Professional Documents
Culture Documents
Tilt measurement (003) liebher
Tilt measurement (003) liebher
Rotary joint
To determine the condition of the swing ring bearing, the wear must be determined.
The wear of the swing ring bearing track shows when changing the axis movement
of the swing ring bearing. The wear is determined through regular reference meas-
urements of the tilt clearance.
Make sure the following prerequisites are met:
q Two gauges with an accuracy of 0.01 mm are available.
q Two magnetic gauge holders are available.
Fig. 1017: Slewing gear position and measuring points of the gauges (illustration of
principle)
1 Measuring point1 3 Measuring point3
2 Measuring point2 4 Measuring point4
LWN/RL/111 V001//Auslieferung/2015-10-12/en
Fig. 1018: Measuring points of the ball swing ring bearing or roller swing ring
bearing (illustration of principle)
1 Slewing column (slewing) A Recommended measuring points
2 Swing ring B Alternative measuring points
3 Base column (not slewing)
u Attach gauges to measuring point1 and measuring point2.
LWN/RL/111 V001//Auslieferung/2015-10-12/en
Fig. 1019: Measuring points of the swing ring bearing tilt clearance measurement
in the load chart
1 Maximum radius, maximum A Radius
permitted load (recommended)
2 Maximum radius, maximum B Load
permitted load (alternative)
3 Minimum radius, without load
u Set machine to status “minimum radius, without load” 3.
u Set gauges to zero.
u Set machine to status “maximum radius, maximum permitted load (recom-
mended)” 1.
u Read measuring values off on gauges and enter in chart (see: tab. 35,
page 378) .
If the maximum admissible swing ring bearing tilt clearance is exceeded when
measuring the swing ring bearing tilt clearance:
u Contact Liebherr customer service.