Professional Documents
Culture Documents
Pioneer Deh-3750mp
Pioneer Deh-3750mp
CRT3399
DEH-3750MP/XU/GS
DEH-3750MP
DEH-3770MP/XU/CS DEH-3750MP/XU/CN
Model No.
CX-3158
/XU/GS
This service manual should be used together with the following manual(s):
Order No.
CRT3394
Mech.Module
S10.1AAC
Remarks
CD Mech. Module : Circuit Description, Mech. Description, Disassembly
4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
1. SPECIFICATIONS
A
DEH-3750MP/XU/GS
5 6 7 8
DEH-3750MP/XU/GS
1 2 3 4
The > mark found on some component parts indicatesthe importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screw adjacent to mark on the product are used for disassembly. For the applying amount of lobricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.)
2.1 PACKING
18
17
D
"
4 5
6 7 9 10
16
12
14 11
15
13
DEH-3750MP/XU/GS
2 3 4
(2) CONTRAST TABLE DEH-3750MP/XU/GS, DEH-3770MP/XU/CS and DEH-3750MP/XU/CN are constructed the same except for the following:
Mark No.
12 13 16-1 16-2 16-3 * 16-4
Description
Carton Contain Box Owner's Manual Installation Manual Caution Card Warranty Card
DEH-3750MP/XU/GS
YHG5020 YHL5020 YRD5021 YRD5024 CRP1310 Not used
DEH-3770MP/XU/CS
YHG5019 YHL5019 YRD5025 YRD5026 CRP1310 Not used
DEH-3750MP/XU/CN
YHG5023 YHL5023 YRB5011 YRB5013 Not used ARY7046
Language
English, Traditional Chinese, Arabic English, Traditional Chinese, Arabic English, Spanish, Portuguese(B) English, Spanish, Portuguese(B) Casual Chinese Casual Chinese
D
DEH-3750MP/XU/GS
5 6 7 8
2.2 EXTERIOR
60
A
61 13 75 74 31 44 31 31 65 66 10 65
62 57 64 63 56
C
59
B
52 55 31 45 42 36 35 43 41 39 33
C
58
65
46 50 76 48 47 40 38 32 34 2 3 2 68 17 68 23 25 30 17 67 27 28 69
B
51
49 37
53
71
16
9
A
8 19
2 2
D
22 20 21 18 70
12
26 29
5 14
E
15
A B
7 4 4
54
C
F
10
DEH-3750MP/XU/GS
1 2 3 4
Part No. BSZ26P060FTC BSZ30P060FTC BSZ30P200FTC YDE5008 CNB2793 CNC8659 CNC8915 CNM8890 See Contrast table(2)
Mark No. 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76
Description Button(DOWN, RIGHT) Button(UP, LEFT) Button(CLOCK, EQ) Spring Cover Connector(CN1801) Sheet Connector LCD(LCD1801) Holder Lighting Conductor Lighting Conductor Rubber Contact Grille Unit Chassis Unit Button(DETACH) Spring Spring Spring Bracket Holder Cover Arm Arm Arm Screw Panel IC(IC921) Transistor(Q911, 991) IC(IC302) FM/AM Tuner Unit(Z401) Sheet Remote Control Unit Cover Cushion IC(IC1802) Sheet
Part No. See Contrast table(2) See Contrast table(2) YAC5039 YBL5001 YNS5038 CKS4943 CNM7932 CNV7369 See Contrast table(2) YNC5005 YNV5004 YNV5005 YNV5006 See Contrast table(2) YXA5080 CAC4836 CBH1835 CBH2208 CBH2367 CNC6791 CNC8042 CNM6276 CNV4692 CNV4728 CNV5576 IMS20P030FZK YNS5046 NJM2388F84 2SD2396 PAL007A CWE1646 See Contrast table(2) CXC3173 CNS7068 YNM5004 TSOP4840SB1 See Contrast table(2)
A
Cord Assy Insulator Insulator Tuner Amp Unit Screw Screw Screw Fuse(10A) Pin Jack(CN352) Plug(CN901) Connector(CN721) Connector(CN831) Antenna Jack(CN401) Holder Heat Sink Holder Holder Screw Spring Knob(VOLUME) Button(DETACH) Button(SOURCE) Button(1-6, LOCAL/BSM) Button(AUDIO, LOUDNESS) Button(BAND) Button(EJECT, DISPLAY)
XDE7008 XNM7106 YNM5012 See Contrast table(2) ASZ26P060FTC BPZ26P080FTC BSZ26P160FTC CEK1208 CKB1057 CKM1376 CKS3837 CKS4944 CKX1056 CND1328 CNR1668 CND1054 YNC5004 BPZ20P100FZK CBH2210 See Contrast table(2) YAC5027 YAC5030 YAC5031 YAC5032 YAC5033 YAC5034
>
DEH-3750MP/XU/GS
5 6 7 8
11
(2) CONTRAST TABLE DEH-3750MP/XU/GS, DEH-3770MP/XU/CS and DEH-3750MP/XU/CN are constructed the same except for the following:
Mark
A
No.
10 12 16 33 40 41 48 53 71 76
Description
Panel
DEH-3750MP/XU/GS
YNS5045
DEH-3770MP/XU/CS
YNS5045 CXK5668 YWM5073 YAA5002 YAC5038 YAC5037 YAW5015 YXA5051 Not used Not used
DEH-3750MP/XU/CN
CNS8046 CXK5669 YWM5039 YAA5001 YAC5035 YAC5036 YAW5027 YXA5052 CNM9404 YNM5011
Tuner Amp Unit YWM5037 Knob(VOLUME) YAA5002 Button(DOWN, RIGHT) YAC5038 Button(UP, LEFT) LCD(LCD1801) Grille Unit Sheet Sheet YAC5037 YAW5027 YXA5082 Not used YNM5011
12
DEH-3750MP/XU/GS
1 2 3 4
13 5 13 34 5 93 13
A B
81 15
E
22
F
92 82 83 68
G
26
44 5
1
13
D
86 86
54 53 37
52
28 4
28 45
J
4 55 5
1 1
71 87 50 72 10
23 38
36 4 18 29 51
1 2
73
23
K
64 47
75 59
I
1
76
24
49
E M
1
61
2
F A Q H
77
90 48
63
2 1
27 8 67 17 78 46 60 80 6
N
21
M
G N R
1 1
57
D
16
79
12
3
58
2
33
P
2
62
1
20
1
40
60 11 89 10
1 1
39 69 30 14 25
L
43
K
19
70
74
R
41 31 85
91
C
1 3 2
14 65 85 66 85
O
35 31
14
DEH-3750MP/XU/GS
1 2 3 4
DEH-3750MP/XU/GS
5 6 7 8
15
7 6
CE2
13
ROM_VDD
5
SL
10 9 8
DI CK CE1
11
NC
14
DO
18 19 20 21
NC NC NC NC
WC
5V
OSC
LPF
ANTENNA
CN401
1 2
IC 2 2.5V Lch DET, FM MPX AM ANT 1 ATT Rch FMRF
T51
CF52 CF51
AUDIOGND
OSCGND
VDD_3.3
RFGND
DGND
3.3V
VCC
NC
12
15
22
16
17
C CD CORE UNIT(S10.1)
PICKUP UNIT (P10)(SERVICE)
V3R3D LASER DIODE
CN101
LDMD 15 5 15 5 AC,BD E,F FOP 1 TOP 4 LD+ 14 1 4 14 FOP TOP FD,TD 12 FOP 13 TOP M1 SPINDLE MOTOR SD,MD 142 Q101 143 LD PD
IC 201 UPD63763GJ CN901 RF AMP, CD DECODER, LOUT MP3 AND WMA DECODER, DIGITAL SERVO/DATA PROCESSOR
31 LOUT 10 14
X701
12
13 X2
CD DRIVER
16 SOP 15 SOM 18 LCOP 17 LCOM LOEJ CONT 22 53 9 47
X1
MICRO COMPUTER
LOEJ CONT reset
14
M2 LOADING/CARRIAGE MOTOR
IC 301 BA5835FP
32 31
IC 701 PE5454A
BRST,BRXEN,BSRQ BDATA,BSCK
VD VD 3 4 21 20
30 97
S904 12EJ
3V REGULATOR
3
IC 703
V3R3D
VD2
S-812C33AUA-C2N
VDD
16
DEH-3750MP/XU/GS
1 2 3 4
IC 3 EEPROM 5.0V
IC 5 3.3V
24
23
E
TUN L 2
CDL
CN721
CD L
SYSTEM
IC P
RESET
15
RESET
RST
VD1
VDCONT
19
VDCONT
VDD
19
VDD
Q993
VD2 2 22
VD2
Q994
CD3VON 1 23
CD3VCONT
CN352
RESET
A RST
REAR OUTPUT
R Lch
VDD
IC 961 S-80834CNY
Q352
60 RESET
11 12
TUNPDI TUNPDO
VDD REGULATOR
Q911 VDD Q912
SYSTEM CONTROLLER
IC 601(1/2) PE5460A
DALMON 32
BACKUP SENSE
BSENS ASENS 64 63 BSENS Q931 ASENS
B.UP
CN901
1
FUSE 10A
1 3
BACK UP
ACC
ACC
ACC SENSE
2 B.UP 2
GND
TUN L
CDL
IC 151 PML003AM
IN2-L R Lch
11
12
IC 302 PAL007A
FLFL+ RLRL+
B. REM
RLIN
22
MUTE
STBY 4
B. REM
25
SYS8V
MUTE
Q453 TU 3.3V
TUN 3V REG.
SYS 8V REG.
IC 981 BA33BC0FP
IC 921 NJM2388F84
B.UP
MUTE
Q452 MUTE 48 SYSPW
SYSPW
43
SYSPW
SYSTEM CONTROLLER
IC 601(2/2) PE5460A
X1 X2
70 69 X601 12.58291MHz
B
CN831
Q801 VDD 21 66 SWVDD SOURCE SRC 3 SWVDD 3 SWVDD
KEYBOARD UNIT
B.UP
CN1801
SWVDD SOURCE
E
4 4 SOURCE
DSENS
65
DSENS
10 Q821
DSENS
10
ILM
REM.CON.
3
IC1802 TSOP4840SB1
KEY MATRIX
ROT1 ROT0
36 35
SWVDD S1827
DPDT KYDT
9 8
8 9
DPDT KYDT
8 9
17 19 10 57
F
LCD1801
DEH-3750MP/XU/GS
5 6 7 8
17
Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST". C CN901
A-a A-b
A-a
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23
A-a
A-b
Guide page
A-a
A-b
Detailed page
471/16
STRKEY1 DISCSENS
AVREF1
AVDD
VSS
dsens
bsens
GS,CN
D
FM/AM TUNER UNIT
ADPW
SYSTEM CONTROLLER
isens STRKEY2
BDATA RECEIVE
swvdd
brxen
brst
source
asens bsrq
ANTENNA
NOTE : Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors. For resistors and capacitors in the circuit diagrams, their resistance values or capacitance values are expressed in codes: Ex. *Resistors Code Practical value 123 12k ohms 103 10k ohms
B
CN1801
*Capacitors Code Practical value 103 0.01uF 101/10 100uF/10V The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation.
A
18
1
DEH-3750MP/XU/GS
2 3 4
A-b
>
CEK1286 3A
REAR L CH REAR R CH
332/16
dsens
bsens
source
asens
CEK1208
TROLLER
isens STRKEY2
>
10A
RECEIVE
bsrq
A
DEH-3750MP/XU/GS
5 6 7 8
19
471/16
AVDD
dsens
bsens
AVREF1
STRKEY1 DISCSENS
source
asens
GS,CN
VSS
20
A-a A-b
A-b
A-a
C
CN901
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23
DEH-3750MP/XU/GS
3 4
AVDD
dsens
bsens
AVREF1
STRKEY1 DISCSENS
source
asens
GS,CN
VSS
swvdd
brst
brxen
RECEIVE
5
ADPW
SYSTEM CONTROLLER
isens STRKEY2
BDATA
bsrq
DEH-3750MP/XU/GS
ANTENNA
7
NOTE : Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors.
Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors.
For resistors and capacitors in the circuit diagrams, their resistance values or capacitance values are expressed in codes:
B
CN1801
2
Ex. *Resistors Code Practical value 123 12k ohms 103 10k ohms
8 E
A-b
A-a
The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation.
A-a A-b
21
CEK1286 3A
332/16
22
A-a A-b
A-b
A
TUNER AMP UNIT
1
>
REAR L CH REAR R CH
2
FM: 29.6dB AM: 19.1dB CD: 36.45dB
DEH-3750MP/XU/GS
3 4
CEK1208
>
10A
A-a A-b
A-b
8
DEH-3750MP/XU/GS
5 6 7
23
DIS
GS,CN : YAW5027
CS : YAW5015
B
24 DEH-3750MP/XU/GS
1 2 3 4
KEYBOARD UNIT
B
A
40mA,14V
CN831
DISPLAY
F
D1803,D1804 GS,CN : CL-490SWFSD(12) CS : CL-490S-WF-SD
B
7 8
DEH-3750MP/XU/GS
5 6
25
C-a
C S T F
PICKUP UNIT(P10)(SERVICE)
%
F F F T T
T F T T F F T
# @
3
$
2
T
1
F
9
C
7 8
E
M1 CXC4440 SPINDLE MOTOR
S S
TY
F F T T
C C
CD DRIVER
C
26 DEH-3750MP/XU/GS
1 2 3 4
C-b
Decimal points for resistor and capacitor fixed values are expressed as : 2.2 2R2 0.022 R022
SWITCHES: CD CORE UNIT(S10.1) S901:HOME SWITCH..........ON-OFF S903:DSCSNS SWITCH......ON-OFF S904:12EJ SWITCH.............ON-OFF S905:8EJ SWITCH...............ON-OFF The underlined indicates the switch position.
ras
SIGNAL LINE
F T C
!
FOCUS SERVO LINE TRACKING SERVO LINE CARRIAGE SERVO LINE SPINDLE SERVO LINE
CD CORE UNIT(S10.1)
3.3V REGULATOR
SRAMLEVEL2
MICRO COMPUTER
SRAMLEVEL1 SRAMLEVEL0
3V REGULATOR
A
CN721
E
TYPE_A/D
&
C
DEH-3750MP/XU/GS
5 6 7 8
27
28
C-b
C-a
C-a C-b A-a
2
F F F T T T F T T F F T
DEH-3750MP/XU/GS
# @
2
5
3
$
T S
6
9
C F
2
7 8 0 5
1
4
S F F T T
DEH-3750MP/XU/GS
CD DRIVER
C-a C-b A-a
7 E D
6
8
C-b
C-a
29
30
C-a C-b
C-b
Decimal points for resistor and capacitor fixed values are expressed as : 2.2 2R2 0.022 R022
1
SWITCHES: CD CORE UNIT(S10.1) S901:HOME SWITCH..........ON-OFF S903:DSCSNS SWITCH......ON-OFF S904:12EJ SWITCH.............ON-OFF S905:8EJ SWITCH...............ON-OFF The underlined indicates the switch position.
1
2
SIGNAL LINE
F
ras
2
FOCUS SERVO LINE TRACKING SERVO LINE CARRIAGE SERVO LINE SPINDLE SERVO LINE
T C
!
DEH-3750MP/XU/GS
C CD CORE UNIT(S10.1)
3
3.3V REGULATOR
2
5
SRAMLEVEL2
5
SRAMLEVEL1 SRAMLEVEL0
3
3V REGULATOR
^ &
C-a C-b
MICRO COMPUTER
6
A
CN721
TYPE_A/D
4
7 8 E A D C B
DEH-3750MP/XU/GS
C-b
31
- Waveforms
A
Note : 1. The encircled numbers denote measuring points in the circuit diagram. 2. Reference voltage REFO1(1.65V) 500ms/div 1 DSCSNS 5 CLCONT 4 LOEJ 6 VD 5V/div 5V/div 5V/div 10V/div 500ms/div 1 DSCSNS 2 8SNS 3 12SNS 4 LOEJ 5V/div 5V/div 5V/div 5V/div 500ms/div
12 cm CD Loading operation
12 cm CD Loading operation
8 cm CD Loading operation
# FE 0 FIN @ TE 9 TIN
$ MDX 7 SIN
$ MDX 7 SIN
2V/div 1V/div
5s/div
32
DEH-3750MP/XU/GS
1 2 3 4
0 FIN # FE
% RFAGC @ TE 9 TIN
% RFAGC @ TE 9 TIN
% RFAGC @ TE 9 TIN
Ref.: REFO
C
Mode: TEST
1V/div 1V/div
500ms/div
12 cm CD Eject operation
D
Ref.: REFO Mode: Normal Ref.: AGND Mode: Normal Ref.: GND Mode: Normal
8 cm CD Eject operation
DEH-3750MP/XU/GS
5 6 7 8
33
500s/div
34
DEH-3750MP/XU/GS
1 2 3 4
CORD ASSY
1 2 1 2 3 4 5 6 7 9 11 13 15 8 10 12 14 16
Connector
Capacitor
SIDE A
3
B
P.C.Board Chip Part
SIDE B
C
F
CN901
A
36 DEH-3750MP/XU/GS
1 2 3 4
SIDE A
11 13 15 0 12 14 16
1 2
3 4
ANTENNA
B
RCA
B
FRONT
CN1801
F
A
DEH-3750MP/XU/GS
5 6 7 8
37
TEST
PCL
A
38 DEH-3750MP/XU/GS
1 2 3 4
SIDE B
EST
PCL
A
DEH-3750MP/XU/GS
5 6 7 8
39
40
B
B
KEYBOARD UNIT
EJECT AUDIO UP DISPLAY
LCD1801
CLOCK
VOLUME LEFT
RIGHT
EQ
BAND
DOWN LOUDNESS
SIDE A
KEYBOARD UNIT
SIDE B
A
CN831
B
DEH-3750MP/XU/GS
5 6 7 8
41
C
A
CD CORE UNIT(S10.1)
SIDE A
A
CN721
PICKUP UNIT(P10)(SERVICE)
HOME
FE REFO1
C
42 DEH-3750MP/XU/GS
1 2 3 4
CD CORE UNIT(S10.1)
SIDE B
A
8EJ
12EJ
DSCSNS
B
C
DEH-3750MP/XU/GS
5 6 7 8
43
NOTE: Parts whose parts numbers are omitted are subject to being not supplied. The part numbers shown below indicate chip components. Chip Resistor RS1/_S___J,RS1/__S___J Chip Capacitor (except for CQS.....) CKS....., CCS....., CSZS..... The > mark found on some component parts indicatesthe importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation.
Circuit Symbol and No. Part No.
D D D D D L L L L L
Part No.
HZS7L(C3) HZS7L(A1) S5688G S5688G HZS7L(C3) LAU2R2K LAU1R0K LAU1R0K LAU4R7K LAU1R0K
A Number:YWM5037(GS) Unit
Unit Number:YWM5073(CS) Unit Number:YWM5039(CN) Unit Name:Tuner Amp Unit
MISCELLANEOUS
C
IC 151 IC 302 IC 601 IC 921 IC 961 IC 981 Q 352 Q 452 Q 453 Q 801
D
(B,132,80) IC (A,93,132) IC (B,85,52) IC (A,6,119) IC (A,46,62) IC (B,146,27) IC (B,159,125) Transistor (B,140,115) Transistor (B,135,107) Transistor (B,28,25) Transistor (B,20,29) (B,17,33) (A,6,100) (B,17,64) (B,70,86) Transistor Transistor Transistor Transistor Transistor
PML003AM PAL007A PE5460A NJM2388F84 S-80834CNY BA33BC0FP IMH3A DTC124EU DTA124EU 2SA1036K 2SA1036K DTC114EU 2SD2396 IMD2A IMX1 2SD2396 IMD2A 2SA1036K DTC114EU 1SS133 1SS133 1SS133 1SS133 1SS133 1SS133 1SS133 1SS133 1SS133 1SS133 1SS133 1SS133 S5688G S5688G S5688G HZS6L(B2)
LAU1R0K LAU2R2K (A,35,103) Choke Coil 600H CTH1280 (A,101,61) Radiator 12.58291MHz CSS1402 (B,140,136) Fuse 3A CEK1286
(A,163,100) FM/AM Tuner Unit CWE1646 (A,159,119) Surge Protector DSP-201M-S00B
Fuse 10A
CEK1208
RESISTORS
R R R R R R R R R R R R R R R R R R R R R R R R R 153 154 155 156 157 301 353 354 357 358 405 407 408 409 410 414 420 421 454 455 456 457 601 602 603 (B,127,104) (B,147,93) (B,127,102) (B,136,94) (B,84,79) (A,100,96) (B,141,122) (B,163,125) (B,145,130) (B,160,134) (B,158,62) (B,159,83) (B,159,85) (B,159,86) (B,159,88) (B,156,88) (B,105,44) (B,159,79) (B,133,114) (B,141,132) (B,139,132) (A,120,54) (B,102,49) (GS,CN) (B,102,51) (B,63,75) (B,60,75)
3
Q Q Q Q Q Q Q Q Q D D D D D D D D D D D D D D D D
821 822 911 912 931 991 992 993 994 831 832 833 834 835 836 837 838 839 840 841 842 901 902 911 912
RS1/16S471J RS1/16S471J RS1/16S471J RS1/16S471J RAB4C102J RD1/4PU153J RS1/16S471J RS1/16S471J RS1/16S223J RS1/16S223J RS1/16S681J RS1/16S681J RS1/16S681J RS1/16S681J RS1/16S681J RS1/16S0R0J RS1/16S681J RS1/16S473J RS1/16S103J RS1/16S153J RS1/16S221J RD1/4PU681J RS1/16S473J RS1/16S473J RS1/16S103J RS1/16S103J
4
(A,6,66) Transistor (B,25,50) Transistor (B,32,41) Transistor (B,39,41) Transistor (A,139,18) Diode (A,122,23) (A,114,24) (A,111,19) (A,113,10) (A,126,25) (A,134,21) (A,119,18) (A,117,18) (A,118,15) (A,116,15) Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode
(A,130,25) Diode (A,69,113) Diode (A,72,110) Diode (A,30,78) Diode (A,18,60) Diode
R 604
44
DEH-3750MP/XU/GS
1 2
Part No.
RS1/16S222J RS1/16S104J RS1/16S0R0J RD1/4PU473J RD1/4PU681J RS1/16S473J RS1/16S104J RS1/16S473J RS1/16S104J RS1/16S0R0J RS1/16S104J RS1/16S473J RS1/16S682J RS1/16S682J RS1/16S473J RS1/16S682J RD1/4PU682J RS1/16S102J RS1/16S0R0J RS1/16S0R0J RS1/16S221J RS1/16S221J RS1/16S221J RD1/4PU221J RS1/16S221J RS1/16S0R0J RS1/16S0R0J RS1/16S153J RS1/16S153J RS1/16S222J RS1/16S222J RS1/16S103J RS1/16S222J RS1/16S222J RS1/16S104J RD1/4PU103J RD1/4PU102J RS1/16S1R0J RD1/4PU102J RD1/4PU102J RS1/16S102J RS1/16S102J RS1/16S222J RS1/16S222J RS1/16S222J RD1/4PU102J RS1/16S223J RD1/4PU152J RS1/16S473J RS1/16S473J RS1/16S104J RD1/4PU102J RS1/16S473J RS1/16S473J RS1/16S473J RS1/16S104J RS1/16S104J RS1/16S473J RS1/16S102J RS1/16S822J R R R R
Part No.
RD1/4PU1R8J RD1/4PU271J RD1/4PU121J RS1/16S103J RS1/16S222J
R 996
CAPACITORS
C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C 151 152 153 154 155 156 157 158 161 162 163 164 165 166 167 301 302 303 304 309 310 312 313 353 354 401 402 403 404 405 420 451 601 604 605 610 611 725 726 801 901 911 912 913 921 922 923 924 961 963 (B,159,71) (B,159,73) (B,122,74) (B,145,82) (A,121,78) (A,143,88) (B,123,85) (B,143,95) (B,125,99) (B,139,94) (B,131,95) (B,139,96) (B,140,70) (A,135,66) (A,124,66) (A,135,111) (A,145,119) (A,130,111) (A,143,125) (B,135,136) (B,122,143) (A,100,118) (B,40,122) (A,132,102) (A,140,102) (B,164,67) (B,153,56) (A,150,53) (A,153,87) (B,166,94) (B,112,68) (A,134,131) (B,54,64) (B,97,64) (B,101,64) (A,94,71) (B,97,68) (B,120,74) (B,148,84) (B,11,36) (A,46,121) 3300F/16V (A,16,76) (B,12,64) (A,25,86) 470F/16V (A,14,115) (A,18,107) (B,18,110) (B,17,101) (B,50,66) (A,46,69) (B,145,40) (A,147,35) CKSRYB224K16 CKSRYB224K16 CKSRYB105K10 CKSRYB105K10 CEJQ4R7M35 CEJQ4R7M35 CKSRYB153K50 CKSRYB153K50 CCSRCH100D50 CCSRCH100D50 CCSRCH100D50 CCSRCH100D50 CKSRYB104K16 CEJQ470M10 CEJQ100M16 CFTNA224J50 CFTNA224J50 CFTNA224J50 CFTNA224J50 CKSQYB225K10 CKSQYB225K10 CEJQ100M16 CKSRYB104K16 CEJQ2R2M50 CEJQ2R2M50 CKSRYB103K50 CKSRYB103K50 CEJQ470M6R3 CEJQ101M10 CKSRYB104K25 CCSRCH470J50 CEJQ330M10 CKSRYB104K25 CCSRCH200J50 CCSRCH200J50 CEJQ100M16 CKSRYB224K16 CKSRYB102K50 CKSRYB102K50 CKSRYB104K16 CCH1494 CEJQ470M10 CKSRYB103K50 CCH1331 CEJQ101M16 CEJQ221M10 CKSRYB103K50 CKSRYB103K50 CKSRYB473K50 CEJQ100M16 CKSRYB103K50 CEJQ220M16
B
C 982 C 983
R 962
DEH-3750MP/XU/GS
6 7 8
45
Part No.
CKSRYB473K50 CEJQ101M16 CCH1331 R R R R
Part No.
RS1/16S472J RS1/16S472J RS1/16S2R2J RS1/16S121J
B Number: Unit
Unit Name:Keyboard Unit
MISCELLANEOUS
IC 1801 IC 1802 D 1801 D 1802 D 1803 (B,29,96) (A,15,27) (B,19,40) (B,24,40) (A,25,38) IC IC Diode Diode (GS,CN) LED PD6340A TSOP4840SB1 MA152WK MA152WA CL-490SWFSD(12) CL-490S-WF-SD CL-490SWFSD(12) CL-490S-WF-SD SML-310PT SML-310PT SML-310PT SML-310PT SML-310PT SML-310PT SML-310PT SML-310PT SML-310PT SML-310PT SML-310PT SML-310PT
CAPACITORS
C C C C C 1801 1802 1811 1812 1813 (B,18,20) (B,27,52) (A,25,32) (A,20,129) (A,39,33) (A,39,133) CKSRYB474K10 CKSRYF104Z25 CKSRYF104Z25 CKSRYF104Z25 CKSRYF104Z25 CKSRYF104Z25
C 1814
(A,25,38) (CS) LED (A,25,128) (GS,CN) LED (A,25,128) (CS) LED (A,13,22) LED (A,26,9) LED (A,30,27) LED (A,39,50) LED (A,5,10) LED (A,34,9) LED (A,39,84) LED (A,39,73) LED (A,39,61) LED (A,39,96) LED (A,39,107) LED (A,39,119) LED (A,39,35) LED (A,39,131) LED
C Number:CWX3096 Unit
Unit Name:CD Core Unit(S10.1)
MISCELLANEOUS
IC 201 IC 203 IC 301 IC 701 IC 703 Q Q L L L L X X S S 101 701 203 207 209 703 201 701 901 903 (A,39,24) (B,45,78) (A,49,88) (A,48,51) (A,30,44) (A,20,22) (B,62,59) (A,53,32) (A,53,31) (A,26,20) IC IC IC IC IC Transistor Transistor Inductor Inductor Inductor UPD63763GJ NJM2885DL1-33 BA5835FP PE5454A S-812C33AUA-C2N 2SA1577 UN2111 CTF1389 CTF1389 CTF1389 CTF1389
1807 1808 1809 1810 1811 1812 1813 1814 1815 1816 1817 1818 1801 1827 1801
D D D D D D D X S IL
D
(A,64,49) Inductor
CL-190UB2-X CL-190UB2-X (B,37,83) Ceramic Resonator 5.00MHz CSS1547 (A,23,19) Encoder(VOLUME) YSD5002 (B,23,147) Lamp 40mA,14V CEL1651 YAW5027 YAW5015
(A,51,35) Ceramic Resonator 16.934MHz CSS1603 (A,59,53) Ceramic Resonator 4.00MHz CSS1652
(A,15,43) Switch(HOME) CSN1067 (B,53,100) Switch(DSCSNS) CSN1068 (B,35,108) Switch(12EJ) (B,48,109) Switch(8EJ) CSN1067 CSN1067
LCD1801
S 904 S 905
RESISTORS
R R R R R R R R R R R R R R R R R R R R 1801 1802 1803 1804 1805 1806 1807 1808 1809 1810 1811 1812 1813 1814 1815 1816 1817 1818 1819 1820 (B,23,43) (B,20,43) (B,22,33) (B,22,31) (B,19,34) (B,29,142) (B,26,142) (B,13,31) (B,24,33) (B,25,30) (B,21,35) (B,29,140) (B,26,140) (B,15,31) (B,25,33) (B,25,29) (B,22,35) (B,29,137) (B,26,137) (B,17,31) (B,27,25)
1
RESISTORS
RS1/16S222J RS1/16S222J RS1/16S151J RS1/16S181J RS1/16S181J RS1/16S181J RS1/16S181J RS1/16S181J RS1/16S151J RS1/16S181J RS1/16S181J RS1/16S181J RS1/16S181J RS1/16S181J RS1/16S151J RS1/16S151J RS1/16S151J RS1/16S151J RS1/16S151J RS1/16S0R0J RS1/16S151J R R R R R R R R R R R R R R R R R R R R 101 102 103 201 202 221 222 225 226 227 228 229 232 241 243 245 301 302 304 305 (A,22,24) (A,22,26) (A,25,25) (A,53,16) (A,55,21) (B,31,18) (B,26,18) (A,27,8) (A,27,7) (B,33,10) (B,36,8) (B,34,8) (B,35,10) (B,42,28) (B,44,28) (A,39,38) (A,48,78) (A,42,78) (A,50,78) (A,42,77) (A,36,85) RS1/10SR2R4J RS1/10SR2R4J RS1/10SR2R7J RS1/16SS102J RS1/16SS333J RS1/16SS103J RS1/16SS103J RS1/16SS103J RS1/16SS393J RS1/16SS562J RS1/16SS122J RS1/16SS472J RS1/16SS122J RS1/16SS333J RS1/16SS333J RS1/16SS333J RS1/16SS183J RS1/16SS822J RS1/16SS183J RS1/16SS822J RS1/16SS183J
R 307 R 1821
46
DEH-3750MP/XU/GS
2 3 4
Part No.
RS1/16SS183J RS1/16SS183J RS1/16SS183J RS1/16S101J RS1/16S101J RS1/16S0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS221J RS1/16SS221J RS1/16SS473J RS1/16SS221J RS1/16SS102J RS1/16SS221J RS1/16SS473J RS1/16SS472J RS1/16SS221J RS1/16SS471J RS1/16S473J RS1/16SS222J RS1/16SS103J RS1/16SS473J RS1/16SS223J RS1/16SS473J RS1/16SS104J RS1/16SS104J RS1/16SS473J RS1/16SS104J RS1/16SS104J RS1/16SS473J RS1/16SS102J RS1/16SS102J RAB4CQ221J RAB4CQ221J RAB4CQ221J RS1/16SS221J RS1/16SS221J RS1/16SS221J RAB4CQ221J RS1/16SS221J RS1/16SS221J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS102J C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C C
Part No.
CKSSYB473K10 CKSSYB104K10 CKSSYB182K50 CKSSYB104K10 CCSSCH560J50 CCSSCH4R0C50 CKSSYB104K10 CKSSYB103K16 CCSSCH680J50 CCSSCH470J50 CKSSYB103K16 CEVW221M4 CKSSYB104K10 CCSSCH220J50 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSRYB102K50 CKSSYB104K10 CKSSYB221K50 CKSSYB221K50 CKSSYB472K25 CKSSYB103K16 CEVW101M16 CKSSYB104K10 CCSRCH102J50 CCSRCH102J50 CKSSYB104K10 CKSSYB103K16 CKSSYB104K10 CKSSYB104K10 CKSRYB224K16 CKSSYB104K10 CKSSYB103K16 CKSQYB475K6R3 CKSRYB105K10 CKSSYB471K50 CKSRYB224K16 CKSSYB103K16 CKSQYB225K10
CAPACITORS
C C C C C C C C C C C C C C 103 105 108 110 201 202 203 204 205 208 209 212 216 217 (B,14,8) 100F/16V (A,19,15) (B,39,16) (A,18,6) (A,51,14) (B,50,17) (A,55,23) (B,28,22) (A,53,25) (B,44,25) (A,54,29) (A,45,37) (A,25,8) (A,28,12) CCH1504 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB102K50 CKSSYB104K10 CKSSYB104K10 CEVW220M6R3 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSRYB105K10 CKSSYB332K50 CKSSYB104K10
DEH-3750MP/XU/GS
5 6 7 8
47
6. ADJUSTMENT
6.1 CD ADJUSTMENT
A
1) Cautions on adjustments In this product the single voltage (3.3V) is used for the regulator. The reference voltage is the REFO1 (1.65V) instead of the GND. If you should mistakenly short the REFO1 with the GND during adjustment, accurate voltage will not be obtained, and the servos misoperation will apply excessive shock to the pickup. To avoid such problems: a. Do not mix up the REFO1 with the GND when connecting the (-) probe of measuring instruments. Especially on an oscilloscope, avoid connecting the (-) probe for CH1 to the GND. b. In many cases, measuring instruments have the same potential as that for the (-) probe. Be sure to set the measuring instruments to the floating state. c. If you have mistakenly connected the REFO1 to the GND, turn off the regulator or the power immediately. Before mounting and removing filters or leads for adjustment, be sure to turn off the regulator. For stable circuit operation, keep the mechanism operating for about one minute or more after the regulator is turned on. In the test mode, any software protections will not work. Avoid applying any mechanical or electrical shock to the mechanism during adjustment. The RFI and RFO signals with a wide frequency range are easy to oscillate. When observing the signals, insert a resistor of 1k ohms in series.
2) Test mode This mode is used to adjust the CD mechanism module. To enter the test mode. While pressing the 4 and 6 keys at the same time, reset. To exit from the test mode. Turn off the ACC and back up. Notes: a. During ejection, do not press any other keys than the EJECT key until the loaded disc is ejected. b. If you have pressed the () key or () key during focus search, turn off the power immediately to protect the actuator from damage caused by the lens stuck. c. For the TR jump modes except 100TR, the track jump operation will continue even if the key is released. d. For the CRG move and 100TR jump modes, the tracking loop will be closed at the same time when the key is released. e. When the power is turned off and on, the jump mode is reset to the single TR (91), the RF amp gain is set to 0dB, and the auto-adjustment values are reset to the default settings.
The load and eject operation is not guarantied with the mechanism upside down. If the mechanism is blocked due to mistaken eject operation, reset the product or turn off and on the ACC to restore it.
48
DEH-3750MP/XU/GS
1 2 3 4
- Flow Chart
[KEY] Contents Display [4]+[6]+Reset or [4]+[6]+BU+ACC Test Mode In
[CD]or[SOURCE] Source On
TRK MIN SEC
[BAND] Power On
(T.Offset is adjusted)
TRK 00 MIN00 SEC 00
[3] Power On
(T.Offset is not adjusted)
TRK 99 MIN 99 SEC 99
B
[BAND] Power Off
TRK MIN SEC
91 MIN91 SEC 91
[] CRG+
TRK
[] *8
TRK
[2] *8
Automatic adjustment switching *3
TRK
CRGor
TRK
or
TRK
or
TRK
?? MIN?? SEC ??
[1]
T.Close and AGC
Applicable servomechanism
TRK MIN SEC TRK
[6]
T.Close
Applicable servomechanism
MIN SEC
[3] RF AGC /
RF AGC coefficient display
TRK ?? MIN ?? SEC ??
[] CRG+
TRK8x MIN8x SEC8x
[2]
T.Balance adjustment /
T.BAL coefficient display
TRK ?? MIN?? SEC ??
?tr
?min ?sec
?tr
?min ?sec
or
or
C
[BAND] Power Off
TRK MIN SEC
[6]
CRG/TR Jump *5 value switching
TRK
[] *4 CRG/TR Jump +
TRK
?? MIN?? SEC ??
?tr
MIN
?min ?sec
SEC
?tr
MIN
?min ?sec
SEC
?tr
MIN
?min ?sec
SEC
?tr
MIN
?min ?sec *6
SEC
or
TRK
or
*1)
TRK
TYP
MIN SEC
-6dB
TRK 06 MIN 06 SEC 06
-12dB
TRK 12 MIN 12 SEC 12
[Key]
F EQ measurement setting
TRK 02 MIN 02 SEC 02
[BAND] Power On / Off [] CRG + / TR Jump + (Direction of the external surface) CRG - / TR Jump (Direction of the internal surface) U.CLS and AGC and Applicable servomechanism / AGC, AGC display setting RF Gain switching / Offset adjustment display / T.Balance adjustment / T.Open Close, S.Curve / Rough Servo and RF AGC / F, T, RF AGC SPDL 1X / 2X switching As for the double speed (2x), audio output cannot be supported. Error Rate measurement 1st - ON : ERR count Beginning (30Sec) 2nd - ON : BER display data [%]
*3) F.Offset Display T.Offset Display Switch to the order of the original display [] *4) 1TR / 32TR / 100TR [1] [2] *5) Single TR 32TR 100TR CRG Move 9x(8x) : 91(81) 92(82) 93(83) 94(84) *6) Only at the time of CRG move, 100TR jump [5] *7) TRK/MIN/SEC F.AGC T.AGC F Bias RF AGC [6] [3] [4]
1X
TRK 11 MIN 11 SEC 11
Applicability : G TYP(2X)
TRK MIN SEC
1X
2X
TRK 22 MIN 22 SEC 22
DEH-3750MP/XU/GS
5 6 7 8
49
Note : The grating angle of the PU unit cannot be adjusted after the PU unit is changed. The PU unit in the CD mechanism module is adjusted on the production line to match the CD mechanism module and is thus the best adjusted PU unit for the CD mechanism module. Changing the PU unit is thus best considered as a last resort. However, if the PU unit must be changed, the grating should be checked using the procedure below. Purpose : To check that the grating is within an acceptable range when the PU unit is changed.
B
Symptoms of Mal-adjustment : If the grating is off by a large amount symptoms such as being unable to close tracking, being unable to perform track search operations, or taking a long time for track searching. Method : Measuring Equipment Measuring Points Disc Mode
CD CORE UNIT(S10.1)
C
L.P.F. E VREF Xch 100k 390pF Ych
Oscilloscope
F VREF
D
F E REFO1
Checking Procedure 1. In test mode, load the disc and switch the 3V regulator on. 2. Using the and buttons, move the PU unit to the innermost track. 3. Press key 3 to close focus, the display should read "91". Press key 2 to implement the tracking balance adjustment the display should now read "81". Press key 3. The display will change, returning to "81" on the fourth press. 4. As shown in the diagram above, monitor the LPF outputs using the oscilloscope and check that the phase difference is within 75 . Refer to the photographs supplied to determine the phase angle. 5. If the phase difference is determined to be greater than 75 try changing the PU unit to see if there is any improvement. If, after trying this a number of times, the grating angle does not become less than 75 then the mechanism should be judged to be at fault. Note Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the average angle. Hint Reloading the disc changes the clamp position and may decrease the "wobble".
50
DEH-3750MP/XU/GS
1 2 3 4
Grating waveform
30
45
60
75
90
DEH-3750MP/XU/GS
5 6 7 8
51
Error is displayed with number for Error cause when CD is inoperative or stops with Error during operation. The purpose is to reduce nonsense calls from users as well as to assist all related analysis and repair for defects at service station. (1) Basic Display Method 1) When CSMOD (CD mode area for system) is SERRORM, Error code will be written in DMIN (minutes area for display), DSEC (seconds area for display). The same data shall be written in DMIN and DSEC. DTNO is blank as usual. 2) Display Example of Head Unit The following is about LCD display ability. xx is Error number.
8 digits ERRORxx
4 digits Exx
(2) Error Code List No. Classification Contents 10 Electricity Carriage Home NG
C
11 12
Electricity Electricity
Details Cause CRG cant move to the inner. CRG cant move from the inner. HOME SW failure, CRG movement failure. Focus cant be caught. Back of Disc / Severe dirt and vibration. Not spindle, lock. Wrong subcode (cant read). Defective Spindle. Scratch and dirt on Disc. Intense vibration. The appropriate gain of the RF amp cannot be obtained. Defective spindle. Scratched or dirty disc. Severe vibration. Abnormal CD signals. Blanc CD-R disc. Disc inserted upside down. AGC protection doesnt work, out of Focus soon. Scratch on Disc/Severe dirt and vibration. There is no playable MP3 or WMA file present in a disc. No MP3 or WMA file exists in a CD-ROM disc inserted. Contents are stored in an incompatible file format. The contents in a CD-ROM disc inserted are recorded in a file format other than ISO9660 Level-1 and 2. Cant reach the target address. Defective CRG/tracking, or scratch on Disc. There is no playable TRK No. present in a disc. All TRK Nos. In a disc inserted are specified as a track which should be skipped, in the track skip information. Disc loading/ejection cannot be complete. Foreign objects entered into the mechanism. Disc caught in between during loading/ejection.
17 22 23
30 44
Electricity Disc
50
Mecha
Power supply (VD) isnt connected to the ground. Defective SW transistor. Abnormal power (failed connector) Note : Error doesnt display in mechanism only. (CD off causes mechanism off) If TOC cant be read, error wouldnt occur, but mechanism still continues its operation. The upper digits of error code is mainly classified by 3 kinds as follows: 1x: Setup related error, 3x: Search related error, Ax: Other errors.
A0
System
Power NG
52
DEH-3750MP/XU/GS
1 2 3 4
- PCL Output
In the normal operation mode (with the detachable panel installed, the ACC switched ON, the standby mode cancelled), shift the TESTIN (Pin 15) terminal to H. The clock signal is output from the PCL terminal (Pin 14). The frequency of the clock signal is 786.432kHz that is one 16th of the fundamental frequency. The clock signal should be 786.432kHz 31.5Hz. If the clock signal is out of the range, the X'tal (X601) should be replaced with new one.
DEH-3750MP/XU/GS
5 6 7 8
53
7. GENERAL INFORMATION
7.1 DIAGNOSIS
A
7.1.1 DISASSEMBLY
- Removing the Case (not shown) 1. Remove the Case.
CD Mechanism Module
1
B
1 1
Release the two latchs and then remove the Grille Assy.
1
C
Grille Assy
- Removing the Tuner Amp Unit (Fig.2)
Fig.1
1
D
3 3
2 3
Straighten the tabs at three locations indicated. Remove the three screws and then remove the Tuner Amp Unit.
1
E
Fig.2
54
DEH-3750MP/XU/GS
1 2 3 4
Do not squeeze.
A C
Upper Frame
A
DEH-3750MP/XU/GS
5 6 7 8
55
1. Apply shorting solder to the Pickup flexible cable. Disconnect the cable. 2. Set the mechanism to the clamp mode. 3. Remove the lead wires from the inner holder. 4. Remove the washer, styling holder, change arm, and pickup lock arm. 5. While releasing from the hook of the inner holder, lift the end of the feed screw. Caution: In assembling, move the planet gear to the load/eject position before setting the feed screw in the inner holder.
Shorting Solder
Feed Screw
56
DEH-3750MP/XU/GS
1 2 3 4
16 14 12 10 8 6 4 2 15 13 11 9 7 5 3 1
10A
B
ANTENNA JACK
REAR OUTPUT
Pin No. 1 2 3 4 5 6 7 8
Pin No. 9 10 11 12 13 14 15 16
DEH-3750MP/XU/GS
5 6 7 8
57
7.2 PARTS
7.2.1 IC
A
- Pin Functions(PE5460A)
Pin No. 1 2, 3 4 5, 6 7 8 9 10 11 12 13 14 15 16 17 18 19, 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35, 36 37 38 39 40 41 42 43 44, 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 Pin Name MODEL1 NC AVSS NC AVREF1 KYDT DPDT ADPW TUNPDI TUNPDO TUNPCK PCL TESTIN BSI BDATA BSCK NC swvdd ILMPW NC XRST brst XSTB brxen CONT LOEJ CLCONT NC DALMON VSS TELIN ROT0, 1 ROMDATA ROMCLK ROMCS RECEIVE bsrq NC SYSPW NC STRKEY2 isens MUTE ANTPW NC VST VDT VCK NC TUNPCE2 TUNPCE RDT RDSLK RDS57K RESET LDET RCK I/O I Function and Operation Model select input Not used GND Not used VDD Display microcomputer data input Display microcomputer communication data output A/D converter power supply output PLL data input PLL data output PLL clock output Clock adjustment output Test program input P-BUS serial data input P-BUS serial data output P-BUS serial clock input/output Not used Display microcomputer chip select output Illumination power output Not used CD LSI reset control output P-PUS reset signal output CD LSI strobe output P-BUS reception enable signal input/output Driver output Load/eject output Driver control output Not used Output for dark current reduction circuit GND TEL mute input Rotary volume input 0, 1 ROM collection data output ROM collection clock output ROM collection chip select output RDS decoder receiving output (Not used) P-BUS serial pole request input Not used System power output Not used Wired remote control input Illumination input System mute output Auto antenna control output Not used E.VOL strobe output E.VOL data output E.VOL clock output Not used PLL chip enable output 2 PLL chip enable output RDS LK input (Not used) RDS clock input (Not used) RDS 57K input (Not used) Reset PLL lock detection input RDS clock input
I O O I O O O I I O I/O O O O O O I/O O O O O I I O O O I O I I O O O O O O O
I I
58
DEH-3750MP/XU/GS
1 2 3 4
Pin Name asens bsens dsens source VSS VDD X2, 1 IC(VPP) NC VSS AVDD AVREF1 SL TEMP VDSENS DISCSENS STRKEY1
I/O I I I I
I I I I I
Function and Operation ACC sense input Back up sense input Grille detach sense input Source sense input GND VDD Crystal oscillator connection pin GND Not used VSS VDD VDD Signal level input Temperature detection input VD power supply short circuit input DISC loading detection input Wired remote control input
* PE5460A 80 61
IC's marked by * are MOS type. Be careful in handling them because they are very liable to be damaged by electrostatic induction. 60
C
20 21 40
41
BA33BC0FP
Vref
Vref
+
E
OCP
TSD
1
OUT
2
NC
3
VCC
DEH-3750MP/XU/GS
5 6 7 8
59
- Pin Functions(PD6340A)
A
Pin No. 1-5 6-9 10 11-14 15,16 17 18 19 20 21 22 23 24 25,26 27 28 29-32 33-55 56 57-64 * PD6340A 1
Pin Name SEG4-0 COM3-0 VLCD KST3-0 KDT0,1 REW DPDT NC KYDT MODA X0 X1 VSS KDT2,3 NC KST4 NC SEG35-13 VDD SEG12-5
I/O O O O I I I O
I O O O
Function and Operation LCD segment output LCD common output LCD drive power supply Key strobe output Key data input (analogue input) Remote control reception input Display data input Not used Key data output GND Crystal oscillator connection pin Crystal oscillator connection pin GND Key data input Not used Key strobe output Not used LCD segment output Power supply LCD segment output
16
64
17
49 48
D
32 33
NJM2388F84
N.C. 5 N.C. 4 2 VDD 3 GND
Vref
1 VOUT
F
60
DEH-3750MP/XU/GS
1 2 3 4
- Pin Functions(UPD63763GJ)
Pin No. 1 2 3 4-8 9-16 17 18 19 20 21 22 23, 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39-41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73-88 89-99 Pin Name D.VDD D1.GND reset AB12-8 AD7-0 cs ASTB read write wait INTQ IFMODE0, 1 D1.VDD DA.VDD ROUT DA.GND REGC DA.GND LOUT DA.VDD X.VDD XTAL xtal X.GND VDDREG15 PWMSW0 TEST3-1 PWMSW1 TESTEN D1.GND DIN DOUT SCKIN SCKO LRCKIN LRCK xtalen D1.VDD RFCK/HOLD WFCK/MIRR PLCK/RFOK LOCK/RFOK C1D1/C8M C1D2/C16M C2D1/RMUTE C2D2/LMUTE C2D3/SHOCK D1.GND C33M (rcs) RA11 (CKE) ras cas)(LDQM) cas!(UDQM) we oe(cas) D.GND RDB0-15 RA0-10 I/O Function and Operation Power supply for digital circuits GND for 1.6V digital circuits Input of reset Address bus 12-8 from the microcomputer Address/data bus 7-0 to the microcomputer Chip selection Address strobe Control signals(read) Control signals(write) Control signals(wait) Interruption signals to the external microcomputer Switching the microcomputer I/F 0, 1 Power supply for 1.6V digital circuits Power supply for DAC Output of audio for the right channel GND for DAC Connected to the capacitor for band gap GND for DAC Output of audio for the left channel Power supply for DAC Power supply for the crystal oscillator Connected to the crystal oscillator(16.9344MHz) Connected to the crystal oscillator(16.9344MHz) Ground for the crystal oscillator Control of 1.6V regulator Setup 0 for PWM output(SD, MD) Connected to GND Setup 1 for PWM output(FD, TD) Connected to GND GND for 1.6V digital circuits Input of audio data Output of audio data Clock input for audio data Clock output for audio data Input of LRCK for audio data Output LRCK for audio data Permission to oscillate 16.9344MHz Power supply for 1.6V digital circuits Output of RFCK/HOLD signal Output of WFCK/MIRR signal Output of PLCK/Output of RFOK Output of LRCK/Output of RFOK Information on error correction/C8M : 8MHz Information on error correction/C16M : 16MHz Information on error correction/Mute for Rch Information on error correction/Mute for Lch Information on error correction/Detection of vibration GND for 1.6V digital circuits Output of 33.8688MHz(CLK for SDRAM) DRAM cs Output of DRAM address 11 Output of DRAM CKE Output of DRAM ras Output of DRAM lower cas(LDQM) Output of DRAM upper cas(UDQM) Output of DRAM we Output of DRAM oe(cas) Ground for digital circuits Input/output of DRAM data0-15 Output of DRAM address0-10
A
I I I/O I I I I O O I
I O
I I I I I O I O I O I O O O O O O O O O O O O O O O O O O I/O O
DEH-3750MP/XU/GS
5 6 7 8
61
Pin No. 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120, 121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144
Pin Name D.VDD FD+ FDTD+ TDSD+ SDMD+ MDREFOUTSV AD.VDD EFM ASY ATEST RFI AD.GND AGCO C3T AGCI RFO EQ2, 1 RF2RFA.GND A C B D F E VREFIN A.VDD REFOUT REFC FEFEO ADIN TETEO TE2 TEC LD PD D.GND
I/O O O O O O O O O O O I O I O O I O I I I I I I I I I I O I I O I I O O I O I
Function and Operation Power supply for digital circuits Output of focus drive PWM + Output of focus drive PWM Output of tracking drive PWM + Output of tracking drive PWM Output of thread drive PWM + Output of thread drive PWM Output of spindle drive PWM + Output of spindle drive PWM REFOUT for servo Power supply for ADC Output of EFM signals Input of asymmetry Analog tests Input of RF Ground for the analog system Output of RF Connection to the capacitor for detecting 3T Input of AGC Output of RF(AGC) Equalizer 2, 1 Reversal input of RF2 Reversal input of RF Ground for the analog system Input of A Input of C Input of B Input of D Input of F Input of E Input of reference voltage Power supply for the analog system Output of reference voltage Connected to the capacitor for output of REFOUT Reversal input of FE Output of FE Input of FE, TE A/D converter Reversal input of TE Output of TE TE2 TEC Output of LD Input of PD Ground for digital circuits
* UPD63763GJ 108 73 72 37 1 36
109
144
F
62
DEH-3750MP/XU/GS
1 2 3 4
- Pin Functions(PE5454A)
Pin No. 1 2 3 4 5 6, 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35, 36 37 38 39-42 43 44 45 46 47 48 49 50 51 52 53 54 55 56-58 59 60 61 62 63 64 65 66 Pin Name AVREF AVSS RFOK NC EVDD NC IC/FLMD0 VDD REGC VSS X1 X2 reset XT1 XT2 NC NC xint NC brst BSI BSO bsck FTXD FRXD BRXEN bsrq NC DSCSNS 8EJ(S905) 12EJ(S904) EVSS EVDD SRAMLEVEL0, 1 EMPH emph NC adena LRCKOK SRAMLEVEL2 CD3VON CONT xrst VDCONT ROMDATA ROMCS ROMCK LOEJ CLCONT CDMUTE NC xcs NC xwait CLKOUT LOCK NC xwrite NC I/O Format Function and Operation A power supply Positive power supply(5V) A power supply GND Output of state of RFOK Not used E power supply Positive power supply Not used IC : VSS direct connection/FLMOD0 : Pull-down Positive power supply(5V) Connected to the capacity stabilizing output of the regulator GND Oscillator connection for mainclock Oscillator connection for mainclock System reset input Connected to the oscillator for subclock (connected to VSS via the resistor) Connected to the oscillator for subclock(Open) Connected to EVDD or EVSS via the resistor Not used CD LSI interruption signal input Connected to VSS via the resistor P-Bus reset input P-Bus serial data input P-Bus serial data output P-Bus serial clock input/output For flash rewriting output(transmitted signal) For flash rewriting input(received signal) It is possible to receive P-Bus input/output P-Bus service request demand input/output Not used Disc state sense input Input of detection of 8 cm disc ejection Input of detection of 12 cm disc ejection E power supply GND E power supply Positive power supply SRAM level meter output Emphasis information output Emphasis information output Not used A/D reference voltage supply control output (DOUT mute output) SRAM level meter output CD +3.3V power supply control output Servo driver power supply control output CD LSI reset control output VD power supply control output E2PROM data input/output E2PROM chip selection output E2PROM clock output The direction change output of LOAD/EJECT Driver input change output CD mute control output Not used CD LSI chip selection output Not used CD LSI write control signal input Internal system clock output(Open) Spindle lock input Not used CD LSI write control signal output Not used
A
I I I
C /C C /C /C
O O O O O O O O O O I/O O O O O O O I O I O
C C C C C C C C C C /C C C C C C C
DEH-3750MP/XU/GS
5 6 7 8
63
Pin Name xread XASTB BVSS BVDD AD0-12 NC FMODE FLRQ NC csens TYPE_A/D testin HOME TEMP VDSENS NC
I/O O O
Format
I/O I O I I I I I I
/C
Function and Operation CD LSI read control signal output CD LSI address strobe output B power supply GND B power supply Positive power supply Address/data Bus 0-12 Not used For flash rewriting Connected to VSS via the resistor For flash rewriting Not used Flap closing sense input CD-DA analog/digital output change setup Chip check test program starting input Home SW sense input Temperature information sense input VD power supply short sense input Not used
Format C 50
Meaning CMOS
76
75
51 26 25
Thermal Protection Bandgap Reference 1 IN 2 GND
100 1
D
NJM2885DL1-33
-+
3 OUT
64
DEH-3750MP/XU/GS
1 2 3 4
13
ROM_VDD
5
SL
10 9 8
CE1 DI CK
11
NC
14
DO
18 19 20 21
NC NC NC NC
5V
OSC
LPF
AM ANT 1 ATT
T51
CF52 CF51
AUDIOGND
OSCGND
VDD_3.3
RFGND
DGND
3.3V
12
15
22
16
VCC
NC
17
2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24
I O I I I I I
RF ground FM antenna input power supply signal level chip enable-2 write control chip enable-1 clock data in non connection osc ground power supply data out digital ground non connection power supply non connection non connection non connection non connection audio ground L channel output R channel output
AM antenna input high impedance AMANT pin is connected with an all antenna by way of 4.7H. (LAU type inductor) A series circuit including an inductor and a resistor is connected with RF ground for the countermeasure against the hum of power transmission line. Ground of antenna block Input of FM antenna 75 Surge absorber(DSP-201M-S00B) is necessary. The power supply for analog block. D.C 8.4V 0.3V Output of FM/AM signals level Chip enable for EEPROM Low active You can write EEPROM, when EEPROM write control is Low. Ordinary non connection Chip enable for AFRF High active Clock Data input Not used Ground of oscillator block Power supply for EEPROM pin 13 is connected with a power supply of micro computer. Data output Ground of digital block Not used The power supply for digital block. 3.3V 0.2V Not used Not used Not used Not used Ground of audio block FM stereo L-ch signal output or AM audio output FM stereo R-ch signal output or AM audio output
DEH-3750MP/XU/GS
5 6 7 8
IC 3 EEPROM 5.0V
IC 5 3.3V
24
23
65
7.2.2 DISPLAY
- LCD(YAW5027)(DEH-3750MP/XU/GS, DEH-3750MP/XU/CN) - LCD(YAW5015)(DEH-3770MP/XU/CS)
SEGMENT
66
DEH-3750MP/XU/GS
1 2 3 4
COMMON
Power ON
Starts communication with Grille microcomputer. 300ms swvddL Pin 21 Source keys operative
300ms
D
In case of the above signal, the communication with Grille microcomputer may fail. If the time interval is not 300msec, the oscillator may be defective.
Source ON
SYSPWH Pin 43
DEH-3750MP/XU/GS
5 6 7 8
67