Professional Documents
Culture Documents
CC2 Questionnaire
CC2 Questionnaire
CC2 Questionnaire
a. “Installation of screw- jointed and solder- jointed tubing: All pipes and tubing shall
be cut accurately to measurements established by the contractor without springing
or forcing”
b. “the existing culverts shall be replaced as indicated on the drawing”
a. “Installation of screw- jointed and solder- jointed tubing: All pipes and tubing shall
be cut accurately to measurements established by the contractor without springing
or forcing”
b. “the existing culverts shall be replaced as indicated on the drawing”
a. Water contained in open canals, aqueducts may be used for watering plants
as long as the water is withdrawn by manual methods
b. When reuse of waste water is feasible, it shall not longer be limited for
efficiency and may help to lessen cost.
c. Excavation for purpose of emission of hot spring is not allowed ; must first
obtain a permit from Department of Environmental and Natural Resources
d. Drainage systems shall be constructed that their outlets are manmade
infrastructure provided by private property
According to the Presidential Decree no. 1067 or the Water Code
of the Philippines, which of the following is true about the
utilization of waters: Correct Anwers: Chapter 4 Utilization of Waters
a. Article 33 Water contained in open canals,
aqueducts may be used for watering
a. Water contained in open canals, aqueducts may plants as long as the water is withdrawn
be used for watering plants as long as the water by manual method. Provided there would
is withdrawn by manual methods be no damage checking the stream
b. When reuse of waste water is feasible, it shall b. Article 36: When reuse of waste water is
not longer be limited for efficiency and may help feasible, it shall longer be limited for
to lessen cost. efficiency and may help to lessen cost.
c. Excavation for purpose of emission of hot spring c. Article 40 Excavation for purpose of
is not allowed ; must first obtain a permit from emission of hot spring is not allowed ;
Department of Environmental and Natural must first obtain a permit from
Resources Department of Health
d. Drainage systems shall be constructed that their d. Drainage systems shall be constructed that
outlets are manmade infrastructure provided by their outlets are rivers, lakes natural
private property bodies of water approved by government
agency
According to the Presidential Decree no. 8749 or the Philippine
Clean Air Act, which of the following is true Rule 23 Non-Burn
Technologies:
a. Type I
b. Type V
c. Type IV
d. Type III
Type III
Shall be of masonry and wood construction. Structural elements may
be any of the materials permitted by the Code provided, that the
building shall be one-hour fire-resistive throughout. Exterior walls shall
be of incombustible fire-resistive construction.
Type I
Shall be of wood construction. The structural elements may be any
of the materials permitted by the Code.
Type V
Shall be four-hour fire-resistive throughout and the structural elements
shall be of steel, iron, concrete, or masonry construction.
Type IV
Shall be steel, iron, concrete, or masonry construction and walls,
ceiling and permanent partitions shall be of incombustible fire-resistive
construction, except, that permanent non-bearing partitions of one-hour
fire-resistive construction may use fire-retardant treated wood within
the framing assembly.
Any condition or act which increases or may cause an increase in
the probability of the occurrence of fire, which may obstruct, delay,
hinder or interfere with fire fighting operations and the
safeguarding of life and property.
a. Fire Protective Assembly
b. Fire Hazard
c. Fire Resistance Rating
d. Hazard Evaluation
Any condition or act which increases or may cause an increase in
the probability of the occurrence of fire, which may obstruct, delay,
hinder or interfere with fire fighting operations and the
safeguarding of life and property.
Correct Answers
a. Fire Protective Assembly - An assembly incorporated in the structure
designed to prevent the spread of fire, such as dampers, curtain boards, fire
stoppers and the like.
b. Fire Hazard
c. Fire Resistance Rating - The time duration that a material or construction
can withstand the effect of a standard fire test.
d. Hazard Evaluation - Identification of potential hazards which includes risk
evaluation that takes into account the likelihood of the hazard resulting in a
fire or explosion.
According to BP220 Planning Design and Standards for
Residential Sudbivision Project, what is the minimum lot area for a
single detached economic housing?
a. 28 sqm
b. 36 sqm
c. 72 sqm
d. 48 sqm
According to BP220 Planning Design and Standards for
Residential Sudbivision Project, what is the minimum lot area for a
single detached economic housing?
Correct Answers
What is BPP 344 ‘s purpose?
Correct Answers
a. Provide minimum requirements and standards to make buildings, facilities and utilities for
public use accessible to disabled persons.
b. An acct providing for the rehabilitation, self-development, and self-reliance of disabled
persons and their integration into the mainstream of society and for other purposes. – RA
7277 Magna Carta for Disabled Persons
c. It is a policy of the government to promote and encourage the development of economic
and socialized housing projects, primarily by the private sector in order to make available
adequate economic and socialized housing units for average and low income earners in
urban and rural areas. – BP 220 Declaration of Policies
d. It is the policy of the State to ensure public safety, promote economic development
through the prevention and suppression of all kinds, of destructive fires, and promote the
professionalization of the fire service as a profession. – Fire Code of the Philippines (Rule 1)