Professional Documents
Culture Documents
Lectures Radar2 Hocvien
Lectures Radar2 Hocvien
Lectures Radar2 Hocvien
Outline
Basic radar range equation 2. Developing the radar range equation 3. Design impacts 4. Receiver sensitivity 5. Radar cross-section Exercises
1.
2/2011
Pt G RMax 4 3 (4 ) S min
2 2
2/2011 Radar range equation - 3
Pt G RMax 4 3 (4 ) S min
2 2
units of RMax
W m2m2 4 m W
2/2011
2/2011
Recall from the previous lecture that the average transmitted power is a function of peak pulse power and the pulse duration:
Pt Pave
2/2011
Ppeak Tp
1 , where Tp PRF
Radar range equation - 7
The amount of power reflected back from a target is a function of the power density at the target and the targets radar cross-section, :
The power density of the returned signal, echo, again spreads as it travels back towards the radar receive antenna.
2/2011
The antenna captures only a portion of the echoed power density as a function of the receive antennas effective aperture:
Pt G Pt G 2 2 power at receiver , Pr Ae , 2 4 3 4 (4 ) R (4 ) R
2G recalling that Ae 4
* In this equation the receiver is assumed to be all radar receive chain components except the antenna.
2/2011 Radar range equation - 11
2/2011
Therefore a radar system is capable of detecting targets as long as the received echo power is greater than or equal to the minimum detectable signal power of the receive chain:
Pt G 22 4 3 (4 ) S min
Radar range equation - 13
2/2011
A careful study of the radar range equation provides further insight as to the effect of several radar design decisions. In general the equation tells us that for a radar to have a long range, the transmitter must be high power, the antenna must be large and have high gain, and the receiver must be very sensitive.
2/2011
3.1 Power, Pt
Increases in transmitter power yield a surprisingly small increase in radar range, since range increases by the inverse fourth power.
For
example, a doubling of transmitter peak power results increases radar range by only 19%,
2 1.19
2/2011
The average power transmitted can also be increased by increasing the pulse duty cycle, sometimes referred to as the time-on-target. A combined doubling of the pulse width and doubling of the transmitter peak power will give a fourfold increase in average transmitted power, and ~41% increase in radar range.
4
4 1.41
Radar range equation - 16
2/2011
3.3 Gain, G
a parabolic dish, doubling the antenna size (diameter) will yield a fourfold increase in gain and a doubling of radar range.
D4
Radar range equation - 17
Similar to that of transmitter power, increases in receiver sensitivity yield relatively small increases in radar range.
Only
19% range increase for a halving of sensitivity, and at the expense of false alarms.
Receiver design is a complex subject: OK Simplistically, the smaller the radar pulse width, the larger the required receiver bandwidth and the larger the receiver noise floor.
Radar range equation - 18
2/2011
2/2011
3.4.2 Signal-to-noise
2/2011
2/2011
4. Radar cross-section,
The radar cross-section of a target is a measure of its size as seen by a radar, expressed as an area, m2. It is a complex function of the geometric crosssection of the target at the incident angle of the radar signal, as well as the directivity and reflectivity of the target. The RCS is a characteristic of the target, not the radar.
Radar range equation - 22
2/2011
Large RCS, but decreases rapidly as the incident angle deviates from the normal.
4a b
2 2
2/2011
2/2011
2ra 2
4 r
3 4 2
, as viewed
2/2011
The RCS of a trihedral (corner) is both large and relatively independent of incident angle.
2/2011
Exercises
Think carefully about the derivation of the radar range equation just presented. Is there a potentially significant loss component missing? Hint: recall the simple link equation from your very early lectures. (Atmospheric loss is not accounted for in this version of the radar range equation. It rather complicates this simple estimate)
2/2011
The US Navy AN/SPS-48 Air Search Radar is a medium-range, three-dimensional (height, range, and bearing) air search radar. Published technical specifications include:
Operating frequency 2900-3100 MHz Transmitter peak power 60-2200 kW PRF 161-1366 Hz, and pulse widths of 9 / 3 sec Phased array antenna with a gain of 38.5 dB
For its published maximum range of 250 miles for a nominal target such as the F-18, what is the receiver chain sensitivity in bBm?
Radar range equation - 28
2/2011