Professional Documents
Culture Documents
RP54_Fitting-Instruction_V2
RP54_Fitting-Instruction_V2
DOOR STOP
IN LINE
gasket (FIG.A). WITH SEALING SECTION PARALLEL
MARK SECTION
7. Re-hang the door. ON SILL 22 to
• Finally, follow step 8. INSIDE OF
SILL 25mm
*SEALING SILL OFFSET
For double doors: 22 to DOOR 3mm
SECTION
Buy 2 seals. 25mm
• • With door closed, • With door closed, mark line on door
sealing section to full width between jambs. position sealing section bottom, parallel to and 22 to 25mm
SILL
INSIDE • For an optimum seal at the latch side cut end, use a under door and hard up from door sill.
FLOOR TREAD
PLATE
against hinge side jamb. •
GASKET
Mark seal at door edge. door stop from inside face of door.
4 5 8
SAW IN LINE
INSIDE DOOR WITH
OF BOTTOM OFFSET
DOOR ‘V’ GROOVE
DOOR MARK
BOTTOM ON SILL
TREAD
CUT AWAY PLATE
SEALING SECTION DRIP STRIP SILL
UNWANTED AREA GASKET
• Remove door. • If door is thicker than 35mm split sealing • Position tread plate to
• Saw along marked line. section at ‘v’ groove so drip strip can be
• Sand and paint the cut
• sealant at ends of tread
V2 / 14.07.23