Professional Documents
Culture Documents
Radius Turner
Radius Turner
Radius Turner
Chuck a dowel pin or other at least 1.5" so the tool can s the chuck.
Make sure the center of rota the lathe centerline and mov tip touches the rod and tigh
Move the cross slide in half You can use this same meth line and offset it for radii no
Note that the tool now has th side. Do not touch the cros on.
Chuck the workpiece. Bring the work. Set a carriage stop the face.
Swing the tool to take repea in a bit each time, closer to t Do not go past perpendicula
Done.
Once the hemisphere is form cut, if you do this before you you won't get a full round. N the chuck. You can't form th hemisphere, unless the work course means chatter, etc.