Professional Documents
Culture Documents
Jósmenta
Jósmenta
100g Salvia divinorum Leaf You can get Salvia divinorum Leaf all over the Internet. 1x Large Saucepan Just a regular large saucepan. Make sure its clean. No one wants to find the remains of burnt on spaghetti in their pipe. 1x Pyrex Tray A large, wide, glass dish essentially. You might find a casserole dish fits the bill. 1x Small Glass Container Anything will do, even a jam jar. 1x Tall, Narrow Glass Container The perfect tool for the job is a boiling tube, but anything remotely similar will do. 1x Pipette Not everyone has access to calibrated volumetric pipettes so anything that looks like an eye dropper will do. That means, a thin tube with a rubber bit on the end which you can squeeze. 2lt Propane Based Solvent No not propane, but either propan-2-ol (AKA Isopropanol, Isopropyl Alcohol, Rubbing Alcohol) or propanone (AKA Acetone). They need to be 99% pure at least. Dont even think about using nail varnish remover. 300ml Naphtha The best source of commercially available naphtha in the UK is lighter fluid.
As simple as it sounds, you have about 16 hours in which to twiddle your thumbs, watch some paint dry, or whatever you feel like. During this time, dont even think about touching your extraction, and make sure its in a dark place. Light has a nasty habit of destroying salvinorin-a in solution. The purpose of this step is to let any sediment such as tannins fall out of the leaf which are hard to extract later on. After the 16 or so hours are up, you may pour off the remaining liquid into the original saucepan, provided you emptied out the powdered leaf earlier.
Step 5 - Purification
When your black gunk is completely dry, you can scrape it out of your container and place it into a tall, narrow container. To this, add 50ml or so of naphtha. The naphtha dissolves the green/black waxes but leaves behind the salvinorin-a. After you add the first lot of naphtha, allow the container 30 minutes or so to settle, then pipette off two thirds of the naphtha and discard it. Repeat this process at LEAST 5 more times until your salvinorin-a is no longer a black colour. If you keep washing with naphtha, it will eventually turn white, however that kind of purity isnt necessary for making 10x extract. If you were making something like 40x or 60x (not recommended), then the higher the purity, the better. After the last naphtha wash, remove two thirds one last time and this time, allow the naphtha to evaporate off, leaving you with relatively pure salvinorin-a. DO NOT try and smoke/ingest this, as even a tenth of a milligram can be too much for some people.
Step 6 - Fortification
Now we have the salvinorin-a from 90g of leaf, we shall add it back to the 10g of quality leaf you set aside in Step 1. Although not completely accurate, you can see this is why its called 10x extract, as theres 10x the amount of salvinorin-a in the finished product. To do this, we place the salvinorin-a we produced in the previous step into the saucepan and add to it the same amount of solvent we used in step 1. Stir it round for a few minutes to ensure it has all dissolved. Next, add the 10g of leaf to your small container and pour the contents of the saucepan over it. You can now evaporate off all of this solvent as before, until all of the solvent has evaporated.
The finished product is approximately 10g of leaf, looking a little darker than normal, 10 times as strong.