAT, NH-30, KANKER , PH :7887518100. 278. COMPETENT AUTOMOBILES CO. LTD.
NO. 284/1, RAMSAGAR PARA, RAIPUR ROAD,
DISTRICT – KANKER, CHHATTISGARH - 494334 SARAIPALLI (0806-08-03), PLOT NO.3,GAZIPUR,DELHI, -
PITHORA, CHHATTISGARH. - 761008
PH :8889998625. 110096
PH :9926280700. 268. SKY AUTOMOBILES PVT. LTD. (BUF1-BUF-01),
KAWARDHA PH :45300000.
RAIGARH KHASRA NO.482/5 AND 482/6, RAIPUR ROAD, 279. T.R. SAWHNEY MOTORS PVT LTD (0819-08-01),
245. CHOUHAN AUTOMOBILES LLP (DI02-DI-01), SARAIPALI, DIST-MASAMUND, SARAIPALI -
255. SATYA AUTO PVT LTD (7Y03-7Y-01), JINDAL 33 & 34, HARICHAND MELARAM COMPLEX,
KHASRA NO. 100/6, TALPUR BILASPUR ROAD, 493558
ROAD, RAIGARH - 496001 EAST GOKULPUR, WAZIRABAD ROAD, DELHI -
KAWARDHA, CHHATTISGARH. - 491 995 PH :7000723259.
PH :7024398350. 110094
PH :6262000222. SARANGARH PH :71115333.

18
Dealer Workshop (AS ON 31.05.2023 )
280. RANA MOTORS PVT LTD (08A1-08-02), 293. COMPETENT AUTOMOBILES CO. LTD. 306. JAGMOHAN AUTOMOTIVES (08F6-08-01), PLOT MARGAO
C-47,OKHLA INDUSTRIAL AREA,PHASE-II,NEW (0806-08-06), 14, SHIVAJI MARG, NAGAFGARH NO. 69/2, WAZIRPUR INDUSTRIAL AREA, NEW
318. CHOWGULE INDUSTRIES PVT. LTD.
DELHI - 110020 ROAD, NEW DELHI - 110 015 DELHI, PIN-110052 - 110052
(3408-1Y-01), OPP.DAMODAR
PH :41707777. PH :8377007980/81/02. PH :9650790351.
TEMPLE,FATORDA,MARGOA,GOA - 403602
281. T.R. SAWHNEY MOTORS PVT LTD (0819-08-02), 294. PREM MOTORS PVT. LTD. (08D4-08-01), KH. 307. RANA MOTORS (08A1-08-08), B-83, GTK ROAD
PH :0832-6623444/420/7796630235.
B-6 INDUSTRIAL AREA, PHASE I, OPP SECTOR NO.804/2,MAHIPALPUR MATA CHOWK, DELHI - INDUSTRIAL AREA, DELHI. - 110033
319. SAI POINT CARS PVT LTD (3409-1Y-01),
18, BADLI, NEW DELHI - 110042 110037 PH :9873400386.
H.NO.17,WARD NO.5,SURVEY
PH :71118333. PH :42390000. 308. AAA VEHICLEADES (08B9-08-G1), KHASRA NO.
NO.34/3,34/4,MARGAON PONDA
282. DD MOTORS (A DIVISION OF D.D. PREM 295. AAA VEHICLEADES PVT. LTD. (08B9-08-03), 204, MAIN CHHATARPUR ROAD, CHHATARPUR,
HIGHWAY,SONFATOR
PVT.LTD.) (08F2-08-01), 5, VILLAGE GHEVRA, KHASRA NO.87/3, 87/8 & NEAR SAI BABA MANDIR, DELHI, PIN-110030 -
AMBORA,CAMURLIN,SALCETE ,GOA - 403722
WAZIRPUR,INDUSTRIAL AREA,ADJACENT TO 87/13/1, DELHI-ROHTAK ROAD, METRO PILLAR 110030
PH :9545454826/8380013499.
WAZIRPUR DEPOT,RING ROAD, NEW DELHI - NO.616, MUNDKA, NEW DELHI - 110041 PH :9829342761.
320. SAI SERVICE PRIVATE LIMITED (3402-1Y-02),
110034 PH :66118888. 309. VIPUL MOTORS (08F7-08-01), B-26, JHILMIL
SURVEY NO. 212/4,VILLAGE - VERNA,TAL :
PH :27153996-99, 27151466-67. 296. RANA MOTORS PVT LTD (08A1-08-05), A-8, INDUSTRIAL AREA, DELHI -110095 - 110095
SALCETE ,NEXT TO AGNEL POLYTECHNIC,
283. ROHAN MOTORS LTD. (0886-08-01), F-9/B-1, RAJASTHANI UDYOG NAGAR, NEAR AZADPUR PH :9811233385.
MARGAO - 403718
MOHAN COOPERATIVE INDUSTRIAL ESTATE, FRUIT MARKET, G.T. KARNAL ROAD, OPP. OKHLA, DELHI PH :2883000, 2791195,9834398096.
MATHURA ROAD, DELHI - 110044 METRO PILLAR NO.119, DELHI. - 110033
310. AAA VEHICLEADES PVT LTD (08B4-08-01), B243, 321. CHOWGULE INDUSTRIES PVT. LTD.
PH :40567900, 41679252-259. PH :41609999, 42474444.
OKHLA PHASE-1, OKHLA, DELHI - 110020 (3408-1Y-08), PLOT NO. M-58 AND M-59, PHASE
284. MAGIC AUTO PVT. LTD. (0888-08-01), 297. SHREYASH AUTOMOTIVES PRIVATE LIMITED
PH :8448582912. 3B, VERNA INDUSTRIAL ESTATE, MARGAO,
A-93,PHASE-2,MAYAPURI INDL AREA,DELHI - (08F9-08-01), A-3, WAZIRPUR INDUSTRIAL
WAZIRPUR - DELHI VERNA, SALCETE SOUTH GOA, GOA - 403722
110064 AREA, DELHI. - 110052
PH :0832-6621800/9922950800.
PH :41847777. PH :42020000, 9910114255. 311. DD MOTORS (08F1-08-05), A-90, WAZIRPUR
285. DD MOTORS (A DIVISION OF D.D. PREM 298. T.R. SAWHNEY MOTORS PVT LTD (08D2-08-01), INDUSTRIAL AREA, NEW DELHI-110052 - 110052 PANAJI
PVT.LTD.) (08F3-08-01), A-1 UDYOG VIHAR,NEW B-19, MAYAPURI INDUSTRIAL AREA, PHASE-1, PH :9310367233. 322. CHOWGULE INDUSTRIES PVT. LTD.
ROHTAK ROAD,PEERAGARHI,DELHI - 110041 NEW DELHI. - 110064 (3408-P1-02), D.B BANDODKAR
PH :25963535, 48616500. PH :71119333, 9999049337. GOA MARG,CAMPAL,PANAJI,GOA - 403001
286. T.R. SAWHNEY MOTORS PVT LTD (0819-08-04), 299. DD MOTORS (A DIVISION OF D.D. PREM BICHOLIM PH :9922950798/9922925701.
PLOT NO.-508, FUNCTIONAL INDUSTRIAL PVT.LTD.) (08F1-08-02), 9/55 KIRTI NAGAR, 312. SAI SERVICE PRIVATE LIMITED (BHN1-BHN-01), 323. SAI SERVICE PRIVATE LIMITED (3402-P1-07),
ESTATE, PATPARGANJ - 110092 INDUSTRIAL AREA, NEW DELHI - 110015 CITY SURVEY NO. 46/1, MUSLIM WADDO, SHED NO.18/329, PLOT NO.5A, SURVEY
PH :9873851333. PH :999903888. BICHOLIM, GOA - 403529 NO.117/6, TELEIGAON, ST. INEZ, PANJIM,
287. MAGIC AUTO PVT. LTD. (08B7-08-01), PLOT NO. 300. MAGIC AUTO PVT. LTD. (08D5-08-01), PLOT NO. PH :2385500, 9881746566. GOA-403 002. - 403001
68/3,MOTINAGAR,NEW DELHI, - 110015 449 & 450, PATPARGANJ INDUSTRIAL AREA, PH :22229222/2225222,9923865179.
CANACONA
PH :43777777, 43777721. NEW DELHI. - 110092 PERNEM
288. SHREYASH AUTOMOTIVES PRIVATE LIMITED PH :9818741741. 313. CHOWGULE INDUSTRIES PVT. LTD. (IT01-IT-01),
(08F8-08-01), PLOT NO.9, SSI INDUSTRIAL 301. DD MOTORS (A DIVISION OF D.D. PREM PLOT NO.40, CANCONA INDUSTRIAL ESTATE, 324. CHOWGULE INDUSTRIES PVT. LTD.
ESTATE, GT KARNAL ROAD, NEW DELHI. - PVT.LTD.) (08F1-08-03), 85B RANAJI ENCLAVE, SHREESTAL, CANCONA, SOUTH GOA - 403702 (CUA1-CUA-01), SURVEY NO. 258/1-B & 258/1-C,
110063 NAGLI SAKRAWATI, NAJAFGARH, NEW DELHI. - PH :0832-2633010/8805024916. OPPOSITE INDUTRIAL TRAINING INSTITUTE,
PH :43288888. 110043 CUNCOLIM TALUKA - PERNEM, DIST.-NORTH GOA. - 403512
289. SAYA AUTOMOBILES (0808-08-2B), KHASRA PH :9999127840/9999127947. PH :8380082893.
314. SAI SERVICE PRIVATE LIMITED (3402-AAO-06),
NO.2,G.T. KARNAL ROAD,OPP. GURUDUARA 302. DD MOTORS (A DIVISION OF D.D. PREM POLEM
SURVEY NO.64/7, SHOP NO.3-A-II,
HARGOVIND SINGH,SIRAS PUR BADLI,DELHI - PVT.LTD.) (08F5-08-01), 36/22/2 AND 36/19, PANA 325. CHOWGULE INDUSTRIES (SHO1-SHO-01),
CANCNAMODDI, CUNCOLIM, SOUTH GOA -
110033 UDHYAN, NARELA, NEW DELHI. - 110040 DULGAL-SHELIM,VILLAGE POLEM-LOLIEM
403703
PH :27731325, 27731856. PH :8860637358. .SOUTH GOA.403728 - 403728
PH :2763062, 2763063, 9850398057.
290. COMPETENT AUTOMOBILES CO. LTD. 303. DD MOTORS (A DIVISION OF D.D. PREM PH :#REF!.
(0806-08-05), B-83 MAYAPURI PHASE I, NEW PVT.LTD.) (08F1-08-04), 32/19, MATIALA, BEHIND
DHARBANDORA
PONDA
DELHI - 110015 DELHI PUBLIC SCHOOL, SECTOR-3, DWARKA, 315. CHOWGULE INDUSTRIES PVT. LTD.
PH :47268980. NEW DELHI. - 110059 (3408-GO-07), AT- KHANDEPAR- USGAON, 326. SAI SERVICE PRIVATE LIMITED (3402-34-03),
291. BAGGA LINK MOTORS PVT LTD. (0811-08-03), PH :9873173005. TAL-DHARBANDORA, SOUTH GOA - 403401 OFF PANJIM HIGHWAY,PONDA,GOA, - 403401
PLOT NO.4,6,8,10 NEAR FORTIS HOSPITAL, 304. FAIR DEAL WHEELS PVT. LTD (08E3-08-01), PH :0832-6623477/7888004357. PH :2324106, 2311499, 2324120, 9518349559.
OPPOSITE NIRULAS, BABA POTERY PLOT NO.25, KHATA KHATAUNI NO.97/98, MAPUSA PORVORIM
COMPOUND, ARUNA ASAF ALI ROAD, VASANT KHASRA NO.48/17, OPP. BRAHMSHAKTI 327.
316. SAI SERVICE PRIVATE LIMITED (3402-8Z-05), SAI SERVICE PRIVATE LIMITED (3402-P1-01),
KUNJ, NEW DELHI - 110070 HOSPITAL, BUDH VIHAR, POOTH KALAN, MAIN
D-2/9,MAPUSA INDUSTRIAL ESTATE,MAPUSA, SURVEY NO: 36/1,PENHA DE FRANCE,TAL :
PH :45688888, 45688811. KANJHAWALA ROAD, DELHI - 110086
GOA, - 403507 BARDEZ, ALTO PCRVORIM,GOA - 403501
292. RANA MOTORS PVT LTD (08A1-08-04), B-6/6, PH :9711993801.
PH :2267000, 8660432266. PH :2419200, 2414324, 9881746567.
OKHLA INDUSTRIAL AREA PHASE-II, NEW 305. COMPETENT AUTOMOBILES CO. LTD.
DELHI - 110020 (0806-08-07), 23/2, MATIALA PHIRNI, POCKET C,
317. CHOWGULE INDUSTRIES PVT. LTD. SANVORDEM
(3408-8Z-03), PLOT NO. 19/20,THIVIM
PH :40877777, 26389930. SECTOR 3, DWARKA, DELHI. - 110059
INDUSTRIAL ESTATE,KARASWADA,
PH :9582797774.
MAPUSA,GOA - 403507
PH :0832-6631666/6631608/8888817955.

19
Dealer Workshop (AS ON 31.05.2023 )
328. CHOWGULE INDUSTRIES PVT. LTD. 339. POPULAR WHEELERS (INDIA) PVT. LTD. 350. STARLINE CARS PVT. LTD. (D101-01-09), SR NO ANKLESHWAR
(BTK1-BTK-01), SURVEY NO. 4, SUBDIVISION-3, (0111-01-01), BESIDE SOLA ROAD BRIDGE,S. G. – TP - 57, PLOT NO. 67, NEAR GOTA FLYOVER
361. RAVIRATNA MOTORS PVT LTD (P901-P9-01),
VILLAGE – CACORA, TALUKA – CURCHOREM, HIGHWAY SOLA,AHMEDABAD - 380054 BRIDGE, OPP. SHANKU FARM HOUSE, S.G.
PLOT NO. 624/2/BA, GIDC, VALIA ROAD,
SANVORDEM, DIST. – SOUTH GOA, GOA . - PH :65058111. HIGHWAY, GOTA, AHMEDABAD. - 382481
ANKLESHWAR - 393002
403706 340. KIRAN MOTORS LTD (0112-01-01), SURVEY NO. PH :9824601729.
PH :9687691063.
PH :9850477607. 82/1/1, NEAR H.P. PETROL PUMP, MOTERA 351. KATARIA AUTOMOBILES PVT. LTD. (0110-01-02),
SATTARI ROAD, CHANDKHEDA, AHMEDABAD - 380005 PLOT NO. 112, 116 & 119, SURVEY NO. BAGODRA
PH :8347491800/9824023122. 283/3.7.10, B/H SILVER STAR, BESIDE HARI 362. NANDA AUTOMOBILES PVT. LTD.
329. CHOWGULE INDUSTRIES PVT. LTD.
341. UDAY AUTOLINK PVT. LTD. (0113-01-01), NEAR VILLA BUNGLOWS, GOTA ROAD, (CVQ1-CVQ-01), SHOP NO. 9, 10, 11, 12,
(3408-BOP-10), SURVEY NO. 60, SUB DIV NO. 05,
GALAXY SPACIA, OPP. DASTAN FARM, S. P. CHANDLODIYA, AHMEDABAD. - 382481 KAMDHENU COMPLEX, BAGODRA HIGHWAY,
VILLAGE ARVALEM, VILLAGE PANCHAYAT
RING ROAD, KATHWADA, AHMEDABAD, PH :9824000378. NR. SBI BANK, BAGODRA. - 382240
ARVALEM, TALUKA SATTARI, NORTH GOA,
GUJARAT - 382430 352. DB MOTORS PRIVATE LIMITED (0119-01-01), PH :9727822000, 9726269111.
GOA - 403505
PH :7567229999. SURVEY NO. 131A, NH-8, ASLALI, OPP.-OCTROI BALASINOR
PH :9923464422.
342. NANDA AUTOMOBILES PVT. LTD. (0114-01-01), NAKA, AHMEDABAD. - 382427
TALEIGAON SURVEY NO. 229/3, OPP. GOKULESH PETROL PH :9726031111. 363. AMAR CARS PVT. LTD. (CJE1-CJE-01), SR. NO.
PUMP, NAROL - ASLALI ROAD, NAROL, 353. POPULAR WHEELS (0111-01-02), SAVAN 1451, OPP. OIC PETROL PUMP, AHMEDABAD
330. CHOWGULE INDUSTRIES PVT. LTD.
AHMEDABAD, GUJARAT. - 382405 SQUARE, SHOP NO. 1, 2, 3, 4, 5, SERVE NO. HIGHWAY (NH-47), KANTHARJINA MUVADA,
(3408-NP-06), SURVEY NO. 122, MAHBOS, NEAR
PH :8866558787 / 8460088883. 39/1, F.P. NO. 92, T.P. NO. 66/A, CHENPUR, NEW VILLAGE – VADALA, TALUKA – BALASINOR,
SHANKARWADI TEMPLE, SHANKARWADI,
343. STARLINE CARS (AHMEDABAD) PVT LTD RANIP, AHMEDABAD. - 382 427 DISTRICT – MAHISAGAR, GUJARAT. - 388255
TALEIGAON, - 403001
(0115-01-01), PLOT NO. 103/2, NANDA CHILODA, PH :9925203344. PH :7211109960.
PH :9922950798/9922925701.
VASCO NEAR RAILWAY CROSSING, KRISHNANAGAR 354. DB MOTORS PRIVATE LIMITED (0119-01-02), BARDOLI
ROAD, NARODA, AHMEDABAD - 382330 PLOT NO. 718, ASHRAM ROAD, OPPOSITE 364. DHRU MOTORS (4002-Q1-02), G.I.D.C,SURAT
331. SAI SERVICE PRIVATE LIMITED (3402-CP-04), PH :9824601729. GANDHI ASHRAM, OLD VADAJ, HRIDAYA KINJ, BARDOLI ROAD,BARDOLI, - 394601
NEXT TO SHIKALIM 344. KIRAN MOTORS LTD (0112-01-02), FINAL PLOT AHMEDABAD. - 380013 PH :9825413113/9879104454.
CHURCH,SHIKALIM,VASCO,GOA - 403802 NO.33/1/1, NEAR SHRUSHTI LAVISH, OPP. PH :9909048260. 365. KATARIA AUTOMOBILES PVT. LTD.
PH :2542581/2526008/2526000/9850398058. SHYAM VILLA-II, NARODA-NIKOL ROAD, NIKOL AMBAJI (Q106-Q1-02), BLOCK NO.13, NANDIDA CROSS
332. CHOWGULE INDUSTRIES PVT. LTD. DISTT. AHMEDABAD - 382330
355. TANU MOTORS (SKQ1-SKQ-01), OPP ROAD, BARASADI VILLAGE, SURAT-BARDOLI
(3408-CP-09), OPP BHRAMASTAL TEMPLE, PH
KUMBHARIYA JAIN DERASAR, GIDC ROAD, ROAD, BARDOLI, GUJARAT - 394310
PATRONG BAINA, VASCO,GOA - 403802 :7069868374/9173840458/7383651643/9173044104
AMBAJI, DIST-BANASKANTHA, GUJARAT 385110 PH :7698022665/9924138860.
PH :0832-2500407/427/9921943608/9850986904. .
- 385110 BAREJA
GUJARAT 345. KIRAN MOTORS LTD (0102-01-04), SURVEY NO.
PH :#REF!.
245/3, TP SCHEME NO. 43, NEAR KARGIL 366. KATARIA AUTOMOBILES PVT. LTD.
AHMEDABAD AMOD (BAN1-BAN-01), 5/6/7, ADITYA COMPLEX
PETROL PUMP, SCIENCE CITY ROAD,
333. KIRAN MOTORS LTD (0102-01-01), SARKHEJ - AHMEDABAD - 380060 356. RAVIRATNA MOTORS (F801-ZE-03), ROYAL NATIONAL HIGHWAY-8, BAREJA , TALUKA –
GANDHINAGAR HIGHWAY,OPP. RAJPATH PH :9327617447, 9327214890. PARK, JAMBUSAR-BHARUCH ROAD, AMOD, DASKROI, DISTRICT – AHMEDABAD, GUJARAT -
CLUB,AHMEDBAD - 380054 346. POPULAR WHEELERS (INDIA) PVT. LTD. DISTRICT: BHARUCH, GUJARAT. - 392110 382425
PH :9624055445. (0109-01-01), BEHIND G. B. SHAH COLLEGE, PH :9687691106/9687699383. PH :7046079997.
334. KATARIA AUTOMOBILES PVT. LTD. (0104-01-01), NEAR SWAMINARAYAN PARK, VAISHALI BARWALA (AHMEDABAD)
AMRELI
D/8 BEHIND ESI HOSPITAL,OUTSIDE DARIAPUR TOWNSHIP ROAD, VASNA, AHMEDABAD,
357. ALPHA AUTOLINK LLP (9E02-9E-01), LATHI BY 367. UDAY AUTOLINK PVT. LTD. (I401-I4-01), OPP.
DARWAJA,AHMEDABAD - 380016 GUJARAT. - 380007
PASS ROAD, AMRELI, GUJARAT. - 365601 HILTON HOTEL, BHAVNAGAR HIGHWAY, TA
PH :9824543500. PH :9099993830.
PH :9978938858/9978938833. BARWALA, DIST. AHMEDABAD - 382450
335. POPULAR WHEELERS (INDIA) PVT. LTD. 347. PEGASUS (A UNIT OF VISUAL AUTOLINK PVT.
PH :7567449999/9687677611.
(0105-01-01), PATEL TRUST BUILDING, AVTAR LTD.) (0129-01-01), PLOT NO. 116, BOPAL – ANAND
HALL,NAROL, NARODA HIGHWAY,ISANPURA AMBIL ROAD, BOPAL , AHMEDABAD, DISTRICT
BAVLA
358. AMAR CARS PVT. LTD. (F702-F7-01), JANTHA
ROAD,AHMEDABAD - 382443 – AHMEDABAD, GUJARAT. - 380058 368. KATARIA AUTOMOBILES PVT. LTD.
CROSSING,SOJITRA ROAD,ANAND - 388121
PH :61903232. PH :7211140026, 7211130053. (0104-RX-07), NEAR ESSAR PETROL PUMP,
PH :9909960772.
336. KIRAN MOTORS LTD (0102-01-02), BEHIND L&T 348. TANU MOTORS PVT. LTD. (0118-01-01), SURVEY BAVLA -AHMEDABAD HIGHWAY, BAVLA -
359. KATARIA AUTOMOBILES PVT. LTD.
GODOWN,SARKHEJ SANAND HIGHWAY, NO. 1155/1-2, 1154 & 1156, PLOT NO. 39, 382220
(F703-F7-01), SURVEY NO. 189/1+2/A+3/A/K
AHMEDABAD - 382210 SARKHEJ-SANAND ROAD, SANAND, PH :9824344889.
190/P, OPP. OLD JAKAT NAKA, NEAR RAILWAY
PH :26891863, 26891009, 26891294. AHMEDABAD (GUJARAT) - 382110 BECHRAJI
OVERBRIDGE, ANAND-CHIKHODRA ROAD,
337. KATARIA AUTOMOBILES PVT. LTD. (0104-01-05), PH :9512009110. ANAND, GUJARAT. - 388 120 369. STARLINE CARS PVT. LTD. (GJM1-GJM-01), R.S.
NEAR KOKHRA BRIDGE,MANINAGAR - 380008 349. PEGASUS (A UNIT OF VISUAL AUTOLINK PVT. PH :7698954466. NO. 336 PAIKI, MOJE-BECHAR (BECHARAJI),
PH :7567568182. LTD.) (0117-01-01), PLOT NO.116 & 118/2,
338. KATARIA AUTOMOBILES PVT. LTD. (0110-01-01), ANKLAV TALUKA - BECHARAJI, DIST.-MEHSANA. -
SARDAR PATEL RING ROAD, VASTRAL,
BEHIND ADANAL PUMP, ,NEAR MAKARBA 360. KATARIA AUTOMOBILES (SEO1-SEO-01), 384210
AHMEDABAD - 382418
CROSSING, MAKARBA,SG HIGHWAY - 380051 AMBICA COMPLEX, GROUND FLOOR SHOP NO. PH :9909043244.
PH :7623089000.
PH :7069054900. B, C AND D, ASODAR CHOKDI, TAL. ASODAR, BHABHAR
CITY ANKLAV, DIST. ANAND, PIN-388510,
GUJARAT - 388510
PH :7227917151.

20
Dealer Workshop (AS ON 31.05.2023 )
370. STARLINE CARS (CWD1-CWD-01), SHOP NO. 7, 380. KATARIA AUTOMOBILES (AP03-AP-19), PLOT DABHOI 398. TANU MOTORS PVT. LTD. (CQ02-CQ-01),
8 ,9, SIDDHI VINAYAK BUSINESS HUB, R.S. NO. NO.13, SURVEY NO 33,34, AND 35 PAIKKI SURVEY NO. 722, OPPOSITE RANI RUDY
389. KATARIA AUTOMOBILES PVT. LTD.
225, PANJRAPOLE ROAD, BHABAR, DIS. VILLAGE, HADADAD, OPP. PATEL HYUNDAI MATAJI MANDIR, DHOLKA KALIKUND HIGHWAY,
(UU01-UU-01), OPP. VEGA BUS STOP, NEAR
-BANASKANTHA, GUJARAT. - 385320 SHOWROOM, PALIYAD BOTAD ROAD - 364710 DHOLKA, GUJARAT - 382 225
VEGA CROSS ROAD, DABHOI-BODELI ROAD,
PH :9909043244, 9824601729. PH :9558060658. PH :9512009104.
DABHOI, TA:DABHOI, DI:VADODARA - 391110
BHACHAU CHANASMA PH :8156000463. DHORAJI
371. K.D. MOTORS (P501-JP-02), SUNRISE 381. STARLINE CARS (CVF1-CVF-01), 16/17, PASABHI DAHOD 399. PERFECT AUTO SERVICE (5502-DL-09), JETPUR
MALL,OPP. BUS STAND,BHACHAU BHUJ ROAD, COMPLEX, NEAR ROYAL PALACE HOTEL, ROAD, OPP. SHRINATHJI SOCIETY, DHORAJI - -
390. R B CARS PVT. LTD. (2C01-PL-02), NEAR
BHACHAU, GUJARAT - 370140 MEHSANA HIGHWAY, CHANASMA. - 384220 360410
SIMANDHAR JAIN TEMPLE, OLD INDORE
PH :9909953036, 9879390919. PH :9909043244, 9824601729. PH :9099027402, 8200969617.
HIGHWAY,DAHOD - 389151
BHANVAD CHANDKHEDA - AHMEDABAD PH :9099043715, 9727700823. DHRANGADHRA
372. ATUL MOTORS JAM LLP (BND2-BND-01), R.S. 382. KATARIA AUTOMOBILES PVT. LTD. (0104-01-10), DEESA 400. DREAM VEHICLES PVT LTD (IM01-IM-01), PLOT
NO.439, PLOT NO.19, BHANVAD (GUJARAT) - SURVEY NO. 247, TP NO. 73, OPP. PAVITRA NO. 79, SURENDRANAGAR- DHRANGADHRA
391. TANU MOTORS PVT. LTD. (Q801-UQ-03), NH-14,
360510 ENCLAVE, MANSAROVER ROAD, NEAR HARI ROAD, OPP. ARMY WORKSHOP,
NR. ESSAR PETROL PUMP, RADHANPUR
PH :9574005964 / 9574004714. OM FARM, TRAGAD, CHANDKHEDA, DISTRICT-SURENDRANAGAR. - 363310
HIGHWAY, HANUMAN NAGAR, MALGADH,
BHARUCH AHMEDABAD. - 382470 PH :9227775725.
DEESA - 385535
PH :9723302111. DIYODAR
373. RAVIRATNA MOTORS (F801-F8-01), NH 8, OPP PH :9909006099.
YOGI PETROL PUMP,P.O. CHANDRALA 401. TANU MOTORS (SFU1-SFU-01), NR.HP PETROL
DEHGAM
ZADESHWAR,BHARUCH - 392011 383. NANDA AUTOMOBILES PVT. LTD. PUMP, BHESANA CROSS ROAD, BHABHAR
392. NANDA AUTOMOBILES PVT. LTD. (2B01-NR-03),
PH :9687691044; 9687632647. (GLT1-GLT-01), HIMMATNAGAR HIGHWAY NO.8, HIGWAY,DIYODAR-385330 - 385330
NEAR UMIYA MATAJI TEMPLE,COLLEGE
BHAVNAGAR NEAR DEVANSHI PARTY PLOT, CHANDRALA, PH :#REF!.
ROAD,AHMEDABAD ROAD, DEHGAM - 382305
DIST- GANDHINAGAR, GUJARAT - 382320 DWARKA
374. KATARIA AUTOMOBILES (C902-C9-01), SURVEY PH :234567.
PH :9725062187, 9727726003.
NO 137/2, PLOT NO 301/2&3 AND 301/4&5, DETROJ 402. ATUL MOTORS JAM LLP (CJG2-CJG-01),
VERTEJ GIDC, NARI CHOWKDI, RAJKOT ROAD, CHANGODAR SURVEY NO. 41, NEAR, SHRI SANTAN SEVA
393. PEGASUS (A UNIT OF VISUAL AUTOLINK PVT
BHAVNAGAR. - 364004 384. PEGASUS (A UNIT OF VISUAL MOTORS PVT. MANDAL, CORNER PLOT OF STATION ROAD
LTD) (GLC1-GLC-01), PLOT NO-61,MILKAT
PH :9426168286. LTD.) (CTD2-CTD-01), SURVEY NO.393, VILLAGE AND HIGHWAY ROAD, DWARKA, DISTRICT –
NO-2534,
375. KATARIA AUTOMOBILES (C902-C9-02), PLOT – MORAIYA, CHANGODAR, TALUKA – SANAND, DWARKA – . - 361335
AT-DETROJ,TALUKA-DETROJ-RAMPURA-382120
NO-29, NR. TALAJA OCTROI CIRCLE, SUN DISTT - AHEMADABAD. - 382210 PH :9712212900 / 9574004714.
- 382120
JAKATNAKA, AT-ADHEWADA, PH :7211120014. GANDHIDHAM
PH :#REF!.
DIST-BHAVNAGAR, GUJARAT – 364002. - 364002 CHIKHLI
DEVGADH BARIA 403. B M AUTOLINK (7702-77-01), EAST OF PLOT NO.
PH :9638884422.
385. KATARIA AUTOMOBILES PVT. LTD. 30-35,NATIONAL HIGHWAY, GANDHIDHAM -
BHUJ (BCB1-BCB-01), SURVEY NO.461,
394. R B CARS PVT. LTD. (2C01-AOA-05), BESIDE
370201
ARIHANT PETROL PUMP, PIPLOD ROAD,
376. K.D. MOTORS (P501-P5-01), PLOT NO. VILLAGE-MAJIGAM, TALUKA-CHIKHALI, PH :9727725723.
DEVGADH BARIA - 389380
5/6/14,UMANAGAR,MIRZAPUR HIGHWAY ROAD , DISTT-NAVSARI, GUJARAT - 396521 404. B M AUTOLINK (7702-77-03), SURVEY NO.129/26
PH :9099049344, 6352384846, 9099043715.
BHUJ,GUJARAT - 370001 PH :7698953899. P, GALPADAR HIGHWAY, GANDHIDHAM ,
PH :02832-232534/5, 9879898799, 8780351870. CHILODA DHANERA DISTT.KACHCHH, GUJARAT. - 370110
377. K.D. MOTORS (P501-P5-03), R.S NO. 25/2, 25/3, 395. TANU MOTORS PVT. LTD. (BZW1-BZW-01), 01 & PH :9727725723, 9727739550.
386. PEGASUS (A UNIT OF VISUAL AUTOLINK PVT.
26/2, PLOT NO. 57 TO 61, VILLAGE - MIRZAPUR, 02, MARUTI NANDAN COMPLEX, NEAR ESSAR GANDHINAGAR
LTD.) (GJO1-GJO-01), PLOT NO. 332, BESIDES
TALUKA - BHUJ, GUJARAT. - 370001 PETROL PUMP, DHANERA-DEESA HIGHWAY,
GALLOPS TATA, NH-8, 405. NANDA AUTOMOBILES PVT. LTD. (2B01-2B-01),
PH :9909953124. DHANERA. - 385310
CHILODA-HIMMATNAGAR HIGHWAY, CHILODA. 1003,SECTOR-28,GANDHI NAGAR - 382028
BODELI - 382355
PH :9909006099, 8401784018.
PH :(079)23212692 / 93 / 94.
378. KIRAN MOTORS LTD (0R01-0R-01), PH :7211168938, 7623039000. DHARAMPUR 406. NANDA AUTOMOBILES PVT. LTD. (2B01-2B-05),
OPP.NARMADA GUEST HOUSE,DABHOI ROAD, CHOTILA 396. KATARIA AUTOMOBILES PVT. LTD. PLOT NO. 805, GIDC, SECTOR-28,
BODELI, TALUKA: SANKHEDA,VADODARA - (BSK1-BSK-01), SURVEY NO.29/3/P1, VILLAGE GANDHINAGAR. - 382028
387. DREAM VEHICLES PVT LTD (CFI1-CFI-01),
391135 ASHURA NR. ASHURA CIRCALE, DHARAMPUR PH :079-23212692/93/94
SURVEY NO. 31, PLOT NO. 1, NILKANTH
PH :9714592999. DISTT. VALSHAD, GUJARAT - 396050 9727726003.
SOCIETY, NH NO. 8A, AHMEDABAD-RAJKOT, AT
BORSAD & PO – CHOTILA, DISTRICT –
PH :9723455291. GODHRA
379. AMAR CARS PVT. LTD. (BJM1-BJM-01), BORSAD SURENDRANAGAR, GUJARAT. - 363520 DHARI 407. R B CARS PVT. LTD. (2C01-2C-01), PLOT NO.
– TARAPUR HIGHWAY, BORSAD , DISTRICT – PH :9227775709. 397. ALPHA AUTOLINK LLP (GG02-GG-01), PLOT NO. 112/11.,12-VAVDI,GODARA - DAHOD HIGHWAY,
ANAND, GUJARAT - 388540 CHUDA 9, DHARI - KHAMBHA ROAD, NEAR RAILWAY GODHRA, PANCHMAHAL, GUJARAT - 389001
PH :9586477744. FATAK DHARI , TALUKA - DHARI, DIST. - PH :9099043715, 9727700823.
388. DREAM AUTOMOBILES (SOC1-SOC-01), NR.
BOTAD AMRELI, GUJARAT. - 365640 408. R B CARS PVT. LTD. (2C01-2C-04), SURVEY
GOVT HOSPITAL,CHATARLIYA
PH :9904549999/9978938858. NO.107, LUNAWADA ROAD, GIDC, GODHRA,
ROAD,CHUDA,SURENDRANAGAR. - 363410
DHOLKA DISTT. PANCHMAHAL-389001. - 389001
PH :9313802500.
PH :9099043715, 9727700823.

21
Dealer Workshop (AS ON 31.05.2023 )

GONDAL 419. ATUL MOTORS PVT LTD (5503-OB-09), SURVEY KESHOD LUNAWADA
NO. 1253, PLOT NO. 4, NEAR KALYAN PETROL
409. ATUL MOTORS PVT LTD (5503-AD-05), 8-B 429. PERFECT AUTO SERVICES (BZY1-BZY-01), R S 438. R B CARS PVT. LTD. (BYN1-BYN-01), SURVEY
PUMP, JASDAN-ATKOT HIGHWAY, JASDAN,
NATIONAL HIGHWAY, OPP. DAULAT OIL MILL, NO. 125/1, GODOWN NO. 01, SONDARDA, NO.90, AT-BHAYASAR, GODHRA-LUNAWADA
DIST.-RAJKOT, GUJARAT. - 360050
NR. NILKANTH VIRUDASHRAM, RAJKOT TALUKA – KESHOD, DISTRICT – JUNAGADH, HIGHWAY, LUNAWADA , TALUK-LUNAWADA,
PH :9265404142.
HIGHWAY,GONDAL - 360311 GUJARAT. - 362220 DISTT-MAHISAGAR, GUJARAT. - 389230
PH :9904922333. JHALOD PH :7043999073. PH :9099043715, 9727700823.
GOZARIA 420. R B CARS PVT. LTD. (CJF1-CJF-01), SURVEY KHAMBHAT MAHUVA (BHAVNAGAR)
NO. 2550B/10, 11, AT - JHALOD, TALUKA-
410. VIMCO MOTORS PVT. LTD. (GJN1-GJN-01), 430. AMAR CARS PVT. LTD. (BNF1-BNF-01), PLOT 439. KATARIA AUTOMOBILES (IV03-IV-01), V.P.
JHALOD, DISTRICT - DAHOD. - 389170
1597/339 P4 VISHNAGAR-GOZARIYA ROAD, NO. 7/8/9, RAJMAHAL PARK, OPP. SARDAR COMPLEX, BUNDER RD, NR. GAUSHALA,
PH :9099684363, 9099043715.
GOZARIYA, DIST.-MEHSANA. - 382825 CHATRALAY, LAL DARWAJA, GAYATRINAGAR BARPARA,
PH :7016623842. JUNAGADH ROAD, KHAMBHAT, TALUKA KHAMBHAT, MAHUVA, GUJARAT 364290. - 364290
HALOL 421. PERFECT AUTO SERVICES (5502-K8-06), ANAND DISTRICT, GUJARAT - 388620 PH :6357327534.
SURVEY NO.45/1, PLOT NO. 214-C/D/E/F, GIDC-I, PH :9909960772. MANAVADAR
411. R B CARS PVT. LTD. (BKC1-BKC-01), PLOT NO.
DOLATPARA, JUNAGADH - 362001 KHEDA
104/6 & 104/8, VADODARA – GODHRA 440. PERFECT AUTO SERVICE (CUI1-CUI-01), RS NO.
PH :9879518052, 7043999073, 9909022618.
HIGHWAY, NEAR NAVJIVAN HOTEL, HALOL, 431. AMAR CARS PVT. LTD. (BNA1-BNA-01), 13/1, 14, PLOT NO. 48, BHAKTINAGAR, TALUKA -
DISTRICT – PANCHMAHAL, GUJARAT - 389350 JUNAGARH S.NO.708, PLOT NO.1, VILLAGE-SOKHDA, TAL: MANAVADAR, DIST.-JUNAGADH. - 362 630
PH :9099043715, 9727700823. 422. PERFECT AUTO SERVICES (5502-K8-02), PLOT MATER, DISTT. KHEDA, GUJARAT - 387570 PH :7043999073.
HALVAD NO. 81-82,G.I.D.C. PH :9909960761. MANDAL
DOLATPURA,RAJKOT-JUNAGARH HIGHWAY, KHERALU
412. DREAM VEHICLES PVT LTD (GX01-GX-01), PLOT 441. KIRAN MOTORS LTD (IW01-IW-01), SURVEY NO.
JUNAGARH - 362001
NO.5 & 6, NAKLANKDHAM TOWNSHIP, OPP. 432. STARLINE CARS (SN02-SN-01), R S NO. 4962 708, MANDAL - DETROJ HIGHWAY, NR.
PH :9909006980, 7043999073, 9909022618.
HONEST RESTAURANT, AHMEDABAD MAHAVIR COMPLEX, KHERALU, DIST. RELIANCE PETROL PUMP, MANDAL , DI:
HIGHWAY, HALVAD DISTT. SURENDRANAGAR KADI -MEHSANA. - 384325 AHMEDABAD, GUJARAT. - 382130
(GUJARAT) - 363330 423. STARLINE CARS PVT. LTD. (D101-UR-07), OPP. PH :9909043244, 9824601729. PH :9408803925.
PH :8238000965. COTTON MARKETING YARD, KADI-CHATRAL KIM MANDVI
HANSOT ROAD, TAL: KADI, DIST: MEHSANA - 382715
433. KATARIA AUTOMOBILES PVT. LTD. 442. K.D. MOTORS (UY01-UY-01), PLOT NO.25,26 &
PH :8160707156.
413. RAVIRATNA MOTORS (BGQ1-BGQ-01), AT (UW01-UW-01), PLOT NO. 116-121, DAL MILL 27, RAJ COMMERCIAL, SURVEY NO.246, NEAR
UTRAJ, HANSOT, DISTRICT - BHARUCH. - KAKANPUR COMPOUND, OPP. SURAT JILLA SANGH, KIM “THE BEACH RESORT”, MANDVI NALIYA ROAD,
393030 424. RB CARS (SDN1-SDN-01), SURVEY NO.618/2, CROSS ROAD, NH-8, KIM - 394110 MANDVI-KUTCH - 370465
PH :9687691063. PAIKI PLOT NO. 29,30,31 AT. KAKANPUR, TAL. PH :9723555185. PH :9909953088, 9825353679.
HIMMATNAGAR GODHRA, DISTRICT. PANCHMAHAL PIN-388713. KODINAR MANGROL
- 388713
414. KIRAN MOTORS LTD (P601-P6-01), NEAR 434. PERFECT AUTO SERVICES (A DIVISION OF 443. KATARIA AUTOMOBILES PVT. LTD.
PH :9099049347.
G.I.D.C,MOTIPURA, HIMMATNAGAR - 383001 PERFECT RETREADS PVT LTD) (CSO1-CSO-01), (CAH1-CAH-01), PLOT NO. 12-28, MOSALI,
PH :9824576711. KALOL R.S.NO.222, PLOT NO.2, 3 SHOPS, MANGROL, DISTRICT-SURAT. - 394410
IDER 425. NANDA AUTOMOBILES PVT. LTD. (2B01-FW-02), KODINAR-362720 DISTT. JUNAGADH, GUJARAT PH :6357071775.
PLOT NO.- 162-168, GIDC,KALOL MEHSANA - 362720 MANSA
415. KIRAN MOTORS LTD (UX01-UX-01), SURVEY
HIGHWAY, NEAR CHIRAG CINEMA ROAD, PH :7043992893, 7043340792.
NO.69 IDAR-AMBAJI ROAD, IDAR DIST: 444. NANDA AUTOMOBILES PVT. LTD. (2B01-0L-04),
KALOL. - 383028 KUKARWADA
SABARKANTHA - 383430 OPP. GIDC, VISNAGAR ROAD, MANSA,
PH :220781 / 82 / 83.
PH :8155994111. 435. STARLINE CARS PVT. LTD (CSC1-CSC-01), DISTRICT-GANDHINAGAR, GUJARAT - 382845
KAPADVANJ SHOP NO.1741, 1742 AND PLOT NO.1752, PH :9727921000.
JAMNAGAR
426. AMAR CARS PVT. LTD. (NC01-NC-01), SAMARTH KUKARWADA TALUKA, VIJAPUR, DISTT MEHMDABAD
416. ATUL MOTORS JAM LLP (F402-F4-01), SURVEY
SQUARE, SHOP NO. 1, MODASA KAPADWANJ MAHESANA (GUJARAT) - 382830
NO.422, PLOT NO. 16,17 & 19, JAMNAGAR, 445. AMAR CARS PVT. LTD. (BRA1-BRA-01), PATEL
ROAD, KAPADVANJ, GUJARAT-387620 - 387620 PH :9909043244, 9824601729.
GUJARAT - 361001 FALIYA, KHATRAJ, MEHMEDABAD, DIST.
PH :9909960761. LAVANA
PH :9574004710 / 9574004716. -KHEDA, GUJARAT. - 387130
417. STARLINE CARS PVT. LTD. (D101-Q9-02), KARJAN 436. RB MOTORS (SLW1-SLW-01), AT PO -LAVANA, PH :9909960761.
CHANASMA HIGHWAY, PATAN - 384265 427. AMAR CARS PVT. LTD. (UZ01-UZ-01), SURVEY NEAR BABILIYA CROSSING, MODASA ROAD, MEHSANA
PH :7046046187. NO.851/787 BESIDE PMT TOOLS, KANDARI, N.H. LAVANA-389230 - 389230
446. STARLINE CARS PVT. LTD. (D101-D1-01),
418. ATUL MOTORS JAM LLP (F402-F4-02), C-36, MP -8, KARJAN, DISTT-VADODRARA (GUJARAT) - PH :9860999470.
NAGALPUR HIGHWAY,MAHESANA , GUJRAT -
SHAH ARUN UDYOG, SARUSECTION ROAD, 391210 LIMBDI 384002
JAMNAGAR - 361002 PH :7567299666/99252462929.
437. DREAM VEHICLES PVT LTD (BSG1-BSG-01), PH :9909043635.
PH :9574004704 / 9574004717. KATHLAL SURVEY NO.276/1, NEAR PANCHVATI HOTEL, 447. TANU MOTORS PVT. LTD. (Q801-D1-04),
JASDAN 428. AMAR CARS PVT. LTD. (CXA1-CXA-01), LIMDI CROSS ROAD, AHMEDABAD-RAJKOT SURVEY NO.78, NEAR SUNRISE AUTOMOBILES
MAHAVEER AUTO SHOWROOM, NADIAD ROAD, HIGHWAY, LIMDI, DISTT. SURENDRANAGAR, (AMW DEALER), GUJARAT STATE HIGHWAY
JB PLAZA, KATHLAL, GUJARAT. - 387 630 GUJARAT. - 363421 NO.41, MEHSANA - 384002
PH :9909960761. PH :02753-261262/ 9227775728. PH :9909006076.

22
Dealer Workshop (AS ON 31.05.2023 )
448. VIMCO MOTORS PVT. LTD. (D103-D1-01), NANA PONDHA 467. KATARIA AUTOMOBILES (CSD2-CSD-01), PLOT 476. ATUL MOTORS PVT LTD (5503-55-01), PLOT
SURVEY NO. 104 & 104 PAIKI 1, AT P.O. - NO 15, YASOVIJAYNAGAR, NEAR RAILWAY NO.49/1 & 2, GIDC, BHAKTI NAGAR INDUSTRIAL
458. AMAR CAR (SEL1-SEL-01), SHOP NO 7-11,
PALAVASANA, MEHSANNA, GUJARAT. - 384 002 CROSSING, PALITANA HIGHWAY, ESTATE, RAJKOT. - 360002
JALASHAI SHOPPING CENTER, AT-NANA
PH :8909953333. PALITANA-364270 DIST BHAVNAGAR. - 364270 PH :8140909093.
PONDHA, TALUKA- KAPRADA, DIST-VALSAD -
METODA PH :#REF!. 477. PERFECT AUTO SERVICES (5502-55-04), 150
396126
PALSANA RING ROAD,OPP. GANDHIGRAM POLICE
449. ATUL MOTORS PVT LTD (5503-BLW-08), PLOT PH :7227971155.
CHOWKI,RAJKOT - 360005
NO. 2328, GATE NO. 2, METODA GIDC, NASWADI 468. KATARIA AUTOMOBILES PVT. LTD.
PH :9925238691, 9925117104.
METODA, TALUKA LODHIKA, DISTRICT - (4004-ZF-07), BESIDE SAINATH COMPLEX,
459. RAVIRATNA MOTORS (SCV1-SCV-01), HOUSE 478. ATUL MOTORS PVT LTD (5503-55-02), BEHIND
RAJKOT, GUJARAT - 360021 KADODARA AHMEDABAD ROAD , NH-8,
NO-301,302,303, IN VALPURA-RAMLALNAGAR, HP PUMP,UNIVERSITY ROAD ,NEAR SNK
PH :8140909095, 9924688774. UMBHEL GAM,TALUKA: PALSANA KADODARA,
VILLAGE AT-NASWADI, DIST: CHOTTA UDEPUR SCHOOL, RAJKOT - 360005
MODASA SURAT. - 382721
- 391150 PH :8347005382.
PH :9924446895.
450. KIRAN MOTORS LTD (P601-CR-02), SHAMLAL JI PH :9687691047. 479. ATUL MOTORS PVT LTD (5503-55-06), RAJKOT
ROAD,SABARKANTHA DIST., MODASA - 383315 PATDI AHMEDABAD HIGHWAY, NR. CHANDARANA
NAVSARI
PH :8155995111. 469. DREAM VEHICLES PVT LTD (BFS1-BFS-01), R.S. PETROL PUMP, OPP. GUJARAT SAMACHAR
460. KATARIA AUTOMOBILES PVT. LTD. PRESS, AT. NAVAGAM RAJKOT - 360003
MORBI NO.1614/2, PLOT NO.16, PATDI TALUKA
(Q701-Q7-01), PLOT NO.-891, OPP PAUVA MILL, PH :9924688774.
DASADA, DISTT. SURENDRANAGAR, GUJARAT -
451. PERFECT AUTO SERVICES (5502-X5-07), NH-8,NEAR GANESH SISODRA 480. PERFECT AUTO SERVICES (5502-55-08), R.S.
382765
SURVEY NO. 351/2, PLOT NO. 10, DHARTI CHOKDI,GANESH SISODIA NAVSARI, GUJRAT - NO. 50/1, 150 FEET RING ROAD, RAIL NAGAR,
PH :9227775709.
INDUSTRIAL AREA, RAJPURA ROAD, SANALA, 396463 RONKI, RAJKOT, GUJARAT. - 360006
MORBI , TEHSIL-MORBI, DISTT.-MORBI, PH :9723430012. PAVI JETPUR
PH :9979861995, 9925117104.
GUJARAT. - 363641 NETRANG 470. PERFECT AUTO SERVICES (PK01-PK-01), NEAR 481. KATARIA AUTOMOBILES PVT. LTD. (5504-55-01),
PH :9099058044, 9925199569, 9879499088. ANKUR HOTEL, OPP. DHARESHWAR GEB S. NO. 10/1, TPS NO. – 10, KALAVAD ROAD,
461. RAVIRATNA MOTORS (CUZ1-CUZ-01), SURVEY
452. DREAM VEHICLES (LC01-X5-03), NR. PRIME STATION, PITHADIA, RAJKOT HIGHWAY, MOTAMAVA, RAJKOT, GUJARAT. - 360001
NO. 184, PLOT NO. 1 & 2, VILLAGE - NETRANG,
FILLINGS, PLOT-6 ,DHARMASIDDHI JETPUR (GUJARAT). - 360370 PH :7573870001.
TALUKA - VALIA, DIST.-BHARUCH. - 393130
VILLAGE:MAHENDRANAGAR, TALUKA: MORBI, PH :9099027402, 8200969617.
PH :9687691063. RAJPARDI
DIST:MORBI. - 363642 PETLAD
PH :7069089532. OLPAD 482. RAVIRATNA MOTORS PVT. LTD. (CAI1-CAI-01),
471. AMAR CARS PVT. LTD. (CMW1-CMW-01), R.S.NO.973, CTS NO. 1298, SHOPS PLOT NO.29
MOTI KHAVADI 462. COMET CAR SALES & SERVICE PVT LTD
SURVEY NO. 396/2, RANGAIPUR VILLAGE,
(4006-ZZ-02), 1906/1907, OPP. KUMBHARVAD, & 30, MOJE RAJPARDI, TALUKA-JHAGADIA,
453. ATUL MOTORS JAM LLP (AAU2-AAU-01), PLOT PETLAD, DIST.-ANAND. - 388450 DISTT. BHARUCH - 393115
JUNA PURA, OLPAD - 394540
NO.22 & 29, NEAR PADANA POLICE STATION, PH :9099017068. PH :9687691044; 9687632647.
PH :9099916099.
JAMNAGAR-KHAMBHALIYA HIGHWAY, MOTI PORBANDAR
PADRA RAJPIPLA
KHAVDI, ZANKHAR, TA: LALPUR, DIST -
472. ATUL MOTORS JAM LLP (T601-T6-01), PLOT NO. 483. RAVIRATNA MOTORS PVT. LTD. (9X01-9X-01),
JAMNAGAR, GUJARAT. - 361140 463. AMAR CARS PVT. LTD. (2205-OC-02), NEAR
208, GIDC VANANA, NATIONAL HIGHWAY , OPP. JALARAM SAW MILL, NEAR HARSIDDHI
PH :9574004709 / 9574004743. WESTERN BYPASS, AT SAMIYALA, PADRA,
PORBANDAR, DIST. PORBANDAR GUJARAT - MATAJI TEMPLE, RAJPIPLA, DIST: NARMADA,
MUNDRA DIST. – VADODARA, GUJARAT - 391440
360577
PH :8980036200, 8980006795. GUJARAT - 393145
454. B M AUTOLINK (7702-AJ-02), PRAGPAR PH :9574004746 / 7228819123. PH :9687691062/9687645880.
ROAD,MUNDRA,DISTRICT-KUTCH, GUJARAT, - PALANPUR PRANTIJ RAPAR
370421 464. TANU MOTORS (Q801-Q8-01), OPP.DHARTI
473. KIRAN MOTORS LTD (AAI1-AAI-01), NO.6/P, 484. B.M. AUTOLINK (SCO1-SCO-01), PARAGPAR
PH :9687632631, 9978940978. RESORT, ABU- AHMEDABAD HIGHWAY,
OPP. VEGETABLE MARKET, PRANTIJ CHAAR RASTA RAPAR GHANDHIDHAM KUTCH -
NADIAD PALANPUR - 385001
HIGHWAY, VILLAGE-KHAMALPUR,
PH :9099017756. 370165
455. AMAR CARS PVT. LTD. (F702-P7-02), NEAR TALUKA-PRANTIJ, DISTT. SABARKANTHA, PH :9727725723.
465. STARLINE CARS PVT. LTD. (D101-Q8-08),
RAJHANS MULTIPLEX,NADIAD-UTTARSANDA GUJARAT - 383205
SURVEY NO.4 & 5/2, OPPOSITE L K PETROL SAMI
ROAD - 387370 PH :9624401888.
PUMP, PALANPUR-DEESA HIGHWAY, 485. STARLINE CARS (BNH1-BNH-01), SHOP NO.
PH :9909960761. RADHANPUR
PALANPUR-385001, DISTT BANASKANTHA, 55-56, AMBESHWAR PLAZA, SAMI-HARIJ ROAD.
NAKHATARANA GUJARAT - 385001 474. STARLINE CARS PVT. LTD. (BNI1-BNI-01), - 384240
456. KD MOTORS (CMV1-CMV-01), PLOT NO-1, RS PH :9824601793. SURVEY NO. 208/A, MOUJA – RADHANPUR, PH :9909043244, 9824601729.
NO-19, AT-NANA ANGIYA, PALEJ RADHANPUR MAIN ROAD, DISTRICT – PATAN,
SANTEJ
TALUKA-NAKHATRANA, KUTCH - 370615 GUJARAT. - 385340
466. RAVIRATNA MOTORS (BGR1-BGR-01), PLOT 486. NANDA AUTOMOBILES PVT. LTD.
PH :#REF!. PH :9909043244, 9824601729.
NO. 626/6, GIDC AREA, PALEJ, DISTRICT - (CXC1-CXC-01), SUB PLOT NO. 05, SHOP NO. 3
NALIYA BHARUCH - 392220 RAJKOT
& 4, BLOCK NO. 1162, SANTEJ, KALOL. - 380060
457. KD MOTORS (SLX1-SLX-01), AT PO - SHAKTI PH :9687691044; 9687632647. 475. PERFECT AUTO SERVICES (5502-55-01), PH :9727822000.
SOCIETY, MAHAVIR NAGAR, PLOT(1), OPP. PALITANA PERFECT HOUSE,GONDAL
SANTRAMPUR
BANK OF BARODA, NALIYA, TAL-ABDASA, ROAD,VANDI,RAJKOT - 360004
KUTCH. - 370655 PH :9879499077, 9909006982, 9825304940.
PH :9909953119.

23
Dealer Workshop (AS ON 31.05.2023 )
487. R B CARS PVT. LTD. (2C01-RY-03), NEAR PTC 496. COMET CAR SALES & SERVICE PVT LTD 508. COMET CAR SALES & SERVICE PVT LTD 518. KATARIA AUTOMOBILES PVT. LTD.
COLLEGE, SANT ROAD, SANTRAMPUR,DISTT.- (CWE1-CWE-01), LAXMI PLAZA, SHOP NO. 21 & (4006-40-03), R. S. NO. 311, T. P. SCHEME-3, (BNB1-BNB-01), PLOT NO. 239, LORD COMPLEX,
PANCHMAHAL - 389260 22, SURAT DHULIYA HIGHWAY, TALUKA - FINAL PLOT NO. 102/A, KATARGAM, SURAT, SHOP NO. B-9 AND B-10, UMERGAON, DISTRICT
PH :8980585851, 9099043715. SONGADH, DIST.-TAPI. - 384220 DISTRICT – SURAT, GUJARAT. - 395004 – VALSAD, GUJARAT. - 396170
SAVLI PH :9099916099. PH :9099916099. PH :9624001794.
SUPEDI 509. DHRU MOTORS (4002-40-03), PLOT NO.54/A, UMRETH
488. KIRAN MOTORS LTD (CFD1-CFD-01), SURVEY
LAXMINARAYAN LNDUSTRIAL ESTATE, UDHNA,
NO. 2592/1 PAKKI 2, NEAR RELIANCE PETROL 497. KATARIA AUTOMOBILES (SEM1-SEM-01), 519. AMAR CARS PVT. LTD. (CFE1-CFE-01), R. S. NO.
SURAT-394210 - 394210
PUMP, BHADRVA CHOWKDI, SAVLI – TIMBA SURVEY NO-482/7, PAIKI PLOT NO-18, 30/2, NADIAD-DAKOR ROAD, UMRETH ,
PH :#REF!.
ROAD, SAVIL, TALUK – SAVLI, DISTRICT – MATRAVAD ROAD, GRAM-SUPEDI, DIST - DIST.ANAND, GUJARAT. - 388220
VADODARA, GUJARAT. - 391770 RAJKOT - 360440 SURENDERNAGAR PH :9909960772.
PH :7984799054. PH :9409497902. 510. DREAM VEHICLES PVT LTD (LC01-LC-01), 261/P, UNA
SAYAN SURAT OPP MARKETING YARD,GIDC AREA,WADHWAN
520. PERFECT AUTO SERVICES (BFD1-BFD-01),
CITY, SURENDERNAGAR - 363030
489. KIRAN MOTORS LTD (OO01-OO-01), PLOT NO.6 498. KIRAN MOTORS LTD (4001-40-01), SURVEY NO. 113, PLOT NO. 6, OPP. SWAMI
PH :02752-241314 / 02752-651516/ 9227775721.
TO 10 OF R BLOCK, SURVEY NO.209, VILLAGE SURAT-BARDOLI ROAD,DUMBHAL,NEAR PUNA VIVEKANAND VIDYALAYA, NEAR BANSIDHAR
511. DREAM VEHICLES (LC01-LC-02), PLOT
PARIA, TALUKA: OLPAD, SAYAN - 394130 JAKAT NAKA,SURAT - 395010 PETROL PUMP, BHAVNAGAR HIGHWAY,
NO-504/B, GIDC PHASE-3, WADHWAN,
PH :8155888862/9662330480. PH :9924448715/9924637898. VAYAJPUR, UNA, DISTRICT – GIR SOMNATH,
SURENDRANAGAR, GUJARAT-363030 - 363030
SAYLA 499. DHRU MOTORS (4002-40-01), JEEVAN GANGA GUJARAT. - 362560
PH :9227775724.
NAGAR,NEAR JEEVAN JYOT THEATRE,UDHNA PH :7043992893, 7043340792.
490. DREAM VEHICLES (SJM1-SJM-01), LALGURU
MAIN ROAD,SURAT - 394210 TALAJA
COMPLEX, SUDAMDA ROAD, SAYLA, DISTRICT UNJHA
PH :9925155911/9925155907. 512. KATARIA (BCI2-BCI-01), SURVEY NO-168,
SURENDRANAGAR, GUJARAT PIN 363430 - 521. TANU MOTORS (Q801-GR-02), OPP. DHANA DAL
500. KIRAN MOTORS LTD (4001-40-02), DHANJIBHAI BALADHIYA NI VADI, NEAR
363430 FACTORY,MEHSANA PALANPUR HIGHWAY,
PANDESARA,BAMROLI ROAD,SURAT - 395002 MAHUVA PALITANA CROSS ROAD, MAHUVA
PH :9227775709. UNJHA - 384170
PH :9824603880. BHAVNAGAR HIGHWAY, TALAJA-364140. -
SHANKESHWAR PH :9727762079.
501. KATARIA AUTOMOBILES PVT. LTD. (4004-40-04), 364140
491. STARLINE CARS (SLY1-SLY-01), MANIBHADRA TP NO. 6, SURVEY NO. 317/2, FINAL PLOT NO. PH :9316626475. UPLETA
SHOPPING CENTRE, SHANKHESHWAR 39, OPP SMS GARDEN, NEAR VIP ROAD, VESU, TANKARA 522. PERFECT AUTO SERVICE (CH01-CH-01), S. NO.
HIGHWAY, SHANKHESHWAR (GUJARAT)- DIST: SURAT -395007 - 395007 184/1, PLOT NO. 15-16, UPLETA, GUJARAT - 360
513. ATUL MOTORS PVT LTD (BQY1-BQY-01), PLOT
PATAN - 384246 PH :9714612700, 9924401000. 490
NO. 8/1, S. NO. 107, VILLAGE – JABALPUR,
PH :9824601729. 502. DHRU MOTORS (4002-40-1B), 207, NEW PH :9099027402, 8200969617.
TALUKA – TANKARA, SUB DISTRICT – MORBI,
SHAPAR INDUSTRIAL ESTATE,ROAD NO.-6,UDHNA VADNAGAR
DISTRICT – RAJKOT. - 363650
UDYOG NAGAR, SURAT - 394210
492. ATUL MOTORS PVT LTD (BQZ1-BQZ-01), SHOP PH :9714008492, 9624711397. 523. VIMCO MOTORS PVT LTD (GKU1-GKU-01),
PH :0261-2272118/ 9978900862.
NO. 1 TO 4, SURVEY NO. 305/1, PLOT NO. 169, 503. KATARIA AUTOMOBILES PVT. LTD. (4004-40-05), TARAPUR SHILALEKH COMPLEX, BLOCK-D, SURVEY
SHAPAR, DISTRICT – RAJKOT, GUJARAT - KATARIA ARCADE,OPP. RAJHANS NO-2713, VADNAGAR-VISNAGAR HIGHWAY,
514. AMAR CARS PVT. LTD. (GH01-GH-01), NEAR N K
360024 CINEMA,DUMAS ROAD, PIPLOD, SURAT - NEAR FOOD PARADISE HOTEL, VADNAGAR,
STEEL, TARAPUR ROAD, TARAPUR, DIST.
PH :9714008492, 9624711397. 395007 GUJARAT - 385355
-ANAND. - 388180
SIDDHPUR PH :7698022449/9624477252. PH :7016623842.
PH :9909960772.
493. STARLINE CARS PVT. LTD. (CMY1-CMY-01), 504. COMET CAR SALES & SERVICE PVT LTD THARA VADODARA
PLOT NO. 140-1285/7, SIDHPUR, TALUKA – (4006-40-01), CHIKUWADI COMPLEX, GHB 524. KIRAN MOTORS LTD (2201-22-01),
ROAD, PANDESARA, SURAT. - 394221 515. TANU MOTORS PVT. LTD. (0V01-0V-01), SHOP
VADGAM, DISTRICT – PATAN. - 384151 909/4,G.I.D.C.MAKARPURA,VADODARA - 390010
PH :9099915995. NO.17 & 18, SIHORI HIGHWAY, R.B. THAKKAR
PH :9909043244, 9824601729. PH :9624472699.
505. KATARIA AUTOMOBILES PVT. LTD. (4004-40-08), COMPLEX, THARA, KAKREJ TALUKA,
SINOR 525. KIRAN MOTORS LTD (2201-22-02), PLOT
BLOCK NO.233, TP NO.8, OPP. SHREE LEKHA BANASKANTHA DISTT. - 385555
NO.160,SUB-I NUTAN GUJ.INDL.ESTATE,OLD
494. RAVIRATNA MOTORS PVT LTD (GML1-GML-01), RESIDENCY, PALANPORE, ADAJAN, SURAT - PH :9909006099, 9913830329.
CHHANI ROAD, VADODARA - 390002
NEAR SEVGA CHOKDI, SEVGA DABHOI ROAD, 394310 THARAD PH :9824207889.
AT AND POST SEGVA, TALUKA SINOR, DIST. PH :9924119020. 516. TANU MOTORS PVT. LTD. (CDM1-CDM-01), 526. AMAR CARS PVT. LTD. (2203-22-01), GORWA
VADODARA, PIN-391105, GUJARAT - 391105 506. KIRAN MOTORS LTD (4005-40-01), PLOT NO. PLOT NO. 21 & 22, VAJEGADH, DEESA ROAD,VARODARA,GUJARAT, - 390016
PH :7227055065. 443, FP NO. 26 MOJE PALGAM, ADAJAN, SURAT HIGHWAY, THARAD, DIST.-BANASKANTHA - PH :9081311990, 9723742425, 8980036184.
SITAPUR - 395009 384220 527. AMAR CARS PVT. LTD. (2203-22-02), KALA
495. PH :9824611153/9824701590. PH :9909006099, 9724219565. GHODA, OPP. KIRTI MANDIR, VADODARA, DIS:
STARLINE CARS PVT LTD (SFV1-SFV-01), SHOP
507. AMAR CARS PVT. LTD. (4009-40-02), PLOT VADODARA, GUJARAT - 390001
NO. 2, RUDRA ARCADE, REVENUE SURVEY NO. THASARA
NO.10&11, SURVEY NO.7 & 9, SONARAS PH :7211109952.
129, VITHLAPUR (SITAPUR) BECHARAJI –
COMPOUND, NEAR DGVCL OFFICE, KARMNATH 517. KATARIA AUTOMOBILES (SIM1-SIM-01), PLOT
VIRAMGAM HIGHWAY, DIST. AHMEDABAD, PIN 528. KATARIA AUTOMOBILES PVT. LTD. (2204-22-01),
MAHADEV TEMPLE LANE, KAPODARA, NO 1 & 2, GIDC THASRA, BESIDES NARMADA
CODE: 382120 - 382120 984/4,GIDC, OLD NH-8,MAKARPURA ROAD,
VARACHHA ROAD, SURAT - 395006 VASAHAT, DAKORE THASRA ROAD,
PH :9909043244. VADODARA, GUJARAT - 390010
PH :7069026512. GUJARAT-388250 - 388250
SONGADH PH :9904033422.
PH :7984092780.
UMERGAON

24
Dealer Workshop (AS ON 31.05.2023 )
529. AMAR CARS PVT. LTD. (2205-22-01), VARASIYA 539. PERFECT AUTO SERVICES (5502-AH-05), NR. 548. MODERN AUTOMOBILES (1801-18-02), NEAR 558. DINCO 4 WHEELS LLP (AUTO VIBES)
AIRPORT ROAD, OPP POONAM CINEMA, BALIYA HANUMAM,VERAVAL - JUNAGADH AMAR PALI RESTAURANT, G.T. ROAD, AMBALA (BBD2-BBD-01), KHATA NO. 326 AND KHATAUNI
KARELIBAUG, VADODARA,GUJARAT - 390016 HIGHWAY, JUNAGADH, GUJARAT - 362265 - 134003 NO. 362, OPPOSITE PRATHAM HOUSING, NH-8,
PH :8980006756. PH :9998994550, 9898121122. PH :9215016044. BAWAL, DISTRICT – REWARI, HARYANA . -
530. KIRAN MOTORS LTD (2201-22-03), C/O ARBUDA VIJAPUR 549. EAKANSH WHEELS (1802-18-01), STONE NO. 123501
COLD STORAGE, 823 POWER CABLE ROAD, 126, JAGADARI ROAD, VILLAGE TEPLA, PH :7082100250.
540. STARLINE CARS PVT. LTD. (D101-V2-04),
DHARMSINH ROAD, OPP. UMA AMAR PARTY AMBALA - 133001 BHIWANI
HIMMATNAGAR HIGHWAY, ANANDPURA CHAR
PLOT, NEAR CHHANI JAKAT NAKA, VADODARA PH :9991703000.
RASTA, VIJAPUR - 382870 559. JAGMOHAN MOTORS PVT LTD (X301-X3-01),
- 390002 550. EAKANSH WHEELS (1802-18-03), PLOT NO. 8,
PH :9909043635. DELHI ROHTAK ROAD, NEAR RADHA SWAMI
PH :2771122. BASANT VIHAR, BEHIND SWASTIK MARBLE,
VIRAMGAM SATSANG MANDIR, BHIWANI - 127021
531. KATARIA AUTOMOBILES PVT. LTD. (2204-22-02), NEAR MOTOR MARKET, AMBALA CITY,
PH :8685005592.
OPPOSITE SHARDA MANDIR HIGH SCHOOL, 541. KIRAN MOTORS LTD (AAB1-AAB-01), SURVEY HARYANA - 133001
VINOBA BHAVE ROAD, SALATWADA, NO.319/P, NILKI CHOKDI, VIRAMGAM, DISTT: PH :88813874888. BILASPUR
VADODARA - 390001 AHMEDABAD, GUJARAT. - 382150 551. TR SAWHNEY (1803-18-01), JAGGI GARDEN, 560. PANDIT AUTOMOBILES PVT. LTD.
PH :8156017770. PH :8156016222. BALDEV NAGAR, OPPOSITE AMBALA (BGH1-BGH-01), NEAR GRAMIN BANK,
532. RAVIRATNA MOTORS PVT LTD (2206-22-01), VISNAGAR PASSPORT OFFICE, AMBALA - 134003 JAGADHRI ROAD, BILASPUR, DISTRICT –
SURVEY NO. 1581, MILES HOUSE, ATLADARA PH :9990110068. YAMUNANAGAR, HARYANA. - 135102
ROAD, VADODARA. - 390012 542. STARLINE CARS PVT. LTD. (D101-RW-05),
ASSANDH PH :9992113854.
PH :7227055065, 7227055064. VISNAGAR -AMBAJI ROAD, OPP. DHAROI
COLONY, VISNAGAR, DISTT.- MEHSANA - 552. KARNAL MOTORS PVT. LTD. (8906-CS-04), OPP. BILASPUR (HARYANA)
VALOD NEW GRAIN MARKET, KARNAL ROAD
384315 561. PLATINUM MOTOCORP LLP (2L04-CIA-02),
533. DHRU MOTORS (CSW1-CSW-01), PLOT NO.5 TO PH :7046046174. ASSANDH, DISTT. KARNAL - 272032 KHASRA NO.54/67, CHOUDHARY NIHAL SINGH
9, TAIYABA PARK SOCIETY, AT & PO - VALOD, VYARA PH :7082111325. MARKET, BILASPUR CHOWK, NH-8, BILASPUR,
TALUKA - VALOD, DISTT. - TAPI, GUJARAT. - BABARPUR DISTRICT – GURUGRAM. - 122413
394640 543. COMET CAR SALES & SERVICE PVT LTD
PH :9953345329/9953345403.
(BIY1-BIY-01), SHOP NO. 11 & 12, BLOCK NO. 553. AUTO GALLERY(A UNIT OF RKH AUTOMOBILES
PH :9712984522. CHARKHI DADRI
175/1/A, RS NO. 113, VYARA-SURAT ROAD, P LTD) (CKX1-CKX-01), G.T. ROAD, NEAR PARK
VALSAD RESIDENCY, SHIMLA MAULANA, BADOLI,
VYARA, DISTRICT – TAPI, GUJARAT - 394650 562. JAGMOHAN MOTORS PVT LTD (X301-CT-02),
534. KATARIA AUTOMOBILES PVT. LTD. PH :9099916099. BABARPUR, DISTT. PANIPAT - 132103 BHIWANI LOHARU ROAD, CHARKHI DADRI,
(0104-2E-06), SURVEY NO. 211,ATUL-ALSAD WAGHODIA PH :7009396727. BHIWANI - 127306
ROAD,PARNERA,AVALSAD, GUJARAT - 396020 BAHADURGARH PH :8059900538.
PH :9904133306. 544. KATARIA AUTOMOBILES PVT. LTD.
(BZZ1-BZZ-01), OPPOSITE BHARAT 554. COMPETENT AUTOMOBILES CO. LTD. CHEEKA
VANSDA (2G02-2G-01), PLOT NO. 1202, MIE PART B,
PETROLEUM, WAGHODIA, TALUKA – 563. EAKANSH MOTORS PVT. LTD. (U802-HU-04),
535. KATARIA AUTOMOBILES PVT. LTD. WAGHODIA, DISTRICT – VADODARA, GUJARAT. BAHADURGARH, HARYANA - 124 507 MARBLE MARKET, PATIALA ROAD, CHEEKA,
(Q701-SB-02), JAMNABA PARK, VANSDA - 391760 PH :8929648144. HARYANA, - 136034
HANUMAN BARI CHAR RASTA, PH :7203013712. BAPOLI PH :8053086000.
VANSDA-DHARAMPUR ROAD, RANI FALIYA, WANKANER CHHACHHARAULI
555. AUTO GALLERY(A UNIT OF RKH AUTOMOBILES
VANSDA, DISTRICT – NAVSARI, GUJARAT -
545. ATUL MOTORS PVT LTD (BAL1-BAL-01), P LTD) (CWI1-CWI-01), KHEWAT NO. 136, 564. PANDIT AUTOMOBILES PVT. LTD.
396580
RAJKOT-WANKANER HIGHWAY, NEAR VILLAGE – JHAMBA, TEHSIL – BAPOLI, (CQZ1-CQZ-01), HB NO. 311, NEAR MDAV
PH :7624088188.
JADESHWAR CHAMBERS, NEAR DISTRICT – PANIPAT. - 132103 SCHOOL, TEHSIL – CHHACHHRAULI, DISTRICT
VAPI PH :9053400583.
INTERNATIONAL CERAMIC, WANKANER – YAMUNA NAGAR. - 135103
536. KATARIA AUTOMOBILES PVT. LTD. (0104-97-03), (GUJARAT) - 363621 BARARA PH :9812455895.
PLOT NO. C-29,NATIONAL HIGHWAY-8,G. I. D. PH :9904922333. DADRI TOE
556. EAKANSH WHEELS (NX01-NX-01), SH-4, KALA
C., VAPI, TAL. PARDI - 396195
PH :9924204423. HARYANA AMB - SHAHBAD - BARARA ROAD, BARARA - 565. COMPETENT AUTOMOBILES CO. LTD.
ADAMPUR (HARYANA) 133201 (BVH2-BVH-01), KHEWAT NO. – 270 MIN,
537. KATARIA AUTOMOBILES PVT. LTD. (0104-97-09),
PH :9991478100. KHATONI NO. – 319,
PLOT NO. 304/2, VILLAGE BALITHA, NH-8, OPP 546. SARAOGI AUTOMOBILES (P) LTD.
BABA SITARAM TEMPLE, NEAR BARWALA DADRI TOYE, DISTT. JHAJJAR, HARYANA PIN
(CWW2-CWW-01), KEWAT NO. 663, KHAT NO.
SWAMINARAYAN SCHOOL, SALAV, VAPI , 124103 - 124103
1147, KHESRI NO. 44/21/1/2(1-0), MANDI 557. MODERN AUTOMOBILES (BSA2-BSA-01),
DISTRICT -VALSAD, GUJARAT - 369191 PH :9821308849.
ADAMPUR, TEHSIL - ADAMPUR, DIST.-HISSAR, KHEWAT/KHOTONI NO. 388, KHASARA NO. 46/9,
PH :9723462612. STATE - HARYANA. - 125052 10, OPPOSITE AXIS BANK, VILLAGE BATAPUR, DAHINA
538. AMAR CARS PVT. LTD. (9701-97-01), SURVEY PH :8607777153. P.O. BARWALA, TEHSIL AND DISTT. 566. DINCO 4 WHEELS LLP (AUTO VIBES)
NO. 1034, 1035, NEAR WOODLAND HOTEL, PANCHKULA, HARYANA - 134118 (GLH1-GLH-01), REWARI MAHENDERGARH
AMBALA
NH-8, VILLAGE - BALITHA, VAPI. - 396145 PH :9896217059. ROAD, NEAR RAILWAY STATION, DAHINA,
PH :9327909504. 547. MODERN AUTOMOBILES (1801-18-01), MODEL
BAWAL REWARI - 123411
VERAVAL TOWN CROSSING, G.T.ROAD, AMBALA,
PH :7082100201.
HARYANA. - 134003
PH :9215016044. DHAND

25
Dealer Workshop (AS ON 31.05.2023 )
567. EAKANSH MOTORS (BEU1-BEU-01), 577. PLATINUM MOTOCORP LLP (KE01-KE-01), 587. VIPUL MOTORS PVT. LTD. (5801-95-04), PLOT HODAL
PANCHMUKHI CHOWK, KARNAL ROAD, DHAND, KHEVAT NO. 299, MUSTIL NO.-12, KHASRA NO. NO.5/22/1, SARHAUL VILLAGE,SECTOR-18,
600. ROHAN MOTORS (EE01-UE-02), KILA NO.
DISTT. KAITHAL, HARYANA. - 136020 -19/3 AND 22/2, VILLAGE – SEHADPUR MAIN ROAD, GURGAON. (HARYANA) - 201102
8/2(7-11), 9(5-06), 12(5-0), 13(8-0), HIGHWAY
PH :8395906111. MOHAMADPUR, TEHSIL – FARRUKHNAGAR, PH :4395800
ROAD, NEAR RAILWAY BYEPASS CHOWK,
DHARUHERA DISTRICT – GURGAON. - 122506 4395806
TEHSIL - HODAL, DIST.-PALWAL.
PH :9599007357/9953345380. 844848936.
568. DINCO 4 WHEELS LLP (AUTO VIBES) PH :8930202088 ; 9413080376.
FATEHABAD 588. PREM MOTORS PVT. LTD. (9511-95-01), PLOT
(CRP1-CRP-01), KHASRA NO. 57, KILLA NO. 7, ISMAILABAD
NO.101, SAINI PLAZA MARKET, OPP. H BLOCK,
SOHNA-DHARUHERA ROAD, OFF SECTOR-4A, 578. SHAKTI MOTORS PVT.LTD. (2H02-2H-01), NH-10,
NEAR RAM MANDIR, PALAM VIHAR, GURGAON - 601. KARNAL MOTORS PVT. LTD. (I901-I9-01),
DHARUHERA, DIST.-REWARI. SIRSA ROAD, FATEHABAD - 125050
122017 KHEWAT NO. 928, KHASRA NO. 2760(5-14),
PH :7082100270. PH :8222900217.
PH :4337900, 7065003445. 2761(800), VILLAGE - ISMAILABAD, TEHSIL -
ELLENABAD GANAUR 589. PREM MOTORS PVT. LTD. (9512-95-01), PLOT PEHOW, DIST.-KURUKSHETRA, HARYANA. - 136
569. SHAKTI MOTORS PVT.LTD. (E401-IN-03), 579. JAGMOHAN AUTOMOTIVES PVT. LTD. NO. 3,IDC, OPPOSITE SECTOR-14, GURGAON - 129
SURERA CHOWNK, NEAR CHAUDHARI MANI (NA04-NA-01), RAILWAY ROAD, GANAUR - 122001 PH :7082007138.
RAM COLLEGE, SIRSA ROAD, ELLENABAD - 131101 PH :7065003373, 7065003377, 0124-4319000. ISRANA
125055 PH :8199911106. 590. RANA MOTORS PVT LTD (9509-95-02), PLOT
NO.60, IDC, GURGAON - 122001 602. AUTO GALLERY (A UNIT OF RKH AUTOMOBILES
PH :8222900250. GHARAUNDA
PH :4867777, PRIVATE LIMITED) (I802-I8-01), MUSHTIL NO.
FARIDABAD 580. KARNAL MOTORS PVT. LTD. (8906-MR-05), -119, NEAR MANDI MOD, MAIN GOHANA ROAD,
9873400882.
570. VIPUL MOTORS PVT. LTD. (5801-58-01), 27/5 KM, WARD NO.-1, BEHIND GOVT. SR. SEC. SCHOOL 591. PASCO AUTOMOBILES (9510-95-01), PLOT NO. ISRANA - 132107
MAIN MATHURA ROAD, FARIDABAD - 121002 COLONY, GHARAUNDA, - 132114 34/3, DINESH JAIN COMPLEX, DELHI-AJMER PH :9053400417.
PH :2555011 PH :8222022321. EXPRESSWAY (NH-8), RAJIV CHOWK, JHAJJAR
2555013 GOHANA GURGAON, HARYANA. - 122001 603. COMPETENT (0B02-0B-01), PLOT NO 5, NEAR
97114 14556. PH :9953669444/9953669222.
581. JAGMOHAN AUTOMOTIVES PVT. LTD. GOVT POLYTECHNIC COLLEGE,
571. VIPUL MOTORS PVT. LTD. (5801-58-03), UNIT-II, 592. PREM MOTORS PVT. LTD. (9512-95-02), PLOT
(CU03-CU-01), NEAR KHANPUR CHOWNK, JHAJJAR-BAHADURGARH ROAD, JHAJJAR,
PLOT NO. 1A 19/6, MATHURA ROAD, NO. 122, PALAM VIHAR EXTENSION, NEAR
ROHTAK PANIPAT HIGHWAY, GOHANA, DISTT. - HARYANA - 124101
FARIDABAD - 121006 KRISHNA CHOWK, GURUGRAM - 122017
SONEPAT - 131301 PH :9999493040.
PH :4286000 PH :4337933, 7065003442.
PH :8685005521. JIND
4286024 593. PLATINUM MOTO CORP (2L04-95-03), 5/13
4286024 GURGAON 604. EAKANSH MOTORS PVT. LTD. (2K01-2K-01),
SOHNA ROAD VILL-TIKRI ADJACENT TO
9311321419. 582. PASCO AUTOMOBILES (9506-95-01), PASCO POLARIS HOSPITAL GURGAON HARYANA - ROHTAK ROAD, NATIONAL HIGHWAY-71, OPP.
572. TCS AUTOMOBILES (5804-58-01), PLOT NO-1A, HOUSE, 6 PALAM GURGAON ROAD, 122018 GRAIN MARKET, JIND, HARYANA - 126102
SECTOR-6, FARIDABAD, - 121001 INDUSTRIAL ESTATE, GURGAON - 122006 PH :9953345370/9899118867. PH :7876008184.
PH :4292929; 7503036200. PH 594. PREM MOTORS (9512-95-G1), QILA NUMBER JULANA
573. FAIR DEAL PREMIUM WHEELS PVT.LTD. :09650790323/7290069623/9999239959/4952100. 8/2, MUSTAKIL NO - 25, SECTOR 17-18,
(5807-58-01), PLOT NO.-17A, NIT INDUSTRIAL 605. EAKANSH MOTORS PVT. LTD. (MA01-MA-01),
583. VIPUL MOTORS PVT. LTD. (5801-95-02), 504, DIVIDING ROAD, GURGAON, - 122015
AREA, NIT FARIDABAD - 121003 JIND ROHTAK MAIN ROAD, OPP. NEW BUS
UDYOG VIHAR, PHASE-III, GURGAON - 122001 PH :8800000817.
PH :8448296686. STAND, JULANA, DIST. JIND, HARYANA - 126101
PH :4395701 HANSI
574. TCS AUTOWORLD PVT. LTD. (TCS & PH :8816802111.
4395704
ASSOCIATES PVT. LTD. ) (5804-58-02), 20.4 KMS 8448487921. 595. JAGMOHAN MOTORS PVT LTD (GT02-GT-01), G. KAITHAL
MILESTONE, BHASKAR COMPOUND, AMAR 584. COMPETENT AUTOMOBILES CO. LTD. T. HIGHWAY ROAD, MAIN ROHTAK HANSI 606. EAKANSH MOTORS PVT. LTD. (U802-U8-01),
NAGAR, MAIN MATHURA ROAD, FARIDABAD, (9505-95-01), A-25, INFOCITY, SECTOR-33, ROAD, NEAR HOLLAND TRACTORS AGENCY &
AMBALA ROAD, NH-65, KAITHAL - 136027
HARYANA. - 121003 GURGAON - 122004 HP PETROL, HANSI - 124001
PH :9671788801.
PH :2277225; 7290082911. PH :42500002, PH :8059900546.
KALANAUR
575. AUTO NATION (A UNIT OF TAYAL INDIA 9582797735. HISAR
MOTORS PVT. LTD) (5806-58-01), 15/3, 585. PASCO AUTOMOBILES (9506-95-02), SECTOR 607. JAGMOHAN MOTORS (SPQ1-SPQ-01), BHIWANI
596. MODERN AUTOMOBILES (7602-76-01), OPP.
MATHURA ROAD, NEAR SECTOR-28, METRO 17-18, DIVIDER ROAD, GURGAON, HARYANA, - ROAD, KALANAUR, DISTRICT ROHTAK. - 124113
VIDYUT NAGAR, DELHI ROAD, HISAR, - 125005
STATION, FARIDABAD - 121003 122015 PH :9812000425.
PH :9355473000.
PH :4180500 PH :07015804442/7982087767/9650701958/. 597. SARAOGI AUTOMOBILES (P) LTD. (7604-76-01),
KALAYAT
7290032501. 586. ROHAN MOTORS LTD. (9508-95-01), 2482/84, 608.
5TH KM STONE, SIRSA ROAD, HISSAR, EAKANSH MOTORS PVT. LTD. (BJP1-BJP-01),
576. AUTO NATION (A UNIT OF TAYAL INDIA SECTOR-52A, WAZIRABAD VILLAGE, OPP. HARYANA - 125001 NEAR BUS STAND, KAITHAL-KALAYAT ROAD,
MOTORS PVT. LTD) (5806-58-02), BYE PASS AARDI CITY MALL, GURGAON - 122001 PH :8607777043. VILLLAGE-KALAYAT, DISTT. KAITHAL
ROAD, PLOT NO. 12 SECTOR-9, FARIDABAD. - PH 598. MODERN AUTOMOBILES (7602-76-02), OPP. (HARYANA) - 136117
121006 :08860076163/8130593202/8130593201/813059320 BBMB, HISSAR DELHI ROAD, HISSAR - 125001 PH :9671788801.
PH :74287 48467. 3. PH :9355473000. KALKA
FARRUKHNAGAR 599. UNIQUE MOTORS PVT. LTD. (7603-76-01), OPP.
BHANU INDUSTRIES, DELHI ROAD, VILLAGE:
SATROD,HISSAR (HARYANA) - 125006
PH :8818055535.

26
Dealer Workshop (AS ON 31.05.2023 )
609. MODERN AUTOMOBILES (EG02-EG-01), 619. KARNAL MOTORS PVT. LTD. (CRA1-CRA-01), 628. EAKANSH WHEELS (1802-CV-02), NH-72, 638. PLATINUM MOTOCORP LLP (BY03-BY-01), HALI
ADJOINING INDIAN OIL PETROL PUMP, RAM KHEWAT NO.197, KHATONI NO.233, KHASRA AMBALA-KALA AMB ROAD, NEAR ADARSH MANDI ROAD, OPPOSITE SHIV MURTI,
NAGAR, NH-22, KALKA, DISTRICT – NO.27/17/1,27/14, LADWA-KURUKSHETRA FILLING STATION, NARAINGARH - 134203 PATAUDI, DIST. - GURGAON - 122503
PANCHKULA, HARYANA - 133302 ROAD, VILLAGE - LADWA, TEHSIL THANESAR, PH :9991143700. PH :9953345381/9953345488/9953345330.
PH :9896217059. DISTT. KURUKSHETRA - 136132 NARNAUL PEHOWA
KARNAL PH :7082007182.
629. PLATINUM MOTOCORP LLP (9Q02-9Q-01), 639. KARNAL MOTORS PVT. LTD. (2M02-2M-01),
610. KARNAL MOTORS PVT. LTD. (8906-89-01), 71/3 LOHARU KAILASH NAGAR, REWARI ROAD, NARNAUL, NEAR SHARMA SERVICE STATION,
MILESTONE ,G.T.ROAD, KARNAL - 132001 620. JAGMOHAN MOTORS (HB02-HB-01), BHIWANI HARYANA, - 123001 KURUKSHETRA ROAD, PEHOWA - 136128
PH :8222022399. ROAD , OPP. ITI, CITY: LOHARU - 127201 PH PH :8053906011.
611. KARNAL MOTORS PVT. LTD. (8906-89-02), PH :9812000425. :09053088460/9582226838/9053088501/905308845 PUNDRI
KHEWAT NO. 59, JHANJHARI GT ROAD, MADLAUDA 1/9053088500.
640. EAKANSH MOTORS PVT. LTD. (BFF1-BFF-01),
KARNAL - 132001 NARNAUND
621. AUTO GALLERY (A UNIT OF RKH AUTOMOBILES KILA NO- 3/10, KHEWAT 2147 OPP. HARCHARAN
PH :8222022430.
PRIVATE LIMITED) (CFK2-CFK-01), 630. JAGMOHAN MOTORS (SDK1-SDK-01), KHASRA FILLING STATION, KAITHAL ROAD, PUNDRI
612. MODERN AUTOMOBILES (8907-89-01), NEAR
VILLAGE-BHALSI, ASSANDH-PANIPAT ROAD, NO. 234, HANSI ROAD, NARNAUND, DISTT. DIST. KAITHAL, HARYANA - 136026
NAMASTE CHOWK, OLD G.T.ROAD, KARNAL -
MADLAUDA, PIN-132113, HARYANA - 132113 HISAR, HARYANA. - 125039 PH :9671788801.
132001
PH :9053400524. PH :9812000471. PUNHANA
PH :7419900042.
KATHURA MAHENDARGARH NARWANA 641. PASCO AUTOMOBILES (BIU1-01-BIU-01), KILA
622. PLATINUM MOTO CORP (DP01-DP-01), KHEWAT 631. EAKANSH MOTORS PVT. LTD. (U802-CW-03), NO. 4/2, PUNHANA, DIST.-MEWAT, HARYANA -
613. JAGMOHAN AUTOMOTIVES (SFJ1-SFJ-01),
NO. 187, KILLA NO. 51/8, REVENUE ESTATE OF OPP. HAFED GODOWN-2, NH-65 AKHERAM 122508
GOHANA MAHAM ROAD, KATHURA, GOHANA. -
VILLAGE REWASA, DADRI ROAD, TEHSIL & NAGAR, NARWANA - 126116 PH :9991300950, 8059730879.
131301
DISTRICT, MAHINDERGARH, PIN-123029, PH :9813583100. RADAUR
PH :8685005400.
HARYANA - 123029 NUH
KHARKHODA PH :9566136120, 9053088490.
642. PANDIT AUTOMOBILES PVT. LTD. (D201-EN-02),
632. PASCO AUTOMOBILES (7L02-7L-01), MAIN OPP. JMIT ENGG. COLLEGE, NEAR BUS STAND,
614. JAGMOHAN AUTOMOTIVES PVT. LTD. MANDI DABWALI DELHI - ALWAR ROAD, NEAR SHAHEED PARK, RADAUR, DISTRICT-RADAUR, HARYANA -
(BU02-BU-01), NEAR KANYA GURUKUL
623. SHAKTI MOTORS PVT.LTD. (E401-KU-02), NH -248A, NUH, DISTRICT - MEWAT, HARYANA. 135001
MAHAVIDYALYA, DELHI ROAD, NEAR UNION
SANGARIA ROAD, DABWALI, DISTT.-SIRSA - - 122107 PH :9992113854.
BANK, KHARKHODA (HARYANA) - 131402
125104 PH :9810014947. RAJOUND
PH :8685005593.
PH :8222900209. PALWAL
KOSLI 643. EAKANSH MOTORS (SHV1-SHV-01), MITTAL
MANESAR 633. ROHAN MOTORS LTD. (EE01-EE-01), SANWAL KHAL BHANDAR, RAJOUND, DISTT KAITHAL -
615. DINCO 4 WHEELS LLP (AUTO VIBES)
624. PLATINUM MOTOCORP LLP (2L04-2L-01), PLOT COLONY, MAIN MATHURA ROAD, NEAR SDM 136044
(CAN1-CAN-01), OPPOSITE RAJIV GANDHI
NO.282, SEC 6, IMT MANESAR DISTT. COURT, PALWAL - 121101 PH :9671788801.
STADIUM, TEHSIL ROAD KOSLI, DISTRICT –
GURGAON. - 122052 PH :304100 ; 304107/8930202060. REWARI
REWARI, HARYANA . - 123302
PH :09953345326/9953345324/9910100341. PANCHKULA
PH :7082100202. 644. DINCO 4 WHEELS LLP (AUTO VIBES)
KUND MEHAM 634. MODERN AUTOMOBILES (0702-K3-03), PLOT (U102-U1-01), BAWAL ROAD, NEAR BYE PASS
625. JAGMOHAN MOTORS PVT LTD (A601-NZ-08), NO. 318, INDUSTRIAL AREA, PHASE-2, ROAD, REWARI (HARYANA)) - 123401
616. DINCO 4 WHEELS LLP (AUTO VIBES)
MAIN MARKET, NATIONAL HIGHWAY-10, PANCHKULA - 134113 PH :7082100200/7082100204/7082100201.
(CJL1-CJL-01), NEAR KUND BARRIER, OPP. SBI
ROHTAK-HISSAR ROAD, MEHAM, PH :9646000165. ROHTAK
BANK, NARNAUL ROAD, VILLAGE - MANETHI,
DISTRICT-ROHTAK - 124101 635. AUTOPACE NETWORK PVT LTD (0705-K3-03),
KUND, DISTRICT - REWARI, HARYANA . - 123102 645. JAGMOHAN MOTORS PVT LTD (A601-A6-01),
PH :8059900592. PLOT NO. 5, INDUSTRIAL AREA, PHASE-1,
PH :856998928 , 97082100000. SONEPAT ROAD, ROHTAK - 124001
MOHNA PANCHKULA, HARYANA. - 134113
KUNDLI PH :7087119847.
PH :9467465035.
626. TCS & ASSOCIATES PVT LTD (CRT1-CRT-01), 646. JAGMOHAN MOTORS PVT LTD (A601-A6-09),
617. JAGMOHAN AUTOMOTIVES PVT. LTD. 636. AUTO VOGUE PVT. LTD. (K303-K3-01), PLOT
YAMUNA PUL ROAD , NEAR GYATRI PETROL SWAN GARDEN, DELHI ROAD, ROHTAK -
(GU03-GU-01), 34 E, SECTOR 57, PHASE 4 , NO- 388, INDUSTRIAL AREA PHASE-1,
PUMP , VPO-MOHANA,TEHSIL BALLABGARH , 124001
KUNDLI INDUSTRIAL AREA, KUNDLI - 131001 PANCHKULA, HARYANA. - 134113
DISTT FARIDABAD - 121004 PH :9812000357.
PH :8059900518. PH :8558813181.
PH :9911573130, 8929579400. 647. UNIQUE AUTO LEAD LLP (A602-A6-01), KHASRA
KURUKSHETRA PANIPAT NO- 3597 JIND ROAD, JIND CHOWK, ROHTAK,
MUSTAFABAD
618. KARNAL MOTORS PVT. LTD. (8906-U6-03), PLOT 637. AUTO GALLERY(A UNIT OF RKH AUTOMOBILES HARYANA - 124001
627. PANDIT AUTOMOBILES PVT. LTD.
NO. 156, INDUSTRIAL AREA, SECTOR-2, P LTD) (D302-D3-01), KHASRA NO. 43/6, 44/9 & PH :#REF!.
(CDX1-CDX-01), KHATUNI NO. 205/287, KHASRA
KURUKSHETRA - 136 118 10, VILLAGE – JATTIPUR, NEAR HOTEL SAFIDON
NO. 39:17/2, VILLAGE - MANSURPUR, THANA -
PH :8222022371. SWARNA MAHAL, NH-1, PANIPAT, HARYANA. -
CHAPPER, MUSTAFABAD, DIST.-YAMUNA 648. EAKANSH MOTORS PVT. LTD. (U802-JU-05),
LADWA 132103
NAGAR, STATE - HARYANA. - 133 103 NEAR BRSK SCHOOL , OPPOSITE RELIANCE
PH :9053400515.
PH :9992113854. PETROL PUMP, PANIPAT ROAD, SAFFIDON,
PATAUDI DISTRICT- JIND - 126112
NARAINGARH
PH :9416616603.

27
Dealer Workshop (AS ON 31.05.2023 )

SAMPLA TIGAON 668. COMPETENT AUTOMOBILES CO. LTD. 677. PATHANKOT VEHICLEADES PVT. LTD.
(6Y01-6Y-01), KHEWAT NO. 8/8 KHATAUNI, (BXE1-BXE-01), VILLAGE - TIUKARI, NEAR
649. JAGMOHAN MOTORS PVT LTD (NY01-NY-01), 659. TCS (5804-SJY-01), TCS AUTOWORLD, ARYAN
KHASRA NO. 137/30, 31, MAUZA KOTHI, MAHAVIR HOSPITAL LUBH ROAD, TEHSIL -
NEAR VASUNDRA CAFÉ, DELHI ROHTAK ROAD, PLAZA, NEEMKA BHUPGARH,
PARGANA 9, P. O. – CHANDPUR, TEHSIL – JAWALI, DIST.-KANGRA, HAMACHAL PRADESH.
SAMPLA, DISTT. ROHTAK - 124501 TIGAON-BALLABGARH ROAD, FARIDABAD,
SADAR, DIST.- BILASPUR, HIMACHAL - 176023
PH :9812000351. PIN-121004, HARYANA - 121004
PRADESH. - 174001 PH :9418195333.
SATNALI PH :9971422444.
PH :7807166832, 7807800330 / 7807800440. JOGINDER NAGAR
650. PLATINUM (SLH1-SLH-01), KHEVAT NO.605, TOHANA CHAMBA 678. COMPETENT AUTOMOBILES CO. LTD.
KHATONI NO-1134 KILLA NO.167, VILL: SATNALI, 660. SHAKTI MOTORS PVT.LTD. (XP01-XP-01), NEAR
669. KANGRA VEHICLEADES (D902-JF-03), MOHALLA (BBO1-BBO-01), VILL. DHELU PO DOHAG,
NEAR BHARAT PETROL PUMP GREEN VALLEY PUBLIC SCHOOL, RATIA ROAD,
SULTANPUR, BALU BRIDGE, CHAMBA - 176310 JOGINDER NAGAR (H.P.) - 175015
MAHENDRAGARH ROAD, TOHANA - 125120
PH :9418059252 , 9418045778. PH :9805005754.
HARYANA -123024 (LOCATION: PH :8572800991.
670. KANGRA VEHICLEADES (D902-JF-05), KHASRA JWALAMUKHI
MAHENDRAGARH) - 123024 TOSHAM NO. 88/96,1 & KHASRA NO.628/276, VILLAGE &
PH :9910100341. 679. KANGRA VEHICLEADES (CND1-CND-01),
661. JAGMOHAN MOTORS PVT LTD (0Y01-0Y-01), PO SAROO, THE. & DISTT. CHAMBA, HIMACHAL
SHAHABAD KHASRA 880/613, MAUJA BOHAN, TEHSIL
BHIWANI ROAD, TEH. TOSHAM, DIST. BHIWANI. PRADESH. - 176310
JWALAMUKHI, DISTRICT KANGRA - 176031
651. KARNAL MOTORS PVT. LTD. (CCR2-CCR-01), - 127040 PH :9418059252 , 9418013810.
PH :9418488999.
KHEWAT NO. 460, KATONI NO. 486, KHASRA PH :8059900566. CHOWARI
NO. 170, TEHSIL - SHAHABAD, DIST.- KULLU
YAMUNANAGAR 671. PATHANKOT VEHICLEADES PVT. LTD.
KURUKSHETRA. - 136135 680. COMPETENT AUTOMOBILES CO. LTD.
662. PANDIT AUTOMOBILES PVT. LTD. (D201-D2-01), (CWV1-CWV-01), KHATA KHATNI NO. 24/32 MIN,
PH :8222022338. (2Q01-2Q-01), PLOT 3&4, INDUSTRIAL AREA,
GOVINDPURI ROAD, JAGADRI, YAMUNANAGAR KHASRA NO. 90, VILLAGE - LAHRU, P.O. -
SIRSA SHAMSHI, KULLU (HP) - 175126
- 135001 PARCHHORE, TEHSIL - BHATTIYAT, DIST.
PH :7018035136.
652. SHAKTI MOTORS PVT.LTD. (E401-E4-01), PH :9812455896. -CHAMBA, HAMACHAL PRADESH. - 144416
DABBALI RD., SIRSA, HARYANA - 125055 663. PANDIT AUTOMOBILES PVT. LTD. (D201-D2-03), PH :8894569632. KUNIHAR
PH :8222900201. PLOT NO.E-8, INDUSTRIAL AREA, ITI ROAD, DEHRA 681. GOYAL MOTORS PVT LTD (BBX1-BBX-01),
SIWANI YAMUNA NAGAR (HARYANA) - 135001 KHATA NO. – 77, VILLAGE KOTHI, P.O.
672. KANGRA VEHICLEADES (D902-HT-02), VILLAGE
PH :9812455896. KUNNIHAR, TEHSHIL – ARKI, DISTRICT –
653. SARAOGI AUTOMOBILES (P) LTD. (HA03-HA-01), & P.O. SUNHET, TEHSIL DEHRA, DIST. KANGRA
SOLAN, HIMACHAL PRADESH - 173207
OPP.GOVT HOSPITAL ,SIWANI BYPASS HIMACHAL PRADESH - 177101
PH :9418312472.
CHOWK,HISSAR ROAD ,SIWANI,DIST.BHIWANI ALAMPUR PH :9817013058.
-127046 HARYANA - 127046 GAGGAL MANALI
664. KANGRA VEHICLEADES (RL01-RL-01), KHASRA
PH :8607777149. 682. COMPETENT AUTOMOBILES CO. LTD.
NO. 1606/1582, STATE HIGHWAY 673. KANGRA VEHICLEADES (BBV1-BBV-01),
SOHNA (BKU1-BKU-01), VILL. CHOURI VIHAR (AALU
PALAMPUR-SUJANPUR AT JANGAL, VILLAGE - NATIONAL HIGHWAY -20 , ZAMANABAD ROAD,
GROUND), P.O. & THESIL- MANALI, DIST.
654. PASCO AUTOMOBILES (9506-KZ-03), 56, KILLA ALAMPUR, DIST.-KANGRA. - 176082 ICHHI, GAGGAL, DISTT. KANGRA , HIMACHAL
KULLU, (H.P.) - 175131
NO. 13 (4-10), 18(4-6), 19 (8-0), 22 (8-0), 23 (4-2), PH :8988002269. PRADESH - 176209
PH :9418387465.
VILLAGE - ALIPUR, SOHNA GURUGRAM ROAD, BADDI PH :9418988832.
TEHSIL - SOHNA , DISTRICT -GURUGRAM. - HAMIRPUR MANDI
665. GOYAL MOTORS PVT LTD (7D01-CIF-04),
122103 683. COMPETENT AUTOMOBILES CO. LTD.
KHATA/KHATAUNI NO. 26/26, KHASRA NO. 674. COMPETENT AUTOMOBILES CO. LTD.
PH :08683000902/9873711127/8683000919. (B301-B3-01), GUTKAR INDUSTRIAL AREA,
93/56/32 AND 94/56/32, KITAS 2, REVENUE (W901-W9-01), VILLAGE TIKKAR, P.O DIDWIN
SONIPAT DELHI MANDI ROAD, N.H.21 GUTKAR, MANDI -
MAUZA – CHAK JANGI, HADBAST NO. 203, TEHSIL & DISTT, HAMIRPUR - 177401
124501
655. JAGMOHAN AUTOMOTIVES PVT. LTD. TEHSIL – BADDI, DISTRICT – SOLAN, HIMACHAL PH :9805510276.
PH :9805513208/9816664891.
(J502-J5-01), BAHALGARH-DELHI ROAD, OPP. PRADESH. - 173205 INDORA
POWER HOUSE, SONIPAT - 131001 PH :9418076972. NADAUN
675. PATHANKOT VEHICLEADES PVT. LTD.
PH :9992200372. BAIJNATH 684. COMPETENT AUTOMOBILES CO. LTD.
(BHE1-BHE-01), VILLAGE CHANDOR, PO &
656. JAGMOHAN AUTOMOTIVES PVT. LTD. (BXA1-BXA-01), VILLAGE JALAN, KHASRA
666. KANGRA VEHICLEADES (BBC1-BBC-01), TASHI TEHSIL INDORA, DISTT. KANGRA, PIN-176401,
(J502-J5-02), GAYATRI GARDEN, MURTHAL NO.183, PO & TEHSIL NADAUN, DISTT.
JONG, PAPROLA-BAIJNATH, NH-20, KANGRA HIMACHAL PRADESH - 176401
ROAD, SONEPAT (HARYANA) - 131001 HAMIRPUR, HIMACHAL PRADESH - 177041
-MANDI ROAD, TEHSIL BAIJNATH, DISTT. PH :9418008627.
PH :8685005686. PH :9805737436.
657. JAGMOHAN AUTOMOTIVES PVT. LTD.
KANGRA - 176115 JAISINGHPUR
PH :8628820603. NAGROTA
(J502-J5-03), O-11 INDUSTRIAL AREA, SONIPAT, 676. KANGRA VEHICLEADES (BVA1-BVA-01), HARSI
BANIKHET 685. KANGRA VEHICLEADES (D902-D9-01), MALAN,
HARYANA. - 131001 PATTAN ROAD, OPP. SABJI MANDI, TEHSIL –
NAGROTA - BAGWAN, KANGRA, H.P. - 176047
PH :9812615000. 667. PATHANKOT VEHICLEADES PVT. LTD. JAISINGHPUR, DIST. – KANGRA, HIMACHAL
PH :7018268819.
TAURU (BWN1-BWN-01), KHASRA NO.709, KHATA PRADESH. - 176095
KHATOONI NO.23, BANIKHET, THE-DALHOUSIE, PH :9418477756. NAGROTA BAGWAN
658. PASCO AUTOMOBILES (BIV1-BIV-01), KILA NO.
34/1/2, REWARI ROAD, TAURU, DIST.-MEWAT,
DISTT. CHAMBA - 176303 JAWALI
PH :254186, 232036, 9418048803.
HARYANA. - 122015
PH :8683000902, 9873001497, 8683000954, BILASPUR
9671150250,9034926253.

28
Dealer Workshop (AS ON 31.05.2023 )
686. KANGRA VEHICLEADES (D902-D9-06), JHIKLI ROHRU 704. JAMKASH VEHICLEADES (CODE UNDER 713. JAMKASH VEHICLEADES PVT. LTD
AMBARI, MOUZA AMBARI, MALAN, NAGROTA CREATIONS-CODE UNDER CREATIONS-CODE (BFH1-BFH-01), KHASRA NO. 183, KHEWAT
695. GOYAL MOTORS PVT LTD (JZ01-JZ-01),
BAGWAN, TEHSIL & DISTT. KANGRA, UNDER CREATIONS), NEAR PHC ROAD NO.14, KHATANO-74, VILLAGE CHAK SAKTA,
CHARGAON SHIMLA ROAD, ROHRU, DISTRICT
HIMACHAL PRADESH - 176047 MANJAKOTE, TEHSIL MANJAKOTE, DISTRICT DAYALACHAK,TEHSIL & DISTT. KATHUA ,
-SHIMLA - 171207
PH :7018268819. RAJOURI, J&K - 185131 JAMMU & KASHMIR - 184121
PH :9418016072.
NAGROTA SURIAN PH :7006014395. PH :88492849170.
SALOONI VIJAYPUR DODA
687. KANGRA VEHICLEADES (BGI1-BGI-01), KHEWAT
696. PATHANKOT VEHICLEADES (SES1-SES-01),
NO. 115, KHATAUNI NO. 127, KHASRA NO. 2037, 705. JAMMU MOTORS (OZ02-01-OZ-01), JAMMU 714. J& K VEHICLEADES PVT. LTD (2Z02-2Z-01),
KHASRA NO. 299/174, VILLAGE. MANJEER,
MAHAL BASSA, SUB TEHSIL – NAGROTA PATHANKOT HIGHWAY, VIJAYPUR (SAMBA), MINTO CAR CARE, AKHYARABAD, MAIN ROAD,
TEHSIL-SALOONI, DISTT. CHAMBA, PIN-176320,
SURIAN, DISTRICT – KANGRA. - 176027 J&K - 184120 DODA CITY, DODA (J&K) - 182202
HIMACHAL PRADESH - 176320
PH :9418488999. PH :9596975060. PH :9419796821.
PH :9418059252.
NALAGARH JAMMU AND KASHMIR GANDERBAL
SHAHPUR
688. GOYAL MOTORS PVT LTD (IB02-IB-01), NEAR AKHNOOR 715. JAMKASH VEHICLEADES (KASHMIR) PVT LTD
697. KANGRA VEHICLEADES (SCR1-SCR-01),
HP PETROL PUMP, VILLAGE PEERSTHAN, P.O (ZA01-ZA-01), MALSHAIE BAGH, GANDERBAL
VILLAGE MANJHGRAN, P.O. DRAMMAN, TEHSIL 706. JAMMU MOTORS PVT. LTD. (2X02-2X-01), MAIN
& TEHSIL NALAGARH, DISTT. SOLAN (H.P.) - (J&K) - 191201
SHAHPUR, DISTT. KANGRA, HIMACHAL ROAD DASKAL, TEHSIL – AKHNOOR, DISTRICT -
174101 PH :9419000828.
PRADESH - 176206 JAMMU - 181201
PH :9418704572. HANDWARA
PH :9459900241. PH :9419118393.
NERWA 716. JAMKASH VEHICLEADES (KASHMIR) PVT LTD
SHIMLA ANANTNAG
689. GOYAL MOTORS PVT LTD (CRS1-CRS-01), (BYA1-BYA-01), KHEWAT NO-31, KHATTA
698. GOYAL MOTORS PVT LTD (A901-A9-01), 707. PEAKS AUTO PVT. LTD. (2Y01-2Y-01), NH-1A,
KHASRA NO. 482, VILLAGE – KEDI, TEHSIL – NO-298, SURVEY NO- 3764/1816, MOZA
TARADEVI, SHIMLA,(H.P.) - 171010 MOUZA UROONHALL, THE & DISTT. ANANTNAG
NERWA, DISTRICT – SHIMLA, HIMACHAL BRARIPORA, TEH- HANDWARA, DIST-
PH :9418663572. - 228165
PRADESH. - 171210 KUPWARA, J&K - 193221
SOLAN PH :9519275151.
PH :9418663572. PH :262322, 9419074012.
NURPUR 699. GOYAL MOTORS PVT LTD (7D01-7D-01), DEON BANDIPORA JAMMU
GHAT, SOLAN - 173211 708. JAMKASH VEHICLEADES (KASHMIR) PVT LTD
690. KANGRA VEHICLEADES (D902-JG-04), VILLAGE 717. JAMKASH VEHICLEADES PVT. LTD (3306-33-01),
PH :9418138772. (1205-OA-04), AJAR BANDIPORA , J&K - 193502
JACHH, PO JASSUR, TEHSIL NURPUR, DISTT. NH-1A, BYE PASS, OPP CHANNI HIMMAT,
UNA PH :9149726427.
KANGRA - 176201 JAMMU - 180015
PH :9418195333 , 9418041778. 700. COMPETENT AUTOMOBILES CO. LTD. BARAMULLA PH :6006801639.
PALAMPUR (QD01-QD-01), VILLAGE RAINSARY,P.O 709. JAMKASH VEHICLEADES (KASHMIR) PVT LTD 718. JAMKASH VEHICLEADES PVT. LTD (3306-33-02),
JHALERA,TEHSIL & DISTRICT:UNA - 174303 (8C01-8C-01), VILLAGE SANGRAMA,WAGAROO, NEAR GENERAL BUS STAND, OPP. PHE
691. KANGRA VEHICLEADES (2T01-2T-01), NEAR
PH :9805737436. BARAMULA - 193101 OFFICE, B.C. ROAD, JAMMU - 180001
IOCL PUMP, KANGRA MANDI ROAD,
PH :7889612218. PH :9419224014.
PALAMPUR, DISTT. KANGRA, HIMACHAL JAMMU 719. JAMKASH VEHICLEADES PVT. LTD (3306-33-04),
PRADESH. - 176061 BHADRAWAH
MARH SUNJWAN, DISTT. JAMMU - 180011
PH :9418222622/ 9463265072. 710. J& K VEHICLEADES PVT. LTD (AKA1-AKA-01),
701. JAMKASH VEHICLEADES PVT. LTD PH :7006018600.
PAONTA SAHIB KHASRA NO.2863, LOWER SUNGLI UNIVERSITY 720. PEAKS AUTO JAMMU PVT. LTD. (3312-33-01),
(BPM1-BPM-01), KHASRA NO. 269, LOWER
ROAD, BHADERWAH, DISTT. DODA, J&K - GANGYAL INDUSTRIAL AREA, BEHIND COCA
692. GOYAL MOTORS PVT LTD (A901-8G-02), OPP MUTHI DHARMAL, DIST.-JAMMU, STATE -
182222 COLA FACTORY, JAMMU - 180010
BIBIJEET KAUR SENIOR SECONDARY SCHOOL, JAMMU & KASHMIR. - 181205
PH :9419796821. PH :9697001125.
SHAMSHERPUR , NH-72, PAONTA SAHIB - PH :7006898474.
173025 BHASOLI 721. JAMMU MOTORS PVT. LTD. (3308-33-01), 6,
PH :9459210872. JAMMU & KASHMIR 711. JAMKASH VEHICLEADES PVT. LTD. AKHNOOR ROAD, JAMMU. - 180001
RAJGARH CHOWKI CHOURA (GLK1-GLK-01), ZERO MORTH, BASHOLI, DISTT. PH :9419118393.
KATHUA, BASHOLI, PIN-184201, JAMMU & 722. JAMMU MOTORS PVT. LTD. (3308-33-02), PLOT
693. GOYAL MOTORS PVT LTD (BJX1-BJX-01), 702. JAMU MOTORS (SDY1-SDY-01), KHASRA NO. 37
KASHMIR - 184201 NO.2, RAJPURA CHUNGI OPP AG OFFICE,
KHATA NO. 517/505, 478/3, KHASRA NO. – 38/98 MIN, ADJACENT TO J&K BANK, JAMMU
PH :9018847230. AKHNOOR ROAD, JAMMU - 180002
VILLAGE NERI RATAULI, P.O. RAJGARH TEHSIL POONCH HIGHWAY, CHOWKI CHOURA, JAMMU
PH :9419118393.
– RAJGARH, DISTRICT – SIRMAUR , HIMACHAL & KASHMIR - 185154 BUDGAM
723. PEAKS AUTO JAMMU PVT. LTD. (3312-33-02),
PRADESH - 173101 PH :9596975060.
712. HIGHLAND AUTOMOBILES PVT.LTD KHASRA NO.425 & 426, KHATA NO.425 & 426,
PH :9418312472. MAHANPUR (1202-CUG-04), KHASRA NO. 208 MIN, KHEWAT TOPE SHRKHANIAN (BACKSIDE OF BEST
RAMPUR 703. JAMMU MOTORS (SPK1-SPK-01), MAHANPUR, NO. 9 AND KHATTA NO. 55, MOUZA - PALLAR, PRICE), AKNOOR ROAD, JAMMU. - 180001
DISTRICT KATHUA, TEHSIL MAHANPUR - TEHSIL AND DIST.-BUDGAM. - 191111 PH :9697001125.
694. GOYAL MOTORS PVT LTD (CEZ1-CEZ-01),
JAMMU & KASHMIR. - 184202 PH :9419019898. 724. JAMKASH VEHICLEADES PVT. LTD (3306-33-07),
KHASRA NO. 824/825, MINN NO. 155/396,
163/411, NAGLI, ROHRU ROAD, RAMPUR, PH :9596975060. DAYALACHAK KHEWAT NO. 25, KHATA NO. 355, KHASRA NO.
TEHSIL – RAMPUR, DISTRICT – SHIMLA. - MANJAKOTE 544 MIN PALOURA ROAD, JANIPUR, JAMMU. -
172001 180007
PH :9459296572. PH :9419191502.
KATHUA

29
Dealer Workshop (AS ON 31.05.2023 )
725. JAMMU MOTORS PVT. LTD. (3B02-3B-01), WARD 735. JAMKASH VEHICLEADES PVT. LTD 745. RELIABLE INDUSTRIES PVT. LTD. 755. RELIABLE INDUSTRIES (5202-52-01), KATRAS
NO.13, CHAK PARTAP SINGH HATLI MORH, (CDL1-CDL-01), KHASRA NO.80 & KHATA (BHA1-BHA-01), SONTURPI, GT ROAD, GAIDA, ROAD, DHANBAD, JHARKHAND. - 826001
NH1-A, KATHUA TEHSIL KATHUA - 184101 NO.100, VILLAGE SIDHRA, NH1A, NEAR BHARAT BAGODAR, GIRIDIH, JHARKHAND. - 825322 PH :9835830202
PH :9419118393. PETROLEUM PETROL PUMP, TEH. & DISTT. PH :9507102036 7369945040.
KULGAM JAMMU - 180019 9835814404. 756. RELIABLE INDUSTRIES (5202-52-02), BEHIND
PH :9419134144. BALIAPUR PRABHAT KHABAR, AT: KOLAKUSMA, P.O K.G.
726. PEAKS AUTO PVT. LTD. (OY01-OY-01), NEAR
SRINAGAR ASHRAM, SARAIDHELA , DHANBAD - 828127
GRID STATION,MAIN ROAD, KULGAM - 191202 746. CARONE (SNI1-SNI-01), WARD NO 53, HOLDING
PH :8102333474
PH :9519275151. 736. HIGHLAND AUTOMOBILES PVT.LTD NO - SAF3797, KANDRA SINDRI, BALIAPUR. -
7369945043.
KUPWARA (1202-12-01), SONWAR, SRINAGAR - 190001 828123
757. RELIABLE INDUSTRIES (5202-52-06), SUGIADIH,
PH :9419057564. PH :7980074787.
727. JAMKASH VEHICLEADES (KASHMIR) PVT LTD HIRAK ROAD, SARAIDHELA, DHANBAD,
737. JAMKASH VEHICLEADES (KASHMIR) PVT LTD BOKARO
(1205-AX-03), JAMKASH VEHICLEADES, NEAR JHARKHAND. - 828127
(1205-12-01), HYDERPURA BY PASS CROSSING,
GM FILLING STATION, DC OFFICE ROAD 747. HINDUSTAN AUTO AGENCY (B501-B5-02), R1, PH :9334094940.
SRINAGAR - 190015
KUPWARA - 193223 CITY CENTRE, SECTOR-4, BOKARO STEEL 758. CAR ONE (A UNIT OF RAJHANS AUTOMOBILES
PH :7006037255.
PH :9622499902. CITY, BOKARO - 827004 PRIVATE LIMITED) (5205-52-01), NH-2, GT ROAD,
738. PEAKS AUTO PVT. LTD. (1204-12-01), BYE PASS
MAGAM PH :9831550033/7070403002/9431128683. SAHARJORI, BARWADA, DHANBAD. - 828 109
ROAD, NH - 1A, NEAR HOTAL SILVER STAR,
748. HINDUSTAN AUTO AGENCY (B501-B5-03), M2, PH :9006828000, 9835740433.
728. JAMKASH VEHICLEADES PVT. LTD SRINAGAR - 191101
SECTOR-4, CITRY CENTRE, BOKARO STEEL 759. RELIABLE INDUSTRIES (5202-52-09),
(GLS1-GLS-01), KHASRA NO. 34, MOUZA - PH :9519275151.
CITY (JHARKHAND) - 827004 TILAKRAIDIH, K G ASHRAM, NH-32,
CHICHILORA, MAGAM, GULMARG ROAD, 739. JAMKASH VEHICLEADES (KASHMIR) PVT LTD
PH :9431127983/9431128683. GOVINDPUR, DHANBAD, JHARKHAND - 828109
TEHSIL - KWARHAMA, DIST.-BARAMULLA, (1205-12-05), NARBAL CROSSING, NH-1A,
CHAIBASA PH :9031096662.
JAMMU & KASHMIR. - 193 401 SRINAGAR, JAMMU & KASHMIR - 190017
PH :9796700750. DUMKA
PH :8825016046. 749. PEBCO MOTORS (BOY1-BOY-01), KOLHAN
PHINTER SUNDERBANI TIMBER MERCHANT, NEAR RAILWAY 760. RELIABLE INDUSTRIES (L701-L7-01), OPP
CROSSING, TATA ROAD, CHAIBASA, DISTRICT DUDHANI PETROL PUMP, DEOGHAR-PAKUR
729. JAMKASH VEHICLEADES PVT. LTD 740. PEAKS AUTO JAMMU PVT. LTD. (AAM3-AAM-01),
– WEST SINGHDHUM, JHARKHAND. - 833201 ROAD,DUMKA ( JHARKHAND) - 814101
(BHV1-BHV-01), KHASRA NO.2293/405 AND MOUZA THANDA PANI, TEH. SUNDERBANI -
PH :7070449718. PH :6205161170.
KHEWAT NO.81/98, GURHA KALYAL, PHINTER, 185153
PH :9697001125. CHANDWA GARHWA
TEHSIL RAMKOT, DISTT. KATHUA, J&K. - 184203
PH :9419187583. SURANKOTE 750. HILLTOP MOTORS (A UNIT OF HIRALAL 761. PREMSONS MOTOR UDYOG PVT. LTD.
POONCH MOTORS PVT LTD) (SCS1-SCS-01), HILLTOP (VX01-VX-01), KHATA NO. 4, KHESRA NO. 108,
741. PEAKS AUTO JAMMU PVT. LTD. (TY03-TY-01),
MOTORS, MAIN ROAD, CHANDWA, PO AND PS, 109, THANA NO. 342, PIPRAKALA, GARHWA,
730. JAMKASH VEHICLEADES PVT. LTD NEAR KNIET KING FILLING STATION, BHARAT
CHANDWA – 829203, DIST – LATEHAR, JHARKHAND. - 822114
(AAW1-AAW-01), VILLAGE KUNUYIAN, TEHSIL PETROLEUM, POONCH MUGHAL ROAD,
JHARKHAND - 829203 PH :8862828802
HAVELI POONCH, JAMMU & KASHMIR. - 185121 SURANKOTE, DISTT: POONCH - 185101
PH :7061157502. 9835507004.
PH :7006014395. PH :9697001125.
CHIRKUNDA GHATSHILA
PULWAMA THANA MANDI
751. RELIABLE INDUSTRIES (CQT1-CQT-01), PLOT 762. PEBCO MOTORS LTD. (AIA1-AIA-01), PLOT NO.
731. PEAKS AUTO PVT. LTD. (1204-MU-03), MUGHAL 742. JAMKASH VEHICLEADES PVT. LTD.
NO. 109-110, KHAITAN NO. 12, MOUZA NO. 251, 68, KHASRA NO.128, MAUZA PAORA, NH-33,
ROAD, GUNGOO, PULWAMA - 192301 (SO01-SO-01), HASPLOTE(CHRUNG), TEHSIL
P.S. – CHIRKUNDA, DISTRICT – DHANBAD, NEAR FULL-DUNGRI CHOWK,GHATSHILA, EAST
PH :9519275151. THANAMANDI, DISTRICT RAJOURI -185212 -
JHARKHAND. - 828202 SINGHBHUM (JHARKHAND) - 832303
RAJOURI 185212
PH :9905937751 PH :9308433388.
PH :9419267607.
732. JAMKASH VEHICLEADES PVT. LTD 9835814404. GIRIDIH
UDHAMPUR
(3306-KS-06), KALAKOTE ROAD, VILLAGE DALTONGANJ 763. RELIABLE INDUSTRIES (5202-3D-04),
BADOL, RAJOURI - 185131 743. J& K VEHICLEADES PVT. LTD (D801-D8-01),
752. PREMSONS MOTORS UDYOG PVT LTD MOHANPUR, PACHAMBA ROAD, GIRIDIH. -
PH :7006014395. NATIONAL HIGHWAY 1A, NEAR DAK
(5103-MP-02), KACEHRI ROAD, DALTONGANJ, 815301
RS PURA BANGLOW, UDHAMPUR - 182101
PALAMU - 822101 PH :8102924860
PH :7006881028.
733. JAMKASH VEHICLEADES PVT. LTD (3306-JN-03), PH :9835507004. 8102924858.
URI (CHAAL BONIYAAR) 764. RELIABLE INDUSTRIES PVT. LTD (5202-3D-08),
GAGAIN MORTH, R S PURA, JAMMU, - 181102 DEOGHAR
PH :9419190370. 744. JAMKASH VEHICLEADES (KASHMIR) PVT LTD PLOT NO. 7, HALKA NO. 12, KHATA NO. 2,
753. RELIABLE INDUSTRIES (5202-KR-03), SHAHEED THANA NO. 266, MOUZA - CHATRO, GIRIDIH,
SHOPIAN (CCK1-CCK-01), KHASRA NO.346/118, KEWAT
ASHRAM ROAD, JHAUNSAGARHI, DEOGHAR, - JHARKHAND. - 815301
NO.15, KHATA NO.30, MOUZ-CHALAL (URI),
734. PEAKS AUTO PVT. LTD. (AAA1-AAA-01), AGLAR 814112 PH :9835835101.
TEHSIL-BONIYAR, DISTT. BARAMULLA - 193123
SOFANAMAN, SHOPIAN - 192303 PH :6207129088
PH :9419074012. GODDA
PH :9519275151. 7001553251.
SIDHRA JHARKHAND 754. RELIABLE INDUSTRIES (KR02-KR-01), MOUZA - 765. RELIABLE INDUSTRIES (5202-EJ-05), ASANBANI
BAGODAR CHAKRIPAHARI, NO. 587, WARD NO. 36, CHOWK, MAIN ROAD, GODDA. - 814133
DEOGHAR, JHARKHAND. - 814114 PH :6207129088.
PH :9835811220, 9835814404. GUMLA
DHANBAD

30
Dealer Workshop (AS ON 31.05.2023 )
766. PREMSONS MOTOR UDYOG PVT. LTD. 776. HINDUSTAN AUTO AGENCY (VR01-VR-01), AT 787. HILLTOP MOTORS (A UNIT OF HIRALAL 796. MANDOVI MOTORS PVT LTD. (0201-02-07),
(5103-2O-04), VANASTHALI COMPLEX LALMAN DIGTHU, BESIDE KRISHNA SURYA MOTORS PVT LTD) (5109-51-02), NEAR KATHAL 17/A-2&3 IND.SUBURB.IIND STAGE,
PUGUCHAMPA NAGAR,NH-23,SISAI COLD STORAGE, JHUMRI TILAIYA, P.S. – MORE, ARGORA RANCHI RD, NEAR EKLABBA GORAGUNTEPALAYA, TUMKUR ROAD.
ROAD,GUMLA - 835207 TILAIYA, DISTRICT – KODERMA, JHARKHAND. - TOWER, DHIPATOLI, ARGORA, RANCHI - 834004 YESWANTHPUR, BANGALORE - 560022
PH :9835507004. 825409 PH :7061157502. PH :9945235537.
HAZARIBAGH PH :6201998936. 797. MANDOVI MOTORS PVT LTD. (0201-02-05),
KARNATAKA NO.2/106 (NEXT TO KASSIA BLDG.),17TH
767. HINDUSTAN AUTO AGENCY (Y901-Y9-01), NEAR LOHARDAGA
ANEKAL CROSS,MAGADI CHORD ROAD EXTN.
SBI MAIN BRANCH, MAIN ROAD, HAZARIBAGH. - 777. SUDHA MOTORS(A UNIT OF SUDHA BUSINESS
788. PRATHAM MOTORS PVT. LTD (0205-FA-04), VIJAYANAGAR,BANGALORE - 560079
825301 ENTERPRISES PVT LTD) (CX01-CX-01), PLOT
SY#45/3, KAVAL HOSAHALLI, KASABA HOBLI, PH :9945235529.
PH :9304051949, NO. 14P, 15, 23, RIADA, LOHARDAGA,
ANEKAL TALUK - 562106 798. RNS MOTORS (7301-02-03), 2275 TUMKUR
9263631327. JHARKHAND. - 835302
PH :9945540131. ROAD, GURGUNTEPALYA, YESHWANTPUR,
768. HINDUSTAN AUTO AGENCY (Y901-Y9-02), PH :9534199997.
ANKOLA BANGALORE - 560022
MASIPIRHI, BABHANBAY, HAZARIBAGH , MURI PH :9606933236.
JHARKHAND. - 825301 789. BHARATH AUTO CARS PVT. LTD. (FC02-FC-01),
778. HILLTOP MOTORS (CODE UNDER 799. BIMAL AUTO AGENCY INDIA PVT. LTD.
PH :9216888118 NEAR NARAYANA TEMPLE KAKKAR MUTTA,
CREATIONS-CODE UNDER CREATIONS-CODE (0218-02-01), NO.- 60/3, VENKATALA VILLAGE,
9263631327,. BELEGULI CROSS, ANKOLA, UK DISTRICT -
UNDER CREATIONS), NEAR BANK OF INDIA, YELAHANKA HOBLI, BANGALORE NORTH
JAMSHEDPUR SILLI MAIN ROAD, MURI, PIN - 835102 - 835102
581314 TALUK - 560064
PH :7829567400. PH :9945541034.
769. PEBCO MOTORS LTD. (3101-31-01), MEDIUM PH :7061157502.
SECTOR, INDUSTRIAL AREA, ADITYAPUR, RAMGARH ATHANI 800. BIMAL AUTO AGENCY INDIA PVT. LTD.
JAMSHEDPUR - 831001 790. SHANTESHA MOTORS (BWA1-BWA-01), RS NO. (0216-02-01), 60/2, MAHADEVPURA, WHITE
779. HINDUSTAN AUTO AGENCY (AV01-AV-01), FIELD ROAD, BANGALORE - 560048
PH :9308433388. 605, SHIVAYOGI NAGAR, BIJAPUR ROAD,
MARAR, RANCHI ROAD (NH-33), RAMGARH - PH :99723 98105.
770. PEBCO MOTORS LTD. (3101-31-02), 16 ATHANI, DIST. - BELGAUM. - 591304
829122 801. RNS MOTORS (7301-02-04), HOSUR
BALICHALA, CONTRACTORS & GODOWN AREA, PH :8884472587.
PH :9263631345. ROAD,BOMMANAHALLI,MADIVALA
SONARI, JAMSHEDPUR - 831011 ATHRADI
PH :9308433388. RANCHI POST,BANGALORE - 560068
771. MOTOR WORLD (3102-31-01), N.H-33, NEAR 791. ABHARAN MOTORS PVT LTD (G601-UK-04), PH :9148001412.
780. PREMSONS MOTORS UDYOG PVT LTD
PARDIH CHOWK, MANGO, JAMSHEDPUR - HERABETTU ROAD ATHARDI UDUPI - 576107 802. MANDOVI MOTORS PVT LTD. (0201-02-08), NO.
(5103-51-01), 502, KANKE ROAD, RANCHI. -
831012 PH :9845472500. 70 SARAKKI INDUSTRIAL LAYOUT,J.P
834008
PH :9431347164, 9570168342. PH :9304807355. ATTIBELE NAGAR,3RD PHASE, BANGALORE - 560078
JAMTARA 781. PREMSONS MOTOR UDYOG PVT. LTD. 792. PH :9954235522.
SURAKSHAA CAR CARE PVT. LTD.
(5103-51-03), 10/P, NAMKUM INDUSTRIAL 803. PRATHAM MOTORS PVT. LTD (0205-02-01), 16,
772. RELIABLE INDUSTRIES (BOX1-BOX-01), PLOT (BMM1-BMM-01), SURVEY NO.22/7/8, SARJAPUR
ESTATE,BEHIND HIGH TENSION INSULATOR BALLANDUR, SARJAPUR RING ROAD,
NO. 483, PARWAT BIHAR, DUMKA ROAD, MAIN ROAD, INDIABELE VILLAGE, OPP. TO
FACTORY, LOWER CHUTIA, RANCHI - 834010 BANGALORE - 560037
JAMTARA, JHARKHAND. - 815351 GOLDEN LIBERTY, ATTIBELE P.O.,
PH :9262899003. PH :9945540126.
PH :9835814404. BANGALORE. - 562107
782. PREMSONS MOTOR UDYOG PVT. LTD. 804. BIMAL AUTO AGENCY INDIA PVT. LTD.
PH :9449865665.
KATRAS (5103-51-05), PLOT NO.31 & 134, JOHNSON (0216-02-02), NO. 69/2, SARAKKI, KANAKAPURA
BAGALKOT ROAD, BANGALORE - 560078
773. CAR ONE (A UNIT OF RAJHANS AUTOMOBILES MORH, TUPUDANA INDUSTRIAL AREA,
PRIVATE LIMITED) (GLP1-GLP-01), RAJHANS TUPUDANA, RANCHI - 834003 793. VIJAY MOTOWINGS (ZL01-ZL-01), PH :9972398139.
REFRACTORIES, OPP. LIC OFFICE, RAJGANJ PH :9835507004. 180/4-2,BELGUM RAICHUR ROAD,NEAR APMC 805. PRATHAM MOTORS PVT. LTD (0205-02-02),
ROAD, KATRAS, DISTT. DHANBAD, 783. SUDHA MOTORS(A UNIT OF SUDHA BUSINESS MARKET YARD, BAGALKOT - 587103 STHANIKAM'S ARCADE, OPP. ST THERESA
JHARKHAND-828114 - 828114 ENTERPRISES PVT LTD) (5107-51-02), PLOT NO. PH :9481289167. HOSPITAL, DR. RAJ KUMAR ROAD, A
PH :8910900556. 74, OPPOSITE OTC GROUND, HEHAL, RATU BAGEPALLI BLOCK,RAJAJINAGAR 2 STAGE, BANGALORE -
ROAD, RANCHI, JHARKHAND - 834005 560010
KHELARI 794. BIMAL AUTO AGENCY INDIA PVT. LTD.
PH :9534199997, 8227996660. PH :9900061378.
774. SUDHA MOTORS(A UNIT OF SUDHA BUSINESS (BTV1-BTV-01), H.L. NO. 423 AND 436 SRI
784. SUDHA MOTORS(A UNIT OF SUDHA BUSINESS 806. KALYANI MOTORS PVT. LTD. (0211-02-01),
ENTERPRISES PVT LTD) (CFO1-CFO-01), PLOT SATHYA SAI NAGAR, ON NH-7,
ENTERPRISES PVT LTD) (5107-51-03), PLOT NO. MYSORE ROAD,PANTHARAPALYA,KENGRI
113, MOUZA- BUKBUKA, BESIDE PAHADI THIMAKALAPALLI BLOCK-II, PARAGODU GRAM
39, NEAR BOOTY MORE, RANCHI-RAMGARH HOBLI,BANGALORE - 583201
MANDIR, KHELARI, RANCHI - 829205 PANCHAYATH, KASABA HOBLI, BAGEPALLI
ROAD, RANCHI. - 835217 PH :9538887078.
PH :6458222, 9534199997. TALUK, CHIKKABALLAPUR DIST. - 561 207
PH :9534199997. 807. BIMAL AUTO AGENCY INDIA PVT. LTD.
PH :9742458888.
KHUNTI 785. PREMSONS MOTOR UDYOG PVT. LTD. (0216-02-03), NO.7/1, KALANAAGRAHARA
BANGALORE VILLAGE, MOUNT ST. JOSEPH TRAINING
775. PREMSONS MOTOR UDYOG PVT. LTD (5103-51-06), PLOT NO.14 (P) KOKAR
INDUSTRIAL AREA KOKAR, RANCHI. - 834001 795. MANDOVI MOTORS PVT LTD. (0201-02-01), COLLEGE FOR JESUITS COMPOUND, IIMB
(BOL1-BOL-01), PLOT NO. 747, KHATA NO. 2,
PH :9835507004. 24/4,7TH MAIN,WILSON GARDENS,BANGALORE POST, BANNERGHATTA RD. , BANGALORE -
DAHUGUTU, CHAIBASA ROAD, KHUNTI,
786. HILLTOP MOTORS (A UNIT OF HIRALAL - 560027 560076
JHARKHAND. - 835 210
MOTORS PVT LTD) (5109-51-01), KHATA NO. PH :9945235511. PH :9845166612.
PH :9835507004.
KODARMA 247, MOUZA - PUNDAG,P.S. - PUNDAG, RANCHI,
JHARKHAND. - 834004
PH :7061157502.

31
Dealer Workshop (AS ON 31.05.2023 )
808. BIMAL AUTO AGENCY INDIA PVT. LTD. 821. PRATHAM MOTORS PVT. LTD (0205-02-05), 833. VARUN MOTORS PVT. LTD. (0292-02-02), 843. MANDOVI MOTORS (0201-02-09), MUNICIPAL
(0216-02-04), 6TH CROSS, OFF OLD AIRPORT #58/5 KUDLU VILLAGE, NEXT TO ZEE SCHOOL, BEARING NO. 27/1 & 27/2, SURVEY NO. 41/3 & NO. 133 (OLD NO.S 133 & 133/1), BULL TEMPLE
ROAD, HAL 2ND STAGE POST, BANGALORE - SARJAPUR HOBLI, ANEKAL TALUK, 42/7 BAGALAGUNTA, HESSARGHATTA MAIN ROAD, BBMP WARD NO. 49, K G NAGAR,
560038 BANGALORE - 560034 ROAD, NEAR WIDIA SCHOOL BUS STOP, BANGALORE, KARNATAKA-560018. - 560018
PH :9972398106. PH :9900058466. NAGASANDRA POST, BANGALORE. - 560073 PH :9945235516.
809. MANDOVI MOTORS PVT LTD. (0201-02-0C), NO 1 822. RNS MOTORS LIMITED (7301-02-0H), PLOT PH :7338286729. BANGALORE (HEBBAGODI )
TO 5, NAVODAYA HBSC, 4TH STAGE, 4TH MAIN, NO.129, KIADB INDUSTRIAL AREA, HEBBAGODI 834. MANDOVI MOTORS PVT LTD. (0201-02-0J), SITE
844. RNS MOTORS (0210-02-01), SURVEY NO. 48,
RAJAJINAGAR INDUSTRIAL TOWN, VILLAGE, BOMMASANDRA, JIGINI LINK ROAD, NO. 58/1, J.B. KAVAL, MAJOR SANDEEP
HEBBAGODI, HOSUR MAIN ROAD,ANEKAL
BASAWESHWAR NAGAR - 560044 BANGALORE - 562158 UNNIKRISHNAN ROAD, VIDYARANYAPURA,
TALUK, BANGALORE URBAN DIST,
PH :9945235537. PH :9538965771. BANGALORE. - 560097
KARNATAKA - 560 099
810. KALYANI MOTORS PVT. LTD. (0211-02-04), 823. KALYANI MOTORS PVT. LTD. (0291-02-02), 10/1, PH :9945235514.
PH :6366938829.
119/1, 11TH HEBBAL , AMANIKERE KASABA HOBLI, YOGESH 835. KATARIA AUTOMOBILES PVT. LTD. (0293-02-01),
CROSS,MALLESHWARAM,BANGALORE, - NAGAR, BANGALORE - 560024 SURVEY NO. 8/3, 10/4, 10/2, VILLAGE – BANGALORE- KP ROAD
560003 PH :9740985324 , 7760983887. THALAGHATTAPURA, KANAKAPURA MAIN 845. KALYANI MOTORS (0213-02-06), SURVEY NO.
PH :9886026519. 824. BIMAL AUTO AGENCY INDIA PVT. LTD. ROAD, NEAR NANDI TOYOTA, UTTARAHALLI 67, NH-209, NAVARATAN GARDENS, (NEAR
811. MANDOVI MOTORS PVT LTD. (0201-02-0D), 6/8, (0286-02-01), #184/185, OPP. FORUM VALUE HOBLI, TALUK - BENGALURU SOUTH, IOCL PETROL BUNK) DODDAKALASANDRA
SHREE GANGA GARDEN, GANGA NILAYA, MALL, WHITE FIELD MAIN ROAD, BANGALORE - BANGALORE, KARNATAKA. - 560109 VILL., UTTARAHALLI HOBLI, KONANAKUNTE,
HENNUR CROSS, KALYANAGAR POST - 560043 560066 PH :8884434340. KANAKAPURA-KENGERI ROAD, BANGALORE,
PH :9845132048. PH :9900245979. 836. RNS MOTORS LIMITED (7301-02-0J), SY. NO. KARNATAKA - 560062
812. MANDOVI MOTORS PVT LTD. (0201-02-0E), SY 825. SURAKSHAA CAR CARE PVT. LTD. (0280-02-04), 11/2 & 12/1, VILLAGE – ARAKERE, BEGUR PH :9900039844/9900073254.
NO:26,AMBLIPURA VILLAGE,VATHUR PLOT NO. 8 & 9, NEXT TO BDA COMPLEX, 4TH HOBLI, BANNERGHATTA ROAD, BANGALORE – BANGARPET
HOBLI,BANGALORE,EAST TALUKA. - 560102 BLOCK, 100 FT ROAD, KORAMANGALA, 560 076. - 560076
PH :9945235518. BANGALORE, KARNATAKA - 560034 PH :7760982836. 846. SURAKSHA CAR CARE PVT. LTD. (OR04-OR-01),
813. MANDOVI MOTORS PVT LTD. (0201-02-9B), PH :8884419010. 837. SURAKSHAA CAR CARE PVT. LTD. (0280-02-05), 180/4 OPP. APMC YARD, KOLAR-BANGARPET
PLOT NO.-257/1-13, BANNERGHATTA ROAD, 826. KALYANI MOTORS PVT. LTD. (0287-02-01), # SURVEY NO.2/6, BERTENA AGRAHARA, OPP. ROAD, BANGARPET (KARNATAKA) - 563114
N.S. PALYA, BANGALORE - 560076 10/5, NAGADEVANHALLI, KENGERI, MYSORE METRO CASH & CARRY, HOSUR MAIN ROAD, PH :9449865601.
PH :9945238559. ROAD, BANGALORE, KARNATAKA - 560056 BANGALORE. - 560100 BANGLORE - BOMMANAHALLI
814. KALYANI MOTORS PVT. LTD. (0213-02-02), SY. PH :9900019961. PH :8884471200. 847. VARUN MOTORS PVT LTD (0292-02-03), SY NO:
NO.:58/1A & 61/22, AVALAHALLI, NH-4, K.R. 827. BIMAL AUTO AGENCY INDIA PVT. LTD. 838. KALYANI MOTORS PVT. LTD. (0211-02-05), 136 ( OLD NO 54/8) SANGEGURUVANAHALLI(VP)
PURAM, BANGALORE. - 560049 (0216-02-06), PLOT NO. 82, DODDA BANASWADI SY.NO.8/4, G HOSAHALLI MAIN ROAD, KAMAKSHIPALAYA, WARD NO: 17,
PH :9900037122. MAIN ROAD, BEHIND IOC PETROL PUMP, NEXT GOLLARAHATTI, V N POST, YESHWANTPURA VRISHABHAVATHI NAGAR, MAGADI ROAD,
815. SURAKSHAA CAR CARE PVT LTD (0280-02-01), TO AIYAPPA TEMPLE, BANASWADI, HOBLI, MAGADI MAIN ROAD, BANGALORE - BANGALORE NORTH THALUK,
30/3 K AGRAHARA, HOSUR MAIN ROAD, BANGALORE, KARNATAKA - 560033 560091 BANGALORE,KARNATAKA - 560079
ELECTRONIC CITY, BANGALORE - 580100 PH :9738501996. PH :9900080229. PH :9513683052.
PH :9449865605. 828. MANDOVI MOTORS PVT LTD. (0201-02-0H), 839. SURAKSHA CAR CARE (0280-02-06), BEARING
BANTWAL
816. KALYANI MOTORS PVT. LTD. (0213-02-03), BBMP NO.4C, WARD NO.83, JOLLY ESTATE, NO. 54/4-320/2, BEGUR HOBLI, BOMMANAHALLI
NO.129/4, KUNDALAHALLI VILLAGE, OPP. TO OLD MADRAS ROAD, NAGAWARAPALYA, VILLAGE, BEGUR HOBLI, BANGALORE, 848. MANDOVI MOTORS PVT LTD. (TR01-TR-01),
BROOKE FIELD HOSPITAL, BROOKFIELD, BANGALORE - 560093 KARNATAKA. - 560 068 NH-75, PANEMANGALORE, B.C. ROAD,
BENGALURU. - 574239 PH :9945235533. PH :9449865665. BANTWAL, KARANATAKA - 574231
PH :9900038119. 829. VARUN MOTORS PVT. LTD. (0292-02-01), HNO. 840. PRATHAM MOTORS PVT. LTD (0205-02-07), PH :9008810123.
817. SURAKSHAA CAR CARE PVT. LTD. (0280-02-02), 72/19-6 & HNO. 67/2, YESHWANTPUR SUVEY NO. 43/1, ON SH-35, VILLAGE - YAMARE, BELGAUM
#54/1, BOMMANAHALLI, HOSUR MAIN ROAD, INDUSTRIAL SUBURB, WARD NO. 10, RAJAJI SARJAPUR MAIN ROAD, POST - 849. SHANTESHA MOTOR (P) LTD (E801-E8-01),
BANGALORE - 560068 NAGAR, BANGALORE. - 560022 DOMMASANDRA, TALUKA - ANEKAL,
MUJAWAR COMPOUND,NEHRU
PH :9449865655. PH :7337834582. BENGALURU RURAL, KARNATAKA. - 562125
NAGAR,BELGAUM, - 590010
818. KALYANI MOTORS PVT. LTD. (0213-02-04), 830. KALYANI MOTORS PVT. LTD. (0213-02-05), PLOT PH :9611834659.
PH :9902043711.
250/1,BILEKAHALLI, BANNERGHATTA ROAD, NO. 74/5, HORMAVU MAIN ROAD, NEAR BBMP 841. SURAKSHAA CAR CARE PVT. LTD. (0280-02-07), 850. SHANTESHA MOTOR (P) LTD (E801-E8-04),
BENGALURUE - 560076 OFFICE, KR PURAM HOBLI, BANGALORE. - SURVEY NO 106/2A, CHANDAPURA MUNICIPAL
PLOT NO. 8, SURVEY NO. 251/51, HAVLOCK
PH :9686445406. 560043 TOWN,MUTHASANDRA HOSUR MAIN ROAD,
ROAD CAMP, BELGAUM - 290010
819. BIMAL AUTO AGENCY INDIA PVT. LTD. PH :9900037114. ANEKAL TQ, BANGALORE, KARNATAKA -
PH :9588645387.
(0218-02-04), PLOT NO.37/38, 2ND STAGE, 831. KATARIA AUTOMOBILES PVT. LTD. (0294-02-01), 560099 851. SHANTESHA MOTOR (P) LTD (E801-E8-03), CTS
PEENYA INDUSTRIAL AREA, BANGALORE - NO. 5, 15TH CROSS, KOLANDAPPA GARDEN, PH :94498 65666.
NO. 519, 520, BESIDE PARATA
560058 ANEPALYA, POST – AADUGODI, BANGALORE. - 842. KALYANI MOTORS (0291-02-03), SURVEY NO.
CORNER,CONGRESS ROAD, TILAKWADI,
PH :9945237213. 560030 194/5, HUNSEMARANAHALLI, JALA HOBLI,
BELGAUM - 590006
820. RNS MOTORS (7301-02-0G), 106/7, BELLARY PH :7349291802. DEVANAHALLI TALUK, (YELAHANKA NEW
PH :8884433911.
ROAD, NEAR IOC PETROL BUNK, 832. MANDOVI MOTORS PVT LTD. (0201-02-0I), TALUK), NEW KEMPEGOWDA INTERNATIONAL 852. SHANTESHA MOTORS (P) LTD (E801-E8-06),
AMRUTHAALLI, NEAR HEBBAL FLYOVER, KATHA NO.4, SITUATED AT GANAKAL AIRPORT ROAD, NORTH
PLOT NO. 2/I, RS NO. 29, KIADB INDUSTRIAL
BENGALURU (KARNATAKA) - 560092 DHAKALE, SRINIVASPURA, KENGERI HOBLLI, PH :9740985324.
AREA, KIADB BAUXITE ROAD, KANGRALI BK,
PH :6364884787. UTTARAHALLI, BANGALORE - 560060
BELGAUM. - 590010
PH :9945235516.
PH :9731396805.

32
Dealer Workshop (AS ON 31.05.2023 )

BELLARY 862. SAKETH AUTOMOBILES (CKN1-CKN-01), SITE 871. SAKETH AUTOMOBILES (AL01-AL-01), NEAR 880. SHANTESHA MOTORS PVT. LTD. (IR01-IR-01),
NO. 9 & 10, SY. NO. 96/1, OPP. VEDA COMPLEX, NH-4, M H ROAD, RS NO.106/3D/2A, APMC ROAD, GOKAK,
853. K.P.F. PVT. LTD. (G201-G2-01), P.B. NO.
SUJIMALLESHWARA NAGAR, BELLARY ROAD, CHITRADURGA - 572130 BELGAUM DISTT. - 591307
58,BELLARY HOSPET
CHALLAKERE. - 577522 PH :9686550313. PH :7829925760.
ROAD,ALLIPURA,BELLARY - 583101
PH :9686550126. DAVANGERE GONIKOPPAL
PH :9449876025.
CHAMARAJANAGAR 872. SHRUTI MOTORS (S101-S1-01), NEAR 881. MANDOVI MOTORS PVT LTD. (2501-U3-07),
BELTHANGADY
863. MANDOVI MOTORS PVT LTD. (0E01-0E-01), RAJ PANCHDEVASTHANA, P. B. ROAD, KAIKERY VILLAGE,GONIKOPPAL,, - 571213
854. BHARATH AUTO CARS PVT. LTD. (4503-HM-04),
KAMAL BUILDING, SATHYAMANGALA ROAD, DAVANGERE, KARNATAKA - 577004 PH :9900064873.
MAIN ROAD, BELTHANGADY, BELTHANGADY
KUVEMPU EXTENSION, CHAMRAJNAGAR PH :9880401284. GUDIBANDHA
TALUK DK DISTRICT - 574214
(KARNATAKA) - 571313 DAVENGERE
PH :9886543230. 882. BIMAL AUTO AGENCY INDIA PVT. LTD.
PH :9845445586.
BHADRAWATI 873. SHRUTI MOTORS (S101-S1-02), DOOR NO. (SGT1-SGT-01), DOOR NO:160, 1ST WARD, OPP
CHANNAGIRI 473/1, SURVEY NO. 18/1, BESIDE GMIT TO GOVERNMENT BUS STAND, BAGEPALLI
855. SHRUTI MOTORS (FB01-FB-01), SURVEY NO.
864. SHRUTI MOTORS (BUQ1-BUQ-01), SURVEY COLLEGE, OPP. M&M SHOWROOM, OLD P. B. ROAD, GUDIBANDA, CHICKABALLAPURA
18/4, BH ROAD,KADADAKATTE HOBLI,
NO.5, MACHANAYAKANAHALLI, OPP. FIRE ROAD, DAVANGERE, KARNATAKA - 577001 DISTRICT KARNATAKA - 561209
KADADAKATTE, BHADRAVATI, SHIMOGA DIST.,
STATION, CHITRADURGA ROAD, N.H.13, PH :9880401284. PH :9742261903.
KARNATAKA - 577229
CHANNAGIRI DISTT. DAVANGERE - 577213 DEVANAHALLI GULBARGA
PH :7899885404.
PH :7899934143.
BHATKAL 874. BIMAL AUTO AGENCY INDIA PVT. LTD. 883. LAHOTI MOTORS PVT. LTD (E902-E9-01),
CHANNAPATNA (WH01-WH-01), SURVEY NO.241/114/6, 11TH LAHOTI GARDENS,NEAR KMF, HUMNABAD
856. BHARATH AUTO CARS PVT. LTD.
865. KALYANI MOTORS PVT. LTD. (BSX1-BSX-01), WARD, BB ROAD, DEVANAHALLI, BANGALORE ROAD,GULBARGA - 585104
(CEF1-CEF-01), SURVEY NO. 157/2A, SUSGADI
PROPERTY NO.58, MALUR GRAMA, MALLUR DISTT: - 562110 PH :9480825014.
VILLAGE, NH66, BHATKAL, UTTARKANNADA
HOBLI, CHANNAPATNA TALUKA RAMANAGARA PH :9742262514. 884. LAHOTI MOTORS PVT. LTD (E902-E9-02), DOOR
DISTRICT, KARNATAKA. - 581320
DISTRICT - 562160 DHARWAD NO. 7-12-11, 2ND BLOCK, OPP. GUNJ BUS
PH :9008693940.
PH :9845066682. STAND, HUMNABAD ROAD, GULBARGA,
BIDAR 875. REVANKAR MOTORS PVT. LTD. (BIX1-BIX-01),
CHANNARAYAPATNA KARNATAKA. - 585104
SURVEY NO.1, PLOT NO. 10, OLD PB ROAD,
857. LAHOTI MOTORS PVT. LTD (EX01-EX-01), SI PH :7619342035.
866. VENKAT MOTORS (HC01-HC-01), PLOT NO. 389, OPP. KVG BANK, SAYDAPUR VILLAGE,
50/51,PRATAP NAGAR, UDGIR ROAD, KIADB
36/3, 132/1, BESIDES THIRUMALA RICE MILL, DHARWAD, KARNATAKA - 580001 GUNDLUPET
INDUSTRIAL AREA, NAUBAD, BIDAR - 585402
MYSORE ROAD, CHANNARAYAPATNA, PH :8861006707. 885. FRIENDLY MOTORS (INDIA) PVT. LTD.
PH :8884412049.
DISTRICT: HASSAN, KARNATAKA. - 573116 DODDABALLAPUR (BPU1-BPU-01), ASSESSMENT NO. 2491/S. NO.
858. LAHOTI MOTORS PVT. LTD (EX01-EX-02), PLOT
PH :8147077144. 51/1, 2, 3, N.S. 11 AND ASSESSMENT NO.
NO. 58, NAUBAD INDUSTRIAL AREA, PRATAP 876. PRATHAM MOTORS PVT. LTD. (BUA1-BUA-01),
CHICKBALLAPUR 2494/S. NO. 51/ N.S. 11, MYSORE-OOTY ROAD,
NAGAR, BIDAR. - 585 401 PLOT NO. 50, OBADENAHALLI INDUSTRIAL
GUNDLUPET. - 571111
PH :9108707709. 867. BIMAL AUTO AGENCY INDIA PVT. LTD. AREA, DODDABALLAPUR 3RD PHASE, SY. NO.
PH :9686855799.
BIJAPUR (KJ02-KJ-01), NO. 169/1, AMMANI 107, AREHALLI GUDDADAHALLI, KASABA HOBLI
KANDAVARAKERE VILLAGE, KASABA HOBLI, TALUK – DODDABALLAPUR, DISTRICT – HAGARIBOMMANAHALLI
859. RNS MOTORS (7301-T7-0I), SURVEY NO.25K/1,
CHIKBALLAPURA DISTRICT - 562101 BENGALURU RURAL. - 561203 886. MUNEER ENTERPRISES PVT. LTD.
CHITRADURGA SHOLAPUR ROAD, VIJAYPURA,
PH :9742262499. PH :9886671687. (BUX1-BUX-01), SITE NO.112A/2 & 112A/3,
BIJAPUR DISTT. KARNATAKA - 586109
CHICKMAGALUR GADAG BLOCK NO.2, WARD NO.:3,
PH :8861208998.
HAGARIBOMANAHALLI PANCHAYAT, BELLARY
BUDHIGERE 868. SHRUTI MOTORS (B701-3F-02), AIT CIRCLE, KM 877. RNS MOTORS (7301-RK-0E), PLOT NO. 64,
DISTRICT. - 583212
ROAD, CHIKMANGALUR - 577102 DIAGONALLY OPP. REGIONAL TRANSPORT
860. BIMAL (SGM1-SGM-SGM1-01), KHATTA PH :9481343007.
PH :9980157446. OFFICE, HUBLI GADAG MAIN ROAD, GADAG -
NO:115,SY. NO. 128/33, MANDUR MAIN ROAD,
582103 HALIYAL
BUDIGERE CROSS, MANDUR VILLAGE, NEXT CHIKODI
PH :9538925602. 887. RNS MOTORS (SFM1-SFM-01), SURVEY NO:
TO IOCL PETROL BUNK, BANGALORE EAST 869. SHANTESHA MOTORS (E801-ZB-05), OPP. IOC
GANGAVATI 347P/27, DOOR NO:B1180/15 & B1180/16,
TALUK, BANGALORE, - 560049 PUMP, NEAR B.K.COLLEGE, MIRAJ ROAD,
HANUMAN COMPLEX, HALIYAL CIRCLE, MAIN
PH :9742259528. CHIKKODI, KARNATAKA - 591201 878. MUNEER ENTERPRISES PVT. LTD.
ROAD, HALIYAL TOWN & TALUK, UTTARA
BYNDOOR PH :7829925790. (N701-KA-03), JAGANMATHA
KANNADA DISTRICT,KARNATAKA - 581329
CHINTAMANI COMPLEX,RAICHUR ROAD,GANGAVATI, -
861. ABHARAN MOTORS PVT LTD (BUH1-BUH-01), PH :8284200200.
583227
3-256 & 3-257, SOUPARNIKA COMPLEX, NH 66, 870. PRATHAM MOTORS PVT. LTD (0205-BQ-06),
PH :9449870754. HARAHOLLI
VILLAGE - YEDATHRE, BYNDOOR, KUNDAPUR SURVEY NO. 33, NEXT TO VIJAYA P U
GAURIBIDANUR 888. SURAKSHA (SIH1-SIH-SIH1-01), SURVEY NO.
TALUK, UDUPI DISTT. - 576214 COLLEGE, OPP. GOPASANDRA LAKE,
40/4, HOSAKOTE VILLAGE, HAROHALLI HOBLI,
PH :7899751777. SREENIVASPURA MAIN ROAD, CHINTAMANI, 879. MANDOVI MOTORS PVT LTD. (BUY1-BUY-01),
KANAKAPURA TALUK, RAMANAGARA, - 562112
CHALLAKERE KARNATAKA - 563125 NO.592/522, E DIVISION, OPP. PUSHPANJALI
PH :9449865608.
PH :7899761301. TALKIES, B.H. ROAD, GAURIBIDANUR TOWN,
DISTT. CHIKBALLAPUR - 561210 HASSAN
CHITRADURGA
PH :8217453513.
GOKAK

33
Dealer Workshop (AS ON 31.05.2023 )
889. VENKAT MOTORS (C802-C8-01), NO. 326, 898. RNS MOTORS (7301-73-01), PUNE - BANGALOR 908. SHANTESHA (SFO1-SFO-01), PLOT NO. 219, 917. MUNEER ENTERPRISES PVT. LTD.
HASSAN GROWTH CENTRE, H.N. PURA ROAD, ROAD, UNKAL, HUBLI - 580025 KITTUR INDUSTRIAL AREA (KIADB), POONA (BOQ1-BOQ-01), PLOT NO. 11, BASAMMA
HASSAN - 573201 PH :9538965902. BANGALORE HIGHWAY (NH-4),KITTUR TOWN COMPLEX, RAICHUR ROAD, LINGSUGUR,
PH :9844044038. 899. RNS MOTORS (7301-73-0F), GOKUL ROAD AND TALUK, BELGAUM DISTRICT, - 591115 RAICHUR, KARNATAKA - 584122
HAVERI MUREDESHWAR BHAVAN , HUBLI - 580030 PH :9731396808. PH :9480830255.
PH :8861208532. KOLAR MADDUR
890. REVANKAR MOTORS PVT LTD (BBM1-BBM-01),
900. REVANKAR MOTORS PVT. LTD. (7303-73-01),
NEAR TMAE SOCIETY CAMPUS, 909. MANDOVI MOTORS PVT LTD. (0201-QU-0F), 67/3 918. MANDOVI MOTORS PVT LTD. (BMK1-BMK-01),
CTS NO.165/A, WARD NO.III, DESHPANDE
IJARILAKAMAPUR, PB ROAD, HAVERI - 581110 BANGALORE-CHENNAI HIGHWAY, SURVEY NO 802/2A4B, NEAR SANJAY
NAGAR, HUBLI (KARNATAKA) - 580029
PH :7022016903. KONDARAJANA HALLI, OPP HOTEL SHANTHI THEATRE, BM ROAD, MADDUR TOWN,MANDYA
PH :8792008301.
H-CROSS SAGAR, KOLAR. - 563101 DISTRICT, KARNATAKA - 571428
HUNSUR PH :9740020734. PH :90080 31608.
891. BIMAL AUTO AGENCY INDIA PVT. LTD.
901. FRIENDLY MOTORS(INDIA) PVT. LTD. KOPPAL MADIKERI
(CRQ1-CRQ-01), PART NO.1, SITE NO.36, SBT
(GLI1-GLI-01), M-18 & M-19, KSSIDC INDUSTRIAL
COMPLEX, HOSKOTE-BANGALORE ROAD, 910. K.P.F. PVT. LTD. (ER01-ER-01), SL. 283/10, NEAR 919. FRIENDLY MOTORS (INDIA) PVT. LTD.
ESTATE, BM BYPASS ROAD, HUNSUR, MYSORE
KARIYANAPURA, H CROSS, SHIDLAGHATTA MINI VIDHAN SOUDHA, KOPPAL HOSPET ROAD (2502-QX-02), BASAPPA THEATURE BUILDING,
DISTRICT, KARNATAKA - 571105
TALUK, BANGALORE RURAL DISTT. NH63, KOPPAL - 583238 DASAWAL ROAD,MADIKERI KODAGU DISTRICT.
PH :7022669699.
CHIKKABALLAPURA - 562122 PH :9449876027. - 571201
PH :9738948126. JEWARGI PH :9606073867.
KRISHNARAJANAGARA (KRNAGARA)
HEBRI 902. LAHOTI (SLI1-SLI-01), S NO: 125, PLOT NO:7, MAGADI
911. FRIENDLY MOTORS(INDIA) PVT. LTD.
FILTER BED ROAD, OPP. BUS DEPOT,
892. ABHARAN MOTORS PVT LTD (BGD1-BGD-01), (SCQ1-SCQ-01), NO:D, 920. PRATHAM MOTORS PVT. LTD. (BHX1-BHX-01),
JEWARGI, KALABURGI DISTRICT (FORMERLY
SURVEY NO. 61-7C1P1 & 61-2P1, VILLAGE & DORNAHALLI,DODDEKOPPALU GRAMA SY NO:92/2, THIRUMALAI VILLAGE, KASABA
GULABARGA) , KARNATAK-585310. - 585310
TALUK - HEBRI, KARKALA, DIST.-UDUPI, PANCHAYAT,KASABA HOBLI, HOBLI, MAGADI TOWN & TALUK, RAMANAGARA
PH :9480825004.
KARNATAKA. - 576112 KRISHNARAJANAGARA, MYSORE DISTRICT, KARANATAKA - 562120
PH :9900077605. KADABA DISTRICT,KARNATAKA - 571602 PH :9900058483.
HEGGADADEVANA KOTE (H D KOTE) 903. MANDOVI MOTORS PVT LTD. (BYE1-BYE-01), PH :8971159430. MANDYA
SURVEY NO.-11/20, KALARA, KADABA POST, KRISHNARAJAPET
893. FRIENDLY MOTORS (INDIA) PVT. LTD. 921. MANDOVI MOTORS PVT LTD. (2501-BD-06),
DAKSHIN KANNADA DISTT., KARNATAKA -
(CJC1-CJC-01), SURVEY NO. 5/4, VILLAGE – 912. MANDOVI MOTORS PVT LTD. (BMP1-BMP-01), 1660/A, KALLAHALLI EXTENSION, M.C. ROAD, -
574221
YARAHALLI, KASABA HOBLI, TALUK – KHATA NO.3094, SY. NO.278, MYSORE 571401
PH :9740912365.
H.D.KOTE, DISTRICT – MYSORE. - 571125 CHENNERAYAPATNA ROAD (OPP. TO K.B.C. PH :9611165873.
PH :9686855799. KADUR FUEL STATION), KRISHARAJAPET TOWN, MANGALORE
HESSARGHATA 904. SHRUTI MOTORS (BQS1-BQS-01), SHOP NO. 1 & TALUK MANDYA DISTT. KARNATAKA - 571423
922. MANDOVI MOTORS PVT LTD. (4502-45-01),
2, DAGA COMPLEX, ULUKINAKALLU, NEAR PH :9845132038.
894. BIMAL (SGN1-SGN-01), SY NO 294/3, ARVIND BUILDING, BALMATTA ROAD,
PEARLS CLUB, B.H. ROAD, KADUR, DISTRICT – KUMTA
HESARAGHATTA VILLAGE YELAHANKA TALUK, HAMPANKATTA, MANGALORE - 575001
CHIKMAGALUR. - 577548
BENGALURU,KARNATAKA - 560088 913. BHARATH AUTO CARS PVT. LTD. PH :9845107701.
PH :8904823736.
PH :9743658662. (AFA2-AFA-01), MALLYA'S COMPOUND, NH-66, 923. BHARATH AUTO CARS PVT. LTD. (4503-45-01),
KANAKAPURA ALVEKODI KALBAGH VILLAGE, KUMTA NH-17, KUNTIKAN JUNCTION, DEREBAIL, NEAR
HOSDURGA
905. KALYANI MOTORS PVT. LTD. (BXY1-BXY-01), (KARNATAKA) - 581334 A.J. HOSPITAL, MANGALORE - 575004
895. SAKETH AUTOMOBILES (BWO1-BWO-01),
SURVEY NO. 447/1B, KASABA HOBIL, PH :9448979530. PH :9886785730.
ASSESSMENT NO. 9310/6, PLOT NO. 6,
BUDIGUPPE GRAMA, TALUKA- KANAKAPURA, KUNDAPUR 924. MANDOVI MOTORS PVT LTD. (4502-45-03), NO.,
HOSADURGA TOWN, SARASWATI BADAVANE,
DISTRICT- RAMANAGARA. KARNATAKA. - HASSAN GROWTH CENTRE,ADYAR,N.H.
HOSADURGA, DIST.-CHITRADURGA, 914. ABHARAN MOTORS PVT LTD (G601-CY-02),
562117 -48,,MANGALORE - 575007
KARNATAKA. - 577 527 NH-17, THAKKATTE, KUNDAPURA - 272877
PH :9900599933. PH :9845514146.
PH :7625088946. PH :9880197524.
KARKALA 925. MANDOVI MOTORS PVT LTD. (4502-45-07),
HOSKOTE KUNIGAL BALLAL INDUSTRIAL ESTATE, YAYYADI,
906. ABHARAN MOTORS PVT LTD (G601-HY-03),
896. BIMAL AUTO AGENCY INDIA PVT. LTD. 915. SAKETH AUTOMOBILES (VQ01-VQ-01), NEAR MANGALORE,KARNATAKA - 575008
NH-13, MANGALORE KUDREMUKH ROAD,
(0216-SM-05), NO. 205/108, SITUATED AT KRS AGRAHARA,BM ROAD, KUNIGAL, TUMKUR PH :9880079235.
PULKERI, KARKALA - 574104
HOSKOTE TALUK, KASABA HOSKOTE TOWN, DISTRICT, KARNATAKA - 572130 926. BHARATH AUTO CARS PVT. LTD. (4503-45-06),
PH :9880232666.
DISTT.- BANGALORE - 562114 PH :9686550127. PLOT NO. 290/1, 291/1, KODIALBAIL VILLAGE,
PH :9742281726. KARWAR NEXT TO BHARATH BEEDI WORKS PVT. LTD.,
KUSHAL NAGAR
HOSPET 907. BHARATH AUTO CARS PVT. LTD. (8J01-8J-01), BUNTS HOSTEL, KADRI ROAD, MANGALORE,
916. MANDOVI MOTORS PVT LTD. (VN01-VN-01), SY KARNATAKA - 575002
SURVEY NO. 459/2B, 456/2B AND 456/3,
897. MUNEER ENTERPRISES PVT. LTD. NO:88,MADAPATANA,KUSHAL PH :9886333030.
CHITTAKULA VILLAGE, KARWAR TALUKA,
(N701-N7-01), BELLARY NAGAR,SOMVARPUR,NORTH KODAGU, 927. MANDOVI MOTORS PVT LTD. (4502-45-08),
UTTARKANNADA DISTRICT, KARNATAKA. -
ROAD,SANKLAPUR,HOSPET , - 583203 KARNATAKA - 571234 DOOR NO. 2-63/4, SUJITH BAGH LANE,
581301
PH :7619505001. PH :9900080893. YEYYADE, MANGALORE, DISTRICT – DAKSHINA
PH :7829567400.
HUBLI KITTUR, BELGAUM LINGASUGUR KANNADA, KARNATAKA - 575008
PH :9880278077.

34
Dealer Workshop (AS ON 31.05.2023 )
928. BHARATH AUTO CARS PVT. LTD. (4503-45-08), 938. FRIENDLY MOTORS (INDIA) PVT. LTD. RANEBENNUR 957. MUNEER ENTERPRISES PVT. LTD.
S. NO. 1376/1-41, 1375/41-2-A1P1, 2A1P3, (BYK1-BYK-01), 4340/4159/4, HULLAHALLI ROAD, (CTN1-CTN-01), SITE NO:31C/1B & PLOT NO.1,
947. REVANKAR MOTORS (BXV1-BXV-01),
1373/1-40, 1369/1-40-A2, KASABA BAZAR, NANJANGUD, DISTRICT – MYSORE, BELLARY - SIRUGUPPA MAIN ROAD,
SCHEDULE A-2, OPP. STJIT ENGINEERING
KANDADAPALLI, KUDROLI, TALUK - KARNATAKA. - 571301 SIRUGUPPA TALUK, BELLARY DISTRICT. -
COLLEGE, P B ROAD, RANEBENUR,
MANGALORE, MANGALORE, KARNATAKA. - PH :9686855799. 583121
KARNATAKA. - 581115
575003 NARASIMHARAJAPURA PH :7619505001.
PH :8830947883.
PH :9886785730. SOMWARPET
939. SHRUTI MOTORS (SPP1-SPP-01), SURVEY NO # SAGAR
MUDBIDRI SURVEY NO.173,/P KOPPA ROAD, 958. MANDOVI MOTORS PVT LTD. (CSG1-CSG-01),
948. SHRUTI MOTORS (WF01-WF-01), BESIDE H
929. BHARATH AUTO CARS PVT. LTD. (4503-HN-03), NAGALAPURA SURVEY NO.130 SITUATED AT MADIKERI
GANAPATHIYAPPA PETROL BUNK (BP), B H
BHARATH BEEDI COMPOUND, NEAR ALVAR'S VILLAGE,NARASIMHARAJAPURA, CHIKMAGALU ROAD, NAGROOR VILLAGE, BALAGUNDA POST,
ROAD, NH-206, SAGAR, SHIMOGA DISTT. -
HOSPITAL, MOODBIDRI - 574227 R DIST.,KARNATAKA - 577134 SOWMARPET TALUK, NORTH KODAGU DISTT. -
577401
PH :9886785430. PH :8310187660. 571236
PH :9740014703.
MUDHOL NELAMANGALA PH :9845115665.
SAKLESHPUR SRINIVASAPURA
930. VIJAY MOTOWINGS (ET01-ET-01), PLOT NO. 3B, 940. RNS MOTORS LIMITED (BBH1-BBH-01),
949. VENKAT MOTORS (BPW1-BPW-01), SITE NO. 19,
IN NARS NO. 15-2, WARD NO. 5, NO.167/2, TUMKUR ROAD, KASABA HOBLI, NH4, 959. SURAKSHAA CAR CARE PVT. LTD.
3RD WARD, SARASWATHIPURAM,
VISHWESHWAR COLONY, LOKAPUR ROAD, NELAMANGALA, BANGALORE RURAL DT., (BUR1-BUR-01), SY NO. 40, VPRD NO. 86,
SAKLESHPUR TOWN, DISTRICT – HASSAN. -
MUDHOL TOWN, BAGALKOT DIST. - 587 313 BENGALURU, KARNATAKA - 562123 PROPERTY NO. 84 & 87, CHALDIGANA HALLI
573134
PH :9606046173. PH :7259875385. GRAMA PANCHAYATH, PANNASAMAKANA
PH :7892809634.
MULKI NELYADI HALLI VILLAGE, SRINIVASAPURA POST &
SARJAPURA TALUK, DIST.-KOLAR, KARNATAKA - 563 135
931. BHARATH AUTO CARS PVT. LTD. (4503-QV-05), 941. BHARATH AUTO CARS PVT. LTD.
950. PRATHAM MOTORS PVT. LTD. (BSY1-BSY-01), PH :9449865601.
BHARATH BEEDI COMPOUND, NH-17 MULKI - (BPF1-BPF-01), SURVEY NO. 97/11P AND
574154 SURVEY NO. 97/9, VILLAGE - HOSAMAJALU
SURVEY NO. 476/3, SARJAPUR TOWN, TALUKA SULLIYA
– ANEKAL, SARJAPUR HOBLI, DISTRICT –
PH :9986020730. KAUKRADY, POST - NELYADI, TALUK - PUTTUR, 960. MANDOVI MOTORS PVT LTD. (4502-EW-04),
BANGALORE URBAN, KARNATAKA. - 562125
MURUDESHWAR DIST.-DAKSHIN KANNADA . - 574229 ODABAI SULLIA,MANGALORE MYSORE
PH :7760962890.
PH :9886072730. ROAD,KARNATAKA - 574239
932. RNS MOTORS (7301-T8-02), NH-17, SHIMOGA
OORGAUMPET PH :9900002325.
MANGALORE-BOMBAY ROAD, MURUDESHWAR,
KARNATAKA - 581350 942. BIMAL AUTO AGENCY (CODE UNDER
951. SHRUTI MOTORS (B701-B7-01), K.NO 599, SURATHKAL
SHANKARMUTT ROAD, SHIMOGA - 577201
PH :9538965969. CREATIONS-CODE UNDER CREATIONS-CODE 961. MANDOVI MOTORS PVT LTD. (4502-7G-02),
PH :9880401283.
MYSORE UNDER CREATIONS), SITE NO:10, NEW KATHA KANA ROAD, SURATHKAL - 574158
952. SHRUTI MOTORS (B701-B7-03), BLOCK L-1,
NO: 251, ROBERTSONPET, KGF, PH :9845514143.
933. MANDOVI MOTORS PVT LTD. (2501-25-01), NO: INDUSTRIAL ESTATE, BEHIND HP PETROL
OORGAUMPET, KOLAR DIST, KARNATAKA- T. NARASIPURA
5 K.R.S.ROAD, MYSORE - 570005 BUNK, SAGAR ROAD, SHIMOGA. - 577204
563122 - 563122
PH :9945248860. PH :9886829239. 962. MANDOVI MOTORS (SFL1-SFL-01), KHATA
PH :9513748707.
934. MANDOVI MOTORS PVT LTD. (2501-25-05), 953. SHRUTI MOTORS (B701-B7-05), SURVEY NO. NO:472/473/474, OPP TO SRI RAGHAVENDRA
NO.182/145/C, BANNUR ROAD, SIDHARTHA PADUBIDRI 41/3 & 41/4, HONNALI ROAD, SHANTHI NAGAR, SWAMY MUTT, CHAMARAJANAGAR ROAD, T.
NAGAR, MYSORE, KARNATAKA - 570011 943. ABHARAN MOTORS PVT LTD (CSI1-CSI-01), SHIMOGA. - 577201 NARASIPURA TOWN, MYSORE DISTRICT,
PH :9845939936. PLOT NO. 51/20, VILLAGE – PADUBETTU, PH :9986825115. KARNATAKA - 571124
935. FRIENDLY MOTORS (INDIA) PVT. LTD. PADUBIDRI TOWN, TALUKA & DISTRICT – SIDDAPUR PH :9845132038.
(2502-25-01), MANATHAVADI ROAD, UDUPI, KARNATAKA. - 574111 THIRTHAHALLI
954. BHARATH AUTO CARS PVT. LTD.
VIDYARANYA PURAM, MYSORE - 570008 PH :9880232999.
(BPY1-BPY-01), SURVEY NO. 211, NEAR IOCL 963. SHRUTI MOTORS (BQR1-BQR-01), PLOT NO.
PH :7259255558. PUTTUR PETROL BUNK, JOG ROAD, VILLAGE – HOSUR, 1507/2187, OPP. TO HEGDE PETROL PUMP,
936. MANDOVI MOTORS PVT LTD. (2501-25-08),
944. BHARATH AUTO CARS PVT. LTD. (4503-CZ-02), TALUK – SIDDAPUR, DISTRICT – UTTARA AGUMBE ROAD, THIRTHAHALLI . - 577432
217/2., HUNSUR ROAD, HINKAL POST, MYSORE,
NEAR RAIWAY STATION, HARADY, PUTTUR - KANNADA. - 581355 PH :7795851011.
KARNATAKA - 570017
517583 PH :9449402730. THOKOTU
PH :9845939937.
PH :9886072730. SIRISI
NAGAMANGALA 964. BHARATH AUTO CARS PVT. LTD.
RAICHUR 955. RNS MOTORS LTD (MQ01-MQ-01), SURVEY NO (QW01-QW-01), NH-66, KAPIKAD,
937. MANDOVI MOTORS PVT LTD (SFK1-SFK-01),
945. MUNEER ENTERPRISES PVT. LTD. 43/B, LANDAKANALLI VILLAGE, DODNALLI ULLAL,THOKOTTU, DAKSHINA KANNADA DISTT.
SURVEY NO:3316/2327,VISHALAXAMMA
(N701-3K-02), #12-10-64,GOUSHAL ROAD,SIYA GRAMA,SIRSI TALUK AND HOBALI, UTTAR - 575017
COMPLEX, T B BADAVANE B M ROAD,
TALAB AREA,RAICHUR - 584101 KANNADA, KARNATAKA - 581402 PH :9538796330.
NAGAMANGALA TOWN, MANDYA DISTRICT,
PH :9480830264. PH :9895979023. TIPTUR
KARNATAKA - 571432
PH :9845132038. RAMANAGARAM SIRSI 965. SAKETH AUTOMOBILES (H101-HV-03),
NANJANGUD 946. KALYANI MOTORS PVT. LTD. (0211-JB-02), 956. RNS MOTORS (7301-MQ-0D), K H B COLONY, BANDIHALLI INDUSTRIAL ESTATE, N.H.:206,
#K1318/2034C,OPP TO ROTARY HOSPITAL,BM SIRSI - 581402 TIPTUR, KARNATAKA - 572201
ROAD, RAMNAGARAM - 571511 PH :9538925606. PH :9945301023.
PH :9686689007. SIRUGUPPA TUMKUR

35
Dealer Workshop (AS ON 31.05.2023 )
966. SAKETH AUTOMOBILES (H101-H1-01), SIRA 975. INDUS MOTOR COMPANY PRIVATE LIMITED 984. POPULAR VEHICLE (1601-BQT-14), RE SURVEY 994. INDUS MOTOR COMPANY PRIVATE LIMITED
ROAD, TUMKUR - 572106 (2702-CJ-0A), M. C. ROAD, MITHRAPURAM, NO 581/5, BLOCK NO 33, ANCHAL VILLAGE, (4701-47-08), NEAR STEEL COMPLEX,
PH :9686550323. ADOOR, PATHANMTHITTA - 689518 NEAR ALBILAL DRIVING SCHOOL, KAITHADY NALLALAM, CALICUT - 673655
UDUPI PH :9745998303. JUNCTION, ANCHAL, KERALA - 691306 PH :9745998018.
976. AVG MOTORS LTD. (Y501-CJ-02), KOTTAMUKAL, PH :9778698200. 995. POPULAR VEHICLES & SERVICES LTD.
967. ABHARAN MOTORS PVT LTD (G601-G6-01), N.H.
K.P. ROAD, ADOOR PO, PATHANAMTHITTA, ANGAMALY (4702-47-07), NH-17 BYE PASS,PACHAKKIL,
17, NITTUR, UDUPI - 576103
KERALA - 691523 MALAPARAMBU P.O., KOZHIKODE, CALICUT -
PH :9880232999. 985. INDUS MOTOR COMPANY PRIVATE LIMITED
PH :9446355900. 673009
968. ABHARAN MOTORS PVT LTD (G601-G6-05), N0. (2702-JW-0F), ANGAMAALY KALADY ROAD, MC
ALANALLUR PH :9288012082.
305/1C, DOOR NO. 5-51A, RAILWAY STATION ROAD, ANGAMALY - 683572
996. CARINO MOTORS (CARINO AUTO INFRA PVT.
ROAD, INDRALI, UDUPI, DISTT. - UDUPI . - 977. KVR AUTOCARS PVT LTD (CIW1-CIW-01), PH :9745998434.
LTD.) (4704-47-01), RE SURVEY NO. 13,
576101 BUILDING NO. 10/1050, CHANDAPPADI, 986. POPULAR VEHICLES & SERVICES LTD.
BUILDING NO. 5/548, KRISHNARJUNA BUILDING,
PH :9686694341. MANNARKAD ROAD, POST – ALANALLUR, (2701-JW-0D), 182-AIRPORT JUNCTION
AREEKAD, VILLAGE AND PANCHAYATH –
UJIRE TALUKA – MANNARKAD, DISTRICT - PALAKKAD, NAGAR,M. C. ROAD,ANGAMALY - 683572
CHERUVANNUR, P.O. – NALLALAM, CALICUT
KERALA. - 678601 PH :8086078886.
969. BHARATH AUTO CARS PVT. LTD. (KOZHIKODE) , KERALA. - 673027
PH :9747020582. ATTINGAL
(BWT1-BWT-01), SURVEY NO.237-2B1, PH :7592898888, 7594997888.
MANGALORE-CHARMADY ROAD, NEAR INDIAN ALATHIYOOR 987. POPULAR VEHICLES & SERVICES LTD. CHALAKUDY
OIL PETROL PUMP, SAMPIGE NAGAR, UJIRE, 978. A M MOTORS (E601-CVJ-11), RE SURVEY NO. (1601-SX-07), PALAMKONAM,
997. BRD CAR WORLD LIMITED (ZJ02-ZJ-01),
BELTHANGADY TALUKA, DISTT. DAKSHINA 160/3, 161/7 (OLD SURVEY NO. 359/1), VILLAGE - PERUNKULAM,VIA-.ALAMCODE, ATTINGAL -
MURINGOOR P.O., CHALAKUDY - 680316
KANNADA, KARNATAKA. - 574240 ALATHIYOOR, TIRUR PONNAI ROAD, TALUKA - 695102
PH :9645176999.
PH :9886176130. TIRUR, DIST.-MALAPPURAM, KERALA. - 676102 PH :8086078788.
998. INDUS MOTOR COMPANY PRIVATE LIMITED
UPPINANGADI PH :9895940000 , 9072998833. 988. SARATHY AUTODRIVES PVT LTD (SX05-SX-01),
(ZJ03-ZJ-01), SURVEY NO. 53/1, 53/2 & 55/1,
ALATHUR SURVEY NO. 2952/17 & 2952/4, KIZHUVILLAM
970. MANDOVI MOTORS PVT LTD. (4502-NL-05), PANAMBILLY COLLEGE JUNCTION,
VILLAGE, ATTINGAL, CHARAYINKEEZHU
NR.PADMA VIDYA IOC PETROL STATION-34, 979. BRD CAR WORLD LIMITED (BRW1-BRW-01), VILLAGE-PERAMBRA, POTTA, TALUKA
TALUK, TRIVANDRUM DIST., KERALA. - 695 104
NEKKILADY, UPPINANGADY - 574241 SURVEY NO. 456/8, 455/8, 455/9, CHALAKKUDY, DISTT. THRISSUR, PIN-680307,
PH :9526052765.
PH :9740912365. ERATTUKKULAM, KATTUSSERY VILLAGE, KERALA - 680307
989. INDUS MOTOR COMPANY PRIVATE LIMITED
VIJAYPURA ALATHUR TALUKA, PALAKKAD DISTRICT, PH :9747557355.
(SX01-SX-01), SY. NO. 54/13, 14, 15, 16, (OLD SY.
KERALA - 678682
NO. 22, 22/13, 16), IN BLOCK NO. 3 OF VELLOOR CHALAKUDY/ CHILLAKUDDY/ THRISSUR
971. BIMAL AUTO AGENCY (BTZ1-BTZ-01), DOOR NO
PH :9745634999.
563, MARUTHI NAGAR, CHIKKABALLAPUR VILLAGE, EASTERN SIDE OF NATIONAL 999. POPULAR VEHICLES & SERVICES LTD.
ROAD, VIJAYAPURA TOWN, DEVANAHALLI ALLEPPY HIGHWAY 47, NEAR INTERNATIONAL SCHOOL, (2701-8U-0C), OPPSITE CCMK HOSPITAL,
TALUK, BANGALORE RURAL DISTRICT 980. INDUS MOTOR COMPANY PRIVATE LIMITED CHEMBAKAMANGALAM, KORANI PO, VELLIKULAM ROAD, CHALAKUDY, KERALA -
KARNATAKA. - 562135 (2702-E5-12), BLOCK NO. 145, RE-SURVEY NO. ATTINGAL, TRIVANDRUM DIST., KERALA. - 680307
PH :8884433996. 79, ALAPPUZHA WEST VILLAGE, 695104 PH :9072609600.
VITTAL AMBALAPPUZHA TALUK, ALAPPUZHA DIST. PH :9747550888. CHANGARAMKULAM
KERALA-699002. - 699002 BALARAMAPURAM 1000. A M MOTORS (VH01-VH-01), MELE
972. MANDOVI MOTORS PVT LTD. (CCE1-CCE-01),
PH :9745977744.
DOOR NO. 1-287 (9), JISHAN COMPLEX, VITTAL 990. POPULAR VEHICLES & SERVICES LTD. MANTHADAM, ALANKODE, P.O.,
TOWN, TALUKA – BANTWAL, DISTRICT – ALLEPY (1601-AQA-11), POOVAR ROAD, VAZHIMUKKU, CHANGARAMKULAM, MALAPPURAM DISTT,
DAKSHIN KANNADA - 574243 981. POPULAR VEHCILES (E502-E5-01), BUILDING BALARAMAPURAM P.O., TRIVANDRUM KERALA - 679585
PH :9008810123. NO. XVIII/135, DOOR NO. 13/449, CCSB ROAD, DISTRICT - 695501 PH :9895756008.
YADGIR PALACE WARD, CHUNGAM, ALAPPUZHA, PH :8943345922. CHAVAKKAD
KERALA-688011. - 688011 CALICUT 1001. BRD CAR WORLD LIMITED (A404-0J-06),
973. LAHOTI MOTORS (SFP1-SFP-01), SURVEY NO.
PH :9778698161.
101/1, GULSARAM VILLAGE, YADGIR TOWN & 991. INDUS MOTOR COMPANY PRIVATE LIMITED ORUMANAYOOR P.O.CHAVAKKAD,
DISTT, SHAHPUR TALUKA, KARNATAKA ALUVA (4701-47-01), MARUTI WORKSHOP, PANIKKER DISTRICT-THRISSUR - 680512
PH :9480825031. 982. BRD CAR WORLD LIMITED (A404-CBQ-09), RE ROAD, CALICUT, NADAKKAVE - 673011 PH :9645963999.
YELLAPUR SURVEY NO.330/7, NH-47, KUNNUMPURAM, PH :9745998019. 1002. SAI SERVICE PRIVATE LIMITED (0J02-0J-01),
PO-DESHAM PANCHAYATH, CHENGAMANAD, 992. POPULAR VEHICLES & SERVICES LTD. SURVEY NO. 26/5, MULLANTHARA PARAMBU,
974. REVANKAR MOTORS PVT. LTD (CUR1-CUR-01), (4702-47-02), BEHIND MIMS, OVUNGAL, KUNNAMKULAM ROAD, TALUK –
ALUVA. - 683102
PLOT NO. 4 A1A1A1 GR 5, UDYAM NAGAR, EASWARAMANGALAM ROAD, GOVINDAPURAM GURUVAYUR, CHAVAKKAD.) - 680506
PH :9745907100.
YELLAPUR POST, BALGIMANI, HUBLI-ANKOLA, P.O., CALICUT - 673016 PH :9495883852.
YELLAPUR TOWN, UTTARA KANNADA DIST., ANCHAL
PH :9846298613. CHENGANNUR
KARNATAKA. - 581359 983. SARATHY AUTO CARS (BQT1-BQT-01), SURVEY 993. INDUS MOTOR COMPANY PRIVATE LIMITED
PH :7090772121. NO. 371/9, VILLAGE – IDAMULAKKAL, P.O. – 1003. SARATHY AUTO CARS (C701-UL-06),
(4701-47-06), KOYA ROAD JUNCTION,
ANCHAL, TALUK – PUNALUR, DISTRICT – PRAVUMKOOD, THIRUVANVANDOOR P.O.
KERALA KOLLAM. - 691306
PUTHIYANCADI, POST WEST HILL, CALICUT -
CHENGANNUR TALUK, ALAPPUZHA (DIST) -
673005
ADOOR PH :9526906665. 689124
PH :9745998020.
PH :9447002647.

36
Dealer Workshop (AS ON 31.05.2023 )
1004. SAI SERVICE (UL03-UL-01), SURVEY NO. 1013. SAI SERVICE PRIVATE LIMITED (2705-27-01), 1024. INDUS MOTOR COMPANY PRIVATE LIMITED 1034. POPULAR VEHICLES & SERVICES LTD.
276/2,11,13,13-2-2, NEAR BPCL PUMP AND 50/1 15L, ,CHERANALLOOR (2702-A4-08), KUNAMKULLAM CHAVAKKAD (4702-K2-06), HIGHWAY JUNCTION,KANHANGAD
SURVEY NO. 276/12, M C ROAD, NEAR LABHAM ROAD,EDAPPALLY,COCHIN - 682024 ROAD, OPPOSITE CHOOLPURAM MOSQUE, SOUTH P.O .,KANHANGAD - 689641
MAVELI STORE,CHENGANNUR PO & PH :9645106339. GURUYOOR, THRISSUR - 680505 PH :9946104685.
MUNICIPAL, CHENGANUUR VILL & TALUK, 1014. SAI SERVICE PRIVATE LIMITED (2705-27-02), PH :9745998015. KANHANGAD
ALAPUZHA DIST., KERALA-689121 - 689121 NH-47,,PATHADIPALAM,EDAPPALLY,COCHIN - IRINJALAKUDA 1035. INDUS MOTOR COMPANY PRIVATE LIMITED
PH :9288024220. 682024
1025. BRD CAR WORLD LIMITED (A404-KQ-05), (4701-K2-0F), SURVEY NO.491/3A1 AND 491/3A2,
CHERPULASSERY PH :9645105057.
KARUPADANNA P.O., IRINJALAKUDA, AJANUR VILLAGE, KANHANGAD, HOSADURGA
1015. POPULAR VEHICLES & SERVICES LTD.
1005. KVR AUTOCARS PVT LTD (NB01-NB-01), THRISSUR - 680670 TALUK, KASARAGOD DISTT, KERALA. - 671541
(2701-27-04), NEAR LISI HOSPITAL, OPP. IMA
SURVEY NO. 154/4, RS NO. 154/4, VILLAGE – PH :9539006999. PH :9745998024.
BLOOD BANK, COCHIN, - 682018
CHERUPPALASSERY, TALUK – OTTAPPALAM, IRITTY KANJIRAPALLY
PH :9846298618.
DISTRICT – PALAKKAD - 679503
1016. INDUS MOTOR COMPANY PRIVATE LIMITED 1026. INDUS MOTOR COMPANY PRIVATE LIMITED 1036. INDUS MOTOR COMPANY PRIVATE LIMITED
PH :9747020582, 280100.
(2702-27-09), PALARIVATTOM KAKANAD ROAD, (RO02-VJ-02), SURVEY NO. 48, BUILDING NO. (7E01-9Y-02), VADAKUMBHAGAM KARAYIL,
CHERTHALA KAKANAD, COCHIN, - 682030 214, PERUPARAMBA, IRITTY, KANNUR, KERALA KUNNAMBHAGAM P.O. , KANJIRAPALLY -
1006. INDUS MOTOR COMPANY PRIVATE LIMITED PH :9745998013. - 670703 686506
(VL03-VL-01), OPPOSITE TO S.N. COLLEGE, S.N. 1017. SAI SERVICE PRIVATE LIMITED (2705-27-08), PH :9747554929. PH :9745998009.
PURAM P.O., KANJIKKUZHI,CHERTHALA, KETTEZHUTHUM KADAVU, INTUC JUNCTION, IRITY 1037. AVG MOTORS LTD. (9Y03-9Y-01), NEW SURVEY
ALAPPUZHA-DIST. - 688552 NETTOOR, ERNAKULAM, COCHIN (KERALA) - NO. 187/2 (OLD SURVEY NO. 299/1, 299/11),
682040 1027. POPULAR VEHICLE (VJ02-VJ-01), RE-SURVEY
PH :9745997633. KANJIRAPALLY VILLAGE & TALUKA, KOTTAYAM
PH :8129496818. NO: 14/4, 11/2, NEAR JABBAR KADAVU BRIDGE,
1007. POPULAR VEHICLES & SERVICES PVT. LTD. DISTRICT.,KERALA - 686512
1018. GEORGE MAIJO AUTOMOBILES PVT. LTD. KEEZHUR VILL., PERAVOOR ROAD, IRITTY
(VL02-VL-01), RE-SURVEY NO.150/2-1,147/3, PH :8606071155.
(2709-27-01), DOOR NO.5/452, 5/452A, 5/453, MUNICIPAL, KANNUR DIST. KERALA. - 670703
BUILDING NO.KP-18/80, N.H. KANJIKUZHI KANNUR
OLD ELOOR ROAD, ELOOR JUNCTION, NORTH PH :7902473741.
VILLAGE, CHERTHALA, ALAPPUZHA DISTT., -
KALAMASSERY, DISTRICT - ERNAKULAM, KAIPAMANGALAM 1038. HAR CARS (K101-K1-01), HAR AVENUE,
688582
COCHIN. - 683104 KANNOTHUMCHAL, CHOVVA POST, KANNUR -
PH :9072530127. 1028. SAI SERVICE PRIVATE LIMITED (2705-RP-07),
PH :7559997864, 4237700. 670006
CHINGAVANAM VAZHIYAMBALAM PO,
PH :9539009480.
1019. INDUS MOTOR COMPANY PRIVATE LIMITED KAIPAMANGALAM,THRISSURE - 680681
1008. POPULAR (I602-I6-I602-01), BUILDING NO. VI (2702-27-0L), SURVEY NO. 30-A/32, KARIKKAD 1039. HAR CARS (K101-K1-03), POTTIAN SHEKHARAN
PH :8129496846.
461, RE SURVEY NO. 290/9, GOMATHI ROAD, THEKKUMBHAGAM, PUTHIYAKAVU, ROAD, MAKKANY , SOUTH BAZAR, KANNUR -
JUNCTION, MAVILANGU KARA, CHINGAVANAM KALAMASSERY/ ERNAKULAM 670002
TRIPUNITHURA, ERNAKULAM, KERALA - 682301
P.O., DISTT. KOTTAYAM, KERALA - 686531 PH :9745992070. 1029. INDUS MOTOR COMPANY PRIVATE LIMITED PH :9539009443.
PH :9778690817. 1020. GEORGE MAIJO AUTOMOBILES PVT. LTD. (2702-Q3-07), KALAMASSERY, ALUVA WEST, 1040. INDUS MOTOR COMPANY PRIVATE LIMITED
CHITTUR (2709-27-02), PLOT NO.2/316, NH-47, MARADU ERNAKULAM DIST, KERALA - 683106 (4701-K1-0E), BALANKINAR JN.,
VILLAGE, KANNDIKAD, NEAR SAROVARAM, PH :9745998012. KATTAMPALLY.P.O, KANNUR - 690011
1009. INDUS MOTOR COMPANY PRIVATE LIMITED
KUNDANOOR, COCHIN (KERALA) - 607001 KALLAMBALAM PH :9745998023.
(BQX1-BQX-01), S.NO.719/3 AND 721/1, RE
PH :7994763336. 1041. KVR CARS (3L01-K1-04), CP-3-651-B, OPP.
SURVEY NO.671/10, VELLIYAVALLAMPPATHY 1030. POPULAR (QZ02-QZ-01), BUILDING NO. 5/472, DHANRAJ TALKIES, PUTHIYATHERU,
VILLAGE, KOZHINJAMPARA, CHITTUR, EDAPPAL NH-47, KADUVAPALLY, THOTTAKAD P.O, CHIRAKKAL POST, KANNUR, KERALA - 670011
PALAKKAD DISTT. - 678555 1021. POPULAR VEHICLES & SERVICES LTD. KALLAMBALAM, TRIVANDRUM DIST., KERALA - PH :9656034333.
PH :9745991560. (4702-AM-05), KOZHIKODA ROAD, KAVILPADY, 695605 1042. POPULAR VEHICLES & SERVICES LTD.
CHULLIMANOOR EDAPPAL, MALAPPURAM - 679582 PH :8086078788. (4702-K1-0F), PLOT NO.82/6A, NEAR
1010. POPULAR VEHICLES (1601-BAI-16), RE-SURVEY PH :9946104680. KALPETA CHARAPPURAM SREEMUTHAPPAN KAVU,
NO. 43/7, VILLAGE-ANAND, CHULLIMANOOR EDAVANNAPPARA 1031. INDUS MOTOR COMPANY PRIVATE LIMITED KAPPAD ROAD, THAZHE CHOVVA (PO),
TOWN, TALUKA-NEDUMANGAD, DIST. (4701-JE-0C), MEENANGADI, KAKKAVAYAL P.O., KANNUR - 670018
1022. POPULAR VEHICLES (GKP1-GKP-01), SURVEY
TRIVANDRUM, PIN-695541, KERALA - 695541 NORTH KALPETTA,WAYAND - 673591 PH :9846062796.
NO. 77/16-1 & 77/2-4 ,BUILDING NO.18/152-B,
PH :9778690745. CHEEKODE VILLAGE,EDAVANNAPARA PH :9745998592. KARIKKAD
COCHIN KONDOTTY ROAD, CHERUVAYOOR PO, 1032. KVR (JE02-JE-C1), BUILDING NOS. 363, 364, 365, 1043. BRD CAR WORLD LIMITED (A404-GE-02), BRD
MALLAPPURAM DISTRICT, KERALA-673645 - 366,367,368 AND 369 CONSTRUCTED ON THE INDUSTRIAL ESTATE,KARIKKAD,
1011. POPULAR VEHICLES & SERVICES LTD.
673645 PLOT COMPRISED IN RESURVEY NOS. 719/6, KUNNAMKULAM - 680519
(2701-27-01), PERANDOOR ROAD, PUNNAKAL,
PH :#REF!. 722/3, 722/22, 722/6, 722/8, 722/10, 722/21, PH :9995804599.
ELAMAKKARA, COCHIN - 682025
FORT KOCHI SITUATED AT MUTTIL NORTH VILLAGE,
PH :9846017725. KARUNAGAPALLY
VYTHIRI TALUK, KALPETTA SUB-DISTRICT,
1012. INDUS MOTOR COMPANY PRIVATE LIMITED 1023. SAI SERVICE PRIVATE LIMITED (BRS1-BRS-01), WAYANAD DISTRICT, KERALA. - 673 122 1044. SARATHY AUTO CARS (C701-AQ-05), K.S.
(2702-27-02), BEHIND COMMERCIAL SALES TAX, PLOT NO.83/1,2 OPPOSITE TO KUMAR PETROL PH :9747021902. PURAM,NEELIKULAM,
M.G. ROAD, COCHIN, - 682015 PUMP, STATUE ROAD, CHULLIKKAL POST,
KANHAGAD KARUNAGAPPALLY,KOLLAM, - 690544
PH :9745998040. FORT KOCHI - 682005 PH :9526691565.
PH :9645106330. 1033. KVR CARS (3L01-K2-02), ARANGADI, P.O.
GURUVAYUR KANHANGAD, DIST. KASARGOD, - 671315
PH :9605040999.

37
Dealer Workshop (AS ON 31.05.2023 )
1045. INDUS MOTOR COMPANY PRIVATE LIMITED 1055. INDUS MOTOR COMPANY PRIVATE LIMITED 1064. INDUS MOTOR COMPANY PRIVATE LIMITED 1072. POPULAR (S801-S8-S801-02), BUILDING NO.
(AQ03-AQ-01), SY.NO.243/1, 243/10, 243/16, (8K02-8K-01), RE-SURVEY NO. 116/1-6, 116/2-5, (ID02-ID-01), SURVEY NO. 16/1, BLOCK NO. 36 MP/20/749,20/426, 20/748, INCHAKADU,
243/14, 243/15, 243/16, EDAPPALLY KOTTA BUILDING NO. 560/A, WARD NO. VII, AALA (OLD SURVEY NO. 100/1), NEDIYIRUPPU KALAYAPURAM VILLAGE, MYLOM
JUNCTION, NEAR TITANIUM, CHAVARA POST, VILLAGE, (OLD VILLAGE, KONDOTTY PO, ERNAD TALUKA, PANCHAYATH, KOTTARAKKARA TALUKA,
KARUNAGAPALLY, DISTT. KOLLAM. - 691583 VILLAGE-SREENARAYANAPURAM), MALAPURAM DISTRICT, KERALA - 683573 KOLLAM DISTRICT, KERALA- 691560 - 691560
PH :9745998006. KODUNGALLUR TALUK, MADHILAKOM SRO, PH :9746743178. PH :8086073466.
1046. SARATHY (C701-AQ-11), SURVEY NO. 15/3, SANTHIPURAM PO, THRISSUR DIST., KERALA - KOOTHATTUKULAM KOTTARKKARA
SIDCO INDUSTRIAL AREA, EDAKULANGARA PO, 680 008
1065. SAI SERVICE PRIVATE LIMITED (VM01-VM-01), 1073. POPULAR VEHICLES & SERVICES LTD.
NEAR KARUNAGAPALLY RAILWAY STATION, PH :9747513444.
EDAPUTHUSSERY BUILDING, M.C. ROAD, OPP. (S801-S8-01), MYLOM, MC ROAD,
KARUNAGAPALLY, KERALA. - 690 562 KODUVALLY MARYGIRI PUBLIC SCHOOL, KOTTARAKKARA, DISTT-KOLLAM, KERELA -
PH :9526691565.
1056. A M MOTORS (BGX1-BGX-01), SURVEY NO:91/9, KOOTHATHUKULAM P.O., ERNAKULAM DT. - 691531
KASARGOD 91/10,NALLANKADY, VAVAD POST, KODUVALLY, 686662 PH :8086073466.
1047. KVR CARS (3L01-3L-01), ANANGUR, KOZHIKODE DISTRICT, KERALA - 673572 PH :9645106258. 1074. SARATHY AUTO CARS (S802-S8-01), WARD
VIDYANAGAR (PO), NH17, KASARGOD - 671123 PH :9895979023. KOPPAM NO.40, MELILLIA PANCHAYATH, IPPALLOOR
PH :9747021206. KOLANCHERRY LOWER KARIKAM, KOTTARKARA DISTT.
1066. AM MOTORS (CUU1-CUU-01), SURVEY NOS:
1048. POPULAR VEHICLES & SERVICES LTD. KOLLAM (KERALA) - 691531
1057. SAI SERVICE (SJO1-SJO-01), SURVEY NO.138/7, 331/3-6, 331/3-10, NEAR SALAFIYYA TRAINING
(4702-3L-0D), MUNDAKULAM, CHEMMANAD PH :9847423365.
BLOCK NO. 47, WARD-8, KOLENCHERY TOWN, COLLEGE, PERINTHALMANNA-PATTAMBI
(PO), KASARGOD - 671371 1075. INDUS MOTOR COMPANY PRIVATE LIMITED
NH-85, AIKARANADU NORTH VILL., ROAD, KARINGANDU, VILAYUR POST, KOPPAM,
PH :9946104621. (S804-S8-01), RE SURVEY NO.207/3-2,
KUNNATHUNADU TALUK, ERNAKULAM DIST., PALLAKKAD DIST., KERALA-679309 - 679309
1049. INDUS MOTOR COMPANY PRIVATE LIMITED KIZHAKEKKARA MURIYIL, KNS HOSPITAL
KERALA-682311 - 682311 PH :9048666635.
(RO02-3L-03), 18/304A & 18/304B, SY. NO. 39/3B, JUNCTION, KOTTARAKKARA VILLAGE AND
PH :7356605955. KOTHAMANGALAM
RE SY. NO. 57/6,MOGRAL, MANJESHWAR TALUKA, KOLLAM DISTT., - 691531
TALUK, KASARAGOD, KERALA - 671541 KOLLAM 1067. POPULAR VEHICLES & SERVICES LTD. PH :9747562299.
PH :9747550747. 1058. SARATHY AUTO CARS (C701-C7-01), NH-47 BYE (2701-9V-0B), NEAR BSNL OFFICE, KOTTAYAM
KATTAPANA PASS,AYATHIL(P.O.),QUILON - 691017 THANGALAM, KOTOHAMANGALAM, KERALA -
1076. AVG MOTORS LTD. (B801-B8-01),
PH :9744552265. 686691
1050. INDUS MOTOR COMPANY PRIVATE LIMITED ERAYILKADAVU, KOTTAYAM - 686001
1059. POPULAR VEHICLES & SERVICES LTD. PH :9846027990.
(ZN01-ZN-01), KATTAPPANA-IDUKKI KAVALA, PH :7510982222.
(1601-Q4-04), H & C COMPOUND, 1068. INDUS MOTOR COMPANY PRIVATE LIMITED
BYE PASS ROAD, KATTAPPANA, IDUKKI (DIST.). 1077. INDUS MOTOR COMPANY PRIVATE LIMITED
MUNDDACKAL, KOLLAM - 680006 (7E01-9V-03), PALAKKADAN
- 685508 (2702-B8-04), MULANKUZHA JN., NATTAKOM
PH :7594977550. BUILDING,CHANKLAM,KOTHAMANGALAM -
PH :9746743460. P.O., KOTTAYAM , KERALA - 686013
1060. INDUS MOTOR COMPANY PRIVATE LIMITED 686691
1051. POPULAR VEHICLES (ZN02-ZN-01), RE-SURVEY PH :9745998148.
(1602-Q4-03), OLD SARATHY THEATRE, PH :9745998479.
NO. 81/3, VILLAGE & TOWN - KATTAPPANA, 1078. POPULAR VEHICLES & SERVICES LTD.
PUNALOOR ROAD, KOLLAM - 691005 KOTTAKARKARA
TALUK & DIST.-IDUKKI, KERALA. - 685 515 (B802-B8-01), NEAR ST. THOMAS CHURCH, S.H.
PH :9745998004.
PH :9746818407. 1069. INDUS MOTOR COMPANY PRIVATE LIMITED MOUNT, P.O, KOTTAYAM - 686006
1061. SARATHY AUTO CARS (C701-C7-13), SURVEY
KAYAMKULAM (S804-S8-02), RE-SURVEY PH :8086073454.
NO. 431/13-42, NEAR SN PUBLIC SCHOOL,
NO.141/3-4,142/1-2,15-16,143/1-2,143/2,143/15-2,1 1079. INDUS MOTOR COMPANY PRIVATE LIMITED
1052. INDUS MOTOR COMPANY PRIVATE LIMITED VADAKKEVILA, AYATHIL, KILLIKLLOOR PO,
43/15-2-2, BEARING NOS. 25/36 & 38, (2702-B8-0C), MANIPPUZHA, NATTAKOM
(2702-8L-05), KARIYILAKULANGARA, PUNTHALATHAZHAM-PALATHARA ROAD,
KOTTARAKKARA VILLAGE, KOTTARAKKARA P.O.,KOTTAYAM - 686013
KAYANKULAM P.O., ALAPPUZHA DISTT. - KOLLAM, KERALA - 691004
TALUK, KOLLAM DISTRICT, KERALA- 691506 - PH :9745998007.
690572 PH :8606430765.
PH :9745998005.
691506 KOZHENCHERRY
KOLLAM/ QUILON PH :9747562299.
1053. POPULAR VEHICLES & SERVICES LTD. 1080. AVG MOTORS LTD. (W801-AS-03),
1062. SARATHY AUTO CARS (C701-C7-08), SURVEY KOTTAKKAL
(B802-8L-03), NH 47, KOTTUKULANGARA, KOZHENCHERRY, COLLEGE JUNCTION,
NO. (SIDCO) 318/1, SHED NO. B12,
KAYAMKULAM P.O., ALAPPUZHA DISTT. - 1070. INDUS MOTOR COMPANY PRIVATE LIMITED DISTRICT- PATHANAMTHITTA, - 689641
UMAYANALLUR SIDCO INDUSTRIAL ESTATE,
690502 (4701-8M-09), NEAR MATHRUBHUMI PRESS, PH :9446092995.
KOLLAM. - 691589
PH :9946105601. P.O. KOTTAKKAL, MALAPPURAM DIST, - 676503 KUNNAMKULAM
PH :9947127565.
KODUNGALLUR 1063. SARATHY AUTO CARS (C701-C7-12), BUILDING
PH :9745998017.
1081. POPULAR VEHICLES & SERVICES LTD.
1071. POPULAR VEHICLES & SERVICES LTD.
1054. SAI SERVICE PRIVATE LIMITED (2705-8K-03), NO. 15/620, SURVEY NO. 234/1, 235/2, SITHARA (2701-8N-07), CHOONDAL,TRISSUR ROAD,
(4702-8M-03), NH-17, ,CHANDAPARAMBU,
NH-17,T.K.S.PURAM,,KODUNGALLOOR - 680667 JUNCTION, ADICHANALLOOR VILLAGE, KUNNAMKULAM, TRISSUR DIST - 680502
,RANBATHANI P.O, MALAPPURAM, KOTTAKAL -
PH :9645106571. KOTTIYAM PO, KOLLAM DIST., KERALA. - PH :9946105695.
676510
691571 LAKKIDI PERUR
PH :9946104631.
PH :9847936165.
KOTTARAKARA 1082. A M MOTORS (CER1-CER-01), 217/7, 217/2,
KONDOTTY 278/2, 278/1, PALAPPURAM, P.O. OTTAPPALAM,
LEKKIDI PERUR DISTT. PALAKKAD, - 679302
PH :8086305555.
MALAPURAM

38
Dealer Workshop (AS ON 31.05.2023 )
1083. A M MOTORS (E601-E6-01), VARANGODE, 1093. POPULAR VEHICLES (B802-B8-10), BUILDING 1102. POPULAR VEHICLES & SERVICES (AF02-AF-01), 1112. INDUS MOTOR COMPANY PRIVATE LIMITED
DOWNHILL, MALAPURAM, - 676519 NO. 10/115-A, WARD NO. 10, CHENNITHALA RE-SURVEY NO: 6/1 BLOCK NO. 76, (Y202-Y2-01), DOOR NO: 5/366 & 367, NH 47,
PH :9895705325. VILL. AND TOWN, SHANTHIVANAM JUNCTION, CHEMMARAN, NADUVATH PO, WANDOOR KOOTUPATHA, CHANDRANAGAR POST,
MALLAPALLY CHERUKOLE P.O., MAVELIKKARA TALUK, ROAD,NILAMBUR, MALAPPURAM DIST., PALAKKAD - 678007
ALAPPUZHA DIST., KERALA- 690104. - 690104 KERALA - 679328 PH :9747519500.
1084. INDUS MOTOR COMPANY PRIVATE LIMITED
PH :9778690833. PH :7736094999. PANDIKKAD
(I201-I2-01), THOPPIL COMPLEX, MALLAPPALLY
KOTTAYAM RD, MALLAPPALLY WEST, MORAYUR NILAMEL 1113. AM MOTORS (CUV1-CUV-01), SURVEY NOS:
MALLAPPALLY (KERALA) - 689585 1094. A M MOTORS (CUJ1-CUJ-01), SURVEY NO. 1103. INDUS MOTOR COMPANY PRIVATE LIMITED 333/2-2, 333/3-2,CHOORAKKAVU,
PH :9747541400. 328/1, VILLAGE – MORAYUR, VALENCHERY, (DA02-DA-01), SURVEY. NO. 195/10, 195/3-1-2, PERINTHALMANNA ROAD, NEAR INDIAN OIL
MANATHAVADY DISTRICT – MALAPPURAM, KERALA. - 673642 195/3-2-1, 195/8, 195/14, 195/9-1, 195/11-1, PETROL PUMP, PANDIKKAD TOWN & POST,
PH :8086526666. BLOCK NO. 32, ATTINGAL MUNCIPALITY, MALAPPURAM DISTRICT, KERALA - 676 521
1085. INDUS MOTOR COMPANY PRIVATE LIMITED
MUVATTUPUZHA PAZHAYAKUNNAMEL VILLAGE, CHIRAYINKIL PH :9539999570.
(IE02-IE-01), SURVEY NO. 1/2A1, A1, B1, RY
TALUK, (BORDER OF NILAMEL TOWN), PARAPPANANGADI
1/210, 1/99, MYSORE ROAD, CHETTAPALAM, 1095. INDUS MOTOR COMPANY PRIVATE LIMITED
TRIVANDRUM DIST., KERALA - 695601
MANATHAVADY CITY & TALUK, WYANAD DIST., (7E01-7E-01), NH-49, MUVATUPUZHA 1114. A M MOTORS (CTK1-CTK-01), SURVEY NO.66/6,
PH :9745993331.
KERALA. - 670645 KODAMANGALAM ROAD, NEAR R.K. HOSPITAL, 66/7, KODAPPADI, POST-CHETTIPPADY,
1104. POPULAR (DA03-DA-01), BUILDING NO. 10/279
PH :9745997002. MUVATUPUZHA, ERNAKULAM DIST - 686661 PARPANGADI, MALAPPURAM. - 676319
TO 288, M. C. ROAD, KANNANCODU, NILAMEL
MANJERI PH :97459998011. PH :9895900466.
PO, KOLLAM (DIST.), KERALA- 691535 - 691535
1096. POPULAR VEHICLES & SERVICES LTD. PARAVUR
1086. A M MOTORS (E601-8V-05), THURAKKAL PH :8714606483.
(2708-7E-02), MUTHUKALLU
BYEPASS, MANJERI, MALAPURAM, KERALA -
JUNCTION,PERUMPALLUR P.O., OTTAPALAM 1115. POPULAR VEHICLES & SERVICES LTD.
676121 (ZS01-ZS-01), SURVEY NO. 340/1-76,77,78, NEAR
MUVATTUPUZHA, KERALA - 686673 1105. INDUS MOTOR COMPANY PRIVATE LIMITED
PH :9895756035. HP PETROL PUMP, PARAVUR-MANJALI MAIN
PH :7356988840. (PA01-PA-01), BUILDING NO.23/667, 23/669,
1087. KVR AUTOCARS PVT LTD (8V02-8V-01), CH BYE ROAD, MANNAM PO, NORTH PARAVUR
NEDUMANGAD PALAKKAD-OTTAPPALM ROAD, OTTAPPALAM
PASS ROAD, MANJERI, MALAPPURAM, KERALA MUNICIPAL, ERNAKULAM DIST. 683520,
VILLAGE, OTTAPPALAM TALUKA, PALAKKAD
- 676123 1097. POPULAR VEHICLES & SERVICES LTD. KERALA. - 683520
DISTT., KERALA. - 679101
PH :9747020801. (ZO01-ZO-01), RE-SURVEY NO.- 855/29, 855/14/1 PH :9072609638.
PH :9747544454.
1088. POPULAR VEHICLES & SERVICES LTD. (OLD SURVEY NO. 1583/1), KARIPPUR VILLAGE, PATHANAMTHITTA
(4702-8V-0E), NARUKARA VILLAGE, RAJIV NEDUMANGAD TALUK, TRIVANDRUM PALA
1116. AVG MOTORS LTD. (W801-W8-02),
GANDHI BYEPASS JN., THRUKKAL, MANJERI DIST.,KERALA-695541. - 695541 1106. POPULAR VEHICLES & SERVICES LTD.
JUNNUGAPADY, MYLAPRA ROAD,
(KERALA) - 676121 PH :9846036696. (B802-GN-04), 12TH MILE,PALA-PONKUNNAM
PATHANAMTHITTA, - 689671
PH :8589992406. NEYYANTTINKARA ROAD,PALA - 686575
PH :9446002987.
MANNARKAD PH :9072609475.
1098. INDUS MOTOR COMPANY PRIVATE LIMITED 1117. INDUS MOTOR COMPANY PRIVATE LIMITED
1107. INDUS MOTOR COMPANY PRIVATE LIMITED
1089. A M MOTORS (E601-RA-07), NH-213, (AT01-AT-01), INDUS MOTOR CO. PVT. LTD., (1602-W8-13), KUMBAZHA, PATHANAMTHITTA -
(7E01-GN-05), OPP. ALPHONSA COLLAGE
MANNARKAD, DIST.-PALAKKAD - 678582 OLD M.V THEATRE, NEAR KSRTC BUS 689653
ARUNAPURAM(PO), PALA, KOTTAYAM - 686574
PH :9895979048. STATION, NEYYATINKARA, DIST. TRIVANDRUM PH :9745998008.
PH :9745998878.
1090. INDUS MOTOR COMPANY PRIVATE LIMITED - 695121 1118. POPULAR VEHICLES & SERVICES LTD.
1108. AVG MOTORS LTD. (GN03-GN-01), SURVEY
(2702-RA-0K), ANAKATTY ROAD, PH :9747544500. (B802-W8-05), T.K. ROAD, NEAR
NO.670/1, BLOCK-21, LALAM VILLAGE,
AANDIPPADAM, NELLIPPUZHA-PO. NEYYATTINKARA COLLECTORATE,PATHANAMTHITTA - 689645
ANTHINADU MEENANCHIL, PALA, KOTTAYAM
MANNARKAD,KERALA - 678583 PH :9539009734.
1099. POPULAR VEHICLES (1601-16-1601-15), DIST. - 686651
PH :9745995946. 1119. INDUS MOTOR COMPANY PRIVATE LIMITED
BUILDING NO. 11/562, KP-IX-843, NH 47, PH :9447137246.
MAVELIKARA (1602-W8-12), SURVEY NO. 11-13/12(1),
KOTTAMOM , KOLLAYIL PANCHAYAT, PANVEL - 1109. INDUS MOTOR COMPANY PRIVATE LIMITED
KARIMPANKUZHY ROAD, NEAR SAROJ GAS
1091. POPULAR VEHICLES & SERVICES LTD. KOCHI - KANYAKUMARI HIGHWAY, KOTTAMOM, (7E01-GN-07), SURVEY NO. 176, BLOCK NO. 16,
AGENCY, MAKKANKUNNU, PATHANAMTHITTA,
(B802-S9-02), KONNAYIL SUVAKO INDUSTRIAL NEYYATTINKARA, TRIVANDRUM, KERALA- HIGHWAY JUNCTION, ETTUMANOOR-POOJAR
KERALA. - 689645
COMPLEX,,SHED A-1,, KOLLAKADAVU 695122 - 695122 HIGHWAY, CHERPUNKAL, PALA, KOTTAYAM
PH :9745999858.
INDUSTRIAL ESTATE, KOCHAL MOODU, PH :9946104602. DISTRICT - 686584
KALLIMEL P.O.,, MAVELIKKARA, KERALA - PH :9747516934. PATHIRAPALLY
NILAMBUR
690570 PALAKKAD 1120. POPULAR VEHICLES & SERVICES LTD
1100. INDUS MOTOR COMPANY PRIVATE LIMITED
PH :9400052338. (E502-E5-02), BUILDING NO. X/832 TO 834, X/837
(4701-AF-0A), MINERVA JUNCTION, NILAMBUR , 1110. POPULAR VEHICLES & SERVICES LTD.
1092. INDUS MOTOR COMPANY PRIVATE LIMITED TO 838, OPP .UDAYA STUDIO, PATHIRAPALLY
KERALA - 679329 (2701-Y2-09), OPP. PALANA
(1602-S9-07), NEAR PRATHIBA THEATRE, TOWN, AMBALAPUZHA TALUK, NH-47,
PH :9745998396. HOSPITAL,KODUVAYOOR ROAD,KINASSERY
PUTTHIYAKAVU, MAVELIKKARA - 690101 ALAPPUZHA DIST., KERALA-688521. - 688521
1101. INDUS MOTOR COMPANY PRIVATE LIMITED P.O.,PALAKKAD - 678707
PH :9745998137. PH :9778698169.
(4701-AF-0D), MANAVEDHAM HIGH SCHOOL PH :9946105613.
MAVELIKARRA ROAD, CHANDAKUNNU - NILAMBUR PO, 1111. INDUS MOTOR COMPANY PRIVATE LIMITED PATTAMBI
NILAMBUR, MALAPURAM DIST. - 679329 (2702-Y2-0G), VADAKKUMURI-NH-47, KANNADI, 1121. A M MOTORS (E601-8P-04), SHORANUR ROAD,
PH :9745998396. KUZHALMAMMAM (P.O.), PALAKKAD. - 678701 PATTAMBI, DISTRICT-PALAKKAD, - 679306
PH :9745998590. PH :9567866059.

39
Dealer Workshop (AS ON 31.05.2023 )
1122. INDUS MOTOR COMPANY PRIVATE LIMITED 1132. SAI SERVICE (BQW1-BQW-01), SUVEY NO. 1141. POPULAR VEHICLES (VK01-VK-01), SURVEY 1151. POPULAR VEHICLES & SERVICES LTD.
(2702-8P-0B), PERINTHALMANNA ROAD, 788/12-2-5, NEAR PIRAVOM GOVT. HOSPITAL, NO. 421/5, 421/6, BLOCK NO. 22, KRISHNAGIRY (HZ02-HZ-01), SY.NO.124/7A-1, 124/7A-2,
THEKKUMURI, PATTAMBI - 679303 PIRAVOM TOWN & MUNICIPALITY, VILLAGE, PATHIRIPALAM, KOLAGAPPARA (PO), THODUPUZHA EHLOOR MAIN ROAD, VILLAGE &
PH :9745998295. MUVATTUPUZHA TALUK, ERNAKULAM DIST., TALUK & TOWN - SULTHAN BATHERY, TOWN, THODUPUZHA, DISTT. IDUKI - 685585
1123. A M MOTORS (E601-8P-09), CHERPULASSERY KERALA. - 686 664 WAYANAD DIST., KERALA. - 673 591 PH :9072530120.
ROAD, KOOMBAN KALLU, KARIMPULLI, MELE PH :9645106198. PH :7594977551. THRISSUR
PATTAMBI POST, PALAKKAD DISTT., KERALA. - POINACHI TALIPARAMBA 1152. POPULAR VEHICLES & SERVICES LTD.
679306
1133. KVR CARS (3L01-GF-03), CHOWKI, 1142. HAR CARS (K101-9W-02), SREEKANDAPURAM (2701-A4-05), KUNNATHUMKARA,
PH :9567866059.
MAILLATTY(P.O.), (VIA) UDUMA, POINACHI, MAIN ROAD, KANNUR (DIST), KERALA, PARAVATTANI, THRISSUR, KERALA - 680655
PAYANNUR KERALA - 671319 THALIPARAMBA - 670141 PH :6282306495.
1124. POPULAR VEHICLES & SERVICES LTD. PH :9747021026. PH :9539009473. 1153. SAI SERVICE PRIVATE LIMITED (2705-A4-06),
(4702-9Z-04), N H 17,,EZHILODE P O, PUNALUR THALASSERRY 17/30,POOTHOLE,THRISSUR,KERALA - 680004
,,PAYYANUR - 670309 PH :9645105051.
1134. SARATHY AUTO CARS (C701-8Q-03), NH-208, 1143. INDUS MOTOR COMPANY PRIVATE LIMITED
PH :9946104701. 1154. BRD CAR WORLD LIMITED (A404-A4-01), NH
Q.S. ROAD,ELAMPAL POST,PUNALUR, KOLLAM (RO02-RO-01), NETTUR POST, KODUVALLY,
1125. POPULAR VEHICLES & SERVICES LTD. 47,BYE PASS,KONIKARRA POST,THALORE,
DIST - 691322 THALASSERY, KANNUR DISTRICT - 670105
(9Z01-9Z-01), SY. NO. 218/1, CHERUTHAZHAM THRISSUR - 680031
PH :9744400265. PH :9745998022.
VILLAGE, EZHILODE (NEAR COLONY BUS PH :9995807141.
1135. INDUS MOTOR COMPANY PRIVATE LIMITED THALASSERY/ TELLICHERRY
STOP), PAYANNUR-KANNUR NH, PAYANNUR 1155. INDUS MOTOR COMPANY PRIVATE LIMITED
(8Q02-8Q-01), SY. NO. 48/1/42, OLD, SY. NO.
TALUK, KANNUR DISTRICT, KERALA – 670 309. 1144. INDUS MOTOR COMPANY PRIVATE LIMITED (2702-A4-0D), JYOTHI COMPLEX, GURUVAYOOR
231A/3324, (OLD RAMRAJ TILES FACTORY),
PH :9946104701. (4701-Y3-04), TEMPLE GATE, MAKKOOTAM, ROAD, WEST FORT, THRISSUR - 680004
THALICODE, PATHANAPURAM TALUK,
PAYYANUR THALAYI, TELLICHERRY , KERALA - 670102 PH :9745998014.
PUNALUR ANCHAL ROAD. - 691 305
PH :9747520100. 1156. BRD CAR WORLD LIMITED (A404-A4-07),
1126. INDUS MOTOR COMPANY PVT. LTD. PH :9747638885.
THALAYOLAPARAMBU GURUVAYOOR ROAD, PUNKUNNAM P.O.,
(9Z02-9Z-01), SURVEY NO.-289/117, 290/105, QUILANDY PUZHAKKAL, THRISSUR - 680002
KARIVELLUR PERALAM GRAM PANCHAYAT 1145. INDUS MOTOR COMPANY PRIVATE LIMITED
1136. INDUS MOTOR COMPANY PRIVATE LIMITED PH :9746476529.
(NEAR PALATHARA BRIDGE), PAYYANUR (2702-WN-0J), THODUPUZHA ROAD,
TALUK, KANNUR DISTRICT, KERALA-
(3O01-3O-01), BUILDING NO.13/53 A, THRITHALLUR
THALAYOLAPARAMBU, VAIKOM(TALUK),
CHENGOTTUKKAVE VILLAGE, QUILANDY,
PIN-670521. - 670521 DISTRICT-KOTTAYAM, KERALA - 686605 1157. BRD CAR WORLD LIMITED (A404-SS-04), PO-
KOZHIKODE DISTT. - 673306
PH :9745998204. PH :9746743003. THRITHALLUR, NH-17, THRITHALLUR THRISSUR
PH :9745997875.
PERINTHALMANNA THAMARASSERY - 680619
RAMANATTUKKARA PH :9539197888.
1127. A M MOTORS (E601-7H-03), NEAR FIRE 1146. INDUS MOTOR COMPANY PRIVATE LIMITED
STATION, HOSPITAL ROAD, PERINTHALMANNA
1137. A M MOTORS (E601-KB-06), NEAR RED TIRUR
(PB06-PB-01), RE-SY. NO. 44/5A, 44/6, RAROTH
CRESCENT HOSPITAL, FEROKE, CHUNGAM,
- 679322 VILLAGE, (NEAR CHUNGAM), THAMARASSERY 1158. A M MOTORS (E601-Y4-02), SATELLITE AUTO
CALICUT DISTRICT, RAMANATTUKARA, - 673632
PH :8129818235. PANCHAYAT & TALUK, CALICUT DIST., KERALA. WORKS, PAYYANAGADI POST, TIRUR - 676101
PH :9567866144.
1128. KVR AUTOCARS PVT LTD (7H01-7H-01), - 673573 PH :9995879706.
SURVEY NO. 87/8-15, CALICUT ROAD, NEAR RANNI PH :9747553362. 1159. KVR AUTOCARS PVT LTD (7H01-Y4-05), T.P
ITC, THIRURKAD, PERINTHALMANNA - 679351 1138. INDUS MOTOR COMPANY PRIVATE LIMITED 1147. POPULAR (PB07-PB-10), SURVEY NO.43/4 7/204-B, TANUR ROAD,MOOCHIKKAL,
PH :9747020573. (7E01-JX-06), CHELLAKKAD-PO, BLOCK NO:005 , RAROTH VILLAGE , MEENADATHUR P.O., TIRUR,
1129. KVR AUTOCARS PVT LTD (7H01-7H-06), OOTY PATHANAMTHITTA( DISTRICT), RANNI - 689677 THAMARASSERY TALUK , KOZHIKODE DISTRICT-MALAPPURAM, KERALA - 676307
ROAD, PERINTHALMANNA, MALAPPURAM(DT.), PH :9745998737. DISTRICT, KERALA - 673573 PH :9747020673.
KERALA - 679322 SASTHAMKOTTAH PH :9846397060. 1160. A M MOTORS (E601-Y4-08),
PH :9747020837. THIRUVALLA THALAKKADATHOOR PO,
1139. INDUS MOTOR COMPANY PRIVATE LIMITED MALAPPURAM,MALAPPURAM DISTT. - 676103
PERUMBAVOOR
(1602-RT-09), NO. SP IX/661, 662, 663, 1148. AVG MOTORS LTD. (Y501-Y5-01), M.C ROAD, PH :9895705323.
1130. SAI SERVICE PRIVATE LIMITED (2705-8W-04), KADAPUZHA ROAD, PORUVAZHY P.O., PERUMTHURUTHI, THIRUVALLA , 1161. INDUS MOTOR COMPANY PRIVATE LIMITED
M.C.ROAD,PERUMBAVOOR,ERNAKULAM BHARANIKUVU, SASTHAMKOTTAH, KOLLAM – , PATHANAMTHITTA DISTT - 689107 (Y403-Y4-01), SURVEY NO. 119/3, 4, 9A, OLD
DIST,KERALA - 683542 KERALA - 690520 PH :9446323999. MODERN PHARMACEUTICALS PVT. LTD.,
PH :7034258335. PH :9745998849. 1149. POPULAR VEHICLES & SERVICE (B802-Y5-06), THRIKANDIYOOR VILLAGE, CHAMBAVATTOM
1131. INDUS MOTOR COMPANY PRIVATE LIMITED SHORNUR KAVUMBHAGOM P.O, THIRUVALLA, ROAD, TIRUR, KERALA. - 676105
(8W03-8W-01), SURVEY NO. 72/2-3, 72/3-3, PATHANAMTHITTA (DIST.), KERALA - 689103
1140. POPULAR VEHICLES & SERVICES LTD. PH :9747518883.
TALUK - KUNNATHUNADU, VILLAGE - PH :8086073489.
RAYAMANGALAM, SUB DIST.-PERUMBAVOOR, (2701-1I-0E), PALAKKAD PATTAMBI ROAD, TRIPPUNITHURA
KULAPPULLY JUNCTION, VADANAMKURUSSI, THODUPUZHA
DIST.ERNAKULAM. - 683 541 1162. SAI SERVICE PRIVATE LIMITED (2705-AK-05),
PH :9747591803. SHORNUR - 679124 1150. INDUS MOTOR COMPANY PRIVATE LIMITED HILL PALACE ROAD,KARINGACHIRA,COCHIN -
PH :8589992432. (7E01-HZ-04), PALA ROAD, THODUPUZHA - 682301
PIROVAM
SULTHAN BATHERY 685584 PH :9645105067.
PH :9745998631.
TRIPRAYAR

40
Dealer Workshop (AS ON 31.05.2023 )
1163. POPULAR VEHICLES & SERVICES LTD. 1174. POPULAR VEHICLES (1601-16-17), BUILDING 1183. BRD CAR WORLD LIMITED (A404-MX-03), 1191. PATEL MOTORS (INDORE) PVT. LTD.
(2701-8R-08), SURVEY NO. 296/5,8, 296/9, NO. 13/632,632-A, 633,633-A1,633-A2,634-636, VAZHAKODE, CHELAKARA ROAD, (BPT1-BPT-01), KHASRA NO. 2194/1, BADNAGAR
296/9-1, NATTIKA VILLAGE, NEAR CIVIL 6TH MILE STONE, VAZHAYILA PO, MULLURKARA P.O., WADAKKANCHERY, ROAD, BADI CHOUPATI, OPPOSITE BSNL
STATION, POLY JUNCTION, TRIPRAYAR TOWN, PEROORKADA, THIRUVANANTHAPURAM, THRISSUR DIST - 680583 TOWER, BADNAWAR, DISTT. - DHAR, MADHYA
THRISSUR TALUK & DISTRICT, KERALA-680566 KERALA - 695521 - 695521 PH :9567869403. PRADESH. - 454660
- 680566 PH :9288023313. PH :9926932221.
PH :9846699245. 1175. SARATHY AUTODRIVES PVT LTD (1607-16-01),
KERLA
BADWAH / BARWAHA (BOTH NAMES ARE OK)
TRIVANDRUM SURVEY NO. 2448/4, VILL. MUTTATHARA, NH EDAKKARA
1192. NIMAR MOTORS PVT. LTD. (AU01-UJ-05),
BYE PASS ROAD, KALLUMOOD JN., 1184. KVR (GMN1-GMN-01), SURVEY NO. 1087/1C-91,
1164. INDUS MOTOR COMPANY PRIVATE LIMITED NIRMAL COMPLEX , INDORE ROAD , BARWAH -
VALLAKADAU PO, ENCHAKKAL, VAZHIKADAVU VILLAGE, OOTY ROAD, MUNDA,
(1602-16-01), T.C. 24/885 THYCAUD P.O., 451001
THIRUVANANTHAPURAM, KERALA-695008 - EDAKKARA TOWN, NILAMBUR TALUK,
THYCAUD P.O., METTUKUDA, TRIVANDRUM - PH :7770878726, 9669569496.
695008 MALAPPURAM DIST., KERALA - 679 331
695014 BALAGHAT
PH :9562416665. PH :9747020777.
PH :9745998001.
1165. POPULAR VEHICLES & SERVICES LTD. TRIVANDRUM-MANANTHALLA LADAKH 1193. KUNAL MOTORS (U501-TP-04), KH NO.-1/56,
JHULELAL DHARMSHALA ROAD, BALAGHAT,
(1601-16-01), C.I.T. ROAD, KILLIPALAM, 1176. INDUS MOTOR COMPANY PRIVATE LIMITED LEH MADHYA PRADESH - 4811001
KARAMANA P.O, TRIVANDRUM - 695002 (1602-16-08), NEAR MUSLIM JUMA MASJID,
1185. DRUK AUTOZONE (9S02-9S-01), AIRPORT PH :8349992181.
PH :9946104601. MUKKAM PLAMOODE,
1166. INDUS MOTOR COMPANY PRIVATE LIMITED VATTAPPARA-MANNANTHALA M C ROAD, ROAD, LEH (LADAKH), DISTT. LADAKH, LEH - BARELI
(1602-16-02), NH BYE PASS ROAD, VATTAPPARA PO, 194101
1194. RAJRUP MOTOR JUNCTION (A UNIT OF RMJ
VEMPALAVATTOM, TRIVANDRUM - 695029 MANNANTHALA,TRIVANDRUM - 695028 PH :8082800205.
MOTORS PVT. LTD.) (I303-I3-01), SURVEY 423/2,
PH :9745998003. PH :9747540100. MADHYA PRADESH VILLAGE KAMTON, NH 12, BARELI, RAISEN,
1167. SARATHY AUTODRIVES PVT LTD (1607-16-02), UPPALA MADHYA PRADESH. - 464668
AGAR
KOVALAM BYEPASS,SN NAGAR, MANACAUD PH :9826333501.
1177. POPULAR VEHICLES & SERVICES LTD. 1186. UNITARA MOTORS (BJT2-BJT-01), 27, UJJAIN
(PO), TRIVANDRUM - 695009 BARHI
(4702-4I-0A), N.H.17, KAIKAMPA, UPPALA P.O., ROAD,
PH :9947270665.
KASARGOD (KERALA) - 671322 NEAR MARKETING FUEL STATION, 1195. SHUBH MOTORS PVT. LTD. (GMK1-GMK-01),
1168. INDUS MOTOR COMPANY PRIVATE LIMITED
PH :8086078864. AGAR, MADHYA PRADESH (465669) - 465669 1286/2, BARHI, DIST. - KATNI, MADHYA
(1602-16-05), G.G. MEDICAL COLLAGE P.O.,
1178. KVR CARS (4I02-4I-01), NH 17, BANDIYODE, PH :9770018283. PRADESH - 483770
MURINJAPALAM, TRIVANDRUM,
MANGALAPADI (PO), UPPALA, KASARGOD PH :9755580253.
MURINJAPALAM, , - 695011 ALIRAJPUR
DISTT.,KERALA - 671324 BARNAGAR
PH :9745998002. 1187. RUKMANI MOTORS PVT. LTD. (GLY1-GLY-01),
PH :9526021876.
1169. POPULAR VEHICLES & SERVICES LTD. 1196. YUG CARS (A UNIT OF RUKMARANI CARS
VADAKARA WARD NO 1, JHABUA ROAD, ALIRAJPUR,
(1601-16-05), OPP. ST. JUDE CHURCH,CIT INDORE PVT. LTD) (BBK2-BBK-01), RUNIJA
MADHYA PRADESH, MP - 457887
ROAD, KILLIPPALAM,TRIVANDRUM - 695002 1179. INDUS MOTOR COMPANY PRIVATE LIMITED ROAD ,BARNAGAR CITY, DISTRICT UJJAIN -
PH :9755549200
PH :9846298610. (4701-8S-07), BYE PASS 456771
9109978301.
1170. INDUS MOTOR COMPANY PRIVATE LIMITED JN,VATAKARA-673104,CALICUT, - 673104 PH :9755512100/7898900224.
(1602-16-11), SURVEY NO.3, TC-7/1069(9),
ANUPPUR
PH :9745998021. BARWANI
MARUTHAMKUZHI, SASTHAMANGALAM 1180. POPULAR VEHICLES AND SERVICES 1188. SHUBH MOTORS PVT. LTD. (BIB1-BIB-01), NEAR
VILLAGE, PTP NAGAR ROAD, KANJIRAMPARA (8S02-8S-01), NEAR MADAPPALLY GOVT. HDFC BANK, TEHSIL ROAD, ANNUPUR - 484224 1197. NIMAR MOTORS PVT. LTD. (AU01-SA-02),
P.O., TRIVANDRUM - 695030 COLLEGE, MADAPPALLY, P.O. VADAKARA, PH :9303884800. ANJAD ROAD, VILLAGE -KARAHI, BARWANI,
PH :9747508822. KOZHIKODE (KERALA) - 673102 ASHOK NAGAR MADHYA PRADESH - 451551
1171. SOUTH PARK MOTORS PVT. LTD. (1604-16-01), PH :8943345935. PH :7770804492, 9669569496.
1189. PREM MOTORS PVT. LTD. (DS01-DS-02),
SURVEY NO. 985/3-4-5-6, VILLAGE - VALENCHARRY BEGAMGANJ
SURVEY NO. 67/2/3, SINGAKHEDI HOUSE GUNA
KADAKAMPALLY, CHACKAI BYPASS, TALUKA - 1198. RAJRUP MOTOR JUNCTION (A UNIT OF RMJ
1181. A M MOTORS (CUK1-CUK-01), SURVEY NO. BYPASS NEAR RAJ MATA CIRCLE,
TRIVANDRUM, TRIVANDRUM, KERALA. - 695029
132/4, KOLAMANGALAM, PERINTHALMANNA ASHOKNAGAR, MADHYA PRADESH. - 473331 MOTORS PVT. LTD.) (CIL1-CIL-01), IN FRONT OF
PH :9526100008.
ROAD, VALANCHERY, DIST.-MALAPPURAM. - PH :9926809856. DUSHERRA MAIDAN, SAGAR BHOPAL ROAD,
1172. SARATHY AUTODRIVES PVT LTD (1607-16-03),
676552 ASHTA BEGAMGANJ, DIST – RAISEN , MADHYA
77/2-11, NEMOM VILLAGE, PAPPANAMCODU
PH :9745986666. PRADESH – 464881 - 464881
INDUSTRIAL AREA, TALUKA AND DISTRICT- 1190. JEEWAN MOTORS PVT. LTD. (BSF1-BSF-01), PH :9826333501.
THIRUVANANTHPURAM, KERALA. - 695019 VETTICHIRA KHASRA NO.111/1 NEAR RELIANCE PETROL
PH :9961665865.
BEOHARI
1182. KVR AUTOCARS PVT LTD (7H01-MZ-03), AP IV, PUMP, BHOPAL ROAD, ASHTA, DISTT. SEHORE
1173. POPULAR VEHICLES (1601-16-12), RE-SURVEY 75A TO G, NH-17, CHUNKAM, DIST. (M.P.) - 466001 1199. SHUBH MOTORS PVT. LTD. (BKA1-BKA-01),
NO. 26/4-1, MANANTHALA STADIUM ROAD, MALAPPURAM, VETTICHIRA, - 676552 PH :9826429604 REEVA ROAD, NEAR AARRA MACHINE,
NEAR SURYAPRABHA AUDITORIUM, ULOOR PH :9747020023. 6264918307 BEOHARI, DIST.-SHAHDOL, MADHYA PRADESH.
VILLAGE, MANANTHALA, TRIVANDRUM DIST., 8718911222. - 484774
WADAKKANCHERY
KERALA. - 695 015 BADNAWAR PH :9755580253.
PH :9846498605. BERASIA

41
Dealer Workshop (AS ON 31.05.2023 )
1200. RAJRUP MOTOR JUNCTION (A UNIT OF RMJ 1209. SATYAM MOTORS (0307-03-01), 1218. CITY CARS (UNIT OF AGARWAL WHEELS) 1227. STANDARD AUTO AGENCIES (AVA1-AVA-01),
MOTORS PVT. LTD.) (CKG1-CKG-01), BHOPAL NH-12,SUVEESHA NAGAR,HOSHANGABAD (GKS1-GKS-01), PILIKOTHI CHOURAHA, BESIDE SUKKHAR WARD 1, NEAR DHURVE PETROL
ROAD, OPP. BERASIA HOSPITAL, BERASIA, ROAD,MISROAD - 462040 SINGH AUTOMOBILE- A HERO AGENCY, PUMP,DINDORI - 481661
DISTRICT – BHOPAL, MADHYA PRADESH. - PH :6261900423 CHITRA ROAD, CHITRAKOOT, DISTRICT-SATNA PH :9131343928.
463106 6261900696. (MADHYA PRADESH)- 485334 - 485334 FALI
PH :7909997570. BIAORA PH :9754301199.
1228. OCEAN MOTORS (SGH1-SGH-01), NH 47, NEAR
BETMA 1210. UNITARA (0F02-0F-01), OLD AB ROAD, DABRA GRAM - FALI, TEHSIL KHUDEL, INDORE,
1201. OCEAN MOTORS PVT. LTD. (BVR1-BVR-01), KACHNARIA, BIAORA (M.P) - 465674 1219. PREM MOTORS PVT. LTD. (BOR1-BOR-01), MADHYA PRADESH. - 452016
OPPOSITE MPEB OFFICE, PH :9770018283. PICHHORE TIRAHA, GWALIOR JHANSI ROAD, PH :7389936477.
INDORE-AHEMDABAD ROAD, BETMA, DISTRICT BINA DABRA, DIST.-GWALIOR. - 475110 GADARWARA
– INDORE, MADHYA PRADESH . - 453001 PH :9340059606.
1211. ADINATH CARS PRIVATE LIMITED 1229. STANDARD AUTO AGENCIES (BOI2-BOI-01),
PH :7389936477. DAMOH
(BHQ2-BHQ-01), PLOT NO. 2/3/4/5 AMANTIGEL KHASRA NO. 130/31/A & 131/2, HALKA NO. 18/1,
BETUL LAND SEMI URBAN INDUSTRIAL AREA, BINA, 1220. ADINATH CARS PRIVATE LIMITED NO. 119, GADARWARA, DISTRICT –
1202. KUNAL MOTORS (U501-U5-02), BHOPAL - KHURAI ROAD (NH 26) BINA, DISTRICT – (RD02-RD-01), SAGAR JABALPUR BYPASS NARSINGHPUR . - 487551
NAGPUR NATIONAL HIGHWAY, NEAR BADORA SAGAR, MADHYA PRADESH - 470113 ROAD, DAMOH (M.P.). - 470661 PH :7771003374.
CHOWK,, BETUL - 460001 PH :9009780047. PH :9009780035. GANJ BASODA
PH :8349999177. BURHANPUR DATIA 1230. DAGA MOTORS (A UNIT OF DAGA HEIGHTS)
1203. KAMTHI MOTORS (GKF1-HHI-01), KAMTHI
1212. NIMAR MOTORS PVT. LTD. (BRR1-BRR-01), 1221. PREM MOTORS PVT. LTD. (3003-WE-05), (AEA2-AEA-01), LAL BAGH, BARETH ROAD,
MOTORS LLP(SERVICE CENTER) NEAR SUNITA
KHASRA NO. 654/15-16, BASEMENT OF HOTEL NR.BHOJPURIA MOTORS, BHANDER ROAD, GANJ BASODA, VIDISHA, 464221. - 464221
COLONY
AMBIKA RESIDENCY, OPP. PAKIZA DATIA, MADHYA PRADESH - 475661 PH :9425148584.
NEAR FOREST NAKA, SONAGHATI,
SHOWROOM, SANJAY NAGAR, AMRAVATI PH :9926809803. GARRA
ITARSI ROAD,
ROAD, BURHANPUR, MADHYA PRADESH - DEORI
BETUL - 460001 1231. KAMTHI MOTORS LLP (GJC1-GJC-01),
450331
PH :9329918424. 1222. ADINATH CARS PRIVATE LIMITED LALBARRA ROAD, GARRA INDUSTRIAL AREA,
PH :7694011374, 9669569496.
BHAVRA (CUO1-CUO-01), C/O VISHWANATH DIXIT, GARRA, BALAGHAT, MADHYA PRADESH. -
CHAKGHAT VIJAYSHRI GAS SERVICE, NEAR GOVT. HIGH 481331
1204. RUKMANI MOTORS (SPT1-SPT-01), GRAM
1213. CITY CARS (UNIT OF AGARWAL WHEELS) SCHOOL, NARSINGHPUR ROAD,VILLAGE PH :7723020684.
PANCHAYAT, KALIYAVAHO, OPP SUNKER
(GKQ1-GKQ-01), GRAM AND POST - CHANDAI, KHEER, DEORI DISTT. SAGAR (M.P.) - 470226 GAUTAMPURA
MANDIR, BHAVRA TEHSIL, ALIRAJPUR
CHAKGHAT, TEHSIL - TEONTHER, PRAGRAJ PH :9009787562.
DISTRICT, MADHYA PRADESH - 457882. - 1232. OCEAN MOTORS PVT. LTD. (CFW1-CFW-01),
ROAD, NH 27, DIST- REWA, MP – 486226.. - DEPALPUR
457882 RUNJI CHOURAHA, GAUTAMPURA, TEHSIL -
486226
PH :9755549200 1223. OCEAN MOTORS PVT. LTD. (WB01-WB-03), DEPALPUR, DISTT.-INDORE, MADHYA
PH :9754301199.
9109978301. NEAR LEELA RESIDENCY,INDORE PRADESH . - 453220
BHOPAL CHATTARPUR ROAD,DEPALPUR,DIST.INDORE-MP - 453115 PH :7389936477.
1214. ADINATH CARS PRIVATE LIMITED (8B02-8B-01), PH :7389936488. GOTEGAON
1205. DAGA MOTORS (A UNIT OF DAGA HEIGHTS)
MAHOBA ROAD, NEAR BUS STAND, DEWAS
(0309-03-01), 4/1, DAGA HEIGHTS, NEAR 1233. STANDARD AUTO AGENCIES (BLY1-BLY-01),
CHHATARPUR, DISTT SAGAR - 471001
BUDHNA MANDIR, MAIN ROAD KOLAR ROAD, 1224. UNITARA MOTORS PVT LTD (3Q02-3Q-01), JABALPUR ROAD, OPP. NEW KRISHI UPAJ
PH :9009785577.
CHUNABHATTI, BHOPAL, MADHYA PRADESH. - SURVEY NO 255, A.B. ROAD, MANDI, TEHSIL - GOTEGAON, DIST.
462016 CHHINDWARA RASULPUR SQUARE, DEWAS, -NARSINGHPUR. - 443 001
PH :9109900400. 1215. KAMTHI MOTORS LLP (U502-U5-01), KHASRA MADHYA PRADESH PIN 455001 - 455001 PH :7771003374.
1206. JEEWAN MOTORS PVT. LTD. (0302-03-01), 9E NO.1/53, BESIDE MVM SCHOOL, NAGPUR PH :9770018283. GUNA
SECTOR A,INDUSTRIAL AREA, GOVINDPURA, ROAD, VILL.-SARRA, DISTT. CHHINDWARA, DHAMNOD
BHOPAL - 462024 1234. PREM MOTORS PVT. LTD. (S301-S3-01), OPP
MADHYA PRADESH - 480001
PH :9826017799 1225. KATHED MOTOCORP(A UNIT OF KATHED R.T.O.,A.B. ROAD,GUNA, - 473001
PH :9111488444/ 9111535777.
9826429605. MOTORS PVT. LTD.) (UT01-UT-01), KHASRA NO. PH :268015.
1216. KUNAL MOTORS (U501-U5-03), OPP. KUNAL
1207. JEEWAN MOTORS PVT. LTD. (0302-03-04), 484/1/2, OLD A B ROAD, OPPOSITE HP PETROL GWALIOR
MOTORS SHOWROOM, ,LAL BAGH
KHASRA NO. 54-55/1/1, NEAR RELIANCE PUMP, DHAMNOD, DIST.-DHAR, MADHYA
TIRAHA,BEHIND TRUE VALUE OUTLET, 1235. NIKUNJ MOTORS (3006-30-01), GOLE KA
FRESH,CHUNA BHATTI MAIN ROAD, INDIAN OIL PRADESH. - 454552
NASIRABAD ROAD, CHHINDWARA(MP), - 480001 MANDIR SQUARE, AIRPORT ROAD,
PETROL PUMP, BHOPAL (M.P.) - 462036 PH :9109199032
PH :9981852239. GWALIOR, MADHYA PRADESH - 474005 - 474005
PH :8718802178. 7471111132.
1217. KUNAL MOTORS (U501-U5-06), PLOT NO. 546, PH :9109105599.
1208. RAJRUP MOTOR JUNCTION (A UNIT OF RMJ LAHGARUA NEAR MULLU BABA MANDIR, DHAR 1236. PREM MOTORS PVT. LTD. (3003-30-01), M. L. B.
MOTORS PVT. LTD.) (0308-03-01), 8A, NARSINGHPUR ROAD, CHINDWARA, MADHYA 1226. RUKMANI MOTORS (P) LTD (5304-LM-02), 41/2 ROAD,GWALIOR,, - 474002
SECTOR-C, J.K. ROAD, GOVINDPURA PRADESH - 480002 MAGAJPURA,DHAR,, - 454001 PH :9926809803.
INDUSTRIAL AREA, BHOPAL, MADHYA PH :9981852239. PH :9755549200 1237. PREM MOTORS PVT. LTD. (3005-30-01),
PRADESH - 462023 CHITRAKOOT 9109978301. SHIVPURI LINK ROAD, GWALIOR - 474002
PH :9826333501 PH :9926809803.
DINDORI
9826032579.
HALALPURA - BHOPAL

42
Dealer Workshop (AS ON 31.05.2023 )
1238. DAGA MOTORS (0309-03-02), KHASRA NO. 1247. KTL AUTOMOBILES (5309-53-C1), PLOT 1259. RUKMANI MOTORS (P) LTD (5304-53-04), 1269. RUKMANI MOTORS (SOA1-SOA-01), BYEPASS
80/1/K, VILLAGE - HALALPURA, TEHSIL - HUZUR, NO.5/RC, SCHEME NO 134,MR 10,VILLAGE MANGAL COMPOUND, GODOWN NO. 11-12, ROAD, OPPOSITE JP COLLEGE, JOBAT, MP –
DISTRICT - BHOPAL, MADHYA PRADESH. - KHAJRANA, DIST INDORE-452010,MADHYA VILLAGE 15/1, PIPLYA KUMAR, MR 11 RING 457990. - 457990
462030 PRADESH - 452010 ROAD, DEWAS NAKA, INDORE, MADHYA PH :9755549200
PH :9109900365. PH :8889433301. PRADESH. - 452010 9109978301.
HANSA KHEDI 1248. OCEAN MOTORS PVT. LTD. (5306-53-01), PH :9981078226 KARERA
SCHEME NO 97, PLOT NO 49, PART - 4, 9109978301.
1239. KATHED MOTORCORP (SGI1-SGI-01), MAIN 1270. PREM MOTORS (SMO1-SMO-01), GRAM - JHASI
COMMERCIAL MANDI, RING ROAD, NEAR CAT JABALPUR
DHARMAT ROAD, HANSA KHEDI ROAD, KARERA, DISTRICT - SHIVPURI,
SQUARE, RAJENDRA NAGAR, INDORE,
(CHANDRAWATI GANJ), TEHSIL –SANWER, 1260. MAA GAYTRI (AGGARWAL) (5404-54-01), MOUZA MADHYA PRADESH - 473660. - 473660
MADHYA PRADESH 452012 - 452001
DISTRICT –INDORE, MADHYA PRADESH. - KARMETA N.B. 497, P.H. NO 23/26, KHASRA NO. PH :9926823596.
PH :7389936513.
453551 497 & DIV. KHASRA NO. 484/6, DIV. SHEET NO 2, KATNI
1249. OCEAN MOTORS PVT. LTD. (5306-53-02), NEAR
PH :7471111132. PLOT NO 63/1, JABALPUR-PATAN ROAD,
QUEENS COLLEGE,ASHARAM BAPU ASHRAM, 1271. SHUBH MOTORS PVT LTD (FK01-FK-01),
HARDA JABALPUR. - 482002
KHANDWA ROAD,INDORE - 452017 KHASRA NO.850, NH-7, JHINJARI, INFRONT OF
PH :7489901021.
1240. INFINITY CARS (A UNIT OF FOUZDAR CARS PH :8085916505. POLICE STATION, JABALPUR ROAD, KATNI,
1261. SHUBH MOTORS (5403-54-01), MAHANADDA,
PVT. LTD) (KM01-VY-02), NEAR RTO,INDORE 1250. OCEAN MOTORS PVT. LTD. (5306-53-03), 171A, MADHYA PRADESH. - 483501
MADAN MAHAL ROAD, JABALPUR,
HIGHWAY ROAD,HARDA MP - 461331 174A, 175A, 180A, 181A, 82A, 182A, PH :9755515839.
MADHYAPRADESH - 482001
PH :8889281113. BRAJESHWARI EXTENSION, PIPLIYAHANA, KHANDWA
PH :9755581438.
HATOD INDORE - 452001
1262. SHUBH MOTORS PVT LTD (5403-54-03), 156/5/1, 1272. NIMAR MOTORS PVT. LTD. (AU01-3R-03),
PH :7389936451.
1241. OCEAN MOTORS PVT. LTD. (BVT1-BVT-01), 156/3KA, 156/3KHA, 156/3GHA, BEHIND OM BEFORE VIKAS UDYOG, INDORE ROAD,
1251. OCEAN MOTORS PVT. LTD. (5306-53-04),
726/6, INDORE-DEPALPUR MAIN ROAD, OPP. PETROLEUM, ADHARTAL TIRAHA, JABALPUR, KHANDWA - 450001
SCHEME NO 97, PLOT NO 142 & 151, PART - 4,
HP GAS AGENCY, HATOD DISTT. INDORE - MADHYA PRADESH - 482002 PH :9575105697, 9669569496.
COMMERCIAL MANDI, RING ROAD, NEAR CAT
453111 PH :9755594512. KHARGONE
SQUARE, RAJENDRA NAGAR, INDORE,
PH :7389936477. 1263. STANDARD AUTO AGENCIES (5405-54-07), NEW
MADHYA PRADESH 452012 - 452012 1273. NIMAR MOTORS PVT. LTD. (AU01-AU-01),
HATTA WARD NO. 71, IN FRONT OF ORIENTAL
PH :9285100697. JETAPUR,SANAWAD ROAD,KHARGAONE, -
COLLEGE, KATNI BYPASS, JABALPUR, MP. -
1242. ADHINATH MOTORS (SKK1-SKK-01), NEAR 1252. PATEL MOTORS (INDORE) PVT. LTD. 451001
482003
NAVODAYA SCHOOL, DAMOH ROAD, HATTA, (5303-53-01), 428/3/3,NIRANJANPUR,A B PH :9669569504, 9669569496.
PH :6387098013.
DISTT. DAMOH (M.P.) - 470775. - 470775 ROAD,INDORE - 452010 1274. NIMAR MOTORS PVT. LTD. (AU01-AU-06), PH.
1264. STANDARD AUTO AGENCIES (5405-54-01),
PH :9009787562. PH :9826360699. NO. 35, VILLAGE – DANAPUR, TEHSIL –
OPPOSITE ALLAHABAD BANK,DELITE TALKIES
1253. PATEL MOTORS (INDORE) PVT. LTD. KHARGONE, DISTRICT – KHARGONE, MADHYA
HOSHANGABAD ROAD,CIVIL LINES, JABALPUR - 482001
(5303-53-02), 176/1,PIPLYA RAU,A.B. ROAD PRADESH. - 451001
1243. INFINITY CARS (A UNIT OF FOUZDAR CARS PH :7771014822
,INDORE - 452017 PH :7694011436, 9669569496.
PVT. LTD) (KM01-KM-01), 185, RAMJIBABA 9074360320.
PH :9826360699.
GROUND, HOSHANGABAD, MADHYA PRADESH 1265. STANDARD AUTO AGENCIES (5405-54-03), KHATEGAON
1254. PATEL MOTORS (INDORE) PVT. LTD.
- 461001 DEENDAYAL CHECK, DAMOH NAKA, JABALPUR 1275. UNITARA (BXB2-BXB-01), NEMAWAR-INDORE
(5303-53-03), M.O.G. LINES, NEAR GANGWAL
PH :8889281113. - 482002 ROAD, KHATEGAON, M.P - 455336 - 455336
BUS STAND, DHAR ROAD, INDORE (M.P.) -
PH :7771006920. PH :9770018283.
ICHHAWAR 452006
1266. STANDARD AUTO AGENCIES (5405-54-06),
1244. RAJRUP MOTOR JUNCTION (A UNIT OF RMJ PH :9826360699. KOTMA
CHIMNEY PLOT, MADAN MAHAL, NEAR GULZAR
1255. PATEL MOTORS (INDORE) PVT. LTD.
MOTORS PVT. LTD.) (CIK1-CIK-01), SEHORE HOTEL, JABALPUR - 482001 1276. SHUBH MOTORS (DO01-DO-01), WARD NO.7,
(5303-53-05), SURVEY NO. 174/5 AND 174/6,
NADAN ROAD, NEAR SARASWATI SCHOOL, PH :9302525012. ANNUPPUR KOTMA ROAD, DISTT. ANNUPUR,
PIPLIYA RAO, INDORE, MADHYA PRADESH. -
ICHHAWAR, DISTRICT – SEHORE, MADHYA JAORA KOTMA (M.P.) - 484336
452012
PRADESH. - 466115 PH :9303884800.
PH :9826360699. 1267. PATEL MOTORS (INDORE) PVT. LTD.
PH :9826333501. KUKSHI
1256. RANA MOTORS (5308-53-01), KHASRA NO. (P801-BFR-04), SURVEY NO.57/11/1, RATLAM
INDERGARH 293/2, 299/1, TEJPUR, GADBADI PUL, A.B. 1277. OCEAN MOTORS PVT. LTD. (BIO1-BIO-01),
ROAD, RATLAM NAKA, OPP. KOTHARI AGRIKO,
1245. PREM MOTORS (SPU1-SPU-01), NEAR ROAD, INDORE. - 452009 INDUSTRIAL AREA, INFRONT OF ST. PAUL SURVEY NO.593/5/1, 593/6/1, BARWANI ROAD,
KHERAPATI GARDEN, INDERGARH, MP - 475675 PH :9109975566. SCHOOL, JAORA, DISTT. RATLAM, MADHYA TOLL KANTE KE PASS, TEHSIL-KUKSHI - 454331
. - 475675 1257. RUKMANI MOTORS (P) LTD (5304-53-01), PRADESH - 457226 PH :7389936477,
PH :9926809818. 2-3,,A.B. ROAD,INDORE - 452001 PH :243399, '7089901505, 9926932221. 8085999990.
INDORE PH :9039088702 JHABUA LAKHNADON
9109978301.
1246. KATHED MOTOCORP(A UNIT OF KATHED 1268. PATEL MOTORS (INDORE) PVT. LTD. 1278. KAMTHI MOTORS LLP (SCL1-SCL-01), RANI
1258. RUKMANI MOTORS (P) LTD (5304-53-03), NO.
MOTORS PVT. LTD.) (5307-53-01), PLOT NO. (AAR1-AAR-01), INDORE AHMEDABAD ROAD, DURGAVATI CHOWK, NH-7, WARD NO. - 05,
-4/5, MANORAMA GANJ, INDORE - 452001
483/2/2, MAIN DHAR ROAD, NEAR CHANDAN MEGHNAGAR NAKA, JHABUA ,MADHYA JABALPUR ROAD, LAKHNADON, MADHYA
PH :9109107171
NAGAR POLICE STATION, INDORE, MADHYA PRADESH. - 457661 PRADESH. - 480886
9109978301.
PRADESH. - 452002 PH :9826634449. PH :9285506128.
PH :7471111132. JOBAT MAHESHWAR

43
Dealer Workshop (AS ON 31.05.2023 )
1279. NIMAR MOTORS (SHH1-SHH-01), OPPOSITE 1288. PATEL MOTORS (INDORE) PVT. LTD. 1297. ADINATH MOTORS (SFC1-SFC-01), ATKHASRA 1307. RAJRUP MOTORS (RF03-RF-01), OPPOSITE S P
DEVRAJ HOTEL, MAIN (BRL1-BRL-01), KHASRA NO. 302/1/3, AB ROAD, NO 2017/1, NEAR HDFC BANK MAIN ROAD, OFFICE, NEAR ST. FRANCIS SCHOOL, VIDISHA
MANDLESHWAR-DHAMNOD ROAD, MANPUR, DIST- INDORE - 453661 NIWARI, MADHYA PRADESH –472442. - 472442 ROAD, RAISEN, MADHYA PRADESH. - 464551
MAHESHWAR, MP - 451224 PH :9826360699. PH :9009787562. PH :9826333501.
PH :9669569504, MAUGANJ PANDHURNA RAJGARH
9754979019.
1289. CITY CARS (SEY1-SEY-01), NEAR SENGAR 1298. KAMTHI MOTORS (SFG1-SFG-01), SHANKAR 1308. RUKMANI MOTORS (P) LTD (GKE1-GKE-01),
MAHIDPUR PETROL PUMP ,CHACK MODE WARD NUMBER NAGAR, PANDHURNA, DIST. - CHHINDWARA, CHANDRA SHEKHAR AZAD MARG, NEAR
1280. YUG CARS (A UNIT OF RUKMARANI CARS 03,NH 7 ,MAUGANJ, DISTT – REWA, MADHYA MADHYA PRADESH - 480334. - 480334 TRIMURTI NAGAR, RAJGARH, DIST. - DHAR, MP.
INDORE PVT. LTD) (CWN1-CWN-01), 264/3, PRADESH – 486331. - 486331 PH :9111535777. - 454116
BHIMAKHEDA, MAHIDPUR, UJJAIN - 456443 PH :975301199. PANNA PH :9755549200
PH :9755044300 MHOW 9109978301.
1299. CITY CARS (UNIT OF AGARWAL WHEELS)
9755512100. RATLAM
1290. OCEAN MOTORS PVT. LTD. (WA01-WA-01), A.B. (EQ01-EQ-01), KHASRA NO. 378, MOHAN RAJ
MAIHAR ROAD, NEAR KISANGANJ POLICE STATION, VILAS CHOURAHA, BESIDE MOHAN RAJ HOTEL, 1309. PATEL MOTORS (INDORE) PVT. LTD.
1281. CITY CARS (UNIT OF AGARWAL WHEELS) MHOW - 453441 CIVIL LINE NH-75, PANNA, MADHYA PRADESH . (P801-P8-01), 76 C,D&E,INDUSTRIAL
(D702-GI-04), UNIT OF AGARWAL WHEELS PVT. PH :7389936514. - 488001 AREA,RATLAM - 457001
LTD., NEAR RELIANCE PETROL PUMP, NH-7, MORENA PH :9754301199. PH :99269-32221/93404-31858.
REWA ROAD, MAIHAR (M.P.) - 485771 PARASIA 1310. PATEL MOTORS (INDORE) PVT. LTD.
1291. PREM MOTORS PVT. LTD. (RG01-RG-01), NEAR
PH :9754301199. (P801-P8-03), 181/17/18,DOSHI
SALES TAX BARRIER SQUARE, AB ROAD 1300. KAMTHI MOTORS LLP (GKF1-GKF-01),
MAJHAULI GOAN,INDUSTRIAL AREA ,JAORA
MORENA - 476001 KHIRSADOHMAL, PARASIA, CHHINDWARA. MP -
ROAD,RATLAM - 457001
1282. CITY CARS (SPN1-SPN-01), WARD NUMBER 14, PH :9926809803. 480441
PH :99269-32221/93404-31858.
NAGAR PARISAD MAJHAULI, DIST. SIDHI (M.P) - NAGDA PH :9285506109.
486666. - 486666 REWA
1292. YUG CARS (A UNIT OF RUKMARANI CARS PATAN
PH :9754301199. 1311. CITY CARS (UNIT OF AGARWAL WHEELS)
INDORE PVT. LTD) (CHR2-CHR-01), PLOT NO. 1301. MAA GAYATRI (SHP1-SHP-01), BESIDE KRISHI
MANASA (D702-M2-03), NYPASS CHURHATA,DIST. REWA
17, STATE HIGHWAY NO.17, INDORIYA ROAD, UPAJ MANDI, PATAN, PIN-483119, MADHYA
- 482001
1283. PATEL MOTORS (INDORE) PVT. LTD. NAGDA, DISTRICT – UJJAIN, MADHYA PRADESH - 483119
PH :9754301199.
(BZX1-BZX-01), 982/1, RAMPURA ROAD, PRADESH. - 456335 PH :7489901021.
1312. SHUBH MOTORS (5403-M2-05), VILLAGE –
MANASA, DIST. NEEMUCH, MADHYA PRADESH. PH :9755044300/9755512100. PAWAI RATHARA, TEHSIL – HUZUR, DISTRICT - REWA,
- 458110 NARAYANGARH 1302. CITY CARS (UNIT OF AGARWAL WHEELS) MADHYA PRADESH - 486003 - 486003
PH :9977703139.
1293. PATEL MOTORS (SFN1-SFN-01), 1742/11, (SIX1-SIX-01), NEAR ETORI PETROL PUMP, PH :9755582351.
MANAWAR NARAYANGARH, TEHSIL - MALHARGARH, PANNA ROAD, PAWAI, DIST. – PANNA, MP- SADALPUR
1284. OCEAN MOTORS PVT. LTD. (BVS1-BVS-01), DISTRICT- MANDSAUR, MADHYA PRADESH. - 488446 - 488446
1313. OCEAN MOTORS (SPS1-SPS-01), JAIN SHRI
NEAR SHANTIKUNJ COLONY, 458553 PH :9754301199.
SUPER MARKET, SERVICE ROAD, MHOW-
INDORE-MANAWAR MAIN ROAD, TEHSIL – PH :9977703139. PETLAWAD NEEMUCH ROAD, SADALPUR, DISTRICT DHAR
MANAWAR, DISTRICT – DHAR. - 454335 NARSINGHPUR 1303. PATEL MOTORS (INDORE) PVT. LTD. (M.P) - 454001. - 454001
PH :7389936477.
1294. STANDARD AUTO AGENCIES (BB01-BB-01), KH. (CJD1-CJD-01), NEAR H. P. PETROL PUMP, PH :7389936477.
MANDLA NO. 82/44 & 83/44, NB NO.519, PC NO. 19(42), THANDLA ROAD, PETLAWAD, DISTRICT – SAGAR
1285. STANDARD AUTO AGENCIES (5405-WD-04), OLD 46 (NEW) MOUZA RONSRA R.I.M. 2, TEHSIL JHABUA, MADHYA PRADESH. - 457773
1314. ADINATH CARS PRIVATE LIMITED (G102-G1-01),
KATARA ROAD, MANDLA, DIST. MANDLA MP - & DISTRICT – NARSINGHPUR, MADHYA PH :9926932221.
STATION ROAD, TILAK GANJ, SAGAR (M.P). -
481661 PRADESH. - 487001 PIPARIYA 470001
PH :8959280989. PH :9179779400.
1304. INFINITY CARS (A UNIT OF FOUZDAR CARS PH :9009780030.
MANDSAUR NASRULLAGANJ PVT. LTD) (CGB1-CGB-01), HATHWAS TIRAHA, SANWER
1286. PATEL MOTORS (INDORE) PVT. LTD. 1295. JEEWAN MOTORS PVT. LTD. (CIN1-CIN-01), SHOBHAPUR ROAD, PIPARIYA, MADHYA
1315. RANA MOTORS PVT LTD (CWX1-CWX-01), S.NO.
(WC01-WC-01), NEAR SHIVANA KHASRA NO. 458, VILLAGE – RALA, TEHSIL – PRADESH. - 461775
356/3/1, OLD UJJAIN BYPASS ROAD, TALUKA
BRIDGE,RATLAM MANDSAUR NASRULLAGANJ, DISTRICT – SEHORE, PH :8889281113.
SANWER, DIST.-INDORE, MADHYA PRADESH. -
ROAD,MANDSAUR - 458001 MADHYA PRADESH. - 466331 PITHAMPUR 453551
PH :9977703139. PH :9303884800.
1305. PATEL MOTORS (INDORE) PVT. LTD. PH :9109975566.
1287. PATEL MOTORS (INDORE) PVT. LTD. NEEMUCH
(WC01-WC-02), BLOCK 'C', SHED-5, WARD NO.
(5303-BVD-04), 254-A, SECTOR-1, INDUSTRIAL SATNA
1296. PATEL MOTORS (INDORE) PVT. LTD. AREA, PITHAMPUR, DISTT. DHAR - 454775
1, INDUSTRIAL AREA, CITY - MANDSAUR, 1316. CITY CARS (UNIT OF AGARWAL WHEELS)
(P801-3T-02), MHOW-NEEMUCH PH :9826360699.
MADHYA PRADESH. - 458001 (D702-D7-05), (A UNIT OF AGRAWAL WHEELS
ROAD,NEEMUCH(MP),, - 458441 RAISEN
PH :9977704817. PVT. LTD.), BESIDE BHASKAR PRESS, BEHIND
PH :9977703907.
MANPUR 1306. JEEWAN MOTORS (RF02-RF-01), WARD NO 14, MARUTI SHOWROOM, WARD NO.27, AMOUDHA
NIWARI PATANDEV, SAGAR ROAD, RAISEN, MADHYA KALA, PANNA ROAD, SATNA - 485001
PRADESH - 464551 PH :9754301199.
PH :9644712135. SAUSAR

44
Dealer Workshop (AS ON 31.05.2023 )
1317. KAMTHI MOTORS (CODE UNDER 1326. UNITARA (BGP2-BGP-01), KISHONI, OPPOSITE THIKRI 1345. KANKARIYA AUTOMOBILES PVT. LTD.
CREATIONS-CODE UNDER CREATIONS-CODE HP FUEL STATION, SHUJALPUR, M.P - 465333 - (A501-A5-01), SARDA MILLS,SAVEDI
1336. NIMAR CAR (SED1-SED-01), OPPOSITE OF
UNDER CREATIONS), BESIDE SAUSAR COTTON 465333 ROAD,AHMEDNAGAR, MAHARASTRA - 414001
SHREE BALAJI TYRE SALES & SERVICE, SHREE
INDUSTRIES, CIVIL LINE, PH :9770018283. PH :7410024227.
NAGAR, THIKRI, MADHYA PRADESH –451660. -
NAGPUR-CHHINDWARA ROAD, SAUSAR, SHYAMPUR 1346. KANKARIYA AUTOMOBILES PVT. LTD.
451660
DIST-CHHINDWARA, M.P – 480106. - 480106 (A501-A5-05), MIDC, AHMEDNAGAR - 414003
1327. DAGA MOTORS (SJX1-SJX-01), NEAR MAHADEV PH :9109202186.
PH :9111535777. PH :7447700029.
RESTAURANT, NH-12, SHYAMPUR, DISTRICT – TIKAMGARH
SEHORE SEHORE, MADHYA PRADESH - 466651. - 466651 AJARA
1337. ADINATH CARS PRIVATE LIMITED (RE02-RE-01),
1318. JEEWAN MOTORS PVT. LTD. (0302-EH-02), PH :9752880210. 1347. SAI SERVICE PRIVATE LIMITED (CIR1-CIR-01),
NEAR MAU CHUNGI NAKA, TIKAMGARH (M.P.) -
869/1/2,OFFICERS COLONY,IN FRONT OF SIDHI GAT NO. 30, PLOT NO. 24, GP MILKAT NO.
472001
CHURCH GROUND,BHOPAL, INDORE ROAD - 906/3, NEAR MAYUR PETROL PUMP, AJARA,
1328. CITY CARS (UNIT OF AGARWAL WHEELS) PH :9009987440.
466001 DISTRICT – KOLHAPUR. - 416505
(BKM1-BKM-01), ADHIYAR KHOH, NEAR GYAN UDAIPURA
PH :9617990992. PH :7776837717, 9673331977.
DHARAMKATA, SIDHI, MADHYA PRADESH. -
SENDHWA 486661
1338. JEEWAN (SCI1-SCI-01), WARD NO 3, NH-12, AKLUJ
UDAIPURA, DIST. - RAISEN, MADHYA PRADESH
1319. NIMAR MOTORS PVT. LTD. (CIH1-CIH-01), PH :9754301199. 1348. CHAVAN MOTORS DIVISION INDIA PVT LTD
- 464770
KHASRA NO. 286/10 AND 287/14, HALKA NO. 11, SIHORA (B102-RU-04), PLOT NO. 15/3-A, PANCHVATI
PH :8718911777.
VARLA ROAD, SENDHWA, TEHSIL – SENDHWA, STOP,MALINAGAR ROAD,AKLUJ - 413101
1329. SHUBH MOTORS PVT. LTD. (CIG1-CIG-01), UJJAIN
DISTRICT – BARWANI, MADHYA PRADESH. - PH :0217-223033/8805986848.
KHASRA NO. 31/1, P.H. – 11, MOUZA – GHAT
451666 1339. YUG CARS (3W03-3W-02), 54/3/2, AGAR NAKA, AKOLA
SIMARIYA, TEHSIL – SIHORA, DISTRICT –
PH :7694011408, 9669569496. NEAR VARDHAN HOTEL, MAKODI AAM
JABALPUR, MADHYA PRADESH,. - 483440 1349. KHANDELWAL AUTOWHEELS PVT. LTD.
SEONI PH :9755580253.
CHAURAHA, INDIRA NAGAR, UJJAIN, MADHYA
(F101-F1-01), TIRUPATI CHAMBERS,CONVENT
PRADESH. - 456001
1320. KUNAL MOTORS (U501-8X-05), JYARAT NAKA, SIMROL ROAD,AKOLA - 444005
PH :9755512100,
JABALPUR NAGPUR ROAD, SEONI (M.P.) - PH :9767892552/9112220551.
1330. RUKMANI MOTORS (BZV2-BZV-01), AMRIT 7024235298.
480661 1350. KHANDELWAL AUTOWHEELS PVT. LTD.
SAGAR COLONY, SIMROL, DIST. - INDORE, 1340. YUG CARS (A UNIT OF RUKMARANI CARS
PH :8349999269. (F101-F1-02), PLOT NO E/12-13-MIDC PHASE-2,
MADHYA PRADESH - 452020 - 452020 INDORE PVT. LTD) (3W03-3W-01), SURVEY NO.
SHADOL AKOLA. - 444001
PH :9109978301. 59/3, DEWAS ROAD,UJJAIN - 456010
PH :9767892552/9112220551.
1321. SHUBH MOTORS (MF01-MF-01), JAMUA, NEAR SINGHOLI PH :9755512100,
GYAN GUPTA,BUDHAR ROAD,SHAHDOL, - 7869911945. ALEPHATA
1331. PATEL MOTORS (SEQ1-SEQ-01), BEGHU
484771 UMARIA 1351. THE KOTHARI WHEELS (CSZ1-CSZ-01), GAT
CHITTORGARH ROAD, SINGOLI, NEEMUCH, MP
PH :9755595423. NO.446, MATOSHRI PRIDE, NEAR SADHANA
– 458228 - 458228 1341. SHUBH MOTORS (5403-BVY-04), 8/2 GRAM
SHAHPURA BANK, KALYAN ROAD, A/P – ALEPHATA,
PH :9977703907. BHAGRA, KIRANTAL KHURD, UMARIA DISTRICT
TALUKA – JUNNAR, DISTT. PUNE, PIN-412411 -
1322. STANDARD AUTO AGENCIES (CRD1-CRD-01), SIRONJ UMARIA (MADHYA PRADESH) - 484661
412411
KHASARA NO.172/3, BHERAV MATA MANDIR PH :9755505888.
1332. RAJRUP MOTOR JUNCTION (A UNIT OF RMJ PH :8421753278.
NEAR TOLL NAKA MAIN ROAD, JABALPUR VIDHISHA
NARSINGHPUR ROAD, SHAHPURA. - 483119
MOTORS PVT. LTD.) (CVM1-CVM-01), OPPOSITE ALIBAUG
BALAJI DHAM, LINK ROAD, SIRONJ, MADHYA 1342. DAGA MOTORS (A UNIT OF DAGA HEIGHTS)
PH :7771003374. 1352. SIMRAN MOTORS PVT. LTD. (7S01-3X-05),
PRADESH. - 464228 (AY02-AY-01), PLOT NO 59/1, VILLAGE RANGAI,
SHAJAPUR SURVEY NO. 30/1, OPP. RCF COLONY, VILLAGE
PH :9826333501. VIDISHA, MADHYA PRADESH - 464001
– VESHVI, ALIBAUG, DISTRICT – RAIGAD,
1323. UNITARA (RH03-RH-01), LAL GHATI, A B ROAD, SITAMAU PH :9109900374.
MAHARASHTRA - 402201
SHAJAPUR, MP - 465001 VIDISHA
1333. PATEL MOTORS (SLL1-SLL-01), MAUKHEDA, PH :9223161512, 9270888786.
PH :9770018283.
TEHSIL - SITAMAU, DISTRIST - MANDAUR, 1343. RAJRUP (AY03-AY-01), UDAYNAGAR COLONY, AMALNER
SHAMGARH MADHYA PRADESH - 458990 - 458990 NEAR OIL FACTORY, SAGAR ROAD, VIDISHA,
1353. MANRAJ MOTORS (EL01-EL-01), PRASAD
1324. PATEL MOTORS (INDORE) PVT. LTD. PH :9977703139. DISTRICT-VIDISHA (M.P.) - 464001 - 464001
MOTORS, RAVI
(BFZ1-BFZ-01), KHASRA NO. 1179/1, MOHALLA TARANA PH :7869755501.
NAGAR, NEAR NAYARA PETROL PUMP, DHULE
MAROTH, TEHSIL – SHAMGARH, DISTRICT – WAIDHEN
1334. YUG CARS (A UNIT OF RUKMARANI CARS ROAD, AMALNER, DIST.JALGAON-425401. -
MANDSAUR, MADHYA PRADESH. - 458883
INDORE PVT. LTD) (CHQ2-CHQ-01), HOUSE NO. 1344. CITY CARS (UNIT OF AGARWAL WHEELS) 425401
PH :9977703139.
1/6, WARD NO. 10, TOTLA MARG, (D702-JJ-02), NEAR VIJAY BANDHU PETROL PH :#REF!.
SHIVPURI TARANA-UJJAIN ROAD, TARANA, MADHYA PUMP, KACHANI, THE. WAIDHEN, DISTRICT, AMBERNATH
1325. PREM MOTORS PVT. LTD. (3003-3U-04), A B PRADESH . - 456665 SINGRAULI ,MADHYA PRADESH - 486886
1354. AHER AUTOPRIME LLP (COP1-COP1-01), PLOT
ROAD,SIVPURI,, - 473551 PH :9893563031/9755512100. PH :9754301199.
NO-24,26,27/17, MIDC, KALYAN-BADLAPUR
PH :9926809976. TENDUKHEDA MAHARASHTRA ROAD, VILLAGE - KOHOJ, KHUNTAVLI,
SHUJALPUR 1335. STANDARD AUTO AGENCIES (CRC1-CRC-01), AMBERNATH - 421501
AHMEDNAGAR
KHASARA NO. 49/6, MOUZA – TENDUKHEDA, PH :8422871720.
DISTRICT – NARSINGHPUR . - 470880 AMRAVATI
PH :7771003374.

45
Dealer Workshop (AS ON 31.05.2023 )
1355. ASPA BANDSONS AUTO PVT. LTD. (F201-F2-01), BARSHI 1375. TRISTAR CARS PVT LTD (H302-H3-01), NR. 1385. ARYA CARS (UNIT OF BARBATE AUTOMOTIVE
SATURNA BADNERA HOTEL KUNDAN PLAZA,NAGPUR (I) PVT. LTD) (ZK02-ZK-01), PLOT NO. 10,
1366. CHAVAN MOTORS DIVISION INDIA PVT LTD
ROAD,AMRAVATI,MAHARASTRA, - 444607 ROAD,CHANDRAPUR - 442401 GANESH NAGAR, MUL ROAD, GADCHIROLI ,
(BBA1-BBA-01), GAT NO.1407/1, LATUR ROAD,
PH :9423123665. PH :7722068612. MAHARASTRA - 442702
NEAR ESSAR PETROL PUMP, BARSHI. - 413401
1356. ASPA BANDSONS AUTO PVT. LTD. (F201-F2-05), 1376. TRISTAR CARS PVT LTD (H302-H3-03), NAGPUR PH :8669929188.
PH :8378983726.
A1/A2, OLD BY PASS ROAD, MIDC, AMRAVATI, ROAD, CHANDRAPUR - 442401 GADINGALAJ
DIST: AMRAVATI, MAHARASTRA. - 444607 BEED PH :7722068603.
1386. SAI SERVICE PRIVATE LIMITED (3802-DB-04),
PH :9423339601. 1367. PAGARIYA AUTO PVT. LTD. (V602-V6-01), GUT CHIPLUN 581/7B, PLON NO-12, SANKESHWAR ROAD,
APTA NO. 61, VILLAGE – GHOSAPURI, TALUKA AND
1377. JAGRUT MOTORS PVT LTD (9A01-9A-01), OPP. HOTEL NEELKAMAL, TAL. GADINGLAJ -
DISTRICT – BEED, MAHARASHTRA . - 431122
1357. K.T.S. AUTOMOTORS PVT. LTD. (0582-7S-01), SURVEY NO-543, NH-17, MUMBAI-GOA 416502
PH
VILLAGE: APTA, OPP. APTA RAILWAY STATION, HIGHWAY,AT-KALAMBASTE,TAL-CHIPLUN, PH :02327-222239.
:9834161614/02442256058/02442256056/02442256
LADIWALI, DIST: RAIGAD, PANVEL DIST-RATNAGIRI,MAHARASHTRA - 415605 GONDIA
057/.
(MAHARASHTRA) - 410207 PH :7083687172/8308917693.
BHANDARA 1387. ARYA CARS (UNIT OF BARBATE AUTOMOTIVE
PH :9420611356/94206611326. DAHANU (I) PVT. LTD) (2004-4C-02), ITI ROAD,NR.
AURANGABAD 1368. AUTOMOTIVE MANUFACTURERS PVT. LTD.
1378. SAI SERVICE PRIVATE LIMITED (V901-TD-03), FULCHUR NAKA,OPP LAXMI FLOUR
(2001-FG-03), JINDAL'S BLDG, NEAR NAVKAR
1358. AUTOMOTIVE MANUFACTURERS PVT. LTD. DAHANU-JAWAHAR ROAD, DAHANU(E), MILL,GONDIA - 441601
PETROL PUMP, SAINATH NAGAR, NH-6,
(2102-21-01), PLOT NO. 1,P.B.NO. TAL-DAHANU, DIST. TAHNE - 401602 PH :8888837023/8888859487.
BHANDARA - 441904
716,CHIKALTHANA,AURANGABAD - 431210 PH :9730302821/9167980005/9594952211. 1388. ARYA CARS (UNIT OF BARBATE AUTOMOTIVE
PH :7030932330/9673004280.
PH :9158000046. DAPOLI (I) PVT. LTD) (2004-4C-03), ITI KAWLEWADA
1359. PAGARIYA AUTO PVT. LTD. (2103-21-01), OPP. BHOR ROAD, NEAR HIMGIRI LAYOUT, KARANJA,
1379. JAGRUT MOTORS PVT LTD (G301-VG-06),
OLD HIGH COURT, NEAR HOTEL ASHOKA 1369. SEHGAL AUTORIDERS PVT. LTD. GONDIA, MAHARASHTRA. - 441 601
AT/POST-DAPOLI, DAPOLI-KHED
EXECUTIVE, JALANA ROAD, AURANGABAD - (BSV1-BSV-01), GUT NO. 929/1, UTTROLI, BHOR, PH :8888837023/8888859487.
ROAD,DAPOLI.DIST RATANAGIRI. - 415712
431005 TALUKA – BHOR, DISTRICT – PUNE, GUHAGAR
PH :8308816572/7447752372.
PH :02406659902. MAHARASHTRA. - 412206
DHAMANGAON 1389. JAGRUT MOTORS PVT LTD (BJV1-BJV-01),
1360. AUTOMOTIVE MANUFACTURERS PVT. LTD. PH :9527771016.
SURVEY NO. 23A, SHRUNGALTALI,
(2102-21-03), C-27,MIDC, CHIKALTHANA , N/R BOISAR 1380. ASPA (SFZ1-SFZ-01), RAMDEVBABA NAGAR,
GUHAGHAR-CHIPLUN ROAD, GUHAGAR,
LUPIN LABORATORIES, AURANGABAD, ANJANISINGH ROAD, DHAMANGAON RAILWAY,
1370. SHIVAM AUTO ZONE (ES02-ES-01), PLOT NO. RATNAGIRI, MAHARASHTRA - 415703
MAHARASHTRA - 431006 DIST- AMRAVATI - 444709
J-240, MIDC ROAD, BOISAR, TARAPUR PH :7218548798/7447752072.
PH :9158000059. PH :9850333558.
1361. PAGARIYA AUTO PVT. LTD. (2103-21-05), GAT INDUSTRIAL, MUMBAI, PIN-401501, HINGANGHAT
MAHARAHSTRA - 401501 DHULE
NO. 46, PLOT NO. 50, NEAR MASTER COOK 1390. SEVA AUTOMOTIVE PVT. LTD. (CDZ1-CDZ-01),
RESTAURANT (KAILASH HOTEL) BEED BYPASS PH :8082551155. 1381. SEVA AUTOMOTIVE LTD. (P301-P3-01), GATE
PLOT NO. P-1, HINGANGHAT INDUSTRIAL
ROAD, AURANGABAD, MAHARASHTRA - 431005 BRAMHAPURI NO. 90,AWADHAN,MUMBAI AGRA ROAD,DHULE
AREA, NH-7, AJANTI, HINGANGHAT, TALUK –
PH :9860999484/9860999468. - 424001
1371. TRISTAR CARS PVT LTD (H302-TW-02), 165, HINGANGHAT, DISTRICT – WARDHA,
1362. PAGARIYA AUTO PVT. LTD. (2103-21-06), PLOT PH :02562-281128/29.
NAVEGAON, NEAR VIDYANIKETAN SCHOLL, MAHARASHTRA. - 442301
NO.A-35 MIDC, NEAR MAIN RAILWAY STATION, WADSA ROAD, BRAHMPURI, DIST: DINDORI PH :7722067843.
AURANGABAD - 431001 CHANDARPUR, MAHARASHTRA - 441206 1382. AUTOMOTIVE MANUFACTURERS PVT. LTD. HINGOLI
PH :8408886768/7387279311. PH :7745883000. (AAF1-AAF-01), S.NO.753, NEAR PANDAV
1391. PAGARIYA AUTO PVT. LTD. (IF03-IF-01), PLOT
BADLAPUR BULDHANA PETROL PUMP,NASIK DINDORI ROAD, TAL.
NO.5,7 & 8, SURVEY NO.29/2, AKOLA BY PASS
1363. PRAKASH AUTO PVT. LTD. (9O01-9O-01), SHOP DINDORI, DISTT. NASIK - 422202
1372. MANRAJ MOTORS PVT LTD (COU1-COU-01), ROAD, HINGOLI. - 431513
NO. 2, S. NO. 16, PLOT NO. 25 & 26, KRISHNA PH :9673003132 / 9673006390.
GAT NO. 94, PLOT NO. 11, SUNDERKHED, PH :8411961177.
WATER SUPPLY, OPP. INDIAN OIL PETROL BULDHANA, MAHARASHTRA. - 443 001 DOMBIVALI HUPARI
PUMP, MIDC ROAD, KATRAP, BADLAPUR PH :7875051521. 1383. AUTOMOTIVE MANUFACTURERS PVT. LTD.
(EAST) - 421503 1392. SAI SERVICE PRIVATE LIMITED (CIQ1-CIQ-01),
CHALISGAON (3901-JS-02), PLOT NO. B-43,
PH :8655791288/9870453155. GAT NO.925/8K/2, PLOT NO.7, HUPARI TO
PHASE-1,DOMBIVALI INDUSTRIAL AREA,
1373. MANRAJ MOTORS PVT LTD (AAE1-AAE-01), SL. YALGUD ROAD, HUPARI, TAL-HATKANANGALE,
BALLARPUR DOMBIVALI,DISTT-THANE, MAHARASHTRA, -
NO 406, PLOT NO. 2, NEAR HOTEL RANI PARK, DISTRICT – KOLHAPUR. - 416203
1364. TRISTAR CARS (H302-ZH-04), PLOT NO.11, 421201
DHULE ROAD, CHALISGAON, DIST: JALGAON, PH :9923208454.
BEHIND ZAWERI PETROL PUMP, NEAR GURU PH :8879050913/9769206095/9769206101.
MAHARASHTRA. - 424101
1384. FORT POINT AUTOMOTIVE (CARS) PVT. LTD. ICHALKARANJI
NANAK COLLEGE, ALLAPALLI ROAD, BAMNI, PH :8408889861.
TAH. BALLARPUR - DIST. - 442701 (3906-JS-02), SURVEY NO.13, NEAR 1393. SAI SERVICE PRIVATE LIMITED (4D01-4D-01),
CHANDGAD PIMPLESHWAR TEMPLE, OPP. MAHANAGAR GATE NO. 107,KOLHAPUR
PH :7447473304.
1374. SAI SERVICE PRIVATE LIMITED (BTF1-BTF-01), CNG PUMP, KALYAN-SHILPHATA ROAD, ROAD,KABNOOR,ICHALKARANJI - 416122
BARAMATI
GAT NO.360, G.P.M NO.157, A/P HALKARNI MANGAON, SONARPADA, DOMBIVLI EAST. - PH :0230-2425282.
1365. MAHALAXMI AUTOMOTIVES PVT. LTD. TALUKA CHANDGAD, DISTT. KOLHAPUR, 421203 INDAPUR
(7R01-7R-01), BARAMATI- PHALTAN RD., KASBA, MAHARASHTRA. - 416507 PH :8422800740, 8422978490.
BARAMATI, DIST. PUNE - 413102 PH :9673339103. GADCHIROLI
PH :9881370310.
CHANDRAPUR

46
Dealer Workshop (AS ON 31.05.2023 )
1394. MAHALAXMI AUTOMOTIVES PVT. LTD. 1403. AHER AUTOPRIME LLP (CFV1-CFV-01), SURVEY KHANAPUR (SANGLI) 1423. SAI SERVICE (BUO1-BUO-01), GAT NO-373,
(7R01-NQ-02), STATE HIGHWAY NO. 151, NO.53 & 54, HIND MILL, OPPOSITE STATE BANK VILLAGE-KOREGAON BHIMA, TALUKA-SHIRUR,
1413. CHOWGULE INDUSTRIES LTD (SNM1-SNM-01),
INDAPUR - 412219 OF INDIA, ANDHARWADI ROAD, KALYAN, DIST-PUNE. - 415501
KHANAPUR VITA ROAD, KHANAPUR,
PH :8308807314. MUMBAI - 421301 PH :7774997005.
TAL-KHANAPUR, DIST-SANGLI - 415307
ISLAMPUR PH :9819705444/8657402204/9769927505. KUDAL
PH :75079 66715.
1404. AHER AUTOPRIME LLP (CFV1-CFV-02), SURVEY
1395. CHOWGULE INDUSTRIES PVT. LTD. KHARGHAR 1424. JAGRUT MOTORS PVT LTD (9B01-9B-01),
NO.31B,MOHANE ROAD ,NEAR SHAHAD
(PJ02-PJ-01), GATE NO.905/A/3, NEAR BOMBAY SURVEY NO. 50/5, 51/5, A/P PINGULI,
RAILWAY STATION,SHAHAD,KALYAN. - 421103 1414. EXCELL AUTOVISTA PVT LTD (AAC1-AAC-01),
RAYAN, PUNE-BANGALOE HIGHWAY (NH-4), TEMBDHURI, TALUKA – KUDAL, DISTRICT –
PH :8422871720/8657402204/9833993076. SURVEY NO.742/439, KOPRA VILLAGE,
ISLAMPUR TALUKA : WALVA, DIST:SANGLI - SINDUDURG, MAHARASHTRA - 416520
415409 KANKAVALI SECTOR-10, SION-PANVEL HIGHWAY,
PH :8806664572/8208965235.
KHARGHAR, DIST. RAIGAD - 410210
PH :02342-225757. 1405. JAGRUT MOTORS PVT LTD (G301-V7-05), PLOT KURUDWADI
PH :7666703636 / 9594153308 / 8422991300 /
JALGAON NO.32-33,SURVEY NO.-1886/1,,MUMBAI-GOA
9320357300. 1425. CHAVAN MOTORS DIVISION INDIA PVT LTD
HIGHWAY
1396. MANRAJ MOTORS PVT LTD (C401-C4-01), KHED (CUF1-CUF-01), GAT NO.:256, BYPASS ROAD,
(NH-17),JANAVLI,KANKAVLI,MAHARASHTRA -
AJINTA ROAD, MIDC INDL AREA, JALGAON - A/P KURDA, TALUKA-MADHA, DISTT. SOLAPUR.
416002 1415. JAGRUT MOTORS (COR1-COR-01), GAT NO -
425003 - 413208
PH :7499051071/9021095805. 43/B, MAUZA-BHARNE NAKA, TALUKA-KHED,
PH :9423969538. PH :8806665691.
KARAD DIST-RATNAGIRI. - 415709
JALNA PH :9689533472. KURUNDWAD
1406. CHOWGULE INDUSTRIES PVT. LTD.
1397. AUTOMOTIVE MANUFACTURERS PVT. LTD. KHOPOLI 1426. SAI SERVICE PVT. LTD. (BHO1-BHO-01), GAT
(F303-4E-02), 112/3, PUNE-BANGALORE ROAD,
(2102-BC-02), PLOT NO. 4 & 5 , CTS NO. NO. 250, AT POST - KURUNDWAD, TALUKA -
NEAR RELIANCE GAS PUMP, A/P MALKAPUR, 1416. KIRAN MOTORS (9C02-9C-01), PLOT NO-68,
11427/4-A, BALAJI COMPLEX, SHUROO, DIST.-KOLHAPUR. - 416106
TAL. KARAD, DISTT. SATARA - 415110 VILLAGE-MULGAON, KHOPOLI INDUSTRIAL
JALNA-AURANGABAD ROAD, JALNA, - 431203 PH :9673339695.
PH :9922569835. ESTATE, KHOPOLI, TALUKA-KHALAPUR
PH :9158000063. LANJA
KARJAT DIST-RAIGARH - 410204
JATH PH :8976791922, 8976791920. 1427. JAGRUT MOTORS (SER1-SER-01), GAT NO-663,
1407. SIMRAN MOTORS PVT. LTD. (7S01-TA-03),
1398. CHOWGULE INDUSTRIES PVT. LTD. KOLHAPUR TALUKA-LANJA, DIST - RATNAGIRI,
PANVEL-KARJAT ROAD, KARJAT, DIST. RAIGAD
(J102-BLX-05), PLOT NO. 12, SAWANT ESTATE, MAHARASHTRA -416701 - 416701
- 410201 1417. SAI SERVICE PRIVATE LIMITED (3802-38-01),
MORE COLONY, OPP. CATTLE BAZAR, SATARA PH :8108718346.
PH :8691988895, 8108181978. PLOT NO. 1, E WARD, BEHIND PARVATI
ROAD, JATH, DISTRICT SANGLI, LASALGAON
1408. KANKARIYA AUTOMOBILES PVT. LTD. TALKIES, SHIVAJI UDYAMNAGAR, KOLHAPUR -
MAHARASHTRA - 416404
(GJV1-GJV-01), KARJAT-NAGAR ROAD, KARJAT, 416008 1428. SHAAN CARS PRIVATE LIMITED (BZM1-BZM-01),
PH :02344-246598.
MAHARASHTRA - 414402 PH :0231-2661676. PLOT NO. 337, LASALGAON MAIN ROAD,
1399. SIDHI WHEELS (BLX1-BLX-01), GAT NO- 27/1B,
PH :9890843771. 1418. SAI SERVICE PRIVATE LIMITED (3803-38-01), LASALGAON, TALUKA – NANDGAON, DISTRICT
POST-RAMPUR, JATH-SANGLI ROAD, TALUKA-
JATH, DISTRICT-SANGLI - 416404 KARMAD C-6, SHIROLI MIDC, MENON OPP MENON – NASHIK. - 422306
PISTONS,NH-4, KOLHAPUR - 416122 PH :9075028780, 7720094874.
PH :8956454526. 1409. PAGARIYA (CEB1-CEB-01), GAT NO-245, BHAKTI
PH :0230-2468376. LATUR
JAYSINGPUR COMPLEX, BEHIND BHARAT PETROL PUMP,
1419. SAI SERVICE PRIVATE LIMITED (3802-38-06), R
AURANGABAD ROAD, KARMAD – 431007. - 1429. AUTOMOTIVE MANUFACTURERS PVT. LTD.
1400. SAI SERVICE PRIVATE LIMITED (ASA1-ASA-01), S NO. 1018/1, PLOT NO. 28, APATE NAGAR,
431007 (V801-V8-01), CITY SURVEY NO. 2960, NANDED
GATE NO. 1239, NEAR ACHRYA TULSI BLOOD KALAMBA RING ROAD, KOLHAPUR,
PH :7575077181 / 9687668929. ROAD, OPP. TIRUPATHI LODGE, LATUR -
BANK, A/P UDGAON(JAYSINGHPUR), MAHARASHTRA. - 416012
TALUKA:SHIROL, DIST: KOLHAPUR - 416134 KARMALA PH :0231-2329494.
413512
PH :9607999095.
PH :9673339762. 1410. CHAVAN MOTORS DIVISION INDIA PVT LTD 1420. KR MOTORS KOLKOHUR PVT LTD (3804-38-01),
1430. AUTOMOTIVE MANUFACTURERS PVT. LTD.
JEJURI (GJQ1-GJQ-01), GAT NO. 105, SURVEY NO. PLOT NO. 216/2, 216/3, 216/5, MUMBAI
(V801-V8-02), PLOT NO. 28, 29, 30, SURVEY NO.
3961, KARMALA-NAGAR ROAD, A/P- KARMALA, BANGALORE HIGHWAY,, GOKUL SHIRGAON,
1401. EXCELL AUTO VISTA (SKY1-SKY-01), GAT NO - 36, VARVATTI VILLAGE, LATUR - BARSHI ROAD,
TALUKA - KARMALA, DIST.-SOLAPUR. - 413202 KOLHAPUR. - 416234
224, AT POST-SAKURDE, JEJURI, LATUR - 413512
PH :8806665691. PH :7447755586, 7447755504.
TALUKA-PURANDHAR, DISTRICT-PUNE, PH
PIN-412303. - 412303 KAVATE MAHANKAL KONGAON :9607999091/9607999092/9607999093/9607999094
PH :9146052651. 1411. CHOWGULE INDUSTRIES PVT. LTD. 1421. PRAKASH AUTO PVT. LTD. (3903-AZ-02), /9607999007.
KALWAN (SC02-SC-01), MAHANKALI BAAZAR, KAVATE SURVEY NO.126/127,98/38,AT & POST LONAVALA
MAHANKAL-JAT ROAD, KAVATE MAHANKAL, KONGAON, - 421302
1402. SHAAN CARS PRIVATE LIMITED 1431. SEHGAL AUTORIDERS PVT. LTD.
SANGLI, MAHARASHTRA - 416405 PH :9702809668/9870453155.
(BNW1-BNW-01), GAT NO. 189, PLOT NO. 7, (CGA1-CGA-01), GATE NO. 120/1, VILLAGE –
PH :02341-222102. KOPARGAON
MALEGAON ROAD, A/P KALWAN, NASHIK. - WAKSAI, TALUKA – MAVAL, LUNAVALA,
423501 KHAMGAON 1422. SHAAN CARS PRIVATE LIMITED (COV1-COV-01), DISTRICT – PUNE, MAHARASHTRA. - 410405
PH :9075028780, 9689003988. 1412. MANRAJ MOTORS PVT LTD (BXU1-BXU-01), GAT SURVEY NO. 15/36 GAWARE PATIL ESTATE, PH :89753 73431.
KALYAN NO 41, OLD SURVEY NO. 12/1A, NEAR AMRUT NAGAR MANMAD HIGHWAY, NEAR ASHOKA MAHAD
PETROL PUMP, AKOLA ROAD, KHAMGAON , HOTEL, KOPARGAON. - 423 601
MAHARASHTRA - 444303 PH :9075028780.
PH :07623-250002/3. KOREGAON BHIMA

47
Dealer Workshop (AS ON 31.05.2023 )
1432. SIMRAN MOTORS PVT. LTD. (7S01-TX-04), NEAR MORGAON 1451. SHIVAM AUTO ZONE (I) PVT. LTD. (0531-05-01), 1461. SEVA AUTOMOTIVE LTD. (2002-20-01), 34/3,
RELIENCE PUMP, PANVEL-GOA ROAD, MAHAD, CHARKOP INDUSTRIAL ESTATE, KACHIMET AREA, NEAR VAYUSENA NAGAR
1441. MAHALAXMI AUTO (CODE UNDER
DIST. RAIGAD - 402301 KANDIVLI(WEST), MUMBAI, MAHARASHTRA - BUS STOP, WADI, AMRAVATI ROAD, NAGPUR -
CREATIONS-CODE UNDER CREATIONS-CODE
PH :9870404323. 400067 440023
UNDER CREATIONS), GAT NO-179, MORGAON, -
MALEGAON PH PH :0712-6652863.
TALUKA- BARAMATI, DIST-PUNE - 412304
:7718893072/9152001329/8082551017/9870938888 1462. AUTOMOTIVE MANUFACTURERS PVT. LTD.
1433. SHAAN CARS PRIVATE LIMITED (3703-FF-02), PH :9850994014.
. (2001-20-02), 575 KAMPTEE ROAD,NAGPUR-26,,
PLOT NO. 572/81,CHANDANPURI SHIVAR,OLD MUMBAI 1452. VITESSE PRIVATE LIMITED (0503-05-07), PLOT - 440026
MUMBAI, AGRA ROAD, DIST- NASIK,MALEGAON
1442. SAI SERVICE PRIVATE LIMITED (0504-05-01), NO.A59, KANDIVALI INDUSTRIAL CO-OP. SOC., PH :9673004226/9673004223.
- 423203
462 SENAPATI BAPAT MARG,WORLI GOVERNMENT INDUSTRIAL ESTATE, 1463. SEVA AUTOMOTIVE LTD. (2002-20-03), PLOT
PH :9922969620/9922969656.
NAKA,LOWER PAREL,MUMBAI - 400013 CHARKOP, KANDIVALI (W), MUMBAI - 400067 NO. 33A, CENTRAL MIDC, HIGNA ROAD,
MANCHAR PH :9594952122/9594952088/9167980082. PH :02228674753. NAGPUR, MAHARASHTRA, - 440016
1434. THE KOTHARI WHEELS (1906-AGA-04), SOHAM 1443. SAI SERVICE PRIVATE LIMITED (0504-05-02), 1453. FORT POINT AUTOMOTIVE (CARS) PVT. LTD. PH :0712-666444.
NAGARI, A-WING, SHOP NO.8 & 16, PUNE NASIK ARVIND CHAMBERS,194 ANDHERI KURLA (0521-05-03), C/O VARUN STEEL 1464. ARYA CARS (UNIT OF BARBATE AUTOMOTIVE
HIGHWAY, A/P MANCHAR, TALUKA: ROAD, ANDHERI(EAST), MUMBAI - 400069 INDUSTRIES,AAM TOOL COMPOUND,BOAT (I) PVT. LTD) (2004-20-01), NEAR PARDY NAKA
AMBEGAON, DISTT: PUNE, MAHRASHTRA - PH :43030606 /600, 95949552341 / 9594952084 / HURT ROAD, BEHIND SEWARI POLICE (OUTSIDE), NH-6, BHANDARA ROAD,NAGPUR -
410503 9594952250. STATION, DARUKHANA, REAY ROAD, MUMBAI - 440035
PH :8411003608. 1444. VITESSE PRIVATE LIMITED (0503-05-01), SHAH 400010 PH :8888859506/8888859534.
MANGALVEDHA INDL.ESTATE, PLOT 11 LINK ROAD, ANDHERI PH :9594974678, 8691045341. 1465. AUTOMOTIVE MANUFACTURERS PVT. LTD.
(WEST), MUMBAI - 400058 1454. SHIVAM AUTO ZONE (I) PVT. LTD. (0531-05-02), (2001-20-05), PLOT NO. 38/1, NEAR BOUDDHA
1435. CHAVAN MOTORS (CODE UNDER PLOT NO. 4&5, RAMCHANDRA LANE EXTN., OFF VIHAR, OPP. DELHI PUBLIC SCHOOL, KAMPTEE
PH
CREATIONS-CODE UNDER CREATIONS-CODE LINK ROAD, KANCHPADA, MALAD-WEST. ROAD, NAGPUR, MAHARASHTRA - 441001
:02226730787/02226730280/02226730296/0226164
UNDER CREATIONS), NEAR SWARAJYA HOTEL, MUMBAI. 400064. - 400064 PH :9168699701/9673004277.
2500/02261642500.
PANDHARPUR ROAD, CHOKAMELANAGAR, PH :8082551115/9362721124/9870938888. 1466. ARYA CARS (UNIT OF BARBATE AUTOMOTIVE
1445. VITESSE PRIVATE LIMITED (0503-05-02), 77 AF
MANGALWEDHA, MAHARASHTRA, PIN-413305 - 1455. VELOX MOTORS (A UNIT OF CARCRAFT (I) PVT. LTD) (2007-20-01), PLOT NO. 4, NEW
PALKY GULLY,OFF VEER SAVARKAR MARG,
413305 AUTOMOBILES PVT LTD) (05A3-05-01), PLOT COTTON MARKET, GHAT ROAD, NAGPUR,
PRABHADEVI, MUMBAI - 400025
PH :8805778881. NO.115/116/117 MIVERVA INDUSTRIAL ESTATE, MAHARASTRA - 440018
PH :24229747/24223933/9821894915.
MANGAON 1446. SAH & SANGHI AUTO AGENCIES PVT.LTD MULUND-WEST, MUMBAI - 400080 PH :8888859542.
1436. SIMRAN MOTORS PVT. LTD. (BAM1-BAM-01), (0505-05-01), PRAKASH MILLS COMPOUND,OFF. PH :8104989839/8104989847. 1467. ARYA CARS (UNIT OF BARBATE AUTOMOTIVE
SURVEY NO.97, AT-POST-NANORE, NH-17, GLOBE MILLS PASSAGE,WORLI,MUMBAI - 1456. KIRAN MOTORS (05A7-05-01), CTS NO. 170 & (I) PVT. LTD) (2007-20-02), PLOT NO. 131, NH-6,
MUMBAI-GOA HIGHWAY, MANGAON, RAIGAD, 400013 4081, BOMBAY AGRA ROAD, LB SHASTRI BHANDARA ROAD, MAHALGAON, NAGPUR,
MAHRASTHRA. - 402104 PH :02224925452/02224925453/02224925454. MARG, GHATKOPAR (WEST), MUMBAI, MAHARASTRA. - 441202
PH :9223181120. 1447. SAI SERVICE PRIVATE LIMITED (0504-05-04), MAHARASHTRA, PINCODE: 400086. - 400086 PH :8888820312.
C/O SHAKTI INDUSTRIAL WIRE PH :9152004223/7700988886. 1468. SEVA AUTOMOTIVE PVT. LTD. (2002-20-04),
MANMAD
COMPOUND,DATTA PADA ROAD,BORIVILI 1457. MY CAR (PUNE) PVT LTD (05A8-05-01), PLOT PLOT NO.05, 12, 13A, 13B CHANDRABHAGA
1437. SHAAN CARS PRIVATE LIMITED (BNX1-BNX-01), (EAST),MUMBAI - 400066 NO-10, CHANDIVALI ESTATE, CHANDIVALI GRUHA NIRMAN SAHAKARI LIMITED, KH
GAT NO. 11/3, PLOT NO. 1 AND SHOP NO. 3 & 4, PH :28707000 / 9594057006 / 9594952344 / FARM ROAD, OPP LAKE HOMES, ANDHERI NO.45/3, CITY SURVEY NO.570, MANEWADA
NANDGAON ROAD, MANMAD. - 423104 9594952417. EAST, MUMBAI, MAHARASHTRA - 400072 RING ROAD, NAGPUR, MAHARASHTRA - 440027
PH :9075028780, 8888832369. 1448. EXCELL AUTOVISTA PVT LTD (0510-05-01), PH :8104907081. PH :8390446644.
MANOR RESHAM SINGH COMPOUND,CST MURBAD 1469. ARUN MOTORS (2008-20-01), PLOT NO-9&10,
1438. SAI SERVICE PRIVATE LIMITED (CRE1-CRE-01), ROAD,KALINA, SANTACRUZ EAST,MUMBAI - PATNI PLAZA, KHAMLA RING ROAD,
1458. PRAKASH AUTO PVT. LTD. (BYO1-BYO-01),
400098 SAWARKAR NAGAR, NAGPUR, MAHARASHTRA
GUT NO. 37, NEAR MSEB POWER STATION, SURVEY NO. 61/2, KALYAN - MURBAD ROAD,
PH :67743888,26653242, 43, 46 / 7666703636 / - 440025
PALGHAR MANOR ROAD, AT POST – VILLAGE – DAHAGAON, TALUKA – MURBAD,
9594972889 / 7715804477. PH :7757988800/7028688800.
TAKVAHAL, DISTRICT – PALGHAR, MANOR. - DISTRICT – THANE, MAHARASHTRA. - 421605
1449. AUTOMOTIVE MANUFACTURERS PVT. LTD. 1470. ARUN MOTORS (2008-20-02), C-48/1, MIDC
401403 PH :7798725726.
(3901-05-04), PLOT NO. 108, BAZAR WARD, HINGNA MAIN ROAD, WADI, NAGPUR,
PH :9167980005. MURGUD
KURLA(WEST) , MUMBAI - 400070 PIN-440028, MAHARASHTRA - 440028
MIRA ROAD, THANE PH :7757988800.
PH :61563734 / 61563744 / 61563713 /9167773925. 1459. SAI SERVICE PRIVATE LIMITED
1439. SUPREME AUTOMOBILES (3915-39-01), 1450. FORT POINT AUTOMOTIVE (CARS) PVT. LTD. (AWA1-AWA-01), R.S. NO. 188/4, A/P MURGUD, NALASOPARA
BRILLIANT COMPLEX, WESTERN EXPRESS (0521-05-02), D-9, STREET NO. 21, OPP PATNI TALUKA: KAGAL, DIST: KOLHAPUR - 416219
1471. SHIVAM AUTO (CUH1-CUH-01), SURVEY NO.
HIGHWAY, MIRA ROAD, THANE- 401107. - COMPUTERS, SEEEPZ, MIDC, ANDHERI, PH :02325-265553.
91,92 , PLOT NO. 7, VILLAGE- DHANIV,
401107 MUMBAI - 400096 MURTIZAPUR NALASOPARA, DIST. PALGHAR,
PH :8591942704. PH :9694973889, 8422800747.
1460. KHANDELWAL AUTOWHEELS (SHE1-SHE-01), MAHARASHTRA. - 401209
MIRAJ PH :9152001458/7777002930.
SURVEY NO 38, MAUJA SONORI, NH 06, NEAR
1440. CHOWGULE INDUSTRIES PVT. LTD. HOTEL DEVA, MURTIZAPUR, DISTRICT-AKOLA - NANDED
(J102-SD-03), 42C , OPP. WHISPERING WOODS, 444107
1472. SEVA AUTOMOTIVE LTD. (6801-68-01), NANDED
MIDC AREA, TALUKA MIRAJ, DISTT. SANGLI, PH :#REF!.
HYDERABAD ROAD, NANDED - 431604
MAHARASHTRA - 416410 NAGPUR PH :7447415607.
PH :0233-2643221,0233-264322.

48
Dealer Workshop (AS ON 31.05.2023 )

NANDURBAR 1484. KANKARIYA AUTOMOBILES PVT. LTD. 1493. AUTOMOTIVE MANUFACTURERS PVT. LTD. 1502. SAI SERVICE PRIVATE LIMITED (1901-19-02),
(BSU1-BSU-01), BELOW ADARSH GRAMIN (3901-7S-03), PLOT NO:92/1, VILLAGE KOLAKHA, 889/90 J.M.ROAD, DECCAN GYMKHANA, PUNE -
1473. SEVA AUTOMOTIVE LTD. (P301-KW-02), P NO.
BANK, OPP. ILAKSHI MOTORS, NEVAS PHATA, MUMBAI-GOA HIGHWAY, PANVEL, DISTT. 411004
-324, BASILAL NAGAR SHAHADA BYPASS
AURANGABAD ROAD, TALUKA – NEVASA, RAIGAD - 410206 PH :9923208347.
ROAD, NEAR HOTEL KAREN GARDEN,
DISTRICT – AHMEDNAGAR. - 414603 PH 1503. CHOWGULE INDUSTRIES PVT. LTD.
CHAUFULLY NANDURBAR-425412 - 425412
PH :9420494601. :9769202055/9769206045/9769206018/8291467042 (1908-19-02), S.NO. 53,PUNE SATARA
PH :7720017528.
NIPHAD . HIGHWAY,KATRAJ,PUNE - 411046
NARAYANGAON PARATWADA PH :020-66786200.
1485. SHAAN CARS PVT. LTD. (COX1-COX-01), GAT
1474. THE KOTHARI WHEELS (1906-FV-02), GATE NO. 1504. SAI SERVICE PRIVATE LIMITED (1901-19-03),
NO. 99/3, RASALPUR AURANGABAD HIGHWAY, 1494. ASPA BANDSONS AUTO PVT. LTD.
747, PUNE NASIK HIGHWAY, WARULWADI, S.NO.15A GIDWANI COMPOUND, KONDWA
NIPHAD, DISTRICT – NASHIK, MAHARASHTRA. - (CFZ1-CFZ-01), SURVEY NO. 26/4A, RAMGAON,
NARAYANGAON - 410504 BUDRUK, HAVELI, PUNE - 411046
422303 AMRAVATI PARATWADA ROAD, NEAR JAWARDI
PH :8411003608. PH :9923208345.
PH :9075028780. PHATA, PARATWADA TALUKA – ACHALPUR,
NASHIK 1505. WONDER CARS PVT LTD (1903-19-02), 12, NPS
OSMANABAD DISTRICT – AMRAVATI . - 444 805
LINES,SOLAPUR ROAD,,OLD POOL
1475. AUTOMOTIVE MANUFACTURERS PVT. LTD. PH :7720097106.
1486. CHAVAN MOTORS DIVISION INDIA PVT LTD GATE,CAMP, PUNE - 411001
(3702-37-01), P-1-12,ADDITIONAL NASIK INDL.
(B102-LW-03), PLOT NO. A-53, INDUSTRIAL PARBHANI PH :020-26332934/35.
AREA,AMBAD,NASIK - 422010 1506. THE KOTHARI WHEELS (1906-19-01), 110/A,
AREA, MIDC, OSMANABAD - 413501 1495. PAGARIYA AUTO PVT. LTD. (LN02-LN-01),
PH :9673000262 / 9673000822 / 9673000842. PUNE SOLAPUR ROAD, NEAR FATIMA NAGAR,
PH :8888867861. SURVEY NO-301, PLOT NO-86/A, OPP
1476. SEVA AUTOMOTIVE LTD. (3701-37-01), PLOT PUNE - 411039
PABAL GULMOHAR LODGE, BASMAT ROAD, PARBHANI
NO. X - 46,MIDC. AMBAD, NASIK - 422010 PH :7498272309.
- 431401
PH :0253-6644444. 1487. MAHALAXMI (SKB1-SKB-01), 3733, SHINALKAR 1507. MY CAR (PUNE) PVT. LTD. (1907-19-01),
PH :9511868433.
1477. SHAAN CARS PRIVATE LIMITED (3703-37-01), WASTI, SURVEY NO. 131, MUMBAI BANGALORE
E-3 MIDC AREA,SATPUR , PABAL, TALUK SHIRUR, PATAS
HIGHWAY, WAKAD, PUNE - 411057
NASIK,MAHARASHTRA - 422007 PUNE, PIN 412403 - 412403 1496. MAHALAXMI AUTOMOTIVES PVT. LTD. PH :020-67922900.
PH :9075028780, 9922969646. PH :8956288087. (7R01-PR-03), PUNE-SOLAPUR HIGHWAY, 1508. ACE KUDALE CAR PVT. LTD. (1910-19-01),
1478. SHAAN CARS PRIVATE LIMITED (3703-37-04), PAITHAN PATAS, TALUKA DAUND DISTT.-PUNE - 413106 36/2C/1, MANJRI BUDRUK, PUNE-SOLHAPUR
03/810, NEAR NASARDI BRIDGE, WADALA PH :8888890957. ROAD, TALUKA HAVELI, DISTRICT PUNE -
1488. PAGARIYA AUTO PVT. LTD. (BNQ1-BNQ-01),
ROAD, NASIK ROAD, NASIK - 422011 PEN 412201
GAT NO-277, MAUZA- PAITHAN, TALUKA-
PH :0253-2236080. PH :9552582454.
PAITHAN, DIST - AURANGABAD 431107. - 431107 1497. SIMRAN MOTORS (9I01-9I-01), AT SURVEY NO
1479. SEVA AUTOMOTIVE LTD. (3701-37-06), SEVA 1509. CHOWGULE INDUSTRIES PVT. LTD.
PH :9922994237. 75, PLOT NO 2, MUMBAI-GOA HIGHWAY,
FARMS, GATE NO. 82/2, AMBE BAHULA ROAD, (1911-19-01), S.NO.1, NEXT TO PODAR
PALGHAR WADHKAL (PEN) - 402107
VILHOLI, TALUKA & DISTRICT: NASIK, INTERNATIONAL SCHOOL, KATRAJ BYPASS
PH :9503381198.
MAHARASHTRA - 422010 1489. SAI SERVICE PRIVATE LIMITED (TE01-TE-01), ROAD, AMBEGAON-B, TALUKA-HAVELI, PUNE -
PH :9146000709. SURVEY NO. 86/1, TEMBHODE, MANOR-MAHIM PHALTAN
411046
1480. SEVA AUTOMOTIVE PVT LTD (3701-37-07), ROAD, PALGHAR, DISTRICT: THANE - 401404 1498. CHOWGULE INDUSTRIES PVT. LTD. PH :02066803555/02066803500.
PLOT NO.A-23, NICE INDUSTRIAL AREA, MIDC, PH :9167980042/9167980005/9594952211. (KH02-KH-01), PLOT NO.83/1B/1, LONAND-PUNE 1510. SAI SERVICE PRIVATE LIMITED (1901-19-05),
SATPUR, NASIK (MAHARASHTRA) - 422006 PALUS ROAD, PHRANANDWADI, TALUKA:PHALTAN, NEAR NIGDI-BHOSARI ROAD, CHINCHWAD,
PH :0253-6634444. DISTRICT: SATARA, MAHARASTRA. - 415523 PUNE - 411019
1481. SEVA AUTOMOTIVES PVT LTD (3701-37-08), 1490. CHOWGULE INDUSTRIES PVT. LTD.
PH :8888886301. PH :020-46605999/020-46605995.
SHOP NO. 1 & 2, SER. NO. 241/1-B-1/2, (J102-0Z-04), PLOT NO.B-3, MIDC AREA, TALUKA
PALUS, DISTT. SANGLI. - 416308 PIMPLEGAON 1511. SEHGAL AUTORIDERS PVT. LTD. (1913-19-01),
OPPOSITE NMC SCHOOL, DINDORI ROAD, SURVEY NO. 51, BAVDHAN KHRUD, TAL:
MAHSRUL, NASHIK, MAHARASHTRA - 422004 PH :8888870122. 1499. AUTOMOTIVE MANUFACTURERS PVT. LTD.
HAVELI, DIST: PUNE - 411021
PH :0253-6654444. PANDHARPUR (BAY1-BAY-01), GAT NO.517/P NEAR MARKET
PH :8308304444, 020-41463625, 020-41463627.
COMMITTEE, MUMBAI AGRA HIGHWAY, NH3
NAVI MUMBAI 1491. CHAVAN MOTORS DIVISION INDIA PVT LTD 1512. SAI SERVICE PRIVATE LIMITED (1901-19-06),
A/P PIMPALGAON BASWANT, TALUKA: NIPHAD,
1482. AUTOMOTIVE MANUFACTURERS PVT. LTD. (B102-0H-05), GAT NO.56, ESABAVI, PUNE SURVEY NO.244/1, PHASE-II, NEAR BANK OF
DIST-NASHIK - 422202
(3901-9K-01), D-234 MIDC TTC INDL ROAD, TAL:PANDERPUR, SOLAPUR - 413001 MAHARASHTRA, HINGEWADI, TAL - MULSHI,
PH :9673000844 / 9673001204.
AREA,SHIRVANE NERUL,NEW BOMBAY, - PH :7774997005. DISTRICT-PUNE,MAHARASHTRA - 411057
PIRANGUT PH :9923208302.
400706 PANVEL
PH :66143900/66133923/66143924. 1500. MY CAR (SEC1-SEC-01), GAT NO-314, AT 1513. ACE KUDALE CAR PVT. LTD. (1910-19-02),
1492. SIMRAN MOTORS PVT. LTD. (7S01-7S-01),
1483. SIMRAN MOTORS PVT. LTD. (3913-9K-01), VILLAGE-KASAR AMBOLI, PIRANGUT, TALUKA ATLAS TANKS VESSELS, SR. NO 232/2,
PLOT2-8,SECTOR-15, OPP. HOTEL
CAMEO FABRIC COMPANY, GEN 16, NEAR -AMBOLI, DIST-PUNE, PIN-412108. - 412108 PUNE-NASIK ROAD, KHANDOBAMAL, BHOSARI,
GARDEN,OLD MUMBAI PUNE
SULZER COMPANY, DIGHA, TTC AREA, AIROLI - PH :9325424613. PUNE. - 411039
HIGHWAY,PANVEL - 410206
400701 PUNE PH :9552193904.
PH :8291957798, 8657443202.
PH :8788582329, 8369658212. 1514. THE KOTHARI WHEELS (1906-19-03), PLOT NO.
1501. SAI SERVICE PRIVATE LIMITED (1901-19-01),
2B, D1 BLOCK, CHINCHWAD, PUNE, DIST. PUNE
NEVASA BOMBAY PUNE ROAD, FUGEWADI, PUNE -
- 411019
411012
PH :9168662302.
PH :020-46404440/020-46404448.

49
Dealer Workshop (AS ON 31.05.2023 )
1515. MAHALAXMI AUTOMOTIVES PVT. LTD. 1526. SUMANKIRTI CARS PVT. LTD. (1915-19-02), 1536. CHOWGULE INDUSTRIES PVT. LTD. 1545. SAI SERVICE (BFT1-BFT-01), GATE NO. 1213,
(1912-19-03), 59/A, MUNDHWA KHARADI ROAD, SURVEY NO. 9, NEAR BALEWADI SPORTS (J102-J1-01), GAT NO.243 SANGLI KOLHAPUR R/AT DONOLI, TALUKA - SHAHUWADI, DIST.
OPP. MUNDHWA POLICE STATION, MUNDHWA, STADIUMM MUMBAI-BANGALORE HIGHWAYS, ROAD, OPP. TO GAJANAN MAHARAJ MANDIR, -KOLHAPUR - - 416 213
PUNE, MAHARASHTRA - 411036 MAHALUNGE PUNE, MAHARASHTRA. - 411045 ANKALI, TAL-SANGLI, DISTT. SANGLI - 416416 PH :9923208448.
PH :8888874980. PH :8551990106. PH :9850966805. SHILTPATA
1516. WONDER CARS PVT LTD (1903-19-03), PLOT 1527. MY CAR (PUNE) PVT. LTD. (1918-19-01), GAT 1537. SIDDHI WHEELS (J104-J1-01), SR NO. 917//2/B,
1546. VELOX MOTORS (SGJ1-SGJ-01), SURVEY NO-
NO.52/1 BLOCK F2, MIDC, PIMPRI, PUNE. - NO. 625, HISSA NO. 1/3/1, VILLAGE – KURULI, SANGLI MIRAJ ROAD, MIRAJ, DISTRICT - SAGLI.
99/2B, VILLAGE-DAIGHAR, KALYAN SHIL-PHATA
411018 TALUKA – KHED, CHAKAN, DISTRICT – PUNE. - - 416410
ROAD, NEAR DATTA MANDIR, POST-PADALE,
PH :020-46608888. 410501 PH :9371727001, 0233-2211610/1620/1630.
DIST-THANE, PIN-421204. - 421204
1517. SAI SERVICE PRIVATE LIMITED (1901-19-07), PH :7755900000. SANGOLA PH :8419984188.
4/A/1A, 1/3 A, SALUNKE VIHAR ROAD, BORADE 1528. WONDER CARS PVT LTD (1903-19-04), SURVEY
1538. CHAVAN MOTORS DIVISION INDIA PVT LTD SHIRUR
NAGAR, KONDWA, PUNE, MAHARASHTRA. - NO. 20, HISSA NO. 1/1/2, THERGAON, BAL
(CUE1-CUE-01), GAT NO. 276/14/A, MAIN ROAD,
411048 KRISHNA MANGAL KARYALAYA, TALUKA – 1547. MAHALAXMI AUTOMOTIVES PVT. LTD.
KOLHAPUR HIGHWAY, A/P & TALUKA -
PH :9923208358. MULSHI, DANGE CHOWK, PUNE – 411 033. - (ZD01-ZD-01), 1023/1, NEXT INDIAN OIL PETROL
SANGOLA, DIST.-SOLAPUR. - 413307
1518. MAHALAXMI AUTOMOTIVES PVT. LTD. 411033 PUMP, SARADWADI, PUNE-AHMEDNAGAR
PH :8806665691.
(1912-19-04), NO.485/1, CTS NO.1041, OM PH :7887883311. HIGHWAY, TAL: SJIRUR, DIST: PUNE,
SUPER MARKET, GHOKALE CROSS ROAD, RAHATA SASWAD MAHARASHTRA - 412210
MODEL COLONY, SHIVAJI NAGAR, PUNE - 1539. CHOWGULE INDUSTRIES PVT. LTD. PH :8888837082 /9011038682.
1529. KANKARIYA AUTOMOBILES PVT. LTD.
411016 (1908-PH-03), PLOT NO 74/2/A/P, BEHIND SHIRWAL
(ZV03-ZV-01), SHIRDI ROAD, SAKORI, RAHATA, -
PH :8888842887. PURANDAR HIGH SCHOOL, BESIDE MAHADA
423107 1548. CHOWGULE INDUSTRIES PVT. LTD.
1519. CHOWGULE INDUSTRIES PVT. LTD. COLONY, SASWAD, TALUKA PURANDAR, PUNE
PH :8275033313. (BSD1-BSD-01), GAT NO.175, A/P SHINDEWADI,
(1908-19-05), 129/2/B/1, NEW PUNE MUMBAI - 412301
HIGHWAY, KATRAJ DEHU ROAD BYPASS, RAHURI PH :02115224450/02115225210.
SHIRWAL-BHOR ROAD, SHIRWAL, TAL
TATHWADE, TAL-MULASHI, DISTT. PUNE KHANDALA, DISTT. SATARA - 412801
1530. KANKARIYA AUTOMOBILES PVT. LTD. SATANA
(MAHARASHTRA) - 411033 PH :9637399003.
(COZ1-COZ-01), TRIMURTI CRANE SERVICE,
PH :020-67915700/7385265700. 1540. SHAAN CARS (BSW1-BSW-01), GAT NO SHRIRAMPUR
NAGAR-MANMAD ROAD, RAHURI,
1520. SAI SERVICE PRIVATE LIMITED (1901-19-08), 322/2/A/7, PUNDLIK NAGAR MALEGAON ROAD,
MAHARASHTRA. - 413705 1549. KANKARIYA AUTOMOBILES PVT. LTD.
SURVEY NO. 37, HISSA NO. 2, SITUATED AT AT POST SATANA DIST NASHIK - 423301 -
PH :9130026767. (LV03-LV-01), S.NO.139/1/3, NEAR NAKA NO.4,
WADGAON KHURD, NEAR NANDED CITY, 423301
RAJAPUR PH :9922969656.
SANGAMNER ROAD, SHRIRAMPUR DISTT.
SINHAGAD ROAD, TALUKA - HAVELI, DISTRICT - AHMEDNAGAR - 413709
PUNE, MAHARASHTRA. - 411 041 1531. JAGRUT MOTORS PVT LTD (AHA1-AHA-01), SATARA PH :9420494543.
PH :9923208312. SURVEY NO. 14/8, TARALWADI, RAJAPUR,
1541. CHOWGULE INDUSTRIES PVT. LTD. SIKRAPUR
1521. THE KOTHARI WHEELS (1906-19-05), PLOT NO. DIST: RATNAGIRI - 416702
(F303-F3-01), PLOT NO. B-2,OLD MIDC,SATARA -
24/B, HADAPSAR INDUSTRIAL ESTATE, PUNE. - PH :9527623663/8806665572. 1550. EXCELL AUTOVISTA PVT LTD (GKJ1-GKJ-01),
415002
411028 RAJGURUNAGAR PH :9011015066/9850966823.
AT POST SHIKARPUR MALTHAN PHATA, OPP.
PH :8411002005, 8087060432. CHAURASIYA CHANA CENTER, PUNE NAGAR
1532. MY CAR (PUNE) PVT. LTD. (CBZ1-CBZ-01), SAVNER
1522. CHOWGULE INDUSTRIES PVT. LTD. ROAD, TALUKA SHIRUR, DIST. PUNE,
SURVEY NO.94, SANDBHORWADI, NEAR TUKAI
(1908-19-06), SR. NO.- 43/44/S, 7 PARVATI 1542. ARYA CARS (UNIT OF BARBATE AUTOMOTIVE PIN-412208, PUNE - 412208
MANDIR, PUNE-NASIK HIGHWAY, TAL-KHED,
INDUSTRIAL ESTATE, OPP. ADINATH SOCIETY, (I) PVT. LTD) (BTJ1-BTJ-01), PLOT NO -2 PH :9146194973.
RAJGURUNAGAR DISTT. PUNE. - 410505
PUNE- SATARA ROAD, PUNE. - 411009 MADANE LAYOUT MOUZA GUJARKHEDI NEAR SILLOD
PH :9112231553.
PH :020-67273200. INDIN PETROL PUMP NAGPUR ROAD SAONER -
RATNAGIRI 441107
1551. PAGARIYA AUTO PVT. LTD. (2103-ZG-04), PLOT
1523. EXCELL AUTOVISTA PVT LTD (1917-19-01),
NO. 19/20, SURVEY NO. 386, AURANGABAD
GATE NO.1232, 10TH MALL, PUNE SASWAD 1533. JAGRUT MOTORS PVT LTD (G301-G3-01), PH :8888859546.
NAKA, SILLOD, AURANGABAD - 431112
ROAD, VILLAGE – WADKI, TAL – HAVELI, DIST D-25,,MIDC MIRJOLE,MAHARASTRA,RATNAGIRI SAWANTWADI PH :8600037213.
PUNE. - 412308 - 415639
1543. JAGRUT MOTORS PVT LTD (BBL1-BBL-01), SINNAR
PH :9594632888/9146052651. PH :2352228380/9130013172.
SHIVSHAMBHO APARTMENT, 1190, A/P
1524. THE KOTHARI WHEELS (1906-19-06), SURVEY ROHA KOLGAON, SURVEY NO.187, HISSA NO.33B,
1552. SHAAN CARS PRIVATE LIMITED (3703-FU-03),
NO.46, HISSA 9/1 (CITY SURVEY NO.6181+6180), A-24, MIDC AREA MALEGAON,SINNAR TAL-
1534. EXCELL AUTOVISTA (COS1-COS-01), SHOP NO. TAL-SAWANTWADI, DISTT. SINDHUDURG. -
WADGAON SHERI, CHANDAN NAGAR, PUNE SINNAR,, - 422103
1 & 2, PANCHARATNA APARTMENTS, ROHA, 416510
NAGAR ROAD, TAL-HAVELI, PUNE. - 411014 PH :02551-230305.
ROHA KOLAD ROAD, RAIGAD - 402109 PH :9970654699, 9689533472.
PH :8411003631. SOLAPUR
PH :9209200073. SHAHAPUR
1525. ACE KUDALE CAR PVT. LTD. (1910-19-03),
SURVEY NO. 272, 1/4, NEAR MOSHI TOLL
SANGAMNER 1544. SHIVAM AUTO ZONE (I) PVT. LTD.
1553. CHAVAN MOTORS DIVISION INDIA PVT LTD
(B102-B1-02), 150, AKALKOT ROAD,OPP. SVCS
PLAZA, MOSHI GAON, TALUKA – HAVELI, 1535. SHAAN CARS PRIVATE LIMITED (HE03-HE-01), (BZU1-BZU-01), DR. DESHPANDE COMPOUND,
HIGH SCHOOL,SOLAPUR, - 413006
DISTRICT – PUNE. - 412105 GAT NO. 173/4/5/6, A/P VELHALE, NASHIK PUNE NEAR BHATSA COLONY, VILLAGE –
PH :0217-2606666/8805986818.
PH :7767814381. HIGHWAY, SANGAMNER , DIST AHMEDNAGAR, GOTHEGHAR, TALUKA – SHAHPUR, DISTRICT –
1554. CHAVAN MOTORS DIVISION INDIA PVT LTD
MAHARASHTRA - 422605 THANE, MAHARASHTRA - 421601
(B102-B1-01), 18,39, INDUSTRIAL
PH :02425-259197. PH :7718893483.
ESTATE,HOTAGI ROAD,SOLAPUR, - 413224
SANGLI SHAHUWADI PH :8805778881.

50
Dealer Workshop (AS ON 31.05.2023 )
1555. CHAVAN MOTORS DIVISION INDIA PVT LTD 1565. PRAKASH AUTO PVT. LTD. (3903-39-01), U VITA YEOLA
(B102-B1-06), PLOT NO.95, IND. ESTATE, NO-3,SHEET NO. 30,VITHALWADI STATION
1575. CHOWGULE INDUSTRIES PVT. LTD. 1585. SEVA AUTOMOTIVES PVT LTD (BST1-BST-01),
HOTAGI ROAD, SOLAPUR. - 413003 ROAD, ULHASNAGAR - 421003
(BSE1-BSE-01), S NO. 900, HISSA NO. 1,2,3/1/2, GAT NO. 65-A, PLOT NO. 41, AHMED
PH :8805986826. PH :9987992127/9870453155.
SANGLI VITA ROAD, VITA, TALUKA – NAGAR-MANMAD ROAD, NEAR TEHSIL OFFICE,
TALASARI URALI KANCHAN KHANAPUR, DISTRICT – SANGLI, YEOLA, TALUKA – YEOLA, DISTRICT – NASHIK,
1556. SHIVAM AUTO ZONE (I) PVT. LTD. (BIN1-BIN-01), 1566. EXCELL AUTOVISTA PVT LTD (GKI1-GKI-01), MAHARASHTRA - 415311 MAHARASHTARA. - 423401
SURVEY NO. 191/1 PLOT NO. 5, AT-POST – GAT NO-244, VILLAGE-SORTAPWADI, TALUKA PH :8888870120. PH :9130033944.
VADAVALI, NH-8, TALASARI, THANE, -HAVELI, URULI KANCHAN, DIST-PUNE, WAGHOLI YEWAT
MAHARASHTRA - 401606 PIN-412201 - 412201
1576. SAI SERVICE PRIVATE LIMITED (1901-AB-04), 1586. MAHALAXMI AUTOMOTIVES PVT. LTD.
PH :6355248143/7777002930. PH :9226089614.
GAT NO 2406/1440, VILLAGE- WAGHOLI,TAL- (AZA1-AZA-01), SOLAPUR PUNE NATIONAL
TALEGAON VADUJ HAVELI, DIST- PUNE - 412207 HIGHWAY, SAHAJAPUR, YEWAT, TALUKA:
1557. MY CAR (PUNE) PVT. LTD. (4K01-4K-01), 1567. CHOWGULE INDUSTRIES PVT. LTD. PH :9923208313/9923208221/9923208133. DAUND, DISTT: PUNE (MAHARASHTRA). -
SR.NO.113, HISSA NO.1/3/2/A, MUMBAI PUNE (F303-GQ-03), KALEVASTI, VADUJ DAHIWADI WAI 412202
OLD HIGHWAY, MAVAL, TALEGAON - 410506 ROAD , VADUJ - 415506 PH :8308818946.
1577. CHOWGULE INDUSTRIES PVT. LTD.
PH :9730855855. PH :8888866659.
(BYC1-BYC-01), GAT NO. 407, A/P MANIPUR
TALOJA VAIJAPUR SHENDURJANE, MIDC ROAD, NEAR HOTEL BISHNUPUR
1558. EXCELL AUTOVISTA PVT LTD (AAC1-9K-02), 1568. PAGARIYA AUTO PVT. LTD. (BNR1-BNR-01), GANDHARVA, OPP. DHOM LEFT CANAL, TAL –
1587. EASTERN MOTORS (CSA1-CSA-01),
PLOT NO-9,MIDC,NAVADE,TALOJA, NEAR SUBHASH BUNGLOW, STATION ROAD, WAI, DISTT. SATARA - 412803
BISHNUPUR BAZAR, TIDIM ROAD, BISHNUPUR
TAL-PANVEL ,DIST-RAIGAD - 410208 VAIJAPUR, AURANGABAD. - 423701 PH :8380080501.
DISTT. MANIPUR. - 795126
PH :9136948195/9320357300. PH :9922994237. WALUJ PH :8415945626.
TASGAON VASAI 1578. PAGARIYA AUTO PVT. LTD. (2103-MC-03), CHANDEL
1559. SIDDHI WHEELS (A UNIT OF TARALEKAR 1569. SAI SERVICE PRIVATE LIMITED (V901-V9-01), E-16,WALUJ,AURANGABAD - 431001
1588. EASTERN MOTORS (CSB1-CSB-01), KAKCHING
MOTORS PVT. LTD.) (GKB1-GKB-01), SHETKARI ANDRADESH BHAVAN, SURVEY #27 A,NEAR PH :9860999466.
LAMKHAI, AH1 (INDO BURMA ROAD), CHANDEL
MARKET, NEAR ISHA HOTEL, UMELA PHATAK, VASAI (WEST), DIST. THANE, WARANANAGAR (MANIPUR) - 795103
TASGAON-SANGLI ROAD, TALUKA - TASGAON, MAHARASTRA - 401202
1579. SAI SERVICE PRIVATE LIMITED (CRB1-CRB-01), PH :8415945626.
DIST.-SANGLI. - 416312 PH :9167980080/9167980036/9594952211.
GAT NO.:1122/A, KODOLI, TALUKA: PANHALA, CHURACHANDPUR
PH :8275030748. 1570. SAI SERVICE PRIVATE LIMITED (0504-V9-03),
DIST. KOLHAPUR - 416114
THANE C/O MR. KENNETH NICHOLAS D’SOUZA, 1589. EASTERN MOTORS (BBE1-BBE-01), HMUIA
PH :9923204173.
SURVEY NO-89, SATIVALI ROAD, VENG,TEDDIM ROAD, CHURACHANDPUR,
1560. FORT POINT AUTOMOTIVE (CARS) PVT. LTD. WARDHA
VILLAGE-WALIV, VASAI (EAST), DIST-PALGHAR, MANIPUR - 795128
(3906-39-01), KOTHARI WAREHOUSE NO.
MAHARASHTRA, PIN-410208 - 401208 1580. SEVA AUTOMOTIVE LTD. (2002-AC-02), GOPURI PH :03874235969, 9862555472.
111,POKHRAN ROAD NO. 11,MANPADA,
PH :9167980004/9167980084/9594950000. CHOWK, ,OPP. BANK OF INDIA COLONY, IMPHAL
CHATALSAR,THANE - 400607
PH :9594974656, 8691039873,. VASHI NAGPUR ROAD, WARDHA - 442001
1590. EASTERN MOTORS (7401-74-01),
PH :07152-253545/253525.
1561. NAVNEET MOTORS (3908-39-02), B R T PLOT 1571. MY CAR (PUNE) PVT. LTD. (05A4-05-01), A-751/2, CHINGMEIRONG EAST, IMPHAL, MANIPUR - 795
1581. SEVA AUTOMOTIVE PVT. LTD. (2002-AC-05),
,THANE (W) ,MAHARASHTRA - 400607 MIDC TTC, TURBHE MAHAPE ROAD, PAWANE, 001
PLOT NO. 177, WARDHA-NAGPUR HIGHWAY,
PH :9664496732, 9167215178. NAVI MUMBAI - - 400 071 PH :8415945626.
AT. PAVNAR, TEHSIL – WARDHA, DIST.
1562. VELOX MOTORS (A UNIT OF CARCRAFT PH :8104906953, 9372802861, 9326713481. 1591. EASTERN MOTORS (7401-74-02), NH,39,
-WARDH, PIN-442111, MAHARASHTRA - 442111
AUTOMOBILES PVT LTD) (05A3-39-02), NEW VELHE CHINGMEIRONG, WEST, IMPHAL. - 795010
PH :7720009444.
SURVEY NO. 17/1/B, NEAR BLUE ROOF CLUB, PH :8415945626.
1572. SUMANKIRTI CARS (SLO1-SLO-01), MAUZA WARUD
VILLAGE - OWALE, GHODBUNDER ROAD, 1592. SAMADON ENTERPRISE (7402-74-01), 82 GHARI
NO-492/2, A/P-VELHA, TAL- VELHA,
THANE (W). - 400615 1582. ASPA BANDSONS AUTO PVT. LTD. MAKHA LEIKAI, IMPHAL WEST, MANIPUR. - 795
DIST-PUNE-412212 - 412212
PH :8104989847,96536 88455. (F201-UG-04), SURVEY NO. 50/3, 140
PH :8554981603/8550995444.
TITWALA SETURJANAGHAT ROAD, TALUKA: WARUD, PH :7005987123.
VIKRAMGADH DIST. AMRAWATI - 444906
1563. AHER AUTOPRIME (BYP2-BYP-01), SURVEY NO. JIRIBAM
1573. SHIVAM AUTOZONE (SKV1-SKV-01), NEAR PH :7248925687.
23/2, SHOP NO. 3, NEAR GOVELI, TITWALA 1593. EASTERN MOTORS (SMG1-SMG-01), AT
GOVERNMNET DISPENSARY HOSPITAL, WASHIM
ROAD, GHOTSAI, TITWALA, PIN-421301, HILGHAT, IMPHAL SILCHAR ROAD, JIRIBAM -
DAHANU ROAD, TEHSIL-VIKRAMGADH,
MAHARASHTRA - 421301 1583. ASPA BANDSONS AUTO PVT. LTD. (F201-9D-02), 788104
DIST-PALGHAR-401605 - 401605
PH :18008334369. NEAR RAILWAY CROSSING,HIGOLI PH :8415945626.
PH :#REF!.
TURBHE ROAD,WASHIM, - 444505 SENAPATI
VIRAR PH :9922500981/ 9146191534.
1564. SAI SERVICE (0504-9K-06), D 42, TTC 1594. EASTERN MOTORS (CNN1-CNN-01), DIST.
1574. SAI SERVICE PRIVATE LIMITED (V901-PG-02), YAVATMAL
INDUSTRIAL AREA, NAVI MUMBAI, PIN-400705 - -COUNCIL (POULEA) VILLAGE, P.O. - SENAPATI,
SURVEY NO.16, AGASHI ROAD, PADMAN
400705 1584. HIMALAYA CARS (4M01-4M-01), OPPOSITE SENAPATI, MANIPUR. - 795 106
NAGAR, VIRAR-WEST, DISTT. PALGHAR. -
PH :022-268611111/ 8976999060. RAUT PETROL PUMP, DARWHA ROAD, PH :8415945626.
401301
ULHASNAGAR PH :9594952343/9167980036/9594952211.
YAVATMAL, MAHARASHTRA - 445001 THOUBAL
PH :9011014729.

51
Dealer Workshop (AS ON 31.05.2023 )
1595. EASTERN MOTORS (BJL1-BJL-01), THOUBAL 1605. BANALARI CAR WORLD (CBJ1-CBJ-01), WOKHA 1625. SKY AUTOMOBILES (E203-E2-02), PLOT NO.
ATHOKPAM KHUNOU, NEAR D.C. OFFICE PHLANGSHLAIN MAIN ROAD, SHILONG DAWKI, 876, WESTERN ROW NH-5, KONISI HATO,
1616. PROGRESSIVE MOTORS (SFH1-SFH-01),
COMPLEX, THOUBAL, MANIPUR - 795138 PYNURSLA, DISTRICT - EAST KHASI HILLS, VILLAGE – KONISI, BERHAMPORE, GANJAM,
NIROPEN COLONY, WOKHA-797111, NAGALAND
PH :9862662225. MEGHALAYA - 793110 - 793110 ODISHA. - 761008
- 797111
UKHRUL PH :8415942700. PH :7381266000.
PH :9774070707.
1596. SAMADON ENTERPRISE (SCK1-SCK-01), SHILLONG BHADRAK
KAMPHASOM, UKHRUL, MANIPUR - 795142 1606. RANI MOTORS (8501-85-01), SUNNY HILLS,
ODISHA 1626. JYOTE MOTORS (BALASORE) PVT. LTD
PH :9774216305. GARIKHANA, G.S.ROAD, SHILLONG - 793014 ANANDAPUR (IZ01-IZ-01), PLOT NO. 14/4837, KHATA NO.
PH :9862099400. 1345/1087, TRISHALPUR, CHARMPA, BHADRAK ,
MEGHALAYA 1607. RANI MOTORS (8501-85-02), MAWBLEI, NH-44,
1617. JYOTE MOTORS PVT LTD (CIU2-CIU-01), KHATA
ODISHA - 756101
NO. 246/407, PLOT NO. 76, P.S. – GHASIPURA,
BHOIRYMBONG SHILLONG JOWAI ROAD, MEGHALAYA. - 793021 MOUZA – SUDUSUDIA, DISTRICT – KEONJHAR, PH :9776345311.
1597. RANI MOTORS (CHP1-CHP-01), VILLAGE – PH :8014734780. ANANDPUR, ODISHA . - 758021 BHAWANIPATNA
UMROI MADAN, DISTRICT – RI BHOI, 1608. BANALARI WORLD CARS (8502-85-01), MAWLAI PH :7381028525.
1627. LEGEND CARS PVT. LTD. (SW01-TB-02), NH-201,
MEGHALAYA. - 793103 NONGKWAR, G.S. ROAD, SHILLONG - 793017 ANGUL KESINGA ROAD, BHAWANIPATNA - 766001
PH :9774478281. PH :7005757760/7005569550.
1618. ODYSSEY MOTORS PVT LTD (W101-W1-01), PH :9937198684.
JOWAI TURA
AT/PO KULAD (NEAR NALCO CPP PLANT), BHUBANESHWAR (NAYAPALLI)
1598. RANI MOTORS (3I01-3I-01), LADTHADLABHO, 1609. RANI MOTORS (CLF1-CLF-01), AGILLANGRE, KANDASAR, NALCO NAGAR, ANGUL (DISTT:
1628. JYOTE MOTORS PVT LTD (0405-04-01), A/62,
OPP. PWD OFFICE, JOWAI, DIST - JAINTIA ARAIMILE, PO NEW TURA, TURA - 794101 ANGUL). - 759145
NAYAPALLI,NH-5,BHUBANESHWAR,ORISSA-751
HILLS, MEGHALAYA - 793150 PH :7005563791. PH :9439817308.
003 - 751003
PH :7085849525. UMSAW BALASORE PH :7381028525.
KHLIEHRIAT 1610. BANALARI WORLD CARS (CHZ1-CHZ-01), 1619. JYOTE MOTORS (BALASORE) PVT. LTD BHUBANESWAR
1599. BANALARI WORLD CARS (8502-PZ-03), UMSAWKHWAN RAID MAWBUH, MYLLIEM (L501-L5-01), PLOT NO. 276,
1629. NARAYANI MOTORS PVT. LTD. (0403-04-01),
JOWAI-SICHAR ROAD, MEGHALAYA, SYIEMSHIP, RI BHOI DISTRICT, MEGHALAYA. - GANESHWARPUR-NH-5, POST-JANUGANJ VIA
217, CUTTACK ROAD, JHARPARA,
KHLIEHRIAT - 793150 793123 REMUNA, DIST.-BALASORE - 756019
BHUBANESWAR - 751006
PH :7005757760/7005569550. PH :7005757760/7005569550. PH :7381072600.
PH :9583022031.
MAWKYRWAT MIZORAM BALUGOAN 1630. JYOTE MOTORS PVT LTD (0402-04-01), A-62,
1600. RANI MOTORS (CGR1-CGR-01), DAK BANGLA, AIZAWL 1620. JYOTE MOTORS (CWG1-1-CWG-01), .M/S PLOT NAYAPALLI,NEAR CRPF SQUARE,
MAWKYRWAT, WEST KHASI HILLS, MEGALAYA NO 758/31,KHATA NO BHUBANESWAR - 751003
1611. G.I.G. MOTORS (9103-91-01), EDENTHAR,
- 793114 350/30,MOUZA-GOBARDHANPUR,BALUGAON, PH :7064493302.
AIZAWL, MIZORAM. - 796001
PH :9856005544. DISTRICT-KHORDA,ODISHA-752030 - 752030 1631. SKY AUTOMOBILES (0404-04-01), PLOT NO.
PH :8974559065.
MAWNGAP PH :9776615001. -435/1866, NEAR KIIT SQUARE PATIA,
MP BAMRA BHUBNESHWAR, - 751022
1601. BANALARI WORLD CARS (CBK1-CBK-01), PH :8117829611.
LAITPYNTER, SHILLONG NONGTION ROAD, NAINPUR 1621. ODYSSEY MOTORS (SIA1-SIA-01), M/S 1632. NARAYANI MOTORS PVT. LTD. (0403-04-02),
MAWNGAP, DIST.-EAST KHASI HILLS, 1612. STANDARD AUTO (SEZ1-SEZ-01), MANJU SAHU, ODYSSEY MOTORS,NEAR SATSANG KENDRA, PLOT NO 56 AND 57,RASULGARH,
MEGHALAYA. - 793121 MANDLA ROAD, NEAR MPEB OFFICE, DUMERMUNDA COLLEGE ROAD, BHUBANESHWAR, ODISHA - 751010
PH :7005757760/7005569550. ADJOINING TO BAJAJ SHOW ROOM, NAINPUR, BAMRA,GOVINDPUR-768221. - 768221 PH :9583022046.
MYLLIEM DISST MANDLA, MADHYA PRADESH -481776. - PH :9439314464. 1633. JYOTE MOTORS PVT LTD (0402-04-04), PLOT
481776 BARGARH NO. 22 & 23, SECTOR-A, ZONE-D,
1602. BANALARI WORLD CARS (CSK1-CSK-01),
PH :7771003374. MANCHESWAR INDUSTRIAL ESTATE AREA,
MADANIING SYIEM, MYLLIEM, SHILLONG 1622. ODYSSEY MOTORS PVT LTD (D401-SJ-04),
CHERRAPUNJI ROAD, DISTT: EAST KHASI NAGALAND AT/PO -BARGARH, NH-6, DISTT.-BARGARH, BHUBANESHWAR. - 751010
HILLS, MEGHALAYA. - 793009 ORISSA - 768028 PH :7978910223.
DIMAPUR
PH :7005757760/7005569550. PH :8908944206. 1634. SKY AUTOMOBILES (0404-04-02), KHATA NO.
1613. PROGRESSIVE MOTORS (3201-32-01), 457/675, PLOT NO. 543, 756, 789 AND 546,
NONGPOH OPPOSITE AIRPORT, N.H.39, DIMAPUR KOHIMA BARIPADA
SRIVIHAR, INFRONT OF IOCL OFFICE, P.S.
1603. RANI MOTORS (8501-TN-05), NEAR D.T.O. ROAD, DIMAPUR - 797112 1623. JYOTE MOTORS (BALASORE) PVT. LTD -CHADRASHEKARPUR, BHUBANESHWAR,
OFFICE, G.S. ROAD, NONGHPOH, RIBHOI PH :7005254089. (L501-RQ-02), PLOT NO. 90/523/904, SWARUP ODISHA. - 751 024
DISTT. - 793102 KOHIMA VILLA, NH-5, BARIPADA - 757001 PH :7440011604.
PH :9774478281. PH :7381072624. BOLANGIR
1614. SEYIE AUTO (4N02-4N-01), TSIECIE, NH-29,
NONGSTOIN PHEK ROAD, KOHIMA, NAGALAND - 797001 BERHAMPUR
1635. ODYSSEY MOTORS PVT LTD (D401-MW-03),
1604. RANI MOTORS (8501-0P-04), OPP.IRANI PETROL PH :7005867051. 1624. SKY AUTOMOBILES (E203-E2-01), PLOT NH-201, MADHIAPALI, SAMBHALPUR ROAD,
PUMP, NEW NONGSTEIN, DISTRICT-WEST MOKOKCHUNG NO.80/1191 DHARMA NAGAR, MAIN ROAD, BOLANGIR, ORISSA - 767001
KHASI HILLS ,MEGHALAYA - 793119 BERHAMPUR - 760002 PH :8895418122.
1615. PROGRESSIVE MOTORS (CGL1-CGL-01),
PH :9856005544. PH :7381266000. CHANDIKHOLE
SUNGKONMEN ROAD, MOKOKCHUNG,
PYNURSULA NAGALAND. - 798601
PH :87877325534.

52
Dealer Workshop (AS ON 31.05.2023 )
1636. SKY AUTOMOBILES (BXL1-BXL-01), PLOT JHARSUGUDA 1655. LEGEND CARS (YB01-YB-01), M/S LEGEND 1664. JYOTE MOTORS (SFI1-SFI-01), M/S JYOTE
NO.285/3, SHANTI MANDAP MOUZA -SUNGUDA, CARS, JK PUR ROAD, KOMTALPETA, NEAR MOTORS, KHATA NO: 351/85, PLOT NUMBER
1646. ODYSSEY MOTORS PVT LTD (BJU1-BJU-01),
TEHSIL-DARPANI, PO CHANDIKHOL, DIST. ENFIELD 633, MOUZA-ALBANKA, KENDRAPARA, ODISHA.
KHATA NO. 466/502, PLOT NO. 966,
-JAJPUR, ODISHA, - 755044 SHOWROOM, RAYAGADDA, ODISHA - 765001 - 754208
JHARSUGUDA TOWN, UNIT NO. 7, SARBAHAL
PH :9776645798. PH :7008771180. PH :9776615001.
P.S. JHARSUGUDA, ORISSA - 768201
CUTTACK PH :9439548823. ROURKELA KUCHINDA
1637. SKY AUTOMOBILES (6701-67-02), BHANPUR, KEONJHAR 1656. ORBIT MOTORS PVT. LTD. (8701-87-01), 1665. ODYSSEY MOTORS (SLN1-SLN-01), /S
NH-5, CUTTACK - 753011 VEDVYAS, NEAR PAAHADI BAR, ODYSSEY MOTORS ,PLOT NO 146,KHATA NO
1647. JYOTE MOTORS PVT LTD (7U01-7U-01), NH 215,
PH :9776645798. ROURKELA,ORRISA - 769041 76/9,MOUZA-KUNDAPOSHI,NEAR
DHRUPADA, BARBIL ROAD, KEONJHAR. -
1638. TUSHI MOTORS PVT. LTD. (6702-67-01), PLOT PH :9437061040. KUNDESHWAR
758001
NO. C-14, PLOT NO.C-13 ,INDUSTRIAL ESTATE SAMBALPUR MANDIR,KUCHINDA,SAMBULPUR. - 768222
PH :7064499047.
,KHAPURIA,TAHASIL - CUTTACK SADAR PH :9439314464.
NAYAGARH 1657. ODYSSEY MOTORS PVT LTD (D401-D4-01),
,CUTTACK DISTRICT,BHUBANESWAR - 753001 PADAMPUR
AINTHAPALI, SAMBALPUR, ORISSA - 768004
PH :9692912345. 1648. JYOTE MOTORS PVT LTD (0402-DC-02), PLOT
PH :7381083571. 1666. ODYSSEY MOTORS (SFB1-SFB-01), M/S
DEOGARH NO. 1319/3750, KHANDAPADA, NAYAGARH -
ODYSSEY MOTORS, CHARPALLI,PADAMPUR,
752069 SORO
1639. ORBIT MOTORS PVT. LTD. (CBB1-CBB-01), NEAR REGENCY HOTEL,DISTRICT:BARGARH,
PH :7064499048. 1658. JYOTE MOTORS (SQF1-SQF-01), PLOT NO
KHATA NO. 270, OI MOUZA, DEOGARH, ODISHA ORISSA - 770039
NIMPARA 15/1269,KHATA NO 442, SORO, BALASORE,
- 768108 PH :9439314464.
ODISHA STATE. - 756045
PH :9437607865. 1649. NARAYANI MOTORS PVT. LTD. (CFL1-CFL-01),
PH :9776615001. PUDUCHERRY
DHENKENAL PLOT NO. 345/1344, GANESH BAZAR,
NIMAPARA, DISTRICT – PURI, ODISHA. - 752106 SUBARNAPUR KARAIKAL
1640. SKY AUTOMOBILES (6701-4P-04), PLOT
PH :7381093622. 1659. ODYSSEY MOTORS PVT LTD (BUK1-BUK-01), 1667. SHENBAKA CARS PVT. LTD. (CCF1-CCF-01), R.
NO-136/1103, KATHAGARA , NEARASSAM OIL,
PALLAHARA KHATA NO. 32, MOUZA – SANJHINIK, SONEPUR S. NO. 173/3PT, T. S. NO. 9/5, WARD, L-BLOCK,
NH-42, DHENKANAL. - 759001
(ALSO KNOWN AS SUBARNAPUR), DISTRICT – NO. 3, KARAIKAL NAGORE MAIN ROAD,
PH :7440025919. 1650. ODYSSEY MOTORS PVT LTD (CHV1-CHV-01),
SUBARNPUR, ODISHA - 767017 VILLAGE - ODUTHURAI REVENUE, NERAVY
GANDAI KHATA NO. 260, PLOT NO. 998/3720,
PH :8895418122. COMMUNE, KARAIKAL MUNICIPALITY,
PAHALLARA, ODISHA. - 759119
1641. SPARSH AUTOMOBILES (SHU1-SHU-01), M/S SUNDERGARH KARAIKAL. - 609602
PH :9439817308.
SPARSH AUTOMOBILES ,WARD NO – 7, NEAR PH :04368-227800/1/2.
PARADEEP 1660. ORBIT MOTORS PVT. LTD. (BWJ1-BWJ-01), M/S
KRISHI UPAJ MANDI, MADAGADIPET
ORBIT MOTORS, AT - PATRAPALI, PO
GANDAI RAJNANDGAON ROAD,GANDAI – 1651. NARAYANI MOTORS PVT. LTD. (OE01-OE-01),
SUNDERGARH, BY PASS ROAD, NEAR BJP 1668. SHENBAKA CARS PVT. LTD (CUD1-CUD-01),
491888 - 491888 PLOT NO. 1438, UDAYA VIHAR, NEAR DO
OFFICE, SUNDERGARH - 770001 SURVEY NO. 129/4/A/2, MADAGADIPET
PH :9926626662. CHOWKI SQUARE, PARADEEP, ODISHA. -
PH :8249354447. REVENUE VILLAGE, MADAGADIPET,
JAGATSINGHPUR 754141
PONDICHERRY - 605 107
PH :9583022020. UDALA
1642. NARAYANI MOTORS PVT. LTD. (CFM1-CFM-01), PH :8220046178.
PARLAKHEMUNDI 1661. JYOTE MOTORS (BALASORE) PVT. LTD
KHATTA NO. 827/221 & 827/222, PLOT NO. 1197 PONDICHERRY
(CHW1-CHW-01), MOUZA - UDALA, TOWN UNIT
& 1199/3065, MOUZA-MARKHANDPUR, PO 1652. SKY AUTOMOBILES (CLG1-CLG-01), PLOT NO.
NO. 7, NAGBANI, TEHSIL NO. 325, THANA NO. 1669. SHENBAKA CARS PRIVATE LIMITED
PUNABGA, DISTT. JAGATSINGHPUR, ODISHA - 273, KHATA NO. 78, WARD NO. 1,
110, DIST.-MAYURBHANJ, ODISHA. - 757041 (9601-96-01), 133/1A, MOOLAKULAM,
754103 PARLAKHEMUNDI, GAJAPATI, ORISSA. - 761211
PH :8249877935. VILLUPURAM MAIN ROAD, PONDICHERRY -
PH :9556511213. PH :9776999977.
605010
JAJPUR PURI ODISHAN PH :0413-2293391/92/93.
1643. SKY AUTOMOBILES (6701-RZ-05), P.O JAHNA, NIRGUNDI
P.S KORAI, KEONJHAR ROAD, JAJPUR,
1653. NARAYANI MOTORS PVT. LTD. (4Q01-4Q-01), PUNJAB
PLOT NO.1797/2449, KHATA NO.187A/32, AT. 1662. NARAYANI (0403-SIP-4), KHATA NO 251/255,
ORRISSA - 7553019 BATAMANGLA,PO HAREKRISHNAPUR, PLOT NO 233,MALGOWDINI-MOUZA BLITERUA, ABOHAR
PH :9583011010. BATAGAON, PURI, ODHISA - 752002 NIRGUNDI,DISTRICT-CUTTACK, ORISSA. - 1670. TARA AUTOMOBILES (ABOHAR) (H501-H5-01),
JALESWAR PH :9583022220. 754025 SHREE GURU JAMBHESHWAR CHOWK,
RAIRANGPUR PH :9583001877. MALOUT SHREE GANGA NAGAR BYPASS,
1644. JYOTE MOTORS (BALASORE) PVT. LTD
ABOHAR, PUNJAB - 152116
(BXP1-BXP-01), KHATA NO. 422/744, PLOT NO. 1654. JYOTE MOTORS (BALASORE) PVT. LTD ORISSA PH :9876047847.
2304 AT P.O. - NAYABAZAR, JALESWAR, DIST.- (CES1-CES-01), PLOT NO.1077/2466, BHUBANESWAR
BALASORE, ODISHA. - 756032 PURNAGHATI, RAIRANGPUR, DISTT: ADAMPUR
PH :7381072600. 1663. NARAYANI (0403-04-03), KHATA NO-652,PLOT
MAYURBHANJ, ODISHA - 757046 1671. LOVELY AUTOS (CHA1-CHA-01), KHASRA
NO 4493, MAUZA PANDRA
JEYPORE PH :7064499936. NO.10/7/1, JALANDHAR-HOSHIARPUR
THANA-RASULGARH,BHUABNESHWAR - 751025
RAYAGADA HIGHWAY, ADAMPUR DISTT. JALANDHAR -
1645. LEGEND CARS PVT. LTD. (SW01-SW-03), PH :9583001877.
144102
SOURAGUDA,JEYPORE,DISTT-KORAPUT,ORISS KENDRAPARA PH :8288050777.
A,INDIA - 764001
PH :9437575188. AJNALA

53
Dealer Workshop (AS ON 31.05.2023 )
1672. SWANI MOTORS PVT. LTD. (CBP1-CBP-01), 1682. LOVELY AUTOS (3503-MS-03), 1692. LOVELY AUTOS (CHB1-CHB-01), WARD NO. 1, 1702. TARA AUTOMOBILES (H501-4V-03), NH-10,
KHASRA NO. 71, AJNALA-AMRITSAR ROAD, NAWASEHAR-JALANDHAR ROAD, BANGA - NADALA-BEGOWAL ROAD, VPO BHULATH, NEAR SARVHITKARI BAL VIDYA MANDIR,
VILLAGE - BHARKA TARA SINGH, TEHSIL - 144505 DISTRICT – KAPURTHALA, PUNJAB. - 144622 FAZILKA - 152116
AJNALA, DISTRICT - AMRITSAR, PUNJAB. - PH :9915028625. PH :9876541065, 8288050777. PH :9876047847.
143102 BANUR BILGA FEROZEPUR
PH :8872001731.
1683. TRICITY AUTOS PVT. LTD. (BRT1-BRT-01), 1693. LOVELY AUTOMOBILES (SPM1-SPM-01), VPO 1703. BABA AUTOS (7C01-7C-01), MOGA ROAD,
AMRITSAR SANDHU MARKET NEAR SALES TAX BARRIER, BILGA, NEAR GOVT. PRIMARY SCHOOL, TEHSIL FEROZEPUR CANTT - 152002
1673. SWANI MOTORS LTD. (1701-17-01), 81,COURT BANUR RAJPURA HIGHWAY, BANUR, PUNJAB - PHILLAUR, JALANDHAR. - 144036 PH :8872013211.
ROAD, AMRITSAR - 143001 140601 PH :9815069814. GARHSHANKAR
PH :9877482175, 8872000000. PH :9988882330. CHUNNI KALAN 1704. HOSHIARPUR AUTOMOBILES (H402-V4-02),
1674. JAYCEE MOTORS (1704-17-01), 274 EAST BARNALA 1694. HOSHIARPUR AUTOMOBILES (CFG1-CFG-01), OPP. COURT, CHANDIGARH ROAD,
MOHAN NAGAR, G.T.ROAD, AMRITSAR - 143006
1684. MAX AUTOMOBILES (4S02-4S-01), NR. NEAR RAJINDER MOTORS, GARHSHANKAR, DIST. HOSHIARPUR - 144527
PH :9780038335.
HANDIYAN CHOWK,MANSA BYE SIRHIND-CHANDIGARH ROAD, VILLAGE PH :9815131766, 9781543131.
1675. RISHABH FOURWHEELS PVT. LTD.
PASS,BARNALA,PUNJAB - 151001 CHUNNI, DIST. FATEHGARH SAHIB. - 140307 GHANAUR
(1703-17-01), ADARSH SOAP COMPLEX, BATALA
PH :285022, 9216529220. PH :248005, 9815131766.
ROAD, AMRITSAR - 143004 1705. HIRA AUTOWORLD LLP (CVX2-CVX-01), WARD
PH :9914841577. BATALA DASUYA NO. 1, OPPOSITE OLD PETROL PUMP
ANANADPUR SAHIB 1685. PATHANKOT VEHICLEADES PVT. LTD. 1695. HOSHIARPUR AUTOMOBILES (H402-8D-04), GHANAUR PATIALA ROAD, SUB TEHSIL -
(A701-V5-05), NEAR VMS INSTITUTE, SAID OPP CHEEMA PETROL PUMP, G.T. ROAD, GHANAUR, TEHSIL - RAJPURA, DIST.-PATIALA,
1676. CM AUTOSALES PVT. LTD. (OF01-OF-01),
MUBARAK, GT ROAD, BATALA - 143505 DASUYA - 144205 STATE - PUNJAB. - 140401
VILLAGE MIYANPUR, NAINA DEVI ROAD,
PH :9417900850 , 9417900918. PH :9815131766, 9872312371. PH :9217048437.
ANANDPUR SAHIB,TEHSIL ANANDPUR SAHIB,
DISTT. ROPAR,PUNJAB - 140123 BEGOWAL DERABASSI GHAROTA
PH :9915022897. 1686. MARWAHA AUTOS (BHF2-BHF-01), PELIA 1696. AUTOPACE NETWORK PVT LTD (0705-AW-02), 1706. PATHANKOT VEHICLEADES (SFF1-SFF-01),
APRA TOWN, BHADAS ROAD, WARD NO. 11, AT NH-2, NEAR DERABASSI, TOLL VILLAGE AND PO GHAROTA, OPPOSITE
JALANDHAR ROAD, VPO. BEGOWAL, BARRIER-DERABASSI - 140507 PUNJAB GRAMIN BANK, TEHSIL & DISTT.
1677. LOVELY AUTOS (CVW1-CVW-01), SAMRAI
KAPURTHALA, PIN-144621, PUNJAB - 144621 PH :9815011669. PATHANKOT – 143533. - 143533
CHOWK PHILLAUR ROAD, VILLAGE - APRA,
PH :9779166004. DEVIGARH PH :8264105000.
TEHSIL - PHILLAUR, DIST.-JALANDHAR, STATE -
PUNJAB. - 144416 BHADSON 1697. HIRA AUTOMOBILES LTD (OG01-OG-01), GHOMAN
PH :9915020515. 1687. HIRA AUTOMOBILES LTD (BAG1-BAG-01), CHANNA MOUR, PEHOWA PATIALA ROAD, 1707. PATHANKOT VEHICLEADES PVT. LTD.
AUR VILLAGE CHASWAL, NABHA ROAD, BHADSON - DEVIGARH, DISTT. PATIALA (PUNJAB). - 147111 (CUL1-CUL-01), KHEWAT NO. 36, KHATAUNI NO.
147202 PH :8872034118, 9217048250. 122, KHASRA NO. 11//25 (7-18), VILLAGE -
1678. LOVELY AUTOS (CVY1-CVY-01), KHATUNI NO.
PH :9217048236, 9217048250. DHILWAN BALRAMPUR ADDA, KHASBA - GHOMAN. -
479/588, KHASRA NO. 27/20/04(2-18), 21/2(2-10),
BHAGTA BHAI KA 143514
VILLAGE - AUR, TEHSIL - NAWASHAR, DIST. 1698. MARWAHA AUTOS (SGU1-SGU-01), MIANI
PH :8054500130.
-SBS NAGAR, STATE - PUNJAB. - 144417 1688. TARA AUTOMOBILES (BHG1-BHG-01), NEAR BAKARPUR,AMRITSAR ROAD, OPP-INDIAN OIL
PH :9915020510. SARPANCH HOUSE, BHAGTA BHAI KA, PETROL PUMP, DHILWAN DISTT KAPURTHALA - GIDDARBAHA
BAGHA PURANA DISTRICT – BHATINDA. - 151206 144804 1708. HIRA AUTOMOBILES LTD (AUA1-AUA-01), NEAR
PH :8437030666. PH :9779166004. BHARU CHOWK, BATHINDA-MALOUT ROAD,
1679. REMIRA MOTORS PVT. LTD. (BAH2-BAH-01),
BHATINDA DORAHA GIDDERBAHA, DISTT. SRI MUKTSAR SAHIB
BUILDING NO.68, OPP. SHINA ENCLAVE, MOGA
(PUNJAB) - 152101
ROAD, BAGHA PURANA, DISTT. MOGA, 1689. TARA AUTOMOBILES (BHATINDA) (7002-70-01), 1699. GULZAR MOTORS (QC02-QC-01), G.T. ROAD,
PH :231510, 9217048250.
PIN-142038 - 142038 MANSA ROAD, OPP. I.T.I, BATHINDA - 151001 NEAR ARRICHAN CHOWK, DORAHA, DISTT.
PH :7087025009. PH :0164-2235349, 50. LUDHIANA, PUNJAB. - 141421 GORAYA
BALACHAUR BHIKHIWIND PH :9814191122. 1709. LOVELY AUTOS (BJR1-BJR-01), NEAR MILAN
FARIDKOT PALACE, G.T. ROAD, GORAYA. - 144409
1680. LOVELY AUTOS (XV01-XV-01), NEAR 1690. RISHABH FOURWHEELS PVT. LTD.
PH :9417804049.
MCDONALD – GHUGGI JUNCTION), VPO-GARHI (BPK1-BPK-01), KHASRA NO. 67/3/2, 4/1, 7/2, 8/1, 1700. MAPSKO AUTO INDIA PVT. LTD. (4U02-4U-01),
KANUGO, NAWANSHAHR CHANDIGARH 8/2, PIND BHIKHIWIND, TEHSIL – PATTI, FARIDKOT- KOTKAPURA ROAD, FARIDKOT, GURDASPUR
HIGHWAY, CHANDIGARH ROAD, BALACHAUR, DISTRICT – TARN TARAN, PUNJAB. - 143303 PUNJAB - 151204 1710. PATHANKOT VEHICLEADES PVT. LTD.
DISTRICT-S.B.S NAGAR, PUNJAB PH :9914708577. PH :01639- 264001,7347000520. (A701-4X-03), V.P.O. BABRI NH-15, DIST.
(NAWANSHAHR) - 144521 BHOGPUR FATEHGARH CHURIAN GURDASPUR - 143521
PH :9878427910. PH :9417900870 , 9878050710.
1691. LOVELY AUTOS (BRU2-BRU-01), KHASRA NO. 1701. PATHANKOT VEHICLEADES PVT. LTD.
BALBEHRA 1711. PATHANKOT VEHICLEADES PVT. LTD.
31/114, 17/2 18/2 23, MAIN (BAO1-BAO-01), KHASRA NO. 17 R, DERABABA
(A701-4X-06), VPO - JEEWANWAL BABRI, NH-15,
1681. HIRA AUTOWORLD (SOG1-SOG-01), NEAR JALANDHAR-PATHANKOT HIGHWAY,OPP- AJIT NANAK ROAD, FATEHGARH CHURIAN, TEHSIL -
GURDASPUR (PUNJAB) - 143521
HDFC BANK LTD., SAMANA ROAD, BALBEHRA - PALACE, BHOGPUR - 144201 BATALA, DIST.-GURDASPUR, STATE - PUNJAB.
PH :9417900870.
147101 PH :9872030006. - 143 602
PH :9888341118. PH :9417900850 , 9875930180. HOSHIARPUR
BHULATH
BANGA FAZILKA

54
Dealer Workshop (AS ON 31.05.2023 )
1712. HOSHIARPUR AUTOMOBILES (H402-H4-01), 1723. MARWAHA AUTOS (A UNIT OF INDERJIT 1734. LOVELY AUTO (6209-62-01), BABA NAND SINGH 1745. RISHAB (CDS1-CDS-01), KHASRA NO. 343, BABA
SINGRIWALA, JALLANDHAR ROAD, MARWAHA AUTOS PVT. LTD.) (4Z02-4Z-01), NAGAR, NEAR AYALLI CHOWK, FEROZEPUR BAKALA ROAD, VILLAGE MEHTA CHOW,
HOSHIARPUR, - 146001 SIDHU COMPLEX, CIRCLE ROAD - ROAD, LUDHIANA – 141001 - 141001 TEHSIL: BABA BAKALA, DIST AMRITSAR,
PH :9815131766, 9878632537. KAPURTHALA, PUNJAB - 144602 PH :9875928451, 9875928450. PUNJAB - 143114
JAGRAON PH :9779166004. 1735. LOVELY AUTOS (6209-62-02), GILL ROAD, NEAR PH :7760315710.
KATHU NANGAL CANAL BRIDGE, LUDHIANA, PUNJAB - 141003 MOGA
1713. SANDHU AUTOMOBILES (6206-LT-05),
PH :9815069814.
NATIONAL HIGHWAY-64, JAGRAON - 142026 1724. JAYCEE MOTORS (CSP2-CSP-01), KHASRA 1746. REMIRA MOTORS PVT. LTD. (H602-H6-01),
1736. LOVELY AUTOS (6209-62-03), OPPOSITE BHAI
PH :8437025969. NO.12/20/2, 21/1 KHATA NO.212/186/229 GILL INDUSTRIAL AREA, OPPOSITE ITI, GT ROAD,
BALA SAHIB GURUDWARA, VILLAGE DAD,
JAITU KHETI STORE, GT ROAD, MOGA. - 142001
PAKHOWAL ROAD, LUDHIANA, PIN-141001,
VILLAGE-KATHUNANGAL, DISTT. AMRITSAR, PH :7087025402.
1714. MAPSKO AUTO INDIA PVT. LTD. (YX02-YX-01), PUNJAB - 141001
PUNJAB - 143502 MOHALI
NEAR CANAL, BATHINDA ROAD, JAITO, PH :9815069814.
PH :9780038335.
DISTRICT – FARIDKOT. - 151202 1737. LOVELY AUTOS (6209-62-04), EURO MART 1747. NAVDESH AUTOS LLP (L105-L1-01), PLOT
PH :7347000520. KHANNA COMPLEX, HAMBRAN ROAD, NEAR RADHA NO.C-89, INDUSTRIAL AREA, PHASE-7, MOHALI
JALALABAD 1725. HOSHIARPUR AUTOMOBILES (N302-N3-01), SWAMI SATSANG BHAWAN - 141008 - 160059
VILLAGE-KAUNI, NEAR GILL PETROL PUMP, GT PH :9815069814. PH :8872016453.
1715. TARA AUTOMOBILES (H501-8E-02), F.F. ROAD,
ROAD, KHANNA, DIST.-LUDHIANA, PUNJAB. - MACHIWARA 1748. CM AUTOSALES PVT. LTD. (0706-L1-03), PLOT
NEAR THANA SADAR, JALALABAD - 152024
141401 NO. B-64, INDUSTRIAL AREA PHASE-7, MOHALI
PH :9876047847. 1738. HOSHIARPUR AUTOMOBILES (9T03-9T-01),
PH :9888716261. – PUNJAB - 140110
JALANDHAR SAMRALA ROAD, MACHIWARA, NEAR SHEEVA
KHARAR PH :8284800597.
MARRIAGE PALACE - 141115
1716. LOVELY AUTOS (3503-35-01), DR. AMBEDKAR
1726. CM AUTOSALES PVT. LTD. (7K01-JH-03), NH-95, PH :9875900147. MORINDA
CHOWK, JALANDHAR CITY - 144001
MORINDA ROAD,KHANPUR, KHARAR. DIST. MAHILPUR 1749. CM AUTOSALES PVT. LTD. (BHH1-BHH-01),
PH :9915020515.
MOHALI - 140301 KHASRA NO. 1092, CHANDIGARH-SAMRALA
1717. MARWAHA AUTOS (A UNIT OF INDERJIT 1739. HOSHIARPUR AUTOMOBILES (H402-DD-05),
PH :9915022878. ROAD, MORINDA, DIST.-ROPAR, PUNJAB. - 140
MARWAHA AUTOS PVT. LTD.) (3506-35-01), OPP NEAR NEW BUS STAND, CHANDIGARH ROAD,
KILANWALI 101
DPS SCHOOL, G.T. ROAD, JALANDHAR - 144010 MAHILPUR, DIST. HOSHIARPUR - 146105
PH :9915022811.
PH :9779166004. 1727. HIRA AUTOMOBILES LTD (BFV1-BFV-01), GT PH :9914720424.
1718. LOVELY AUTOS (3505-35-01), KHASRA NO. ROAD (NH NO. 09), NEAR GURU NANAK MAJITHA MUKERIAN
24/20/4, B D ENCLAVE, VILLAGE - JALANDHAR, COLLEGE, KILANWALI, TEHSIL – MALOUT, 1750. HOSHIARPUR AUTOMOBILES (IP01-IP-01), VILL.
1740. RISHABH FOURWHEELS PVT. LTD.
DIST.-JALANDHAR, PUNJAB. - 144001 DISTRICT – MUKTSAR SAHIB. - 152107 TALWANDI KALAN, GT ROAD, MUKERIAN -
(CDR1-CDR-01), PLOT NO.130, OPP. DANA
PH :9876044001, 9915020515. PH :8872034131. 144211
MANDI, AMRITSAR ROAD, MAJITHA. - 143601
JANDIALA GURU KOTKAPURA PH :9815131766, 8437919900.
PH :9914841577.
1719. BABA AUTOS (7C01-GL-03), GT ROAD, NEAR 1728. MAPSKO AUTO INDIA PVT. LTD. (BIS2-BIS-01), MALERKOTLA MUKTSAR
TARN TARAN BYE PASS, JANDIALA GURU - MOGA ROAD, NEAR GREEN DHABA OPPOSITE 1751. HIRA AUTOMOBILES LTD (6302-J8-03), BHAI
1741. MAX AUTOMOBILES (CCI2-CCI-01),
143115 FUN PLAZA, KOTKAPURA, DISTRICT – COMPLEX, MALOUT ROAD, MUKTSAR, PUNJAB
MALERKOTLA-LUDHIANA MAIN ROAD, VILLAGE
PH :8872013029. FARIDKOT - 151204 - 152026
- BHOGIWAL, MALERKOTLA, DIST.-SANGRUR,
JANDIALA MANJKI PH :7347000518. PH :9217048250, 9056900042.
PUNJAB. - 148023
1720. LOVELY AUTOS (BJS1-BJS-01), SANT MARKET, LALRU PH :9814403131 , 9056903131. MULLANPUR
JANDIALA-BUNDALA ROAD, VILLAGE – 1729. AUTOPACE NETWORK PVT LTD (BRJ1-BRJ-01), MALOUT 1752. SANDHU AUTOMOBILES (YY01-YY-01),
JANDIALA MANJKI, TEHSIL – NOORMAHAL, VILLAGE – LALRU, DERA BASSI, SAS NAGAR OPPOSITE DHAKA ROAD, FEROZEPUR ROAD,
1742. HIRA AUTOMOBILES LTD (6302-LE-05), TINKONI
DISTRICT – JALANDHAR, PUNJAB. - 144033 MOHALI, PUNJAB. - 140501 MULLANPUR - 141101
CHOWK, NEAR LIC BUILDING, MALOUT - 152107
PH :7087439797. PH :9815011669. PH :8437025969.
PH :299524, 264724,9988417000.
KAHNUWAN LUDHIANA MANDI GOBINDGARH MULLANPUR GARIBDASS
1721. PATHANKOT VEHICLEADES PVT. LTD. 1730. GULZAR MOTORS LTD. (6204-62-01), G.T.ROAD, 1753. NAVDESH AUTOS LLP (CVZ2-CVZ-01), H NO.
1743. HOSHIARPUR AUTOMOBILES (U903-U9-01),
(CGM1-CGM-01), KHASRA NO.606, DHOLEWAL, OPP. MILITARY CARMP, LUDHIANA 341, POST OFFICE - MULLAPUR GARIBDASS,
PLOT GOYAL MOTORS, NEAR YES BANK,
VPO-KAHNUWAN, THE. & DISTT. GURDASPUR. - - 141003 TEHSIL - MAJRI, DIST.-SAS NAGAR, STATE -
MANDI SIRHIND ROAD, NH-1,
143528 PH :9814160099. PUNJAB. - 140901
MANDIGOBINDGARH, PUNJAB. - 147301
PH :8288993301. 1731. SANDHU AUTOMOBILES (6206-62-01), PH :8872004676.
PH :9815131766, , 9914119292.
KALA SANGHIAN DHOLEWAL CHOWK, LINK ROAD, LUDHIANA - NABHA
141203 MANSA
1722. MARWAHA AUTOS (SPL1-SPL-01), MAIN 1754. HIRA AUTOMOBILES LTD (6302-UF-06), RADHA
PH :9815600095. 1744. TARA AUTOMOBILES (7002-TL-02), BALATA
CHOWK, KALA SANGHIAN, DISTRICT SWAMI ROAD, NABHA - 147201
1732. LIBRA AUTO CAR CO. LTD (6207-62-01), G.T. ROAD, NEAR ARVIND NAGAR, MANSA , PUNJAB
KAPURTHALA, PUNJAB - 144623 PH :9317000004 ,9217048250.
ROAD, NEAR AIRPORT, LUDHIANA - 141020 - 151505
PH :9779166004. NAKODAR
PH :0160-2512701, 03. PH :01652-216042.
KAPURTHALA 1733. LIBRA AUTO CAR CO. LTD (6207-62-02), G.T MEHTA 1755. LOVELY AUTOS (3503-5B-04), JALANDHAR
ROAD, NEAR AIRPORT, LUDHIANA. - 141020 ROAD, NEAR MALARI GATE, NAKODAR - 144040
PH :0160-25035130. PH :9915028603.

55
Dealer Workshop (AS ON 31.05.2023 )

NANGAL 1767. MARWAHA AUTOS (A UNIT OF INDERJIT 1777. HOSHIARPUR AUTOMOBILES (TF03-TF-01), 1786. TRICITY AUTOS (9M01-9M-01), PATIALA
MARWAHA AUTOS PVT. LTD.) (5C02-5C-01), KHEWAT KHATONI NO. 802/1049 & 821/1070 HIGHWAY,VILLAGE - NABHA, ZIRAKPIR,
1756. CM AUTOSALES PVT. LTD. (7K01-8F-02),
PLOT NO-62, INDUSTRIAL AREA, NEAR JCT KHEWAT KHAS NO. 43/1/2/1 (1-0), BESIDE SBI PUNJAB - 140603
PLOT#36,AJOLI MOR, FOCAL POINT
BRIDGE LUDHIANA - 141001 BANK, BASSI ROAD, SIRHIND, TEHSIL AND PH :9988882330.
INDUSTRIAL AREA, NAPA NANGAL ,PUNJAB -
PH :9779166004. DISTRICT – FATEHGARH SAHIB - 140406
140126
PH :9815131766, 7527082471.
RAJASHTHAN
PH :9592916811. PHILLAUR
SULTANPUR LODHI JAIPUR
NAWANSHAHR 1768. LOVELY AUTO (XU01-XU-01), OLD
1787. AURIC MOTORS (1116-11-C1), COMMERCIAL
NAWANSHAHR ROAD CIVIL LINE, PHILLAUR, 1778. MARWAHA AUTOS (A UNIT OF INDERJIT
1757. LOVELY AUTOS (3503-J7-02), NAWANSHAHR PLOT NO. J4, COMMERCIAL BELT B, VT ROAD,
DISTRICT JALANDHAR - 144410 MARWAHA AUTOS PVT. LTD.) (ZY02-ZY-01),
CHANDIGARH ROAD, VILL- LANGROHA, DISTT:- NEW SANGANER ROAD, MANSAROVAR
PH :9815069814. NEAR TALWADI BRIDGE, TALWANDI ROAD,
NAWANSHAHR, PUNJAB - 144514 SCHEME, JAIPUR, RAJASTHAN 302020 - 302020
RAIKOT SULTANPUR LODHI, DISTRICT -KAPURTHALA -
PH :9915028682. PH :9571105651.
144626
NIHAL SINGH WALA 1769. GULZAR MOTORS PVT LTD (XT02-XT-01),
BARNALA BY PASS ROAD, RAIKOT - 141109
PH :9779166004. RAJASTHAN
1758. REMIRA MOTORS PVT LTD (QB02-QB-01),
PH :9814160099. TALWANDI BHAI ABU ROAD
BARNALA ROAD, NEAR DEAR BABA SEWA
RAJPURA 1779. BABA AUTOS (GMF1-GMF-01), FEROZEPUR 1788. NAVNEET MOTORS (OQ01-OQ-01), PLOT NO.
DASS, TEHSIL-NIHALSINGHWALA, DIST.-MOGA.
ROAD, NEAR FUNISLAND, TALWANDI BHAI, E-26, RIICO AMBAJI INDUSTRIAL AREA,
- 142 055 1770. HIRA AUTOWORLD LLP (HK02-HK-01), VILLAGE
DISTT. FEROZEPUR - 142050 PALANPUR HIGHWAY, ABU ROAD DISTT.
PH :7067025009. BADHAK, RAJPUR PATIALA ROAD, RAJPURA -
PH :8872013002. SIROHI - 307026
PATHANKOT 140401
PH :244881-84, 9217048437,9217048250. TALWANDI SABO PH :99501 56579.
1759. PATHANKOT VEHICLEADES PVT. LTD. ACHROL
RAMPURA PHUL 1780. TARA AUTOMOBILES (ON01-ON-01), TALWANDI
(A701-A7-01), NEAR MAMOON CHOWK,
RAMA MAIN ROAD, NEAR VILLAGE-JAJJAL, 1789. KTL AUTOMOBILE PVT. LTD. (GKD1-GKD-01),
DALHOUSIE ROAD, PATHANKOT, - 145001 1771. TARA AUTOMOBILES (XR01-XR-01), RAMPURA
RAMAMANDI,TALWANDI SABO, BHATINDA - #REF! - 303002
PH :8264105000 , 9417900883. -BARNALA ROAD, RAMPURA PHUL - 151103
1551302 PH :7412077022.
1760. PATHANKOT VEHICLEADES PVT. LTD. PH :01651-266643.
PH :9646691047, 8437008666. AHORE
(A701-A7-04), NEAR A. B. COLLEGE, RAYYA
PATAHANKOT - 145001 TALWARA
1790. AURIC MOTORS (SHN1-SHN-01), MADHOPURA,
1772. RISHABH FOURWHEELS PVT. LTD.
PH :9417900828 , 9417900842. 1781. HOSHIARPUR AUTOMOBILES (H402-LR-07), NEAR KARNAWATI HOSPITAL, AHORE,
(CAK1-CAK-01), NH-1, GT ROAD RAYYA, TEHSIL
PATIALA DAM ROAD, NEAR KALI MATA MANDIR, DISTRICT – JALORE, RAJASTHAN PIN CODE:
– BABA BAKALA, DISTRICT – AMRITSAR. -
VILLAGE-NAGAR, TALWARA, PUNJAB - 144216 307029 - 307029
1761. HIRA AUTOMOBILES LTD (6302-63-01), 13-B, 143112
PH :9815131766, 9781842244. PH :#REF!.
FACTORY AREA, PATIALA - 147001 PH :9914708577.
PH :2360131, 2360562,9217048250. TANDA AJMER
ROPAR
1762. HIRA AUTOMOBILES LTD (6302-63-04), C-20 & 1782. HOSHIARPUR AUTOMOBILES (H402-DE-06), 1791. AJMER AUTO AGENCIES PVT. LTD.
1773. CM AUTOSALES PVT. LTD. (7K01-7K-01),
C-45, FOCAL POINT, PATIALA, PUNJAB - 147001 VILL.PULPUKHATA, MIANI ROAD, TANDA - (B201-B2-01), SRINAGAR ROAD,AJMER
CHANDIGARH ROPAR ROAD, ROPAR - 140001
PH :2232377, 9217048234, 9217048250. 144203 (RAJASTHAN) - 305001
PH :9915022802.
1763. HIRA AUTOMOBILES LTD (6302-63-07), D-1A, PH :9815131766, 8437430400. PH :9314955201.
INDUSTRIAL FOCAL POINT, PATIALA (PUNJAB). SAMANA TARAGARH 1792. RELAN MOTORS (B203-B2-01), NEAR BIRLA
- 147001 1774. HIRA AUTOMOBILES LTD (BFU1-BFU-01), WATER TANK, PARABATPURA BYEPASS,
1783. PATHANKOT VEHICLEADES PVT. LTD.
PH :2232295, 2232296, 9217048250. KEWAT NO. 948/950, KHATUNI NO. 1427, AJMER - 305001
(BVC1-BVC-01), VILLAGE - RAHIMPUR,
1764. ATELIER AUTOMOBILES (6304-63-01), VILLAGE KHASRA NO. 101/27(4-7), PATIALA SAMANA PH :95876 87000, 84400 41027.
VPO-TARAGARH, TEHSIL & DISTT.
MITHUMAJRA, RAJPURA-PATIALA ROAD, NEAR ROAD, SAMANA, DIST.-PATIALA, STATE 1793. RELAN MOTORS (B203-B2-02), F-243 RIICO
PATHANKOT, HIMACHAL PRADESH - 143534
CASABA RESORT, PATIALA - 147001 PUNJAB. - 147101 INDUSTRIAL AREA, PALRA, AJMER - 305001
PH :9988639963.
PH :7527000106, 7527000111. PH :9217048236. PH :95876 87000, 87400 16329.
PATRAN TARN TARAN 1794. AJMER AUTO AGENCIES PVT. LTD.
SANGRUR
1784. JAYCEE MOTORS (BLP2-BLP-01), VILLAGE – (B201-B2-05), KHASRA NO.343/2, 344, 345, 347
1765. HIRA AUTOMOBILES LTD (6302-V3-02), 1775. MAX AUTOMOBILES (G402-G4-01), DHURI
KAKKA, KANDIALA, NEAR SANDHU PETROL GHUGHRA GHATI, JAIPUR ROAD, AJMER. -
NARWANA ROAD, PATRAN, PUNJAB, - 147105 ROAD, SANGRUR, - 148024
PUMP, AMRITSAR ROAD, TARAN TARAN, 305001
PH :244445, 245788, 9217048250. PH :01672-239627.
PUNJAB - 143401 PH :9314955201.
PATTI SHAHKOT PH :9780038039. AKLERA
1766. JAYCEE MOTORS (BQA2-BQA-01), KHASRA NO. 1776. LOVELY AUTOS (BHT1-BHT-01), PUBLIC ZIRA 1795. BHATIA AND COMPANY (SGK1-SGK-01), NH-52,
64/19/2/1 KA 16/49 & KHASRA NO. 64/20 KA SCHOOL ROAD, SHAHKOT, DISTRICT –
1785. BABA AUTOS (7C01-GK-02), FEROZEPUR ROAD, RAM NAGAR COLONY, AKLERA, JHALAWAR,
29/94, NEAR RADHA SWAMI, TARN TARAN JALANDHAR, PUNJAB. - 144702
ZIRA - 142047 PIN-326033, RAJASTHAN - 326033
ROAD, VILLAGE - PATTI, DISTT.-TARN TARAN, PH :8437936811.
PH :8872013230. PH :9057047891.
PUNJAB. - 143416 SIRHIND
PH :9780038335. ZIRAKPUR ALWAR
PHAGWARA

56
Dealer Workshop (AS ON 31.05.2023 )
1796. MG MOTORS (F901-F9-01), MUKESH GENERAL BARAN 1816. SUWALKA MOTORS PVT LTD (SDB1-SDB-01), 1826. LOHIA AUTOMOBILES (E301-UA-02), R/O
FINANCE COMPANY, ROAD NO. 2, NEAR MEO K.NO. 327 MANDAVI OPPOSITE SDM OFFICE GOLDEN CORRIDOR, OPP. ASHOK LEYLAND
1806. BHATIA & COMPANY (A UNIT OF BHATIA
BOARDING, ALWAR - 301001 JHALAWAR ROAD, W/S, CHITTOR-BIJOLIA HIGHWAY, BIJOLIA,
CORPORATION PVT. LTD.) (6101-PM-03),
PH :9001795520. BHAWANIMANDI,JHALAWAR- 326502. - 326502 DIST. -BHILWARA - 311602
BESIDE OJHA METAL, ATRU ROAD, BARAN -
1797. MG MOTORS (F901-F9-02), KHASRA NO.803/198, PH :9116178571. PH :82094 11856.
325205
BHUGORE TIRAHA, NEAR ALWAR PUBLIC BHILWARA BIKANER
PH :9413379013.
SCHOOL, JAIPUR ROAD, ALWAR - 301001
BARMER 1817. LOHIA AUTOMOBILES (E301-E3-01), AJMER 1827. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT
PH :9001795520.
ROAD,NEAR OCTROI POST,BHILWARA - 311001 LTD) (7101-71-01), OPP. URMUL DAIRY
ANOOPGARH 1807. LMJ SERVICES LTD. (6502-SH-06), G-216, RIICO
PH :82094 11856. PLANT,GANGANAGAR ROAD,BIKANER - 334004
INDUSTRIAL AREA, BARMER - 344001
1798. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT 1818. CHAMPION CARS (UNIT OF PREM CARS PVT. PH :1512253984,9414138511.
PH :8005898360.
LTD) (BFE1-BFE-01), PLOT NO. AMEDKAR LTD) (E302-E3-01), NEAR GRAM BHARTI, 1828. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT
1808. LMJ SERVICES LTD. (SH01-SH-01), NH# 68, OPP.
CHARAHARA,RAILWAY STATION ROAD CHITTORGARH ROAD, BHILWARA, RAJASTHAN, LTD) (7101-71-04), JAIPUR BYE PASS,BIKANER
SADAR THANA - 344001
,ANUPGARH (ANOOPGARH ),DISTT SRI - 311001 , - 334004
PH :8005898360.
GANGANAGAR . - 335701 PH :7073461987. PH :1512230384,8875010507.
PH :9982638516. BASSI 1819. LOHIA AUTOMOBILES (E301-E3-03), PLOT NO. 1829. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT
ANTA 1809. PREM MOTORS PVT. LTD. (VF02-VF-01), H-11, EVERGREEN TEXTILE PARK, RIICO LTD) (7101-71-05), OPP. AVYYAPPA TEMPLE, K.
MOHAN PURA BASSI, JAIPUR, RAJASTHAN - INDUSTRIAL AREA, PUR ROAD, BHILWARA. - K. COLONY, BIKANER - 334003
1799. BHATIA & COMPANY (A UNIT OF BHATIA
303301 311001 PH :7014063193,9413311949.
CORPORATION PVT. LTD.) (CTG2-CTG-01),
PH :01414711118,8058794151. PH :82094 11856. 1830. DUDI AUTOMOBILES (A UNIT OF DMAS
KOTA-BARAN ROAD, ANTAH, DIST.-BARAN. -
BAYTU BHINDER AUTOMOBILES) (7102-71-01), KHASRA NO.
325502
376/33, JAIPUR ROAD, NH-11, BIKANER,
PH :9414032859. 1810. LMJ SERVICES (SIT1-SIT-01), NH-8 ,NEAR 1820. TECHNOY MOTORS INDIA PVT. LTD.
RAJASTHAN. - 334001
ASIND JAGDAMBA PETROL PUMP , BAYTU - 344034 (CBS1-CBS-01), NEAR RAILWAY
PH :8929834417.
PH :8094011126. STATION,SALUMBAR CHOURAHA, BHINDER -
1800. CHAMPION CARS (SID1-SID-01), DEV TOWERS,
313603 BILARA
BEAWAR ROAD, ASIND, DISTRICT – BHILWARA, BEAWAR
PH :9001234056. 1831. LMJ SERVICES LTD. (BZB1-BZB-01), BANGANGA
RAJASTHAN - 311301 - 311301 1811. RELAN MOTORS (FL03-FL-01), PLOT NO 1,
BHINMAL MOD, JODHPUR ROAD, BILARA , RAJASTHAN -
PH :7073461987. INDIRA GANDHI UDYOGPURI , AJMER ROAD 342602
BAGRU ,BEAWAR, RAJASTHAN . - 305202 1821. SHRI KRISHNA AUTOSALES PVT LTD
PH :8104698935.
PH :9587687000. (CQN1-CQN-01), KHASRA NO. 2281, KARADA
1801. PREM MOTORS PVT. LTD. (US02-US-01),
CROSSING, BHINMAL, DISTRICT - JALORE, BUNDI
JAIPUR-AJMER HIGHWAY, BAGRU, BEGUN
RAJASTHAN. 1832. BHATIA & COMPANY (A UNIT OF BHATIA
DISTRICT-JAIPUR - 303007 1812. BHATIA & CO (BTD1-BTD-01), BHATIA & CO. (A PH :9610242790. CORPORATION PVT. LTD.) (6101-EF-02), SUMAN
PH :01414711118,8058411181. UNIT OF BHATIA CORPORATION PVT LTD),IN
BHIWADI PLAZA, NEAR TEACHER'S COLONY, CHITTOR
BALESAR FRONT OF GURUKUL, CHITTOR ROAD,BEGUN, ROAD, OPPOSAITE ICICI ATM, BUNDI - 323001
TEHSIL – BEGUN, DISTRICT CHITTORGARH, 1822. FORTUNE CARS (A UNIT OF JYOTI
1802. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT PH :9413353099.
312023 - 312023` AUTOMOBILES PVT LTD) (9H01-9H-01), OPP.
LTD) (CWO1-CWO-01), KHASRA NO. 2167
INDAG RUBBER,MAIN ROAD ,BHIWADI - 301019 CHAKSU
PH :95097 06827.
JODHPUR JAISALMER ROAD, VILL:- BALESAR
BEHROR PH :9214794326,8875005116. 1833. K P AUTOMOTIVES PVT LTD (1104-JM-03),
SATTA, TEH:- BALESAR , DIST:- JODHPUR (
1823. FORTUNE CARS (A UNIT OF JYOTI TONK ROAD, CHAKSU - 303901
RAJ.) - 342203 1813. MG MOTORS (FQ01-FQ-01), B-168, RIICO AUTOMOBILES PVT LTD) (9H01-9H-02), PH :0141-4071111, 4071101,8696934973.
PH :7412087344. INDUSTRIAL AREA, PHASE-II, OPP. APEX TUBE, F-458-C,RIICO,INDUSTRIAL AREA,BHIWADI - CHANDAN
BALOTRA BEHROR, DISTT: ALWAR. - 301701 301019
PH :9001795520. 1834. LMJ SERVICES LTD. (SHR1-SHR-01),
1803. LMJ SERVICES LTD. (6502-9G-05), JODHPUR PH :9214794326,8875005116.
BHADRA JAISALMER ROAD ,CHANDAN , DISTT
BALOTRA ROAD,BALOTRA, RAJASTHAN - 1824. FORTUNE CARS (A UNIT OF JYOTI
JAISALMER ,RAJASTHAN - 345031
344022 1814. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT AUTOMOBILES PVT LTD) (9H01-9H-04), KHASRA
PH :8094011126.
PH :8005898360. LTD) (BIF1-BIF-01), CHAK NUMBER-8,BARANI, NO. 656/431, ALWAR ROAD, BHIWADI. - 301019
PH :9214794326,8875005116. CHIRAWA
BANSUR NEAR HISAR BYEPASS BHADRA -BALSAMAND
ROAD ,BHADRA. - 335501 BIJAYNAGAR 1835. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT
1804. FORTUNE CARS (A UNIT OF JYOTI
PH :9166712222, 9413311745. LTD) (SY02-SY-01), NEAR PILANI CIRCLE,
AUTOMOBILES PVT LTD) (BQP1-BQP-01), 1825. AJMER AUTO AGENCIES PVT LTD
BHARATPUR LOHARU ROAD, STATE HIGHWAY-8, CHIRAWA -
KOTPUTLI ROAD, NEAR SUBHASH CHOWK, (GLF1-GLF-01), KHASRA NO 39 , AJMER
333026
BANSUR, RAJASTHAN - 301402 1815. TM MOTORS PVT. LTD. (5J01-5J-01), BRIJ VIHAR -BHILWARA HIGHWAY CITY -BIJAYNAGAR
PH :01596-217163,7230081668.
PH :8875005116. COLONY,,MADARPUR DISTRICT – AJMER ,RAJASTHAN - 305624
PH :8890902472. CHITTORGARH
BANSWARA ROAD,BHARATPUR,RAJASTHAN - 321001
PH :9251423392. BIJOLIA 1836. BHATIA & COMPANY (A UNIT OF BHATIA
1805. NAVNEET MOTORS (X903-X9-01), NEAR J.C.
BHAWANI MANDI CORPORATION PVT. LTD.) (K901-K9-01), PLOT
MILL,OPPOSITE AKASHWANI,DAHOD
NO. 1001/1-1002/1,NIMBAHERA
ROAD,BANSWARA - 327001
ROAD,CHITTORGARH - 312001
PH :86023 83260.
PH :97854 61267.

57
Dealer Workshop (AS ON 31.05.2023 )

CHOMU 1847. SHRI MANGLAM AUTO PVT. LTD. (FT03-FT-01), 1857. K P AUTOMOTIVES PVT LTD (1104-11-01), E-198, 1870. LMJ SERVICES LTD. (BNY1-BNY-01), KHASRA
DIDWANA BYPASS, MAIDASAR CHORAHA, SANGANER INDUSTRIAL NO. 784, JAIPUR-JODHPUR BYE PASS ROAD,
1837. KTL AUTOMOBILES (HW02-HW-01), KHARSA
DIDWANA - 341303 AREA,MANSAROVAR,JAIPUR - 302020 JAITARAN, DIST.-PALI. - 306302
NO.695, JAIPUR SIKAR BYPASS ROAD, CHOMU,
PH :7230055924. PH :0141-4071111, 4071101,6377203709, PH :9269971266.
RAJASTHAN. - 303702
DUDU 6377203731. JALORE
PH :7412077034.
1858. PREM MOTORS PVT. LTD. (1112-11-02), 12
1838. SATNAM MOTORS (HW03-HW-01), NEAR CM 1848. PREM MOTORS PVT. LTD. (BRY1-BRY-01), 1871. SHRI KRISHNA AUTOSALES PVT LTD
13,SUDARSHANPURA INDUSTRIAL AREA,
CHOPRA HOSPITAL, JAIPUR ROAD, CHOMU, KHASRA NO.1107 & 1108, OPPOSITE POWER (VD01-VD-01), KHASRA NO.6809/2616, 2623,
JAIPUR - 302006
DISTRICT – JAIPUR, HOUSE SERVICE LANE, NH-8, DUDU. - 303008 INDUSTRIAL AREA, JALORE-BHINMAL ROAD,
PH :0141-4711111,8058703388 , 8058794122.
RAJASTHAN - 303702 PH :8058411181. JALORE - 343001
1859. SANGA AUTOMOBILES PVT. LTD. (1110-11-01),
PH :8302090000. DUNGURPUR PH :2973211613,9829203644.
SECTOR 35, PRATAP NAGAR,SANGANER,
CHURU 1849. NAVNEET MOTORS (4902-GP-02), G-71, JAIPUR - 302033 JAMWA RAMGARH
1839. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT INDUSTRIAL AREA, DUNGARPUR - 314001 PH :9772210922. 1872. K P AUTOMOTIVES PVT LTD (BZL1-BZL-01),
LTD) (MD03-MD-01), NEAR DTO OFFICE, JAIPUR PH :94141 04833. 1860. VIPUL MOTORS PVT. LTD. (1102-11-05), 29, KHASRA NUMBER -228/169,OPP UDAY
ROAD, CHURU - 331001 FALNA INDUSTRIAL AREA, JHOTWARA, JAIPUR - AUTOMOBILES,JAIPUR ALWAR ROAD –JAMWA
PH :8696543584. 302012 RAMGRAH. - 303109
1850. LMJ SERVICES LTD. (BBR1-BBR-01), OPPOSITE PH :0141-3524203,9672211333.
DATA RAMGARH PH :6377203709, 6377203731.
PRAKASH DINING HOTEL ,FALNA - 306116 1861. PREM MOTORS PVT. LTD. (1112-11-01), PLOT
1840. JAMU AUTOMOBILES PVT LTD (CTQ1-CTQ-01), PH :#REF!. JHADOL
NO. E101/A, VKI , JAIPUR - 302039
KHASRA NO. 1016/256, VILLAGE - RAMGARH, FATEHNAGAR PH :01414411123,8929409921. 1873. TECHNOY MOTORS (SKO1-SKO-01), KHASRA
TEHSIL - DATAH RAMGARH, DIST.-SIKAR. - 1862. SATNAM MOTOCORP PVT. LTD. (1113-11-01), NO. 186/1, NH # 8, NEAR ASHOK LEYLAND
1851. TECHNOY MOTORS INDIA PVT. LTD.
332703 PLOT NO. E-524, SITAPURA INDUSTRIAL AREA, WORKSHOP, SARDARPURA, SOJAT,
(4903-SV-03), PLOT NO.15, FATENAGAR
PH :9799501048. JAIPUR – 302 022, RAJASTHAN. - 302022 PIN-306104, RAJASTHAN - 306104
SANWAR ROAD, UDAIPUR-CHITTORGARH
DAUSA PH :1412771976,8302390000. PH :7726809510.
HIGHWAY NO.76, FATEHNAGAR-313205 DISTT.
1841. VIPUL MOTORS PVT. LTD. (1102-FM-03), AGRA UDAIPUR - 313205 1863. KTL AUTOMOBILE PVT. LTD. (1115-11-01), PLOT JHALAWAR
JAIPUR ROAD, DAUSA - 303303 PH :9829793402. NO. 13B, JHOTWARA INDUSTRIAL AREA, 1874. BHATIA & COMPANY (A UNIT OF BHATIA
PH :9672211333. JAIPUR. - 302012 CORPORATION PVT. LTD.) (6102-RV-02), OPP.
GANGAPUR CITY
PH :7412077022. BALAJI KI CHHATRI , KHEL CIRCULAR STADIUM,
DEGANA 1852. PREM MOTORS PVT. LTD. (BUT1-BUT-01), 1864. PREM MOTORS PVT. LTD. (1112-11-03), PLOT BUS STAND ROAD, JHALAWAR - 326001
1842. SHRI MANGALAM (SDJ1-SDJ-01), NEAR KHASRA NO. 5854, 5858, 5860, 5861, VILLAGE NO. B-12, MALVIYA NAGAR, JAIPUR. - 302017 PH :9414034728.
NAGAUR FATAK, STATION ROAD, DEGANA - UDAI KALAN, THE GANGAPUR CITY - 322201 PH :9358715550,8929409921.
341512 PH :8058794122. JHUNJHUNU
1865. KTL AUTOMOBILES (1115-11-02), KHASRA NO
PH :7230055955. GUDHAGORJI 1210-1216/2959 , BHANKROTA , TEH SANGANER 1875. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT
DEOLI , DISTRICT JAIPUR. - 302026 LTD) (FN03-FN-02), E1-2, AUTOMOBILES
1853. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT
PH :7412077007. SERVICE SECTOR, RIICO INDUSTRIAL AREA,
1843. K P AUTOMOTIVES PVT LTD (Z001-Z0-01), LTD) (CGC1-CGC-01), BHORKI ROAD,
1866. KTL AUTOMOBILES (1115-11-03), ORBIT MALL PHASE-2, SIKAR JAIPUR ROAD, JHUNJHUNU. -
KOTA- JAIPUR HIGHWAY, NH-12, DEOLI - GUDHAGORJI, DISTRICT – JHUNJHUNUN,
CIVIL LINES METRO STATION AJMER ROAD 333001
304804 RAJASTHAN. - 333022
,JAIPUR. - 302006 PH :01592-250045,7412087489.
PH :8696925259. PH :7412059848.
PH :7412077007. JOBNER
DEVGARH HANUMANGARH 1867. K.P. AUTOMOTIVE (1104-11-G1), B-1, GOVIND
1876. PREM MOTORS PVT. LTD. (BRD1-BRD-01),
1844. LOHIA AUTOMOBILES (CUQ1-CUQ-01), NEAR 1854. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT MARG, ADARSH NAGAR, JAIPUR – 302004 -
KHASRA NO. 758 & 754, BABER WALON KI
KRISHI MANDI, KAMLIGHAT ROAD, TEHSIL – LTD) (7101-S7-03), JUNCTION TOWN 302004
DHANI, JOBNER, TEHSIL – PHULERA, DISTRICT
DEVGARH, DISTRICT – RAJSAMAND, ROAD,HANUMANGARH - 335512 PH :9549656559.
– JAIPUR, RAJASTHAN - 303328
RAJASTHAN. - 313331 PH :01552-231295,9166712222, 9413311745. 1868. KTL AUTOMOBILES (1115-11-04), CHOKDI
PH :8058411181.
PH :8306009399. HINDAUN HAWALI SHAHAR, SHIRKI SHAHAR, NEAR
IDGAH, BILOCHOYAN MOHALLA, TRANSPORT
JODHPUR
DHARIYAWAD 1855. FORTUNE CARS (A UNIT OF JYOTI
NAGAR, DELHI ROAD, JAIPUR - 302002 - 302002 1877. LMJ SERVICES LTD. (6502-65-01), PRATAP
1845. BHATIA & CO. (SMC1-SMC-01), PRATAPGARH AUTOMOBILES PVT LTD) (S002-S0-01), KHASRA
PH :9772210922. NAGAR,JODHPUR - 340002
ROAD, DHARIYAWAD , DIST. - PRATAPGARH, NO. 737, VILLAGE – PATTI NARAINPUR, NEAR
JAISALMER PH :9950496202.
RAJASTHAN - 313605 - 313605 HANUMAN MANDIR, HINDAUN-MAHWA ROAD,
1878. LMJ SERVICES LTD. (6502-65-04), OPP TO RFC
PH :98287 46677. HINDAUN. - 322230 1869. LMJ SERVICES LTD. (5L01-5L-01), PLOT NO.36,
OFFICE,NEW POWER HOUSE ROAD,JODHPUR
DHOLPUR PH :7017024146,7017024146. 37, MAHESH REFUGEE COLONY,HDC SOCIETY,
- 342003
JAIPUR DABLA ROAD, JAISALMER (RAJASTHAN) -
1846. TM MOTORS PVT. LTD. (5K01-5K-01), TM PH :8094011127.
345001 1879. SHRI KRISHNA AUTOSALES PVT LTD
MOTORS PVT. LTD., GT ROAD DHOLPUR, 1856. VIPUL MOTORS PVT. LTD. (1102-11-01),
PH :8005898360.
RAJASTHAN. - 328001 F-124A,MALVIYA INDUSTRIAL AREA,MALVIYA (6503-65-01), 32-A,HEAVY INDUSTRIAL AREA,NR
PH :8094777862. NAGAR,JAIPUR - 302017 JAITARAN FCI GODOWNS, JODHPUR - 342005
DIDWANA PH :9269117654,8949686508. PH :2912748402,9001894669.

58
Dealer Workshop (AS ON 31.05.2023 )
1880. LMJ SERVICES LTD. (6502-65-09), B-8,9,10, KISHANGARH 1902. SHRI MANGLAM AUTO PVT. LTD. 1912. BHATIA & COMPANY (A UNIT OF BHATIA
MARUDHAR INDUSTRIAL AREA, PHASE 1, (CUP1-CUP-01), KHASRA NO. 1011 SUJANGARH CORPORATION PVT. LTD.) (CTJ1-CTJ-01),
1891. AJMER AUTO AGENCIES PVT LTD (TU01-TU-01),
BASNI, JODHPUR - 342008 ROAD, LADNUN - 341206 UNIARA ROAD, OPP: PETROL PUMP, NAINWA,
R K LINK ROAD, - 305802
PH :8094011147. PH :7412044506. DIST. KOTA - 323801
PH :9314391011.
1881. LMJ SERVICES LTD. (6502-65-0C), 21/1, PAL LALSOT PH :9413379001.
MAIN BALOTRA ROAD, NEAR D.P.S. CIRCLE, KISHANGARH BAS NASIRABAD
1903. VIPUL MOTORS PVT. LTD. (BZF1-BZF-01), PLOT
JODHPUR - 342002 1892. FORTUNE CARS (A UNIT OF JYOTI
NO.22,23, KHASRA NO.1502-03, NARAYAN 1913. AJMER AUTO AGENCIES PVT. LTD.
PH :7230057721. AUTOMOBILES PVT LTD) (9H01-TU-03),
VIHAR, SAWAI MADHOPUR ROAD, LALSOT, (B201-VB-04), CHAVANI BOARD NO:1613, HAWA
1882. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT KISHANGARH BIWADI HIGHWAY, NEAR
RAJASTHAN - 303502 CHAKKI, NASIRABAD ROAD, NASIRABAD,
LTD) (6504-65-01), C-62 BASNI INDUSTRIAL KISHANGARH, DISTRICT ALWAR - 301405
PH :9672211333. DISTT. AJMER - 305601
AREA, PHASE-1, JODHPUR - 342005 PH :8875007753,8875007753.
LOSAL PH :9314955201.
PH :7412059839. KOTA
1883. LMJ SERVICES LTD. (6502-65-0D), 1904. JAMU MOTORS (SMD1-SMD-01), NATHDWARA
PARSHWANATH COLONY, KAYLANA ROAD, 1893. BHATIA & COMPANY (A UNIT OF BHATIA
LOSAL-SALASAR-DIDWANA ROAD, OPPOSITE 1914. LOHIA AUTOMOBILES (X201-TZ-02), NH-8, LAL
JODHPUR. - 342 001 CORPORATION PVT. LTD.) (6101-61-01), 13-16
SHIV MANDIR, WARD NO. 1, LOSAL, BAG, NATHWARA, DISTRICT: RAJSAMAND -
PH :8696916455. B,INDUSTRIAL ESTATE, KOTA - 324007
RAJASTHAN - 332025. - 332025 313301
1884. LMJ SERVICES LTD. (6502-65-10), KHASRA NO. PH :9414085574.
PH :9571959931. PH :8306009399.
357/5, BANAR ROAD, OPPOSITE VIDHYA 1894. BHATIA & COMPANY (A UNIT OF BHATIA
CORPORATION PVT. LTD.) (6102-61-01), AUTO LUNI NAWALGARH
PUBLIC SCHOOL, JODHPUR, RAJASTHAN - 342
003 MOBILE ZONE,G-11/12 INDUSTRIAL AREA, 1905. LMJ SERVICES (SFD1-SFD-01), NEAR SBI BANK, 1915. AURIC MOTORS (SIE1-SIE-01), KHATA NO. 76,
PH :7222002424. KOTA - 324005 SALAWAS ROAD,LUNI, TEHSIL – LUNI,DISTRICT PUNIA KI DHANI, SIKAR ROAD, NAWALGARH,
PH :9001027933. – JODHPUR,RAJASTHAN PIN CODE: 342802 - DISTRICT – JHUNJHUNU, RAJASTHAN PIN
KAPRAIN
1895. BHATIA & COMPANY (A UNIT OF BHATIA 342802 CODE: 333042 - 333042
1885. BHATIA & COMPANY (A UNIT OF BHATIA CORPORATION PVT. LTD.) (6101-61-04), PH :8094011126. PH :9928720360.
CORPORATION PVT. LTD.) (BGG1-BGG-01), 3(K),CHAMBAL INDUSTRIAL MAHWA NEEM KA THANA
MEGA HIGHWAY ROAD, NEAR PETROL PUMP, AREA,KOTA,RAJASTHAN - 324007
KAPRAIN DISTT. BUNDI - 323301 1906. VIPUL MOTORS PVT. LTD. (BKZ1-BKZ-01), 1916. JAMU AUTOMOBILES PVT LTD (K701-TV-03),
PH :9414077682.
PH :9587894896. KHASRA NO.37/384, BHARATPUR ROAD NEAR TOLL PLAZA, KOTPUTLI ROAD, NEEM KA
1896. BHATIA & COMPANY (A UNIT OF BHATIA
BYE-PASS, N.H.-11, MAHWA, DISTT. DAUSA THANA, SIKAR - 332713
KEKRI CORPORATION PVT. LTD.) (6101-61-05), E-46,
(RAJASTHAN) - 321608 PH :9529178046.
CHAMBAL INDUSTRIAL AREA, KOTA - 324007
1886. AJMER AUTO AGENCIES PVT. LTD. PH :9672211333. NEEMRANA
PH :9414085574.
(B201-GZ-03), KOTA SAWAR ROAD,KEKRI - MAKRANA
1897. BHATIA & COMPANY (A UNIT OF BHATIA 1917. FORTUNE CARS (A UNIT OF JYOTI
305404
CORPORATION PVT. LTD.) (6101-61-06), PLOT 1907. SHRI MANGLAM AUTO PVT. LTD. AUTOMOBILES PVT LTD) (OP01-OP-01), F-42 &
PH :9314955201.
NO. E-222, ROAD NUMBER 5, INDRAPRASTHA (CFX1-CFX-01), MANGLANA ROAD, MAKRANA - 42(B), PHASE-1, NEEMRANA, TEHSIL: BEHROR,
KHAJUWALA INDUSTRIAL AREA, KOTA, RAJASTHAN. - 341512 DISTT. ALWAR - 301705
1887. AURIC MOTORS (SJC1-SJC-01), DANTOR ROAD, 324005 PH :7230055934. PH :9610715222,9636139386.
KHAJUWALA, DIST. - BIKANER, RAJASTHAN. - PH :9116108613. MALPURA NIMBAHERA
3340323 1898. SUWALKA MOTORS PVT. LTD. (6104-61-01),
PH :9982299866. RIDDHI SIDDHI NAGAR, KUNHARI, BUNDI ROAD, 1908. K P AUTOMOTIVES PVT LTD (BLB1-BLB-01), 1918. BHATIA & COMPANY (A UNIT OF BHATIA
KOTA, RAJASTHAN. - 324008 PLOT NO.07, SHRI KALYAN NAGAR COLONY, CORPORATION PVT. LTD.) (CTH1-CTH-01),
KHANDAR
PH :9116178516. JAIPUR-KEKRI ROAD, MALPURA - 304502 PLOT NO. 7-8, 33-34, 35-36, NIMBAHERA, DIST.
1888. PREM MOTORS (CODE UNDER PH :8696925262. -CHITTORGARH. - 312601
CREATIONS-CODE UNDER CREATIONS-CODE KOTPUTLI
MANDALGARH PH :97854 61267.
UNDER CREATIONS), SAWAI 1899. PREM MOTORS PVT. LTD. (MH09-MH-01), NH-8, NIWAI
MADHOPUR-KHANDAR RD., KHANDAR, BUCHARA COLONY, OPP. SHAKTI VIHAR, 1909. CHAMPION (SHA1-SHA-01), OPP. MODEL
RAJASTHAN - 322025. - 322025 KOTPUTLI, JAIPUR - 303108 SCHOOL, BIJOLIA ROAD, MANDALGARH, 1919. K P AUTOMOTIVES PVT LTD (BLA1-BLA-01),
PH :8058899960. PH :01414711118,8058411181. DISTRICT – BHILWARA, PIN-311604, VANASTHALI CIRCLE, NEAR PRATEEK GAS
1900. PREM MOTORS PVT. LTD. (MH09-MH-02), RAJASTHAN - 311604 AGENCY, TONK ROAD, NIWAI, DISTRICT –
KHERLI
KHASRA NO- 636, KOTPUTLI, DIST. JAIPUR, PH :7073461987. TONK. - 304021
1889. MG MOTORS (BZE1-BZE-01), KHERLI MERTA PH :8696925262.
RAJASTHAN - 303108
KATHUMAR ROAD, VILLAGE KHERLI, DISTT. NOHAR
PH :01414711118,8058411181. 1910. SHRI MANGLAM MOTORS (NG03-NG-01),
ALWAR, RAJASTHAN - 321606
PH :9001795520. KUCHAMAN KHASRA NO.1679, NH89, MERTA - 341015 1920. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT
1901. SHRI MANGLAM AUTO PVT. LTD. (VA02-VA-01), PH :9116007201. LTD) (VE02-VE-01), OPP. RAILWAY STATION,
KHERWARA
SUDHRSHAN NAGAR, BUDSU ROAD KHASRA NAGAUR NOHAR, DISTRICT-HANUMANGARH - 335523
1890. TECHNOY MOTORS (SEE1-SEE-01), OPP. PH :0155-5221485,7412059821, 8875010541.
NO.148 KUCHAMAN - 341508 1911. SHRI MANGLAM AUTO PVT. LTD. (HL03-HL-01),
ATITHI PALACE, VILLAGE BADLA, NH NOKHA
PH :7230055928. KHASRA NO.1479/982 & 1478/83 BIKANER
8,KHERWARA, TEHSIL – KHERWARA, DISTRICT
– UDAIPUR, RAJASTHAN PIN CODE: 313803 - LADNU ROAD, NAGAUR - 341001
313803 PH :9116008624.
PH :7726809510. NAINWA

59
Dealer Workshop (AS ON 31.05.2023 )
1921. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT 1931. AJMER AUTO AGENCIES PVT. LTD. 1940. SHRI KRISHNA AUTOMOBILES (SGX1-SGX-01), 1949. KTL AUTOMOBILE PVT. LTD. (CVD1-CVD-01),
LTD) (I501-I5-01), F-46, RIICO EXTENSION, (CTL1-CTL-01), PLOT NO.11, SHIV VIHAR NEAR RAILWAY GATE, BHINMAL ROAD PLOT NUMBER -C1 NEAR SHAKUMARI PG
NOKHA INDUSTRIAL AREA, NOKHA DISTT- COLONY, MANGLIYAWAS ROAD, PISANGAN, ,RANIWARA, TEHSIL – RANIWARA, DISTRICT – COLLEGE , PHULERA ROAD , SAMBHAR 303604
BIKANER (RAJASTHAN) - 334803 DISTRICT – AJMER, RAJASTHAN. - 305204 JALORE, RAJASTHAN,PIN CODE: 343040 - - 303604
PH :7412059805. PH :9314955201. 343040 PH :7412077022.
PADAMPUR POKHRAN PH :9928377669. SANCHORE
1922. DUDI MOTORS (SGC1-SGC-01), NEAR BASANT 1932. LMJ SERVICES (BOA1-BOA-01), SUNDER RATANGARH 1950. SHRI KRISHNA AUTOSALES PVT LTD
PLACE, BHAGAT SINGH CHOWK, KARANPUR NAGAR, TEHSIL POKHRAN, DISTRICT – 1941. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT (GY01-GY-01), PLOT NO. 217, KHASRA NO. 844,
ROAD, PADAMPUR SRI GANGANAGAR 335041 - JAISALMER, RAJASTHAN. - 345021 LTD) (BHJ1-BHJ-01), PLOT NO. AREA F-186 865, 867, MANMOHAN SINGH PARK, NH-15,
335041 PH :9610115660. INDUSTRIAL AREA, RATANGARH. - 331 022 BARMER ROAD, SANCHORE, DIST.-JALORE. -
PH :8619215475. PRATAPGARH (RAJASTHAN) PH :7412087301. 343041
PALI RAWATBHATA PH :9636224546.
1933. BHATIA & COMPANY (A UNIT OF BHATIA
1923. LMJ SERVICES LTD. (6502-J9-03), KHASRA NO. CORPORATION PVT. LTD.) (PN01-PN-01), 1942. BHATIA & COMPANY (A UNIT OF BHATIA SANGARIA
771/1, JODHPUR PALI ROAD, PALI - 306401 CHITTORGARH-PRATAPGARH ROAD, CORPORATION PVT. LTD.) (JQ01-JQ-01), NEAR 1951. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT
PH :9269971266. GRAM-BAMBOTARA, PRATAPGARH INDIAN OIL PETROL PUMP, KOTA ROAD, LTD) (GKK1-GKK-01), HANUMANGARH ROAD
PAOTA (RAJASTHAN) - 312605 RAWATBHATA , DIST. CHITTORGARH, NEAR KARMA PETROL PUMP - 335035
PH :97723 78682. RAJASTHAN. - 323307 PH :7412059827.
1924. K P AUTOMOTIVES PVT LTD (BRH1-BRH-01),
RAIPUR PH :9001027933. SANGOD
PATTA SANKHYA 31, MISAL SANKHYA 89, NEAR
BAMORIA PETROL PUMP, NH-8, PAOTA, 1934. LMJ SERVICES LTD. (CRZ1-CRZ-01), NATIONAL RAWATSAR 1952. BHATIA & COMPANY (A UNIT OF BHATIA
RAJASTHAN. - 303106 HIGHWAY, PALI ROAD, VILLAGE – RAIPUR, 1943. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT CORPORATION PVT. LTD.) (GLG1-GLG-01),
PH :6377203709, 6377203731. DISTRICT – PALI. - 306304 LTD) (SDA1-SDA-01), CHAK 21-22,DWD,PLOT KHASRA NO 1637 , SANGOD BAPAPAR MAIN
PARBATSAR PH :9269971266. NUMBER -10 & 11, RAWATSAR (RAJASTHAN). - ROAD ,SANGOD - 325601
RAISINGHNAGAR 335524 PH :9251641358.
1925. SRI MANGLAM (SKT1-SKT-01), NEAR IFL
PH :9166712222, 9413311745. SARDARSHAHAR
HOUSING FINANCE CO, KISHAN - 341512 1935. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT
PH :8740909096. LTD) (BHK1-BHK-01), PLOT NO. H-2, REENGUS 1953. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT
PARTAPUR INDUSTRIAL AREA, RAISINGHNAGAR, DISTRICT 1944. JAMMU MOTORS (SGL1-SGL-01), REENGUS LTD) (BID1-BID-01), KHASRA NO.134, MOTOR
– SRIGANGANAGAR. - 335051 HIGHWAY , REENGUS DISTT. SIKAR -332404 - MARKET, RATANGARH SARDARSHAHAR ROAD,
1926. NAVNEET MOTORS (BKY1-BKY-01),
PH :9982638516. 332404 SARDARSHAHAR DISTT. CHURU, RAJASTHAN -
AAASHAPURA CHAURAHA, BHAGORA MOR,
RAJGARH PH :9785030973. 331403
NEAR AAASHAPURA MANDIR, PARTAPUR
RENWAL MANJHI PH :9799833995.
,RAJASATHAN - 327024 1936. MG MOTORS (IY01-IY-01), ALWAR SIKANDRA
PH :94140 10306. MEGA HIGHWAY, VILLAGE DIGAWARA, TEHSIL 1945. PREM MOTORS PVT. LTD. (GKZ1-GKZ-01), SAWAI MADHOPUR
PHALODI RAJGARH DISTT. ALWAR - 301408 KHASRA NUMBER 2286/110,OPP ROHINI NAGAR 1954. PREM MOTORS PVT. LTD. (FY03-FY-01), PLOT
PH :9001795520. 1 ,JAIPUR BHILWARA HIGHWAY NO.14, RIICO INDUSTRIAL AREA, KHERDA,
1927. SHRI KRISHNA AUTOSALES PVT LTD
1937. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT ,RENWAL,TEHSIL PHAGI JAIPUR ,RAJASTHAN SAWAI MADHOPUR - 322001
(BQI1-BQI-01), OPP. RCP GUEST HOUSE,
LTD) (CGD1-CGD-01), NH-65, OPP. BHAGAT (303904). - 303904 PH :01414711118,9358725409.
NAGAUR KHICHAN ROAD, PHALODI,
SINGH CHOWK, RAJGARH DISTT. CHURU, - PH :01414711118,9928494441. SAYALA
RAJASTHAN - 342301
331023 REVDAR
PH :9116011958. 1955. AURIC MOTORS (SHM1-SHM-01), NEAR PETROL
PH :9602261977.
PHULERA 1946. TECHNOY MOTORS INDIA PVT. LTD. PUMP, HANUMAN MANDIR SOUTH STYLE, MAIN
RAJSAMAND (CRY1-CRY-01), OPP. TIRUPATI PETROL PUMP, ROAD SAYALA, SAYALA TEHSIL – SAYALA,
1928. KTL AUTOMOBILE PVT. LTD. (CUS1-CUS-01),
1938. LOHIA AUTOMOBILES (X201-X2-01), BHILWARA KAROTI ROAD, REVDAR, DISTT. SIROHI, DISTRICT – JALORE, RAJASTHAN PIN CODE:
KHASRA NO. 21 TO 24 AND PLOT NO. 189 IN
ROAD,KHANKROLI,RAJSAMAND DISTT, RAJASTHAN. - 307514 343022 - 343022
RAM VIHAR COLONY, PANCHBHATI, PHULERA,
RAJSAMAND - 313301 PH :9530396882. PH :9460739993.
DISTRICT - JAIPUR, RAJASTHAN - 303338
PH :8306009399. SAGWARA SHAHPURA
PH :7412077022.
RAMGANJMANDI 1947. TECHNOY MOTORS INDIA PVT. LTD. 1956. K P AUTOMOTIVES PVT LTD (1104-NH-05),
PINDWARA
1939. BHATIA & COMPANY (A UNIT OF BHATIA (CK01-CK-01), BANSWARA ROAD, VILLAGE RAJPURA,GRAM PANCHAYAT
1929. NAVNEET MOTORS (CQP1-CQP-01), OPPOSITE
CORPORATION PVT. LTD.) (BAZ1-BAZ-01), CHUNGINAKA, NR. CENTRAL JAIL, SAGWARA, BIDARA,NH-8, SHAHPURA - 303103
WOLKEM FACTORY, SIROHI ROAD, PINDWARA,
KHAIRABAD ROAD, KHASARA NO. 753, A.S.I DUNGARPUR DISTT., RAJASTHAN - 314025 PH :0141-4071111, 4071101,8696934964,
DIST. - SIROHI. - 307022
COLONY, RAMGANJ MANDI - 326519 PH :9694970143. 9358220012.
PH :86197 44672.
PH :9414085790. SALUMBAR 1957. LOHIA AUTOMOBILES (CCP1-CCP-01),
PIPAR RANIWARA OPPOSITE LIC OFFICE, BHILWARA ROAD,
1948. NAVNEET MOTORS (BZH1-BZH-01), GANESH
1930. LMJ SERVICES LTD. (BTI1-BTI-01), KHASRA NO. SHAHPURA DISTT. BHILWARA - 311404
GHATI, BANSWARA ROAD, SALUMBAR,
1095, PIPAR CITY, DIST.-JODHPUR. - 342601 PH :7568378555,9462979238.
DISTRICT – UDAIPUR. - 313027
PH :9462616268.
PH :76652 01980. SHEO
PISANGAN SAMBHAR

60
Dealer Workshop (AS ON 31.05.2023 )
1958. LMJ SERVICES LTD. (SDO1-SDO-01), NEAR 1968. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT 1978. K.P. AUTOMOTIVES PVT. LTD. (SCB1-SCB-01), 1986. SREE SARADHAMBAL AUTOMOBILES PVT LTD
RIDDI SIDDHI HOTEL , OPPOSITE HP LTD) (BRB1-BRB-01), KHASRA NO.459/333, KHASRA NUMBER 1156,,OPP HOTEL (CUX1-CUX-01), SURVEY NO.495/4, OLD
PETROL PUMP ,TEH SHEO, DISTT – BARMER - SALASAR ROAD, NEAR ANAJ MANDI, GULMOHAR ,,JAIPUR ROAD NO.724B, KANCHI THOTTI THOTTAM, BHAVANI
335521 SUJANGARH , DISTT. CHURU - 331507 ,VIRATNAGAR,DISTT JAIPUR - 303102 MAIN ROAD,ANTHIYUR. - 638501
PH :8094011144. PH :8875011561. PH :0141-4071111, 4071101,9358220012. PH :8754086777.
SIKAR SULTANPUR SIKKIM ARAKKONAM
1959. JAMU AUTOMOBILES PVT LTD (K701-K7-01), 1969. SUWALKA MOTORS PRIVATE LIMITED GANGTOK 1987. GANESH CARS PVT. LTD. (BKQ1-BKQ-01),
F-54,,JAIPUR ROAD (NH-11),SIKAR - 332001 (GKY1-GKY-01), KHASRA NUMBER 485, NEAR SURVEY NO. 556A/3, VILLAGE – ICHIPUDHUR,
1979. ENTEL MOTORS (B901-B9-01), 6TH MILE,
PH :9057400761. PETROL PUMP , SULTANPUR ROAD , TALUKA – ARAKKONAM, VELLORE. - 631003
P.O.TADONG, GANGTOK, SIKKIM - 737102
SIROHI SULTANPUR , DISTT KOTA - 325204 PH :9842345399.
PH :9933031828
PH :9116178594. ARIYALUR
1960. NAVNEET MOTORS (4902-LK-03), PLOT NO. 9933032059.
8,BHADRANAGAR NAGAR, ANADRA ROAD, SUMERPUR 1988. PILLAI & SONS MOTOR CO. (EB01-EB-01),
JORTHANG
SIROHI - 307001 1970. LMJ SERVICES LTD. (6502-VC-08), G-14 NO.1/1 , NEAR ULAVAR SANTHAI,
1980. ENTEL MOTORS (B901-B9-02), PIPALEY
PH :9166261788. JAKHAMATA INDUSTRIAL AREA, OPP. JAYAMKONDAM ROAD, ARIYALUR (TAMIL
ROHTAK, NEAR JNU SCHOOL, WEST SIKKIM,
SIVANA DASHEREA GROUND, SUMERPUR - 306902 NADU). - 621704
JORTHANG - 737121
PH :8094002633. PH :04329-228300, 9442281302.
1961. LMJ SERVICES LTD. (CCO1-CCO-01), BALOTRA PH :9733164882
ROAD, SIWANA, DISTRICT - JODHPUR, SURATGARH 9933009934. ARNI
RAJASHTHAN. - 344044 1971. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT 1989. GANESH CARS PVT. LTD. (BKP1-BKP-01), DOOR
PH :8005898360. LTD) (U201-LG-02), OPP. RELIANCE PETROL
TAMIL NADU NO. 1151/3, VELLORE MAIN ROAD, OPPOSITE
SOJAT PUMP,NH-15, SURATGARH - 335804 ALANDURAI TO HERO MOTORS SHOWROOM,
PH :8875012667. 1981. AADHI CARS PVT. LTD. (CTO1-CTO-01), NO.69/1 RATNAMANGALAM BUS STOP, ARNI ,
1962. LMJ SERVICES LTD. (BWI1-BWI-01), KHASRA
TONK A, SIRUVANI MAIN ROAD, URIPALLAM PUDHUR, THIRUVANAMALAI, TAMIL NADU. - 632301
NO. – 186/1, NH-8, NEAR ASHOK LEYLAND
ALANDURAI, COIMBATORE (TAMIL NADU) - PH :9585553266.
WORKSHOP, SARDARPURA, SOJAT , 1972. K P AUTOMOTIVES PVT LTD (GM01-GM-01),
RAJASTHAN - 306104 F-94, RIICO INDUSTRIAL AREA, TONK ,
641101 ARUPPUKKOTTAI
PH :8754045816.
PH :9269971266. RAJASTHAN - 304001 1990. ASIR AUTOMOBILES PVT LTD (CWF1-CWF-01),
SRI DUNGARGARH PH :9549651972. ALANGULAM SURVEY NO. 205/1, 5/5C, NEHRU NAGAR,
TUNGA 1982. AADHI CARS PVT. LTD. (SJF1-SJF-01), SURVEY ARUPPUKKOTTAI TO MADURAI BYPASS ROAD,
1963. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT
NO. 495/7, TIRUNELVELI - TENKASI ROAD, ARUPPUKKOTTAI, DIST.-VIRUDHUNAGAR. - 626
LTD) (BIG1-BIG-01), 1563/1273, NH-11, 1973. PREM MOTORS (SMB1-SMB-01), VILLAGE
ALANGULAM, TIRUNELVELI DISTRICT,TN - 101
MOMASAR BASS, DUNGARGARH, DISTRICT - GWALANI, BASSI-LALSOT ROAD, TUNGA,
627851 PH :9944059911.
BIKANER, RAJASTHAN. - 331803 TEHSIL- BASSI, JAIPUR - 303302 - 303302
PH :9414138511. PH :8058998123.
PH :8754044143. ATTUR
SRI KARANPUR UDAIPUR AMBASAMUNDRAM (AMBAI) 1991. S.M.CAR PVT. LTD. (QT02-QT-01), SF NO.
1983. AADHI CARS PVT. LTD. (BXT1-BXT-01), DOOR 351/10A, SALEM TO CHENNAI BY PASS ROAD,
1964. AURIC MOTORS (SDL1-SDL-01), PADAMPUR 1974. NAVNEET MOTORS (4901-49-01), 7 CITY
NO. 2/253, SURVEY NO. 104/2, RTO OFFICE APPAMASAMDURAM, ATTUR, SALEM. - 636108
ROAD, NEAR DHAN MANDI, SRI STATION ROAD,UDAIPUR - 313001
ROAD, VILLAGE - VAGAIKULAM, PH :7094440057.
KARANPUR,TEHSIL – SRI KARANPUR, DISTRICT PH :90017 58531.
– SRI GANGANAGAR,RAJASTHAN, PIN CODE: 1975. NAVNEET MOTORS (4902-49-01), S-140,MADRI
AMBASAMUNDRAM. - 627 401 AVADI
PH :7397188858.
335073 - 322243 INDUSTRIAL AREA,OPP. BSNL OFFICE, 1992. VISHNU CARS PVT. LTD. (5P01-5P-01), SURVEY
PH :8875088998. UDAIPUR - 313002 ANAMALAI NO. 146, 147/1F & 147/G, NO. 17 VILLAGE –
SRI MADHOPUR PH :95888 86349. 1984. ABT (CHE1-CHE-01), SITE NO. 6/12, NEAR ABT KAVARAPALAYAM, CTH ROAD, AVADI,
1976. TECHNOY MOTORS INDIA PVT. LTD. SAMUGA KOODAM, SETHUMADAI ROAD, DISTRICT – THIRUVALLUR, CHENNAI, TAMIL
1965. JAMU AUTOMOBILES PVT LTD (BZD1-BZD-01),
(4903-49-02), NH-8, GOVERDHAN VILLAS, ANAMALAI, COIMBATORE DISTRICT, NADU - 600054
WARD NO.4, RINGUS ROAD, SRI MADHOPUR
DEVALI, NEAR JEEVAN TARA RESORT, TAMILNADU - 642 104 PH :7338888021,
DISTT. SIKAR. - 332715
UDAIPUR - 313002 PH :9788174244. 7358024470.
PH :9672822166.
PH :9414165429. ANNUR AVINASHI
SRIGANGANAGAR 1977. TECHNOY MOTORS INDIA PVT. LTD.
1985. JAIKRISHNAA AUTOSALES PVT. LTD. 1993. SHASHTI CAR PVT LTD (CLK1-CLK-01), SURVEY
1966. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT (4903-49-04), KHASRA NO. 546, 547, 554 AND
(DN01-DN-01), SF NO.266/1B, OTTRAPALAYAM NO. 373/1E, THEEKU THOTTAM,
LTD) (U201-U2-01), NEW AUTOMOBILE 555, NEAR CHITRAKOOT NAGAR, OPP.
VILLAGE, OPP. TO KG SCHOOL, NALLIGOUNDANPALAYAM, PALANGARAI,
MARKET,SURATGARH-HANUMANGARH ROAD, BHIRAVGARH HOTEL, SUKHER, TEHSIL –
ANNUR,COIMBATORE (DIST), TAMILNADU - KUPOUDAMPALAYAM POST, NH ROAD,
SRIGANGANAGAR - 335001 BADGAON, UDAIPUR, RAJASTHAN. - 313001
641653 AVINASHI EAST, TIRUPPUR DISTRICT,
PH :0154-2465226,7412059837. PH :9530396896.
PH :9788850733. TAMILNADU - 641654
1967. AURIC MOTORS (A UNIT OF AUDI MOTORS PVT VIRATNAGAR PH :9942903319.
LTD) (U201-U2-03), CHAK 1G CHOTI, NH15, ANTHIYUR
SRIGANGANAGAR, RAJASTHAN - 335001 BHAVANI
PH :8875911503.
SUJANGARH

61
Dealer Workshop (AS ON 31.05.2023 )
1994. SREE SARADHAMBAL AUTOMOBILES PVT LTD 2006. POPULAR VEHICLES & SERVICES LTD. 2020. ABT LIMITED (1401-14-0E), NO. 1/132, RAJEEV 2031. VISHNU CARS PVT. LTD. (1427-14-08), SURVEY
(H701-IG-05), NO.5/1072, LAKSHMI NAGAR, (1410-14-01), NO.11, ARUNACHALAM ROAD, GANDHI SALAI, SHOLINGANALLUR, DISTRICT – NO. 62/2B, DOOR NO. 1/63, AGARAM MAIN
NH-47, VASAVI COLLEGE (P.O.), BHAVANI, SALIGRAMAM, CHENNAI - 600093 CHENNAI, TAMIL NADU. - 600119 ROAD, THIRUVANCHERRY VILLAGE,
ERODE (DIST), TAMIL NADU. - 638316 PH :9282405819, 9282348331, 8939915206. PH :044-24502185 / 87 / 88 / 89. TAMBARAM TALUK, SELAIYUR, KANCHIPURAM
PH :9597385777. 2007. ABT LIMITED (1401-14-07), NO. 422, 2021. VISHNU CARS PVT. LTD. (1427-14-03), 4/13 DIST., CHENNAI , TAMIL NADU. - 600 073
CHENGALPETTU KOLAPERUMAL SCHOOL STREET, POONMA LOYAL GARDEN, KALAHATHAMMAN KOVIL PH :8056260022.
MALLE HIGH ROAD, CHENNAI - 600106 STREET, RAMAPURAM, CHENNAI, TAMIL NADU. 2032. ABT LIMITED (1401-14-10), S. NO: 32/2,
1995. AIE CARS (A UNIT OF AI ENTERPRISES PVT
PH :044-42267628/604. - 600089 NANDAMBAKKAM, PADMINI GARDEN, CHENNAI
LTD) (BBS1-BBS-01), PLOT NO. 98/1,
2008. CRESCO (A UNIT OF NEXGEN VENTURES PVT PH :8754440002/ 9677244332. - 600089, TN.. - 600089
PULIPAKKAM VILLAGE, CHENGALPETTU,
LTD). (1493-14-01), 5,THIRUMURUGAN ST, 2022. VISHNU CARS PVT. LTD. (1487-14-01), NO.203 PH :044-22320161, 8220011558.
DISTRICT-KACHEEPURAM, TAMIL NADU. -
KOYAMBEDU, CHENNAI - 600107 TO 206 MOUNT POONAMALLE ROAD, CHEYYAR
603002
PH :7305087055. KATTUPAKKAM, CHENNAI - 600056
PH :7299057387. 2033. GANESH CARS PVT. LTD. (BUD1-BUD-01),
2009. ABT LIMITED (1411-14-01), 29, WALLES ROAD, PH :9677127432.
1996. AIE CARS (A UNIT OF AI ENTERPRISES PVT NO.16, KANCHEEPURAM ROAD, CHEYYAR,
OPP. ALBERT THEATER, EGMORE, AMBATTUR, 2023. VISHNU CARS PVT. LTD. (1487-14-02), NO.120,
LTD) (BBS1-BBS-02), DOOR NO. 41, GST ROAD, TIRUVANNAMALAI DISTT. - 604407
CHENNAI - 600058 MAMBAKKAM MAIN ROAD, MEDAVAKKAM,
PULIPAKKAM, CHANGELPET, TAMILNADU - PH :9787669339.
PH :044-42281707 / 714 / 719 / 720 / 721 / 737/. CHENNAI - 600100
603202 CHIDAMBARAM
2010. CARS INDIA PVT. LTD. (1403-FP-04), NO.503, PH :9840929994/ 9840944478.
PH :7299057387.
G.N.T. ROAD, REDHILLS, CHENNAI - 600066 2024. VISHNU CARS PVT. LTD. (1427-14-04), NEW S. 2034. VISHNU CARS PVT. LTD. (CPK1-CPK-01),
CHENGAM PH :9952000078. NO. 314/1B1A, PALLAVARAM – THORAIPAKKAM SURVEY NO. 102/2 & 102/5, BHUVANAGIRI MAIN
1997. GANESH CARS PVT. LTD. (BUP1-BUP-01), 2011. VISHNU CARS PVT. LTD. (1427-14-02), 176/1, RADIAL ROAD, NEAR OLD CHETTINADU ROAD, KEERAPALAYAM, CHIDAMBARAM
SURVEY NO. 293/3A, 3A1,VILLAGE - LUZ CHURCH ROAD, NEAR KAMADHENU CEMENT GOWDOWN, KEELAKATTALAI, TOWN, CUDDALORE, TAMIL NADU. - 608 602
THUKAPETTAI, CHENGAM, DIST. THEATRE MYLAPORE, CHENNAI - 600004 CHENNAI. - 600117 PH :041-44241334/7358004555.
-TIRUVANNAMALAI. - 606 701 PH :0427-24661973/74/75. PH :9940057775. COIMBATORE
PH :7397395289. 2012. VISHNU CARS PVT. LTD. (1427-14-01), NO. 91, 2025. VISHNU CARS PVT. LTD. (1427-14-06), PLOT NO.
GST ROAD, ALWITONE ESTATE, BEHIND LAXMI 4, MORISON 4 STREET, ALANDUR, CHENNAI. - 2035. ABT LIMITED (4101-41-06), 744, PULIYAKULAM
CHENNAI ROAD, P.N. PALAYAM, COIMBATORE - 641037
THEATRE, PALLAVARAM, CHENNAI - 600043 600016
1998. ABT LIMITED (1401-14-01), 102, MOUNT ROAD, PH :044-66813729/7338888000. PH :044-45590293. PH :9944400987.
GUINDY, CHENNAI - 600032 2013. POPULAR VEHICLES & SERVICES LTD. 2026. RAJALAKSHMI CARS PVT. LTD. (1486-14-02), 2036. SREE SARADHAMBAL AUTOMOBILES PVT LTD
PH :044-42254544, 42254554. (1410-14-03), NO. 3, 200 RING ROAD, RETTERI OLD NO. 27, NEW NO. 22A, ALAPAKKAM MAIN (4103-41-01), IYER HOSPITAL PREMISES,
1999. KHIVRAJ MOTORS PVT LTD. (1404-14-01), 623 JUNCTION, RETTERI , CHENNAI - 600099 ROAD, MADURAVOYAL, CHENNAI. - 600095 TRICHY ROAD, COIMBATORE - 641005
MOUNT ROAD, CHENNAI - 600006 PH :7448814726/23/33. PH :9841427572/9500125083. PH :8220862666.
PH :9043014530. 2014. CARS INDIA PVT. LTD. (1403-14-05), PLOT NO.- 2027. CRESCO (A UNIT OF NEXGEN VENTURES PVT 2037. ABT LIMITED (4101-41-05), LAKSHMI THEATRE
2000. CARS INDIA PVT. LTD. (1403-14-01), 16 & 17 80, BABU JAGAGEVAN RAM STREET, LTD). (1493-14-03), PLOT NO. G30, 3RD MAIN BUILDING, T.S. NO. 1199/2, TS WARD NO. 3,
INDUSTRIAL ESTATE, AMBATTUR, CHENNAI - GERUGAMBAKKAM, CHENNAI - 600112 ROAD, 9TH STREET, AMBATTUR INDUSTRIAL KEMPATTY COLONY, SOUTH UKKADAM,
600058 PH :9952000079. ESTATE, DIAGONALLY TO TELEPHONE COIMBATORE - 641001
PH :9952000089. 2015. KHIVRAJ MOTORS PVT LTD. (1404-14-03), EXCHANGE, CHENNAI. - 600058 PH :044-4232660, 4232666.
2001. CARS INDIA PVT. LTD. (1403-14-02), NO.17, SURVEY NO. A1& A2, SIDCO INDUSTRIAL PH :7305087033. 2038. SREE SARADHAMBAL AUTOMOBILES PVT LTD
LATTICE BRIDGE ROAD, ADYAR, CHENNAI - ESTATE, GUINDY, CHENNAI - 600032 2028. POPULAR VEHICLES AND SERVICES LTD (4103-41-03), 555, NSR ROAD, SAIBABA
600020 PH :7299971978. (1410-14-06), PLOT NO. 10, NEW SURVEY NO. COLONY, COIMBATORE - 641011
PH :044-24462020. 2016. ABT LIMITED (1401-14-0D), NO.2/170, ECR 88/1A1, 88/1C, 88/1B & 88/2B, NOOMBAL MAIN PH :9047055667.
2002. POPULAR VEHICLES & SERVICES LTD. ROAD, INJAMBAKKAM, CHENNAI TAMIL NADU. - ROAD, VANAKARAM, CHENNAI. - 600 077 2039. ABT LIMITED (4101-41-08), 15/55-C, ALAGESAN
(1410-14-02), OLD NO.155, NEW NO.123, 600041 PH :044-61343434, 46490006/9. ROAD (EAST), METTUPALAYAM ROAD,
PONRANJITHAM COMPLEX, MEDAVAKKAM PH :044-24490584 / 585 /586. 2029. AIE CARS (A UNIT OF AI ENTERPRISES PVT COIMBATORE - 641043
MAIN ROAD, NEAR BUS TERMINUS, 2017. AIE CARS (A UNIT OF AI ENTERPRISES PVT LTD) (1484-14-02), PLOT NO. L-1 SIDCO PH :96009 66056.
KEEKATTALAI, CHENNAI - 600117 LTD) (1484-14-01), PLOT NO.1,2,3 & 4, SURVEY INDUSTRIAL ESTATE, VILLIVAKKAM, CHENNAI, 2040. JAIKRISHNAA AUTOSALES PVT. LTD.
PH :9176906334, 9176906335, 9176906336. NO.91/2, B1, A2 & B, NEELANKARAI, EAST TAMIL NADU. - 600 049. (4107-41-01), 8/60-C&8/62-D, METTUPALAYAM
2003. ABT LIMITED (1401-14-05), A/A2, BHARANI COAST ROAD, CHENNAI - 600115 PH :9841742926. ROAD, G.N.MILLS POST , NEARJOHNBOSCO
STUDIO COMPLEX, DR. BHANUMATHI KRISHNA PH :7401211553. 2030. VISHNU CARS PVT. LTD. (1427-14-07), SURVEY CHURCH,COIMBATORE - 641029
ROAD,22, ARCOT ROAD, SALIGRAMMAM, 2018. RAJALAKSHMI CARS PVT. LTD. (1486-14-01), NO. 19/1A2, 83/18, DOOR NO. 113, NEAR PH :044-4519140.
CHENNAI - 600093 OLD DOOR NO.69, NEW DOOR NO.20,GRAND PARIMALAM THEATER, KUNDRATHUR MAIN 2041. SREE SARADHAMBAL AUTOMOBILES PVT LTD
PH :044-23650488, 23650490. NELLORE TRUNK ROAD, MADHAVARAM, ROAD, MANNADY THALAI, NALLUR, SAMBA (4103-41-07), NO 44, KANNUSAMY GOUNDER
2004. ABT LIMITED (1401-14-06), NO. 1 & 2, VASANTHA CHENNAI . - 600060 THALAI, MOONRAMKATTALAI VILLAGE, ONDI STREET, OORGOUNDER THOTTAM,
PRESS,ROAD, OPPOSITE MALAR HOSPITAL, PH :8939995454/8939995404. COLONY, KUNDRATHUR, CHENNAI. - 600069 SANGANUR, COIMBATORE - 641027
ADYAR, CHENNAI - 600020 2019. KHIVRAJ MOTORS PVT LTD. (1480-14-02), PLOT PH :95000 82346. PH :9655219900.
PH :044-24465814 , 24465815. NO.119 & 120, ELECTRICAL & ELECTRONICS 2042. SREE SARADHAMBAL AUTOMOBILES PVT LTD
2005. CARS INDIA PVT. LTD. (1403-14-03), 4/321, OLD INDUSTRIAL ESTATE, PERUNGUDI, CHENNAI - (4103-41-08), SF-94, SATHY MAIN ROAD,
MAHABALIKPURAM RD. , KOTTIVAKKAM, 600096 VISWASAPURAM, SARAVANNAMPATTI,
CHENNAI - 600040 PH :98414 23569. COIMBATORE, - 641013
PH :044-24540182 /43590913. PH :9585877775.

62
Dealer Workshop (AS ON 31.05.2023 )
2043. JAIKRISHNAA AUTOSALES PVT. LTD. 2055. VISHNU CARS PVT. LTD. (5Q02-5Q-01), SURVEY 2064. SRI CITY AUTO (A UNIT OF CITY AUTO PVT 2073. ABT LIMITED (CHG1-CHG-01), SURVEY NO.
(4107-41-02), DOOR NO. 48, KAMARAJAR ROAD, NO. 35/8, 35/8A, 35/21, 35/6, 35/6A1A, 35/20, LTD) (H702-H7-01), OLD G.S. NO. 337 (1 TO 4), 215/4,NEAR AKT SCHOOL, DURUGAM ROAD,
LAKSHMIPURAM, PEELAMEDU, COIMBATORE, VILLAGE - PERIYA KANANGAKUPPAM, RS NO. 259/11A,10,9,8,, SATHY ROAD, PERIYA NEAR DOORDARSHAN BLDG,
TAMIL NADU - 641004 CUDDALORE - 607 001 SEMUR VILLAGE, ERODE,TAMILNADU - 638003 NEELAMANGALAM VILLAGE., KALLAKURICHI
PH :0422-383220. PH :7338884131. PH :9171791991. TALUK & DIST., TAMILNADU - 606 202
2044. SREE SARADHAMBAL AUTOMOBILES PVT LTD CUMBUM 2065. SRICITY AUTO (H702-H7-02), R.S. NO:1098/3, PH :9047514890.
(4103-41-0D), 98/1 VILANKURICHI MAIN ROAD, VINAYAGAR KOVIL STREET, TELEPHONE 2074. S M CARS (CHG2-CHG-01), SF: 31/3B, NO. 19
2056. MEENAKSHI AUTO ZONE PVT. LTD.
THANEER PANDAL ROAD, COIMBATORE - NAGAR, POONDURAI MAIN ROAD, ,ERODE, EMAPPER VILLAGE, KALLAKURICHI,
(CJS1-CJS-01), PATTA NO. 4388, SURVEY NO.
641004 TAMILNADU - 638002 TAMILNADU - 606213
1003/2 & 1003, VILLAGE - UTHAMAPURAM, SUB
PH :9655345775. PH :9626671444. PH :7094440010.
DIST.-CUMBUM, TAMIL NADU. - 625516
2045. AADHI CARS PVT. LTD. (4108-41-01), SURVEY GOBICHETTIPALAYAM KANCHEEPURAM
PH :9940094881.
NO.469/2,DOOR NO: 46-2,SATHY MAIN ROAD,
DEVAKOTTAI 2066. SREE SARADHAMBAL AUTOMOBILES PVT LTD 2075. GANESH CARS PVT. LTD. (C601-JA-02), ANBU
RAMAKRISHNAPURAM, GANAPATHY,
(H701-QM-03), NO. 318, CUTCHERY, NAGAR, DHIMMA SAMUDRAM POST, NEAR
COIMBATORE - 641035 2057. SIVA AUTOMOTIVE TRADING PVT LTD
GOBICHETTIPALAYAM - 638476 VELLA GATE, CHENNAI BANGALORE NH-4,
PH :0422-4000600. (GKV1-GKV-01), SURVEY NO. 5/1A, MULL
PH :9597560777. KANCHEEPURAM - 631502
2046. ABT LIMITED (4101-41-0D), 36-A GANDHI IGUNDU (SOMANENTHAL VILLAGE),
GUDIYATHAM PH :9842306061.
NAGAR, SUNDARAPURAM, COIMBATORE (DIST) DEVAKOTTAI TALUK, SIVAGANGAI
COIMBATORE - 641024 DISTRICT,TAMILNADU - 630 303 2067. GANESH CARS PVT. LTD. (CQW1-CQW-01), KANGAYAM
PH :78457 74069. PH :7094688870. SURVEY NO.250/1, NEAR NH-75, GANDHI 2076. SREE SARADHAMBAL AUTOMOBILES PVT LTD
2047. AADHI CARS PVT. LTD. (4108-41-02), NEAR DHARAPURAM NAGAR, SETHUVADAI, GUDIYATTAM. - 653803 (GJI1-GJI-01), NO. 407/263, TIRUPPUR ROAD,
KOVAI MEDICAL CENTRE & HOSPITAL, PH :04171-290172. KANGAYAM TALUK & TOWN, TIRUPPUR DIST.
AVINASHI ROAD, CIVIL AERODROME POST, 2058. SREE SARADHAMBAL AUTOMOBILES PVT LTD
GUDUVANCHERY ,TAMIL NADU. - 638701
CHINNIYAMPALAYAM, COIMBATORE - 641004 (H701-QN-04), OPP. TO ANJANEYAR TEMPLE,
PH :7708531777.
PH :0422-3007701. NEAR FIVE CORNER, MADURAI ROAD, 2068. VISHNU CARS PVT. LTD. (BAD1-BAD-01), 52,
DHARAPURAM - 638656 THAILAVARAM VILLAGE, BEHIND HOTEL KARAIKUDI
2048. AADHI CARS PVT. LTD. (4108-41-03), NO.71, OLD
SRIRAM THEATRE COMPLEX, MARUDHA MALAI PH :9597550777. PATTIKADU, GUDUVANCHERRY, 2077. ABT LIMITED (4202-HX-05), 42-43 KOVILOOR
MAIN ROAD, VADAVALLI, COIMBATORE - 641041 DHARMAPURI KANCHEEPURAM DISTT. - 603203 ROAD, OPP. TNSTC DEPOT - 630302
PH :0422-3000201. PH :9500121553/ 9677122225. PH :4565-232484, 232486..
2059. SRI AMMAN CARS INDIA PVT. LTD.
2049. AADHI CARS PVT. LTD. (4108-41-04), PLOT (7Q01-5R-02), NEAR COLLECTOR BUNGALOW, GUMMIDIPOONDI KARUMATHAMPATTI
NO.295, RADHA RANI THEATER COMPLEX, OLD HOSUR ROAD, JETTIHALLI (PO), 2069. RAJALAKSHMI CARS PVT. LTD. (BIZ1-BIZ-01), 2078. SREE SARADHAMBAL AUTOMOBILES PVT LTD
NEAR JAYASHANTHI THEATER, TRICHY ROAD, DHARMAPURI , TAMILNADU - 636807 PLOT NO. F-13, SURVEY NO. 262/2, SIPCOT (CJQ1-CJQ-01), SF: NO.281/B, NEAR BHARAT
ONDIPUDUR, COIMBATORE-. - 641005 PH :9750938892/ 9159086222. INDUSTRIAL COMPLEX, VILLAGE – PETROL BUNK, VILLAGE - VAGUTHANKADU,
PH :0422-4000777. PAPPANAKUPPAM, GUMMIDIPONNDI, SOMANUR ROAD, KARUMATHAMPATTI TOWN,
DINDIGUL
2050. SREE SARADHAMBAL AUTOMOBILES PVT LTD THIRUVALLUR - 601201 TALUK-PALLADAM, DISTT. COIMBATORE. -
(4103-41-0E), PLOT NO. 210, PALAKAD ROAD, 2060. PLA MOTORS (S401-S4-01), NO. 5, TRICHY
PH :044-27922060. 641659
BK PUDUR, COIMBATORE, TAMIL NADU. - MADURAI BY PASS ROAD, NH-45, DINDIGUL -
HARUR PH :9159210008.
641008 624001
PH :7010075200. 2070. SRI AMMAN CARS INDIA PVT. LTD. KARUNGAL
PH :0422-2251225.
2051. AADHI CARS PVT. LTD. (4108-41-06), SF NO. EDAYARPALAYAM, COIMBATORE (AAV1-AAV-01), 429/9, HARUR SALEM MAIN 2079. ATHEN (SGE1-SGE-01), SURVEY NO. 639/5,
14/78-A, RENUKA SHELTERS, VILANKURICHI ROAD, HARUR POST, DHARMAPURI, TAMIL KARUNGAL TOWN, VILAVANCODE TALUK,
2061. SREE SARADHAMBAL AUTOMOBILES PVT LTD
MAIN ROAD, KALAPATTI, COIMBATORE, TAMIL NADU - 636903 KANYAKUMARI DISTRICT, TAMILNADU - 629157
(CJK1-CJK-01), SITE NO. 2, SY. NO. 404/1A1,
NADU-641048. - 641 006 PH :8220014360/7339071500. PH :7094434179.
THADAGAM ROAD, TVS NAGAR,
PH :8754045840.
EDAYARPALAYAM, COIMBATORE. - 641025 HOSUR KARUNGALPALAYAM, ERODE
2052. SREE SARADHAMBAL AUTOMOBILES PVT. LTD.
PH :9047081914. 2071. SRI AMMAN CARS INDIA PVT. LTD. 2080. SREE SARADAMBAL AUTOMOBILES PVT. LTD.
(4103-41-11), PLOT NO. 1, RAJA STREET,
ERODE (7Q01-7Q-01), P.O.- PERANDAPALLI,NH-7, (H701-H7-08), RF. NO. 17/1, 2, CAVERI ROAD,
KALLIMADAI, NANJAPPA NAGAR, COIMBATORE,
KRISHNAGIRI MAIN ROAD, HOSUR, TAMILNADU KARUNGALPALAYAM, ERODE ,TAMILNADU -
TAMIL NADU - 641005 2062. SREE SARADHAMBAL AUTOMOBILES PVT LTD
- 635109 638003
PH :9344870035. (H701-H7-01), 23/1, PERUND, URAI ROAD,
PH :9790036377/8883259555. PH :8098825000.
COONOOR ERODE, - 638011
PH :9677987777. IDAPPADI KARUR
2053. SREE SARADHAMBAL AUTOMOBILES PVT LTD
2063. SREE SARADHAMBAL AUTOMOBILES PVT LTD 2072. THRIVENI CAR COMPANY PVT LTD. (HI01-HI-01), 2081. ABT LIMITED (K401-K4-01), SF NO. 529/1, SALEM
(3G01-3G-01), 78 E, BRINDAVAN SCHOOL ROAD,
(H701-H7-06), SURVEY NO. 1363/3, 1363/5, SURVEY NO.330/3B1B, AVANI PERUR BY PASS,ROAD, VENGAMEDU CIRCLE,
CONOOR, NILGRIS DIST- TN - 643102
1363/6, BEHIND MANIKAVASAKAR COLONY BUS KILMUGAM VILLAGE, IDAPPADI DISTT. SALEM - SEMMADAI - 639002
PH :95852 77775.
STOP, OPPOSITE TO CANARA BANK, KARUR 637101 PH :04324-222261/62/63.
CUDDALORE BYPASS ROAD, SOLAR, ERODE. - 638 002 PH :9003311488. KATPADI
2054. ABT LIMITED (5Q01-5Q-01), K. V. SUBRAMANIAM PH :6385805777. KALLAKURICHI 2082. GANESH CARS PVT. LTD. (C601-APA-04), 170/2B
NAGAR, CHIDAMBARAM MAIN ROAD,
THIRUVALLAM ROAD, ARUMPARUTHI VILLAGE,
CUDDALORE O. T - 607003
KATPADI, VELLORE DISTT. - 632004
PH :04142-224567.
PH :9842313139.

63
Dealer Workshop (AS ON 31.05.2023 )

KATTUMANNARKOIL 2092. ABT LIMITED (4202-42-04), 09, 109A, GST ROAD, 2102. PILLAI AND SONS MOTOR COMPANY NAGARCOIL
TIRUPARANKUNDRAM, MADURAI - 625005 (SKW1-SKW-01), PLOT NO.262, TRICHY
2083. VISHNU CARS (SKG1-SKG-01), SURVEY NO. 6& 2111. ATHEN (S503-S5-01), RESURVEY NO. G.3/9-7,
PH :9600966164. DINDIGUL BYPASS ROAD, VENGAIKURUCHI
7, PERIYAKULAM VADA KARAI, OPP TO BUILDING NO. 254-A/3 & 4 K.P ROAD
2093. SIVA AUTOMOTIVE TRADING PVT. LTD. VILLAGE,MANAPPARAI, TRICHY,TN - 621307
GNANAVINAYAGAR KOIL, KATTUMANNARKOIL ,PARAVATHIPURAM, NAGERCOIL
(4205-42-01), 2C, GATE LOCK ROAD, NEAR NEW PH :8489900908.
TOWN AND TALUK, CUDDALORE DIST., ,KANYAKUMARI DISTRICT TAMILNADU - 629003
RAMNAD ROAD, MADURAI - 625016 MANGALAPURAM
TAMILNADU - 608301 PH :8012029777.
PH :7402780000.
PH :7358004555. 2103. SREE SARADHAMBAL AUTOMOBILES PVT LTD NAMAKKAL
2094. SIVA AUTOMOTIVE TRADING PVT. LTD.
KELAMBAKKAM (CLX1-CLX-01), DOOR NO. 1/518, SURVEY NO.
(4205-42-02), NO. 6-A, TPK ROAD, NEAR 2112. SREE SARADHAMBAL AUTOMOBILES PVT LTD
75/1, ATTUR MAIN ROAD, MANGALAPURAM
2084. CRESCO (A UNIT OF NEXGEN VENTURE PVT SAIBABA TEMPLE, ANDALPURAM, MADURAI. - (X401-X4-01), SURVEY NO. 1/10-11, NEAR
(POST), TALUK – RASIPURAM, DISTRICT –
LTD) (SJV1-SJV-01), AGP MAHAAL, SURVEY 625003 MURUGAN TEMPLE, SALEM ROAD, NAMAKKAL -
NAMAKKAL. - 636202
NO.43, OMR, 60 FEET VEERANAM HIGH ROAD, PH :7402788840. 637001
PH :7094447871.
PADUR, KELAMBAKKAM, CHENGALPATTU 2095. ASIR AUTOMOBILES PVT LTD (4206-42-01), D. PH :937164888.
DISTRICT, TAMIL NADU - 603 103 NO. 28/5B, MELUR MAIN ROAD, UTHANKUDI, MANNARGUDI 2113. SREE SARADHAMBAL AUTOMOBILES PVT LTD
PH :7305087002. MADURAI. - 625107 2104. PILLAI & SONS MOTOR CO. (BKR1-BKR-01), NO. (X401-X4-03), 1/412/1 NEAR PON NAGAR,
KINATHUKADAVU PH :9944059911. 37, THIRUTHURAIPOONDI ROAD, MUDALAIPATTY, SALEM ROAD, NH-7,
2096. MEENAKSHI AUTO ZONE PVT. LTD. MANNARGUDI, THIRUVARUR DISTRICT, TAMIL NAMAKKAL (TAMIL NADU) - 637001
2085. AADHI CARS PVT. LTD. (BBI1-BBI-01), NO.212, (4207-42-01), PLOT NO. 25 D, SIDCO NADU. - 614001 PH :737192888.
KAMARAJ NAGAR, SOLAVALAM PALAYAM INDUSTRIAL ESTATE, KAPPALUR, MADURAI, PH :7094411675. NATRAMPALLI
PANJAAYATH, KINATHUKADAVU DISTT. TAMIL NADU. - 625008
COIMBATORE (T.N.) - 642109 MAYILADUTHURAI 2114. GANESH CARS PVT. LTD. (SPR1-SPR-01),
PH :9442799581.
PH :0422-3000506/ 3000505. 2097. MEENAKSHI AUTO ZONE PVT. LTD. 2105. PILLAI & SONS MOTOR CO. (E701-AG-04), NO:8/12-1, NEAR ARJUNA SULOCHANA MAHAL,
KODUMUDI (4207-42-02), SURVEY NO. 238/2A, PLOT NO. 36, 46,VELLALAGARAM VILLAGE, BENGALURU- CHENNAI MAIN
37, 38, TALLAKULAM VILLAGE, SIVAGAMI MAYILADUTHURAI, TAMILNADU - 609007 ROAD,VELAKALNATHAM, NATRAMPALLI,
2086. SREE SARADHAMBAL AUTOMOBILES PVT LTD
NAGAR, NATHAM MAIN ROAD, MADURAI - 652 PH :04364-251767, 251765, 9442141703. TIRUPATTUR DIST. TAMIL NADU - 635854. -
(CUY1-CUY-01), SURVEY NO.548/A, KARUR
014 MECHERI 635854
MAIN ROAD, NEAR BUS STAND, KODUMUDI. -
PH :9940224881. PH :73977 53146.
638151 2106. SM CARS (CVK1-CVK-01), SURVEY NO. 139A/5,
PH :8754756777. MADURANTHAKAM PATTA NO. 653, AMANI M.KALIPATTY VILLAGE, NEGAMAM
KOTAGIRI 2098. AIE CARS (A UNIT OF AI ENTERPRISES PVT MECHERI TOWN, METTUR TALUK, SALEMN 2115. ABT LIMITED (CHD1-CHD-01), 68, 69, ABT BUS
LTD) (CEW1-CEW-01), SURVEY NO. 38/3 A2B, DIST., TAMIL NADU. - 636 453 STAND, PALLADAM ROAD, PERIA NEGAMAM,
2087. AADHI CARS PVT. LTD. (BAS1-BAS-01), SURVEY
NH-45, MADURANTHAKAM, KANCHIPURAM. - PH :7094440010. POLLACHI, TAMIL NADU - 642120
NO.89/79, OOTY MAIN ROAD, KOTAGIRI, DISTT.
603306 MELUR PH :99948 76794.
NILGIRIS, TAMIL NADU. - 643217
PH :8754045891/ 8754045442. PH :7401212797. 2107. SIVA AUTOMOTIVE TRADING PVT. LTD. OMALUR
KOVILPATTI MALLASAMUDRAM (CHC1-CHC-01), OLD SN. 138/1, SURVEY WARD 2116. SRI AMMAN CARS INDIA PVT. LTD.
2099. SREE SARADHAMBAL AUTOMOBILES PVT LTD C, BLOCK NO. 1, T.S. NO. 21/7, VILLAGE AND (7Q01-UM-04), 123, 3B, NH-7, BANGALORE BYE
2088. ASIR AUTOMOBILES PVT LTD (NO01-NO-01),
(CWY1-CWY-01), SF NO. 194/3C, TOWN – MELUR, MELUR , DIST.-MADURAI. - PASS ROAD, KOTTAMETTUPATTI, OMALUR,
OLD NO.1, NEW NO.13, SATTUR MAIN ROAD,
MALLASAMUDRAM MAIN ROAD, 625109 SALEM (DIST.), TAMIL NADU - 636012
KOVILPATTI (TAMIL NADU) - 628501
MALLASAMUDRAM TOWN, TIRUCHENGODE PH :8098120000. PH :8220010070/8883529888.
PH :4632-232220.
TALUK, NAMAKKAL DIST., TAMIL NADU. - 637503 METTUPALAYAM 2117. THRIVENI CAR COMPANY PVT LTD.
KRISHNAGIRI (UM01-UM-01), PLOT NO. 44 & 45, PALANIYAPPA
PH :9894932019. 2108. ABT LIMITED (4101-EU-0C), PLOT NO. 6 TO
2089. SRI AMMAN CARS INDIA PVT. LTD. NAGAR LAYOUT, NH-7, KAMALAPURAM
MALLUR 9,PONVIZHA NAGAR, KARAMADAI KOVAI MAIN
(7Q01-QL-03), NH-7,NR. AAVIN VILLAGE, OMALUR, DISTRICT – SALEM, TAMIL
2100. THRIVENI CAR COMPANY PVT LTD. ROAD, METTUPALAYAM - 641043
DAIRY,MOTTUR,SALEM BYE PASS ROAD, NADU - 636309
(CDH1-CDH-01), SURVEY NO.50/4A, AMANI PH :95009 45094.
KRISHNAGIRI, TAMILNADU - 635001 PH :4290-222711.
PH :9500202416/ 8220004270. AMMAPALAYAM VILLAGE, DISTT.: MINJUR OOTY
DADHAGAPATTY SUB REGISTRATION , 2109. RAJALAKSHMI CARS PVT. LTD. (BPE1-BPE-01),
KUMBAKONAM 2118. SREE SARADHAMBAL AUTOMOBILES PVT LTD
MALLUR DISTT. SALEM - 636309 PLOT NO. 27, SRI JANAKI RATHINA NAGAR,
2090. PILLAI & SONS MOTOR CO. (E701-N4-02), 369/2 PH :0427-2422399. (4103-Y1-05), VIJAYANAGARAM FARM ROAD,
VILLAGE AND TOWN – MINJUR, PONNERI – 601
B, KUMBAKONAM CHENNAI MAIN ROAD, NEAR ROSE GARDEN, OOTY - 643001
MANAMADURAI 203, DISTRICT – THIRUVALUR. - 601203
KUMBAKONAM , TANJAVUR - 612501 PH :97511 09229.
2101. ABT LIMITED (CHF1-CHF-01), NO. 35, OLD PH :044-27933331.
PH :0435-2442566, 2442565, 9443264696. P.N. PALAYAM, COIMBATORE
RAMNAD ROAD, MANAMADURAI TOWN, NAGAPATTINAM
MADURAI 2119. JAIKRISHNAA AUTOSALES PVT. LTD.
DISTRICT – SIVGANGAI. - 630606 2110. PILLAI & SONS MOTOR CO. (CQQ1-CQQ-01),
2091. ABT LIMITED (4202-42-02), MADURAI-DINDIGAL PH :9994450331. (4107-OH-04), NO.12/190 SRKV PORT, MTR
NO.181, KEELA ANTHANAPETTAI,
BYE PASS ROAD,NEAR FATHIMA ROAD, P.N. PALAYAM, COIMBATORE - 641020
MANAPPARAI ANTHANAPETTAI, P.O. - MANJAKOLLAI,
COLLEGE,MADURAI - 625018 PH :0422-698899.
PUTHUR, NAGAPATTINAM DISTT. TAMIL NADU -
PH :9994400615.
611106 PADAPPAI
PH :4365220250.

64
Dealer Workshop (AS ON 31.05.2023 )
2120. VISHNU CARS PVT. LTD. (CRO1-CRO-01), 2128. SREE SARADHAMBAL AUTOMOBILES PVT LTD 2136. SIVA AUTOMOTIVE (SKI1-SKI-01), NO:2307, 2145. AADHI CARS PVT. LTD. (BXS1-BXS-01), PLOT
SURVEY NO.368/2A/1, 368/2A/2, (BTX1-BTX-01), SF NO.542/1, KOVAI MAIN ROAD, SURVEY NO:279/3A, RAMNAD ROAD, NO. 132/H, OPPOSITE TO NEW TALUK OFFICE,
VANDALLUR-WALAJABAD MAIN ROAD, PERUNDURAI VILLAGE, PERUNDURAI DISTT. ARIYANKADU, RAMESHWARAM, TIRUVENGADAM ROAD, SANKARANKOVIL. -
PADAPPAI EAST, CHENNAI. - 601301 ERODE, TAMIL NADU - 638052 RAMANATHAPURAM DISTRICT, TAMILNADU - 627756
PH :8754417168. PH :9597490777. 623529 PH :7397728025.
PALANI POCHAMPALLI PH :7402788898. SATHY ROAD, ERODE
2121. PLA MOTORS (S401-GLR-02), NO:13-1-11C-1, 2129. SRI AMMAN CARS PVT. LTD. (CUW1-CUW-01), RANIPET 2146. SREE SARADAMBAL AUTOMOBILES PVT. LTD.
WEST AYAKUDI, DINDIGUL ROAD, PALANI, NEW SURVEY NO. 561/5, VILLAGE – 2137. GANESH CARS PVT. LTD. (CJJ1-CJJ-01), (H701-H7-09), SF:N0:245, KANDHAIYAN
DINDIGUL DISTRICT, TAMIL NADU - 624613 JUMBUKUTTANPATTI, POCHAMPALLI, SURVEY NO. 44/1, PLOT NO. 484, OPPOSITE TO THOTTAM, SOOLAI, SATHY ROAD,
PH :04545-290900. KRISHNAGIRI. - 635206 THIRUMALAI CHEMICALS, SIPCOT LAYOUT OF VEERAPPANCHATTIRAM, ERODE, TAMILNADU -
PARAMATHIVELUR PH :9600466988. HOUSE SITES, SIPCOTS INDUSTRIAL 638004
POLLACHI COMPLEX, RANIPET , TAMIL NADU. - 632403 PH :9655240486.
2122. SREE SARADHAMBAL AUTOMOBILES PVT LTD
PH :9842330388. SATHYAMANGALAM
(CC01-CC-01), SURVEY NO. 171, NEAR KONGU 2130. ABT LIMITED (L301-L3-01), NACHIMUTHU
SCHOOL, NAMAKKAL BYPASS ROAD, POLYTECHNIC CAMPUS, UDUMALPET ROAD, RASIPURAM 2147. SREE SARADHAMBAL AUTOMOBILES PVT LTD
PADAMUDI PALAYAM, TALUKA – POLACHI - 642003 2138. SREE SARADHAMBAL AUTOMOBILES PVT LTD (BGU1-BGU-01), SURVEY NO. 51, 54 & RS NO.
PARAMATHIVELUR, NAMAKKAL , TAMIL NADU. - PH :99944 53265. (BSJ1-BSJ-01), SURVEY NO:41/1 B1A, 37, KOTTUVEERAMPALAYAM VILLAGE,
638182 POLUR MOOLAKADU VILLAGE, MASAKALIPATTI, SATHYAMANGALAM – 638 401, DISTRICT –
PH :8870666599. SALEM MAIN ROAD, RASIPURAM DISTT. ERODE, TAMIL NADU - 638401
2131. GANESH CARS PVT. LTD. (GLV1-GLV-01),
PATTUKKOTTAI NAMAKKAL - 637401 PH :9597592777.
AZHAGO COMPLEX, SURVEY NO:77/1,
PH :4286-231402/7539972888. SATTUR
2123. PILLAI & SONS MOTOR CO. (CJA1-CJA-01), CUDADALOR TO CHITTOOR ROAD, POLUR,
SURVEY NO. 85/6, 85/4, 84/6, DOOR NO.314/11, THIRUVANNAMALAI DISTRICT,TAMILNADU - SALEM 2148. MEENAKSHI AUTO ZONE PVT. LTD.
SRI JANAGALAKSHMI NAGAR, THANJAVUR 606803 2139. ABT LIMITED (4101-A2-03), 32 THAMANA (SDR1-SDR-01), SURVEY NO.
ROAD, ALADIKUMULAI VILLAGE, TALUK PH :9842345200. CHETTY ROAD, ARISIPALAYAM, SALEM - 18/10,CHATRAPATTI VILLAGE, MADURAI
PATTUKOTTAI, THANJAVUR. - 614615 PUDUKOTTAI 636009 KANYAKUMARI NATIONAL HIGHWAYS,
PH :7094433074. PH :0427-4066988, 406999. SATTUR, VIRUDHUNAGAR
2132. PLA MOTORS (2305-5U-02), NO. 10,
PAVITHRAM 2140. THRIVENI CAR COMPANY PVT. LTD. DISTRICT,TAMILNADU - 626203
MARIAMALAI NAGAR, ALANGUDI- THIRUMAYAM
(A203-A2-01), 12/2E1, SUBRAMANIA NAGAR, PH :9940094881.
2124. SREE SARADHAMBAL AUTOMOBILES PVT LTD ROAD, PUDUKOTTAI, - 622003
2ND GATE, JUNCTION ROAD, SALEM. - 636005 SEYDUNGANALLUR
(TWT1-TWT-01), SURVEY NO. 102/1B, PH :04322-265566/67.
PH :0427-2440000.
NAMAKKAL MAIN ROAD, PAVITHRAM - 637 021 PUNJAI PULIAMPATTI 2149. ASIR AUTOMOBILES PVT LTD (S603-GJG-02),
2141. S.M.CARS PVT. LTD. (A204-A2-01), SF NO.
PH :9600320888. SURVEY NO. 59/3E, TIRUCHENDUR ROAD,
2133. SREE SARADHAMBAL AUTOMOBILES PVT LTD 64/2C3, ATTUR SALEM BYPASS ROAD,
PENNAGARAM SEYDUNGANALLUR TOWN, TALUK -
(BKO1-BKO-01), SURVEY NO. 250/1, PANKAU PINANGUKARAR THOTTAM,
SRIVAIKUNTAM, TUTICORIN DIST., TAMIL
2125. SRI AMMAN CARS INDIA PVT. LTD. PULIYAMPATTU MUNICIPALITY, PUNJAI SEELANIKANPATTY, SALEM. - 636202
NADU. - 628809
(BXZ1-BXZ-01), SURVEY NO. 419/1, VILLAGE – PULIYAMPATTI - 638459, SATHY THALUK, PH :7094448000, 7034449000.
PH :8344992220.
PARUVADHANAALLI, PENNAGARAM, ERODE. - 638459 2142. THRIVENI CAR COMPANY PVT. LTD.
DHARMAPURI. - 636810 PH :6385810777. (A203-A2-03), SURVEY NO. 57, VILLAGE - SHOLINGUR
PH :9715044700. RAJAPALAYAM MASINAICKENPATTY, AYOTHIAPATTINAM, 2150. GANESH CARS PVT. LTD. (GLU1-GLU-01),
PERAMBALUR AMMAPET, SALEM. - 636103 NO:401, ARAKKONAM MAIN ROAD,OPPOSITE
2134. MEENAKSHI (5V02--01), DOOR NO. 96, COTTON PH :0427-2291000. TVS FOUNDARY,
2126. PLA MOTORS (2305-DQ-04), SURVEY NO.88/1, MARKET, TENKASI-MADURAI ROAD, 2143. S M CAR PRIVATE LIMITED (A204-A2-02), DOOR PANDIYANELLORE,SHOLINGHUR,WALAJA
A3,NH45, ELAMBALUR VILLAGE, PERAMBALUR, RAJAPALAYAM, VIRUDHUNAGAR DIST., NO. 50/28, SF NO. 1/10B, SARADHA COLLEGE TALUK, RANIPET DISTRICT, TMILANADU -
TAMILNADU - 621212 TAMILNADU - 626117 MAIN ROAD, ALAGAPURAM PUDHUR VILLAGE, 631102
PH :8870004960. PH :9443785681. HASTHAMPATTY, SALEM, TAMILNADU - 636007 PH :7397395259.
PERNAMBUT RAMANATHAPURAM PH :7094440053. SIVAKASI
2127. SRI AMMAN CARS INDIA PVT LTD (CODE 2135. SIVA AUTOMOTIVE TRADING PVT. LTD. SANKAGIRI
2151. MEENAKSHI AUTO ZONE PVT. LTD.
UNDER CREATIONS-CODE UNDER (0U02-0U-01), SURVEY NO. 172/1B2C, 172/2C, 2144. THRIVENI CAR COMPANY PVT LTD. (X602-X6-01), 372 D & E, ARUNACHALAM
CREATIONS-CODE UNDER CREATIONS), VILLAGE - ACHUNTHANVAYAL, (BTN1-BTN-01), SURVEY NO.171/5B, KCK COMPLEX, THIRUTHANGAL ROAD, SIVAKASI. -
SURVEY NO:708,PLOT NO: 87,88 & 89, ACHUNTHANGAL GROUP, TALUK - PLAZA, KACHERIDADU, DEPUTY COLLETCTOR 626123
PERNAMBUT TO GUDIYATTAM ROAD, RAMANATHAPURAM, RAMANATHAPURAM. - ROAD, SALEM, SANKAGIRI (TAMIL NADU) - PH :4562-231281.
PERNAMBUT,VELLORE DISTRICT, TAMIL NADU 623502 637301
- 635810 - 635810 PH :8098110000. SRIPERUMBUDUR
PH :+914283242600
PH :7094403100. RAMESHWARAM +914283242601. 2152. RAJALAKSHMI CARS PVT. LTD. (7B01-7B-01),
PERUNDURAI SURVEY NO. 150/1A, DOOR NO 1C, THERADI
SANKARANKOVIL
STREET, NEW VILLAGE NO 42,
SRIPERUMBADUR, KANCHEEPURAM DISTRICT,
TAMIL NADU. - 602105
PH :8939995469.

65
Dealer Workshop (AS ON 31.05.2023 )

SRIVILLIPUTHUR (RAJAPALYAM) 2162. KHIVRAJ MOTORS PVT LTD. (1404-HH-04), 2151, 2171. SREE SARADHAMBAL AUTOMOBILES PVT LTD TONDI
KAKKULUR ROAD, THIRUVALLUR - 602001 (X401-QP-02), PLOT NO-10, OPP TO
2153. ABT LIMITED (4202-5V-03), NO. 10/32, 2181. SIVA AUTOMOTIVES (SHW1-SHW-01), SURVEY
PH :99520 78443. PONNUSWAMY KALYANA MANDAPAM,
PADIKKASUVAITHANPATTI , NEAR RTO NO: 85/16, WARD 10/78, SOUTH THOPU
2163. KHIVRAJ MOTORS PVT LTD. (1404-HH-05), PLOT KOOTAPALLI COLONY, TIRUCHENGODE -
OFFICE, SRIVILLIPUTHUR, VIRUDHUNAGAR, STREET, ECR MAIN ROAD, ECR, THONDI,
NOS.218,219,220,225,226,227.228 AND 637001
TAMIL NADU - 626125 RAMANATHAPURAM DISTRICT, TAMIL NADU -
S.NOS.18/5,18/6, EMPIRE CITY PART-3, PH :4288-282292.
PH :95009 05020. 623409
KAKKALLUR VILLAGE, THIRUVALLUR THALUK, TIRUNELVELI
SULUR PH :7402788820.
THIRUVALLUR - 602001
2172. AADHI CARS PVT. LTD. (A303-A3-01), PLOT NO. TRICHY
2154. JAIKRISHNAA AUTOSALES PVT. LTD. PH :97103 94818.
261, MADURAI MAIN ROAD, KARAIERUPPU,
(4107-TK-05), DOOR NO. 37 F, THIRUVANNAMALAI TIRUNELVELI , TAMIL NADU - 627357
2182. ABT LIMITED (2302-23-02), 4/40, COLLECTOR
RANGANATHAPURAM, TRICHY ROAD, SULUR - OFFICE ROAD, CANTONMENT, TRICHY - 620001
2164. GANESH CARS PVT. LTD. (C601-LX-03), NO.-5, PH :9500991610.
641 402 PH :0431-4221620.
NH-78, KRISHANAGIRI PONDY ROAD, CHINA 2173. AADHI CARS PVT. LTD. (A303-A3-03), DOOR NO.
PH :0422-3199901. 2183. PLA MOTORS (2305-23-01), NO. 18/2, NA-45,
KANKEYANUR, OPP SKP ENGG. COLLEGE, 37, RAMNAGAR, KTC NAGAR, TIRUNELVELI,
TENKASI DHEERAN NAGAR, TRICHY-DINDUGAL MAIN
THIRUVANNAMALAI - 606601 TAMIL NADU. - 627 011.
ROAD, TRICHY - 620009
2155. AADHI CARS PVT. LTD. (BXR1-BXR-01), DOOR PH :9842305072. PH :9500991610.
PH :9994599777/9600950960.
NO. 3/50-1, SURVEY NO. 447B, TIRUNELVELI THIRUVARUR TIRUNVELI 2184. ABT LIMITED (2302-23-03), MADRAS TRUNK
MAIN ROAD, VILLAGE – KUNARAMANALLUR,
2165. PILLAI & SONS MOTOR CO. (E701-LJ-03), 2174. AADHI CARS PVT. LTD. (A303-A3-04), SF ROAD, MAMBALASALAI, TRICHY - 620005
TENKASI. - 627814
THANJAI NAGARI ROAD, OPP. TO S. P. OFFICE NO:161/4, SF NO: 893/2, NORTH BYEPASS PH :0431-4221555.
PH :9500991475.
- 610001 ROAD, GALAXY HOSPITAL BACKSIDE, 2185. PLA MOTORS (2305-23-03), 10A & B, ALXANDRIA
2156. AADHI CARS PVT. LTD. (BXR1-BXR-02), DOOR
PH :04366-250250, 9442163707. PALAYANKOTTAI, TIRUNELVELI, TAMILNADU - ROAD, CANTONMENT, TRICHY - 620001
NO. 47, MADHALAMPARAI, TENKASHI AMBAI
2166. PILLAI & SONS MOTOR COMPANY (LJ01-LJ-01), 627001 PH :0431-2411540/530.
HIGHWAY, TENKASHI, TIRUNELVELI DIST.,
NO. 9, WARD NO.-4, BLOCK NO. 10, NEW SY. PH :95009 91479. 2186. PILLAI & SONS MOTOR CO. (2306-23-01),
TAMILNADU. - 627 814
NO. 601/6B1, SUNDARAVILAGAM, TIRUPATHUR SURVEY NO. 10B, 1A/D, CHENNAI TRICHY
PH :9500991475.
NARSINGHAMPET, THIRUVARUR TOWN & BY-PASS ROAD, VILLAGE - THIRUNALLUR,
THAMMAPATI 2175. GANESH CARS PVT. LTD. (BPD1-BPD-01),
DIST., TAMIL NADU - 610001 TRICHY. - 620002
SURVEY NO.54/4, TIRUPATHUR TO
2157. SM CARS (SNH1-SNH-01), SURVEY NO # SF: PH :9442163509. PH :8489900902, 9384826814.
KRISHNAGIRI ROAD, PALLIPET VILLAGE,
328/11, NAGIAMPATTI, THAMMAPATTI,SALEM THISAYANVILLAI TIRUPATHUR DISTT. VELLORE - 635601 TUTICORIN
DISTRICT, TAMILNADU - 636113. - 636113
2167. AADHI CARS PVT. LTD. (CVL1-CVL-01), SURVEY PH :9842308909. 2187. ASIR AUTOMOBILES PVT LTD (S603-S6-01),
PH :7094440010.
NO. 240/1, 7/1, HIGHWAYS ROAD, OPP. TO VO TIRUPATTUR( SIVAGANGAI) SURVEY NO. 25/1B, MAPPILLAIURINI VILLAGE,
THANJAVUR OFFICE, SELVA MARUTHUR, THISAYANVILLAI. - ETTAYAPURAM ROAD, TUTICORIN, TAMIL
2176. ABT LIMITED (CHH1-CHH-01), DOOR NO.
2158. PILLAI & SONS MOTOR CO. (E701-E7-01), 12A, 627 657 NADU - 628002
8/2/29A, KARAIKUDI ROAD, TIRUPATHUR,
SELVAM NAGAR, TANJAVUR, TAMILNADU - PH :7339511187. PH :7373501220.
DISTRICT – SIVAGANGAI. - 630211
613007 THUCKALAY PH :9994450331. UDUMALPET
PH :04362-271723, 271724, 9443264164.
2168. ATHENS (BWQ2-BWQ-01), DOOR NO. 5/76B, (RE TIRUPUR 2188. ABT LIMITED (QR01-QR-01), 2/3, PERIYAKOTTAI
THARAMANGALAM SURVEY NO-530/7) THIRUVITHANCODE ROAD, PIRIVU, S.V. MILL POST, UDUMALPET - 642126
2177. ABT LIMITED (4101-Y7-09), NO. 4, SABHAPATHI
2159. THRIVENI (CSQ1-CSQ-01), NO. 1/122, KERALAPURAM, MUTHALAKURICHI, VILLAGE – PH :99944 41645.
PURAM, NEAR TMF HOSPITAL, TIRUPUR -
KATTAMPATTI, JALAKANDAPURAM, MUTHALAKURUCHI, KALKULAM-TALUK, UTHANGARAI
641601
THARAMANGALAM, SALEM DIST. ,TAMIL NADU. THUCKALAY, DISCTRICT – KANYAKUMARI,
PH :95009 98368. 2189. SRI AMMAN CARS INDIA PVT. LTD.
- 636501 TAMILNADU - 629174
2178. SHASHTI CAR PVT LTD (Y701-Y7-01), SRI (CFY1-CFY-01), SURVEY NO. 104/1, 104/1B,
PH :9159355999/9003504760. PH :8012029888.
PADMINI GARDENS, KANGEYAM ROAD, OPP. VILLAGE – THANDIYAPANNUR, UTHANGARAI,
THENI THURAIYUR ST JOSEPH SCHOOL, TIRUPUR - 641604 KRISHNAGIRI. - 635304
2160. MEENAKSHI AUTO ZONE PVT. LTD. 2169. PLA MOTORS (CSE1-CSE-01), D.NO.:5/300, PH :044-2430275/ 2430276. PH :9715044600.
(9U02-9U-01), DOOR NO. 871/1, RATHINAM SINGALANDHAPURAM VILLAGE, THURAIYUR TIRUTHANI UTHUKOTTAI
NAGAR, PERIYAKULAM MAIN ROAD, THENI DISTT. TRICHY (TAMIL NADU) - 621010
2179. CARS INDIA PVT. LTD. (CIC1-CIC-01), NO. 9/13, 2190. KHIVRAJ MOTORS PVT LTD. (CUC1-CUC-01),
TOWN, DISTRICT – THENI - 625531 PH :9486763725.
CHENNAI BY PASS ROAD, OLD CHENNAI ROAD, SURVEY NO. 442/1, NEHRU BAZZAR STREET,
PH :9789703881. TIRUCHENDUR DISTT. THIRUVALLUR, TIRUTHANI,TAMILNADU - UTHUKOTTAI, DIST.-THIRUVALLUR - 602 026
THIRUMULLAIVOYAL 2170. ASIR AUTOMOBILES PVT LTD (CCJ1-CCJ-01), 631209 PH :7299635536.
2161. CRESCO (A UNIT OF NEXGEN VENTURES PVT SURVEY NO. 220/1D1A, 221/3, 221/4, 221/5, PH :7358773860. VALLIYUR
LTD). (CDW2-CDW-01), NO. 48, BALAJI NAGAR, 221/5A, 221/5B, PODHIGAI NAGAR, TIRUVANNAMALAI 2191. AADHI CARS PVT. LTD. (BXQ1-BXQ-01), DOOR
NEW SIR IRVANSTADE FORD HOSPITAL, VILLAGE-VEERAPANDIYAPATINAM,
2180. SRI AMMAN CARS INDIA PVT LTD. (LX02-LX-01), NO. 314A/11-14, WITHIN VADAKU VALLIOOR,
THIRUMULAIVOYAL DISTT. CHENNAI - 600062 THIRUCHENDUR, TUTUCORIN. - 628215
2A/2, SURVEY NO. 3676/3, ANNA SALAI, REVENUE VILLAGE, VADAKKU VALLIOOR
PH :7305087044. PH :7373900220.
TIRUVANNAMALAI-CHENNAI NH-101, PANCHAYAT, RADHAPURAM TALUK, VALLIOOR.
THIRUVALLUR TIRUCHENGODE TIRUVANNAMALAI TOWN AND DIST., - 627002
TAMILNADU - 602601 PH :7373091462.
PH :7094471293. VANDAVASI

66
Dealer Workshop (AS ON 31.05.2023 )
2192. GANESH CARS PVT. LTD. (CRN1-CRN-01), 2201. KHIVRAJ MOTORS (1404-14-G1), SURVEY 2209. ASIR AUTOMOBILES (SDC1-SDC-01), S. NO: 2217. VARUN MOTORS PVT. LTD. (BBN1-BBN-01),
SURVEY NO.272, KEELSATHAMANGALAM NO:76/A, NO:27, PLOT NO. D-2, 144/1, SIVAGANGAI-THONDI ROAD, SURVEY NO.277, ARGUL VILLAGE,
VILLAGE, CHETPET ROAD, VANDAVASI, KEELAKOTTAYUR, VANDALUR TO PAIYAURPILLAIVAYAL, JAKARANPALLY (MANDAL), ARMUR,
TIRUVANNAMALAI, DISTT. T.N. - 604408 KELAMBAKKAM MAIN ROAD, MAMBAKKAM, SIVAGANGAI,TAMILNADU - 630561 NIZAMABAD DISTT. (A.P.) - 503224
PH :7395802484. CHENGALPET, CHENNAI,TN - 600127 PH :9750372220. PH :8142281424
VANIYAMBADI PH :9841591558. THANJAVUR 9052901888.

2193. GANESH CARS PVT. LTD. (BJY1-BJY-01), NO. CHETPET 2210. PLA MOTORS FIRM (E702-E7-01), SURVEY NO. BATCHUPALLY , HYDERABAD
197/1B1, NH-46 (AH-7), PETHAKALLUPALLI 2202. GANESH CARS (SGY1-SGY-01), DOOR NO: 35/C, 173/6B4, TRICHY-THANJAVUR ROAD, 2218. SAI SERVICE PRIVATE LIMITED (1011-10-09),
VILLAGE, NEAR TOLL GATE, VANIYAMBADI , CHETPET TOWN, CHETPET TALUKA, NANJIKOTTAI BYPASS, THANJAVUR, SURVEY NO 499/1, MIYAPUR TO BACHUPALLY
VELLORE (DIST), TAMIL NADU. - 635801 TIRUVANNAMALAI DIST.,TAMILNADU, - 606 801 TAMILNADU - 613005 ROAD,BACHUPALLY,HYDERABAD. - 500090
PH :9842327709. PH :98423 06337. PH :9344006433/9344003877. PH :7330771111.
VELLORE CHINNAMANUR THOPPUR BHUPALAPALLY
2194. GANESH CARS PVT. LTD. (C601-C6-01), 91 NEW 2203. ABT LIMITED (SKX1-SKX-01), SF NO. 446 /1A, 2211. SRI AMMAN CARS (SLU1-SLU-01), SITE NO. 422 2219. ADARSHA AUTOMOTIVES PVT LTD
BY-PASS ROAD, VELLORE - 632004 WARD A, BLOCK-2, TS NO.8/15, PERIYAKULAM /2A, BANGALORE TO SALEM HIGH WAY, (D502-BCF-04), 6-113, JAWAHAR NAGAR, MAIN
PH :9842377110. TO CHINNAMANUR MAIN AMMANI, THOPPUR VILLAGE & ROAD, SBH MAIN BRANCH ROAD,
2195. SRI AMMAN CARS INDIA PVT. LTD. ROAD,KEELAPOOLANANDHAPURAM, TOWN,NALLAMPALLI TK, DHARMAPURI BHUPPALPALLY, DISTRICT - WARANGAL,
(C602-C6-01), DOOR NO. 68, SURVEY NO. 66/7, CHINNAMANUR MUNICIPAL TOWN & TALUK, DISTRICT, - 636352 ANDHRA PRADESH - 506169
NEAR RANGALAYA KALYANA MANDAPAM, THENI DIST.,TN- 625515 - 625515 PH :9790004273. PH :7799790526.
VELLORE-KATPADI ROAD, KALINJUR VILLAGE, PH :9715863213. TINDIVARAM BODHAN
KATPADI TALUKA, GANDHINAGAR, VELLORE DENKANIKOTTAI 2212. VISHNU CARS (SDI1-SDI-01), SURVEY NO. 50/4, 2220. VARUN MOTORS PVT. LTD. (O801-O8-01), PLOT
DIST., TAMIL NADU. - 632006
2204. AMMAN CARS (SDT1-SDT-01), SURVEY NO:766/ 50/5 & 63, NEAR RTO OFFICE, MOLASUR, NO. 5/2, ACHANAPALLY CROSS ROAD, OPP :
PH :7094471320, 7094471321.
1B11, THABILAGOUNDAN THOTTI, TINDIVANAM, VILUPPURAM,TAMILNADU - APNA FUNCTION HALL, BODHAN, DIST.
2196. SRI AMMAN CARS INDIA PVT. LTD.
DENKANIKOTTAI , KRISHNAGIRI DISTRICT, 604102 -NIZAMABAD, TELANGANA. - 503 185
(C602-C6-02), SURVEY NO. 316/3B2, 316/8A,
TAMILNADU - 635107 PH :9500039023. PH :9581966691
316/8B, NEAR SHELL PETROL PUMP,
PH :9585599935. TIRUPPUVANAM 8142077222.
MELMONAVUR VILLAGE,VELLORE TALUK &
DIST. ON NH48 (CHENNAI – BENGALURU GANGAVALI 2213. MEENAKSHI AUTO ZONE PVT LTD (CODE CHEVELLA
HIGHWAY), VELLORE, TAMILNADUR - 632010 2205. THRIVENI CARS (SOS1-SOS-01), SURVEY NO # UNDER CREATIONS-CODE UNDER 2221. GEM MOTORS (INDIA) PVT. LTD. (CBL1-CBL-01),
PH :7094471320. SF NO. 22/3A1A,106 ATTUR MAIN CREATIONS-CODE UNDER CREATIONS), SURVEY NO. 17/A, MANDAL – CHEVELLA,
VILLUPURAM ROAD,GANGAVALLI,SALEM, TN - 636105 NO:21,BAKHYA NAGAR, WARD NO:1, DISTRICT – RANGA REDDY, TELANGANA. -
PH :9159722999. MANDAPAM MAIN ROAD, TIRUPPUVANAM, 510101
2197. ABT LIMITED (5Q01-QQ-02), 264/1, GINGEE
KAWALKINARU SIVAGANGA DISTRICT, TAMIL NADU - 630611 - PH :9912899128, 9912834567.
MAIN ROAD, AYINAMPALAYAM, VILLUPURAM -
630611 ETUNAGARAM
605602 2206. AADHI CARS PVT. LTD. (CSU1-CSU-01),
PH :9442799581.
PH :04146-225509 / 225590. SURVEY NO:1943/1, SURESH COMPLEX, 2222. WIN MOTORS (SOJ1-SOJ-01), H.NO 12-412 &
VIRUDHACHALAM KANYAKUMARI BYEPASS ROAD, KAVALKINARU UTHIRAMERUR 12-413,AKULAVARI GHANPUR, ETURNAGARAM,
JUNCTION, KAVALKINARU (VADAKANKULAM), 2214. AIE CARS (SHG1-SHG-01), SURVEY MULUGU DISTRICT,TELANGANA - 506165
2198. ABT LIMITED (BMA1-BMA-01), PLOT NO. 56,
TIRUNELVELI, - 627105 NO:383/3B-B2, UTHIRAMERUR MAIN ROAD, PH :8688828005.
JUNCTION ROAD, NEAR SHANMUGA LODGE,
PH :7339111259. UTHIRAMERUR, KANCHEEPURAM DISTRICT, GADWAL
VIRUDHACHALAM, DISTRICT – CUDDALORE,
KUMBAKONAM TAMILNADU - 603406
TAMIL NADU. - 606101 2223. SRI JAYARAMA MOTORS PVT. LTD.
PH :7299057387.
PH :04143-262631/262632/262633. 2207. PILLAI AND SONS MOTOR CO. (E701-E7-06), D. (WP01-BHR-02), PLOT NO. 5 & 6, BESIDE RURAL
VIRUDHUNAGAR NO. HP-1, GOVT. INDUSTRIAL ESTATE, SIDCO, VELLAKOVIL POLICE STATION, KURNOOL ROAD, MAHABUB
THIRUBHUVANAM TOWN & POST, 2215. SRI CITI AUTO (SGO1-SGO-01), SURVEY NAGAR DISTRICT, ANDHRA PRADESH - 500125
2199. MEENAKSHI AUTO ZONE PVT LTD
KUMBAKONAM, THANJAVUR DISTRICT, NO:502/C &371/D, NO. 196,197,KOVAI KARUR PH :8096990074, 8096996671.
(SCF1-SCF-0A), DOOR NO:6/504, SURVEY NO.
TAMILNADU - 612103 MAIN ROAD, VELLAKOVIL, TIRUPUR DIST. , GAJWEL
11/6, PELAMPATTI VILLAGE,VIRUDHUNAGAR
PH :8489900136. TAMILNADU - 638111
MADURAI HIGH WAY,OPPOSITE TO VVV 2224. ACER MOTORS (A DIVISION OF KRISHNAIAH
NEYVELI PH :9994606000.
COLLEGE. , TALUK & DIST. VIRUDHUNAGAR, MOTORS PVT. LTD) (BYU1-BYU-01), SURVEY
TAMILNADU - 626001 2208. VISHNU CARS (CPN1-CPN-01), SURVEY TELANGANA NO. 220, VILLAGE – PRAGNAYPUR, GAJWEL,
PH :9940094881. NO:545/2A1A, NH-45C, OPP. NATIONAL ADILABAD DISTRICT – MEDAK, TELANGANA . - 502311
TAMILNADU COLLEGE,KUMBAKONAM - CHENNAI HIGH
2216. ADARSHA AUTOMOTIVES PVT LTD
PH :8885088071.
WAY, NEAR NEYVELI ARCH GATE, NEYVELI GHATKESAR
CHENNAI T.S, KEELAKOLLAI, MARUNGUR
(BTM1-BTM-01), SURVEY NO:131/6 & 131/7,
NH-44, ADILABAD TOWN ROAD, MAVALA, 2225. ACER MOTORS (A DIVISION OF KRISHNAIAH
2200. VISHNU CARS (1488-14-01), DOOR NO. 8, NP POST,PANRUTI,CUDDALORE DISTRICT,
ADILABAD, TELANGANA. - 504001 MOTORS PVT. LTD) (BYL1-BYL-01), 3-21,
INDUSTRIAL ESTATE, JAWAHARLAL NEHRU TAMILNADU - 607103
PH :9133307724. JODIMETLA, CHOUDA RIGID VILLAGE
ROAD, EKKATUTHANGAL, CHENNAI,TN - 600032 PH :9384059575.
ARMUR GHATKESAR MANDAL, DISTRICT – RANGA
PH :7550360444. SIVAGANGAI REDDY. - 501301
CHENNAI- MAMBAKKAM PH :8885088075.

67
Dealer Workshop (AS ON 31.05.2023 )

HUSNABAD 2237. VARUN MOTORS PVT. LTD. (4603-10-0A), 2249. SAI SERVICE PRIVATE LIMITED (1011-10-07), 2260. THE MITHRA AGENCIES (1002-10-06), SURVEY
1-11-200,SHAMLALA BUILDING BEGUMPET, PLOT NO.B-21 & B-34, BHEL ANCILLARY NO.57, D.NO.8-2-108, BIRAMALGUDA,
2226. ADARSHA AUTOMOTIVES PVT LTD
HYDERABAD - 500016 INDUSTRIAL ESTATE, RAMACHANDRAPURM, KARMANGHAT NAGARJUN SAGAR ROAD,
(GJE1-GJE-01), SURVEY NO. 202/E, H. NO.
PH :9885206555. HYDERABAD - 502032 HYDERABAD, TELANGANA. - 500079
12-1/4 & 12-1/A, VILLAGE & MANDAL -
2238. THE MITHRA AGENCIES (1002-10-04), 8-18-138, PH :9703811411. PH :8886621232.
HUSNABAD, DIST.-SIDDIPET, TELANGANA. -
PLOT NO. 8,NEAR MARGADARSI CHIT 2250. ADARSHA AUTOMOTIVES PVT LTD (1014-10-01), 2261. VARUN MOTORS PVT. LTD. (4603-10-0M), KSN
505467
FUND,L.B. NAGAR RING ROAD, RR 18-2-45 NEAR FLYOVER, CHANDRAYANGUTTA GARDENS, 5-162/6, BORABANDA MAIN ROAD,
PH :8886092222, 7995835552.
DIST,HYDERABAD - 500074 "X" ROAD, HYDERBAD - 500005 HYDERABAD. - 500018
HYDERABAD PH :9963551265. PH :8142326633. PH :9885579623.
2227. THE MITHRA AGENCIES (1002-10-01), 1-8-670, 2239. GEM MOTORS (INDIA) PVT. LTD. (1009-10-01), 2251. RKS MOTORS PVT. LTD. (1003-10-09), SURVEY 2262. JAYABHERI AUTOMOTIVES PVT. LTD.
NEAR RTC CROSS ROAD,AZAMABAD RAGHUVENDRA NO.434, 5-5-33/19, BEHIND HUDA TRUCK (1017-10-03), SURVEY NO.283, PLOT NO.D-46 &
INDUSTRIAL AREA, HYDERABAD, - 500020 SOCIETY,KONDAPUR,,HYDERABAD , ANDHRA PARKING, KUKATPALLY, DISTT: RANGAREDDY, 47, PHASE-V, IDA, JEEDIMETLA,
PH :9966838294. PRADESH - 500084 HYDERABAD - 500072 QUTUBULLAPUR MANDAL, RANGA REDDY
2228. RKS MOTORS PVT. LTD. (1003-10-01), SABOO PH :9912899128. PH :9010811131. DISTT., HYDERABAD (TELANGANA). - 500055
TOWERS, RAJBHAVAN ROAD, SOMAJIGUDA, 2240. GEM MOTORS (INDIA) PVT. LTD. (1009-10-02), 2252. SAI SERVICE PRIVATE LIMITED (1011-10-08), PH :7799784567.
HYDERABAD - 500482 2-11, SURVEY NO: 165,172,HYDERNAGAR, DOOR NO.7-2-C33 & C34, INDUSTRIAL ESTATE, 2263. ADARSHA AUTOMOTIVES PVT LTD (1014-10-03),
PH :040 44454443, 9010811166. KUKATPALLY, HYDERABAD, ANDHRA PRADESH SANATH NAGAR, HYDERABAD. - 500018 SURVEY NO. 220/A, AMBEDKAR ROAD, OPP
2229. RKS MOTORS PVT. LTD. (1003-10-02), B-4/A,IDA - 500072 PH :7799360003. HERITAGE FRESH, NEAR AMBAEDKAR
BLOCK, INDUSTRIAL ESTATE,UPPAL, PH :9912344538. 2253. KALYANI MOTORS PVT. LTD. (1018-10-01), PLOT STATUE, NEAR ALWAL, SECUNDERABAD. - 500
HYDERABAD - 500039 2241. SAI SERVICE PRIVATE LIMITED (1011-10-01), NO. A-23 & A31/1, I.D.A, NACHARAM, 010
PH :040 23434504, 9010822210. 6-6-29/5/1/NR, VIMANA PURI, QUTHBULLAPUR, HYDERABAD. - 500076 PH :9291859954.
2230. VARUN MOTORS PVT. LTD. (4603-10-04), B-11 HYDERABAD, TELANGANA 500055 - 500055 PH :91000 56490. 2264. KALYANI MOTORS PVT. LTD. (1018-10-03),
CO-OPERATIVE INDUSTRIAL ESTATE, PH :9010827755. 2254. GEM MOTORS (INDIA) PVT. LTD. (1009-10-03), SURVEY NO. 305, NIZAMPET, MANDAL -
BALANAGAR, HYDERABAD, - 500037 2242. THE MITHRA AGENCIES (1002-10-05), PLOT NO. SURVEY NO. 135/A & 135/AA, MANIKONDA, QUTBULLAPUR, DIST.-RANGA REDDY,
PH :9885208555, 9985745222. 19,20 & 21,ROAD NO. 10,IDA NACHARAM, RAJENDRA NAGAR MANDAL, RANGAREDDY HYDERABAD. - 500 072
2231. VARUN MOTORS PVT. LTD. (4603-10-0B), HYDERABAD - 500076 DISTRICT, HYDERABAD, TELANGANA. - 500089 PH :72079 33677.
ADITYA NAGAR COLONY, ,ADITYA NAGAR PH :04027176999 PH :9912341524. 2265. THE MITHRA AGENCIES (1002-10-07), SURVEY
COLONY, TOLICHOWKI, SHAIKPET (VILLAGE, 04027177999 2255. ADARSHA AUTOMOTIVES PVT LTD (1014-10-02), NO,12,13,14& 15, MEDIPALLY, GHATKESAR
HYDERABAD, HYDERABAD - 500008 9963551267. H. NO. 8-64/1, RUDRA COLONY, SHAMSHABAD, MANDAL, RANGA REDDY DISTRICT,
PH :64551700, 8886114856. 2243. VARUN MOTORS PVT. LTD. (1012-10-01), HYDERABAD. - 501218 HYDERABAD, TELANGANA - 500098
2232. VARUN MOTORS PVT. LTD. (1010-10-01), PLOT MARUTI AUTHORISED DEALER, SURVEY PH :9603296633. PH :8886697954.
NO. VI- VII A & B,UNDER WARD NO. 10, NO.115, IT PARK, NANAKRAMGUDA, 2256. JAYABHERI AUTOMOTIVES PVT. LTD. IBRAHIMPATNAM
AUTONAGAR, VANASTALIPURAM, HYDERABAD, GACHIBOWLI, HYDERABAD - 500008 (1017-10-01), PLOT NO. 113, 114, 115 IN LUMBINI
2266. PAVAN MOTORS PVT. LTD (CSF1-CSF-01),
R. R. DISTT - 500070 PH :9985104860, 69997979. ENCLAVE CB SQUARE, VILLAGE –
S.NO.123/E, MPP PATELGUDA,
PH :9885208555. 2244. RKS MOTORS PVT. LTD. (1003-10-08), GACHIBOWLI, SHERLINGAMPALLY MNADAL,
IBRAHIMPATNAM, RANGA REDDY - 501506
2233. VARUN MOTORS PVT. LTD. (4603-10-06), SHOP D.NO.1-10-1/285/1, OPP. VEGITABLE MARKET, HYDERABAD, TELANGANA STATE. - 500032
PH :8790144499.
NO. 31, SRIKRUPA MARKET, D.NO. 16-10-1/F/31, ECIL CROSS ROADS, KUSAIGUDA, HYDERABAD PH :9100909401.
MALAKAPET, HYDERABAD - 500036 - 500062 2257. JAYABHERI AUTOMOTIVES PVT. LTD. JAGITIAL
PH :4553395, 4547676, 9885093360. PH :7799779810. (1017-10-02), SURVEY NO.11/36, PLOT NO.32, 39 2267. ADARSHA AUTOMOTIVES PVT LTD
2234. RKS MOTORS PVT. LTD. (1003-10-04), H: NO 2245. SAI SERVICE PRIVATE LIMITED (1011-10-04), & 40, NEAR N CONVENTION CENTRE, (N601-NU-04), HOUSE NO.-1-5-216/A,OPPOSITE
16-9-409/P,PLOT NO.4/1,4/2,SY.NO. 97,98,OLD H.NO.16-2-839/4/10, SAIDABAD, L.B.NAGAR, KHANAMET, HYDERABAD, SHERLINGAMPALLY TO KVA SUBSTATION, KARIMNAGAR ROAD,
MALAKPET OPP HYDERABAD. - 500059 MANDAL, HYDERABAD. - 500081 JAGTIAL, - 505327
GOLNAKA BRIDGE, PH :7799352000. PH :7799916666. PH :8886152222.
MOOSARAMBAGH,HYDERABAD - 500036 2246. VARUN MOTORS PVT. LTD. (4603-10-0G), 2258. KALYANI MOTORS PVT. LTD. (1018-10-02), M/S JANGAON
PH :9010811192. 1-10-28/1 SY. NO.285, KUSHAIGUDA, NEAR ECIL VIDHATA BINNY MODERN RICE MILL, BEARING
X ROADS, HYDERABAD - 500062 NO. 8-4-15 IN SURVEY NO. 239 & 240 OF 2268. ADARSHA AUTOMOTIVES PVT LTD (KI01-KI-01),
2235. THE MITHRA AGENCIES (1002-10-03), PLOT NO.
PH :7799600093. VILLAGE – KARMANGHAT, MANDAL – H.NO.339, HYDERABAD ROAD, JANGAON. -
3-4-10,NEAR MADHAPUR POLICE STATION,
2247. VARUN MOTORS PVT. LTD. (4603-10-0H), PLOT SAROORNAGAR, DISTRICT – RANGA REDDY, 506167
MADHAPUR, HYDERABAD - 500081
NO. 1354/1, ROAD NO. 1, NEAR IOC PETROL HYDERABAD. - 500079 PH :7799626633.
PH :04023113399
04023113388 PUMP, JUBLEE HILLS, HYDERABAD, ANDHRA PH :9100222377. KAMAREDDY
9959912702. PRADESH - 500033 2259. ADARSHA AUTOMOTIVES PVT LTD (1019-10-01), 2269. VARUN MOTORS PVT. LTD. (KX01-KX-01),
2236. RKS MOTORS PVT. LTD. (1003-10-05), PH :8886322776. H. NO. 2-4-43/15, SURVEY NO. 34, SOGBOWLI H.NO.11-107/61, BESIDE:GURU RAGHAVENDRA
11-6-191/192,OPP. HOTEL HARSHA,PUBLIC 2248. VARUN MOTORS PVT. LTD. (4603-10-0J), PLOT (PILLER NO. 185 OF P.V. NARSIMHA RAO COLONY, CHINNA MALLAREDDY VILLAGE,
GARDEN ROAD, NAMPALLY, HYDERABAD - NO. 1-45, SY.NO:1 TO 7, GOPINATH COMPLEX, EXPRESSWAY), RAJENDRANAGAR, KAMAREDDY. - 503111
500001 TARANAGAR, LINGAMPALLY, HYDERABAD, UPPERPALLY, ATTAPUR, RANGA REDDY, PH :9985557570
PH :9848811158. RANGAREDDY DISTRICT, TELANGANA STATE - HYDERABAD, TELENGANA. - 500048 8142551166.
500019 PH :9705436633, 8297426633.
KARIMNAGAR
PH :8886067847.

68
Dealer Workshop (AS ON 31.05.2023 )
2270. ADARSHA AUTOMOTIVES PVT LTD MAHABUBNAGAR 2288. SRI JAYARAMA MOTORS PVT. LTD. 2296. VARUN MOTORS PVT. LTD. (CBO1-CBO-01),
(N601-N6-01), H.NO. 8-6-313/1,HYDERABAD (EV01-EV-01), SURVEY NO.44/A AND 45/A, HOUSE NO. 2-356 JANGAIAH COMPLEX,
2280. SRI JAYARAMA MOTORS PVT. LTD.
ROAD,BY-PASS JUNCTION,KARIMNAGAR - UYYALWADA VILLAGE, NAGARKURNOOL, SURVEY NO. 217/EE4, JAYANTHI NAGAR
(WP01-WP-01), PLOT NO.C1 & C2, INDUSTRIAL
505001 TELANGANA - 509209 COLONY, MANDAL – PARGI, DISTRICT – RANGA
ESTATE, METTUGADA, MEHBOOBNAGAR -
PH :8886600315. PH :8096990074. REDDY. - 510501
504001
2271. ADARSHA AUTOMOTIVES PVT LTD NALGONDA PH :988521055, 9885200000.
PH :8096998846.
(N601-N6-05), H.NO.8-6-301/18, BY-PASS ROAD, PARKAL
MAHESHWARAM 2289. PAVAN MOTORS PVT. LTD (AN01-AN-01),
AUTONAGAR, KARIM NAGAR, TELANGANA. -
CHERLAPALLY VILLAGE, NALGONDA ROAD, 2297. ADARSHA (SEK1-SEK-01), SY.NO 946, H.NO
505001 2281. ADARSHA AUTOMOTIVES PVT LTD
NALGONDA - 508001 5-27, VIKAS NAGAR, PARKAL,WARANGAL. -
PH :8886152222. (CQR1-CQR-01), (BEARING #5-187, SURVEY
PH :8790902146. 506164
2272. VARUN MOTORS PVT. LTD. (N603-N6-01), NO.:336/A1, VILLAGE & MANDAL:
NARAYANKHED PH :8886742222.
BEARING NO. 1-81/3/10/2, SURVEY NO. 221 & MAHESHWARAM DISTT. RANGA REDDY -
222, REKURTHY VILLAGE, 501359 2290. VARUN MOTORS PVT. LTD. (CGI1-CGI-01), D. PEDAPALLY
KARIMNAGAR-JAGTIAL ROAD, KARIMNAGAR PH :8142326633, 9703152222. NO. 1-6-111/25/B/5/A/1, SY NO. 57/2, BHUMAN 2298. ADARSHA AUTOMOTIVES PVT LTD
MANDAL & DIST. , TELANGANA. - 505 001 MANCHERIAL COLONY, GRAM PANCHAYAT & MANDAL - (GKN1-GKN-01), SURVEY NO 142, H NO 185,
PH :8886619373. NARAYANKHED, DISTRICT – MEDAK, RANGAMPALLI VILLAGE, PEDDAPALLI ,
2273. VARUN MOTORS (N603-N6-2), SURVEY NO. 2282. ADARSHA AUTOMOTIVES PVT LTD
TELANGANA. - 502286 TELANGANA - 505172
277,278/B, AREPALLY VILLAGE, (N601-CM-03), BEHIND MAHINDRA TRACTORS
PH :9885210555. PH :8886618155, 8886672222.
TEEGALAGUTTAPALLI GRAM PANCHAYAT, SHOWROOM,BELLAMPALLY ROAD,
MANCHIRIAL , DISTT. ADILABAD - 504208 NARAYANPET RAMAGUNDAM
KARIMNAGAR - 505001
PH :91549 03258. PH :8886302222. 2291. SRI JAYARAMA MOTORS PVT. LTD. 2299. ADARSHA AUTOMOTIVES PVT LTD
MEDAK (BPG1-BPG-01), SURVEY NO. 468/4, (BGA1-BGA-01), 5-6-172 SURVEY NO. – 259/B,
KEESARA
MAHABUBNAGAR ROAD, NARAYANPET TOWN, MEDIPALLY SHIVAR, RAMAGUNDAM
2274. JAYABHERI AUTO (SEI1-SEI-01), H-NO 3-56/9/6A, 2283. VARUN MOTORS PVT. LTD. (KF01-KF-01),
DIST.-MAHABUBNAGAR, STATE - TELANGANA. - MUNICIPALITY, DISTRICT – KARIM NAGAR,
SURVEY NO 5,KEESARA, SY.NO.:1486/A3, HYDERABAD ROAD, MEDAK
509210 ANDHRA PRADESH - 505209
MEDCHAL-MALKAJGIRI, TELANGANA - 501301 (MDL & TOWN) - 502110
PH :8096997701, 7893177448. PH :8886144550.
PH :9676076666. PH :9154953337.
NARSAPUR RAMAYAMPET
KHAMMAM MEDCHAL
2292. KALYANI MOTORS PVT. LTD. (SCX1-SCX-01), 2300. VARUN MOTORS PVT. LTD. (CDO1-CDO-01),
2275. MITHRA AUTO AGENCIES PVT LTD 2284. AUTOFIN LIMITED (CID1-CID-01), H. NO. 11-27/1,
SURVEY NO 66, BLOCK SURVEY NO. 1626 & 1626/2 SITUATED AT
(2604-1G-02), SURVY NO. 182,WARANGAL SURVEY NO.401, MEDCHAL VILLAGE AND
NO-19,NARSAPUR,DISTRICT:MEDAK, BLOCK NO. 16, RAMAYAMPET, DISTRICT –
ROAD, OPP. FCI GODOWNS,PEDA MANDAL, DIST. - MEDCHAL. - 501401
TELANGANA. - 534275 MEDAK. - 502101
THANDA,KHAMMAM - 507003 PH :8885040020.
PH :9573179790. PH :9885208555, 9703803399.
PH :8886063527. METAPALLY NIRMAL SADHASHIVPET
KODAD 2285. ADARSHA (BJF1-BJF-01), SURVEY NO. 40/U/2
2293. ADARSHA AUTOMOTIVES PVT LTD 2301. SAI SERVICE (SFQ1-SFQ-01), PLOT NO. 2, SY
2276. PAVAN MOTORS PVT. LTD (BRP2-BRP-01), CHOULAMADHI, METPALLY PIN CODE 505325 -
(N601-AA-02), H. NO. 1-1-131, ,SHASTRINAGAR, NO. 974, GURUNAGAR COLONY, OLD BOMBAY
SURVEY NO. 42, KOMARBANDA REVENUE 505325
,MANCHIRIAL ROAD, DISTT. ADILABAD, HIGHWAY ROAD, SADASHIVPET, SANGAREDDY
LIMITED, KODAD , DISTRICT – NALGONDA, PH :8886092222.
NIRMAL - 504106 DIST. 502291. - 502291
TELANGANA - 508206 MIRYALGUDA PH :8886342222. PH :9966377888.
PH :8790902114. 2286. PAVAN MOTORS PVT. LTD (WR01-WR-01), NIZAMABAD SANGAREDDY
KOLLAPUR SURVEY NO-940 &943, (OPPOSITE TO MINA
2294. VARUN MOTORS PVT. LTD. (1H02-1H-01), PLOT 2302. SAI SERVICE PRIVATE LIMITED (1011-OI-05),
2277. SRI JAYARAMA (SHC1-SHC-01), SURVEY NO ENGINEERING COLLEGE) NARKETPALLY
NO. GP 1-51/4/1,PANGARA H.NO.4-8-92/1/4/5, AHMED NAGAR,
259/AA2, 259/E2,KOLLAPUR, NAGAR KURNOOL ADDANKI BY-PASS ROAD,MIRYALAGUDA
BORGOAN,NIZAMABAD, OPP.GOVT.ITI, SANGAREDDY, MEDAK (DIST),
DISTRICT, TELANGANA - 509102 ,NALGONDA DISTRICT,ANDHRA PRADESH -
TELANGANA - 503230 ANDHRA PRADESH - 502001
PH :9985880015. 508207
PH :8297848999, 9052080444. PH :7661811000.
PH :8790900399.
KOTHAGUDEM PALWANCHA SATUPALLI
MOINABAD
2278. VARUN MOTORS PVT. LTD. (2603-HF-04), DOOR 2295. VARUN MOTORS PVT. LTD. (HF01-CSS-01), 2303. MITHRA AUTO AGENCIES PVT LTD
NO. 5-35/4/B,LAKSHMIDAVI 2287. GEM MOTORS (INDIA) PVT. LTD.
SURVEY NO.758 & 757, NEHRU NAGAR, (SHD1-SHD-01), SURVEY NO. 75 NEAR
PALLI,BHADRACHALAM ROAD, KOTTHAGUDEM (CFN1-CFN-01), SURVEY NO. 70, PLOT NO. 4,
PALWANCHA (NEW POLANCHA) MANDAL & VIVEKANANDA STATUE,SATHUPALLI,
- 507101 VILLAGE AND GRAM PANCHAYAT – HIMAYATH
TOWN, BHADRADRI KOTHAGUDEM DISTT., KHAMMAM. - 507303
PH :9581494499. NAGAR, MANDAL – MOINABAD, DISTRCT –
TELANGANA. - 507115 PH :8886063508.
RANGA REDDY. - 500075
MAHABUBABAD PH :9642225288. SECUNDERABAD
PH :9912899128, 7997994845.
2279. ADARSHA AUTOMOTIVES PVT LTD PARGI 2304. ACER MOTORS (A DIVISION OF KRISHNAIAH
NAGARKURNOOL
(CQS1-CQS-01), SY. NO.38/A, MAHBUBABAD MOTORS PVT. LTD) (K601-K6-01), A1, MOTI
REVENUE VILLAGE AND MANDAL, VALLEY,TRIMULGHERRY,SECUNDERABAD, -
MAHBUBABAD. - 506101 500015
PH :9177746333, 7799700525. PH :8885088080.

69
Dealer Workshop (AS ON 31.05.2023 )
2305. AUTOFIN LIMITED (K606-K6-01), SURVEY NO. 2315. PAVAN MOTORS PVT. LTD (BLC1-BLC-01), 2324. WIN MOTORS (A UNIT OF BHADRAKALI 2334. JAIN UDYOG (6901-RN-03), DHARMANAGAR
33, MEDCHAL ROAD, BOWENPALLY, SURVEY NO. 493, THALLAGADDA, SURYAPET AUTOCARE PVT. LTD) (D503-D5-01), SURVEY COLLEGE ROAD, DHARMANAGAR,
SECUNDERABAD - 500011 MANDAL, NALGONDA DISTRICT, ANDHRA NO. 16, 16/A & 16/B, OPPOSITE KAKATIYA TRIPURA(NORTH). - 799250
PH :8885040130. PRADESH. - 508213 UNIVERSITY GATE-2, LASHKERSINGARAM PH :97747 93164.
2306. VARUN MOTORS PVT. LTD. (4603-K6-0I), PH :8790902545. REVENUE VILLAGE, HANAMKONDA MANDAL, UDAIPUR
1-10-176/1, BEHIND VARUN TOWERS-I, OPP. TALLADA WARANGAL. - 506 001
2335. JAIN UDYOG (YU01-YU-01), DHWAJANAGAR
HYDERABAD PUBLIC SCHOOL, BEGUMPET, PH :8688828010.
2316. MITHRA AUTO (SOU1-SOU-01), SURVEY NO INDUSTRIAL ESTATE,UDAIPUR,TRIPURA
SECUNDERABAD, HYDERABAD, TELANGANA 2325. WIN MOTORS (A UNIT OF BHADRAKALI
890/A, D.NO 7-8, NARAYANAPURAM, TALLADA, (SOUTH) - 799116
STATE. - 500016 AUTOCARE PVT. LTD) (D503-D5-02), PLOT
TELANGANA - 507167 PH :9774020152.
PH :9985552452. NUMBER 9,10,11 & 13/A ,SURVEY NUMBER
PH :8886063527.
2307. RKS MOTORS PVT. LTD (K605-K6-01), PLOT NO. 148/A&B OF BHEEMRAM VILLAGE, WARANGAL. UP
207, TADBUND, SECUNDERABAD. - 500003 TANDUR - 506015 BULANDSHAHAR
PH :9010801004. 2317. VARUN MOTORS PVT. LTD. (CFR1-CFR-01), H. PH :8688828015.
2308. AUTOFIN LIMITED (K606-K6-02), SURVEY NO. 2336. SK UNIVERSE (M502-M5-02), KHASRA NO.2261,
NO. 2-1-20/3, 2-1-20/3/A & 2-1-20/9, PLOT NO. 45, ZAHIRABAD
177/B & 178/C SITUATED AT VILLAGE – NEAR T POINT , BYPASS SIKARPUR ROAD
46, 47, SURVEY NO. 57 OF MALREDDYPALLY
2326. SAI SERVICE PRIVATE LIMITED (BAT1-BAT-01), ,BULANDSHAHR - 203001
KOMPALLY, MANDAL – QUTHBULLAPUR, VILLAGE, TANDUR MUNICIPALITY, VIKARABAD
PLOT NO-5,NEAR IBP PETROL BUNK, PH :7055118430.
HYDERABAD. - 500090 DISTRICT, TELANGANA. - 501141
NH-9,ALIPUR,ZAHIRABAD,MEDAK DIBYAPUR
PH :8885040126. PH :8886619370.
(DIST),ANDHRA PRADESH - 502220
2309. PAVAN MOTORS PVT. LTD (K608-K6-02), PLOT THORRUR 2337. KULDEEP MOTORS (SLA1-SLA-01), AURAIYYA
PH :7660005206.
NO. 1-12, 749, 750, SURVEY NO. 751/2, ROAD, DIBIYAPUR - 206244
VENKATADRI NAGAR, NEW MIRJALGUDA, 2318. ADARSHA AUTOMOTIVES PVT LTD TELENGANA PH :9235258425.
MALKAJGIRI, SECUNDERABAD, TELANGANA - (BYV1-BYV-01), SURVEY NO.1 TO 5, BEARING
M. NO.4-153/1, VILLAGE & MANDAL THORRUR KAGHAZNAGAR MEERUT
500047
PH :9121293690. DISTT. WARANGAL - 506163 2327. ADARSHA AUTOMOTIVES (SCN1-SCN-01), H.NO 2338. TR SAWHNEY (4808-48-01), MUNICIPAL NO 101,
PH :9059438007, 7799790527. :1-61/3,BORIGAON,KAGHAZNAGAR,KOMARAMB KHASRA NO 1926/ MINJUMLA & 1927/1, MAHAL
SHAD NAGAR
TOOPRAN HEEM - 504296 LEKHRAJ MUJBITA, MAIN DELHI ROAD,
2310. SRI JAYARAMA MOTORS (P) LTD. PH :8886092222. MEERUT, UP - 250002 - 250002
(WS01-WS-01), SERVEY NO.445, FAROOQ 2319. ADARSHA (SEJ1-SEJ-1), PLOT NO 7&8, SY NO
185,184,179U, NAGULAPALLY PALAKURTHY PH :9999163125.
NAGAR, SHADNAGAR, MAHABUB NAGAR
VILLAGE,TOOPRAN MANDAL,TELANGANA 2328. WIN MOTORS (SCY1-SCY-01), SURVEY NO MOOSANAGAR
DISTT. ANDHRA PRADESH. - 500216
PH :8096996671. STATE: TELANGANA CITY: TOOPRAN PIN : 537/B,MAIN RAOD, PALAKURTHY,JANGAON 2339. MY CAR (SLP1-SLP-01), VILL GAUSGANJ, POST
502334 CITY CATEGO - 502334 DISTRICTTELANGANA. - 506317 MOOSANAGAR, KANPUR DEHAT, UTTAR
SHAMIRPET
PH :9291859954. PH :8688838005. PRADESH. - 209208
2311. RKS MOTOR PVT. LTD. (SDE1-SDE-01), SHED VIKARABAD
NO 2-242, MAJEEDPUR CROSS TRIPURA PH :97929 70005.

ROADS,SHAMIRPET, 2320. GEM MOTORS (INDIA) PVT. LTD. AGARTALA UTTAR PRADESH
MEDCHAL-MALKAJGIRI,TELANGANA - 500078 (BYM1-BYM-01), SHOP NO. 3-2-93/2, VILLAGE – AGRA
2329. JAIN UDYOG (6901-69-01), ARUNDHUTI NAGAR,
PH :9848866618. YENNAPALLY, VIKARABAD MUNCIPALITY,
OPP. INDUSTRIAL ESTATE, AGARTALA - 799003 2340. MADHUSUDAN MOTORS PVT LTD (6603-66-01),
VIKARABAD, DISTRICT – RANGA REDDY,
SHANKARPALLY PH :9862149275. B-5 LAWYERS COLONY, BYE PASS ROAD,
TELANGANA . - 501101
2312. SAI SERVICE PRIVATE LIMITED (CEX1-CEX-01), 2330. JAIN UDYOG (6901-69-05), 58-B/C, INDUSTRIAL AGRA - 282005
PH :9912349840.
SURVEY NO. 203, HYDERABAD ROAD OPP. SM AREA ARUNDHATI NAGAR, AGARTALA. - 799003 PH :531102-05.
WANAPARTHY PH :70057 71216.
FUNCTION HALL ROAD, SHANKARPALLY, 2341. MADHUSUDAN MOTORS PVT LTD (6603-66-02),
RANGA REDDY DISTT. - 501203 2321. SRI JAYARAMA MOTORS (P) LTD. 2331. JAIN UDYOG (6901-69-06), KHATIAN NO. 1843, GANESH GANJ, PRATAPPURA, AGRA - 282001
PH :9966377888, 9912899128, 9703811011. (WQ01-WQ-01), SURVEY NO.1149, KURNOOL MOUJA & TEHSIL – KHAYERPUR, JIRANIA PH :9837097887.
ROAD, WANAPARTHY (A.P.) - 509103 SUBDIVISION, AGARTALA - 799008 2342. MADHUSUDAN MOTORS PVT LTD (6603-66-03),
SIDDIPET
PH :8096903879. PH :97746 16831. 6-A , VIBHAV INDUSTRIAL STATE, AGRA -
2313. ADARSHA AUTOMOTIVES PVT LTD WARANGAL AMARPUR 282007
(CAL1-CAL-01), SURVEY 197/A, VILLAGE – PH :3299221.
PONNALA, SIDDIPET, DISTRICT – MEDAK, 2322. ADARSHA AUTOMOTIVES PVT LTD 2332. JAIN UDYOG (CVR1-CVR-01), NEAR MOTOR
2343. MADHUSUDAN MOTORS PVT LTD (6603-66-04),
TELANGANA. - 502103 (D502-D5-02), PLOT NO.10, INDUSTRIAL AREA, STAND, AMARPUR,TRIPURA - 799101
26/253, SULTAN GANJ KI PULIA, MAUZA
PH :09703716633, 9160746633. MULUGU ROAD, WARRANGAL - 506007 PH :97748 45751.
LASKARPUR, AGRA - 283203
PH :8886132222. AMBASSA
SIRCILLA PH :9837097894.
2323. ADARSHA AUTOMOTIVES PVT LTD
2314. ADARSHA AUTOMOTIVES PVT LTD 2333. JAIN UDYOG (CDT1-CDT-01), A.A. ROAD, 2344. PREM MOTORS PVT. LTD. (6605-66-01),
(D502-D5-03), OPPOSITE TO ORUGALLU
(BYW1-BYW-01), H. NO. 10-1-7/2, 10-1-7/3, OPPOSITE OF CHANDRAI PARA HS SCHOOL, KHASRA NO.382,386,387,388, VILLAGE
FILLING STATION, HUNTER ROAD,
10-1-7/3/A/1, KARIMNAGAR ROAD, SIRCILLA, AMBASSA, DHALAI, TRIPURA. - 799289 ARTHONI, DELHI-AGRA HIGHWAY, NH-2, AGRA,
SHAYAMPET, HUNAMKONDA, WARANGAL -
DISTRICT – KARIMNAGAR, TELANGANA - PH :70052 88437. UTTAR PRADESH - 282007
506001
505301 DHARMANAGAR PH :9690010839.
PH :8886492222.
PH :8886618155, 8142244131. 2345. KTL PVT. LTD. (6606-66-01), MUGHAL ROAD,
KAMLA NAGAR, AGRA - 282004
SURYAPET
PH :8449715033,8449715099.

70
Dealer Workshop (AS ON 31.05.2023 )
2346. PREM MOTORS PVT. LTD. (6607-66-01), 45, 2357. KAVISHA MOTORS PVT LTD (CVI1-CVI-01), 2367. ANAND MOTORS AGENCIES LTD (XB01-XB-01), 2378. SMARTWHEELS PVT. LTD. (7201-6B-05),
OPPOSITE AGRA COLLEGE, GOKULPURA, COMMERCIAL PLOT, RAN NAGAR ROAD, NEAR NEAR BALRAMPUR CHINI MILLS, GONDA MANORI CHAURAHA, DUMARIYA GANJ ROAD,
AGRA, UTTAR PRADESH - 282002 MUNICIPALITY OFFICE, TEHSIL - AONLA. DIST., ROAD,BALRAMPUR-UTTAR PRADESH - 271201 BASTI - 270002
PH :9690010799. BAREILLY, STATE- UTTAR PRADESH. - 243301 PH :6307995976. PH :286294.
2347. KTL PVT. LTD. (6606-66-02), KHASRA NO. 171, PH :07895980222, 07895980300. BANDA BEHTA
SEWLA JAT, GWALIOR ROAD, AGRA, UTTAR AURAI 2368. MY CAR PVT. LTD. (2803-KV-03), KALUKUAN, 2379. MEGA MOTORS (A UNIT OF AKM MOTORS PVT.
PRADESH - 282001
2358. VARANASI MOTORS PVT LTD (CBM1-CBM-01), TINDWARI ROAD, BANDA - 210001 LTD) (GMI1-GMI-01), KHASRA NO. 254,
PH :8449715099.
KHATA / KHATAUNI NO. 00045, GT ROAD (EHAK PH :9792971223. OPPOSITE SANGAM MOTORS, KURSI ROAD,
2348. MERAK VEHICLES (6609-66-01), KHASRA NO 65
BHAURA), OPP. CHINI MILL,VILLAGE & TEHSIL 2369. SUMITRA DS MOTORS (SPB1-01-SPB-01), BEHTA - 226026
& 74, MAUZA MOHAMMADPUR, AGRA-DELHI
AURAI, DISTT: BHADHOI, UTTARPRADESH, PIN PURANPUR ROAD, BANDA, TEHSIL BANDA, PH :6388901514.
ROAD (NH-2), SIKANDRA, AGRA UTTAR
2221 301 - 2221301 THANA BANDA, DISTT. SHAHJAHANPUR – U.P. - BHADOHI
PRADESH-282007. - 282007
PH :9838360662, 7617002786. 242042
PH :9690486139. 2380. VARANASI MOTORS PVT. LTD. (8402-TT-02),
AURAIYA PH :9336408074.
AKBARPUR VARNASI ROAD, BHADOHI - 221401
2359. KULDEEP MOTORS (QJ01-QJ-01), NEAR INDIAN BANSI PH :9838360662.
2349. KTL PVT. LTD. (2801-LH-03), KANPUR ROAD,
OIL TIRAHA, KANPUR ROAD, AURAIYA. - 206241 2370. ARBIT AUTOMOBILES PVT LTD (GMD1-GMD-01), BHINGA
AKBARPUR - 209206
PH :9235358444. KHASRA NO. 66 M, GRAM: BHAWNI, TAPPA:
PH :7408409348. 2381. ANAND MOTORS (BVG1-BVG-01),
AZAMGARH KUNDARANA, PARGANA: BANSI EAST, TEHSIL
2350. SMARTWHEELS PVT. LTD. (7201-LH-08), TANDA PATNAKHARGAURA, BHINGA, SHRAVASTI -
BANSI, DISTT : SIDARTHNAGAR - 272153
ROAD, VILL-BUDHAEEPUR, PO-KATRIYA 2360. DEEP MOTORS (K501-K5-01), HARBANSHPUR 271831
PH :89534 12821.
YAKOOBPUR, AKBARPUR , DIST-AMBEDKAR NARAULI, AZAMGARH - 276001 PH :9415013059.
NAGAR (U.P.) - 224122 PH :9838072905. BANTHRA
BHOJPUR
PH :7705803248. BABRALA 2371. MEGA MOTORS (SGQ1-SGQ-01), KHASRA
2382. MOTORCRAFT SALES INDIA PVT LTD
ALIGARH NO.1628 AMARPUR, SIKANDARPUR MARKET,
2361. AKANKSHA AUTOMOBILES PVT. LTD. (SDQ1-SDQ-01), OPPOSITE PRIMARY
BANTHRA, KANPUR ROAD LUCKNOW - 226401
2351. DEV MOTORS (P) LTD (B601-B6-01), NEAR (SJU1-SJU-01), CHANDAUSI ROAD, BABRALA, GOVERNMENT SCHOOL, HAPUR ROAD,
PH :9919101456.
BANNA DEVI, G.T.ROAD, ALIGARH - 202001 DISTRICT SAMBHAL, UTTAR PRADESH. - 243751 VILLAGE BHOJPUR, TEHSIL – MODINAGAR,
PH :521771. PH :9837649177. BARABANKI DISTRICT – GHAZIABAD. - 201204
2352. DEV MOTORS (B601-B6-04), PLOT NO 97, BACHRAWAN 2372. BRIGHT 4 WHEEL SALES PVT. LTD. PH :9410038456.
VILLAGE SIKANDERPUR, BHUKRAVALI, GT (1305-6A-03), VILL. DHARSANIA, LUCKNOW BIJNOR
ROAD BYE PASS, ALIGARH - 202002 2362. KTL AUTOMOBILE PVT. LTD. (CGX2-CGX-01),
ROAD, NAWABGANJ, BARABANKI - 225001
PH :7351345577. VISHNUPUR, PHARWAN, 2383. SHAKUMBARI AUTOMOBILES (P) LTD
PH :9838075960.
RAEBARELI-LUCKNOW ROAD, DIST. (6D01-6D-01), PLOT & KHASRA NO. 253/3 & 258/1
ALLAHABAD BARAUT
-RAEBARELI. - 229301 ADJACENT KHEDI CHAURAHA, NEAR PULKIT
2353. AMITDEEP MOTORS (2901-29-01), 26 SULEM PH :99184512222. 2373. TANYA AUTOMOBILES (LL02-LL-01), 240/2 HOSPITAL, DELHI-BIJNOR HIGHWAY, BIJNOR,
SARAI, G.T ROAD, ALLAHABAD - 211001 BAH SHAHPUR-BADOLI, DELHI SAHARANPUR ROAD, DIST. – BIJNOR, UTTAR PRADESH. - 246701
PH :8948122749, 9026111339, 7738555692, BARAUT, BAGHPAT, UTTAR PRADESH. - 250611 PH :8630881409.
9839890333, 9936413399. 2363. KTL PVT. LTD. (CHI1-CHI-01), 16B, DHOBAIR,
PH :7055300019. BILARI
VILLAGE - BAH, DIST.-AGRA, UTTAR PRADESH.
AMETHI BAREILLY
- 283104 2384. AKANKSHA AUTOMOBILES PVT. LTD.
2354. KTL AUTOMOBILE PVT. LTD. (BBB2-BBB-01), PH :7055707169, 8449715033. 2374. CORAL MOTORS (P) LTD. (5602-56-01), STATION (SDM1-SDM-01), 2KM-BILARI NH 509, NEAR SBS
PLOT NO – E 32, INDUSTRIAL AREA TEKARIA, BAHERI ROAD, BAREILLY - 243001 SCHOOL, BILARI, MORADABAD 244001 - 244001
UPSIDC, GAURIGANJ, DIST: C.S.M.NAGAR - PH :559191. PH :9927459707.
227409 2364. KAVISHA MOTORS PVT LTD (BSB1-BSB-01),
2375. CORAL MOTORS (P) LTD. (5602-56-03), PILIBHIT BILASPUR
PH :7379557377. KASRA NO. 530, 531, 532, 533. NAINITAL ROAD,
BYE PASS ROAD, EXECUTIVE CLUB CROSSING,
OPP. RAMLILA GROUND, BAHERI, DISTRICT – 2385. AKANKSHA AUTOMOBILES PVT. LTD.
AMROHA BAREILLY, UTTAR PRADESH - 243002
BAREILLY, UTTAR PRADESH - 243201 (BCN1-BCN-01), NH-87 ,OPPOSITE SHAGUN
PH :0581-2554922.
2355. AKANKSHA AUTOMOBILES PVT. LTD. PH :8756000000, 7607696666. BANQUET HALL, NEAR MILTON ACADEMY
2376. KAVISHA MOTORS PVT LTD (5601-56-01), 4TH
(AO01-AO-01), AMROHA – JOYA ROAD, NEAR BAHRAICH SCHOOL, RAMPUR NAINITAL ROAD, BILASPUR,
KM, RAMPUR ROAD, CLUTTER BUCKGANJ,
PUNJAB NATIONAL BANK, AMROHA, UTTAR DISTRICT – RAMPUR. - 244921
2365. ANAND MOTORS AGENCIES LTD (1301-5Z-05), BAREILLY - 243502
PRADESH, PIN CODE: 244221 - 244221 PH :9917745000.
LUCKNOW ROAD,BEHRAICH,UTTAR PRADESH - PH :8756000000, 7607696666.
PH :7895400003. BISALPUR
271801 2377. ETERNITY MOTORS LLP (5603-56-01), KHASRA
ANPARA NO. 803/2, PILIBHIT BYPASS ROAD, PEER
PH :9519596080. 2386. CORAL MOTORS PVT LTD (CXB1-CXB-01),
2356. STAR CARS (A UNIT OF SARASWATI VEHICLES BALLIA BAHORA, OPP, FUN CITY, BAREILLY, UTTAR KHASRA NO. 668, VILLAGE : BISALPUR, DISTT:
LLP) (NJ02-NJ-01), KAHUWA NALA, AURI-BINA PRADESH. - 243001 PILIBHIT, UTTAR PRADESH - 262201
ROAD, AURI ANPARA, DISTRICT – 2366. DEEP MOTORS (K501-BA-03), MAIDEYPUR, PH :9105555746. PH :9837891846.
SONEBHADRA. - 232101 RAJDHANI ROAD, BALLIA - 277001
BASTI BISWAN
PH :7052547903, 9721905002, 9151154306, PH :9838072917.
9450544961. BALRAMPUR
AONLA

71
Dealer Workshop (AS ON 31.05.2023 )
2387. CONCEPT CARS LIMITED (SEW1-SEW-01), 2397. ATELIER AUTOMOBILES (XK02-XK-01), 2407. KTL PVT. LTD. (2801-TM-04), NH-2, OPP. RTO GORAKHPUR
BILJHARIYA, OPPOSITE-555, BRICK FIELD, OPPOSITE CIVIL COURT, MUZZAFARNAGAR OFFICE, KANPUR ROAD, FATEHPUR - 212601
2418. SMARTWHEELS PVT. LTD. (7201-72-01),
BISWAN - 261201 - 261201 HIGHWAY, DEOBAND - 247001 PH :7408409383, 7408400000.
MOHADDIPUR, (NEAR RAMGARH TAL),
PH :7607696666. PH :7500220011. FEROZABAD GORAKHPUR (U.P.) - 273012
BUDAUN DEORIA 2408. MADHUSUDAN VEHICLES PRIVATE LTD. PH :7705803152.
2388. CORAL MOTORS (P) LTD. (5602-NF-04), PLOT 2398. SMARTWHEELS PVT. LTD. (M601-M6-01), PLOT (DF01-DF-01), 746, ALI NAGAR KEJRA , NEAR 2419. SMARTWHEELS PVT. LTD. (7201-72-06), NEAR T
NO.- 72, BAREILY-MATHURA HIGHWAY, NO. C-7, AND SHED NO. D-3, GOVERNMENT RAJA KA TAL CROSSING, NH 2, FEROZABAD - B HOSPITAL, LACHCHIPUR, NEPAL ROAD,
BUDAUN, UTTAR PRADESH - 132103 INDUSTRIAL ESTATE MEHRA, DEORIA, DIST. 283203 GORAKHPUR - 273012
PH :9837891846. -DEORIA, UTTAR PRADESH. - 274001 PH :9690003077. PH :7705803109.
BULANDSHAHR PH :7705800602. GAJRAULA 2420. SMARTWHEELS PVT. LTD. (7202-72-01), PLOT
DHAMPUR NO.AL-4, SECTOR-9, GIDA, GORAKHPUR. -
2389. SK UNIVERSE (M502-M5-01), KHASRA NO 561 , 2409. AKANKSHA AUTOMOBILES PVT. LTD.
273209
BHOOR, OPP PANDIT PETROL PUMP , 2399. SHAKUMBARI AUTOMOBILES (P) LTD (XD01-XD-01), JHANAKPURI OPPOSITE
PH :9235401004.
BULANSHAHR - 203001 (CPQ1-CPQ-01), KHASRA NO. 205, OPPOSITE, RELIANCE PETROL PUMP, DELHI ROAD,
2421. ARBIT AUTOMOBILES PVT LTD (7203-72-01),
PH :9219694600. UHSA SMARAK SCHOOL, MORADABAD ROAD, GAJRAULA - 244235
ARAZI NO. 66/1/1 MI & 66/2/1MI, 66 MI, MAUZA -
CHAKIA TEHSIL - DHAMPUR, MOJA - ALEHPUR, DIST. PH :9690518865.
MAHEWA MUSTAKIL, NEAR FALMANDI CHOWK,
-BIJNOR, UTTAR PRADESH. - 246761 GHAZIABAD
2390. STAR CARS (A UNIT OF SARASWATI VEHICLES TRANSPORT NAGAR, GORAKHPUR, UTTAR
PH :8630881458.
LLP) (CJH1-CJH-01), KATHSILA NAHER, NEAR 2410. ROHAN MOTORS LTD. (5904-59-01), 432 PRADESH. - 273016
SAINT JOHN’S SCHOOL CHAKIA, DISTRICT – DOMARIAGANJ MUKAND NAGAR, G.T.ROAD, GHAZIABAD - PH :8953412821.
CHANDAULI. - 232101 2400. SMARTWHEELS (SMW1-SMW-01), VILL & POST 201001 GOSAIGANJ
PH :9450544961. – CHAUKHARA, DOMARIAGANJ, DISTT – PH :9971466644
2422. BRIGHT 4 WHEEL SALES PVT. LTD.
CHANDAUSI SIDDHARTH NAGAR - 272193 011-204170810, +911204170816, +911204170826,
(CWK1-CWK-01), KHASRA NO. 24, VILLAGE -
PH :7705800602. +911204170819.
2391. AKANKSHA AUTOMOBILES PVT. LTD. SHEKHANPUR, PARGANA MOHANLALGANJ,
ETAH 2411. REGENT AUTOLINKS (P) LTD (5902-59-01),
(XA01-XA-01), AZAD ROAD, NEAR ROADWAYS, TEHSIL - MOHANLALGANJ, DIST.-LUCKNOW,
A-10/9 INDUSTRIAL AREA, SITE NO 3, MEERUT
CHANDAUSI (BHEEM NAGAR) - 202412 2401. MADHUSUDAN VEHICLES PRIVATE LTD. UTTAR PRADESH. - 226501
ROAD, GHAZIABAD - 201001
PH :7247800008. (XG01-XG-01), 472 ASROLI, GT ROAD, ETAH - PH :9838075929.
PH
CHAURI CHAURA 207125
:0120-4641900,904,911,8744042111,9999740464,9 GREATER NOIDA
PH :9837097894.
2392. ARBIT AUTOMOBILES (SIR1-SIR-01), ARAZI NO 711127008. 2423. ROHAN MOTORS LTD. (T201-T2-01), 63-A,
561 DOMARI KHURD, CHAURI CHAURA, ETAWAH 2412. ROHAN MOTORS (5904-59-02), PLOT NO.46, UDYOG VIHAR, GREATER NOIDA, UTTER
GORAKHPUR - 273201 2402. KULDEEP MOTORS (6E01-6E-01), PAKKA BAGH, MEERUT-DELHI ROAD, MORTA, GHAZIABAD - PRADESH - 201306
PH :8953412821. KANPUR ROAD, ETAWAH - 206001 201102 PH :4513739, 4513736, 4513734,
CHIBRAMAU PH :257029. PH :09310404354 , 9971466644. 4513700/9958506111.
FAIZABAD 2413. T.R. SAWHNEY MOTORS PVT LTD (5905-59-01), HAIDERGARH
2393. KTL PVT. LTD. (BMY1-BMY-01), PLOT GHATA PLOT N0. 96, RAJINDER NAGAR INDUSTRIAL
NO. 70, MAUJA - LALAKPUR, VILLAGE - 2403. SMARTWHEELS PVT. LTD. (7201-F5-02), 2424. BRIGHT 4 WHEEL SALES PVT. LTD.
AREA, MOHAN NAGAR, GHAZIABAD, DISTT. -
CHHIBRAMAU, DIST.-KANNAUJ, UTTAR SAHADAT GANJ, LUCKNOW ROAD, FAIZABAD, (CVU1-CVU-01), PROPERTY SHOP NO. 5, 6 AND
GHAZIABAD, U.P. - 201007
PRADES. - 209721 UTTAR PRADESH. - 224001 7, VILLAGE - GOTAUNA, PARGANA -
PH :9999052148; 9999130612.
PH :7408409200, 9414113666. PH :7705803245. HAIDERGARH, TEHSIL - HAIDERGARH,
2414. SNV AUTO (5906-59-01), PLOT NO. 15, SOUTH
CHITRASENPUR FARIDPUR DISTRICT - BARABANKI. - 225124
SIDE GT ROAD INDUSTRIAL AREA, GHAZIABAD,
PH :9935275786, 9838075929.
2394. AGR (SMM-SMM-01), KHASRA 2404. KAVISHA MOTORS PVT LTD (CEM1-CEM-01), UTTAR PRADESH - 201001 - 201001
PH :9650324325. HAMIRPUR
NO-194,CHITRASENPUR, KACHHUWA ROAD, GATE NO. 216, KASBA SARAI, TEHSIL –
VARANASI, PIN -221313 - 221313 FARIDPUR, DISTRICT – BAREILLY, UTTAR GHAZIPUR 2425. KTL PVT. LTD. (QH01-QH-01), VILLAGE
PH :9889803355. PRADESH. - 243503 RAMEDI,KANPUR ROAD, HAMIRPUR - 210301
2415. AGR AUTOMOBILES PVT. LTD. (8403-KT-03),
DALMAU PH :07895980222, 07895980300. PH :7704907587.
RKBK PETROL PUMP, NEAR BANSI BAZAR,
FARRUKHABAD GAZIPUR - 2333001 HAPUR
2395. KTL AUTOMOBIELS (SGZ1-SGZ-01), DALMAU
ROAD, OPPOSITE BHAGIRATHI GUEST HOUSE 2405. MY CAR PVT. LTD. (2803-TS-04), NEKPUR PH :2361136. 2426. ROHAN MOTORS (6G01-6G-01), DELHI-HAPUR
- 229203 KALAN, FARRUKHABAD - 209625 GHIROR ROAD, OPPOSITE SSV INTERCOLLEGE,HAPUR,
PH :9918451222. PH :9792970093. DISTRICT- GHAZIABAD - 245101
2416. KULDEEP MOTORS (CVA1-CVA-01), KARHAL
DANKAUR FATEHABAD PH :8476853930, 9536129292.
ROAD, TEHSIL – GHIROR, DISTRICT –
MAINPURI, UTTAR PRADESH. - 205121 HARDOI
2396. MOTORCRAFT SALES (HG01-HG-01), OPP. SHRI 2406. KTL PVT. LTD. (BLQ1-BLQ-01), KHASRA NO.
DRONACHARYA DEGREE COLLEGE, DANKAUR, 730/731, GRAM MAUJA, MADAYNA SIKRARA PH :9536755555. 2427. CONCEPT CARS PVT. LTD. (QE01-QE-01),
DIST. - GAUTAM BUDH NAGAR, HARYANA. - MODE, FATEHABAD, DISTRICT – AGRA, UTTAR GONDA NANAK GANJ, LUCKNOW ROAD, HARDOI -
203201 PRADESH - 283111 241001
2417. SMARTWHEELS PVT. LTD. (7201-FZ-07), JANKI
PH :9810289355. PH :9754979019. PH :8756000000, 7607696666.
NAGAR, OPP INDIAN OIL DEPOT, BAHRAICH
DEOBAND FATEHPUR ROAD, GONDA, UTTAR PRADESH, - 271001
PH :7705803261.

72
Dealer Workshop (AS ON 31.05.2023 )
2428. CONCEPT CARS PVT. LTD. (QE01-QE-04), PLOT KANNAUJ 2451. SUMITRA DS (SHY1-SHY-01), GRAM: SAALPUR 2461. SUMITRA DS (M301-M3-01), GATE NO 604, PALIA
NO. 1609 & 1605 GANGA BUX PURVA, BILGRAM NAVADIYAM, NH24, KATRA, TEHSIL - TILHAR, ROAD, NEAR FCI WEAR HOUSE, VILLAGE -
2438. KTL PVT. LTD. (2801-EM-05), PLOT NO. - 377,
ROAD, HARDOI KANPUR HIGHWAY, HARDOI, SHAHJAHANPUR - 242301 BHARDSARIYA, KHERI, LAKHIMPUR - 262702
AKBARPUR, KANNAUJ - 209725
UTTAR PRADESH. - 241001 PH :9336408074. PH :7522888333, 9415770000.
PH :7408409305.
PH :7607696666, 8756000000. KAYAMGANJ LALGANJ
HATHRAS KANPUR
2452. MY CAR PVT. LTD. (CBV1-CBV-01), BYE PASS 2462. KTL AUTOMOBILE PVT. LTD. (CSL2-CSL-01),
2439. KTL PVT. LTD. (2801-28-01), 9/46, BENAJHABAR
2429. DEV MOTORS (P) LTD (B601-LP-03), NEAR ROAD , NEAR KHAN PETROL PUMP, VILLAGE : JEEWAN DEEP COMPOUND, ALLAHABAD
ROAD, HARSH NAGAR, KANPUR - 208002
NAGLA UMMED, ALIGARH ROAD, HATHRAS - KAYAMGANJ , DISTT: FARUKHABAD - 209502 ROAD, LALGANJ, DISTT. RAIBARELLI - 229206
PH :7408409341.
204101 PH :9839029868, 9792970391. PH :9918451222.
2440. MY CAR PVT. LTD. (2803-28-01), 84/54 C, JARIB
PH :9917435500. KHAIR LALITPUR
CHOWKI ,G.T. ROAD, KANPUR - 208003
IGLAS PH :9792970511. 2453. DEV MOTORS (SHQ1-SHQ-01), PLOT 117, 2463. SURI AUTOMOBILES (6001-6J-03), JAHANSI
2430. DEV MOTORS (SOD1-01-SOD-01), MATHURA 2441. KTL PVT. LTD. (2801-28-02), SHVAATRA ALIGARH PALWAL ROAD, VILLAGE CHAMAN SAGAR ROAD, LALITPUR - 284001
ROAD, IGLAS, DISTRICT ALIGARH. - 202124 KRISHNA NAGAR, G T ROAD, KANPUR - 208007 NAGARIYA, KHAIR - 202138 PH :9451496015.
PH :9837549000. PH :7408409253. PH :7351345577. LUCKNOW
ITUNJA 2442. MY CAR PVT. LTD. (2803-28-02), C-16, SITE-1, KHANDAULI 2464. ANAND MOTORS AGENCIES LTD (1301-13-01),
PANKI INDUSTRIAL AREA, KANPUR - 208022
2431. BRIGHT 4 WHEEL (SJD1-01-SJD-01), 90M GATA 2454. MADHUSUDAN MOTORS PVT LTD 11TH KMS, FAIZABAD ROAD, CHINHAT,
PH :9792970086.
GRAM MANDOLI, ITTAUNJA, LUCKNOW, UTTAR (BVV1-BVV-01), KHASRA NO. 97, LUCKNOW - 227105
2443. S B CARS PVT.LTD (2806-28-01), 77B ,
PRADESH-226203. - 226203 AGRA-SADABAD, HATHRAS ROAD, OPP. HDFC PH :7080000462.
FAZALGANZ, KANPUR - 208012
PH :7011482503. BANK, VILL.-KHANDAULI, TEHSIL ETHMADPUR, 2465. KTL AUTOMOBILE PVT. LTD. (1311-13-01),
PH :2241660.
JAGDISHPUR DIST. AGRA, UTTAR PRADESH. - 283126 MATIYARI CHAURAHA, CHINNHAT, FAIZABAD
2444. MY CAR PVT. LTD. (2803-28-05), 88, BLOCK-T,
PH :9837097863, 9690003034. ROAD, LUCKNOW - 227105
2432. BRIGHT 4 WHEEL SALES PVT. LTD. FACTORY AREA, FAZALGANJ, KANPUR - 208004
KHUTAR PH :7408411453.
(XC01-XC-01), PH :9792970081.
2466. ANAND MOTORS AGENCIES LTD (1301-13-02),
KATHORA,MUSAFIRKHANA,LUCKNOW 2445. S B CARS PVT.LTD (2806-28-05), 1/6-7 2455. SUMITRA DS MOTORS PVT LTD (CIO1-CIO-01),
47, NEHRU ROAD, SADAR BAZAR, LUCKNOW -
SULTANPUR ROAD,JAGDISPUR-UTTAR AMBEDKAR PURAM, AWAS VIKASH, VILLAGE – NARAINPUR, VIKRAMPUR GOLA
226016
PRADESH - 227817 KALYANPUR, KANPUR - 208017 ROAD, KHUTAR, DISTRICT – SHAHJAHANPUR,
PH :3098257, 7080000463.
PH :9721526961 , 9628374814. PH :7408525252. UTTAR PRADESH. - 242405
2467. BRIGHT 4 WHEEL SALES PVT. LTD.
JAGNER 2446. KULDEEP MOTORS KANPUR LLP. (2808-28-01), PH :9336408074.
(1305-13-01), 11/CP- 6, VIKAS NAGAR, RING
BUKHAND NO. 756, 756A, 757, BLOCK: W, KIRAOLI
2433. MERAK VEHICLES (SPJ1-SPJ-01), SHRI RAM ROAD, LUCKNOW - 226022
YOJNA: 2, JUHI KALAN, BARRA BYE PASS,
GARDEN, AGRA ROAD, NEAR RADHA KRISHNA 2456. PREM MOTORS PVT. LTD. (BJZ1-BJZ-01), PH :2739501.
KANPUR. - 208017
MANDHIR, JAGNER, UTTAR PRADESH, 283115 - GOVIND PALACE, NEAR KIRAWALI TEHSIL, 2468. ONE UP MOTORS INDIA PVT. LTD. (1306-13-01),
PH :9076608701.
283115 AGRA – JAIPUR HIGHWAY, KIRAWALI, C-16A,TRANSPORT NAGAR,KANPUR ROAD,
2447. KTL PVT. LTD. (2801-28-07), ARAZI NO. 1110,
PH :7896500400. DISTRICT – AGRA, UTTAR PRADESH. - 283122 LUCKNOW, KANPUR ROAD, LUCKNOW - 226012
VILLAGE BAIRI, AKBARPUR, KACHHAR, INDIRA
JALALABAD PH :9690010799. PH :9918100801.
NAGAR, KANPUR, UTTAR PRADESH - 208 026
KOSI 2469. KTL AUTOMOBILE PVT. LTD. (1311-13-02),
2434. SUMITRA DS MOTORS PVT. LTD. PH :7408409379.
INDRA NAGAR, OPP. HALFAIZABAD ROAD,
(GJX1-GJX-01), GRAM: SUJAWALPUR, BARIELLY KARWI 2457. UMA MOTORS PVT. LTD. (CPV1-CPV-01), LUCKNOW, UTTAR PRADESH - 226016
ROAD, TEHSILL: JALALBAD, DIST. 2448. MY CAR PVT. LTD. (CBU1-CBU-01), ARAJI NO. KHASRA NO. 245, CITY - KOSI, DIST.-MATHURA. PH :7408411478.
SHAHJHANPUR - 242221 58, MAUJA - AMANPUR, TEHSIL - KARWI, DIST. - 281004 2470. KTL AUTOMOBILE PVT. LTD. (1311-13-03),
PH :9336408074, 9897019488. -CHITRAKOOT, UTTAR PRADESH. - 210205 PH :9997683333, 9997511006. BEHIND N S KOHLI PETROL PUMP, SARDARI
JAUNPUR PH :9839029868, 9792970391. KUBERPUR KHEDA, KANPUR ROAD, ALAMBAGH, LUCKNOW
2435. KIRTIKUNJ AUTOMOBILES PVT. LTD. KASGANJ 2458. KTL PVT. LTD. (6606-CRU-04), KHASRA - 226005
(6H01-6H-01), KHANPUR AKBAR, KUTTUPUR NO.248,249,251, NAWALPUR, BHAGPUR, PH :9918451222.
2449. MADHUSUDAN VEHICLES PRIVATE LTD.
TIRAHA - 222001 POST-ETHMADPUR, NH-2, KUBERPUR, AGRA, 2471. ANAND MOTORS AGENCIES LTD (1301-13-04),
(BVX1-BVX-01), ARAJI NO. 646, SAURO ROAD,
PH :9554951026. UTTAR PRADESH - 282006 G-3, LDA MARKET, ALIGANJ, LUCKNOW -
KASGANJ, DISTRICT – KASGANJ, UTTAR
PH :8449715099. 226024
JHANSI PRADESH. - 207123
PH :4103406/407/408, 7080000464.
2436. SURI AUTOMOBILES (6001-60-01), BALAJI UNNA PH :9837097863, 9690003034. KUNDA
2472. ONE UP MOTORS INDIA PVT. LTD. (1306-13-03),
ROAD, ANSAL COLONY, JHANSI PIN – 284002. - KASIA 2459. SARASWATI MOTORS (CBF2-CBF-01), CHHANNILAL CROSSING, MANDIR MARG,
284002 2450. ARBIT AUTOMOBILES PVT LTD (GMJ1-GMJ-01), ALLAHABAD-LUCKNOW HIGHWAY, KUNDA, LUCKNOW - 226005
PH :8881811383. MAUJA BHAISAHA, HETIMPUR KASIA, DISTRICT PRATAPGARH. - 230204 PH :9918500451.
2437. VELOCITY CARS (A UNIT OF BASERA VELOCITY KUSHINAGAR, UTTAR PRADESH - 274206 PH :8090854005. 2473. BRIGHT 4 WHEEL SALES PVT. LTD.
AUTOHUB PVT. LTD) (6002-60-01), PLOT NO 486, PH :8953412821. LAKHIMPUR (1305-13-02), PARGANNA MOHANNA, STP
487, 488, 489 AND 477 (PATTA NUMBERS), ROAD, CHATMEEL, LUCKNOW - 226021
KATRA 2460. SUMITRA DS MOTORS PVT LTD (W201-M3-02),
MAUZA - KOCCHABHANWAR, BLOCK - PH :9838075960.
GATA NO. 66, LRP ROAD, TOWARDS GOLA,
BADAGAON, TEHSIL AND DISTT - JHANSI. -
LAKHIMPUR KHERI - 242001
284128
PH :7522888333, 9415770000.
PH :9889440999.

73
Dealer Workshop (AS ON 31.05.2023 )
2474. BRIGHT 4 WHEEL SALES PVT. LTD. (1305-II-04), MAHOBA 2494. VELOCITY CARS (A UNIT OF BASERA VELOCITY 2504. AKANKSHA AUTOMOBILES PVT. LTD.
PLOT NO: 57 TO 60, KAUSHALABAD, BADHAULI AUTOHUB PVT. LTD) (GJJ1-GJJ-01), BASERA (B401-B4-01), DELHI ROAD, 5TH.KM,
2485. SURI AUTOMOBILES (6001-RM-02), NEAR
BKT, PARGANA MOHANNA, SITAPUR ROAD, CITY, MAURANIPUR - GARUTHA ROAD, MORADABAD (U.P.) - 244001
PARMANAND CHOWK, GANDHINAGAR,
BAKSHI KA TALAB, LUCKNOW - 226020 MAURANIPUR, DISTT: JHANSI, UTTAR PH :7247800008.
MAHOBA, UTTAR PRADESH, - 284001
PH :7317049000. PRADESH - 284204 2505. AKANKSHA AUTOMOBILES PVT. LTD.
PH :244344, 9451496015.
2475. BRIGHT 4 WHEEL SALES PVT. LTD. PH :8299202863. (B401-B4-03), 5TH KM DELHI ROAD,
2486. VELOCITY MOTORS (RM02-RM-01), BAJRANG
(1305-13-05), PLOT NO. 68, BUTLER GANJ, MAWANA MORADABAD - 244001
CHOWK, SAGAR-KANPUR HIGHWAY, MAHOBA -
BAALU ADDA, LUCKNOW. - 226001 PH :7895600007.
210427 2495. RADHA GOVIND AUTOMOBILES PVT LTD
PH :8756000000, 7607696666. 2506. AKANKSHA AUTOMOBILES PVT. LTD.
PH :9560998709. (CWZ1-CWZ-01), MAIN SHANTI NAGAR ROAD,
2476. MEGA MOTORS (A UNIT OF AKM MOTORS PVT. (B401-B4-04), KHASRA NO. 569-570, VILLAGE –
MAHOLI MAWANA KALAN, SUBDIVISION HASTINAPUR,
LTD) (1313-13-01), CP1 (COMMERCIAL PLOT 1), KAJIPURA, KANT ROAD, MORADABAD, UTTAR
TEHSIL MAWANA, DISTRICT MEERUT - 250401
VIBHAV KHAND, GOMTI NAGAR, LUCKNOW. - 2487. CONCEPT CARS PVT. LTD. (CWS1-CWS-01), PRADESH. - 244001
PH :9012575727.
226 010 MUSKAN TRACTORS, NEAR MELA MAIDAN, PH :7895500007.
PH :9935096417, 7054631666. SHAHJHANPUR ROAD, MAHSUNIYAGANJ, MEERUT MUZAFFARNAGAR
2477. KTL AUTOMOBILE PVT. LTD. (1311-13-07), MAHOLI, DIST.-SITAPUR, UTTAR PRADESH. - 2496. TANYA AUTOMOBILES PVT. LTD. (4802-48-01),
2507. RADHA GOVIND (H903-H9-01), NH -58 ,121 KM
B-6/1A, AMAUSI INDUSTRIAL AREA, 261141 GOVT. INDUSTRIAL TRAINING INSTITUTE,
STONE, BY-PASS ROAD, NEAR TRANSPORT
NADARGANJ, LUCKNOW, UTTAR PRADESH. - PH :7607696666. BACHHA PARK, MEERUT - 250001
NAGAR, MUZAFFARNAGAR - 251001
226008 MAHRONI PH :9837077003.
PH :9760092009.
PH :7800007376. 2497. TANYA AUTOMOBILES PVT. LTD. (4802-48-03),
2478. BRIGHT 4 WHEEL SALES PVT. LTD. 2488. SURI AUTOMOBILES (CGN1-CGN-01), LALITPUR
90, NAUCHANDI GROUND,GARH ROAD, NAJIBABAD
(1305-13-06), KHASRA NO. 418, MISHRAPUR ROAD, MEHRONI, DISTRICT – LALITPUR, UTTAR
MEERUT - 250001 2508. SHAKUMBARI AUTOMOBILES (P) LTD
PARGANA MAHONA, KURSI ROAD, LUCKNOW. - PRADESH. - 384405
PH :9837077004. (CPS1-CPS-01), NEAR BUS STAND, BIJNORE
226022 PH :7705000558, 8881811383.
2498. RADHA GOVIND AUTOMOBILES PVT. LTD. BYPASS ROAD, NAJIBABAD, DIST.-BIJNORE,
PH :9935275786. MAINPURI (4807-48-01), VILLAGE – BARAL, KUNDA GATE UTTAR PRADESH. - 246 701
2479. ONE UP MOTORS INDIA PVT. LTD. (1314-13-01), 2489. KULDEEP MOTORS (6E01-SG-02), SKP-4A, NEAR YOGI FARM HOUSE, PARTAPUR, DELHI PH :9045815209.
KHASRA NO. 20 TO 25, 30, 35, 37, 42, 43, 45, 47, MAINPURI - 205001 ROAD, MEERUT. - 250002 NAUGARH
48, 49, 67, 68, 71 & 99, RAJJABGANJ, HARDOI PH :9235258444. PH :9821217610.
ROAD, LUCKNOW. - 226003 2509. SMARTWHEELS PVT. LTD. (QG01-QG-01), NEAR
MALIHABAD 2499. TANYA AUTOMOBILES PVT. LTD. (4802-48-04),
PH :9821026545, 7800005200. PAKARI CHAURAHA, NAUGARH ROAD,
MUNICIPAL NO. 9, 9/2, 9/3, 9/4, 11, 11/1, VILLAGE
2480. MEGA MOTORS (A UNIT OF AKM MOTORS PVT. 2490. ONE UP MOTORS INDIA PVT. LTD. SIDDHARTHNAGAR - 272205
- ROSHANPUR DORLI, OPP. KONARK COLONY,
LTD) (1313-13-02), KHASRA NO. 614, VILLAGE: (BOD1-BOD-01), KHASRA NO. 326/1 AND 327, PH :7705803129.
NEAR RAJMANDIR MANDAP, ROORKEE ROAD,
BHADRUKH, VIP CANNEL RINGI ROAD, DEVI VILLAGE PARGANA, TEHSIL – MALIHABAD, TEHSIL - SARDHANA, MEERUT, U.P. - 250001 NAUTANWA
KHERA, TELIBAGH (VIP ROAD), TEHSIL: DISTRICT – LUCKNOW, UTTAR PRADESH. - PH :7900201515. 2510. SMARTWHEELS PVT LTD (SDW1-SDW-01), OPP.
SAROJNI NAGAR, 227111
MIRZAPUR RAJIV GANDHI DEGREE COLLEGE, BYPASS
LUCKNOW, U�AR PRADESH 226002 - 226002 PH :9918100781.
ROAD, NAUTANWA, DISTT – MAHARAJGANJ -
PH :6388901514. MANDURI 2500. STAR CARS (6K02-6K-01), PILI KOTHI, STATION
273164
ROAD, MIRZAPUR, UTTAR PRADESH - 231001
MADHOGANJ 2491. DEEP MOTORS (K501-K5-04), VILLAGE – PH :77058 00602.
PH :7052547903, 9721905002, 9151154306,
2481. CONCEPT CARS PVT. LTD. (BHI1-BHI-01), BALDEV MADURI, TEHSIL – SAGRI, DISTRICT – 9450544961. NAWABGANJ
KANPUR ROAD, NEAR RAILWAY CROSSING, AZAMGARH, UTTAR PRADESH. - 276138
MISHRIKH 2511. KAVISHA MOTORS PVT LTD (CHT1-CHT-01),
MADHOGANJ DIST. HARDOI. - 241001 PH :09838072902.
VILLAGE – EIDH JAGIR NEAR GURUDWARA AT
PH :220016, 220064, 7607696666. MATHURA 2501. CONCEPT CAR (SKJ1-SKJ-01), NEAR
NH-74, TEHSIL – NAWABGANJ, DISTRICT –
ARYAVART BANK, SITAPUR ROAD, MISHRIKH,
MAHARAJGANJ 2492. UMA MOTORS PVT. LTD. (H801-H8-01), 68, BAREILLY. - 262406
SITAPUR, U.P, PINCODE: 261401 - 261401
2482. SMARTWHEELS PVT. LTD. (EI01-EI-01), NEAR MAHOLI,NEAR JAI GURUDEV TEMPLE, NH-2, KM PH :07895980222, '07895980300.
PH :7607696666.
PHARENDA TAXI STAND, NAHAR ROAD, PIPAR STONE 146, MATHURA - 281004
MODINAGAR NIGOHA
DEORA, MAHARAJGANJ, DIST. MAHARAJGANJ, PH :2463043/ 6290700.
2512. BRIGHT 4 WHEELS (SGV1-SGV-01), GATA NO
UTTAR PRADESH. - 273303 MATI 2502. MOTORCRAFT SALES PVT. LTD. (5903-M7-02),
146, VILL NIGOHA, TEHSIL MOHANLALGANJ,
PH :7705800602, 7705803109. OPPOSITE SONIA ENCLAVE, ADJACENT
2493. MEGA MOTORS (A UNIT OF AKM MOTORS PVT. LUCKNOW - 226302
2483. KTL AUTOMOBILE PVT. LTD. (CSM2-CSM-01), SUMAN CINEMA, NH-58, MODINAGAR - 201204
LTD) (SCG1-SCG-01), GATA NO 761, NEAR MATI PH :7011482503.
MUNNA MARKET HAIDERGARH ROAD TOWN PH :09557338222 & 07042427140.
POLICE CHOWKI, VILLAGE- MATI, PARGANA-
MOHANLAL GANJ NOIDA
AREA, TEHSIL – MAHARAJGANG, DISTRICT –
DEWA, TEHSIL- NAWABGANJ, BARABANKI,
RAIBAREILLY, UTTAR PRADESH. - 229306 2513. ROHAN MOTORS LTD. (A102-A1-01), C-8/9,
UTTAR PRADESH - 225 003 2503. BRIGHT 4 WHEEL SALES PVT. LTD.
PH :99184512222. SECTOR - I, NOIDA - 201301
PH :6388901514. (BWU1-BWU-01), KHASARA PLOT NO.581,
MAHMUDABAD PH :4071900, 4071909, 4071931, 4071932,
MAURANIPUR VILLAGE PURSANI, PARGANA AND TEHSIL
4071209, 4071949/9582210152.
2484. CONCEPT CARS PVT. LTD. (AAN1-AAN-01), IN MOHANLALGANJ, LUCKNOW DISTT., UTTAR
2514. ROHAN MOTORS LTD. (A102-A1-02), C-11,
FRONT OF POWER HOUSE, SIDAULI ROAD, PRADESH - 227305
SECTOR-1, NOIDA, UTTAR PRADESH - 201301
MAHMOODABAD (U.P.) - 261203 PH :7571905966.
PH :4071900, 209,31,32/9582210152.
PH :7607696666, 8756000000. MORADABAD

74
Dealer Workshop (AS ON 31.05.2023 )
2515. FAIR DEAL PREMIUM WHEELS PVT.LTD. 2527. BRIGHT 4WHEELS (2905-29-01), ARAZI NO 390 2536. FAIR DEAL WHEELS PVT. LTD (08E1-M9-01), 2546. RADHA GOVIND AUTOMOBILES PVT. LTD.
(A108-A1-01), D-39, SEC-10, NOIDA - 201301 AND 389 AT KATKA, ANDAWA SAHSON 12/67 SITE 4, INDUSTRIAL AREA,,SAHIBABAD, (XJ01-XJ-01), KHERI KARMU, OPPOSITE
PH :08448296694 & 09654326008. BYPASS, PRAYAGRAJ - 211002 GHAZIABAD - 110095 POWER HOUSE, PANIPAT-KAIRANA ROAD,
2516. VIPUL MOTORS PVT. LTD. (A101-A1-02), B-124 & PH :9415324201. PH :4740409/102/436, SHAMLI UTTAR PRADESH - 247776
B-125, SECTOR – 5, NOIDA, UTTAR PRADESH - PURANPUR 8860088659. PH :8979862084.
201301 2537. MOTORCRAFT SALES PVT. LTD. (5903-M9-01), SHIKOHABAD
2528. CORAL MOTORS (P) LTD. (CAD1-CAD-01),
PH :4603100/28/33/8527835888. S-7 SITE-IV, SAHIBABAD INDUSTRIAL AREA,
KHASRA NO. 768 & 770, VILLAGE – KHAMRIYA 2547. MADHUSUDAN VEHICLES PRIVATE LTD.
2517. VIPUL MOTORS PVT. LTD. (A106-A1-01), J-14, NEAR DABUR CHOWK, SAHIBABAD - 201010
PATTI, PURANPUR – PILIBHIT ROAD, TEHSIL (XH01-XH-01), 2508, KATRA MIRA,
SECTOR-63, NOIDA, DISTT. GAUTAM BUDDH PH :4172222 / 4102222, 09958562222 &
AND PARGANA – PURANPUR, DIST. PILIBHIT. - MAHAMMABAD, OPP PROFESSOR COLONY, NH
NAGAR (U.P.) - 201301 09560605122.
262124 2, BYE PASS ROAD, SHIKOHABAD, DISTT:
PH :4758600/01/02/8448589759. 2538. T.R. SAWHNEY MOTORS PVT LTD (0819-M9-03),
PH :9837891846, 9927001120. FIROZABAD,UTTAR PRADESH - 283203
2518. MOTORCRAFT SALES PVT. LTD. (5903-A1-04), 28/1/1, SITE-IV, SAHIBABAD INDUSTRIAL
RAIBAREILLY PH :9837097894,9690003001.
PLOT NO.15, SECTOR-140, NOIDA (U.P.) - AREA,DISTT- GHAZIHABAD, UTTAR PRADESH -
201305 2529. KTL AUTOMOBILE PVT. LTD. (HS07-HS-01), 201010 SIDHAULI
PH :09818532222 & 09971733233. PLOT NO. 1550, GULLUPUR, P O KATWARA, PH :9999399152; 9999399143. 2548. CONCEPT CARS PVT. LTD. (BFO1-BFO-01), R/O
2519. MOTORCRAFT SALES (5903-A1-05), PLOT NO 19 HIJARCHANDRAPUR, RAIBAREILLY - 229303 SALEMPUR MISHRIKH ROAD NOROTTAM NAGAR,
ECOTECH 12 GREATER NOIDA WEST ,GB PH :7800001601. DAKSHIDI, OPP. BLOCK, SIDHAULI, SITAPUR. -
2539. SMARTWHEELS PVT LTD (GKA1-GKA-01),
NAGAR , UP - 201306 RAM SANEHI GHAT 261303
GHATA NO. 48, GRAM: DEVPAR, TEHSILL:
PH :8826312222. PH :7607596666.
2530. BRIGHT 4WHEELS (SDH1-SDH-01), GATA NO 76, SALEMPUR, PARGANA: SALEMPUR
ORAI MAUJHAULI, DISTT: DEORIA - 274509 SIKANDRA
VILLAGE - BHENDUWA BRAHMANAN, TEHSIL -
2520. S B CARS PVT.LTD (2806-LU-02), KANPUR RAM SANEHI GHAT, BARABANKI, UTTAR PH :7705800602, 7705803321. 2549. KTL PVT LTD (SJE1-SJE-01), YADAV MARKET,
ROAD, ORAI - 285001 PRADESH, PIN 225409 - 225409 SALON NEAR SURYA DHABA, NH-19,
PH :9307219303. PH :9935275786. ETAWAH-KANPURROAD, SIKANDRA, U.P. -
2540. KTL AUTOMOBILES (SCP1-SCP-01), SALON
PADRONA RAMNAGAR BYPASS, PARSHEDAPUR ROAD, SALON,
209715
PH :9414113666.
2521. SMARTWHEELS PVT. LTD. (BGJ1-BGJ-01), 2531. BRIGHT 4 WHEEL SALES PVT. LTD. DISTRICT RAIBARELLI, UTTAR PRADESH -
AARJI NO. 37 & 38, MAUJA - BELWA MISRA, (BRK1-BRK-01), KHASRA NO. 629, VILLAGE - 229127 SIKANDRABAD
TAPPA PAKDI, PARAGNA - SIDHUWA JAUBNA, BUDHAWAL, TEHSIL - RAMNAGAR, DIST. PH :9918451222. 2550. SK UNIVERSE (CWQ1-CWQ-01), NEAR R K
TEHSIL - PADRAUNA, DIST.-KUSHINAGAR, -BARABANKI, UTTAR PRADESH. - 225205 SAMBHAL SCHOOL, VILLAGE – SANWALI SIKANDRABAD ,
UTTAR PRADESH. - 274304 PH :9935275786, 9838075929. DIST - BULANDSHAHR UTTAR PRADESH , PIN
2541. AKANKSHA AUTOMOBILES PVT. LTD.
PH :7705803259. RAMPUR 203202 - 203202
(BBP1-BBP-01), PLOT NO. 303, NEAR TAJ MILK
PANWARI FACTORY, MORADABAD SAMBHAL ROAD,
PH :7310106565.
2532. AKANKSHA AUTOMOBILES PVT. LTD.
2522. SURI AUTOMOBILES (SLC1-SLC-01), PANWARI, (B401-6L-02), SHAHZAD NAGAR BAREILLY SAMBHAL, UTTAR PRADESH - 244302 SITAPUR
NEAR RAM LEELA GROUND, TEHSIL ROAD RAMPUR PH :9997776876. 2551. CONCEPT CARS PVT. LTD. (QE01-6M-02),
KULPAHAR, DISTRICT MAHOBA. - 210429 UTTAR PRADESH - 244901 SANDILA LUCKNOW-DELHI ROAD, NH-24, VILLAGE
PH :9452287690. PH :7248000002. JAMMAYAPUR, SITAPUR - 261001
2542. CONCEPT CARS PVT. LTD. (WY01-WY-01),
PAPHUNDA RAYA PLOT NO.371, SARAY MARUFPUR, LUCKNOW
PH :7607696666, 8756000000.
2523. TANYA AUTOMOBILES (4802-SIB-05), 354/1, 2533. UMA MOTORS PVT. LTD. (BXK1-BXK-01), ROAD, SANDILA-241204 DISTT. HARDOI. - SIYANA
MAIN HAPUR ROAD, PHAPHUNDA. - 245206 CHAUDHARY PADAM SINGH MARKET, NEAR 241204 2552. SK UNIVERSE (SIN1-SIN-01), BULANDSHAHR
PH :93193 24588. INDIA INTER COLLEGE, RAYA - MAANT ROAD, PH :8756000000, 7607696666. ROAD, SIYANA DIST- BULANDSHAHR, UTTAR
PEPPEGANJ RAYA, DISTT. MATHURA (U.P.) - 281204 SARDHANA PRADESH PIN CODE 203412 - 203412
PH :9997683333, 9997511006. PH :9219694600.
2524. ARBIT AUTOMOBILES PVT LTD (GKG1-GKG-01), 2543. RADHAGOVIND AUTOMOBILES (MM01-MM-01),
GHATA NO. 466, 465 & 472, PEPPEGANJ, ROBERTSGANJ DAURALA ROAD, NEAR RADHASWAMI SULTANPUR
MOUZA - SAHABGANJ, TEHSIL - CAMPIERGANJ, 2534. STAR CAR (CTY1-CTY-01), UMRAURA, PIMPRI SATSANG, SARDANA - 250342 2553. KIRTIKUNJ AUTOMOBILES PVT. LTD.
DISTT: GORAKHPUR - 273165 ROAD, ROBERTSGANJ, UTTAR PRADESH. - 231 PH :7456003222. (N101-N1-01), SHAURYAMAU, MIRANPUR,
PH :89534 12821. 216 SHAHABAD VARANSI-LUCKNOW HIGHWAY, NH-56
PILIBHIT PH :7052547903, 9721905002, 9151154306,
2544. CONCEPT CARS PVT. LTD. (AAX1-AAX-01),
(FAIZABAD BYPASS) SULTANPUR - 228001
9450544961. PH :227760 , 220107.
2525. CORAL MOTORS (P) LTD. (IL01-IL-01), BISALPUR VILLAGE MUJAGADH, SHAHABAD - 241124
ROAD, PILIBHIT, U.P. - 262001 SAHARANPUR PH :8756000000, 7607696666. SWAR
PH :9837891846. 2535. ATELIER AUTOMOBILES (S203-S2-01), NEAR SHAHJAHANPUR 2554. AKANKSHA AUTOMOBILES PVT. LTD.
PRAYAGRAJ BARI NAHAR, AMBALA ROAD, SAHARANPUR -
2545. SUMITRA DS MOTORS PVT LTD (W201-W2-01),
(CQX1-CQX-01), IN FRONT OF EIDGAH, TEHSIL
247001 – SWAR, DISTRICT – RAMPUR, UTTAR
2526. SARASWATI MOTORS (2904-29-01), PLOT NO SITAPUR ROAD, NH-24, SHAHJAHANPUR -
PH :7500250042. PRADESH. - 244924
24, INDUSTRIAL AREA MNIT COLLEGE, 242001
SAHIBABAD PH :9528004006.
TELIYARGANJ, PRAYAGRAJ, UTTAR PRADESH. PH :7522888333, 9415770000.
- 211004 SHAMLI TAMBOUR
PH :8090854053.

75
Dealer Workshop (AS ON 31.05.2023 )
2555. CONCEPT CARS (SOB1-SOB-01), NEAR INDIAN 2565. NAINITAL MOTORS PVT LTD (J603-SQ-04), 2576. FUTURE AUTO WHEELS PVT LTD (BRI1-BRI-01), 2586. AKANKSHA AUTOMOBILES (RUDRAPUR) PVT
GAS GANJAR, SITAPUR ROAD TAMBOUR - PAWAR BHAWAN, JOSHI KHOLA RAJPURA, 26, MISSARAWALA, DOIWALA, DISTRICT – LTD (DG02-DG-01), BAZPUR ROAD, KASHIPUR -
261208 PITHRAGARH ROAD, ALMORA - 263601 DEHRADUN, UTTARAKHAND. - 248140 244713
PH :7607696666. PH :9997194132. PH :7983071196. PH :7307704864.
THAKURDWARA BAGESHWAR GADARPUR KHATIMA
2556. AKANKSHA AUTOMOBILES PVT. LTD. 2566. NAINITAL MOTORS PVT LTD (J603-8I-05), VILL. 2577. AKANKSHA AUTOMOBILES (RUDRAPUR) PVT 2587. AKANKSHA AUTOMOBILES (RUDRAPUR) PVT
(KO01-KO-01), 2 KM. MORADABAD ROAD, NEAR BILOMA,SERA, BAGESHWAR, UT, LTD (CVS1-CVS-01), BHASIYA MOD, RUDRAPUR LTD (XL02-XL-01), VILLAGE: CHARUBETA,NEAR
JEETA KA DHABA, SAHAB GANJ (MUNSHI BAGESHWAR - 263642 ROAD, GADARPUR, UDHAM SINGH NAGAR, RTO CHECK POST,PILIBHIT ROAD KHATIMA,
GANJ), THAKURDWARA, DISTT. MBD. UTTAR PH :9557200522. UTTARAKHAND. - 263152 U.S NAGAR,UTTRAKHAND - 262308
PRADESH - 244601 BAZPUR PH :9258156028. PH :8191000132.
PH :9917224562. GAIRSAIN KOTDWAR
2567. AKANKSHA AUTOMOBILES (RUDRAPUR) PVT
TILOI LTD (CGU2-CGU-01), KHASRA NO. 96/2, 2578. ROHAN MOTORS LTD (CRH1-CRH-01), KHASRA 2588. SHAKUMBARI AUTOMOBILES (P) LTD
2557. KTL AUTOMOBILE PVT. LTD. (CGY2-CGY-01), VILLAGE – BHONA, ISLAM NAGAR, TEHSIL – NO. 1048, RANIKHET ROAD, OPP. GIC GROUND, (6N02-2I-02), PLOT NO.23 & 30 INDUSTRIAL
VILLAGE PURE LANGDA, PAKAR GAON, MOHAN BAZPUR, UTTARAKHAND. - 262401 GAIRSAIN, DISTRICT – CHAMOLI, UTTARA ESTATE, SITABPUR, KOTDWAR, DIS. PAURI
GUNJ, TEHSIL - TILOHI, DIST.-RAIBARELI. - PH :9634151501. KHAND. - 246428 (GARHWAL), UTTRAKHAND - 249001
229309 CHAMPAWAT PH :8755839951. PH :8755998075, 7310106565.
PH :99184512222. GANGOLIHAT LAKSAR
2568. AKANKSHA AUTOMOBILES (RUDRAPUR) PVT
UJHANI LTD (SF02-SF-01), TANAKPUR LOHAGHAT 2579. NAINITAL MOTORS (CODE UNDER 2589. SHAKUMBARI AUTOMOBILES (CTF1-CTF-01),
2558. ETERNITY MOTORS LLP (GJK1-GJK-01), ROAD, CHAMPAWAT, UTTARAKHAND - 262523 CREATIONS-CODE UNDER CREATIONS-CODE HARIDWAR ROAD, LAKSAR - 247664
BADAUN BYE PASS ROAD, UJHANI - 243639 PH :8929400545, 8191000832. UNDER CREATIONS), VILL- KHETIGARA, PH :8630087926.
PH :94122 89074. CHAUKHUTIYA PITHORAGARH-GANGOLIHAT ROAD, NANAKMATA
UNCHAHAR GANGOLIHAT, DISTT: PITHORAGARH - 262522
2569. NAINITAL MOTORS PVT LTD (CVG1-CVG-01), 2590. AKANKSHA AUTOMOBILES (RUDRAPUR) PVT
PH :9997093043.
2559. KTL AUTOMOBILE PVT. LTD. (IH02-IH-01), NH-58, BADRINATH ROAD, CHAUKHUTIYA, LTD (CVT1-CVT-01), KHATIMA ROAD, OPP
ALLAHABAD LUCKNOW ROAD, NEAR PURANA DIST.-ALMORA, UTTARAKHAND - 263656 GOPESHWAR GURURAMDAS HOSPITAL, NANAKMATTA, U.S.
PETROL PUMP, WARD NO. 5, UNCHAHAR, PH :9997026565. 2580. ROHAN MOTORS LTD. (5702-MV-03), CHOPTA NAGAR, UTTARAKHAND. - 262311
DISTT: RAIBARELI - 229404 DEHRADUN MANDAL ROAD, NEAR FOREST GATE, PH :7830033763.
PH :99184512222. GOPESHWAR - 131028 PITHORAGARH
2570. ROHAN MOTORS LTD. (5702-57-01), 130/1
UNNAO PH :9634852898.
CHAKRATA ROAD, YAMUNA COLONY, 2591. NAINITAL MOTORS PVT LTD (J603-NM-03),
2560. S B CARS (2806-KL-04), HUSSAIN NAGAR DEHRADUN - 248001 HALDWANI VILLAGE PANDA, ODSAINI, DHARCHULA ROAD,
BYPASS,KANPUR-LUCKNOW HIGHWAY ROAD, PH :9997036800. 2581. NAINITAL MOTORS PVT LTD (J603-J6-01), PITHORAGARH - 262501
UNNAO,U.P. - 209801 2571. DD MOTORS (A DIVISION OF D.D. PREM VILLAGE JEETPUR NEGY, 5TH KM RAMPUR PH :9634092692.
PH :9839806451. PVT.LTD.) (5707-57-01), 918/221, PATEL NAGAR, ROAD, HALDWANI - 263139 RAMNAGAR
VARANASI INDUSTRIAL AREA, DEHRADUN - 248001, PH :7060201024.
2592. NAINITAL MOTORS PVT LTD (XM01-XM-01),
PH :9368193007. 2582. NAINITAL MOTORS PVT LTD (J603-J6-02), KALA
2561. VARANASI MOTORS PVT. LTD. (8402-84-01), OPP. GAYATRI VIHAR, VILL. BASAI, 7TH KM.
2572. ROHAN MOTORS LTD. (5702-57-02), 257/2, GMS DUNGI ROAD, NEAR HARIPRIYA BANQUET
THE MALL, CANTONMENT, VARANASI - 221001 KASHIPUR ROAD, RAMNAGAR - 244137
ROAD,,VILL. NIRANJANPUR, ADJ TO KAMLA HALL, KATHGHARIYA, HALDWANI - 263139
PH :2509068, 2509069. PH :9639016895.
PALACE, DEHRADUN - 248001 PH :8126359222.
2562. AGR AUTOMOBILES PVT. LTD. (8403-84-01), RANIKHET
PH :8630956832, 9897227227. HARIDWAR
B-38/2A, MAHMOORGANJ, GOPAL VIHAR,
2573. FUTURE AUTO WHEELS PVT LTD (5706-57-01), 2593. NAINITAL MOTORS PVT LTD (AXA1-AXA-01),
VARANASI - 221010 2583. SHAKUMBARI AUTOMOBILES (P) LTD
KHASRA NO. 8KHA, MOHABEWALA GANYADYOLI, NEAR DRUG FACTORY,
PH :2360436. (6N02-6N-01), E-5/6, INDUSTRIAL AREA,
INDUSTRIAL AREA, DEHRADUN, - 248001 RANIKHET DISTT. ALMORA (UTTARAKHAND) -
2563. VARANASI MOTORS PVT. LTD. (8402-84-03), HARDWAR - 249407
PH :0135-2640263, 7895956011. 263645
AARAJI NO.2 AND 48, G.T. ROAD, TODAPUR, PH :9897476897.
2574. FUTURE AUTO WHEELS (5706-57-02), PH :9557243222.
MOHANSARAI, RAJATALAB, VARANASI (U.P.) - JASPUR
MUNICIPAL NUMBER 45 AND 46, RAJPUR ROAD, RISHIKESH
221311
DEHRADUN, PIN: 248001 - 248001 2584. AKANKSHA AUTOMOBILES (RUDRAPUR) PVT
PH :2632786, 9838360662. 2594. FUTURE AUTO WHEELS PVT LTD
PH :9760444430. LTD (BKL2-BKL-01), GANGUWALA, INFRONT OF
2564. AGR AUTOMOBILES PVT. LTD. (8403-84-04), (AAS1-AAS-01), 640, LAXMAN JHULA ROAD,
ARAZI NO. 399, 398, 400, 401,NH2 PANDITPUR, DIDIHAT ROOPAM CONVENT, KASHIPUR ROAD,
RISHIKESH. DISTT. DEHRADUN, UTTARAKHAND
JASPUR, UTTARAKHAND. - 244712
DEHAT AMANAT, TEHSIL - RAJATALAB, 2575. NAINITAL MOTORS (SKN1-SKN-01), SUBHASH - 249201
PH :8958023786.
VARANASI - 221112 CHANDRA BOSE WARD, NEAR D.I.E.T, DIDIHAT, PH :7409241219.
PH :98898 03355. DISTT PITHORAGARH, PINCODE: 262551. - KARANPRAYAG
ROORKEE
262551
UTTARAKHAND PH :9634092692.
2585. ROHAN MOTORS LTD (CRG1-CRG-01),
2595. SHAKUMBARI AUTOMOBILES (P) LTD
BADRINATH ROAD, KARANPRAYAG, DISTRICT –
ALMORA DOIWALA CHAMOLI, UTTARAKHAND. - 246444
(H201-H2-01), 3RD KM STONE, DELHI-ROORKEE
HIGHWAY, NEAR IOC PETROL BUNK, ROORKEE
PH :8755011005.
DISTT HARIDWAR - 247667
KASHIPUR PH :7055104191.

76
Dealer Workshop (AS ON 31.05.2023 )

RUDRAPRAYAG 2605. PODDAR CAR WORLD PVT. LTD. 2613. BHANDARI AUTOMOBILES PVT LTD 2621. BHANDARI AUTOMOBILES PVT LTD
(BZO1-BZO-01), BIRPARA MORE, COOCH (CAV1-CAV-01), VILLAGE – KAPTYAPA BARI, (G701-BJW-05), PLOT NO. 610, BARSUNDARA,
2596. ROHAN MOTORS (IK01-IK-01),
BEHAR ROAD, BESIDE GOYENKA PETROL P.O. – KAJLAGARH, P.S. – BHAGWANPUR, ISHWARDAHA, JALPAI, P.S. BHAWANIPUR,
GULABRAI-BADRINATH ROAD, RUDRAPRAYAG
PUMP, ALIPURDUAR, WEST BENGAL. - 736121 BAJKUL, DISTRICT – PURBA MIDNAPORE. - EAST MIDNAPORE. WEST BENGAL - 721654
- 246171
PH :8945533002 721626 PH :9933055539.
PH :8650876815.
9735008343 PH :9933055539. BASIRHAT
RUDRAPUR 9749707070. BALAGARH 2622. BHANDARI AUTOMOBILES PVT LTD
2597. AKANKSHA AUTOMOBILES (RUDRAPUR) PVT AMTALA 2614. SANEI MOTORS PVT. LTD (BMI1-BMI-01), DAG (X701-0D-03), RAGHUNATHPUR, TALKI ROAD,
LTD (U404-U4-01), KICHHA BYE PASS ROAD,
2606. BHANDARI AUTOMOBILES PVT LTD NO. 671, MOUZA - BARUIPARA, J L NO. 100, P.O. BASIRHAT NR. INDIAN PERTOL PUMP,
INDUSTRIAL AREA, RUDRAPUR - 263153
(BQH1-BQH-01), VILLAGE - UDAYRAMPUR, P.O. - BALAGARH, DIST.-HOOGLY, WEST BENGAL - NORTH-24 PARGANAS. - 743428
PH :8859502864.
- KANYANAGAR, P.S. - BISHNUPUR, AMTALA, 712 501 PH :8017569789.
SELAQUI DIST.-24 PARGANAS SOUTH, WEST BENGAL - PH :8584050184. BELACOBA
2598. ROHAN MOTORS LTD (CRF1-CRF-01), KHASRA 743 398 BALURGHAT 2623. PODDAR CARWORLD (SCU1-SCU-01),
NO.783, BAHADURPUR ROAD, NH-72, SELAKUI, PH :9903850402.
2615. J K WHEELS PVT. LTD. (PT01-PT-01), BARO PRASANNA NAGAR, BELACOBA, BATTALA,
DISTT.-DEHRADUN, UTTARAKHAND. - 248011 ARAMBAGH RAGHUNATHPUR, P.O. - BELTALA PARK, P.S. - JALPAIGURI - 735133 - 735133
PH :8006000439.
2607. SANEI MOTORS PVT. LTD. (7T02-7T-01), R.S. BALURGHAT, DIST.-DAKSHIN DINAJPUR. - 733 PH :8945533002.
SITARGANJ DAG NO. 1887, R.S. KHATIAN NO. 104, HAL 103 BIRPARA
2599. AKANKSHA AUTOMOBILES (RUDRAPUR) PVT KHATIAN NO. 1233, MOUZA-PARUL, J.L.NO. 38, PH :9064301464.
2624. SEVOKE MOTORS (CQL1-CQL-01), BHAGAT
LTD (CD02-CD-01), PLOT NO.228/5 AND 228/6 R.S.NO. 3111, P.S. ARAMBAGH, DISTT. BANKURA PARA, NH - 31, MADARIHAT ROAD, BIRPARA,
KHATIMA ROAD, SITARGANJ, DISTT - HOOGHLY, WEST BENGAL - 712601
2616. BHANDARI AUTOMOBILES PVT LTD BESIDE TASHI HOTEL, OPP - HIMALYAN HOTEL,
RUDRAPUR, UTTARAKHAND. - 262405 PH :8584050184.
(G701-6Q-02), PLOT NO.-156, KH NO.-173, P.S - MADARIHAT, DIST - ALIPURDUAR, PIN -
PH :8192000375. ASANSOL MITHILA MOUZA, AT/PO-BANKURA (WB) - 735204 - 735204
SRINAGAR 2608. BEEKAY AUTO PVT LTD (F601-F6-01), CHANDA 722101 PH :9800069144.
2600. SHAKUMBARI AUTOMOBILES (ANA1-ANA-01), MORE, N.H.-2, ASANSOL - 713301 PH :256766. BISHNUPUR
SRICOT GANAGANALI , NEAR MEDICAL PH :9932049425, BARASAT 2625. BHANDARI AUTOMOBILES PVT LTD
COLLEGE, PO- SRICOT, SRINAGAR - 246174 9932049435.
2617. PREMIER CARWORLD PVT. LTD. (XZ03-XZ-01), (AAG1-AAG-01), STATION ROAD, P.O+P.S-
PH :8077425944. BADURIA R.S DAG NO. 512 AND PARTY IN DAG NO. 513, BISHNUPUR, DIST: BANKURA, WEST BENGAL -
TEHRI 2609. PREMIER CARWORLD (SOE1-SOE-01), VILL- MOUZA-KHILKAPUR, P.O BARASAT, POLICE 722122
2601. DD MOTORS (A DIVISION OF D.D. PREM KIRRTIPUR, P.O- MANDRA, P.S - BADURIA, DIST STATION: DUTTA PUKUR, TOUZI NO. 146, J.L PH :9933055539.
PVT.LTD.) (QA02-QA-01), PLOT NO. 541, - NORTH 24 PARGANAS, WEST BENGAL. PIN - NO. 4, DISTRICT – NORTH 24 PARGANAS, BOLPUR
SECTOR-8E, DISTT. - NEW TEHRI - 249001 743438. - 743438 WEST BENGAL - 700125
2626. SWG- (A UNIT OFSAI NATH AUTO LINKS PVT.
PH :9690994366. PH :9831414956. PH :8420122407.
LTD) (4402-TC-03), KABI JOYDEB ROAD, NEAR
UTTARKASHI BAGDAH BARDHAMAN BOLPUR BY PASS, BOLPUR, DIST: BIRBHUM -
2602. DD MOTORS (A DIVISION OF D.D. PREM 2610. SANEI MOTORS PVT. LTD. (BON1-BON-01), C/O, 2618. BEEKAY AUTO PVT LTD (T301-T3-03), NH-2, 731204
PVT.LTD.) (6I02-6I-01), HOTEL RAMOLA, DINABANDHU TARAFDAR, S/O LATE PAMRA VILLAGE ROAD, CHANDNI MORE, PH :9647444888
BARETHI CHUNGI, GANGOTRI NATIONAL NARENDRANATH TARAFDAR, VILLAGE – SATTAR MILE, BURDWAN, WEST BENGAL - 8927895511.
HIGHWAY, UTTARKASHI. - 249151 HALENCHA SOUTH, P.O. – HALENCHA COLONY, 713101 BONGAON
PH :7248886807. P.S. – BAGDAH, DISTRICT – NORTH 24 PH :9932049454.
2627. STARBURST MOTORS PVT LTD (TQ02-TQ-01),
PARGANAS, WEST BENGAL. - 743270 BARJORA
UTTRAKHAND PH :8584050184.
376/D, R D B ROAD, NEAR JESSORE ROAD,
DEHRADUN 2619. BHANDARI AUTOMOBILES PVT LTD BAKSHIPALLY, BONGAON, NORTH 24
BAHRAMPUR (BED1-BED-01), VILLAGE + P.O. + P.S. – PARGANAS, WEST BENGAL - 743235
2603. SHAKUMBARI AUTOMOBILES (5708-57-01), 2611. BEEKAY AUTO PVT LTD (DJ02-DJ-01), BARJORA, MOUZA – BARJORA, JL NO. 46, PH :9748298939.
KHASRA NO.15-ANA, MOHABBEWALA, BOKULTALA (PASCHIM GAMINI), NH-34, KHATIAN NO. 3380, PLOT NO. 2795, BARJORA BUDGE BUDGE
SAHARANPUR ROAD, DEHRADUN, PIN-248001, BAHARAMPUR, DISTT. MURSHIDABAD. - 742101 DISTRICT – BANKURA, WEST BENGAL. - 722202
UTTARAKHAND - 248001 2628. ONE AUTO PVT. LTD. (BAV1-BAV-01), MAHESH
PH :267340. PH :8016087297.
PH :9639698871. TALA, NEAR DAKGHAR KALIMANDIR, BUDGE
2612. BEEKAY AUTO PVT LTD (DJ02-DJ-01), NH-34 BARRACKPORE
PATI BUDGE TRUNK ROAD, DAKGHAR, WARD NO.
MANKARA NEAR NEKRATALA, BAHRAMPUR,
2620. STARBURST MOTORS PVT LTD (BXJ1-CIY-02), 22, POLICE STATION-MAHESHTALA, WEST
2604. AKANKSHA AUTOMOBILES (RUDRAPUR) PVT MURSHIDABAD - 742165
NEAR RAIL GATE, WARD NO. 24, WEST BENGAL - 700141
LTD (SFX1-SFX-01), LOHAGHAT- HALDWANI PH :267340.
BARASAT ROAD, P.S. – TITAGARH, PH :8584878802
MAIN ROAD, NEAR PITHORAGARH BAJKUL BARRACKPORE, DISTRICT – NORTH 24 7604084762.
CO-OPERATIVE BANK, PATI-262528 - 262528 PARGANAS, KOLKATA. - 700120 C K ROAD
PH :8191000832. PH :8335061333.
WEST BENGAL BARSUNDRA
ALIPURDUAR

77
Dealer Workshop (AS ON 31.05.2023 )
2629. BHANDARI AUTOMOBILES PVT LTD 2637. BEEKAY AUTO PVT LTD (BWD1-BWD-01), 2645. BHANDARI AUTOMOBILES PVT LTD 2654. STARBURST MOTORS PVT LTD (IJ01-IJ-01),
(D001-D0-01), P.O:SAT BANKURA, PS:GARBETA, MOUZA – DHUPGURI, PLOT NO. 1814, WARD (G701-SE-04), BALGHASIPUR, BHABANIPUR, KALYANI INDUSTRIAL GROWTH CENTRE,
CHANDRAKONA ROAD, DIST. PASCHIM NO. 16, DHUPGURI, DISTRICT – JALPAIGURI, PURBA MEDIANPUR, HALDIA - 721657 PHASE-III, A-5 (OPP. U I C UDYOG, NEAR: J I S
MIDNAPORE, WEST BENGAL - 721252 WEST BENGAL. - 735210 PH :8016082344, 9233502421. COLLEGE), KALYANI. - 741234
PH :9933055539. PH :7477785203 HOWRAH PH :8584040215, 8336933447.
CANNING 9932049347 KESHPUR
2646. BHANDARI AUTOMOBILES PVT LTD
9932049382
2630. ONE AUTO (CEG2-CEG-01), SUSUMAPALLY, (X701-X7-01), BANKRA 2655. BHANDARI AUTOMOBILES PVT LTD
7478004430.
CANNING, DIST – SOUTH 24 PARGANAS, WB - THANA,DOMJUR,HOWRAH. - 711403 (CCM1-CCM-01), JL NO. 338, KHATIAN NO. 786/2,
743329 DIAMOND HARBOUR PH :9674735304. PLOT NO. 1749, MOUZA – KESHPUR, VILLAGE +
PH :8442830001. 2638. ONE AUTO PVT. LTD. (YE01-YE-01), VILLAGE – 2647. PREMIER CARWORLD PVT. LTD. (0611-X7-02), P.O. + P.S. – KESHPUR, WEST MIDNAPUR,
CHAKDAHA CHEWRA, OPPOSITE – K.E. CARMEL SCHOOL, MOUZA – PRASASTHA, P.S. – DOMJUR, UNDER WEST BENGAL. - 721150
P.O. – SARISHA HAT, P.S. – DIAMOND MOHIARY 2 NO. GRAM PANCHAYAT, PH :721150, 8170014289.
2631. BHANDARI AUTOMOBILES PVT LTD
HARBOUR, DISTRICT – 24 PARGANAS (S) , ANKURHATI, HOWRAH, WEST BENGAL. - KHARAGPUR
(OM01-OM-01), VILLAGE – PUMLIA, P.O. –
WEST BENGAL. - 743368 711302
CHAKDAHA, DISTRICT – NADIA, WEST BENGAL. 2656. BHANDARI AUTOMOBILES PVT LTD
PH :8584862243. PH :8420122402.
- 741222 (G701-G7-01), BHANDARI BUILDING,
PH :9073940368, 9674735303, 9674169007. DURGAPUR JALPAIGURI JHAPATAPUR, KHARAGPUR, WEST BENGAL -
CHANDITALA 2639. SWG- (A UNIT OFSAI NATH AUTO LINKS PVT. 2648. PODDAR CAR WORLD PVT. LTD. (XY01-XY-01), 721301
LTD) (4402-44-01), PLOT NO-743, MAUZA COLLEGE PARA, SIRISHTALA, NEAR ASSAM PH :755537.
2632. BHANDARI AUTOMOBILES PVT LTD
FRIDPUR, BURDWAN, DURGAPUR - 713213 MORE, JALPAIGURI, WEST BENGAL. - 735101 KHATRA
(BPC3-BPC-01), RS DAG NO.2986, LR DAG NO.
PH :9647444888 PH :8945533002.
3150, UNDER L R KHATIAN NO.3859, MOUZA- 2657. BHANDARI AUTOMOBILES PVT LTD
8927895511. JAYGAON
KRISHNARAMPUR, J.L. 59, POLICE STATION- (BGZ1-BGZ-01), VILLAGE - SENAPATI, P.O & P.S
CHANDITALA, HOOGHLY, WEST BENGAL - FALAKATA 2649. SEVOKE MOTORS PVT. LTD. (CHS1-CHS-01), - KHATRA, MOUZA-SENAPATI, JL NO.189,
712702 2640. PODDAR CAR WORLD PVT. LTD. HOUSE NO.43, WARD NO.11/22, N.S ROAD KHATIAN NO.659, PLOT NO.33/34, DISTT.
PH :6296900498. (CSR1-CSR-01), DAKSHIN PARANGAPAR, DARAGAON, P.S - JAYGAON, DISTT. BANKURA, WEST BENGAL. - 722140
CHANDRAKONA KHATIAN NO. 167/1 JL NO. 60, DAG NO. ALIPURDUAR, WEST BENGAL - 736182 PH :9933055539.
652/1159, P.S. – FALAKATA , DISTT PH :9433825851. KOLKATA
2633. BHANDARI AUTOMOBILES PVT LTD
ALIPURDWAR - 735211 JHARGRAM
(D001-CIP-02), AT. VILL. GOSAI PO+PS 2658. MACHINO TECHNO SALES LTD. (0601-06-02), 48
PH :8945533002.
CHANDRAKONA TOWN, MOUZA DHARABILA, 2650. BHANDARI AUTOMOBILES PVT LTD A, TARATALA ROAD, KOLKATA - 700066
J.L.NO. 095, KHATIAN NO. 315, PLOT NO. 203 & GAZOLE (BUG1-BUG-01), DAG NO.383, KHATAN NO. PH :9073330177.
189, NEAR MUNIPAL GATE TOWARDS C.K. 2641. JK WHEELS (SKZ1-SKZ-01), MOUZA- JL396, WARD NO.11, RAJBATI CAMPUS, 2659. DEWAR'S GARAGE (0605-06-01), (PROP. DELTA
ROAD. - 721201 BAJEGAIRAL, RANIGANJ, PURBAPARA, JHARGRAM, WEST BENGAL - 721507 INTERNATIONAL LTD.), 14 BRITISH INDIAN
PH :8945526833. KAMALDANGA, P.S- GAZOLE, DIST-MALDA, PIN PH :8016087297, 9933055539. STREET, CALCUTTA - 700069
CONTAI - 732138 - 732138 KADAMBAGACHI PH :8584015205.
PH :9734963360. 2660. MACHINO TECHNO SALES LTD. (0601-06-01),
2634. BHANDARI AUTOMOBILES PVT LTD 2651. STARBURST MOTORS PVT LTD (BXJ1-CTE-04),
GHATAL 21/1 DARGA ROAD, (PARK CIRCUS), CALCUTTA
(G701-GV-03), SERPUR BAMUNBAR,P O- MOUZA - PURBA ICHAPUR, J L NO. 111, RESU
- 700017
MARISHDA, NEAR MECHEDA BYPASS, CONTAI, 2642. BHANDARI AUTOMOBILES PVT LTD NO. 131, DAG NO. 385, KHATIAN NO. L R 754,
PH :9073330178.
WEST BENGAL - 721401 (AAD1-AAD-01), VILL. NIMTOLA, P.O. & P.S. KADAMBAGACHI, P.S. - BARASAT, DIST.-NORTH
2661. PREMIER CARWORLD PVT. LTD. (0611-06-01),
PH :254572. DASPUR, GHATAL,WEST MIDNAPORE,WEST 24 PARGANAS, WEST BENGAL. - 700125
AGARPARA JUTE MILL, 28-B.T.ROAD, P.O.:
COOCH BEHAR BENGAL - 721211 PH :8336933410.
-KAMARHATI, DISTT.-KOLKATA - 700058
PH :9933055539. KALIMPONG
2635. PODDAR CAR WORLD PVT. LTD. PH :8697730344.
(BWZ1-BWZ-01), CHAKCHAKA, NEELKUTHI GOPIBALLAVPUR 2652. BEEKAY AUTO (BWF1-BWF-01), 10TH MILE, 2662. BHANDARI AUTOMOBILES PVT LTD
BAZAR, NEAR ADA FACTORY, NH-31, COOCH 2643. BHANDARI AUTOMOBILES PVT LTD GUMBA HATTA, PO&PS -KALIMPONG, DIST - (0609-06-01), BUDGE BUDGE TRUNK ROAD,
BEHAR, WEST BENGAL. - 736101 (BPQ1-BPQ-01), JL NO. 1103, KHATIAN NO. 1103, KALIMPONG, WB. - 734301 NEW GOPALPUR, SARKARPOOL,
PH :8945533002 PLOT NO. 438, VILLAGE + P.O. + P.S. – PH :9932049347. MAHESHTALA, DISTT. SOUTH 24 PARGANAS,
9735008343. GOPIBALLVPUR , MOUZA – GOPIBALLVPUR, KALNA WEST BENGAL - 700143
DARJEELING WEST MIDNAPUR, WEST BENGAL. - 721506 PH :9674476000.
2653. BEEKAY AUTO PVT LTD (WZ01-WZ-01), KALNA 2663. BHANDARI AUTOMOBILES PVT LTD
PH :9933055539, 8170018577.
2636. BEEKAY AUTO PVT LTD (4301-6U-05), MERRY ROAD, NEAR KALNA SUB DIVISIONAL (0609-06-02), 37, GULAM JILANI KHAN ROAD,
VILLA, DARJEELING, DISTRICT-DARJEELING. - GUMA (ASHOKNAGAR) HOSPITAL, KALNA, PO+PS: KALNA, DISTT. KOLKATA. - 700039
734101 2644. STARBURST MOTORS PVT LTD (BXJ1-CLB-03), BURDWAN, (W.B.) - 713409 PH :9903850402.
PH :9932049347 JESSORE ROAD, MANIKNAGAR, KHOSDELPUR PH :9932251483. 2664. SANEI MOTORS PVT. LTD. (0612-06-01), 16/2
9932049382 MORE, P.S. – ASHOKNAGAR, NORTH 24 KALYANI CANAL EAST ROAD, NEAR MANIKTALA POLICE
7478004430. PARGANAS, WEST BENGAL. - 743222 STATION,KOLKATA - 700067
DHUPGURI PH :8697731763, 8336933447. PH :8584050184.
HALDIA

78
Dealer Workshop (AS ON 31.05.2023 )
2665. ONE AUTO PVT. LTD. (0614-06-02), 62 EAST 2675. BEEKAY AUTO PVT LTD (BWG1-BWG-01), 2682. BHANDARI AUTOMOBILES PVT. LTD. 2690. BEEKAY AUTO PVT LTD (BWS1-BWS-01), P.S. –
TOPSIA ROAD, P.S. TILJALA, ARUPOTA, CALTEX MORE, VILLAGE + P.S. – MALBAZAR (BPI1-BPI-01), L.R DAG NO 3274, UNDER L.R SALANOUR, UNDER MOUZA – JEMARI, J.L. NO.
KOLKATA , WEST BENGAL - 700105 AND DISTRICT – JALPAIGURI . - 735221 KHATIAN NO 3044, MOUZA-MALLICKBAGAN, JL 32, PLOT NO. 343-344, KHAITAN NO. 933,
PH :8584878802. PH :9932049347 NO-7, POLICE STATION – PANCHLA, DIST- RUPNARAYANPUR, PASCHIM BARDHAMAN
2666. ONE AUTO PVT. LTD. (0614-06-01), JL NO.3, 9932049382 HOWRAH - 711310 DISTRICT, WEST BENGAL. - 713335
MOUZA-JAGADIPOTA, P.S:SONARPUR, 7478004430 PH :9073664926. PH :9932049425,
KHEYADAHA NO.2, GRAM PANCHAYAT, DISTT. 7477785203. PANDUA 9932049435.
SOUTH 24 PARGANAS. - 700099 MALDA SABANG
2683. BHANDARI AUTOMOBILES PVT LTD
PH :8584870725.
2676. J K WHEELS PVT. LTD. (L801-L8-01), (BOS1-BOS-01), GT ROAD, PANDUA, NEAR 2691. BHANDARI AUTOMOBILES PVT LTD
2667. DEWAR'S GARAGE (0605-06-03), P-27/2,
GABGACHHI, N.H. 34, MALDA, - 732103 KAKOLI CINEMA HALL, OPP. POWER HOUSE, (CCL1-CCL-01), VILLAGE - PAIKAN
TARATALA ROAD, KOLKATA - 700088
PH :9851520855 , 9735003949. HOOGLY, WEST BENGAL. - 712149 DAKSHINBARH, P.O. - DHANSWARPUR & P.S. -
PH :8584015293.
MATHABHANGA PH :9073912566. PINGLA, DIST.-PASCHIM MIDNAPORE, SABANG
2668. SANEI MOTORS PVT LTD (0612-06-02), 235,
PANSKURA - 721 166, WEST BENGAL. - 721166
HATIYARA ROAD, SITALATALA, BAGUIATI, 2677. BEEKAY AUTO PVT LTD (BQF1-BQF-01),
PH :9933055539.
KOLKATA, WEST BENGAL - 700059 SITAKULCHI ROAD, WARD 2684. BHANDARI AUTOMOBILES PVT LTD
PH :8584050184. NO.9,MATHABHANGA, DISTRICT – (BPS1-BPS-01), MOUZA – PASCHIM NEKRA, JL SEORI
2669. OSL MOTOCORP PVT LTD (0616-06-01), 49 COOCHBEHAR. - 736146 NO.98, LR NO.1154, LR NO.1156, PANSKURA, 2692. BEEKAY AUTO PVT LTD (F601-KC-02),
DEBENDRA CHANDRA DEY ROAD, LANE PH :7477785202 WEST BENGAL. - 721139 RAMBADANPUR, NEAR SP MORE,
BESIDE SILVER SPRING CLUB, E.M. BYE-PASS, 9932049347 PH :9933055539. DIST-BIRBHUM, SEORI - 731101
KOLKATA - 700015 9932049382 PURULIA PH :9932049425,
PH :8336996355 7478004430. 9932049406.
8697982283. 2685. SWG- (A UNIT OFSAI NATH AUTO LINKS PVT.
MOHANPUR LTD) (4402-6W-02), PO. LAKDA, VILLAGE-DADKA SHYAMPUR
2670. JYOTE MOTORS (0624-06-01), NAZIRABAD MAIN
ROAD, NAZIRABAD, ANANDAPUR, NEAR 2678. BHANDARI AUTOMOBILES PVT LTD , ON RANCHI ROAD, PURULIA - 723149 2693. SANEI MOTORS PVT LTD (CAW1-CAW-01),
BISHNU BIJOLI GARDEN, KOLKATA, PIN-700150, (CIV1-CIV-01), VILLAGE-NAYAGAON, P.O. PH :9647444888 VILLAGE + P.O. – GOBINDAPUR, P.S. –
WEST BENGAL - 700150 -PAROI, P.S.-MOHANPUR, MOUZA - NAYAGAON, 8927895511. SHYAMPUR, DISTRICT – HOWRAH, WEST
PH :8334930830. JL NO.395, KHATIAN NO.175/1, PLOT NO.895, RAGHUNATHPUR BENGAL . - 711314
DISTT.-PASCHIM MIDNAPUR,W.BENGAL. - PH :8584050184.
KOLKATTA 2686. BEEKAY AUTO PVT LTD (CKZ1-CKZ-01), MOUZA
721436 SILIGURI
2671. BHANDARI AUTOMOBILES (0619-6-C1), PLOT – BUNDLA, J.L. NO. 197, PLOT NO. 2656,
PH :9933055539.
NO. IID/15, ACTION AREA 2D, NEW TOWN, P.S. KHATIAN NO. LR 207, P.O. – RAGHUNATHPUR, 2694. BEEKAY AUTO PVT LTD (4301-43-01), NH-31,
NAIHATI P.S. – RAGHUNATHPUR, DISTRICT – PURULIA. - P.O. MATIGARA,SILIGURI. - 734428
RAJARHAT, KOLKATA, WEST BENGAL
PIN-700156 - 700156 2679. PREMIER CARWORLD PVT. LTD. (YD01-YD-01), 723133 PH :9932049347
PH :6291042160. P.O. BHATPARA, GRAM-MUKTARPUR, P.S. - PH :9932049425, 9932049382
JAGATDAL, DIST-24 PGS (N), NAIHATI (WB) - 9932049435. 7478004430.
KOTULPUR
743123 RAIGANJ 2695. BEEKAY AUTO PVT LTD (4301-43-04), AMAI
2672. BHANDARI AUTOMOBILES PVT LTD PH :801700824. DIGHI, PHOOL BARI,STATE HIGHWAY -12,
(BIP1-BIP-01), KHATIAN NO.644, PLOT NO.373, 2687. J K WHEELS PVT. LTD. (BN02-BN-01), JL NO.
NAKASHIPARA SILIGURI - 734001
JL NO. 101, VILLAGE - MULDARA, P.S. + P.S. - 150, KHATIAN NO. 168/3 & 168/4, PLOT NO.
PH :9932049347
KOTULPUR, DISTT.-BANKURA, WEST BENGAL. - 2680. BHANDARI AUTOMOBILES PVT LTD 4158., P.S. – RAIGANJ, MUNICIPALITY –
9932049380.
722141 (BMJ1-BMJ-01), L R DAG NO. 7271, UNDER L R RAIGANJ, WARD NO. 11, HOLDING NO. 577/N,
2696. SEVOKE MOTORS PVT. LTD. (4302-43-01), 233,
PH :9933055539. KHATIAN NO. 6734, MOUZA - DEBAGRAM, J L MOUZA – RAIGANJ, DISTRICT – UTTAR
SEVOKE ROAD,2ND MILE, SILIGURI - 734001
NO. 60, POLICE STATION - KALIGANJ, BLOCK - DINAJPUR, - 733134
KRISHNANAGAR PH :9706010366.
KALIGANJ, NAKASHIPARA, DIST.-NADIA, WEST PH :9735008842.
2697. PODDAR CAR WORLD PVT LTD (XY01-43-02),
2673. BHANDARI AUTOMOBILES PVT LTD BENGAL. - 741138 RAJARHAT - KOLKATA VILL. EAST DHANTALLA, FULBARI II G.P, P.O
(X701-GS-02), PLOT NO.-1874, PH :9163314418.
2688. STARBURST MOTORS PVT LTD (BXJ1-06-05), SATELLITE TOWNSHIP, DIST- JALPAIGURI -
MOUZA-GOBINDSARAK ,J.K. NO. 94, NAXALBARI R.S & L.R. DAG NO. 3434, MOUZA- GOPALPUR, 734015
PS-KOTWAL, OLD WARD NO. 20, LAL MOHAN
2681. BEEKAY AUTO PVT LTD (CSJ1-CSJ-01), MOUZA JL NO. -02, RS NO. -140, LR KHATIAN NO. -5638, PH :8945533002.
GHOSH ROAD, KRISHNANAGAR - 742011
PH :9051999742. – GENI, KHATIAN NO.275, NEW TOWN, RAJARHAT - 700136 SONADA
PARGANA-HATIGHISHA, P.S. NAXALBARI, PH :9681080301.
MADHYAMGRAM 2698. SEVOK (SDX1-SDX-01), RATO MATEY DARA,
DISTT. DARJEELING, WEST BENGAL - 734429 RANAGHAT NEAR PETROL PUMP,P.O- SONADA, WEST
2674. STARBURST MOTORS PVT LTD (BXJ1-BXJ-01), PH :9932049347
2689. STARBURST MOTORS PVT LTD BENGAL PIN - 734209 - 734209
9/1, HEMANTA BOSE SARANI, BASUNAGAR, 9932049382
(BBW1-BBW-01), THANA: GANGNAPUR, ADSR PH :9800069144.
NEAR DEAF & DUMB SCHOOL, UDAYRAJPUR, 7478004430
MADHYAMGRAM - 700129 9563370099.
OFFICE, 151 NO.MOUZA PATULI, PLOT NO.309, SONAMUKHI
PH :9836075989, 8336933447. RANAGHAT, DISTT: NADIA - 741256
PANCHLA PH :8145821191, 8584040215.
MALBAZAR
RUPNARAYANPUR

79
Dealer Workshop (AS ON 31.05.2023 )
2699. BHANDARI AUTOMOBILES PVT LTD
(CAU1-CAU-01), J L NO. 77, KHATIAN NO. 360,
PLOT NO. 114/287, SONAMUKHI BISHNUPUR
ROAD, VILLAGE - CHURAMANIPUR, P.O. & P.S. -
SONAMUKHI, WEST BENGAL. - 722207
PH :9933055539.
SREERAMPORE (SREERAMPUR)
2700. BHANDARI AUTOMOBILES PVT LTD
(BBT1-BBT-01), BANGIHATI (MADPUR) DELHI
ROAD, SREERAMPUR, DISTT: HOOGHLY, WB -
712203
PH :66137505, 66137585, 9674741544.
TAMLUK
2701. BHANDARI AUTOMOBILES PVT LTD
(OL01-OL-01), MOUZA PADUMBASAN, WARD NO
10, JL NO:144, DISTT: EAST MIDNAPUR, WEST
BENGAL - 721636
PH :9933055539.
TARAKESHWAR
2702. SANEI MOTORS PVT. LTD. (YH01-YH-01),
MOUZA BAIDYAPUR, UNDER BALIGORI(1),
GRAM PANCHAYET, TARAKESHWAR, DISTT.
HOOGLY, WEST BENGAL. - 712410
PH :8584050184.
UDAYNARAYANPUR
2703. BHANDARI AUTOMOBILES PVT LTD
(BOO1-BOO-01), VILLAGE-JANGALPARA
BELGRAM, PS- UDAYNARAYANPUR, DIST-
HOWRAH, WEST BENGAL. - 711226
PH :9073664902.
ULUBERIA
2704. BHANDARI AUTOMOBILES PVT LTD
(2401-24-01), HOLDING 1242A, BANITABLA,
P.O+P.S: ULUBERIA, NH-6, DISTT: HOWRAH,
WEST BENGAL - 711316
PH :9052901888.

80
Maruti Service Master (AS ON 31.05.2023 )

DELHI
DELHI
1. MARUTI SALES & SERVICE(DELHI) (0810-08-01),
C-119, INDUSTRIAL AREA PHASE-I, NARAINA,
NEW DELHI - 110028
PH :45541113.
2. J J IMPEX (DELHI) LTD(MARUTI SERVICE
MASTERS) (0883-08-01), F-39,OKHLA
INDUSTRIAL AREA,PHASE-II,NEW DELHI -
110020
PH :41612194, 40685500.
TAMIL NADU
CHENNAI
3. J J IMPEX (DELHI) LTD(MARUTI SERVICE
MASTERS) (1485-14-01), # 9, (SP),THIRU-VI-KA
INDUSTRIAL ESTATE, GUINDY, CHENNAI -
600032
PH :044-43563366, 43563367, 9176615000.

81
Maruti Service Zone (AS ON 31.05.2023 )
11. PUNJAB MOTOR & ENGG WORKS (1881-18-01), 20. THANAWALA MOTOR AGENCY (P) LTD MEERUT
ARUNACHAL PRADESH NH-73, SHAHZADPUR ROAD, SAHA, DISTT.- (3981-39-01), B-31, OPPOSITE ITI,WAGLE
ITANAGAR 30. UNIQUE CAR SCANNERS (4881-48-01), PLOT
AMBALA - 133104 ESTATE MAIN ROAD,WAGLE ESTATE,THANE -
NO:514/4, SURAJ KUND ROAD, MEERUT, -
1. HIBRO AUTOMOBILES (7581-75-01), D-SECTOR, PH :9896666402. 400007
250001
DISTT: PAPUMPARE, ITANAGAR - 791111 YAMUNANAGAR PH :9833947772, 9833947778.
PH :9837072642.
PH :7005337938.
12. HIRA MOTOR GARAGE (D281-D2-01), PLOT NO ODISHA NOIDA
ASSAM 46, SHIVAJI PARK, OPPOSITE MADHU PALACE, KEONJHAR 31. MOTORCRAFT INDIA PVT LTD (A181-A1-01), F-8
BARPETA YAMUNANAGAR, HARYANA - 135001
21. KUMAR AUTOMOBILES (7U81-7U-01), & 9,SECTOR-8,NOIDA - 201301
PH :8950000069.
2. ROY AUTO ENGINEERING WORKS (7Z81-7Z-01), DHRUPADA, KEONJHAR, ORISSA - 758001 PH :08826172222 & 09971689689.
POST OFFICE, BARPETA ROAD, MAIN ROAD , HIMACHAL PRADESH PH :9437075366. 32. MOTORCRAFT INDIA PVT LTD (A181-A1-02),
JASSUR C-125,SECTOR-63,NOIDA, - 201301
WARD NO.-4, ASSAM - 781315 PUNJAB PH :09958732222 & 09910282222.
PH :9954069396.
13. CLASSIC MOTOR GARAGE (8H81-8H-01), BATALA
DULIAJAN 33. JKM MOTORS (A184-A1-01), A-25,SECTOR
TEHSEEL NOOPUR, KANGRA, JASSUR,
22. CITI AUTOMOBILES (V581-V5-01), NEAR 9,DISTT. GAUTAM BUDH NAGAR,NOIDA - 201301
3. B.S. MOTORS (X881-X8-01), NO. 01, HIMACHAL PRADESH - 176201
GURUDWARA ACHAL SAHIB, PATHANKOT PH :0120-4052400, 9899424000.
BORPOTHAR TINALI, DULIAJAN. - 786602 PH :9882217575 , 9459500613.
JALANDHAR ROAD, BATALA, - 143505 34. FAST TRACK AUTOCARE(INDIA) PVT. LTD.
PH :9435719753. JAMMU AND KASHMIR PH :9876024243 , 9876024254. (A185-A1-01), A-13, SECTOR 63, NOIDA, G.B.
BIHAR SRINAGAR MOGA NAGAR - 201301
PH :4581111; 4581131/9650631111.
PATNA 14. RAHIM MOTORS (1281-12-01), SIDGO 23. SM AUTO CARE CENTRE (H681-H6-01), OOP. ITI
SAHIBABAD
4. CITY AUTO SERVICES (1582-15-01), 9/1, INDUSTRIAL AREA, RANGRETH, SRINAGAR - , G.T. ROAD, MOGA - 142001
PATLIPUTRA INDUSTRIAL ESTATE, 2441384 PH :06136-226807. 35. FAST TRACK SERVICES (M981-M9-01), PLOT
PH :9906631702. NO.40/1B/2, 3 & 4, SITE 4, INDUSTRIAL AREA,
PATLIPUTRA , PATNA - 800013 RAJASTHAN SAHIBABAD, DISTT. GHAZIABAD (U.P.). - 201010
PH :9334117070/8210810240. JHARKHAND JAIPUR PH :9560868111.
DELHI RANCHI 24. KATARIA AUTOZONE PVT.LTD (1181-11-01), 1-A UNNAO
DELHI 15. PODDAR MOTOR (P) LTD. (5181-51-01), 47, 48 , ; NARAYANPURI,KATARIA KRISHI FARM,SIRSI 36. VISHAL WHEELERS PVT. LTD. (1382-KL-01),
5. GALAXY AUTOMOBILES (0881-08-01), 8 KOKAR INDUSTRIAL AREA, RANCHI. - 834001 ROAD,JAIPUR - 302034 PLOT NO. 1164, KANPUR-LUCKNOW BYE PASS,
INDUSTRIAL AREA,TILAK NAGAR,NEW DELHI, - PH :2544661, 2542650. PH :7427059388. UNNAO, UTTAR PRADESH, - 209801
110018 KERALA TELANGANA PH :2830610,2831248.
PH :43276666. VARANASI
6. A M AUTOMOBILES ( A UNIT OF BLUE BIRD COCHIN HYDERABAD
ENTERPRISES) (0891-08-01), 189-91, 16. AUTOTEAM SALES & SERVICES PVT.LTD 25. RETOUCH (1082-10-01), H.NO. 3-67/A, B, C, 37. PRATAP ENGINEERS (8481-84-01), S 2, 653/A-2,
,LAWRANCE ROAD,,DELHI - 110035 (2781-27-01), PIPELINE ROAD, PADIVATTOM, D,NEW NAGOLE COLONY,NAGOLE VILLAGE, CLUB ROAD, VARANASI - 221002
PH :48280000. COCHIN, ERNAKULAM, COCHIN - 682024 HYDERABAD,NAGOLE, HYDERABAD - 500068 PH :25100469, 9415203641.

HARYANA PH :9025730007. PH :9848062263. WEST BENGAL


PATHANAMTHITTA UTTAR PRADESH KOLKATA
BALLABGARH
17. AGT MOTORS (W881-W8-01), AGT TOWERS, ALIGARH 38. MANOCO SALES (P) LTD. (0681-06-01), 25/1,
7. ROYAL MOTORS (9R82-9R-01), 21/5, G.T. ROAD,
PUTHENPEEDI, OMALLUR, PATHANAMTHITTA - CHETLA CENTRAL ROAD, OPPOSITE CHETLA
BALLABHGARD, DISTT-FARIDABAD - 121004 26. VINEET MOTORS (B681-B6-02), PLOT NO.D-138
689640 PARK, KOLKATA - 700027
PH :4271800; 9899232536;9212142536. &139, SECTOR-1, TALA NAGARI, RAMGHAT
PH :9288117477. PH :24568326, 24486568, 24568325.
MURTHAL ROAD, ALIGARH - 202001
MADHYA PRADESH PH :9917473052, 9582123586.
8. MURTHAL AUTO PVT. LTD. (BV81-BV-01), 44
HSIIDC, MURTHAL - 131027 NEEMUCH GHAZIABAD
PH :9215182230. 18. AUTO SCAN (3T81-3T-01), MHOW 27. KAP AUTOMOBILES PVT. LTD. (5981-59-01),
PANCHKULA ROAD,NEEMUCH,MADHYAPRADESH, - 458441 D-BLOCK SHASHTRI NAGAR,HAPUR
PH :9425106588. ROAD,GHAZIABAD - 201002
9. CARE TAKER (K381-K3-01), PLOT NO. 36,
PH :0120-4538200 , 9717629599, 9810523345.
INDUSTRIAL AREA, PHASE-2, PANCHKULA - MAHARASHTRA 28. CHIRAG AUTOMOBILES (5983-59-01), PLOT NO.
134113 PUNE B1, SECTOR-B3, TRONICA CITY, GHAZIABAD -
PH :9914115427.
19. MARUTI CARE POINT (1981-19-02), 17/1, 201102
PANIPAT RAHATANI, AUNDH-CHINCHWAD ROAD. OPP PH :9582945510, 9999107841.
10. VIJAY MOTORS (D381-D3-01), PLOT# 136, PCMC 'D' PRABHAG KARYALAY, NEXT TO HP LUCKNOW
INDUSTRIAL AREA, PHASE-1 - 132103 SUBHIKA PETROL PUMP, RAHATNI, PUNE,
29. K M AUTOCRAFT (1381-13-01), 76/3, BARAURA,
PH :9896118618. MAHARASHTRA - 411017
HUSSAIN BARI, HARDOI ROAD, LUCKNOW -
SAHA PH :9689901459.
226003
THANE PH :2473369.

82
September, 2023

99011M55T04-74E

2023
99011M55T03-74E
Part No. 99011M55T03-74E
99011M55T04-74E
March, 2023

You might also like