Professional Documents
Culture Documents
Logisnext Elec Schematics For Fuel Systems
Logisnext Elec Schematics For Fuel Systems
• Simple Layout
-7 total pages
-ECM,VCM,DCM,OCM, FC/MC
Always check to make sure you are looking at the correct model schematic for your truck
Key points:
• 610 – PDS
© MITSUBISHI LOGISNEXT AMERICAS INC. All Rights Reserved.
Title
CAN BUS
-CN2 715/716 Optional
Sensors
© MITSUBISHI LOGISNEXT AMERICAS INC. All Rights Reserved.
Title
Highlight ALL fuses that have power with battery connected and key OFF
Using a different color, highlight ALL fuses that power up with battery connected, and key ON
Starter relay- 12v input to coil from pin 122 of Key Switch, NEG input from FNR lever and
Neutral SW
Supplies 12v to starter coil at S
IGN Relay – 12v input to coil from pin 121 of Key Switch , NEG input from chassis ground,
When coil closes the relay will power VCM Fuse, Meter Panel Fuse, Back up lamp fuse, Fuel
Disconnect fuse
© MITSUBISHI LOGISNEXT AMERICAS INC. All Rights Reserved.
Title
EGI(1) – Shares a NEG and 12v with EGI (2), 12v comes from F7, supplies 12v to Spark Plugs
EGI (2) – Supplies 12v to MAIN/C Relay coil , Supplies 12v to OCM, Supplies 12v to Main INJ, Sensors,
Crankshaft and Camshaft, INJ assistance, Air Flow Sensor. 12v supply to activate ECM @ pins 189/190
MAIN/C – Supplies 12v to Fuel Lock solenoid and LPG/GAS selector switch
ETC Motor- 12v from F9, 12v to ECM @ pin 192. The ECM knows the relay is functional when it sees
voltage at pin 192, if no voltage is seen a E31 code will generate