Professional Documents
Culture Documents
PTC Creo Parametric Demo
PTC Creo Parametric Demo
PTC Creo Parametric Demo
Parametric ™
AN INTRODUCTION AND BASIC TRAINING ON
PTC® Creo® Parametric™
TWO APPROACHES TO DESIGN
1. BOTTOM UP DESIGN
AIR VALVE
final assembly
Continue……
PROECESS OF BOTTOM-UP DESIGN
IN Creo Drawings is referred to the Component.
Hence a change in the Component reflects the drawing automatically
BI DIRECTIONALLY
ASSOCIATEIVE
Also a component definition change in the drawing reflects the part too.
PROECESS OF BOTTOM-UP DESIGN
IN Creo Drawings is referred to the Assembly.
Hence a change in the Assembly reflects the drawing automatically
BI DIRECTIONALLY
ASSOCIATEIVE
Also a component definition change in the drawing reflects the Assembly too.
PROECESS OF TOP-DOWN DESIGN
IN Creo
Design objective here is to
make a cabinet (enclosure)
for the printed circuit
board.
Shows the Top-Down approach in designing a cabinet from the inputs given.
Exploded View showing the inside
details
Design-Iteration1
TESTING THE DESIGN
Make design modifications. Re-run the FEA and make sure that the design successfully handles the loads. Check for
the stress values and deflections.
FINAL DESIGN