Chain Tape Survey.....

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 17

1.

Well-conditioned triangles are preferred because

સારી રીતે કન્ડિશડિ ત્રિકોણ પસંદ કરવામાં આવે છે કારણ કે

A. They causes less survey work(તેઓ ઓછા સવે કાર્યન ં કારણ બને છે )

I R
B. Their apex good sharp and can be locate easily(તેમની ટોચ સારી તીક્ષ્ણ અને સરળતાથી શોધી શકાર્ છે )S
A Y
C. They give good pictures on drawing sheets(તેઓ ડ્રોઇંગ શીટ્સ પર સારા ચચિો આપે છે )
S H
A K
D. None of the above(ઉપર્ક્ય તમાંથી કોઈ નહિ)
BY
2. The total length of eight links is a ‘Revenue chain’ is
M Y
કલ આઠ ચલિંક્સની લંબાઈ 'રે વડર્ ચેઈન' છે D E
C A
A. 16.5 feet A B. 33 feet

IC
C. 26 feet

I ST D. 13 feet

L
3. In chain surveying work, the line joining tie stations for taking offsets from it, is known as:-
O
H
સાંકળના સવેક્ષણ કાર્યમાં, તેમાંથી ઓફસેટ લેવા માટે ટાઈ સ્ટેશનોને જોિતી લાઇન, આ રીતે ઓળખાર્ છે :-

A. Tie line(ટાઇ લાઇન) B. Check line(લાઇન તપાસો)

C. Chain line સાંકળ રે ખા D. Base Line બેઝ લાઇન

4. The length of an engineering chain is:-

એન્ડજત્રનર્હરિંગ સાંકળની લંબાઈ છે :-

A. 33 ft. B. 20 ft.

C. 66 ft. D. 100 ft.

5. When two stations for which ranging is to be done are not intervisible, the ranging method used in such case is:

જ્ર્ારે બે સ્ટેશનો કે જેના માટે રે ન્ડજિંગ કરવાન ં છે તે ઇડટરત્રવચઝબલ નથી, ત્ર્ારે આવા હકસ્સામાં ઉપર્ોગમાં લેવાતી રે ન્ડજિંગ

પદ્ધત્રત છે :

A. Reciprocal ranging( પારસ્પહરક શ્રેણી ) B. Direct ranging(િાર્રે ક્ટ રે ડજ)

C. Partial ranging (આંત્રશક શ્રેણી) D. Simultaneous ranging(એક સાથે શ્રેણી)Page 1 of 16

akshaypatel00037 holisticacademy holistic.academy


6. A 30 m metric chain is found to be 0.1 m too short throughout the measurement. If the distance measured is
recorded as 300 m, then the actual distance will be.

સમગ્ર માપન દરમ્ર્ાન 30 મીટરની મેહિક સાંકળ 0.1 મીટર ખ ૂબ ટૂંકી િોવાન ં જણાર્ ં છે . જો માપવામાં આવેલ અંતર 300
I R
મીટર તરીકે નોંધવામાં આવે, તો વાસ્તત્રવક અંતર િશે.
S
A Y
A. 300.1 m B. 101.0 m
S H
C. 299.0 m D. 310.0 m
A K
7. In chain survey the area is divided is to :
BY
સાંકળ સવેક્ષણમાં ત્રવસ્તારને ત્રવભાજજત કરવામાં આવે છે :
M Y
D E
A. Rectangles(લંબચોરસ)
C A B. Triangles (ત્રિકોણ)
A
C. Squares (ચોરસ)
I C D. Hexagon (ષટ્કોણ)

S T
L I
8. While applying correction due to sag in a chain or tape survey, which of the following shapes is assumed to be

HO
followed

સાંકળ અથવા ટેપ સવેક્ષણમાં નમી જવાને કારણે કરે ક્શન લાગ કરતી વખતે, નીચેનામાંથી કર્ા આકારને અનસરવામાં

આવે તેવ ં માનવામાં આવે છે

A. Circular(પહરપિ) B. Parabolic( પેરાબોચલક)

C. Hyperbolic (િાર્પરબોચલક) D. Quadratic (ચતર્યજ)

9. Which of the following instruments is generally used for base line measurements?

નીચેનામાંથી કર્ ં સાધન સામાડર્ રીતે બેઝ લાઇન માપન માટે વપરાર્ છે ?

A. Chain સાંકળ B. Metallic tape મેટાચલક ટેપ

C. Steel tapeસ્ટીલ ટેપ D. Invar tape ઇડવર ટેપ

10. Cross staff is an instrument used for:

ક્રોસ સ્ટાફ એ એક સાધન છે જેનો ઉપર્ોગ આ માટે થાર્ છે :

A. measuring approximate horizontal angles અંદાજજત આિી ખ ૂણાઓન ં માપન


Page 2 of 16

akshaypatel00037 holisticacademy holistic.academy


B. setting out right angles જમણો ખ ૂણો સર્ોજજત કરી રહ્યા છીએ

C. Measuring bearing of the line રે ખાના બેહરિંગને માપવા

I R
D. None of these આમાંથી એક પણ નહિ S
A Y
11.Triangulation stations should be
S H
ત્રિકોણ સ્ટેશનો િોવા જોઈએ A K
A. in commanding positions કમાન્ડિિંગ િોદ્દાઓ પર
BY
M Y
D E
B. all of three mentioned here િણેર્નો અિીં ઉલ્લેખ કર્ો છે
C A
C. intervisible ઇડટરત્રવચઝબલ
A
I C
S T
D. easily accessible સરળતાથી સલભ
L I
HO
12. Length of a 50 m chain is short by 0.05 m. what kind of error will it introduce

50 મીટરની સાંકળની લંબાઇ 0.05 મીટર ઓછી િોર્ છે . તે કર્ા પ્રકારની ર્ ૂલ રજૂ કરશે

A. Positive cumulative error િકારાત્મક સંચચત ર્ ૂલ

B. Negative cumulative error નકારાત્મક સંચચત ર્ ૂલ

C. Negative compensating error નકારાત્મક વળતર ર્ ૂલ

D. Positive compensating error સકારાત્મક વળતર ર્ ૂલ

13. Survey of a piece of land is being carried out. Out of the following errors, which one may be either cumulating
positive or cumulating negative error

જમીનના ટકિાનો સવે કરવામાં આવી રહ્યો છે . નીચેની ર્ ૂલોમાંથી, જે કાં તો સકારાત્મક અથવા સંચચત નકારાત્મક ર્ ૂલ િોઈ

શકે છે

A. Sag નમી B. Erroneous length of chain સાંકળની ખોટી લંબાઈ

C. Bad rangingખરાબ શ્રેણી D. Bad straightening ખરાબ સીધ ં કરવ ં


Page 3 of 16

akshaypatel00037 holisticacademy holistic.academy


14. Pick the incorrect pair:( ખોટી જોિી પસંદ કરો:)

A. Butt Rod: Measuring offsets બટ્ટ રોિ: ઓફસેટ્સ માપવા

B. Invar Tape: Baseline Measurement ઇડવર ટેપ: બેઝલાઇન મેઝરમેડટ


I R
C. Plasters laths: Marking terminal points પ્લાસ્ટર લેથ્સ: ટત્રમિનલ પોઈડટને ચચહ્નિત કરવ ં
S
A Y
S H
D. Prism square : Setting right angles ત્રપ્રઝમ સ્ક્વેર : જમણો ખ ૂણો સેટ કરી રહ્યા છીએ
A K
15. Length of revenue chain is આવક શખ
ં લાની લંબાઈ છે
BY
A. 33 ft M Y B. 66 ft

D E
C. 100 ft
C A D. 66 m

A
16. The correction due to sag and pull are equalized by:

I C
T
સૅગ અને પલને કારણે કરે ક્શન આના દ્વારા સમાન થાર્ છે :
S
L I
HO A. Normal equation સામાડર્ સમીકરણ B. Normal pressure સામાડર્ દબાણ

C. Normal tension સામાડર્ તણાવ D. All of these આ બધજ

17. The Length of a ranging rod should be

રે ન્ડજિંગ સચળર્ાની લંબાઈ િોવી જોઈએ

A. 1.5 to 2.0 m B. 2 to 3.0 m

C. 3 to 4.0 m D. 2.5 to 4.5 m

18. Marking the end of chain length is an example of –

સાંકળની લંબાઈના અંતને ચચહ્નિત કરવ ં એ એક ઉદાિરણ છે -

A. Positive error િકારાત્મક ર્ ૂલ B. Negative error નકારાત્મક ર્ ૂલ

C. Cumulative error સંચચત ર્ ૂલ D. Compensating error વળતર ર્ ૂલ

19. Which of the following used in measuring perpendicular offset?

કાટખ ૂણે ઓફસેટ માપવા માટે નીચેનામાંથી કર્ો ઉપર્ોગ થાર્ છે ?


Page 4 of 16

akshaypatel00037 holisticacademy holistic.academy


A. Cross staff ક્રોસ સ્ટાફ B. Optical square ઓન્પ્ટકલ ચોરસ

C. Steel tape સ્ટીલ ટેપ D. All of these આ બધજ

20. Measuring with a 30 m chain which is 0.41 m too short introduces a:


I R
30 મીટરની સાંકળ સાથે માપવા જે 0.41 મીટર ખ ૂબ ટૂંકી છે એ પહરચર્ આપે છે S
A Y
A. positive compensating error િકારાત્મક વળતર ર્ ૂલ
S H
A K
B. Negative compensating error નકારાત્મક વળતર ર્ ૂલ
BY
C. Positive cumulative error િકારાત્મક સંચચત ર્ ૂલ
M Y
D E
A
D. Negative cumulative error નકારાત્મક સંચચત ર્ ૂલ
C
A
C
21. Consider the following : નીચેનાનો ત્રવચાર કરો
I
S T
I
(i) Line ranger લાઇન રે ડજર
L
HO
(ii)Reciprocal Ranging પારસ્પહરક શ્રેણી

(iii) Random line ranging રે ડિમ લાઇન રે ન્ડજિંગ

(iv) Optical square ઓન્પ્ટકલ ચોરસ

Which of these are employed to solve the problem of vision obstructed but chaining free?

આમાંથી કોને દ્રન્ટટ અવરોત્રધત પરં ત સાંકળ મક્ત કરવાની સમસ્ર્ાને િલ કરવા માટે કાર્યરત છે ?

A. (i), (ii), (iii) and (iv) B. (ii) and (iii) only

C. (ii) and (iv) only D. (iii) and (iv) only

22. The magnitude of the sag correction during measurement of length by chaining is proportional to the:

સાંકળ દ્વારા લંબાઈના માપન દરત્રમર્ાન ઝોલ કરે ક્શનની તીવ્રતા આના પ્રમાણસર છે :

A. Cube of the weight of the chain, in kg per m run સાંકળના વજનન ં ઘન, હકગ્રા પ્રત્રત મીટર દોિમાં

B. Cube root of the weight of the chain, in kg per m run સાંકળના વજનન ં ઘનમ ૂળ, હકગ્રા પ્રત્રત મીટર રનમાં

Page 5 of 16

akshaypatel00037 holisticacademy holistic.academy


C. Square of the weight of the chain, in kg per m run સાંકળના વજનનો ચોરસ, હકગ્રા પ્રત્રત મીટર દોિમાં

D. Square root of the weight of the chain, in kg per m run સાંકળના વજનન ં વગયમ ૂળ, હકગ્રા પ્રત્રત મીટર દોિમાં

23. Correction due to sag a tape is ટેપ નમી જવાને કારણે કરે ક્શન છે
I R
A. always positive િંમેશા િકારાત્મક
S
A Y
B. always negative િંમેશા નકારાત્મક S H
A K
BY
C. Sometimes negative and sometimes positive ક્યારે ક નકારાત્મક તો ક્યારે ક સકારાત્મક

M Y
D. dependent on the temperature conditions તાપમાનની સ્સ્થત્રત પર આધાર રાખે છે
D E
C A
24. Among the following which equipment is not used in chain survey?
A
C
નીચેના પૈકી કર્ા સાધનોનો ઉપર્ોગ સાંકળ સવેક્ષણમાં થતો નથી?
I
S T
L I
A. ranging rod રે ન્ડજિંગ લાકિી B. offset rod ઓફસેટ લાકિી

HO C. alidade એચલિેિ D. plumb bob પ્લમ્બ બોબ

25. As per Indian standard specification, the length of one link in 30 meter chain is

ભારતીર્ માનક સ્પટટીકરણો મજબ, 30 મીટર સાંકળમાં એક ચલિંકની લંબાઈ છે

A. 20 cm B. 30 cm

C. 40 cm D. 10 cm

26. Systematic errors are those errors:

પદ્ધત્રતસરની ર્ ૂલો તે ર્ ૂલો છે :

A. whose effects are cumulative and can be determined જેની અસરો સંચચત છે અને તે નક્કી કરી શકાર્ છે

B. which cannot be recognized જે ઓળખી શકાર્ તેમ નથી

C. whose character is not understood જેન ં પાિ સમજાત ં નથી

D. whose effect is recognized but character is not understood(જેની અસર ઓળખાર્ છે પણ પાિ સમજાત ં નથી

Page 6 of 16

akshaypatel00037 holisticacademy holistic.academy


27. An invar tape is made up of an alloy of:

ઇડવર ટેપ એલોર્થી બનેલી છે :

A. Copper and Steel કોપર અને સ્ટીલ B. Brass and Nickel ત્રપત્તળ અને ત્રનકલ

I R
C. Brass and Steel ત્રપત્તળ અને સ્ટીલ D. Nickel and Steel ત્રનકલ અને સ્ટીલ S
A Y
S H
28. When (h) is the difference in heights between the extremities of a chin length (l) then the correction for the
slope required is –
A K
BY
જ્ર્ારે (h) એ રામરામની લંબાઈ (l) ના િાથપગ વચ્ચેની ઊંચાઈમાં તફાવત િોર્ ત્ર્ારે ઢોળાવ માટે કરે ક્શન જરૂરી છે -

A. h/l
M Y B. 𝐡𝟐 /l

D E
C. 𝐡𝟐 /2l
C A D. h/2l

A
29. In chain surveying, perpendiculars to the chain line are set out by-

I C
T
સાંકળના સવેક્ષણમાં, સાંકળ રે ખાના લંબ આના દ્વારા ત્રનધાયહરત કરવામાં આવે છે -
S
L I
HO A. a theodolite ત્રથર્ોિોલાઇટ B. a prismatic compass ત્રપ્રઝમેહટક િોકાર્ંિ

C. a clinometers ન્ક્લનોમીટર D. an optical square એક ઓન્પ્ટકલ ચોરસ

30. A tie line in a chain surveying

એક સાંકળ સવેક્ષણમાં ટાઇ લાઇન

A. checks the accuracy of the framework

A. ફ્રેમવકય ની ચોકસાઈ તપાસે છે

B. enables the surveyor to locate the interior details which are far away from the main chain lines

B. સવેર્રને આંતહરક ત્રવગતો શોધવા માટે સક્ષમ કરે છે જે મખ્ર્ સાંકળ રે ખાઓથી દૂ ર છે

C. fixes up the directions of all other lines

C. અડર્ તમામ રે ખાઓની હદશાઓ સધારે છે

D. All of these

D. આ બધજ
Page 7 of 16

akshaypatel00037 holisticacademy holistic.academy


31. Which of the following is not used to in measuring perpendicular is not used to in measuring perpendicular
offsets?

નીચેનામાંથી કર્ ં કાટખ ૂણે માપવા માટે ઉપર્ોગમાં લેવાત ં નથી?

A. Line ranger લાઇન રે ડજર B. Tape ટેપ


I R
S
C. Optical square ઓન્પ્ટકલ ચોરસ Y
D. Cross-staff ક્રોસ સ્ટાફ
A
S H
32. Triangulation is based on the principle that knowing –
A K
ત્રિકોણ એ ત્રસદ્ધાંત પર આધાહરત છે કે જાણવ ં
BY
M Y
A. three sides, the angles can be calculated precisely

D E
A
A. િણ બાજઓ, ખ ૂણાઓની ચોક્કસ ગણતરી કરી શકાર્ છે
C
A
C
B. three angles, the sides can be calculated precisely
I
S T
B. િણ ખ ૂણા, બાજઓની ચોક્કસ ગણતરી કરી શકાર્ છે

L I
HO C. two sides and one angle, the remaining side and angles can be determined precisely

C. બે બાજઓ અને એક ખ ૂણો, બાકીની બાજઓ અને ખ ૂણાઓ ચોક્કસ રીતે નક્કી કરી શકાર્ છે

D. one side and three angles, the remaining sides can be calculated precisely

D. એક બાજ અને િણ ખ ૂણા, બાકીની બાજઓની ચોક્કસ ગણતરી કરી શકાર્ છે

33. A metallic tape is made of- મેટાચલક ટેપ બને છે -

A. Steel સ્ટીલ

B. Invar ઇડવર

C. a composite material of steel and brassસ્ટીલ અને ત્રપત્તળની સંર્ક્ત સામગ્રી

ં ૂ ેલા કાપિ
D. cloth interwoven with metallic fibersધાતના તંતઓ સાથે ગથ

34. Normal tension for a tape is defined as the pull-

ટેપ માટે સામાડર્ તાણને પલ તરીકે વ્ર્ાખ્ર્ાત્રર્ત કરવામાં આવે છે -

Page 8 of 16

akshaypatel00037 holisticacademy holistic.academy


A. applied by an average adult સરે રાશ પખ્ત દ્વારા લાગ

B. applied for standardizing the tape ટેપને પ્રમાચણત કરવા માટે અરજી કરી

C. which equalizes the effect due to sag જે નમી જવાને કારણે અસરને સમાન બનાવે છે
I R
D. that equalizes the effect due to the slope જે ઢાળને કારણે અસરને સમાન બનાવે છે
S
A Y
S H
35. When a chain used at a temperature more than the temperature it was calibrated, the error in the measured
length will be
A K
BY
જ્ર્ારે સાંકળ માપાંહકત કરાર્ેલા તાપમાન કરતાં વધ તાપમાને વપરાર્ છે , ત્ર્ારે માપેલ લંબાઈમાં ર્ ૂલ િશે

M Y
A. cumulative સંચચત
D E B. compensating વળતર

C A
C. negative નકારાત્મક A D. observational error અવલોકન ર્ ૂલ

I C
T
36. Cross staff is used for
S
L I
ક્રોસ સ્ટાફ માટે વપરાર્ છે

HO A. Measuring approximate horizontal angles અંદાજજત આિી ખ ૂણાઓન ં માપન

B. Measuring bearing of Lines રે ખાઓન ં માપન બેહરિંગ

C. Setting right angles જમણો ખ ૂણો સેટ કરી રહ્યાં છીએ

D. Measuring the weight bearing capacity of a beam બીમની વજન વિન ક્ષમતા માપવી

37. The error in measured length due to sag of chain or tape is known as:

સાંકળ અથવા ટેપના નમી જવાને કારણે માપેલી લંબાઈમાં ર્ ૂલ આ રીતે ઓળખાર્ છે :

A. Positive error િકારાત્મક ર્ ૂલ B. Negative error નકારાત્મક ર્ ૂલ

C. Compensating error વળતર ર્ ૂલ D. Instrumental error ઇડસ્ુમેડટલ ર્ ૂલ

38. Direct ranging is possible only when the end stations are

જ્ર્ારે અંત્રતમ સ્ટેશનો િોર્ ત્ર્ારે જ સીધી શ્રેણી શક્ય છે

A. Close to each other એકબીજાની નજીક Page 9 of 16

akshaypatel00037 holisticacademy holistic.academy


B. Not more than 100 m apart 100 મીટરથી વધ નિીં

C. Mutually intervisible મ્ર્ચ્ર્અલી ઇડટરત્રવચઝબલ

D. Located at highest points in the sea સમદ્રમાં ઉચ્ચતમ ચબિંદઓ પર સ્સ્થત છે


I R
S
39. The adjustable cross-staff is used for setting out an offset:
A Y
એિજસ્ટેબલ ક્રોસ-સ્ટાફનો ઉપર્ોગ ઑફસેટ સેટ કરવા માટે થાર્ છે :
S H
A K
A. at any angleકોઈપણ ખ ૂણા પર
BY
B. at an angle of 45 degree 45 હિગ્રીના ખ ૂણા પર
M Y
D E
C. at a right angle જમણા ખ ૂણા પર
C A
A
C
D. at an angle of 60 degree 60 હિગ્રીના ખ ૂણા પર
I
S T
L I
HO
40. When the length of chain used in measuring distance is longer than the standard length, the error in measured
distance will be

જ્ર્ારે અંતર માપવા માટે વપરાતી સાંકળની લંબાઈ પ્રમાણર્ ૂત લંબાઈ કરતાં લાંબી િોર્, ત્ર્ારે માપવામાં આવેલા અંતરમાં

ર્ ૂલ થશે

A. Positive error િકારાત્મક ર્ ૂલ B. Mean error મીન ર્ ૂલ

C. Compensating error વળતર ર્ ૂલ D. Negative error નકારાત્મક ર્ ૂલ

41. Chain surveying is well adopted for :

સાંકળ સવેક્ષણ આ માટે સારી રીતે અપનાવવામાં આવે છે :

A. Small areas in open ground ખલ્લા મેદાનમાં નાના ત્રવસ્તારો

B. Large areas with simple details સરળ ત્રવગતો સાથે મોટા ત્રવસ્તારો

C. Small areas with crowded details ગીચ ત્રવગતો સાથે નાના ત્રવસ્તારો

D. Large areas with difficult details મશ્કેલ ત્રવગતો સાથે મોટા ત્રવસ્તારો
Page 10 of 16

akshaypatel00037 holisticacademy holistic.academy


42. In surveying Offsets are

સવેક્ષણમાં ઓફસેટ્સ છે

A. Lateral Measurements made with respect to main survey Line

A. મખ્ર્ સવેક્ષણ રે ખાના સંદભયમાં કરવામાં આવેલ પાર્શ્વીર્ માપ I R


S
A Y
B. Perpendicular are elected from chain lines
SH
B. કાટખ ૂણે સાંકળ રે ખાઓમાંથી ચટ
ં ૂ ાર્ છે
A K
C. Taken to avoid unnecessary walking between chain line BY
M Y
C. સાંકળ રે ખા વચ્ચે ચબનજરૂરી વૉહકિંગ ટાળવા માટે લેવામાં આવે છે
D E
C A
A
D. Measurements which are not made at right angles to the chain line

C
D. માપન જે સાંકળ રે ખાના જમણા ખ ૂણા પર કરવામાં આવત ં નથી
I
S T
I
43. Which of the following is NOT a cumulative type of error in chaining?
L
HO
નીચેનામાંથી કર્ો ચેઇત્રનગ
િં માં સંચચત પ્રકારની ર્ ૂલ નથી?

A. Error in marking tape length ટેપની લંબાઈને ચચહ્નિત કરવામાં ર્ ૂલ

B. Incorrect length of tape ટેપની ખોટી લંબાઈ

C. Error due to temperature તાપમાનને કારણે ર્ ૂલ

D. Tape not stretched horizontally ટેપ આિી રીતે ખેંચાઈ નથી

44. A well-conditioned triangle is one which

સારી રીતે કન્ડિશડિ ત્રિકોણ તે છે જે

A. is either isosceles or equilateral

A. સમહ્નદ્વબાજ અથવા સમબાજ છે

B. is composed of lines measured with the invar tape

B. ઇડવર ટેપ વિે માપવામાં આવતી રે ખાઓથી બનેલી છે

Page 11 of 16

akshaypatel00037 holisticacademy holistic.academy


C. has angles either too acute nor too obtuse

C. ખ ૂણાઓ કાં તો ખ ૂબ તીવ્ર અથવા ખ ૂબ સ્થ ૂળ છે

D. connects any three stations visible from a single station

D. એક સ્ટેશન પરથી દે ખાતા કોઈપણ િણ સ્ટેશનોને જોિે છે I R


S
A Y
45. In triangulation survey, the strength of figure in a triangulation system is more:
S H
ત્રિકોણ સવેક્ષણમાં, ત્રિકોણ પદ્ધત્રતમાં આકત્રતની મજબ ૂતાઈ વધ િોર્ છે
A K
A. in the method of trilateration BY
A. ત્રિપક્ષીર્ પદ્ધત્રતમાં M Y
D E
C A
A
B. when the error is the least when computing the length of last line

C
B. જ્ર્ારે છે લ્લી લાઇનની લંબાઈની ગણતરી કરતી વખતે ર્ ૂલ ઓછામાં ઓછી િોર્ છે
I
S T
I
C. when any angle of a triangle is not less than 30° or more than 120°
L
HO C. જ્ર્ારે ત્રિકોણનો કોઈપણ ખ ૂણો 30° કરતા ઓછો અથવા 120° કરતા વધ ન િોર્

D. when the angles of a triangle are very nearly equal to 60°

D. જ્ર્ારે ત્રિકોણના ખ ૂણા લગભગ 60° જેટલા િોર્ છે

46. The position of a point can be fixed more accurately by

દ્વારા ચબિંદની સ્સ્થત્રત વધ સચોટ રીતે ત્રનત્રિત કરી શકાર્ છે

A. perpendicular offset કાટખ ૂણે ઓફસેટ B. Optical square ઓન્પ્ટકલ ચોરસ

C. prism square ત્રપ્રઝમ ચોરસ D. oblique offsets િાંસી ઓફસેટ્સ

47. Optical square is based on which of the following principles:

ઓન્પ્ટકલ ચોરસ નીચેનામાંથી કર્ા ત્રસદ્ધાંતો પર આધાહરત છે :

A. Double refraction િબલ રીફ્રેક્શન B. Refraction રીફ્રેક્શન

C. Reflection પ્રત્રતચબિંબ D. Double reflection િબલ પ્રત્રતચબિંબ

Page 12 of 16

akshaypatel00037 holisticacademy holistic.academy


48. The operation of establishing number of intermediate points on a straight line between two fixed end points on
ground is known as

જમીન પરના બે ત્રનત્રિત અંત્રતમ ચબિંદઓ વચ્ચે સીધી રે ખા પર મધ્ર્વતી ચબિંદઓની સંખ્ર્ા સ્થાત્રપત કરવાની કામગીરી

તરીકે ઓળખાર્ છે

I R
A. offsets ઓફસેટ્સ B. station points સ્ટેશન પોઈડટ S
A Y
C. ranging રે ન્ડજિંગ
S H
D. auxiliary points સિાર્ક ચબિંદઓ

A K
BY
49. The error due to bad ranging is

ખરાબ રે ન્ડજિંગને કારણે ર્ ૂલ છે


M Y
D E
A
A. cumulative; positive સંચચત; િકારાત્મક
C
A
C
B. cumulative; negative સંચચત; નકારાત્મક
I
S T
C. compensating વળતર
L I
HO D. cumulative; positive or negative સંચચત; િકારાત્મક અથવા નકારાત્મક

50. The position of a point can be fixed more accurately by

દ્વારા ચબિંદની સ્સ્થત્રત વધ સચોટ રીતે ત્રનત્રિત કરી શકાર્ છે

A. cross staff ક્રોસ સ્ટાફ B. optical square ઓન્પ્ટકલ ચોરસ

C. oblique offsets િાંસી ઓફસેટ્સ D. perpendicular offsets કાટખ ૂણે ઓફસેટ્સ

51. Example for an obstacle that obstructs both chaining and ranging:

િં અને રે ન્ડજિંગ બંનેને અવરોધે છે તેવા અવરોધ માટેન ં ઉદાિરણ:


ચેઇત્રનગ

A. River નદી B. Hillock હિલોક

C. Lake તળાવ D. Building ચબલ્િીંગ

52. To enhance the accuracy of the measurement, which of the following points is important when selecting a site
for a base line?

માપનની સચોટતા વધારવા માટે, બેઝ લાઇન માટે સાઇટ પસંદ કરતી વખતે નીચેનામાંથી કર્ો મદ્દો મિત્વપ ૂણય છે ?
Page 13 of 16

akshaypatel00037 holisticacademy holistic.academy


A. Site should be as away as possible from satellite points

A. સાઇટ સેટેલાઇટ પોઈડટથી બને તેટલી દૂ ર િોવી જોઈએ

B. The ground should be free from obstacles

B. જમીન અવરોધોથી મક્ત િોવી જોઈએ I R


S
A Y
C. The ground should be free sunlight
S H
C. જમીન સ ૂર્યપ્રકાશ મક્ત િોવી જોઈએ
A K
BY
D. The ground should be of a uniform gradient to all sides from center

M
D. જમીન કેડદ્રથી ચારે બાજ એક સમાન ઢાળવાળી િોવી જોઈએ
Y
D E
C A
53. An average length of a pace is:
A
ગત્રતની સરે રાશ લંબાઈ છે :
I C
S T
A. 60 cm
L I B. 80 cm

HO C. 100 cm D. 120 cm

54. The ranging operation in survey is a process of:

સવેક્ષણમાં શ્રેણીબદ્ધ કામગીરી એ એક પ્રહક્રર્ા છે

A. Reconnaissance હરકોત્રનસડસ

B. Judging the distance અંતર નક્કી

C. Establishing intermediate points terminals મધ્ર્વતી પોઈડટ ટત્રમિનલ્સની સ્થાપના

D. Determination of slope ઢાળન ં ત્રનધાયરણ

55. When two stations for which ranging is to be done are not intervisible, the ranging method used in such case is:

જ્ર્ારે બે સ્ટેશનો કે જેના માટે રે ન્ડજિંગ કરવાન ં છે તે ઇડટરત્રવચઝબલ નથી, ત્ર્ારે આવા હકસ્સામાં ઉપર્ોગમાં લેવાતી રે ન્ડજિંગ

પદ્ધત્રત છે :

A. Reciprocal ranging પારસ્પહરક શ્રેણી B. Direct ranging િાર્રે ક્ટ રે ડજ

C. Partial ranging આંત્રશક શ્રેણી D. Simultaneous ranging એક Page


સાથે શ્રેણ
14ી of 16

akshaypatel00037 holisticacademy holistic.academy


56. Correction due to slope is

ઢાળને કારણે કરે ક્શન છે

A. Negative નકારાત્મક B. Positive િકારાત્મક

I R
B. Fluctuating વધઘટ D. Can’t say કિી શકતા નથી S
A Y
57. For indirect ranging, number of ranging rods required is……….
S H
પરોક્ષ રે ન્ડજિંગ માટે, રે ન્ડજિંગ સચળર્ાની સંખ્ર્ા જરૂરી છે ………. A K
A. 3 BY
B. 4
MY
C. 2
A DE D. 1

A
58. An invar tape is made up of an alloy of C
એક invar ટેપ એક એલોર્ બનેલી છે
I C
S T
L I
A. Copper and steel કોપર અને સ્ટીલ B. Brass and nickel ત્રપત્તળ અને ત્રનકલ

HO C. Brass and steel ત્રપત્તળ અને સ્ટીલ D. Nickel and steel ત્રનકલ અને સ્ટીલ

59. The accuracy of measurement in chain surveying does not depend upon

સાંકળ સવેક્ષણમાં માપનની ચોકસાઈ તેના પર ત્રનભયર નથી

A. Length of the offset (ઑફસેટની લંબાઈ)

B. Scale of the plotting( પ્લોહટિંગન ં સ્કેલ)

C. Importance of the features( લક્ષણોન ં મિત્વ)

D. General layout of the chain lines( સાંકળ રે ખાઓન ં સામાડર્ લેઆઉટ)

Answer sheet:-

1 B 26 A 51 B
2 A 27 D 52 B
3 A 28 C 53 B
4 D 29 D 54 C Page 15 of 16

akshaypatel00037 holisticacademy holistic.academy


5 A 30 B 55 A
6 C 31 A 56 A
7 B 32 D 57 B
8 B 33 D 58 D
9 D 34 C 59 D
10 B 35 C
I R
11 B 36 C S
12 A 37 A
A Y
13 B 38 C
SH
14 C
15 A
39 A
40 D A K
16 C 41 A BY
17 B 42 A
M Y
18 D 43 A
D E
19 C 44 A
C A
20 C 45 B
A
21 B
I C
46 A
22 C
23 B ST 47 D
48 C
L
24 CI 49 A

HO
25 A 50 D

Page 16 of 16

akshaypatel00037 holisticacademy holistic.academy

You might also like