Youtube Search
Ali Ejaz PPSC
1. For concreting of heavily reinforced sections without vibration, the workability .
concrete expressed as compacting factor should be: Above 0,92,
When a canal flowing under pressure is carried below a natural drainage such that its
Materials and Construction:
F.S.L. does not touch the underside of the supporting structure, the structure so provided,
is called Super Passage,
3. Flexibility of proportional outlet is Ons,
4. Incorrect statement; for hyper proportional outlet Mexibility fs tess than one.
$S. Depth of slab having both ends continuous as per ACI is L228.
4, Gauge is installed on inclined slope then factar used for the reading is; Cosine of angle
seth vertical,
7. Intevelling, the correction for curvature (in metres) is equal: 0.07851.
8. If fore bearing of a line is N26"35'W then its back bearing: $26°35'E.
9, ‘The magnetic bearing of a line is 133° 30" and the magnetic declination is $° 15' east. The
true bearing of a line will be:
10. A line normal to the plumb line ot all paints is known as: Level Ling,
HL. Anangle between the inclined line af sight and the horizontal is called: Verileal Angle.
12. The shape of cable under uniformly distributed horizontal load is :
. The strain cnergy stared when subjected to maximum load, without suffering permanent
distortion, is known as: Proof Resillence,
1M. Slag is added in cement to impart: Bg
15. 1? moment in an unbraced fength ix constant then value af Ce will be: 1.
16, Unit of co-efficient uf consolidation is: gmi/see.
17. Which of the following is mineral: Quartz.
18, In case of modified Compaction Test compared to standard comp:
shifted:
19, Use of gusset plate is; To Jala the members at a foint,
20, Shear stress in wide Mange section is: Maximum at center of web and minimum in
Manges,
21. Brick retains its shape becouse of Silla,
22. 1 watt is equal to one joule per: I-second.
23, If duration of project is decreased then: Direct cost will Increase und indirect cost will
tion test, graph is
24, Transverse distance between the row of fasteners: Gauge.
25, If mach number is less then ane, then flow is: Sub-Sonics.
26. Retarder commonly used in cement is; Gypsum,
27. Pigment used for corrosive resistance in paint is: Red Lead,
28. The maximum permissible limit of lead in drinking water is: 0.05 ppm.
29. Dummny activity in a network path: does nat consume time.
30. Which industrial waste is most disastrous for drinking water: Ceramic Industry,
J, Which of the following causes most deathy: polluted water,
32. Length to dia ratio for cylinder used in tri axial compression test is : (None of these),
d>33. Hardest Rock is: Diamond Civil Knowledge
34, Which of the following is measured in 100 cu m: gl of thess,
35. Cofficient of restitution for perfectly elastic collision is: 1 Factory
36, In case af fly leveling (level is placed at ils point while shifting staff, staff is placed at
point when shitting level); alL of these
37, Incorrect statement: For bypersproportiana) Qutlets, Flexibility is fess thun one,
38, One way and two-way slab is decided on the basis of hath supporting system and.
dimensions,
39, Luter! Strain.
40. Vibro-foatation is used for; Cohestontess So
AL. Difference of level between banks and full supply in canal is:
42, Mas flow curve is: Graph of accumulative discharge and time,
43. Zone berween water level and ground surface: 4
4, The value of Es used in the immediate settlement equation, can be found out using:
Rankine Theory.
45, Velocity is simple harmonic motion: Omeva * r
46, Pipe of length double than the dimeter of orifice filted internally ar externally to the
orifice is; mouthplece,
47, ay of netual velocity at vena-contracta and theoretical velocity is:
Iv.
18, tan icy of well depends upon: permeability.
49, Flow In expanding pipe al constant rate is: steady non-uniform, -
50. Legal Conulitions on which both parties work: General Contitionsor, 2 / 3 v
SI. Item rate depends on; specifications of Works
52. Value of active earth pressure is always; Lesser than passive carth pressure .
53. Reduction factor for member bearing an concrete: 0,65.
$4. Which place ean be subjected to harmful level of nois
55, Ductile failure occurs in: under-relnforced,
56, For isotropic cube, number of elastic constants will be: ane,
57. Top level consumer in jungle are; conrnivores,
58, Triaxial test preferred over vane shear: because Hf cun perform under nll three
conditions of drainage,
59, Fine materials added in cement to impan useful properties: admbstures,
60, Range of value of deNection angle: Ethese,
61, For stable and determinant frame which is true; Im+r=3],
62, If Gm+r<6j then frame will be unstuble,
63, Brick having full width on one end and half width on other end: Bevelled Closure.
64, Trap which is provided to disconnect house drain from street sewer: nlLof these
65, Deduction of areas is not done for; nll of these,
66, Low grade bitumen is___and it is used for ; pone of these,
67, Necking is between elastic and plastle,
68, Which is not a greenhouse gas: Nitrogen,
69, Values for stiffness and fMexibility matrix is; positive for both,
Ib-way,70. Plywood has: has greater resistance to blows than ordinary wood,
71. Process of passing water through fine material: {iltrution.
72. Shakes in timber wider on outer side and narrower on inner side: star shakes,
73. Hath Kangan for Aarsi Kiya: Ja bant zair ho usay daryafal_karne ki kia zarorat,
74. Taweelay ki Bala, ke sar:_Bandar.
75. Key uscd for refreshing:
76. What is recommended after driver installation: Restart,
77. WY is 6% of: 300,
78. If interest on 800 is 40 mare than an interest on 400 for two years then interest nate is:
5%.
79, Antonym of ENFRANCHISE is: Subgugate,
80. Indirect narration is: Almul suid that he had not committed his mistuke,
81. Office head of state of New Zealand is: Elizabeth.
82. Treaty after World War 1; Treaty of Versallase,
83. Number of naphrones in human: J Million,
84. Call a spade, a spade means: Saving in plain terms,
85. Olive branch means: Cull for peace,
86, Afghanistan joined SAARC in: April 2007.
87. England created NWFP in year: 1901,
88. First FIFA WC was held in: 1930.
89. Friends not masters is book of Ayub Khan.
90. Biggest Island is: Greenland.
91. Kroshko Currents flows on which side of Japan: West side,
Youtube Search
Ali Ejaz PPSC