Professional Documents
Culture Documents
Planning The Wet Scrubber On Auxiliary Boiler Unit at Pt. Indonesia Power Ujp Jabar 2 Pelabuhan Ratu
Planning The Wet Scrubber On Auxiliary Boiler Unit at Pt. Indonesia Power Ujp Jabar 2 Pelabuhan Ratu
Planning The Wet Scrubber On Auxiliary Boiler Unit at Pt. Indonesia Power Ujp Jabar 2 Pelabuhan Ratu
PROPOSED SUPERVISOR:
1. Ahmad Erlan Afiuddin, ST., MT.
2. Mochammad Choirul Rizal, ST., MT.
Add an image
INTRODUCTION
Background
3
Identification of Emission
Characteristics on Auxiliary
Boiler
Planning a Coating on
Wet Scrubber
AIMS/OBJECTIVE
Planning a Coating and
Platform on Wet Scrubber
4
R E S E A R C H D E L I M I TAT I O N S
Start with identification the problem on auxiliary boiler area at Collecting some data to support this research. Data on this research is
divided by two, main data and secondary data. Main data is based on
PT. Indonesia Power UJP JABAR 2 Pelabuhan Ratu caused by
analyzing some samples and secondary data is based on books, journals,
SO2 and the total of particulate exceed the regulations. and etc.
Studies based on journals, books, regulations, and After collecting data and data analysis, the next step
standard methods . is to design the wet scrubber.
6
SO WHAT IS
WET
SCRUBBER? The dirty exhaust stream is brought into contact
with the liquid by spraying it into the liquid; by
forcing it through a pool of liquid; or by some
contacts methods. These air pollution control
devices can removes both particulate matter and
gaseous pollutants. In this research, it only removes
SO2 and particulate.
A mass transfer operation in which a gas dissolved in a
ABSOPRPTION liquid. It is transfers of gaseous components from the
gas phase to a liquid phase.
8
The liquid, usually water mixed with neutralizing
ABSORBENT agents, into which the contaminant is absorbed. In this
case, can use lime. Cause lime can remove SO 2
9
S T E P S O F P L A N N I N G T H E W E T S C R U B B E R
1 C A L C U L AT E I N E RT I A L I M PA C T I O N 4 C A L C U L AT E P O W E R L O S S
Known the separation number for Calculates power loss on gas passing through
impaction. the scrubber
2 C A L C U L AT E M E A N D R O P L E T 5 C A L C U L AT E P O W E R L O S S
The mean droplet for standard air and water Calculates power loss of spray liquid during
in wet scrubber. atomization
3 C A L C U L AT E P R E S S U R E D R O P 6 C A L C U L AT E U N I T T R A N S F E R
1 STRESS
Stress is a physical quantity that expresses the internal forces that neighboring particles of a
continuous material exert on each other, while strain is the measure of the deformation of the material, which
is not a physical quantity.
2 BUCKLING
Buckling is characterized by a sudden sideways deflection of a structural member. This may occur even
though the stresses that develop in the structure are well below those needed to cause failure of the material of
which the structure is composed.
3 FATIGUE
Fatigue is the weakening of a material caused by cyclic loading that results in progressive and
localized structural damage and the growth of cracks.
11
TIME SCHEDULE OF THIS RESEARCH
THANK YOU!
ANY QUESTIONS?