Professional Documents
Culture Documents
S. E. Woosley Et Al - The Collapsar Model For Gamma-Ray Bursts
S. E. Woosley Et Al - The Collapsar Model For Gamma-Ray Bursts
S. E. Woosley (UCSC) Weiqun Zhang (UCSC) Alex Heger (Univ. Chicago) Andrew MacFadyen (Cal Tech) Harvard CfA Meeting on GRBs, May 21, 2002
Requirements on the Central Engine and its Immediate Surroundings (long-soft bursts)
Collimate the emergent beam to approximately 0.1 radians Make bursts in star forming regions In the internal shock model, provide a beam
with rapidly variable Lorentz factor
Allow for the observed diversity seen in GRB light curves Last approximately 20 s, but much longer in some cases Explain diverse events like GRB 980425 Produce a (Type Ib/c) supernova in some cases Make x-ray lines
Collapsars
A rotating massive star whose core collapses to a black hole and produces an accretion disk.
Type I II III
Comment neutrino-dominated disk black hole by fall back time dilated, redshifted very energetic, pair instability, low Z
Type I is what we are usually talking about. The 40 solar mass limit comes from assuming that all stars above 100 solar masses on the main sequence are unstable (except Pop III).
Quasar 3C 175 as seen in the radio Quasar 3C273 as seen by the Chandra x-ray Observatory
Collapsar Progenitors
Two requirements:
outside the black hole (this virtually guarantees that the hole is a Kerr hole)
Solar metallicity
Low metallicity
With decreasing metallicity, the binding energy of the core and the size of the silicon core both increase, making black hole formation more likely at low metallicity.
Woosley, Heger, & Weaver, RMP, (2002)
The more difficult problem is the angular momentum. This is a problem shared by all current GRB models that invoke massive stars...
In the absence of mass loss and magnetic fields, there would be abundant progenitors. Unfortunately nature has both.
Heger, Woosley, & Spruit in prep. for ApJ Spruit, (2001), A&A, 381, 923
15 M Helium Star
followed here
Heger and Woosley (2002) using prescription for magnetic torques from Spruit (2001)
deficient regions, either at high red shift or in small galaxies (like the SMC). The metallicitydependence of mass loss rates for RSGs is an important source of uncertainty. (Kudritzsky (2000); Vink, de Koters, & Lamers A&A, 369, 574, (2001))
But below some metallicity Z about, 0.1, single massive stars will not make GRBs because they do not lose their hydrogen envelope. GRBs may therefore not track the total star formation rate, but of some special set of stars with an appreciable evolutionary correction.
Progenitor Winds
Massive Wolf-Rayet stars during helium burning are known to have large mass loss rates, approximately 10-5 solar masses/yr or more. This wind may be clumpy and anisotropic and its metallicity dependence is uncertain. The density dependence of matter around a single star in vacuum could be approximately 1000 (1016 cm/R)2 cm-3 composed of carbon, oxygen, and helium, BUT During approximately the last ~100 1000 years of its life, the star burns carbon (mainly) and heavier fuels. The mass loss rate of the star during these stages is unknown. No WR star has ever knowingly been observed in such a state. This means that the mass distribution inside ~ 1017 - 1018 cm is unknown (100 yrs at 1000 km/s).
Given the necessary angular momentum, black hole formation is accompanied by disk formation...
7.6 s
7.5 s
Neutrino flux low Neutrino flux high MacFadyen & Woosley ApJ, 524, 262, (1999)
It is good to have an energy deposition mechanism that proceeds independently of the density and gives the jet some initial momentum along the axis
a=0.5
Fryer (1998)
a 1
The efficiencies for converting accreted matter to energy need not be large. B ~ 1014 1015 gauss for a 3 solar mass black hole. Well below equipartition in the disk.
Eventually shuts off when M can no longer sustain such a large B-field.
Jet Initiation - 1
The jet is initially collimated by the density gradient left by the accretion. It will not start until the ram pressure has declined below a critical value.
Jet Initiation -2
High disk viscosity (7.6 s + 0.6 s) Low disk viscosity (9.4 s + 0.6 s)
Needed to power the light curve of the supernova if A bigger problem than most realize
The jet doesnt do it too little mass Forming the black hole depletes the innermost core of heavy elements Pulsars may have a hard time too if their time scale is > 1 sec
is made by a wind off of the accretion disk. Its abundance is related to how much mass accretes into the hole
56Ni
Zoom out by 10
480 radial zones 120 angular zones 0 to 30 degrees 80 angular zones 30 to 90 degrees 15 near axis
Initiate a jet of specified Lorentz factor (here 50), energy flux (here 1051 erg/s), and internal energy (here internal E is about equal to kinetic energy), at a given radius (2000 km) in a given post-collapse (7 s) phase of 15 solar mass helium core evolved without mass loss assuming an initial rotation rate of 10% Keplerian. The stars radius is 8 x 1010 cm. The initial opening angle of the jet is 20 degrees.
The pressure in the jet is greater than in the star through which it propagates.
The jet can be divided into three regions: 1) the unshocked jet, 2) the shocked jet, and 3) the jet head.
For some time, perhaps the duration of the burst, the jet that emerges has been shocked and has most of its energy in the form of internal energy. Information regarding the central engine is lost.
Zhang, Woosley, & MacFadyen ApJ, to be submitted
Independent of initial opening angle, the emergent beam is collimated into a narrow beam with opening less than 5 degrees (see also Aloy et al. 2000)
The previous calculation was 2D in spherical coordinates. This puts all the resolution near the origin and also spends a lot of zones following the unshocked star. Repeat using cylindrical coordinates and study the just the jets interactions with finer zoning but keeping the same density and temperature structure as in the star along its rotational axis. Carry 80,000 km = 10% of the star.
150 x 800 zones; zone size 100 km R i = 2000 km initial jet radius = 700 km (20 deg at 2000 km) = 10 E int / KE = 20 E = 5 x 1050 erg s -1
Lorentz factor
Density
Density structure at 2.2 seconds; inner 80,000 km (star radius is 800,000 km).
Lessons Learned
The variations in Lorentz factor and density can An initially collimated jet stays collimated. There may be important implications for the
light curve especially its time structure.
The Jet Explodes the Star Continue the spherical calculation for a long time, at least several hundred seconds. See how the star explodes, the geometry of the supernova, and what is left behind.
Inner radius = 2 x 108 cm Outer radius = 1012 cm = 10 for 20 seconds then declines to 2 at 1000 sec E = 5 x 1050 erg s -1 declining to 10 47 erg s -1 at 1000 s E int / KE = 20 declining to 2 at 1000 sec o = 20o
Zoom in by 5... The shock has wrapped around and most of the star is exploding. Outer layers and material along the axis moves very fast. Most of the rest has more typical supernova like speeds ~ 3000 10,000 km s-1
80 seconds
Shown on a magnified scale, there is still a lot of dense low velocity material near the black hole
radial velocity/c
at 240 seconds
The shock has wrapped around and the whole star is exploding (initial radius was less than one tick mark here). A lot of matter in the equatorial plane has not achieved escape velocity though and will fall back. Continuing polar outflow opens a channel along the rotational axis.
240 seconds By this time the star has expanded to over ten times its initial radius the expansion has become (very approximately) homologous. Provided outflow continues along the axis as assumed, an observer along the axis (i.e., one who saw a GRB) will look deeper into the explosion and perhaps see a bluer supernova with broader lines (e.g., SN2001ke; Garnavich et al. 2002). Continued accretion is occurring in the equatorial plane. Caution: Effect of disk wind not included here
10 seconds
35 seconds
The jet properties are shown 35 seconds after its initiation. Lines give properties at 6.0, 7.5, and 9.0 x 1011 cm. At 15 degrees in Model W1, the equivalent isotropic energy flux is about 1046 erg s -1 (solid line).
GRB
200
5o , internal shocks
Some Conclusions:
The light curves of (long-soft) GRBs may reflect more the
interaction of the jet with the star than the time variability of the engine itself.
large fraction of its energy as internal energy. Expansion after break out of material with Lorentz factor of order 10 can still give final Lorentz factors over 100.
Circum-burst mass distribution highly uncertain 56Ni synthesis given by disk wind. May be related to
total mass accreted.