This document discusses a simple video amplifier circuit that uses an op-amp such as the LM359 to increase the strength of a video signal. The circuit provides a gain of around 10 times through negative feedback configuration of the op-amp. It is capable of amplifying signals up to frequencies of 30MHz with a gain of approximately 20dB. The input and output resistor values are selected to match standard video signal impedances.
This document discusses a simple video amplifier circuit that uses an op-amp such as the LM359 to increase the strength of a video signal. The circuit provides a gain of around 10 times through negative feedback configuration of the op-amp. It is capable of amplifying signals up to frequencies of 30MHz with a gain of approximately 20dB. The input and output resistor values are selected to match standard video signal impedances.
This document discusses a simple video amplifier circuit that uses an op-amp such as the LM359 to increase the strength of a video signal. The circuit provides a gain of around 10 times through negative feedback configuration of the op-amp. It is capable of amplifying signals up to frequencies of 30MHz with a gain of approximately 20dB. The input and output resistor values are selected to match standard video signal impedances.
This document discusses a simple video amplifier circuit that uses an op-amp such as the LM359 to increase the strength of a video signal. The circuit provides a gain of around 10 times through negative feedback configuration of the op-amp. It is capable of amplifying signals up to frequencies of 30MHz with a gain of approximately 20dB. The input and output resistor values are selected to match standard video signal impedances.
amplifiers can be used. • The circuit in Figure below is simple video amplifier circuit. It uses an op-amp IC: LM359 or similar. Which they can work in a high frequency such as LM3900series. • Gain bandwidth of the LM359 is approximately 10-100 times at frequency30MHz range. Also, they can use up to 400MHz, but lower gain. Circuit Diagram The principle of simple video amplifier
• This op-amp is connected in negative feedback
from or non-inverting. Because of has signal is fed to negative polarity. Then, the output signal will be feedback to the negative polarity again. To make a more stable operation. • Although, the gain is reduced. It will raise the bar even higher frequencies in equal proportions. • The gain of the circuit calculated by dividing R3 and R1, around 10 times. • So, it is a gain of approximately 20 dB at the frequency band of 20 MHz. • Resistors-R1 is input resistance value 750 Ohms, to appropriate values to load 75 Ohms. Load on the antenna is 75 Ohms. The R1 value is the specific values at only applies to the number LM359. • If you want to use other op amps. The input impedance can be as high as approximately 20K ohms.