Professional Documents
Culture Documents
Raj Eev Sin GH Raj Eev Sin GH: Ans. (B)
Raj Eev Sin GH Raj Eev Sin GH: Ans. (B)
R
h
To drill, free machining stainless steel at a cutting speed of 15 mm/ min with a 15 mm
g g h
i n Si n
(a) 320 rpm (b) v 640 rpm
S
diameter drill, the drill must rotate at a speed of:
v
e e j e e
j 3.1416 rpm
(c) 1000arpm(d) a
R R
g h
Si n g h
v Sin
je e v
a j e e
R a
Ans.(a)
R
g h g h
While drilling holes in steel plate by a 20mm diameter SS drill with a given feed,
i n i n
the tool life deceasedSfrom 40min to 24min when speed was raised fromS250rpm
e v e e v
a
to 320rpm. At je j
what speed (rpm) the life of that drill under theasame condition
R R
would be 30min.
R a
R
g h
What is the drilling time for producing a hole in an MS sheet of 45mm g h
thickness using an S i n S i n
v
e and 0.25mm/rev respectively. Neglect time e e v
HSS drill of 20mm diameter? The cutting speed and feed
for drill areje j
a 30m/min
R a taken for
settingRup, approaching and traveling of tools.
(a) 22.6 sec (b) 27.6 sec
g h
(c) 32.6 sec (d) None
Si n g h
v Sin
je e v
a j e e
R a
Ans.(b) R
g h g h
Which of the following statements are correct in drilling operation?
i n S i n
S
1. Large amount of helix
v v
angle variation is required during drilling of hard materials.
e e j e e
a j
2. Small point angle is required during drilling of soft materials.
a
R
3.Twisted portion R
of drill bit can be joined to the shank by using friction welding process.
4.Drilling is a multipoint cutting tool oblique machining operation.
a
be as 2mm.j e
The time required for drilling two holes if the a j
feed is 0.1
R R
mm/rev and the material is cut with a velocity of 15 mm/min is
_________ min
g h
Si n g h
v Sin
je e v
a j e e
R a
Ans.(2.41) R
h
In drilling operation, if the diameter of the drill bit is doubled keeping the
g g h
i n S i n
v S
feed and surface velocity of the bit as constant, the percentage change in
v
the
metal removalee
j e e
a j rate will be ----- %.
a
R R
g h
Si n g h
v Sin
je e v
a j e e
R a
Ans. 100 R