Professional Documents
Culture Documents
Wireless
Wireless
Wireless
MOTIVE OF TRAINING
Main motive of the training is to interface the wireless module with the microcontroller and computer.
Makes wireless network different from wired networks Should be taken into account by all layers
Wireless = Waves
Electromagnetic radiation
Emitted by sinusoidal current running through a wire (transmitting antenna)
Creates propagating sinusoidal magnetic and electric fields according to Maxwells equations
Fields induce current in receiving antenna
Name Range
Bandwidth
26 Mhz
MICROCONTROLLER
The MCU used in the training is P89V51RD2 Features
BOARD FEATURES:
9 Snap switches
8 onboard LEDs
Onboard Reset switch 1 LCD A Serial Port for ISP External Interrupt (INT0) Switch Onboard interfaces for
16X2 character LCD 7-Segment Display 4X4 Matrix keyboard ADC module Stepper and DC motor driver Real Time Clock
HARDWARE REQUIREMENTS
SOFTWARE REQUIREMENTS
NT/2000/2003
FREQUENCY OF MCU
and 19 of MCU. This crystal provides accurate baud rate for serial communications. 11.0592MHz is maximum clock frequency that the standard 8051 will support.
RESET CIRCUITRY
A logical high on pin 9 of MCU will reset the chip.
SERIAL INTERFACE
POWER SUPPLY
1. 2. 3.
RF Tx & Rx
GSM MODULE
LCD
AT COMMANDS
AT is the abbreviation of ATtention To call a number : ATD [phone number]
EXTRA HARDWARE
Matrix Keypad of any number
LCD only 16*2 Bluetooth GPS Module Zigbee etc,.
THANKYOU