Professional Documents
Culture Documents
Detection of Specks in Mammography: Sreyas Institute of Engineering & Technology
Detection of Specks in Mammography: Sreyas Institute of Engineering & Technology
Presented by:
L.AkhilaReddy(15VE1A04E5)
N .Lokesh(15VE1A04F9)
R.SaiKrishna(15VE1A04G9)
1
DETECTION OF SPECKS IN MAMMOGRAPHY
Introduction
• Breast cancer is one of the leading causes of cancer-related
deaths.early detection of suspicious lesions is crucial for the
prognosis of the patient.
• In cases where a lesion is detected before cancer cells spread
into the surrounding tissue,the 5-years survival rate is 97.9%.
• It drops sharply to 81.3% and 26.1% for regionally advanced
and metastatic cancer,respectively detection of breast cancer is
conducted by means of two most widely used diagnostic
methods.
• Mammography and ultrasonography(USG)
2
DTEECTION OF SPECKS IN MAMMOGRAPHY
Introduction
• And if the data is matched then that device buzzer will be
activated indicating the location of that particular device.
• If the data is not matched then the buzzer will not be activated.
• Here the module is constructed for two devices only.
• Depending on the requirement, it can be enhanced to any
number of devices.
• The required power supply for the transmitter section is given
through the mains and for the receiver sections, supply is
provided through small batteries.
• By using RF technology we can find the hidden things in the
range of 60 to 70 feets
3
Innovative Hidden Things Locator Using Wireless Technology
BLOCK DIAGRAM
4
DETECTION OF SPECKS IN MAMMOGRAPHY
BLOCK DIAGRAM
RECEIVER
ALARM ANTENNA
+ - 89C2051
RF RECEIVER
9V MICROCONTOLLER
BATTERY
89S51 microcontroller
6
Innovative Hidden Things Locator Using Wireless Technology
CIRCUIT DIAGRAM:
7
Innovative Hidden Things Locator Using Wireless Technology
Architecture :
TRANSMITTER:
8
Innovative Hidden Things Locator Using Wireless Technology
RECEIVER:
• Consists of 9V battery.
• RF receiver
• 89C2051 microcontroller and RF decoder.
• It has a voltage regulator(IC7805).
• BC547 transistor acts as a switch in receiver
where as in transmitter it acts as amplifier.
TRANSMITTER:
• Vcc to 40th pin and 20th pin is grounded.
• Switches S1 and S2 are connected using 12 and 13 pins.
• 31st pin is made high to indicate that external access is not
enabled.
• Encoder encodes the signal using 11th pin of controller it is
transmitted to the 4th pin of RF transmitter through BC547 .
• The crystal oscillator is connected to the 18th and 19th pins which
generates the frequency.
RECEIVER:
11
Innovative Hidden Things Locator Using Wireless Technology
Advantages
• We need to waste our time in searching the forgotten or hidden
things usig this technology time can be saved.
• Wireless technology is used.
Applications
Secondly,using highly advanced RF and with the help of growing technology the project has
been successfully implemented
14
Innovative Hidden Things Locator Using Wireless Technology