Professional Documents
Culture Documents
r0
r0
Cisco 2621 (MPC860) processor (revision 0x200) with 253952K/8192K bytes of memory
.
Processor board ID JAD05190MTZ (4292891495)
M860 processor: part number 0, mask 49
Bridging software.
X.25 software, Version 3.0.0.
2 FastEthernet/IEEE 802.3 interface(s)
32K bytes of non-volatile configuration memory.
63488K bytes of ATA CompactFlash (Read/Write)
Router>en
Router# conf t
Enter configuration commands, one per line. End with CNTL/Z.
Router(config)#int f0/0
Router(config-if)#ip add 172.30.0.0 255.255.255.0
Bad mask /24 for address 172.30.0.0
Router(config-if)#ip add 172.30.0.1 255.255.255.0
Router(config-if)#no shut
Router(config-if)#
%LINK-5-CHANGED: Interface FastEthernet0/0, changed state to up
Router(config-if)#
Router(config-if)#ex
Router(config)#route ospf 6
Router(config-router)#?
area OSPF area parameters
auto-cost Calculate OSPF interface cost according to bandwidth
default-information Control distribution of default information
distance Define an administrative distance
exit Exit from routing protocol configuration mode
log-adjacency-changes Log changes in adjacency state
neighbor Specify a neighbor router
network Enable routing on an IP network
no Negate a command or set its defaults
passive-interface Suppress routing updates on an interface
redistribute Redistribute information from another routing protocol
router-id router-id for this OSPF process
Router(config-router)#network 172.30.0.0 0.0.0.255 area 0
Router(config-router)#
00:28:23: %OSPF-5-ADJCHG: Process 6, Nbr 172.30.10.1 on FastEthernet0/0 from
LOADING to FULL, Loading Done
Router(config-router)#
Router(config-router)#network 172.30.10.0 0.0.0.255 area 10
Router(config-router)#network 172.30.20.0 0.0.0.255 area 20
Router(config-router)#
00:35:24: %OSPF-5-ADJCHG: Process 6, Nbr 172.30.20.1 on FastEthernet0/0 from
LOADING to FULL, Loading Done