Professional Documents
Culture Documents
Nitration (Lec 2 and 3)
Nitration (Lec 2 and 3)
LEARNING OBJECTIVES
Introduction
Nitrating Agents
Mechanism For Nitration
Kinetics of Aromatic Nitration
Equipments For Nitration Processes
Industrial Application
2
NITRATION???
3
INTRODUCTION
The reaction between a nitrating agent and an
organic compound that results in one or more nitro
( --NO2) groups becoming chemically bonded to an
atom in the organic compound.
1. Ionic or
2. Free-radical.
MECHANISM (CONTD)
Ionic nitrations are commonly used for aromatics;
many heterocyclics; hydroxyl compounds, e.g., simple
alcohols, glycols, glycerol, cellulose and amines.
36
HEALTH AND SAFETY FACTORS
Batch Nitration
Continuous Nitration
Advantages And Disadvantages of Batch And Continuous Reaction
Processes.
Advantage of a Batch Process Advantage of a Continuous Process
• More cost effective if large quantities of the chemical are
• A variety of different products can be made using the plant.
being made.
• Slow reactions can be carried out.
• No expensive ‘down time’ when plant is not being used.
• Can use reactants in any state including solids. • Automated process requires less labour.
Degree of agitations
Control of temperature
BATCH NITRATION ( CONT..)
Cooling is generally accomplished by coils of tubes through
which either cold water or brine for cooling may be circulated
or hot water and steam for heating.
Advantages of coils:
High coolant velocity is possible
More compact so can be installed anywhere in the tank.
Disadvantages of coils:
Fouling& scaling problem. Cleaning is no easy.
AGITATING MECHANISM
1. Single shaft
2. Double shaft
3. Propeller or turbine with cooling sleeve,
1. SINGLE-SHAFT AGITATOR
It consists of one vertical
shaft containing horizontal
arms (one or more
propellors mounted on it).
The shaft may be placed
off center in order to create
rapid circulation past, or
local turbulence at, the
point of contact between
the nitrating acid and the
organic compound.
2. DOUBLE-SHAFT AGITATOR
• The consists of two vertical shafts rotating in
opposite directions, and each shaft has a series of
horizontal arms attached.
• The lower blades have an upward thrust, whereas the
upper ones repel the liquid downward. This
conformation provides a reaction mix that is
essentially homogeneous.
3. SLEEVE-AND-PROPELLER
AGITATION
47
CONTINUOUS NITRATION
The reactants, both of which are fed from the top are
immediately drawn into the vortex thoroughly mixed and
circulated down through the center of the bank of
cooling coils and backup through and around the coils.
a) Nitration
b) Washing of crude nitrobenzene…
c) Distillation to separate the water‚ benzene and
dinitrobenzene.
BATCH NITRATION PROCESS
HNO3 32 – 39 wt %
H2SO4 60 – 53 wt %
H2 O 8 wt %