The document describes a cascode common-source LNA design. It consists of a common-source amplifier M1 followed by a common-gate device M2. An input matching network with inductor LG and L1 is used to match the low input impedance caused by the large device size for noise optimization. The output is resonated by LD and C1 tuned to the operating frequency, while R1 determines the gain. Simulation shows the designed LNA achieves desired gain and noise figure.
The document describes a cascode common-source LNA design. It consists of a common-source amplifier M1 followed by a common-gate device M2. An input matching network with inductor LG and L1 is used to match the low input impedance caused by the large device size for noise optimization. The output is resonated by LD and C1 tuned to the operating frequency, while R1 determines the gain. Simulation shows the designed LNA achieves desired gain and noise figure.
The document describes a cascode common-source LNA design. It consists of a common-source amplifier M1 followed by a common-gate device M2. An input matching network with inductor LG and L1 is used to match the low input impedance caused by the large device size for noise optimization. The output is resonated by LD and C1 tuned to the operating frequency, while R1 determines the gain. Simulation shows the designed LNA achieves desired gain and noise figure.
common-source LNA. 1 forms the common-source amplifier followed by the common-gate device 2 . For noise optimized design, the device size is large leading to high input capacitance providing low input impedance. Input signal will be attenuated because of low input impedance, hence input matching network comprising and 1 is constructed. and 1 is the output resonating network tuned to frequency of operation. 1 is the parasitic resistance of the resonant network determining the gain of the LNA.
8/7/2017 IIT Kharagpur 1
Cascode CS LNA design example
8/7/2017 IIT Kharagpur 2
Cascode CS LNA design example Input impedance looking into the input of the LNA is 1 1 = + 1 + 1 1 The real part should be matched to 50 and 1 and 1 tuned to operating frequency. This constrains the values of , 1 and 1 . A better solution is to add an inductor . More freedom in choosing passives for input matching 1 1 = + 1 + + 1 1
8/7/2017 IIT Kharagpur 3
Cascode CS LNA design example
8/7/2017 IIT Kharagpur 4
Cascode CS LNA design example
8/7/2017 IIT Kharagpur 5
Cascode CS LNA design example
8/7/2017 IIT Kharagpur 6
Cascode CS LNA design example Final LNA with all the component values
8/7/2017 IIT Kharagpur 7
Simulation Results for Cascode CS LNA Gain Noise Figure