Professional Documents
Culture Documents
Necneomicrowaveequipmentintroduction 150521223111 Lva1 App6891
Necneomicrowaveequipmentintroduction 150521223111 Lva1 App6891
Equipment Introduction
Microwave Communication
Introduction
PASOLINK NEO Equipment
Introduction
PASOLINK NEO Equipment
System Configuration
Typical Networking Examples
Microwave Communication Introduction
Microwave Communication
Concept
Microwave Communication
Features
Microwave Communication Concept
Point to Point Digital Microwave transmission system
Coaxial cable
Microwave link
MUX MUX
Satellite
microwave
MSC PDH
PDH BTS
BTS PDH
BTS
BTS BTS PDH
BTS
BTS BTS
BTS BTS
PSTN MSC
BSC
SDH SDH BTS
BSC
BTS
SDH
PSTN: Public Switched BSC
BTS
SDH
Telephone Network
MSC: Mobile Switching Center BTS BTS BSC
BSC: Base Station Controller
PDH BTS
BTS: Base Transceiver Station
PDH BTS
BTS PDH
BTS
SDH PDH
SDH
Microwave
BTS
BTS BTS
PDH PDH
Microwave
Microwave Communication Features
Wide frequency band has larger capacity for more radio communication equipments.
High transmission quality, High stability and reliability, High antenna gain and High Security.
High resistance against disasters such as earth quake and flood. Less affected by terrain.
Equipments Overview
IDU
ODU
Hybrid
System Performance
PASOLINK Equipments Overview
Equipment Features
Equipment Application
PASOLINK Family Road Map
PASOLINK NEO Overview
Antenna
Non-protective (1 0)
System Configuration
Protective (1 1)
Equipment Features
IDU Overview
IDU Configuration
Equipment Parameters
PDH E1
PDH E3
SDH STM-1
: Available
X: Unavailable
Interface Card Introduction
: Available
X: Unavailable
Interface Card Introduction
4P LAN Interface Card
Interface Card Introduction
GbE Interface Card
: Available
X: Unavailable
Interface Card Introduction
32E1 Interface Card
: Available
X: Unavailable
IDU Configuration Introduction
PDH 16E1
PDH 48E1
SDH STM-1
IDU Panel Introduction 1
1. Grounding bolt 2. IF cable port 3. XPIC in/out port 4. XPIC CTRL Port
5. LED lights
RX: RX Status (Green) ODU: ODU Alarm (Red)
14. EOW: EOW phone port 18. LCT: Local Craft Terminal port
Equipment
Parameters 1
Physical Parameters
Power requirements -48 VDC (-40.5 VDC to -57 VDC), comply with EN300 132-2
PDH 1+0 25W SDH 1+0 27W
Power consumption (Typical)
1+1 35W 1+1 37W
Modulation
2 QPSK/16/32QAM 128QAM QPSK/16/32/128QAM
Mode
10/100Base-T(X)
E1:2.048Mbp s50ppm E3:34.36820ppm 155.52Mbps20ppm 1000Base-SX
1000Base-T
Base Band
Interface 75ohm/120ohm 75ohm 75ohm/S-1.1/L-1.1
3 RJ45(10/100/1000Base-T(X))
D-sub37 / MDR68 IEC169-29(1.0/2.3) IEC169-29(1.0/2.3)
LC(1000Base-SX)
Channel
5/10/16/20/40/48 1/2 1/2 2/4
Quantity
Total 10/20/40/80/100
10/20/32/40/80/96Mbps 34/68Mbps 155/2X155Mbps *
Capacity 100+50,75+75Mbps
Service
4 V11(codirection/contradirection)x2CH , RS-232x2CH
Channel
Application Example 1+1
XIF IN/XIF OUT: For XPIC XPIC CTRL: For 1+1 protection IDU
ODU Introduction
ODU Overview
ODU Appearance
Modulation mode:
QPSK 16QAM 32QAM 128QAM
ODU Appearance
13022.25 12756.25
2 12756.25 13022.25 2
13024
3 12758 13024 3 12758
13025.75 12759.75
4 12759.75 13025.75 4
A A
13027.5 12761.5
5 12761.5 13027.5 5
12763.25
6 12763.25 13029.25 6 13029.25
13032.75 12766.75
8 12766.75 13032.75 8
ODU Performance Parameters 3
Output +25 +25 +21 +21 +21 +19 +19 +18 +18 +17 +14.5
Power dBm
Power Control 0 to 20 dB, in 1 dB step variable
Frequency 6ppm
Stability
Threshold Level (dBm measured at Antenna port) BER = 10 -6
CS = 28 (27.5) - 69.5 -68.5 -68.5 -69 -69 -69 -68.5 -68.5 -67 -67
MHz
BER = 10-3 Above value with -1.5 dB
System Gain (dBm measured at Antenna port) BER = 10 -6
Hybrid Appearance
Loopback
EOW Operation
System Upgrade
IDU and ODU Interconnection 1
140MHz 340MHz
RX Signal TX Signal
Frequency
150 m (5D-FB)
Maximum IF Cable
4 300 m (8D-FB)
Length
350 m (10D-FB)
Near-end IF loop
EOW Operation
5E1(4P/16Q)
16E1(4P/16Q)
40E1(16Q)
48E1(32Q)
STM-1(128Q)
System Upgrade 2
System Configuration
Typical Configuration
Performance Compare
Separated
1+0
Integrated
Separated
Single
Antenna
Hybrid Integrated
1+1
(7dB Loss/Hop)
Separated
Twin
Antennas
Integrated
System Configuration(1)
System
Configuration