Professional Documents
Culture Documents
Site Installation Guidelines
Site Installation Guidelines
Guidelines
Best Practices to Adopt
Table of Contents
Antenna Installation
Cabling for Antenna
Ethernet Cabling
RF Cabling
Electrical Works
Grounding
Active Equipment
Antenna
Cable
Labelling
Health and Safety
Antenna Installation
Applies to
Ceragon
Cambium
Ubiquity
Solectek
Infinet
Position of antenna on pole at height with best LOS between transmitter and receiver
Pole/bracket dimension to tally with antenna clamp size (e.g. 2)
Guide to be used where required, depending on antenna size/weight (e.g. antenna 4ft for microwave)
Antenna Tilt and Azimuth to be implemented as per link engineering report and RF measurement during
alignment process
Antenna separation between antennas on same pole
Grounding of Antenna (where applicable)
Antenna stability must be checked i.e. no swaying or moving due to wind. This will affect the RF
performance
NOTE: Always refer to specific antenna manual/installation guide as this will vary on the supplier/antenna
make/model
Typical Length
Outdoor Ethernet Cable (Cat5e/Cat6/Cat7)
Ethernet cable grounding
Cable Laying
Ethernet Cable Test
Typical Length
Belden RG8-U/50 Ohm coaxial cable
Connectors (Male/Female) as per equipment installation materials and guidelines
Coaxial Cable Grounding
Coaxial Cable Test
Electrical Connection
PDU
Breaker
Grounding
Ventilation and Cooling
Labelling
Electrical Works
A.C Installation
PDU
Direct on Breaker (A.C MDB)
Cable Size and Color Code
Grounding
D.C Installation
Recitifier
Direct on Breaker (D.C MDB)
Cable Size and Color Code
Grounding
UPS
UPS Module
UPS Battery Bank
UPS Monitoring
Grounding
Grounding System
Grounding Cable
Components to ground
Cable Size and Color Code
Labelling
Equipment
Cable
Rack/Shelter/Cabinet
Naming Convention/Label Format