The document describes a level control process for a tank. It involves two level sensors (LS1 and LS2) and two pumps (P1 and P2). If the fluid level drops below LS1, pump 1 starts operating until the level reaches LS1. If the level drops below LS2, both pumps operate until the level reaches LS1, at which point both pumps stop until the level drops below LS1 again. The document instructs the reader to write a PLC program to control this level control process.
The document describes a level control process for a tank. It involves two level sensors (LS1 and LS2) and two pumps (P1 and P2). If the fluid level drops below LS1, pump 1 starts operating until the level reaches LS1. If the level drops below LS2, both pumps operate until the level reaches LS1, at which point both pumps stop until the level drops below LS1 again. The document instructs the reader to write a PLC program to control this level control process.
The document describes a level control process for a tank. It involves two level sensors (LS1 and LS2) and two pumps (P1 and P2). If the fluid level drops below LS1, pump 1 starts operating until the level reaches LS1. If the level drops below LS2, both pumps operate until the level reaches LS1, at which point both pumps stop until the level drops below LS1 again. The document instructs the reader to write a PLC program to control this level control process.
Lecturer - Industrial Electronics and Control Eng. Dept. Faculty of Electronic Engineering - Minoufia University 8/20/2018 1 8/20/2018 2 8/20/2018 3 2-Write PLC program to control the following process: Continues flow through the out LS pipe, if the level of the tank 1
become below LS1, one of the In Flow
two pumps start operation till LS
2 P1 the fluid level reaches LS1, if the fluid level become below LS2, the two pumps operate until the P2 Out Flow level of the fluid reaches LS1. (The two pumps stops till the fluid level become below LS1)