Professional Documents
Culture Documents
Rps 500
Rps 500
Rps 500
Features
Analog Ranging Card Ranges 2"-14", 5"-36", 5"-72", 10"-240"
0 -10 VDC Analog Voltage Zero, Span, Sample & Hold Controls
Output 4 - 20mA: Current sourcing, load 0 to 500 ohms. Reference to "GND OUT" terminal.
Output 0 - 10VDC: Load Equal to or Greater than 500 ohms. Reference to "GND OUT" terminal.
Up Date Time: 10mS 14" card, 20ms 36" card, 40mS 72" card, 150mS 240" card.
Output Isolation: 2500V for outputs 0-10 VDC, 4-20MA when powered by 120 VAC.
Using the RPS-500: The distance control on the front cover of the control box must be full cw for maximum analog ranges.
The supplied cable is used to connect the RPS-500 board to the RPS-100, 300, 325, or 326 Ultrasonic Sensor.
This cable has shielding between "XMIT" and "1st DET" which is needed to prevent cross talk. The following
wire connections should be made.
110 VAC
NEAR COM
COM
DISTANCE
110 VAC
DISPLAY
+ 24 VDC
FAR GND IN
RPS-500 4 - 20 mA
RPS-100, SAMPLE
0 - 10 v
Fig. A 300,325,326
& HOLD
GND OUT Fig. B
SPAN ENABLE
GND OUT
ZERO GND
INVERTING + 12
SWITCH XMIT
1ST DET.
Figure:
A - Wiring Diag. For RPS-100, 300, 325, 326
B - Wiring Diag. For RPS-500