Download as pptx, pdf, or txt
Download as pptx, pdf, or txt
You are on page 1of 40

UNIVERSITY OF

CALABAR
CROSS-RIVER STATE
DRIVE TEST REPORT

12TH MAY, 2022


Test Summary

› Region – PH.
› Cluster Name – UNIVERSITY OF CALABAR
› Drive test done – 12TH MAY, 2022
› DT Tool version - TEMS Investigation 23.1

TEST SCENARIO

› MS1 – 2G VOICE
› MS2 – 3G VOICE
› MS3 – 3G DATA
› MS4 – 4G
OVERVIEW

Frequencies in PH Region .
They are:
•G900
•G1800
•U2100 & U900
•L800, L2600, L1800

L2600
L800
L1800
U900
DRIVE TEST ROUTE
DRIVE TEST SUMMARY

OBSERVATIONS
 2G Coverage is GOOD as samples above -95dBm is 93.82%.
 2G Quality is GOOD as samples below 5 is 93.06%.

 3G Coverage is GOOD as samples above -95dBm is 99.38%.


 3G Quality is GOOD as samples above -16dB is 89.55%.
 HS Indoor Data Throughput is GOOD as samples above 1Mbps is 97.92%.

 4G Coverage is GOOD as samples above -105dBm is 92.42%.


 4G Quality is GOOD as samples above -5dB is 99.92%.
 4G PDCP DL Throughput is GOOD as samples above 2Mbps is 89.34%.
GSM ›GSM STATS
›GSM KPI PLOTS & ANALYSIS
Presentation Name Section
UNIVERSITY OF 7
CALABAR CLUSTER 2G KPI STATISTICS
  PRE POST
Event Detail MTN
Call Start Results  
Call Attempt 18
Call Attempt Retry 0
Call Initiation 18
Call Ending
Call End 17
Dropped Call 0
% Dropped Call Rate 0.00
% Call Completion Ratio 100.00
Call Setup Results
Blocked Call 1
Call Established 17
Call Setup 17
% Call Setup Success Rate (CSSR) 94.44
% Blocked Call Rate 5.56
% Establish Call Rate 100.00
Handover
Total Handover Success 43
Total Handover Failures 0
Total Location Update Success 0
Total Location Update Failures 0
% Handover Success 100.00
% Handover Failures 0.00
% Location Update Success 0.00
% Location Update Failures 0.00
Service Accessibility
% Call Setup Time MOC ≤ 10s 100.00
Call Setup Time MOC (Mean) sec 2.63
Presentation Name Section
UNIVERSITY OF 8
CALABAR CLUSTER RX-LEVEL
Presentation Name Section
UNIVERSITY OF 9
CALABAR CLUSTER RX-QUAL
Presentation Name Section
UNIVERSITY OF 10
CALABAR CLUSTER BCCH
Presentation Name Section
UNIVERSITY OF 11
CALABAR CLUSTER CELL ID
Presentation Name Section
UNIVERSITY OF 12
CALABAR CLUSTER 2G BAD PATCHES ANALYSIS
Presentation Name Section
UNIVERSITY OF 13
CALABAR CLUSTER 2G POOR QUALITY ANALYSIS P1

Analysis: The poor signal quality was due to:


1. Suspected transmission issue on CR0401F
2. Poor quality from overshooting cell CR0001F
Recommendation:
3. Audit CR0401 and perform a health check on CR0401F to resolve perceived transmission issue
4. Check for any physical obstruction between CR0401F and the affected path.
5. Audit and electrically down-tilt CR0001F
Presentation Name Section
UNIVERSITY OF 14
CALABAR CLUSTER 2G POOR QUALITY ANALYSIS P2

Analysis: The poor signal quality was due to:


1. Perceived transmission issue on CR0401E
Recommendation:
2. Audit CR0401 and perform a health check on CR0401E to resolve perceived transmission issue
3. Check for any physical obstruction between CR0401E and the affected path.
Presentation Name Section
UNIVERSITY OF 15
CALABAR CLUSTER 2G POOR QUALITY ANALYSIS P3

Analysis: The poor signal quality was due to:


1. Perceived transmission issue on CR0401E
2. Poor quality from overshooting cell CR1306E
Recommendation:
3. Audit CR0401 and perform a health check on CR0401E to resolve perceived transmission issue
4. Check for any physical obstruction between CR0401E and the affected path.
5. Audit and electrically down-tilt CR1306E
Presentation Name Section
UNIVERSITY OF 16
CALABAR CLUSTER 2G OPTIMIZATION ACTIONS
2G
S/N ISSUES CELLS RCA ACTION
1. Audit CR0401 and perform a health check on CR0401F
to resolve perceived transmission issue
Poor signal CR0401F 1. Suspected transmission issue on CR0401F 2. Check for any physical obstruction between CR0401F
1
quality CR0001F 2. Poor quality from overshooting cell CR0001F and the affected path.
3. Audit and electrically down-tilt CR0001F

1. Audit CR0401 and perform a health check on CR0401E


Poor signal to resolve perceived transmission issue
2 CR0401E 1. Perceived transmission issue on CR0401E
quality 2. Check for any physical obstruction between CR0401E
and the affected path.
1. Audit CR0401 and perform a health check on CR0401E
to resolve perceived transmission issue
Poor signal CR0401E 1. Perceived transmission issue on CR0401E 2. Check for any physical obstruction between CR0401E
3
quality CR1306E 2. Poor quality from overshooting cell CR1306E and the affected path.
3. Audit and electrically down-tilt CR1306E
WCDMA ›KPIs Summary
›Radio Conditions & Events Failures Analysis
Presentation Name Section
UNIVERSITY OF 18
CALABAR CLUSTER 3G KPI
  STATISTICS PRE
Event Detail MTN
Call Start Results  
Call Attempt  19
Call Attempt Retry  0
Call Initiation  19
Call Ending  
Call End  19
Dropped Call  0
% Dropped Call Rate 0.00 
% Call Completion Ratio  100.00
Call Setup Results  
Blocked Call (CSFB)  0
Call Established  19
Call Setup  19
% Call Setup Success Rate (CSSR) 100.00 
% Blocked Call Rate  0.00
% Establish Call Rate 100.00
Handover  
Radio Link Addition 184
Radio Link Addition Failure  0
Radio Link Removal  165
Radio Link Removal Failure  0
Radio Link Replacement 28
Soft Handover Success  377
Soft Handover Failure  0
% Soft Handover Success Rate 100.00 
Service Accessibility  
% Call Setup Time MOC ≤ 10s 100.00
Call Setup Time MOC (Mean) sec 1.29
Presentation Name Section
UNIVERSITY OF 19
CALABAR CLUSTER RSCP
Presentation Name Section
UNIVERSITY OF 20
CALABAR CLUSTER EC/
NO
Presentation Name Section
UNIVERSITY OF 21
CALABAR CLUSTER PS
C
Presentation Name Section
UNIVERSITY OF 22
CALABAR CLUSTER 3G DL THROUGHPUT
Presentation Name Section
UNIVERSITY OF 23
CALABAR CLUSTER 3G BAD PATCHES
ANALYSIS
Presentation Name Section
UNIVERSITY OF 24
CALABAR CLUSTER 3G POOR QUALITY ANALYSIS P1

Analysis: The poor Ec/No was due to:


1. Perceived poor physical parameters settings (mechanical and electrical tilts) on CR0001V
2. Swapped cells on CR0401 between CR0401_S1 and CR0401_S2
3. Outages on 2519GB
Recommendation:
4. Audit CR0001V, check for physical obstructions and optimize tilt parameters.
5. Resolve swap on CR0401.
6. Clear transmission issue on 2519GB.
Presentation Name Section
UNIVERSITY OF 25
CALABAR CLUSTER 3G POOR QUALITY ANALYSIS P2

Analysis: The poor Ec/No was due to:


1. Perceived transmission issue on CR0401Z
Recommendation:
2. Audit CR0401 and perform a health check on CR0401Z to resolve perceived transmission issue
3. Check for any physical obstruction between CR0401Z and the affected path.
Presentation Name Section
UNIVERSITY OF 26
CALABAR CLUSTER 3G POOR QUALITY ANALYSIS P3

Analysis: The poor Ec/No was due to:


1. Unavailability of 2325GC as at the time (12/05/2022, 5:14pm) of the test.
2. Perceived poor physical parameters settings (mechanical and electrical tilts) on CR2513W
Recommendation:
3. Bring-up 2325GC
4. Audit CR2513W, check for physical obstructions and optimize tilt parameters.
Presentation Name Section
UNIVERSITY OF 27
CALABAR CLUSTER 3G OPTIMIZATION
ACTION 3G
S/N ISSUES CELLS RCA ACTION
1. Perceived poor physical parameters settings 1. Audit CR0001V, check for physical obstructions and
CR0001V (mechanical and electrical tilts) on CR0001V optimize tilt parameters.
1 Poor Ec/No CR0401_S1/S2 2. Swapped cells on CR0401 between CR0401_S1 and 2. Resolve swap on CR0401.
2519GB CR0401_S2 3. Clear transmission issue on 2519GB.
3. Outages on 2519GB
1. Audit CR0401 and perform a health check on CR0401Z
to resolve perceived transmission issue
2 Poor Ec/No CR0401Z 1. Perceived transmission issue on CR0401Z
2. Check for any physical obstruction between CR0401Z
and the affected path.
1. Unavailability of 2325GC as at the time (12/05/2022, 1. Bring-up 2325GC
2325GC 5:14pm) of the test. 2. Audit CR2513W, check for physical obstructions and
3 Poor Ec/No
CR2513W 2. Perceived poor physical parameters settings optimize tilt parameters.
(mechanical and electrical tilts) on CR2513W
LTE ›KPIs Summary
›Analysis
Presentation Name Section
UNIVERSITY OF 29
CALABAR CLUSTER
RSRP
Presentation Name Section
UNIVERSITY OF 30
CALABAR CLUSTER SIN
R
Presentation Name Section
UNIVERSITY OF 31
CALABAR CLUSTER PC
I
Presentation Name Section
UNIVERSITY OF 32
CALABAR CLUSTER FREQUENCY
BAND
Presentation Name Section
UNIVERSITY OF 33
CALABAR CLUSTER 4G DL THROUGHPUT
Presentation Name Section
UNIVERSITY OF 34
CALABAR CLUSTER 4G BAD PATCHES
ANALYSIS
Presentation Name Section
UNIVERSITY OF 35
CALABAR CLUSTER 4G POOR COVERAGE ANALYSIS P1

Analysis: The poor coverage was due to:


1. Suspected swap between S2 & S3 of LCR0001
2. Outages on L0211X
Recommendation:
3. Check and correct detected swap on LCR0001 between S2 and S3
4. Resolve transmission issue on L0211X
Presentation Name Section
UNIVERSITY OF 36
CALABAR CLUSTER 4G POOR COVERAGE ANALYSIS P2

Analysis: The poor coverage was due to


1. Unavailability of LCR2513C and LCR2513Z as at the time (12/05/2022, 2:56pm) of the test
Recommendation:
1. Bring-up LCR2513C and LCR2513Z
Presentation Name Section
UNIVERSITY OF 37
CALABAR CLUSTER 4G POOR COVERAGE ANALYSIS P3

Analysis: The poor coverage was due to


1. Delayed handover between L2519F and LCR0401B.
Recommendation:
1. Review handover threshold between L2519F and LCR0401B
Presentation Name Section
UNIVERSITY OF 38
CALABAR CLUSTER 4G OPTIMIZATION
ACTION 4G
S/N ISSUES CELLS RCA ACTION
1. Check and correct detected swap on LCR0001 between
LCR0001_S2/
Poor 1. Suspected swap between S2 & S3 of LCR0001 S2 and S3
1 S3
coverage 2. Outages on L0211X 2. Resolve transmission issue on L0211X
L0211X

Poor LCR2513C 1. Unavailability of LCR2513C and LCR2513Z as at


2 1. Bring-up LCR2513C and LCR2513Z .
coverage LCR2513Z the time (12/05/2022, 2:56pm) of the test

1. Review handover threshold between L2519F and


Poor
3 L2519F 1. Delayed handover between L2519F and LCR0401B. LCR0401B
coverage
END
THANK YOU

You might also like