Professional Documents
Culture Documents
Quiz Bee For Techdraw7
Quiz Bee For Techdraw7
Quiz Bee For Techdraw7
Technical Drawing G7
Instruction:
1. The class will group into five.
2. The game is composed of three parts; the EASY
round, AVERAGE round, and last the DIFFICULT
round.
3. Each group is given 5 seconds to answer for the
easy and average round and 10 seconds for the
difficult round.
4. Each round, every correct answer have its
coressponding points.
1 points for the EASY round
3 points for the AVERAGE round
5 points for the DIFFICULT round
5. If the game master command to raise their answer,
the group should raise their answer or else it will not
be counted even if it is correct.
6. If in case there’s a tie, a tiebreaker question will be
asked to those group. The group who will first to
raise their answer will be declared as the winner.
7. During the game, no one is allowed to shout, to
cheat and to make unnecessary noise, for it will be a
deduction of points in the group.
8. Just listen carefully to the questions. The
questions will be revealed through PPT. The teacher
should only read the questions once. The signal “GO”
is the only time that groups can write the answer on
their board.
9. Make your writings clear and readable.
10. Wrong spelling is wrong.
Are you now ready?
EASY ROUND
(1 point)
Question no. 1
Multiple Choice
This means to
Bisect/Bisecting
divide into two
parts?
Question no. 2
Identification
It is a solid
figure whose two Prism
bases are parallel
equal polygons.
Question no. 3
Identification
A polygon that
can be inscribed Regular Polygon
and
circumscribed
around a circle.
CLINCHER
Question no.
Identification
The point of
intersection of Vertex
two or more
sides.
Question no. 3
Identification
The length of a
straight line from
the center of the Radius
circle to a point in
the circumference
of the circle.