Professional Documents
Culture Documents
Rfid Based Security Access Control System: NAME:-VISHAL MANIKPURI (0213CS201104) NAME: - VIKAS GUPTA (0213CS201103)
Rfid Based Security Access Control System: NAME:-VISHAL MANIKPURI (0213CS201104) NAME: - VIKAS GUPTA (0213CS201103)
PROJECT PRESENTATION ON
RFID BASED SECURITY ACCESS CONTROL SYSTEM
SUBMITTED BY
NAME:- VISHAL MANIKPURI (0213CS201104)
NAME:- VIKAS GUPTA (0213CS201103)
1. INTRODUCTION
2. FEATURES
3. SCOPE
4. H/W & S/W REQUIREMENTS
5. DESIGN
(USE CASE/CLASS/DFD/E-R ETC.)
6. DETAILED PROCESS FLOW OF THE PROJECT
7. MODULES OF THE PROJECT
INTRODUCTION
In the previous age, a normal Lock and key are used to lock the door and gate. But in
this modern age, some houses, hotels, offices, and other places are using Electronic
door locks systems, these are basically keyless door locks i.e don’t need a key to unlock
the door. Several types of access control systems are used in electronic door locks to
access the door. The most used access control systems are PIN/Password (Personal
Identification Number), fingerprint, and RFID based Electronic door locks systems.
In this project make RFID based Electronic door locks systems using Arduino and RFID
(Radio-Frequency Identification) Module. In this system, you need a particular card or
key tag and put it in front of the RFID door locks system box (RFID Reader) to unlock the
door. If you put the wrong card or key tag in front of the RFID door locks system box
(RFID Reader) then the door would not unlock. This system is also known as the card
door lock system or key card door lock system.
FEATURES
A unique ID .
Easy to configure.
More secure.
Increased awareness.
RFID Module :-
RFID is contracted as Radio Frequency Identification. It makes a remote correspondence
and empowers information move between RFID tag and RFID reader [12] [13]. This
module can read and compose information without direct contact. The RFID label
comprises of kilobytes of rich data in it. The RFID reader is a functioning segment .The
RFID tag, then again, is a detached segment that is situated on the item we need to
distinguish. It has an antenna attached to a microchip. So as we place the tag is near the
scope of RFID reader than some voltage is created in reception apparatus curl and
voltage act as power. In our work, we have utilized RC522 MODULE to get to door control
framework Figure 2.
Fig. 2:- RFID Module
Servo motor:-
Jumper Cables:-
Jumper links are utilized to move electric flow from one point to other inside a circuit.
Because of high conductivity, jumper links are made of copper and aluminum [17]. In this
model, we have utilized three mix of jumper link for example male to male, female to
female and male to female Figure 4.
Fig.4:- Jumper Cable
S/W REQUIREMENTS