Professional Documents
Culture Documents
07a40403-Semi Conductor Devices and Circuits
07a40403-Semi Conductor Devices and Circuits
SET-1
JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY, HYDERABAD R07 II B.Tech. II Semester Regular Exams, April/May 2009
1. a) b)
2.
[4+4+4+4]
3. a) b) 4. a) b) 5.
Draw the basic block diagram of a DC power supply and explain each block. Explain how p-n junction diode acts as a rectifier. [8+8] Explain the construction and principle of operation Bipolar junction transistor Describe the current components in NPN and PNP transistors. [8+8] Derive the following with reference to the h-parameter model of BJT in CE configuration. a) Ai b) Ri c) Av d) Ro [4+4+4+4] Write short notes on the following with reference to the RC coupled amplifier: a) Band width b) Lower cutoff frequency c) Upper cutoff frequency d) Effect of shunt and bypass capacitances. [4+4+4+4] Describe Transconductance amplifier with neat diagram. In an amplifier has a gain of 60dB, a feedback of =0.005 is applied. What would be the change in overall gain of the feedback amplifier if the basic amplifier is subjected to a gain reduction of 12%. [6+10] Explain the principle behind negative resistance oscillator with an example. Draw the circuit of RC phase shift oscillator, what is condition for oscillations and also derive the frequency oscillations. [6+10] -----
6.
7. a) b)
8. a) b)
SET-2
JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY, HYDERABAD R07 II B.Tech. II Semester Regular Exams, April/May 2009
1.
[4+4+4+4] [8+8]
2. a) b)
3. a) Explain the principle, Construction, advantages and disadvantages of full wave rectifier. b) In a Full Wave Rectifier a signal of 300V at 50Hz is applied at the input. Each diode has internal resistance of 800 . If the load is 200 then calculate Idc, Vdc, Pdc and efficiency. [6+10] 4. a) Clearly explain the constructional features of MOSFET. b) Compare BJT, JFET and MOSFET characteristics. [8+8] 5. a) b) 6. a) b) 7. a) b) Draw the h parameter models for CB, CE and CC configurations. Give the relation between CE, CB and CC h parameters. Draw the small signal model of JFET and explain each parameter. Discuss on the frequency response of JFET-CS amplifier. [8+8] [8+8]
Describe Trans conductance amplifier with neat diagram. Two amplifiers each with a gain of 100 are connected in cascade, and negative feed back is applied to provide an overall gain of 20. Determine i) The Feed back factor ii) The Percentage increase in the overall gain if the gain of each amplifier increases by 100%. [6+10] Classify oscillators and explain. Draw the circuit of a Wein bridge oscillator and explain with necessary expressions for the frequency of oscillations. [6+10]
8. a) b)
------
SET-3
JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY, HYDERABAD R07 II B.Tech. II Semester Regular Exams, April/May 2009
1 a) b) 2. a) b) 3.
4. a) b) 5.
[6+10] [8+8]
6. a) b) 7. a) b) 8. a) b)
Discuss on the need of feedback amplifier and give few advantages and disad vantages. Briefly explain current series feedback amplifier with neat sketches and necessary equations. [8+8] Compare Wein bridge and phase shift oscillators. A crystal has the following parameters L=0.33H, C1=0.065pF, C2=1.0pF and R=5.5K . Find the series resonant frequency and Q of the crystal. [6+10] -----
SET-4
JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY, HYDERABAD R07 II B.Tech. II Semester Regular Exams, April/May 2009
1. a) b) 2.
[8+8]
[4+4+4+4]
3.
4.
[5+6+5]
5.
[5+5+6]
6. a) Discuss on the frequency response characteristics JFET-CS amplifier. b) Calculate the voltage gain Av= Vo/Vi at 1 KHz for the circuit shown. The FET parameters are gm = 2m A/V and rd=10K . [6+10]
7. a) b) 8. a) b)
Discuss on the general structure of the Feedback circuit. Determine Ri and Ro of current shunt Feedback amplifier. State and explain Barkhausan criterian. For a wein bridge oscillator prove that 1 f = 2 R1 R2C1C2 --------
[8+8]
[6+10]