Professional Documents
Culture Documents
Fillet Welding
Fillet Welding
ON YOUR
CAMERA
BEST MORNING!
SHIELDED METAL ARC WELDING
FILLET WELDING
T WE LD
FILLE
Lap Joint
Corner Joint
Tee Joint
LAP JOINT
• is frequently used in all kinds
of work, which may be single-
fillet lap joint or double fillet
lap joint.
• Single fillet lap joint should
not be used if root of joint is
to be subjected to bending
• This type of joint should
never replace the butt joint on
works under severe load.
CORNER JOINT
• is a weld joint formed when two joint
members are positioned at an
approximate 90 degrees angle with the
weld joint at the outside of the joint
members
• Half open corner joint may be used on
12 gauge up to 4.5mm
• Full open joint can be cut absolutely
square and suitable clamping and
holding devices are needed to facilitate
fit up.
TEE JOINT
• is a welding joint at the
junction of two parts
located approximately
at right angles to each
other in the form of a T
BUTT JOINT EDGE JOINT
PARTS OF FILLET WELD
Throat Toe
WELD ROOT
• is the
• is the shortest distance from
distance from the face of a
the face of a fillet weld to
fillet weld to the the weld root
weld root, minus before
any convexity welding.
after welding