This document provides instructions for drafting a back blouse sloper pattern based on body measurements. It lists the specific body measurements needed and their corresponding pattern measurements. It then outlines 25 steps to draft the sloper, which includes drawing construction lines, marking key points for shoulder width, back width, armholes, waist, bust and back dart, and connecting points to shape the pattern pieces.
This document provides instructions for drafting a back blouse sloper pattern based on body measurements. It lists the specific body measurements needed and their corresponding pattern measurements. It then outlines 25 steps to draft the sloper, which includes drawing construction lines, marking key points for shoulder width, back width, armholes, waist, bust and back dart, and connecting points to shape the pattern pieces.
This document provides instructions for drafting a back blouse sloper pattern based on body measurements. It lists the specific body measurements needed and their corresponding pattern measurements. It then outlines 25 steps to draft the sloper, which includes drawing construction lines, marking key points for shoulder width, back width, armholes, waist, bust and back dart, and connecting points to shape the pattern pieces.
Measurements Needed in Drafting Back Blouse Sloper (Sample Measurement) Parts of the body Actual Body Measurement Computed measured Measurement Needed Measurement
Shoulder width 15 ½ 7 1/2
Back Across width 14 1/2 ½ 7¼ Back Figure length 15 1/2 1 15 ½ Bust Circumference 35 ¼ 8¾ Waist Circumference 26 ¼ 6½ Armholecircumference 16 ½ 8 Bust distance 7 1/2 3½ Procedure in Drafting Pattern for Back Blouse Sloper 1. Draw construction line by tracing the outer edge of the L-square. Mark the corner A. 2. A – B is ½ inch downward on the construction line. 3. A – C is 5 inches downward on the construction. 4. A – D is ½ of the armhole circumference. 5. A – E is the back figure length. 6.Draw horizontal line from points B – C – D – E. 7. A – F on the horizontal construction line is 3 3/4 inches. 8.Shape back neckline from point F to B with a French curve. 9.A –G IS ½ of the shoulder width. 10.G – H is 1 ½ inches down. 11. Connect points F and H with a straight line. 12. C – I is ½ of the back across width. 13.D – J is ¼ of the bust circumference. 14.Shape back armhole from points H – I – J with a French curve 15.E – K is ¼ of the waist circumference plus 1 inch for the back dart. 16.Connect points J – K with straight line. 17.E – L is 7 inches upward on line AE. Draw horizontal line for point L. 18.E – M is 3 ½ inches on line EK trace point M up. 19.Mark intersection of line LM as point N . 20.M – O is ½ inch towards point E. 21. M – P is ½ inch towards point K. 22.Connect points N and O to pint P with a straight line. 23.K – Q is 1 inch upward on line KJ. 24.Connect point Q to point M with a slight curve. 25.Cut back bodice sloper along lines B – C – D – L - E – N - M – O - Q –J – I – H – F – B. A quiet place the movie Draft their own back bodice pattern