Professional Documents
Culture Documents
Full download Electrical Wiring Industrial Canadian 5th Edition Herman Solutions Manual file pdf free all chapter
Full download Electrical Wiring Industrial Canadian 5th Edition Herman Solutions Manual file pdf free all chapter
https://testbankbell.com/product/solution-manual-for-electrical-
wiring-industrial-15th-edition/
https://testbankbell.com/product/test-bank-for-electrical-wiring-
industrial-15th-edition/
https://testbankbell.com/product/test-bank-for-electrical-wiring-
residential-20th-edition-ray-c-mullin-phil-simmons/
https://testbankbell.com/product/solutions-manual-to-accompany-
industrial-electronics-9780132064187/
Electrical Control for Machines 7th Edition Lobsiger
Solutions Manual
https://testbankbell.com/product/electrical-control-for-
machines-7th-edition-lobsiger-solutions-manual/
https://testbankbell.com/product/macroeconomics-canadian-5th-
edition-blanchard-solutions-manual/
https://testbankbell.com/product/future-of-business-canadian-5th-
edition-althouse-solutions-manual/
https://testbankbell.com/product/solutions-manual-to-accompany-
probability-random-processes-for-electrical-computer-
engineers-9780521864701/
https://testbankbell.com/product/introduction-to-managerial-
accounting-canadian-5th-edition-brewer-solutions-manual/
Electrical Wiring: Industrial, Fifth Canadian Edition
Electrical Wiring Industrial Canadian 5th
REVIEW
3. The three main components of a unit substation are identified below. For each component,
name the principal parts and identify their function(s). The parts are listed in Figure 2-3.
a. High-voltage section principal parts: pothead, lightning arrester, overcurrent
protection, and grounding bus. A pothead is installed whenever lead-covered cable is
used in order to terminate the cable and to provide load-side connections. The
lighting arrester provides protection from lightning strikes to overhead power lines. An
overcurrent device (a fused switch or circuit breaker) is installed to provide
protection from overloads and short circuits (faults). A grounding bus is installed in
all three sections to provide a convenient and reliable place to make the required
grounding connections.
b. Transformer section principal parts: transformer and transformer taps. The
transformer converts the voltage that is transmitted (provided by the utility company)
to the voltage that required in the building. The transformer is equipped with taps that
allow the adjustment, higher or lower (usually in small percentage steps), of the
incoming voltage to create an appropriate output voltage for the user.
c. Low-voltage section principal parts: terminals, secondary bus, and neutral
connections. Terminals are provided on the load side of the protective devices to
allow the connection of the load conductors. The secondary bus connects the
transformer output with the feeder protective devices. All neutral connections are
brought to a neutral bus. This provides a convenient and reliable place to make
neutral connections.
4. Explain the operation of ground detectors and identify the situation that would require their use.
Under certain conditions, if the secondary is ungrounded (floating) then detectors may be
installed to detect inadvertent grounding. By connecting a lamp from each phase to a
common ground, the lamps will each light dimly until a ground occurs, then one of the lamps
will go out while the other two will become brighter. Some ground faults will not trigger a
fuse or breaker to interrupt current so a ground fault detector allows personnel to know that a
fault exists and begin the process of troubleshooting to locate it.
Electrical Wiring: Industrial, Fifth Canadian Edition
7. Calculate the pulling tension on a run of conduit containing three conductors that weigh 3 kg
per metre each. The run consists of a straight section 25 m long, a 90° bend, and a second
straight section 40 m long.
The pulling tension throughout the run would be as follows:
Pulling tension:
at start of run Ts = 0
at end of 25 m straight length TS1 = L × W × f = 25 m × 9 kg × 0.5 = 112.5 kg
at end of bend TB1 = TS1 × bending coefficient = 112.5 kg × 2.2 = 247.5 kg
at end of second straight piece TS2 = TB1 + (L × W × f) = 247.5 + (40 × 9 × 0.5) = 427.5 kg
8. What maximum size overcurrent device would be required in the primary disconnect of a 600 V
primary and to a 120/208 V secondary, three-phase, four-wire, 45 kVA drytype transformer?
CEC Rule 26-256 Iprimary = kVA/√3 * Vprimary * 125% = 54.1265 A fuse. CEC Rule 26-256 (3)
allows you to go to a 60 A fuse. That would allow you to get the full 45 kVA out of the
transformer. CEC Rule 26-256 (1) would limit you to a 50 A (43.3 * 1.25) fuse since the
rated primary current of the transformer is 43.3 A. This would result in less available current
on the secondary due to the transformer, so it is common to quote CEC Rule 26-256 (3) and
take full advantage of the transformer. Either answer is technically correct but common trade
practice would be to use a 60 A fuse.
— Dobs., Vesperugo, 15
— — minima var., 10
— (Gray), Nyctinomus, 18
— Sciurus, 22
brachyotis, Cynopterus, 8
— Pachysoma, 8
— (Dobs.), Xantharpyia, 6, 7
brachyotum, Pachysoma, 8
brachyotus, Cynopterus, 8
— (Temm.), Vesperugo, 14
Carponycteris, 8, 10
— australis (Ptrs.), 10
— minima (Geoffr.), 10
— (Gr.), Phalanger, 31
— Schl., Pteropus, 6
— Sus, 28
— peroni Geoffr., 8, 9
— equinus, 30
Cynonycteris minor, 6
— — nigrescens (Temm.), 4
— nigrescens (Temm.), 3
— latidens Dobs., 7
— marginatus (Geoffr.), 7, 8
— — var. andamanensis, 8
— — var. brachyotis, 8
Dysopes, 43, 48
Echimys Gray, 27
Echinothrix, 27
Echiothrix, 27
equinus, Cervus, 30
Harpyia, 8
Hesperoptenus Ptrs., 14
— diadema (Geoffr.), 11
— fulvus Gr., 12
— tonkeanus A. B. M., 3
Macroglossus, 8
— minimus, 10
— Mus, 24
— Ptrs., Vesperus, 12
— Cynonycteris, 6
— Horsf., Rhinolophus, 11
— (Dobs.), Xantharpyia, 6, 7
Molossops Ptrs., 51
— bonariensis (Ptrs.), 50
— fluminensis Lat., 50
— beccarii Ptrs., 19
— concolor Blyth, 23
— datae A. B. M., 25
— ephippium Jent., 23
— — negrinus Thos., 23
— hellwaldi Jent., 25
— meyeri, 24
— rattus L., 22
musanga, Paradoxurus, 20
— Schl., Paradoxurus, 20
Myopterus Geoffr., 51
— Papio, 4
— Cynopithecus niger, 4
— albiventer Dobs., 51
— angolensis Ptrs., 45
— australis (Gray), 18
— brachypterus (Ptrs.), 44
— kalinowskii Thos., 50
— orthotis H. Allen, 50
— plicatus (Buch. Ham.), 17, 18, 37, 38, 40, 41, 43, 44, 45, 46, 51
— sarasinorum A. B. M., 16, 17, 18, 32, 36, 37, 40, 42, 44, 45, 50, 51
— setiger (Ptrs.), 50
— tenuis, 44
— wilcoxi (Krefft), 18
Ornithorhynchus, 41
Pachysoma brachyotis, 8
— brachyotum, 8
Papio niger, 4
— musanga, 20
— musschenbroeki Schl., 20
— doreyana Q. G., 41
— gunni Gr., 41
peroni, Cephalotes, 8
— Geoffr., Cephalotes, 9
personatus, Pteropus, 7
— ursinus (Temm.), 31
philippensis, Tarsius, 5
plicatus (Buch. Ham.), Nyctinomus, 17, 18, 37, 38, 40, 41, 43, 44, 45, 46, 51
Promops Gerv., 52
— celebensis Schl., 6
— hypomelanus Temm., 6
— mackloti Temm., 6, 7
— personatus, 7
— wallacei, Gr. 5, 7
— euryotis Temm., 11
— hippocrepis (Hermann), 34
— hipposideros (Bchst.), 34
— megaphyllus Gr., 11
— minor Horsf., 11
sangirensis, Tarsius, 5
sarasinorum A. B. M., Nyctinomus, 16, 17, 18, 32, 36, 37, 40, 42, 44, 45, 50, 51
— A. B. M., Sciurus, 21
Sciurus bicolor, 22
— — occidentalis A. B. M., 21
— sarasinorum A. B. M., 21
spectrum, Tarsius, 5
Sus celebensis, 28
— philippensis, 5
— sangirensis, 5
— spectrum, 5
tenuis, Nyctinomus, 44
— major (Dobs.), 8, 9
— hasselti Temm., 16
— muricola Hdgs., 16
— affinis Dobs., 15
— brachypterus (Temm.), 14
— imbricatus Horsf., 15
— indicus Dobs., 15
— minahassae A. B. M., 14
— — orientalis A. B. M., 14
— stenopterus Dobs., 15
— pachypus (Temm.), 12
— brachyotis (Dobs.), 6, 7
— minor (Dobs.), 6, 7
xanthurus Gr., Mus, 25, 26
[Inhalt]
Addenda
Seite 5, 1. Zeile, füge hinzu: Sowie vom Pik von Bonthain, circa 1350
m hoch, Wald bei Erelompu, Süd Celébes.
Seite 20, Zeile 12 von unten: Das Exemplar ist in Spiritus conservirt.
Seite 20, Zeile 6 von unten: Es ist noch ein junges Exemplar (h), Fell
und Schädel, in Spiritus, von Rurukan, Minahassa, Nord Celébes,
vorhanden. [1]
[Inhalt]
1 Da es zweifelhaft geworden war, ob es richtig sei, Celebes mit dem Ton auf der
zweiten Silbe zu sprechen, so habe ich neuerdings die von mir seit lange
geübte Schreibweise Celébes, mit einem Accent auf dem zweiten e, verlassen
(Abh. Ber. 1896/7 Nr. 6 p. 1 Anm. 1); kürzlich hat jedoch Dr. F o y nachgewiesen
(Publ. Ethn. Mus. Dresden Bd. XII 1899, Anhang: Über den Namen Celébes), dass
aller Wahrscheinlichkeit nach „Celébes“ das richtige ist, und ich kehre daher dazu
zurück. ↑
2 W. L. S c l a t e r (Geogr. J. VIII, 387 1896 u. Geogr. Mam. 1899, 148) kennt 31
Gattungen Landsäugethiere, darunter 16 Fledermäuse von Celébes, lässt sich
aber über die Artenzahl nicht aus. Die von mir genannte Artenzahl (83) vertheilt
sich auf 35 Gattungen Landsäugethiere, darunter 17 Gattungen Fledermäuse, und
rechnet man die Arten von den Inseln des Celébes-Areals dazu, die nicht auf
Celébes selbst vorkommen (13), so erhöht sich die Zahl der Fledermausgattungen
auf 19. — Von Bórneo kannte H o s e (Mam. Borneo 1893, 38–41) 37 Arten
Fledermäuse und E v e r e t t (PZS. 1893, 494–5), mit Einbeziehung gewisser
Inseln im Norden Bórneos („Bórneo-Gruppe“), ebenfalls 37, was aber gegenüber
den 44 Arten der Celébes-Gruppe vermuthen lässt, dass dort noch manche zu
entdecken sein werden. ↑
3 TZS. = Trans. Zool. Soc., PZS. = Proc. Zool. Soc., NLM. = Notes Leiden Mus.,
Cat. MPB. = Cat. Mus. Pays-Bas, TTLV. = Tijdschr. ind. Taal-, Land- en
Volkenkunde, NTNJ. = Nat. Tijdschr. Ned. Ind., AMNH. = Ann. Mag. Nat. Hist., NZ.
= Nov. Zool., u. a. m. ↑
[Inhalt]
Primates