Professional Documents
Culture Documents
r1
r1
r1
Cisco 2621 (MPC860) processor (revision 0x200) with 253952K/8192K bytes of memory
.
Processor board ID JAD05190MTZ (4292891495)
M860 processor: part number 0, mask 49
Bridging software.
X.25 software, Version 3.0.0.
2 FastEthernet/IEEE 802.3 interface(s)
32K bytes of non-volatile configuration memory.
63488K bytes of ATA CompactFlash (Read/Write)
Would you like to enter the initial configuration dialog? [yes/no]: System
Bootstrap, Version 12.1(3r)T2, RELEASE SOFTWARE (fc1)
Copyright (c) 2000 by cisco Systems, Inc.
Initializing memory for ECC
..
C2600 processor with 524288 Kbytes of main memory
Main memory is configured to 64 bit mode with ECC enabled
Cisco 2621 (MPC860) processor (revision 0x200) with 253952K/8192K bytes of memory
.
Processor board ID JAD05190MTZ (4292891495)
M860 processor: part number 0, mask 49
Bridging software.
X.25 software, Version 3.0.0.
2 FastEthernet/IEEE 802.3 interface(s)
1 Low-speed serial(sync/async) network interface(s)
32K bytes of non-volatile configuration memory.
63488K bytes of ATA CompactFlash (Read/Write)
Router>
Router>
Router>en
Router#conf t
Enter configuration commands, one per line. End with CNTL/Z.
Router(config)#int f0/0
Router(config-if)#ip add 172.30.0.3 255.255.255.0
Router(config-if)#no sh
Router(config-if)#
%LINK-5-CHANGED: Interface FastEthernet0/0, changed state to up
Router(config-if)#
Router(config-if)#ex
Router(config)#int s0/0
Router(config-if)#ip add 172.30.20.1 255.255.255.0
Router(config-if)#no sh
Router>
Router>en
Router#conf t
Enter configuration commands, one per line. End with CNTL/Z.
Router(config)#route ospf 6
Router(config-router)#network 172.30.0.0. 0.0.0.255 area 0
^
% Invalid input detected at '^' marker.
% Incomplete command.
Router(config-router)#
Router(config-router)#
Router(config-router)#network 172.30.20.0 0.0.0.255 area 20
Router(config-router)#
00:35:11: %OSPF-5-ADJCHG: Process 6, Nbr 172.30.20.2 on Serial0/0 from LOADING to
FULL, Loading Done
Router con0 is now available