This document is an ANPQP report summarizing gap and trim measurements for a dash reinforcement assembly. Gap measurements were taken at 9 points (a, d(S7), e, etc.) and trim measurements at 3 points (J, K(P10), x). All measurements were outside the specified tolerance of 3.00 ± 0.5 for gaps and 3.0 ± 1.0 for trims, with status reported as "Not.Ok" for all samples and points.
This document is an ANPQP report summarizing gap and trim measurements for a dash reinforcement assembly. Gap measurements were taken at 9 points (a, d(S7), e, etc.) and trim measurements at 3 points (J, K(P10), x). All measurements were outside the specified tolerance of 3.00 ± 0.5 for gaps and 3.0 ± 1.0 for trims, with status reported as "Not.Ok" for all samples and points.
This document is an ANPQP report summarizing gap and trim measurements for a dash reinforcement assembly. Gap measurements were taken at 9 points (a, d(S7), e, etc.) and trim measurements at 3 points (J, K(P10), x). All measurements were outside the specified tolerance of 3.00 ± 0.5 for gaps and 3.0 ± 1.0 for trims, with status reported as "Not.Ok" for all samples and points.