Professional Documents
Culture Documents
r2
r2
r2
Cisco 2621 (MPC860) processor (revision 0x200) with 253952K/8192K bytes of memory
.
Processor board ID JAD05190MTZ (4292891495)
M860 processor: part number 0, mask 49
Bridging software.
X.25 software, Version 3.0.0.
2 FastEthernet/IEEE 802.3 interface(s)
32K bytes of non-volatile configuration memory.
63488K bytes of ATA CompactFlash (Read/Write)
Would you like to enter the initial configuration dialog? [yes/no]: System
Bootstrap, Version 12.1(3r)T2, RELEASE SOFTWARE (fc1)
Copyright (c) 2000 by cisco Systems, Inc.
Initializing memory for ECC
..
C2600 processor with 524288 Kbytes of main memory
Main memory is configured to 64 bit mode with ECC enabled
Cisco 2621 (MPC860) processor (revision 0x200) with 253952K/8192K bytes of memory
.
Processor board ID JAD05190MTZ (4292891495)
M860 processor: part number 0, mask 49
Bridging software.
X.25 software, Version 3.0.0.
2 FastEthernet/IEEE 802.3 interface(s)
1 Low-speed serial(sync/async) network interface(s)
32K bytes of non-volatile configuration memory.
63488K bytes of ATA CompactFlash (Read/Write)
Router>
Router>en
Router#conf t
Enter configuration commands, one per line. End with CNTL/Z.
Router(config)#int f0/0
Router(config-if)#ip add 172.30.0.2 255.255.255.0
Router(config-if)#no shut
Router(config-if)#
%LINK-5-CHANGED: Interface FastEthernet0/0, changed state to up
Router(config-if)#
Router(config-if)#ex
Router(config)#
Router(config)#int s0/0
Router(config-if)#ip add 172.30.10.1 255.255.255.0
Router(config-if)#no sh
Router(config-if)#
Router(config-if)#
Router(config-if)#ex
Router(config)#route ospf 6
Router(config-router)#network 172.30.0.0 0.0.0.255 area 0
Router(config-router)#
00:25:48: %OSPF-5-ADJCHG: Process 6, Nbr 172.30.0.1 on FastEthernet0/0 from LOADING
to FULL, Loading Done
Router(config-router)#ex
Router(config)#
Router(config)#ex
Router#
%SYS-5-CONFIG_I: Configured from console by console
Router#
Router#sh ip ?
access-lists List access lists
arp IP ARP table
bgp BGP information
cache IP fast-switching route cache
cef Cisco Express Forwarding
dhcp Show items in the DHCP database
eigrp IP-EIGRP show commands
interface IP interface status and configuration
nat IP NAT information
nbar Network-Based Application Recognition
ospf OSPF information
protocols IP routing protocol process parameters and statistics
rip IP RIP show commands
route IP routing table
ssh Information on SSH
Router#sh ip ospf ?
<1-65535> Process ID number
border-routers Border and Boundary Router Information
database Database summary
interface Interface information
neighbor Neighbor list
virtual-links Virtual link information
<cr>
Router#sh ip ospf nieghbour
^
% Invalid input detected at '^' marker.