A pulse oximeter is a medical device that measures heart rate and oxygen saturation in the blood. To use a pulse oximeter, you turn it on, place the sensor on a finger with the screen facing up, and wait for it to acquire a signal which may take 10 seconds. The display will then show the heart rate and oxygen saturation percentage. For continuous monitoring, leave the sensor on but check and move it every 2-4 hours to prevent discomfort or pressure sores.
A pulse oximeter is a medical device that measures heart rate and oxygen saturation in the blood. To use a pulse oximeter, you turn it on, place the sensor on a finger with the screen facing up, and wait for it to acquire a signal which may take 10 seconds. The display will then show the heart rate and oxygen saturation percentage. For continuous monitoring, leave the sensor on but check and move it every 2-4 hours to prevent discomfort or pressure sores.
A pulse oximeter is a medical device that measures heart rate and oxygen saturation in the blood. To use a pulse oximeter, you turn it on, place the sensor on a finger with the screen facing up, and wait for it to acquire a signal which may take 10 seconds. The display will then show the heart rate and oxygen saturation percentage. For continuous monitoring, leave the sensor on but check and move it every 2-4 hours to prevent discomfort or pressure sores.
A pulse oximeter is a medical device that measures heart
rate and the oxygen level in the blood, expressed as the percent of oxygen saturation. Pulse oximeters operate by shining light through the skin to the blood vessels below. STEP 1 Turn on the pulse oximeter by firmly pressing the power button. The screen should light up almost instantly. STEP 2 Place the sensor the part that opens and closes like a clothespin on any finger, with the sensor screen above the fingernail. STEP 3
Wait quietly while the pulse oximeter acquires a signal. This
may take 10 seconds or more, depending on the device and the conditions. STEP 4
Look at the display to see the heart rate, usually indicated
with a heart or pulsing light. The percent of oxygen saturation is typically indicated by the symbol "SpO2." STEP 5 Leave the sensor on for continuous monitoring. The sensor can become uncomfortable or cause pressure sores if left on the finger too long. Check and/or move the sensor at least every two to four hours. If only a single measurement is required, remove the sensor and press the power button to turn off the device. THANK YOU FOR ATTENTION
Differentiating Anesthesia Equipment: Identify and Understand Anesthesia Equipment in 1 Hour (Including the most popular manufacturers and suppliers to buy Anesthesia Equipment)
Local Anesthesia Made Easy: Complete Guide on How to make your Local Anesthetic Procedure a Success (Including a List of Anesthetic Equipment and their Uses)